2001 Pontiac Aztek

Defect. ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Risk. A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy. DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Risk. THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy. OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Defect. ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.

Risk. THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.

Remedy. DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.

Defect. VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.

Risk. IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.

Remedy. DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Defect. VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.

Risk. IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.

Remedy. DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.

BOUT 3 WEEKS AGO CAR JUST KEEP ACTING UP HAD IT FOR ONE YEAR CANT READ CODES ON CAR KEEP OVERHEATING REPLACED RADIATOR CVL AXLE BRAKES OIL CHANGE TRANSMISSION FLUID CAR JUST DECIDED TO NOT PASS 50MPH BE DRIVEABLE ONE DAY DRIVING IT WENT TO A STOP SIGN BRAKE CAR CUT OFF I SEE CHECK GAUGES COME ON SERVICE LIGHT ON CANT READ CODES TO FIND OUT ANYTHING I THINK THE WIRING IS MESS UP REPLACED STARTED AS WELL JUST TO MUCH ONLY HAD IT FOR A 1AND A HALF

I HAVE REPLACE 2 IGNITION SWITCHES, AND STILL HAVING PROBLEMS..THE KEY WILL NOT COME OUT/UNLOCK WHEN SWITCHING CAR OFF..WHICH KILLS THE BATTERY BECAUSE I CAN'T TURN OFF THE CAR THIS IS TERRIBLE ..IT'S THE IGNITION SWITCH OR THE STEERING COLUMN, THIS HAPPENS WHEN PUTTING THE CAR IN PARK!!!!KEY WILL NOT TURN CAR OFF/CAN'T GET KEY OUT TOO

GM HAS ISSUED A SAFETY BULLETIN IN REGARDS TO A BROKEN FUEL TANK THAT COULD CAUSE EXPLOSIONS, OR FIRE. I HAVE TRIED TO GET THEM TO PERFORM THE REPAIR BUT THEY ARE REFUSING. THE PROBLEM IS FOR ALL YEARS OF THE PONTIAC AZTEK AND BUICK RENDEZVOUS. I HAVE A LEAK FROM THIS LOCATION, THE FUEL INLET, AND AM NEARLY AFRAID TO DRIVE THE VEHICLE, BUT AT A COST OF OVER 2000 DOLLARS, GM IS ALSO INFLATING THE COST BECAUSE THEY KNOW THE REPAIR NEEDS TO BE DONE.

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE VEHICLE FAILED TO START WITHOUT WARNING. THE CONTACT CHARGED THE BATTERY AND STARTED THE VEHICLE, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT IT WAS NOT A BATTERY ISSUE. THE TECHNICIAN SUSPECTED AN IGNITION FAILURE AND PLANNED TO RUN A DIAGNOSTIC TEST THE FOLLOWING DAY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.

THE DRIVER SIDE SEAT AIRBAG DEPLOYED AFTER THE DRIVER SHUT THEIR DOOR, WHILE THE CAR WAS IN PARK.

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. WHILE ATTEMPTING TO CLOSE THE DOOR, THE AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

THE CAR WAS PARK! THE KEYS IN, I PULLED KEYS OUT N THE CAR ROLLED BACKWARDS I HOP IN THE CAR N TURN THE WHEEL AND I FLEW OUT AND THE CAR RAN ME OVER TIRE ON MY BACK THE CAR DIDN'T STOP I PUSHING THE BRAKES NOTHING! *TR

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED THAT AFTER REVERSING OUT OF A DRIVE WAY, THE VEHICLE MADE A LOUD NOISE AS THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS PLACED INTO PARK AND THE IGNITION WAS TURNED OFF. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A ROUND OBJECT FELL FROM UNDER THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSE THAT THE POWER STEERING FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE 100,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO INDICATE THE AMOUNT OF FUEL THAT WAS STORED IN THE FUEL TANK AFTER IT WAS REFUELED. NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE FUEL GAUGE FLOATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

THE KEY CAN BE PULLED OUT OR FALL OUT OF THE IGNITION CYLINDER WITH ALMOST NO RESISTANCE IN THE RUN POSITION, AND DOOR AJAR, KEYS IN IGNITION CHIMES NO LONGER OPERATE AFTER FIRST OCCURRENCE OF KEY FALLOUT. KEY FALLOUT OCCURS EASIER AS TIME GOES ON, I AM UNSURE OF THE EXACT DATE OF FIRST OCCURRENCE. *TR

AFTER ARRIVING HOME FROM WORK, I FOLLOWED MY NORMAL ROUTINE: PARKING IN MY DRIVEWAY, CUTTING OFF THE ENGINE AND REMOVING THE KEY BEFORE EXITING THE VEHICLE; HOWEVER, I COULD NOT REMOVE THE KEY FROM THE IGNITION SWITCH. NO MATTER WHAT I ATTEMPTED IT WOULD NOT BUDGE. MY ADULT SON ALSO TRIED TO REMOVE THE KEY FROM THE IGNITION SWITCH WITH NO SUCCESS. THE KEY WAS STUCK IN THE 2ND POSITION-- MEANING THAT THE VEHICLE WAS STILL "ON" JUST NOT RUNNING. I LEFT IT AS IT WAS WITH MY KEY STUCK IN THE IGNITION. THE NEXT MORNING, OF COURSE, MY BATTERY WAS DEAD BECAUSE THE IGNITION SWITCH WAS STILL IN THE "ON" POSITION. THE NEXT DAY I FOUND A TEMPORARY "WORKAROUND" ON YOUTUBE. HOWEVER, THE IGNITION IS STILL NOT FIXED AND I AM STILL USING THE TEMPORARY WORKAROUND. I HAVE CONTACTED A LOCAL GM DEALER AND GM OFFICES ONLY TO BE TOLD THAT THE RECALL DOES NOT COVER MY VEHICLE. I KNEW THAT BEFORE I CALLED THEM; WHICH WASN'T THE REASON I CONTACTED THEM. I ASKED WHY THIS PARTICULAR IGNITION PROBLEM WAS NOT ISSUED A RECALL AND I WAS TOLD BY A GM REPRESENTATIVE THAT IT HAD TO BE ISSUED FROM YOUR ORGANIZATION. I THINK THIS SHOULD BE ADDED TO THE IGNITION SWITCH RECALL THAT IS CURRENTLY BEING INVESTIGATED. GM DID AN OVERALL POOR JOB WITH THE IGNITION SWITCHES ON THE VEHICLES THAT WERE SOLD TO THE PUBLIC AND THEY NEED TO TAKE ACCOUNTABILITY FOR IT. THANK YOU. *TR

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED WHEN HIS WIFE APPLIED THE BRAKE, SHE EXPERIENCED IMMEDIATE AND COMPLETE BRAKE FAILURE. A POPPING AND WHOOSHING SOUND WAS HEARD AND THE BRAKE PEDAL WENT TO THE FLOOR. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT ONE OF THE BRAKE LINES FAILED DUE TO RUSTED THROUGH AT THE POINT OF FAILURE, AS WELL AS EXTREMELY RUSTED AT EVERY PLACE IT WAS CLIPPED TO THE BODY OF THE VEHICLE TO THE BACK OF THE VEHICLE. THE MECHANIC RECOMMENDED THE ENTIRE BRAKE LINE BE REPLACED. . THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 136,000. THE CONSUMER STATED IT WAS THE SECOND TIME, THE BRAKE LINE FAILED, DUE TO CORROSION. THE FIRST TIME WAS IN 2007, WHEN THE VEHICLE HAD 65,000 MILES. UPDATED 03/11/15. *JB

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE IGNITION SWITCH HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE. *TR

WAS DRIVING THE CAR THE PASSENGER AIRBAG DEPLOYED . LIKE TO SCARE ME TO DEATH. *TR

AS I HAVE SEEN OTHER OWNERS OF THIS SPECIFIC CAR STATE ON YOUR SITE, MY FUEL TANK HAS DEVELOPED A CRACK, AND I WAS TOLD BY GM THAT I AM OUT OF LUCK BECAUSE IT IS "OUT OF RECALL SINCE 2011," EVEN THOUGH I WAS NEVER NOTIFIED ABOUT A POSSIBLE PROBLEM WITH MY FUEL TANK! SO NOW I AM DRIVING AROUND IN, ESSENTIALLY, A MOLOTOV COCKTAIL, HAVING TO SPEND $800 TO REPLACE A GAS TANK THAT WAS SUPPOSED TO BE REPLACED BY GM IN 2007, AT NO COST, BECAUSE GM FAILED TO NOTIFY ME. THIS IS VILE. TO THINK THAT GM DOESN'T CARE IF OWNERS OF THEIR CARS ARE DRIVING AROUND IN POTENTIAL FIREBOMBS, THAT THEY KNEW ABOUT, IS SICKENING. I PURCHASED THIS CAR NEW, AND CERTAINLY DESERVED TO BE NOTIFIED ABOUT PROBLEMS THAT ARE POTENTIALLY LIFE-THREATENING, AND OFFERS TO REPLACE DEFECTIVE PARTS, THAT WERE SUPPOSED TO BE SENT TO ME, AS PER THE NHTSA CAMPAIGN ID #07V349000. *TR

BRAKE LINE THAT RUNS FROM THE DRIVER'S SIDE TO THE PASSENGER SIDE WAS ROTTED OUT, RIGHT IN THE MIDDLE, AGAINST THE FIREWALL. THE OTHER PARTS OF THE LINE ARE "OK". SEEMS TO BE A COMMON THING IN THIS CHASSIS. *TR

I CONTACTED PONTIAC REGARDING A RECALL ON MY AZTEC WHICH INCLUDES THE FUEL TANK, THIS IS A SAFETY ISSUE SINCE IT CAN CATCH FIRE WITH JUST A SPARK FROM ELECTRICAL ON MY CAR, WELL THEY SAID THAT I WAS OUT OF THE RECALL SINCE 2011 I WAS NOT EVEN AWARE THERE WAS A RECALL UNTIL I STARTED INVESTIGATING MY PROBLEM ONLINE, I DID NOT RECEIVE ANY NOTICE REGARDING THIS SAFETY ISSUE I AM NOT THE ORIGINAL OWNER I BOUGHT IT USED BUT I REGISTERED IT AND NEVER RECEIVED ANY NOTICE, MY CHILDREN AND GRANDCHILDREN RIDE IN THIS CAR, AND ALL THEY COULD TELL ME AT PONTIAC WAS WE ARE SORRY BUT YOU ARE OUT OF THE RECALL TIME, AND WE CAN SCHEDULE YOU AN APPOINTMENT BUT WE WILL NOT PAY, SO THEY DO NOT CARE IF SOMEONE COULD POSSIBLY DIE IN A VEHICLE THAT WAS A FACTORY DEFAULT , WHICH IS THEIR FAULT NOT MINE. THEY ARE REFUSING TO FIX THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE CONTACT STATED THAT WHILE LOADING THE VEHICLE WITH BOXES, THE SIDE AIR BAG DEPLOYED ERRONEOUSLY, STRIKING A PASSENGER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS WAITING FOR A CORPORATE ENGINEER TO FURTHER INSPECT THE DAMAGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 197,000.

BRAKES FAILED - THE PEDAL WENT ALL THE WAY TO THE FLOOR WHILE ENTERING US10 IN BAY COUNTY, MI. WHY - BECAUSE THE BRAKE LINE FAILED. TO ME, THIS IS A VEHICLE SAFETY ISSUE AND A DESIGN PROBLEM. THE PROBLEM WAS FIXED AT GRAFF CHEVROLET, 3636 E WILDER RD, BAY CITY, MI. THE FIX INCLUDED REPLACING A SECTION OF BRAKE LINE THAT WAS WRAPPED IN HEAT REFLECTING TAPE. THE WAY I SEE IT, THE TAPE TRAPPED WATER BETWEEN THE TAPE AND THE STEEL TUBE CAUSING THE RUSTED TUBE TO FAIL. POOR ENGINEERING DESIGN. HOW MANY MORE CARS ARE THERE OUT THERE, ON THIS CAR PLATFORM, THAT WILL EXPERIENCE THIS FAILURE? I OWN A 1958 CHEVY CONV, THAT HAS EXISTED IN MICHIGAN SINCE 1958. IT HAS NOT HAD THIS PROBLEM. I'M NOT LOOKING FOR MONEY. I WANT TO PROTECT ALL THE PEOPLE OWNING THESE VEHICLES FROM BE KILLED OR WHATEVER OTHER LIFE ALTERING THINGS THAT COULD HAPPEN. I WAS VERY VERY LUCKY WHEN MY BRAKES FAILED. *TR

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE CONTACT STATED THAT THE FUEL GAUGE FAILED. AFTER REFUELING THE VEHICLE TO FULL CAPACITY, THE FUEL GAUGE WOULD SHOW AN EMPTY READING ABNORMALLY. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THE SENSOR IN THE FUEL TANK HAD FAILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 89,000.

2001 PONTIAC AZTEC. CONSUMER STATES THAT HE HAS SOME ELECTRICAL SAFETY ISSUES WITH HIS VEHICLE. HE HAS REPLACED THE HEADLAMP SWITCH ASSEMBLY, INSTRUMENT CONTROL ASSEMBLY, HVA TEMPERATURE CONTROL ASSEMBLY, FUEL PUMP MODULE ASSEMBLY AND TURN SIGNAL SWITCH ASSEMBLY. *KB THE LIGHTS THAT ILLUMINATED THE ASSEMBLIES BURNED OUT AND THE CONSUMER WAS UNABLE TO SEE THE INSTRUMENT PANEL AT NIGHT. DUE TO THE SENDING UNIT MALFUNCTIONING, THE FUEL GAUGE WOULD NOT REGISTER THE AMOUNT OF FUEL REMAINING IN THE TANK. BECAUSE THE SENDING UNIT WAS A PART OF THE FUEL PUMP ASSEMBLY, THE ENTIRE UNIT REQUIRED REPLACEMENT. ALSO, WHILE DRIVING AT NIGHT WITH THE HEADLIGHTS ON, WHEN THE CONSUMER ACTIVATED THE TURN SIGNAL, THE HIGH BEAM LIGHTS WOULD COME ON. UPON TURNING THE SIGNAL OFF, THE HIGH BEAMS WOULD ALSO TURN OFF. *JB

