General Motors Corp.: Electrical System › 12v/24v/48v Battery › Cables
General Motors Corp. reported this defect to federal regulators on Mar 17, 2001 and put the number of vehicles at risk at 301. The repair is free for as long as the recall stands.
The defect
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH A MISROUTED POSITIVE BATTERY CABLE ASSEMBLY THAT COULD COME IN CONTACT WITH THE STEERING SHAFT UNIVERSAL JOINT.
The risk
OVER TIME THIS CONTACT COULD CAUSE A WEAR-THROUGH OF THE CABLE ASSEMBLY CONVOLUTED CONDUIT AND CABLE INSULATION EXPOSING THE WIRE CORE AND RESULTING IN INTERMITTENT ELECTRICAL SHORTING. THIS COULD RESULT IN ERRATIC MOVEMENT OF THE VOLTAGE GAGE, TOTAL BATTERY DISCHARGE IN A FEW HOURS, OR THE CABLE INSULATION AND CONDUCT COULD IGNITE IF ENOUGH CURRENT IS DISCHARGED AT THE POINT OF CONTACT, RESULTING IN AN UNDERHOOD FIRE.
The remedy
DEALERS WILL INSPECT THE POSITIVE BATTERY CABLE FOR PROPER ROUTING AND RE-ROUTE THE CABLE IN NECESSARY. THE CABLE WILL ALSO BE INSPECTED FOR WEAR OF THE CONDUIT AND CABLE INSULATION, AND WILL BE REPLACED IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GMC AT 1-800-462-8782.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2001 GMC Yukon Denali | 35 | 2 | 0 | 2 |
| 2001 GMC Yukon XL Denali | 22 | 1 | 2 | 2 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 01V107000.
Full record for the 2001 GMC Yukon Denali → · Recalls carrying a do-not-drive advisory → · Where this data comes from →