2020 Ram 3500 complaints

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) and the vehicle was taken to the dealer who performed an inspection test and informed the contact that the vehicle had failed the inspection. However, the parts to do the recall repair were not yet available. The contact stated that the dealer informed her that the manufacturer was shipping one part per week. The contact stated that she stopped driving the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. Parts distribution disconnect.

Sudden, catastrophic failure of Hydro Boost Pump Port Tube Assembly resulting in severe loss of steering and braking capability accompanied by high pressure release of flammable power steering fluid into and within engine compartment

The contact owns a 2020 Ram 3500. The contact stated that after his son started the vehicle, there was a metal-on-metal sound coming from the engine. The contact stated that his son was not aware of any warning lights being illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 20V511000 (Engine and Engine Cooling, Electrical System). The failure mileage was approximately 135,000.

Truck was new decenber 2020 and only has 25000 miles. The belts are broken and the tire is bulging. from the research I have done online many people are experiencing the same problem with these budget tires put on 80,000$ trucks designed to tow 30,000lbs with 6 people in the car. These are dangers to everyone on the road. drove fine all day then suddenley started shaking the whole truck. I thought a wheel wait fell off but the tire was obviously deformed..

I am attempting to get recall 21V-880 done. This is a safety recall where failure of the engine could result in a crash. I contacted my local dealer and they state repair parts are only available in limited quantities. They put me on a waiting list and stated there are 105 vehicles ahead of me and they don’t think they will have the parts to repair the safety recall until late 2023. This is completely unacceptable for a major safety recall.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

On 6/28/2022 I was involved in an off-set not-at-fault head on collision at 45+ MPH. My vehicle then careened off the initial collision causing a side impact with a large light standard. My vehicle continued until it collided head on with a building and came to a stop. The front impact and side impact airbags did not deploy at any time. My vehicle and the other vehicle were deemed a total loss.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however the part to do the recall repair was unavailable. The contact stated that the dealer had pushed back the date for the part to be the available. The manufacturer was contacted and made aware of the issue. The manufacturer informed the contact parts would be available by July 22, 2022. VIN tool confirms parts not available.

Last week this took place: 2020 Ram 3500 Dual rear wheels AISON transmission is outfitted with factory trailer brake module. Was hauling a horse trailer near 30,000 lbs to a horse show, caravaning with crew pulling another horse trailer about the same weight with a 2020 Ram 3500 (Vin #3C63RRML6LG642630 (see separate complaint)). All connections checked before departure. Unlike the other Ram in the caravan, No ABS warning light activated prior to the failure. When braking, no trailer brakes engaged. Then checked hand paddles on the factory trailer brake module and the hand paddles activated the trailer brakes. Took it into the dealership to check codes and they said none appeared or were somehow reset. There was excessive heat during this trip and the failure occurred in both RAM 3500 vehicles during the same travel segment within minutes of the other.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

As we were traveling home from Florida to Oklahoma our truck completely lost power on a very busy two lane highway in Titus County, Texas. We were pulling our travel trailer which is 40.6 feet in length. We had no warning and had a hard time finding a place to pull over. The dash light then flashed “ exhaust system service required see dealer”. Our truck only has 11000 miles and is well taken care of. As a result , we had to wait for over 2 hours in the Texas heat (91 degrees) on the side of a dangerous highway. Nothing would work in the truck. It took this long for the warranty service to approve the tow. They did not provide any information for rental car or lodging. Our 5th wheel RV is in a tow yard and we are stranded in Tx.They cannot look at our truck until Monday June 27th.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V398000 (Wheels) and 21V880000 (Fuel System, Diesel) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the vehicle experienced hard starting and a loss of power while driving at various speeds. The vehicle was taken to the local dealer who diagnosed that the high-pressure fuel pump had failed and needed to be replaced; however, the part was not yet available. The failure mileage was 5,900. Parts distribution disconnect.