PURCHASED THE PONTIAC 2001 AZTEK FROM A DEALER USED. THE FIRST WEEK THE CHECK ENGINE LIGHT CAME ON. SECOND WEEK THE SERVICE VEHICLE LIGHT CAME ON AND THE THERMOMETER GAUGE WAS STUCK IN COLD, TOOK THE CAR TO CHECKERS AUTOPARTS TO DIAGNOSE. WAS A BAD THERMOSTAT. ANOTHER WEEK LATER THE ENGINE STARTED OVERHEATING. STOPPED CHECKED COOLANT. WAS GONE OUT OF THE RESERVOIR, WHICH I JUST HAD FILLED AT JIFFY LUBE THAT MORNING. STOPPED BY THEM AGAIN, THEY CHECKED THE LIQUIDS, FOUND COOLANT MIXED IN WITH THE OIL. ADVISED NOT TO CONTINUE DRIVING THE VEHICLE SINCE IT CAN MESS UP THE ENGINE. CALLED DEALER AND HAD THEM TOW IT. THEY HAVE BEEN WORKING ON IT FOR THE PAST 4 DAYS. STATED THAT IT WAS THE INTAKE MANIFOLD GASKET. WONDERING IF THIS VEHICLE IS SAFE AFTER READING SEVERAL COMPLAINTS REGARDING IT. AND ALSO IF PONTIAC WOULD FIX IT. *TR

2001 PONTIAC AZTEK TRUCK. CONSUMER SENT DOCUMENTS REGARDING WORK DONE TO VEHICLE *TGW THE CONSUMER STATED THE TRANSMISSION HAD TO BE REPLACED, THE WINDOW WOULD NOT GO DOWN AND THE CHECK ENGINE LIGHT ILLUMINATED *JB

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE CONTACT STATED WHEN HE ATTEMPTED TO TURN ON THE IGNITION, THE VEHICLE WOULD NOT START. HE ATTEMPTED SEVERAL TIMES BUT THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TOWED TO HIS HOME. HE RESEARCHED ONLINE AND DISCOVERED MANY OTHER CONSUMERS HAVING A SIMILAR FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 117,000.

FRONT CRASH AGAINST A SOLID CORNER OF A BUILDING, APROX SPEED CRASH 45 MPH. GM DID NOT WANT TO REPAIR OR REPLACED, INSTEAD FACED A TRIAL WHERE THEY COMMITTED A FRAUD AND OTHER FELONIOUS, ALL OF THEM PROVEN, STILL AFTER NEARLY 9 YEARS STILL FACING CIVIL AND CRIMINAL CHARGES. GM DEALER WITH FALSE STATEMENT STILL NOW A DAYS KEEPS THE VEHICLE, SAME THAT STILL CAN BE ANALYZED NOW A DAYS BECAUSE IT HAS NOT BEEN REPAIRED. LOTS OF DAMAGE CAUSED BY GM, DEALERS, LAWYERS AND EXPERT WITNESSES. REGRET VERY MUCH SUCH A POOR BEHAVIOR OF GM, I MA READY TO SUPPLY AS MUCH INFORMATION AS NEEDED, PHOTOS, REPORTS, AND COURTS DOCUMENTS THAT PROVES THEIR FELONIOUS. A GM EXPERT WITNESS SUBMITTED TO THE COURT A FALSE REPORT, AND ALSO BOUGHT THE OFFICIAL EXPERT WITNESS OF THE COURT, THESE FELONIES HAVE ALREADY BEEN PROVED BYTHE COURT, THAT IS WHY NOW THEY ARE FACING A CIVIL AND CRIMINAL CHARGES, FOR GM IF NOT QUALITY GOOD IS THE FRAUD!!!!! *TR

FIVE YEARS AFTER OWNING OUR 2001, PONTIAC AZTEC OUR INSIDE FAN CONTROL BURNT UP AND NEEDED REPLACEMENT. 07/07/2009 I PURCHASED ANOTHER 2001, AZTEC AT AN AUCTION AND TO FIND OUT THE FAN WASN'T WORKING. I BROUGHT MY VEHICLE INTO THE GARAGE FOR REPAIRS AND MAINTANENCE AND THE MECHANIC SAID THE WIRES WERE MELTED AND IT WILL COST CLOSE TO $200.00 FOR JUST REPLACEMENT PARTS. THE FIRST PONTIAC HAD EXTENDED WARRANTY WHICH WAS A GOOD THING. IN CLOSING I AM CURIOUS TO KNOW IF OTHER COMPLAINTS HAVE BEEN FILED? THANK YOU *TR

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEC. WHILE DRIVING APPROXIMATELY 45 MPH AT NIGHT, THE HEADLIGHTS FAILED WITHOUT WARNING. THE DRIVER EXPERIENCED EXTREMELY LIMITED VISIBILITY. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT MADE SEVERAL ATTEMPTS BEFORE THE HEADLIGHTS ILLUMINATED AGAIN. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THE CONTACT WAS INFORMED THAT THE BODY CONTROL MODULE FAILED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNABLE TO BE ENTERED INTO THE SYSTEM. THE FAILURE AND CURRENT MILEAGES WERE 80,000.

