Ford Motor Company: Tires
Ford Motor Company reported this defect to federal regulators on May 17, 2004 and put the number of vehicles at risk at 6,415. The repair is free for as long as the recall stands.
The defect
CERTAIN LARIAT AND KING RANCH MODEL PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." SOME TRUCKS WERE INADVERTENTLY EQUIPPED WITH AN INCORRECT LOAD RANGE TIRE. THIS WOULD RESULT IN INCORRECT TIRE LOAD RATINGS FOR THE STATED VEHICLE AXLE GROSS AXLE WEIGHT RATING. ALSO, THE TIRE MAY BE INFLATED ABOVE THE DOT LISTED INFLATION PRESSURE.
The risk
IF A TIRE WAS OPERATED IN AN OVER-LOADED OR OVER-INFLATED CONDITION, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH CAN CAUSE A CRASH WITHOUT WARNING.
The remedy
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ANY INCORRECT LOAD RANGE TIRES. ADDITIONALLY, IF ANY TIRE REQUIRED REPLACEMENT, IT IS RECOMMENDED THAT THE WHEEL LUG NUT TORQUE BE CHECKED WITHIN 500 MILES AFTER ANY TIRE REPLACEMENT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT. FORD AT 1-800-392-3673.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2004 Ford F-250 | 154 | 7 | 4 | 8 |
| 2004 Ford F-350 | 159 | 3 | 5 | 13 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 04V229000.
Full record for the 2004 Ford F-250 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →