2006 Nissan Titan complaints

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THE WIRING HARNESS IS BROKEN BETWEEN ON THE REAR DRIVER SIDE DOOR. THE DEALER WAS NOTIFIED OF THE PROBLEM. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 92,450 AND THE CURRENT MILEAGE 92,850.

BOTH REAR AXLE SEALS ARE LEAKING AND NEED REPLACED. I HAVE NEVER PULLED ANYTHING WITH THIS TRUCK AND AT 70,000 OR EVEN SOONER, I'M NOT SURE WHEN IT STARTED LEAKING, YOU SHOULD NOT HAVE TO PAY FOR REPLACE REAR AXLE SEALS. *TR

RIGHT REAR WHEEL SEAL IS LEAKING BADLY NOTICED AT 65000 MILES BUT IT LOOKS LIKE ITS BEEN LEAKING FOR A WHILE. THIS PROBLEM SEEMS TO BE FREQUENT AND IT ALSO SEEMS TO BE A SAFETY ISSUE IT OIL LEAKING ONTO THE BRAKES. *TR

2006 NISSAN TITAN REAR AXLE SEALS BEGAN LEAKING. VEHICLE HAS NEVER BEEN OFF THE PAVEMENT AND HAS HAD ALL MAINTENANCE PERFORMED BY THE OWNER MANUAL LIST. *TR

LEFT AND RIGHT SIDE EXHAUST MANIFOLDS ARE CRACKED. THEY ARE NORMALLY COVERED UNDER THE EMISSIONS WARRANTY OF 8YR/80K MILES. I AM OUT OF WARRANTY BY 4,000 MILES. I PUT 4K MILES EVERY 3 MONTHS AND I HAVE HEARD THE TICKING NOISE WHEN THE VEHICLE IS COLD FOR OVER THIS TIME PERIOD. I CONTACTED NISSAN USA FOR LOYAL CUSTOMER ASSISTANCE AND WAS DENIED. I FILED AN APPEAL AND WAS DENIED WITHIN 2 HOURS. I HAVE OWNED (3) NISSANS IN THE PAST 7 YEARS AND EXPECT SOME COMPENSATION. THIS IS A MAJOR PROBLEM ON ALL TITANS 2004 TO 2007. THIS SHOULD BE UNDER RECALL FOR EXHAUST GASES GETTING INTO THE PASSENGER COMPARTMENT. *TR

I NOTICED AN EXHAUST LEAK ON MY TRUCK. TOOK IT TO A REPUTABLE EXHAUST SHOP, THEY TOLD ME THEIR WAS A CRACK IN THE CONVERTER AND I NEEDED TO TAKE IT TO THE DEALERSHIP. AFTER CHECKING THE WEB I REALIZED IT WAS UNDER WARRANTY (80000 ON EXHAUST EMISSIONS) MY TRUCK ONLY HAD 65K. THEY REPLACED BOTH MANIFOLDS AS THEY WERE BOTH CRACKED. THIS REPAIR WOULD HAVE COST ME 2500.00! AFTER SEEING THIS WAS A COMMON PROBLEM WITH THE TITAN TRUCKS, I THINK THIS SHOULD BE ADDRESSED. ALSO THE DEALERSHIP TOLD ME I HAD A FRONT DIFFERENTIAL LEAK WHICH WAS THE PINION SEAL, THIS REPAIR WILL COST ME 300-500.00. OF COURSE ITS NOT COVERED UNDER WARRANTY SO I WILL HAVE TO PAY THIS. AFTER SEEING THIS IS ALSO A COMMON PROBLEM, I FEEL NISSAN NEEDS TO CORRECT THIS ISSUE AS IT IS A SAFETY PROBLEM FOR BOTH ME AND FELLOW MOTORIST. MY TRUCK HAS 65,000 MILES AND IS BABIED! TOTAL REPAIRS WOULD BE AROUND 3000.00 FOR THE MANIFOLDS AND THE DIFFERENTIAL, I FEEL SOMETHING NEEDS TO BE DONE AS THIS IS AN ONGOING ISSUE. *TR