A/C QUIT WORKING IN MY 2001 PONTIAC AZTEC. GM DEALERSHIP REPLACED A LINE SAYING THERE WAS A HOLE. AFTER THE LINE REPLACEMENT, I'M TOLD THAT THERE IS A LEAK IN THE CONDENSER DUE TO A BRACKET FAILURE. I AM LOOKING AT ABOUT $900 TO $1,000 IN REPAIRS. I AM NOT THE ONLY ONE TO REPORT THIS ISSUE FOR THIS VEHICLE. *TR

MY AZTEK WHICH HAS 92,000 MILES, SUFFERS FROM WHAT IS SOMETIMES CALLED "THE DISCO AZTEK" MEANING MY BCU WENT OUT. THIS HAS CAUSED THE PW, PL, GAUGE CLUSTER BACK LIGHT, REAR HATCH, AND RADIO TO QUIT WORKING. THIS IS NOT ONLY A SAFETY HAZARD BUT IS ANNOYING. IT IS ESTIMATED TO COST AROUND $300 TO FIX. GOOD NEWS IS THAT THERE IS A WAY TO MANUALLY RELEASE THE REAR HATCH, IF YOU'VE GOT SOME TOOLS. *TR

LOSS OF LIGHTS, GAUGES, HORN GOING ON, DURING DRIVING. *TR

SMELLED GAS FUEL LEAKING UNDERNEATH THE VEHICLE. MECHANIC DETERMINED FUEL TANK NEEDED TO BE REPLACED DUE TO A CRACK WELD...GAS GAUGE MALFUNCTION..SAYS TANK IS EMPTY WHEN FULL AND VISE VERSA.. *TR

FUEL LEAKAGE: SYSTEM MALFUNCTIONING-INABILITY TO MAKE A GOOD SEAL... TANK-LEAKAGE FUEL/EMISSIONS- DETECT PROBLEM CURRENTLY PASSENGER AIR BAG MAY NEED PIN REPLACE: WISH TO HAVE ALL CHECKED OUT! SAFETY CHILD SEAT HOLDER MAY NOT BE FUNCTIONAL. *TR

IN EARLY JULY, 2008, SERVICE ENGINE LIGHT CAME ON. DEALERSHIP REPLACED GAS CAP BECAUSE DIAGNOSTIC CODE INDICATED FUEL VAPORS ESCAPING. SERVICE ENGINE LIGHT CAME ON NEXT DAY. RETURNED TO DEALERSHIP, EXPLANATION WAS THAT THE CODES MUST HAVE NOT BEEN RESET. SERVICE ENGINE LIGHT CAME ON NEXT DAY. DIAGNOSTIC CODES INDICATED THAT FUEL VAPORS ARE ESCAPING. CRACK @ FUEL FILL TUBE IS DIAGNOSED. I HAD RECEIVED A LETTER FROM THE MANUFACTURER (GM) ABOUT THIS IN JANUARY 2008. THE LETTER INDICATED THAT REPAIRS WOULD BE MADE IF THIS PROBLEM MADE IT NECESSARY, BUT NOT TO REPAIR UNLESS INDICATED (THERE WAS NO RECALL). THE PART WAS ORDERED MID-AUGUST OF 2008. I WAS TOLD THERE WERE NO PARTS IN INVENTORY, NATIONWIDE. AFTER COMPLAINING TO GM CUSTOMER SERVICE, I WAS TOLD THAT THE PART WOULD SHIP ON SEPTEMBER 19TH, 2008. AS OF OCTOBER 9TH, THERE IS STILL NO PART, STILL NO REPAIR. THE SERVICE ENGINE LIGHT IS STILL ON, FUEL VAPORS ARE STILL ESCAPING FROM THE VEHICLE. IS THIS SAFE??? *TR

I NOTICED FUEL LEAKING FROM UNDERNEATH THE CAR ONTO THE PAVEMENT. UPON CLOSER OBSERVATION I DETERMINED THAT THE SOURCE OF THE LEAK WAS THE JOINT WERE THE FUEL FILLER NECK ENTERS THE FUEL TANK. THIS JOINT APPEARS TO BE LEAKING THROUGH THE PLASTIC WELD. MY VEHICLE WAS NOT COVERED UNDER THE RECALL. BUT IT IS MY INTENTION TO TRY AND GET GM TO COVER THE COST OF REPLACEMENT. *TR

