2008 Pontiac G6

Defect. Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.

Risk. A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.

Remedy. Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.

Defect. General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Risk. Any of the above failure conditions increases the risk of a crash.

Remedy. GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Defect. General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Risk. If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ‘PARK’ position, the transmission may not be in ‘PARK.’ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy. GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Defect. General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Risk. If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy. GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Defect. General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.

Risk. If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.

Remedy. GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

Problem with completed recall 14V252000. Symptoms have returned. In some vehicles, increased resistance in the Body Control Module (BCM) connection can cause voltage fluctuations in the Brake Apply Sensor (BAS) circuit. This may lead to: Brake lights illuminating without the brake pedal being pressed Brake lights not illuminating when the pedal is pressed Difficulty disengaging cruise control Gear shifter not moving out of PARK without the brake pedal pressed Disablement of crash avoidance features such as traction control, electronic stability control (ESC), and panic braking assist ARFC ARFC +1 These failures increase the risk of a crash

While driving my 2008 Pontiac G6 Base, I lost electrician power to the vehicle, on my car it utilizes an electric power steering module instead of fluid and a pump. When I lost power to the car the wheel became stiff but when I regained power the steering column while the vehicle was in motion did what I can only describe as "Forced knockback or steering" as when I attempted to tightly turn the wheel or turn at all the car steering wheel would yank the wheel free from my hands and prevent turning. This is extremely dangerous and especially if the car would be at high speeds or speeds needed to reach normal highway travel like 50 to 65 mph.

The contact owns a 2008 Pontiac G8. The contact stated that while driving approximately 80 mph the cruise disconnected had erroneously deactivated and the brake lights had remained illuminated . The contact replaced brake sensors, emergency brake sensors and ABS Module but the failure continued to occur. The local dealer was notified of the failure but no assistance was offered. The manufacturer was not contacted. The contact was informed of the NHTSA Campaign Number: 14V252000(ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 94,000.

Fuel pump defective, return hose onto the top of fuel pump starts to leak fuel.Which can led to car stalling out from not having the correct fuel pressure which caused the engine to stall everywhere,the road,fire hazard,etc.

The contact owns a 2008 Pontiac G6. The contact stated that while driving, the steering wheel became difficult to maneuver, and the vehicle was pulled over to the side of the road, turned off, and restarted several times for the power steering function to reset. The power steering warning light was illuminated. The failure had occurred several times. The failure was associated with the steering wheel torque angle sensor. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the steering wheel torque angle sensor needed to be replaced. The independent mechanic informed the contact of NHTSA Campaign Number: 14V153000 (Steering). The manufacturer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was 54,000.

The contact owns a 2008 Pontiac G6. The contact stated that while driving at various speeds, the vehicle lost power steering assist functionality. The contact stated that the check engine warning light illuminated, and the “Power Steering Fault” message was displayed. The contact pulled over, turned off, and restarted the vehicle, and the power steering functionality returned. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact stated that the failure was intermittent. The contact related the failure to NHTSA Campaign Number: 14V153000 (Steering); however, the vehicle was previously repaired under the recall in 2014, and the replacement part had started to fail. The manufacturer was informed of the failure. The failure mileage was approximately 95,000.

The contact owns a 2008 Pontiac G6. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred after the recall repair. The vehicle was taken to the dealer but was not repaired. The manufacturer declined to provide additional repairs under the recall. The manufacturer was notified of the failure. The failure mileage was 115,000.

Car shuts off & other lights light up on dash. Not driving over 20mph.

Unknown - vehicle is jist malfunctioning

No warning lights came on, steering kepted locking up shutting off the vehicle

GM claims to have already completed a safety recall for Power steering, but I didn't see any issues with the power steering prior to them doing this service except for the "Power steering" message on the display. The only reason I brought in at that time (5/18/2023) was to replace the gauge cluster which they also had to replace a second time due to faulty replacement. And now the new issue with power steering still continues to persist (steering wheel locks up while driving). Also the "Power steering" error message was never cleared after the initial service. I have a carfax report showing the power steering being serviced by 2 other GM dealerships after the initial service. This is an electric power steering system so there's no fluid that can leak and should not need serviced multiple times in the same year. They now refuse to fix the issue saying that it's now my problem because the part they replaced is out of warranty. The customer service rep for GM told me there wasn't anything more they could do because it's a 2008! I'm sorry but that should not matter considering the car is still under 200k miles and only 10000 miles were driven before we took it back the second time, and 2000 miles before taking it back the third time. They also claimed that safety was their primary concern at the same time they tell me there's nothing more they will do. This definitely a safety concern but GM doesn't actually care. I'm trying to prevent an accident but they are not. I really hope

Power steering motor went I have no power steering

I have replaced my headlights 3 times and all 3 times the wiring harness connector was fried. I’ve had other issues with my brake lights coming on when I’m not pushing the brake pedal. I can shift out of park without hitting the pedal. All of these issues seem to be more and more frequent. After doing research I seen there was already a recall on the vehicle regarding such issues, my vin just wasn’t included for some reason. Now what I thought was just random issues, I am noticing is actually an already known manufacturer issue.

About 6 months ago I believe I file a complaint about this same issue and here I am again. A few nights ago driving home from the movies with my kids out of nowhere my headlights go out so I had to use my fog lights to make it home. I can't understand how isn't this a safety issue and why hasn't anyone done anything about it or why isn't there a recall. What is the wait? Are we waiting for a tragedy to occur to then do something?? This is like the 3 or 4th time that it has happened. Where is the urgency on this matter?? Or will I have to make a petition with other G6 owners that also have had this issue?? Some feedback would be nice on what to do or do I have to continue to spend $$$ with 0 results. Would appreciate some response and some results.

The dashboard showed an error message regarding the power steering. I took it to my mechanic and they put it on the computer to scan. It came back with 2 error codes. The first one was DTC C0569 46. The second one was DTC C0460 00/4B. I was told the dealership would have to address the issue. They told me these codes were not covered by the recalled part they replaced. The car has approximately 81,500 miles. There doesn't appear to be a leak. At this time the steering is working. There is no stiffness or squealing. This first popped up on the screen about a month ago. I've been concerned about driving it until I know more.

While driving down road the seat warmer or electrical controls caught fire lucky I had water to put fire out after pulling over a long side the road and stopping

Power steering stopped working

Power steering popped up on radio whenever I turn it to the left or right while driving.

This has been an issue that has been going on for a few years it has mostly been the driver side headlight a d o. 2 occasions both headlights have not work. On November 2023 my headlights on the driver's side would not work. Also, my turn signal didn't work at all which almost caused me an accident as I was making a turn not knowing that the turn signal was not working. I took my vehicle to Alden Buick GMC where they did inform me of issues with the headlight wiring they replaced a few wires and used a zip tie to fix it. On another occasion leaving work none of my headlights worked so I had to call my wife and have her drive in front of me so that I can make it home. Now on December I was driving on the highway at 1am and all of a sudden my headlights went off so the only thing I could do is use my fog lights and follow a car in front of me. And now here we are once again driver side Not working. Now, everyone that has a Pontiac G6 knows, the issues with the headlights and the wiring. I just don't see why it hasn't been a recall on this continuous problem or even worst, Safty issue!!

The contact owns a 2008 Pontiac G6. The contact stated that the vehicle failed to start. The vehicle was towed to an independent mechanic, where it was diagnosed that an unknown wiring harness had failed. The independent mechanic informed the contact that he could not repair the vehicle for fear that the vehicle could catch on fire. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 174,000.