The contact owned a 2020 Ram 3500. The contact stated that the vehicle would surge whenever he depressed the accelerator pedal while driving. There were no warning lights illuminated. The contact then received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel). The contact notified several unknown dealers of the failure. The dealers informed the contact that though the failure was associated to the recall, they could not assist as the manufacturer had not authorized them to repair the vehicle. The contact then inquired assistance with obtaining the parts for repair and the dealer informed the contact that the manufacturer did not authorize them to sell the parts for repair. The manufacturer was notified of the failure and informed the contact that they would not assist as the vehicle was safe to drive. The vehicle was not diagnosed or repaired. The contact later sold the vehicle to an auction. The failure mileage was approximately 13,300.

The contact owns a 2020 Ram 3500. The contact stated while driving 5 MPH, the oil pressure warning light illuminated. The contact then drove back to his residence. Upon opening the hood to check the oil pressure, the contact noticed that the oil consistency was like jelly. The vehicle was towed to the dealer where it was diagnosed that lack of engine oil, caused engine to cease and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer then followed up with the dealer who provided an estimate for the repair. The manufacturer informed the contact that the engine replacement would not be covered under the warranty however, a vehicle buy back would be considered. The failure mileage was approximately 140,867.

0N 4/4/2022 while traveling on interstate 64 E in WV ,towing an R V camper , no warning signals on the dash screen, my truck started losing power and went completely dead,just missed by a tractor trailer rear ending me, as I rolled off to the side of the road. Iwas towed to the nearest Dodge dealership. When I arrived at the dealership a mechanic came and open the hood, he found diesel leaking and a metal rod of the camshaft sitting on top of the engine, which he stated shot through the engine block. Warranty company doesn't want to tear down engine after I gave approval to investigate issue. This is my work truck and source of income. Four weeks later, I am not getting help from dealership that sold me the truck and warranty. Warranty company is trying to use loop hole to get out of paying. I found similar complaints, reported to the NHTSA, engines falling apart while driving down the road. I had to pay for my truck to tow from WV to Charlotte NC to my driveway. I have a case# with the Dodge Customer Care Department and they are just informing me that the truck has recalls, but parts are not avaible at this time.

While towing 5th wheel vehicle check engine light came on I was out of state in arizona vehicl then started to stall I canceled my trip checking all fluids headed back to California as I was nowhere near a dealership made a appointment at ram dealer when I got there light went out I talked with technician he said would have to leave it for 3 weeks before they could look at vehicle needless to say I took it home then in early Feb about 3 weeks after the first incident the check engine light came on again made appointment which was 3 weeks away just to check it in shop and a week before they even looked at the issue they found a cracked hose on inter cooler dealer stated vehicle ok well again on March 4 2022 vehicle again has check engine light on I took to auto store to check code same as before vehicle regeneration frequency it Regenerates ever 100 miles runs poorly uses excessive fuel hesitates when pedal depressed and long cranking time so now I have to be without a vehicle again

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. UPDATE AS OF 6/24/22: Normandin Chrysler Jeep Dodge Ram, San Jose CA has put owner on a waiting list for parts. Service Director says that the manufacturer will only allow them to order one (1) parts kit for the Y78 / NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) recall once every 7 business days. The dealer says they have a waiting list of approximately 40 customers waiting for repair of this recall. Has told contact that it is expected to be several months before the Y78 recall can be fixed on the contact’s 2020 Ram 3500. Contact finds that this is unacceptable to have such an extreme delay in parts availability for the recall.

The contact owns a 2020 Ram 3500. The contact stated while driving 55 MPH, the Diesel Exhaust Fluid (DEF) warning light illuminated. The contact was able to continue driving to his residence. The vehicle was taken to the dealer on three separate occasions to be repaired; however, the repair failed to correct the failure. The manufacturer was notified of the failure. The approximate failure mileage was 27,000.

DEF reservoir got low and light came on indicating about 300 miles until truck goes into limp mode 5 MPH. Added 1 gallon of DEF and the guage showed to be in the safe zone. The computer system never registered that fluid was added and truck went into limp mode on the way home. When in limp mode you are unable to move vehicle off the roadway in a safe manner or even drive on any roadway without major risk of getting hit. Truck has to be towed to a dealership to have the computer reset. EXTREMELY DANGEROUS. Ironic that first responder and government vehicles with this same engine ect are omitted from the limp mode function due to safety concerns but not the general public.