ABOUT A MONTH AGO I NOTICE A WEIRD NOISE COMING FROM UNDERNEATH MY TRUCK WHENEVER I WOULD SLOW DOWN AND SOMETIMES SPEED UP. AS THE WEEK WENT BY I NOTICE THE NOISE GETTING LOUDER. IT STARTED OUT WITH A CLICKING SOUND THEN IT INTENSIFIED WITH A CLUCKING SOUND. AFTER HAVING A LOCAL SHOP LOOK AT MY TRUCK THEY FOUND FLUIDS BY THE RIGHT BREAK, WHICH INDICATED THAT A SEAL HAD GONE BAD AND THEY ALSO TOLD ME THAT THE CLUCKING AND CLICKING NOISES ARE FROM THE GEARS IN THE DIFFERENTIAL. PIECES OF THE GEARS HAD BROKEN OFF. THEY ESTIMATED A JOB LIKE THIS WOULD RUN ABOUT $3500!!! I DO NOT HAVE THE KIND OF MONEY! I HAVE READ ALL THE TREADS POSTED BY PEOPLE WHO HAVE THIS SAME PROBLEM AND HAVE CONTACT NISSAN'S CONSUMER AFFAIRS DEPARTMENT AND GOT NOWHERE! PLEASE ADVISE ME HOW I CAN HAVE NISSAN PAY FOR THIS!!! *TR

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND HE COULD SMELL GASOLINE COMING FROM THE VEHICLE. TWO YEARS PRIOR TO THE FAILURE, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM). THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE RECALL REPAIR WOULD NEED TO BE PERFORMED FOR THE SECOND TIME ON THE VEHICLE. THE VEHICLE WAS NOT SERVICED. THE CURRENT AND THE FAILURE MILEAGES WERE 33,000.

REAR AXLE SEALS LEAKING GEAR OIL. REPLACED BY CERTIFIED MECHANIC TWICE AND THE LEAK PERSISTS. *TR

REPEATED CRACKED EXHAUST MANIFOLDS WHICH CAN LEAK DANGEROUS AND LETHAL EXHAUST FUMES AND CARBON MONOXIDE INTO THE CABIN INTERIOR. *JS

CATALYTIC CONVERTER WENT OUT & NEEDED TO BE REPLACED IN ORDER TO PASS A SMOG! $2400 TO FIX AND THE MECHANIC SAID THERE WAS NOTHING LEFT OF THE HONEYCOMB INSIDE WHEN THERE SHOULD BE!! RECALL NEEDS TO BE ISSUED!! *TR

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE HEARD AN INDESCRIBABLE NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE INTAKE MANIFOLD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

I WAS HAVING MY VEHICLES FRONT DIFFERENTIAL FLUID CHANGED AND THE SERVICE TECHNICIAN NOTICED 2 CRACKS AROUND THE AXLE HOUSING. UPON FURTHER INSPECTION THE HOUSING WAS DAMAGED ENOUGH TO WEAR IT COULD LEAK AND CAUSE FAILURE. *TR

I HAVE A 2006 SE NISSAN TITAN TRUCK, MY CONCERN IS I JUST FOUND OUT FROM MY LOCAL DEALER THAT I HAVE A EXHAUST MANIFOLD LEAK. THE MAIN REASON FOR MY CONCERN IS... HOW THIS CAME ABOUT WAS BECAUSE I WAS AND STILL AM GETTING EXHAUST FUMES INTO DRIVER COMPARTMENT WHICH IN RETURN GIVES ME HEADACHES, AND ON TWO OCCASIONS CAUSED SERVE DIZZINESS. WHEN I EXPLAINED THIS TO THE DEALER THE SAID THERE WAS NOTHING THEY COULD DO! I HAVE TWO CHILDREN WHO I DRIVE TO SCHOOL, I DON'T NEED THEM GETTING SICK FROM THESE FUMES FROM WHICH I EXPERIENCED! I'M ASKING FOR SOME KIND OF HELP! *TR

BOTH REAR AXLE SEALS STARTED LEAKING ALL OVER MY BRAKES AND INSIDE THE WHEEL WELL CAUSING POOR BREAKING ABILITY. I CALLED THE NISSAN DEALER AND THEY TOLD ME THIS IS A COMMON PROBLEM WITH TITANS AND THAT THEY NO LONGER RECOMMEND REPLACING JUST THE SEALS BUT INSTEAD THE WHOLE AXLE. THE TECH (WHO TOLD ME HE HAD 20 YRS WITH NISSAN) SAID THAT WHEN THEY USED TO JUST REPLACE THE SEALS PEOPLE WOULD HAVE TO COME BACK 6 MONTHS LATER BECAUSE THE SEALS WOULD BLOW AGAIN. ALL OF THE POSTS ONLINE SAY THAT IT IS A RESULT OF AN IMPROPER VENTING SYSTEM THAT DOES NOT ALLOW FOR THE RELEASE OF NEGATIVE PRESSURE. IF THIS IS SUCH A COMMON PROBLEM, AND NISSAN KNOWS THAT IT IS, WHY DON'T THEY DO A FULL RECALL? THIS IS A VERY DANGEROUS PROBLEM THAT CAN CAUSE BRAKE FAILURE. *TR