MY CAR STARTED TO RUN HOT AS SOON AS THE CAR WAS DROVE ABOUT A QUARTER OF A MILE, BUT THE FLUID WASN'T HOT. MY HUSBAND REPLACED THE THERMOSTAT, HOSES, A COOLING SENSOR, AND SOME OTHER THINGS. WHEN NONE OF THAT WORKED, WE TOOK IT TO A RADIATOR SHOP AND THEY TOLD US WE NEED HEAD GASKETS. WE HAVE A 2001 AZTEK AND WHEN WE GOT THE CAR IN 2004, THE GASKETS BLEW BUT IT WAS UNDER WARRANTY. THAT IS AN EXPENSIVE JOB. GM NEEDS TO RECALL THIS VEHICLE AND GIVE US ALL SOME RELIABLE CARS AND TRUCKS! *TR

WE HAVE HAD PROBLEMS WITH OUR REAR HATCH OPENING PROPERLY SINCE WE PURCHASED THIS AZTEC NEW IN 2000. ABOUT 3 YEARS AGO, THE PROBLEM DEVELOPED INTO NOT BEING ABLE TO OPEN THE REAR HATCH WITH THE KEY FOB, DASH RELEASE BUTTON AND THE MOST FRUSTRATING AS WELL AS DANGEROUS ASPECT IS IT WOULD NOT OPEN EVEN BY USING THE VEHICLE KEYS. IT HAS NOW INCREASED TO THE POINT THAT THE CARS ALARM SYSTEM WILL GO OFF ON ITS OWN, THE AIR CONDITIONER QUITS WORKING, THE REMOTE ENTRY DOOR SYSTEM BECOMES USELESS AND ENTIRE VEHICLES ELECTRICAL DOOR LOCK SYSTEM FAILS. SINCE ONLY THE TWO FRONT DOORS WILL OPEN WITH THE VEHICLE KEY AND WE ALMOST ALWAYS HAVE CHILDREN IN CAR SEATS IN THE REAR, THIS HAS BECOME A DANGEROUS SITUATION. IN SEARCHING THE INTERNET, WE FOUND THAT IF WE PULLED THE FUSE THAT CONTROLLED THE VEHICLES COMPUTER MODULE, CALLED THE BCM, THE MODULE WOULD RESET ITSELF AND IT WOULD TEMPORARILY FIX THE PROBLEM. ESTIMATES TO FIX THIS BY THE DEALER ARE UPWARDS OF $ 700.00 AND HE DOESN'T KNOW FOR SURE IF THIS WILL FIX THE PROBLEMS. AN AC DELCO BRANDED BCM REPLACEMENT ON THE INTERNET CAN BE PURCHASE FOR LESS THAN $ 170.00. I BELIEVE GM SHOULD ISSUE A RECALL ON THIS PRODUCT OR AT LEAST OFFER TO FIX THE PROBLEM AT A REASONABLE COST TO THE CONSUMER. *TR

2001 PONTIAC AZTEK I HAVE REPLACED THE UPPER AND LOWER INTAKE GASKETS AS WELL AS THERMOSTAT AT QUITE AND EXPENSE AND NOW THE HEAD GASKETS ARE BLOWN. THIS SEEMS TO BE A VERY COMMON PROBLEM WITH THE 3.4 L FROM GM AND IT STILL HASN'T BEEN RECALLED OR FIXED TO THE CONSUMERS BEHALF?I HAVE READ THAT IT WAS BLAMED ON THE DEX-COOL COOLANT THAT GM USED FROM MID 90'5- PRESENT IF THAT'S THE CASE WHY ISN'T GM HELD RESPONSIBLE IF THEY KNOW THEIR COOLANT IS THE CAUSE OF GASKET BREAKDOWN? *TR

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE VEHICLE WAS LOCKED IN THE PARK POSITION. THE CONTACT READ THE OWNER'S MANUAL AND ATTEMPTED TO RELEASE THE VEHICLE THROUGH THE CUPHOLDER AS INSTRUCTED. SHE COULD NOT DO SO ON THE DRIVER'S SIDE AND WENT TO THE PASSENGER SIDE INSTEAD. SHE WAS ABLE TO RELEASE THE LOCK AND WAS ON HER WAY BACK TO THE DRIVER'S SIDE WHEN THE VEHICLE KNOCKED HER DOWN. ACCORDING TO WITNESSES, THE VEHICLE MADE AN L AND STRUCK ANOTHER VEHICLE. THE VEHICLE WAS TOWED AND HAS NOT YET BEEN DIAGNOSED. UPDATED 08/27/08. *LJ UPDATED 08/27/08. *JB