The contact owns a 2020 RAM 3500. The contact stated that while driving at 15 MPH, the oil warning light was illuminated, and the vehicle made abnormal sounds. Additionally, there was smoke coming from under the hood of the vehicle. The contact pulled over and refilled the oil reservoir; however, the failure recurred with oil leaking from the vehicle. The vehicle was towed to the dealer and diagnosed with engine damage and connecting rod failure, which punctured the engine block. The engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. Upon investigation, the contact related the failure to NHTSA Campaign Number: 20V511000 (Engine and Engine Cooling, Electrical System) however, the VIN was not included in the recall. The failure mileage was approximately 213,000. The oil light did not come on until after the engine had started knocking rapidly. The engine oil also ran out quickly as well. Consumer immediately refilled the oil and drove for 5 minutes and the engine stopped knocking for a few seconds before there was louder knocking, smoke and spewing oil. Consumer had previously reported to the customer care FCA group 2 times last August about metal shavings on the fuel filter. The fuel pump continued to produce metal shavings in the filter every time the filter was change.

This Laramie trim level truck has an electronic drop tailgate with a button to drop the tailgate on the overhead console and one on the key fob. The tailgate on my truck was closed during my pre-trip and entering the vehicle. I had a trailer hooked to the receiver hitch and drove ten miles before realizing the tailgate was now in the down position and caused significant damage to the tailgate because the tailgate made contact with the trailer. With the electronic release tailgate on this particular year truck there is not a warning message alerting the driver that the tailgate is ajar. There is such an alert on newer models (2021-2022) I went to a local dealership to check. I’m sure the tailgate drop button somehow was pressed on the key fob while in my pocket entering the truck. But I did not receive any alert on the instrument cluster or even hear the tailgate open because the tailgate has a soft open feature. I see this being a serious safety concern to possibly lose cargo and cause a more serious accident.

The contact owns a 2020 RAM 3500. The contact stated while her husband was making a right turn, the vehicle began to stall. The contact stated do not turn off the vehicle until arriving at destination warning message was illuminated. The driver was able to continue driving under 15 MPH until arriving at a local dealer. The local dealer was unable to duplicate or diagnose the cause of the failure. The contact was informed that a specialist was needed to diagnose the vehicle. The contact stated that the dealer called back 2 days later and stated that some unknown cables needed to be replaced. The vehicle was repaired but continued to experience the same failure. The contact stated that the failure had been experienced a third time. The VIN was associated with NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) and 21V398000 (Wheels). The manufacturer had not been informed of the failure. The failure mileage was approximately 24,000.

As I was preparing to travel for the holidays comíng up, I was traveling to Texas to see family. I was driving around 65 mph when suddenly the truck started jerking and slowing down when the gas pedal would not give it power. The car behind slammed the brakes and in order to avoid hitting me had to went the the side of the highway. Before coming to a complete stop the truck a 2020 ram 3500 shut off and will not come off. The tow truck was able to scan the truck and the codes are for low fuel pressure and fuel pump. This was a very scary situation because I’m with all my family and not only did I put them in danger by this truck failing with out a notice of any kind but also put others like the vehicle behind in danger because the truck failed. I have look up and this seems to be a common issue with all the “new ram trucks” not sure why there is no recall yet. Hoping this gets looked at and something can be done for the safety of others

I was on my way home from the local RAM Dealer last night, where I wanted to sell my truck (after inspecting it, they offered me $82K for it), when, spontaneously, my truck started to smoke from under the hood and literally burst into flames! I had to pull over and jump out to avoid being burned alive! I am so traumatized. I'm attempting to tow what's left of this truck to the dealer this morning. I hope FCA will take responsibility for this!