LEFT REAR LEAF SPRING SHACKLE FRACTURED ON A SMOOTH ROAD, CAUSING THE LEAF SPRING TO IMPACT AND DEFORM THE BED AND DEGRADING HANDLING. *TR

REAR AXLE SEAL, DRIVER SIDE, AND SOON AFTER, THE PASSENGER SIDE AS WELL, FAILED. DIFFERENTIAL FLUID LEAKED OUT ONTO INNER WHEEL SURFACE, BRAKE PARTS, AND IMMEDIATE AREA CREATING HAZARDOUS CONDITIONS. THIS IS A WIDELY KNOWN PROBLEM FOR NISSAN TITAN OWNERS AND NISSAN IS, AND HAS BEEN, WELL AWARE OF THIS PROBLEM AND HAS NOT OFFERED A DESIGN SOLUTION TO MY KNOWLEDGE. NEARLY EVERY TITAN EXPERIENCES THIS SEAL FAILURE AT SOME POINT. SOME WHILE STILL UNDER WARRANTY, (WHICH TYPICALLY GET REPAIRED BY NISSAN) BUT AS FOR THE REST OF US WHO ARE BEYOND OUR WARRANTIES, WE ARE LEFT WITH THIS HAZARDOUS CONDITION AND A BIG REPAIR BILL. **THIS SHOULD BE A RECALL, OR AT LEAST REPAIRED BY NISSAN AT THEIR EXPENSE. ITS MY UNDERSTANDING THAT THERE WAS A TECHNICAL SERVICE BULLETIN OUTLINING THE ISSUEFOR NISSAN MECHANICS. PLEASE HELP** *TR

DRIVING AT NIGHT AND THE CABIN HEATER WOULDN'T GET WARM. DIDN'T THINK MUCH ABOUT IT AS I WAS DRIVING LESS THAN 5 MILES. THE NEXT MORNING NOTICED A LARGE POOL OF ANTIFREEZE UNDER THE TRUCK. TOPPED THE COOLANT OFF, FIRED THE TRUCK UP AND LET IT IDLE IN THE DRIVEWAY UNTIL IT CAME UP TO NORMAL TO WARM WATER TEMPERATURE AND ANTIFREEZE BEGAN DRIPPING FROM THE BOTTOM OF THE RADIATOR. RESEARCHED THE RADIATOR ISSUE AND FOUND SOME TITAN OWNERS HAVE HAD TO REPLACE CRACKED/SPLIT RADIATORS MORE THAN ONCE. TO AVOID MULTIPLE RADIATOR REPLACEMENTS I WILL BE PURCHASING A HIGH PERFORMANCE ALUMINUM RADIATOR AT A SIGNIFICANT COST DIFFERENCE. I FEEL THIS SHOULD BE A RECALL COVERED BY THE MANUFACTURER. THE PLASTIC RADIATORS MAY CUT DOWN THE VEHICLES WEIGHT, MAKING IT EASIER TO ATTAIN FEDERAL MPG STANDARDS BUT THE ALL METAL ONES JUST LAST LONGER AND ARE EASILY REPAIRED. HOW MANY TITAN RADIATORS HAVE DRAINED THEIR ANTIFREEZE INTO THE STREET AND THEN THE STORM DRAIN? MAYBE THE EPA SHOULD BE INFORMED SINCE; "ANTIFREEZE IS TOXIC TO HUMANS AND ANIMALS. WASTE ANTIFREEZE CONTAINS HEAVY METALS SUCH AS LEAD, CADMIUM, AND CHROMIUM IN HIGH ENOUGH LEVELS TO POTENTIALLY MAKE IT A REGULATED HAZARDOUS WASTE, SO MOST STATES STRICTLY REGULATE ANTIFREEZE DISPOSAL. ANTIFREEZE GENERATORS AND STATE AND LOCAL PROGRAMS SHOULD NOT DUMP SPENT ANTIFREEZE ON LAND OR DISCHARGE IT INTO A SANITARY SEWER, STORM DRAIN, DITCH, DRY WELL, OR SEPTIC SYSTEM; DUMPING ANTIFREEZE CAN CAUSE SERIOUS WATER QUALITY PROBLEMS AND MIGHT HARM PE