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEK. WHILE THE VEHICLE WAS RECEIVING A FREE OIL CHANGE, THE CONTACT WAS INFORMED THAT THE INTAKE MANIFOLD WAS LEAKING ANTIFREEZE INTO THE ENGINE. GENERAL MOTORS ADVISED HIM TO TAKE HIS VEHICLE TO A PONTIAC DEALER. THE DEALER STATED THAT THEY COULD NOT WORK ON THE VEHICLE THROUGH THE WARRANTY AND ADVISED THE CONTACT TO TAKE HIS VEHICLE TO ANOTHER DEALER. GENERAL MOTORS STATED THAT THEY WOULD REPAIR THE VEHICLE UNDER WARRANTY, BUT LATER CHANGED THERE MIND. THE REFERENCE NUMBER FROM GENERAL MOTORS WAS 71-616597877. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 89,595 AND FAILURE MILEAGE WAS 89,575.

AIR CONDITIONING REPLACED 4 TIMES AT MY OWN EXPENSE ONCE WHEN IT WAS UNDER WARRANTY. SHORTLY AFTER IT BROKE AGAIN DUE TO DEFECT IN MANUFACTURING AS STATED BY THE DEALERSHIP. HOLE IS CREATED DUE TO BRACKET AND COOLANT LEAKS OUT. THE PURCHASE AND INSTALL OF A NEW ONE HAS COST ME $1200 EACH TIME IT HAPPENS AND FOR THE PAST 4 YEARS I'VE JUST DRIVEN WITHOUT AIR CONDITIONING DUE TO THE COST FACTOR AND KNOWING IT'S GOING TO HAPPEN AGAIN IN THE NEXT 2 MONTHS. EVERYTIME IT WAS REPLACED IT WAS FOR THE SAME PROBLEM A HOLE IN THE CONDENSER. I'VE HEAR COMPLAINTS FROM EVERY ATZEK OWNER I'VE MET ABOUT THE AIR CONDITIONING AND STILL PONTIAC REFUSES TO FESS US TO THE MANUFACTURING DEFECT. FOR THE PAST 4 YEARS I'VE HAD TO DRIVE AROUND IN 90+ DEGREE HEAT WITHOUT AIR BECAUSE OF THIS. I'M A FIELD TECHNICIAN AND I'M TRAVELING YEAR ROUND. I HAD AN 88 GRAND PRIX PREVIOUSLY AND THAT HAD ISSUES WITH THE BRAKES AND I SPENT THOUSANDS OF DOLLARS ON BRAKES ONLY TO RECEIVE A LETTER 2 YEARS AFTER I GOT RID OF THE CAR CLAIMING I CAN GET MONEY BACK DUE TO A DEFECT IN THE BRAKES. I SHOULDN'T HAVE TO SUFFER FROM HEAT EXHAUSTION DUE TO A DEFECT IN THE WAY PONTIAC DESIGNED THE AC. THEY SHOULD ATLEAST BE ABLE TO DESIGN SOMETHING THAT WON'T CORE A HOLE IN THE CONDENSER. THEY ALSO HAVE ISSUES WITH THE TAILGATE AND REAR LIGHTS PEELING. I HAVE TO OPEN MY TAILGATE 2 TIMES AND USE THE KEY WHILE PULLING THE TAILGATE UP. I'VE GOTTEN THE PARTS REPLACED 2 TIMES AND IT HASN'T SOLVED THE PROBLEM THEY TELL ME EVERYTIME I OPEN

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEC. THE CONTACT WAS CONCERNED THAT HIS VEHICLE MAY CATCH FIRE DUE TO NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE). THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 35,785.

2001 PONTIAC AZTEK FUEL LEAK. CONSUMER STATES THAT HIS DAUGHTER IN LAW WILL HAVE TO PAY FOR THE VEHICLE TO BE INSPECTED FOR A FUEL LEAK PROBLEM. HE STATES THAT THIS SHOULD BE A RECALL OR AT LEAST BE COVERED BY THE MANUFACTURER. *KB

GRADUAL LOSS OF BRAKING DUE TO A LEAK IN THE BRAKE LINE. BRAKE FLUID FROM THE LEAKING BRAKE LINE DRIPPED ON CATALYTIC CONVERTER CAUSING A FIRE. THE BRAKE LINE WAS RECONSTRUCTED BY A LICENSED MECHANIC. NO DAMAGE TO ANY OTHER PART OF THE CAR. *TR

DEFECTIVE WELD ON THE FILL SPOUT LOCATED ON THE FUEL TANK CAUSES A STRONG GAS SMELL AND FUEL DAMPENING AROUND THE FILL NOZZLE. *TR