The contact owns a 2020 Ram 3500. The contact stated while hauling his fifth-wheel travel trailer driving up a hill the vehicle lost all power. The contact stated he had to maneuver over several lanes of traffic to move off the road safely. The police department was contacted and had the vehicle towed. The tow truck driver had to unhitch the trailer from the contact's vehicle to tow the truck to a dealer. The vehicle was towed to the dealer and diagnosed with a fuel sensor failure. The fuel sensor was replaced. The vehicle failed to start and was diagnosed with a fuel injection pump failure which had imploded sending metal fragments throughout the whole fuel system and into the fuel tank. The entire fuel system including the fuel tank and all fuel parts needed to be replaced. The contact stated that the dealer informed him of a notice that was sent to the dealer by the manufacturer of a fuel pump failure. The contact stated that he researched the failure online and found NHTSA Action Number: PE21021 (Fuel System, Diesel). The manufacturer was made aware of the failure and a case was opened. The failure mileage was 25,700. Replacement parts are same defective CP 4 injector pump that already failed and now metal shavings are contaminating fuel system leading to another implosion and possible accident or death FCA has no fix available making truck unsafe to operate. STELLANTIS, FCA and STAR are well aware of this CP 4 safety issue in 2019 and 2020 trucks.

I was driving my truck towing a fifth wheel trailer weighing over 10,000 pounds on a rural state highway in Missouri with many hills, curves, and little to no shoulders. As I was traveling on a downhill slope at approximately 60mph my engine abruptly died with no warning, causing an immediate loss of power steering, power brakes, and engine brake. I began applying heavy pressure to the brakes slowing the vehicle and began looking for a side road to pull into. I came upon a driveway with an open gate into a field. With much manual force to the steering wheel and brakes I was able to guide the truck and trailer off of the highway into the field to a stop. I was fortunate to not have anyone stopping in front of me as I am certain I would not have been able to avoid a crash with the heavy load and no power. The vehicle was towed to a local Ram dealer and metal shavings were discovered in my fuel system. Repairs were made under warranty and after 6 weeks my truck was returned to me with a new fuel system including a new Cp4 fuel pump that had failed. This happened on 08/28/2020 and the truck had 8900 miles at the time. On 09/15/2021 I discovered metal shavings in my rear fuel filter while doing routine maintenance The truck was running appropriately with no codes or warning lights, it had 72000 miles at the time. I telephoned a local Ram dealer shop and was told it would have to be diagnosed at their shop. Unwilling to take the chance with another Cp4 pump failing I contacted a lo

Truck was with high pressure pump issues, spent $2600 in rental truck, $400 i. Towing truck and about one month with no truck, Chrysler still doesn't want to pay me back, this is my second truck with same issue, previous truck was a 2019 3500 ram having the same problem when truck was with only 4,000 miles on it. Now they repaired my truck but now i feel like my truck lose already torque, is using more diesel and more DEF.

I was towing a light trailer (4000 lbs) on I-5 in Oregon on 10/22 when I slowed from ~58 mph to about 45 mph to allow a hasty SUV to merge from the right. When I tried to resume speed the truck seemed "stuck" at 45mph for quite some time. I gave it full throttle and it didn't accelerate. I tapped the brakes, turned off cruise control and it felt like there was no power at all, like it was freewheeling. Finally the motor 'caught' and it accelerated to highway speed. I looked for the problem online and believe this may be related to the CP4 fuel pump issues. Is it safe to continue driving or should I take the truck to a dealer or what? There is no recall yet and I hear the dealership people are telling owners that it is from bad fuel and not covering it! I only have 12128 miles on the truck, please advise!

At 28,000 miles my vehicle in the middle of the Highway going up a hill stall and suddenly lose boost or was inoperable to safety get out of the road. i was able to do a unsafe maneuvering to get out of the way with the momentum of speed that i have at the moment When this happened a message on my screen said power boost service require,contact your dealer. Later and after the poor customer service in moreno valley ca. And yuma az my local dealer provide., i found out that my fuel pump(cp4) went down,completely destroyed on the inside sending metal particles trough the entire fuel system. 93,000 and again my vehicle went out of service exactly for the same reason(cp4) And now at 135,000 miles my vehicle is down again the reason is idle pulley broke and my serpentine belt got damage at the same time serpentine belt damage my crank sensor and i found out today that is on back order until the 3th week of november I have all documents in order to support the complaints im here to submit today

