Mitsubishi America: Electrical System › Wiring › Interior/Under Dash
Mitsubishi America reported this defect to federal regulators on May 20, 2003 and put the number of vehicles at risk at 43,649. The repair is free for as long as the recall stands.
The defect
ON CERTAIN SPORT UTILITY VEHICLES, WATER COULD ENTER THE FRONT FLOORBOARD AREA FROM OPENINGS IN THE SIDE SILL OR UPPER DASH AREA. THIS WATER COULD COLLECT UNDER THE SEAT AND CAUSE ELECTRICAL CORROSION TO OCCUR IN THE HARNESS CONNECTORS THAT CONTAIN THE WIRING FOR THE SEAT BELT PRE-TENSIONER, SIDE AIR BAG IMPACT SENSOR, AND STOP LAMPS.
The risk
ELECTRICAL CORROSION OF THE HARNESS COULD CAUSE THE SEAT BELT PRE-TENSIONER TO MALFUNCTION, THE SIDE AIR BAG NOT TO DEPLOY AND/OR THE BRAKE LAMPS NOT TO ILLUMINATE OR TO FALSELY ILLUMINATE.
The remedy
DEALERS WILL INSPECT THE SIDE SILLS AND DASH PANEL FOR OPENINGS THAT MAY ALLOW WATER LEAKAGE INTO THE VEHICLE CABIN. IN ADDITION TO SEALING ANY OPENINGS THAT MAY BE FOUND, THE WIRING CONNECTORS WILL BE INSPECTED FOR SIGNS OF ELECTRICAL CORROSION. THE FLOOR HARNESS WILL BE REPLACED IF IT HAS ANY SIGNS OF WATER DAMAGE OR ELECTRICAL CORROSION. OWNER NOTIFICATION BEGAN JUNE 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-800-222-0037 OR MITSUBISHI CARIBBEAN AT 1-787-251-8715.
1 model year covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2003 Mitsubishi Outlander | 116 | 6 | 2 | 10 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 03V194000.
Full record for the 2003 Mitsubishi Outlander → · Recalls carrying a do-not-drive advisory → · Where this data comes from →