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE STORAGE TANK IN THE VEHICLE. SHE ARRIVED AT THE DEALER AND THEY ADVISED HER TO GET RID OF THE VEHICLE. GM STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), EVEN THOUGH THE VEHICLE IS EXPERIENCING THE SAME FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED AND IS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

LEAKING FUEL TANK ON 2001 AZTEK AT CHECK VALVE WELDED ON PLASTIC TANK. *JB UPDATED 01/07/08. *LJ TRAFFIC CRASH REPORT. UPDATED 12/12/07 *TR

RETURNED FROM 1 WEEK VACATION AND FOUND CAR WAS LEAKING FUEL. WEATHER HAD BEEN UNUSUALLY HOT IN OUR AREA. CONDITIONS SOUND IDENTICAL TO NHTSA RECALL 07V349000, HOWEVER WHEN I PHONED THE DEALER THEY SAID THAT MY VIN WAS NOT COVERED AND REFUSED TO TAKE ANY RESPONSIBILITY. *JB. UPDATED 01/11/08. *LJ UPDATED *JB

I WAS FINDING ANTIFREEZE IN MY OIL. TOOK TO THE SHOP AND HAD TO HAVE THE INTAKE GASKET AND THE MANIFOLD GASKET REPLACED. ALSO HAD TO HAVE A NEW THERMOSTAT AND PVC VALVE. IT COST ALMOST $900.00. THIS IS NOT THE ONLY PROBLEMS HAVE HAD TO HAVE THE FRONT WHEEL BEARINGS REPLACED 2 TIMES AND BRAKE SHOES 2 TIMES. ALSO HAD TO HAVE THE HEATER FIXED. NOW THE AC DOES NOT WORK. HAD TO HAVE THE WINDOW CONTROL UNIT REPLACED ON THE DRIVER SIDE. HAD TO HAVE COMPUTER COMPONENTS REPLACED BECAUSE THE BATTERY WENT BAD WITH NO NOTICE. AND NOW THE WINDSHIELD WIPERS DO NOT WORK. TO FIX THIS PROBLEM IS GOING TO COST ME $200 THAT IS JUST FOR THE WHOLE MOTOR AND CONNECTING RODS. BECAUSE IT IS A FACTORY ONLY PART. ALL TOGETHER I HAVE PAID ALMOST $2,000.00. THE AC IS THE CONDENSER WHICH IS ANOTHER $300.00. I HAVE HAD AND LOVED GM VEHICLES FOR AWHILE. BUT THIS KIND OF THING HAS NEVER BEEN A PROBLEM.....SOMETHING HAS GOT TO BE DONE. *JB

TL*THE CONTACT OWNS A 2001 PONTIAC AZTEC. SHE STATED THAT THE CONDENSER WOULD NOT BLOW COLD AIR WHEN ENGAGED. THE DEALER STATED THAT THERE WAS A HOLE IN THE CONDENSER. THE CONDENSER HAS BEEN REPLACED ON FOUR OCCASIONS. THE MANUFACTURER OFFERED HER A VOUCHER FOR A NEW VEHICLE. AS OF AUGUST 7, 2007, THE FAILURE HAS NOT BEEN RECTIFIED. THE FAILURE MILEAGE WAS 13,745 AND THE CURRENT MILEAGE WAS 92,000. THE CONSUMER WAS TOLD THAT BRACKETS WERE PUNCHING HOLES IN THE CONDENSER. AFTER THE LAST CONDENSER REPLACEMENT, THE CONSUMER SMELLED SOMETHING BURNING AND NOTICED ANTI-FREEZE LEAKING ONLY WHEN THE AIR CONDITIONER WAS ON. THE CONSUMER RETURNED TO THE DEALERSHIP AND WAS INFORMED THAT A NEW RADIATOR WAS NEEDED AND THERE WAS A PROBLEM WITH THE INTAKE. THE CONSUMER WAS THEN TOLD THE INTAKE WAS OK, BUT A RADIATOR WAS STILL NEEDED. UPDATED 09/11/07. THE BLOWER MOTOR WAS ALSO REPLACED. UPDATED 09/11/07. *JB

THE GAS FILLER INLET PIPE CONNECTS TO THE SIDE OF MY PONTIAC AZTEK FUEL TANK. THE TANK IS PLASTIC AND THE FLANGE ON THE SIDE OF THE TANK IS MOLDED TO THE TANK. I HAVE A CRACK ON THE UNDERSIDE AREA OF THE FLANGE. ALL BUT ABOUT 3 GALLONS OF GAS LEAKED OUT IN MY DRIVEWAY. I ASKED THE SERVICE MANAGER AT THE LOCAL PONTIAC DEALER IF THERE WAS A RECALL ON THIS, HE SAID NO, BUT THIS WAS A COMMON PROBLEM. I WAS QUOTED $1000.00 TO REPLACE THE TANK. *TR