CP4 fuel injection pump and entire fuel system. The original part was replaced by the dealership under warranty. I am 400 miles away from that dealership and the truck has broke down with another suspected CP4 failure and will need a full fuel system replacement again. I do not know if it would be available for inspection upon request. It put my safety and my passenger’s safety at risk as it died while moving on a freeway at night. The problem was confirmed at the first dealership, it is currently pending at the current dealership. The part was inspected at the first dealership that did the warranty work. There were no warning lamps, messages, or other symptoms of the problem prior to the failure. The incident date below, mileage, and invoice is from the FIRST incident. The second incident occurred on 10/18/2021 at approximately 101,300 miles and is currently waiting to be inspected at a dealership.

The component that failed was the CP4 high pressure fuel pump. Currently the truck is at RAM dealer in Champaign IL. If I need the part, I can ask for it. When the fuel pump failed, the engine quit running and I lost power steering and brakes. I was not in a high traffic area at the time and was able to get the truck w/42 foot 5th wheel travel trailer to side of highway safely. The issue with the fuel pump has been confirmed by Hendershot Chrysler Dodge Jeep RAM' Has the vehicle component been inspected by manufacturer? UNKNOWN Just prior to the engine shutting off, the following message appeared on the dash, Exhaust Service Required — See Dealer Now— This message indicates regeneration has been disabled due to a system malfunction.

CP4 High Pressure Fuel pump failed @17,500 miles. I was pulling an 18,500 LB 5th wheel trailer on a 2- lane state highway. Stranded family for 6 hours in 106 degree heat until multiple tow trucks arrived to move both vehicles. 85 miles to nearest dealer. Most expenses covered by Good Sam Platinum coverage. Replacement parts and service covered by Cummins. 35 gallons of diesel NOT replaced by FCA, 5 days lodging and towing expenses denied by FCA. No warning lights or messages prior to failure. No prior issues. 3 identical trucks delivered same day to Redding, CA dealer. Crown Motors with same issue. Blame placed on Low Sulfur diesel mandated by State of CA.

I WAS DRIVING ON I-44 10 PAST MIAMI OKLAHOMA HEADING EAST BOUND AND THE TRUCK LOST ALL POWER THE DODGE 3500 2020 HAD 35,000 MILES ON IT HAD IT TOWED TO THE DODGE DEALER IN MIAMI OK THEY SAID THE HIGH PRESSURE FUEL PUMP EXPLODED

The contact owns a 2020 Ram 3500. The contact stated that while driving at an unknown speed, the vehicle independently went into limp mode and would not accelerate above 20 MPH. Due to the failure, the contact took the vehicle to a dealer where they discovered that a defective fuel pump had caused metal shavings to enter the fuel line, fuel rail, fuel tank, and fuel injectors. The manufacturer was not notified of the failure. The vehicle was repaired. The failure mileage was 111,363.

The contact owns a 2020 Ram 3500. The contact received a recall notification for NHTSA Campaign Number: 21V398000 (Wheels) however, the dealer informed the contact that the parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and confirmed that the parts for the recall repair were not yet available. The contact had not experienced a failure. VIN tool confirms parts are not available.

With 20k miles the High-Pressure Fuel Pump blowup in middle of the freeway in NY. This part name is CP4. My truck subtlety stops in freeway in very dangerous situation. My luck is I had a State Patrol few cars back and he help me to safety the area and wait the tow. My truck stays 2 months parked on at Dealer to fix. The reason is they don’t have a new CP4 to replace is because all 2020 diesel Ram trucks had the same problem. 5 months later my CP4 blowup again with 49k miles now my CP4 and my Tank Fuel Pump breakdown in same time. More 2 months to fix.by the way my truck don’t had 9 months old and stay parked on dealer for 4 months. I paid 4 months of car payments and insurance for not use the truck. Other point is my braking pads. I replaced my front braking pads and rotors with 29k miles. This is unbelievable all my trucks I replaced this part between 70k and 90k. I paid $900 and I believe that my truck had something wrong with braking system also. Like I explained before. In both situations my CP4 subtlety blowups and stop my truck in middle of freeway. Truck engine shutoff and in 65 mph freeway this is very dangerous. God save my life in both situations because all the tomes someone come to help me. First time was State Patrol the second time is Highway Patrol in CA. Yes the problem happened 2 times and my truck in lees the 1 year stay parked on dealer for 6 months. With breakdowns in CP4, EGR, ECM, Tank Fuel Pump, Turbo Actuator and a lot leaks and gaskets breakdowns. My

We have had the truck a year, it started as pulling to the right, we kept track of tire pressure and there had been no tire pressure differences. The passenger front tire wears unevenly. We have had 2 alignments, we replaced the tires due to severe wear damage and 2 weeks later the tire had significant wear damage again. The front end continues to pull to the right with correct tire pressure and correct alignment.

Good afternoon, As I was traveling down the interstate today my tailgate unexpectedly opened with no action of mine. A passing traveler signaled to me that this happened, and I was very lucky that nothing came out of my bed to strike a vehicle behind me. I was towing a travel trailer and the tailgate sustained damage from striking the trailers jack. Not sure if this is a new issue, but I have seen similar recalls on Rams from years past.

Large air bubble on inner sidewall of tire

The contact owns a 2020 Ram 3500. The contact stated while driving at various speeds, the trailer brakes failed intermittently while the brake pedal was depressed. The turn signals and brake lights also failed to function properly. The vehicle was taken to the dealer and diagnosed that the rear bumper brake plugs were installed incorrectly causing water to fill the brake plugs. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the brake plugs were installed and functioned as intended. The manufacturer suggested that the vehicle be taken to another dealer to be diagnosed. The failure mileage was 7,000.

The contact owns a 2020 RAM 3500. The contact stated while attempting to start the vehicle, he depressed the START/STOP button several times however, the vehicle failed to start. After waiting for approximately 45 minutes the vehicle started. The contact also stated the vehicle failed to recognize the key fob inside the cabin of the vehicle. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000.

My wife was driving on a highway with a trailer. Power steering went out. It was near impossible for her to pull over as the vehicle was extremely hard to turn. Not safe!

My truck like all 2019-2020 trucks have the plagued CP4 pump that could fail without showing any symptoms. FCA has failed to step up and have ownership and integrity on this issue. I have asked multiple times to RAM Cares and all I have received is cookie cutter answers from them. I do not know if mine will be next to go or ever will go but FCA has a solution in the 2021 HD Ram trucks and that is the CP-ISB21 fuel pump which looks like the old reliable CP3 fuel pump. Companies out have a solution and that is the CP3 swap but it voids the warranty on the vehicle. The warranty is what is holding me back from having the CP3 pump swap done. Can you please pressure FCA to step up have integrity to replace the plagued CP4 fuel pump with the CP-ISB21 pump. I have challenged FCA on their integrity and ask them if they have it because of the cookie cutter answers I have received from them. I have even asked them to look up what integrity is and to follow the integrity example from the Naval Nuclear Power Program because that program is built on integrity. That program has safely steamed on Nuclear Power for over 60 years. Please again force FCA’s hand on this because this is unsat of them. Look at the forums online and you will see people posting their trucks that have a failed CP4 pump. With that failure FCA is just replacing it another CP4 pump. Also people’s HD rams are down for weeks up to months waiting on the repair. I have also talked to dealership service managers about this i

The contact owns a 2020 Ram 3500. The contact stated while driving 45 MPH, the vehicle lost motive power. The vehicle was restarted and the functionality returned however, the failure recurred after several seconds. There was no warning light illuminated. The vehicle was towed from the scene. The vehicle was diagnosed with a high-pressure fuel system failure. The manufacturer was not informed of the failure. The failure mileage was approximately 17,018.

The contact owns a 2020 Ram 3500. The contact stated while at a standstill the vehicle lost motive power. The vehicle was restarted and functionality returned for several seconds before the failure recurred. There was no warning light illuminated. The vehicle was towed from the scene and diagnosed with a high-pressure fuel system failure. The manufacturer was not informed of the failure. The failure mileage was approximately 31,296.

TL* THE CONTACT OWNS A 2020 RAM 3500. THE CONTACT STATED THAT THE VEHICLE WAS ATTACHED TO A TRAILER. AFTER DRIVING AND ARRIVING AT THE RESIDENCE, THE CONTACT BECAME AWARE THAT THE TAILGATE HAD FALLEN INADVERTENTLY WHILE DRIVING, CAUSING DAMAGE TO THE TAILGATE AND THE TRAILER. THE CONTACT TOOK THE VEHICLE TO AUFFENBERG CHRYSLER DODGE JEEP RAM (176 AUTO CT, O'FALLON, IL 62269, (618) 622-4546) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE KEYFOB WAS UNINTENTIONALLY DEPRESSED WHILE IN HIS POCKET, CAUSING THE TAILGATE TO OPEN INADVERTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,000.

WE WERE DRIVING OUR 2020 RAM 3500 DIESEL WITH A 2000-POUND TRUCK CAMPER IN THE BED ON A CITY STREET ATTEMPTING TO MAKE A RIGHT TURN THROUGH A YIELD SIGN WHEN THE ENGINE SUDDENLY STOPPED COMPLETELY WITHOUT THE ABILITY TO RESTART IT. THIS RESULTED IN SUDDEN LOSS OF ACCELERATION, POWER STEERING, AND POWER BREAKS, LEADING TO A NEAR COLLISION WITH A LARGE POLE AND POSSIBLY OTHER VEHICLES IN THE IN THE INTERSECTION. ALTHOUGH WE MISSED THE POLE AND OTHER VEHICLES, IT WAS EXTREMELY DIFFICULT TO AVOID DUE TO LOSS OF POWER STEERING AND BRAKING. HAD OUR SPEED BEEN SLIGHTLY HIGHER, A COLLISION WOULD HAVE BEEN UNAVOIDABLE. AFTER HAVING OUR TRUCK INSPECTED BY THE DEALERSHIP, IT WAS DETERMINED THAT THE CAUSE OF THE ENGINE BREAKDOWN WAS THE BOSCH CP4.2 INJECTION PUMP CATASTROPHICALLY FAILING (OR "GRENADE-ING" OR "IMPLODING" AS THE DEALERSHIP PUT IT) RESULTING IN THE COMPLETE DESTRUCTION OF THE ENTIRE FUEL SYSTEM, STOPPING ALL FUEL FLOW TO THE ENGINE. AFTER THIS HAPPENED TO US, WE DID SOME RESEARCH AND FOUND THAT THE BOSCH CP4.2 INJECTION PUMP HAS BEEN DETERMINED TO BE INCOMPATIBLE WITH DIESEL FUEL FOUND IN THE USA DUE TO LACK OF LUBRICITY, AND HAS OTHER FUNDAMENTAL DESIGN DEFECTS THAT TOGETHER MAKE CATASTROPHIC FAILURE ALMOST INEVITABLE IN VEHICLES DRIVEN IN THE USA. MOST PREVIOUS RAM 3500'S USED A RELIABLE BOSCH CP3 INJECTION PUMP, BUT STARTING IN 2019 MODEL YEARS SWITCHED TO THE LESS EXPENSIVE CP4.2 EVEN THOUGH THIS ISSUE HAS BEEN KNOWN TO RAM AND CUMMINS DUE TO THE COUNTLESS INCIDENTS OF

TRUCK CAUGHT FIRE IN ENGINE COMPARTMENT. I HAD JUST GOTTEN ON THE FREEWAY AND REACHED 70MPH WHEN I COULD SEE SMOKE COMING FROM THE ENGINE. PULLED OVER AND IT QUICKLY BECAME ENGULFED IN FLAMES. STATE FARM CLAIM 28-18Q6-12R ELIZABETH ANDERSON, CLAIM SPECIALIST, 844-292-8615X2539126712

POWER STEERING WENT OUT WHILE DRIVING AT HIGHWAY SPEEDS. WARNING COMES ON THE DISPLAY ADVISING THAT THE POWER STEERING NEEDS TO BE SERVICED. STEERING WHEEL BECOMES VERY STIFF.