ON A RECALL FOR A FAULTY ECM (ENGINE CONTROL MODULE). THE VEHICLE STALLED AND WOULD NOT START AGAIN, HAD IT TOWED TO DEALER. NISSAN COVERED THIS ECM. DURING THE REPAIR THE MECHANIC NOTED THAT THE REAR AXLE SEALS WERE LEAKING AND RECOMMENDED THAT THEY BE REPAIRED AS SOON AS POSSIBLE. THE COST TO REPAIR WAS ESTIMATED AT $750.00. WHILE WEB SURFING FOR THE REPAIR PROCESS FOR THE SEALS I RAN ACROSS MANY COMPLAINTS CONCERNING THIS PROBLEM WITH THE NISSAN TITAN INCLUDING MODELS FROM 2004 TO PRESENT (2012). BASED ON THE FEEDBACK FROM OTHER TITAN OWNERS, THIS IS A COMMON FLAW WITH THE VEHICLE AND A COSTLY ONE AT THAT. ALSO THIS IS THE FIRST TIME I HAVE EVER WITNESSED REAR AXLE SEALS FAILING IN A VEHICLE. MOST SEEM TO LAST THE LIFE TIME OF THE VEHICLE. I BELIEVE THIS IS A MANUFACTURE'S RESPONSIBLITY DUE TO A DEFECTIVE PARTS CREATING AN UNSAFE AND USELESS MEANS OF TRANSPORTATION. *TT

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE REAR DIFFERENTIAL CRACKED WHILE DRIVING 55 MPH AND CAUSED DIFFERENTIAL FLUID TO LEAK FROM THE REAR DRIVER SIDE TIRE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THE SAME FAILURE BUT TO NO AVAIL. THE FAILURE MILEAGE WAS 64,000.

TRAVELING IN HEAVY MORNING TRAFFIC AND THE VEHICLE SIMPLY QUIT IN THE MIDST OF HUNDREDS OF VEHICLES. IT WOULD NOT FULLY RESTART BUT WOULD ONLY ROUGH IDLE A TIME OR TWO. VEHICLE HAD TO BE TOWED AND IT WAS DETERMINED THAT THE IPDM/ECM HAD FAILED. THE PARTS WERE REPLACED AND AS SOON AS I BEGAN LEAVE THE REPAIR FACILITY THE "SERVICE ENGINE SOON" LIGHT CAME ON. IT WAS DETERMINED THAT ONE OF THE CATALYTIC CONVERTERS HAD FAILED...DUE TO RAW FUEL BEING DUMPED INTO IT AS RESULT OF THE FAILURE OF THE IPDM/ECM. A FEW DAYS LATER, AS I WAS RESEARCHING CATALYTIC CONVERTERS ONLINE, I CAME ACROSS A NISSAN RECALL - NHTSA CAMPAIGN ID 10V517000 AND REALIZED THAT THIS WAS THE EXACT SITUATION BUT THAT I HAD NOT RECEIVED NOTICE OF SAID RECALL. I CONTACTED NISSAN REGARDING THIS SITUATION AND REIMBURSEMENT FOR THE REPAIRS AND THEY ADVISED THAT I'D HAVE TO TAKE THE VEHICLE TO ONE OF THEIR DEALERS FOR INSPECTION BEFORE THEY'D CONSIDER REIMBURSING. I DID SO AND THEY DID REIMBURSE FOR THE IPDM/ECM REPAIRS. HOWEVER, WHEN I ASKED ABOUT THE CATALYTIC CONVERTER FAILURE...WHICH WAS AN IMMEDIATE RESULT OF THE IPDM/ECM FAILURE, THE DEALER (AND NISSAN CONSUMER AFFAIRS) INDICATED THAT I'D HAVE TO GET AN ESTIMATE & "RESTART" THE PROCESS. WHILE DOING SO, I LEARNED OF NUMEROUS EXAMPLES OF THIS VERY SAME THING HAPPENING WHEN IPDM/ECM FAILS & DUMPS RAW FUEL INTO THE CATALYTIC CONVERTER. SO, I OBTAINED THE ESTIMATE FROM A NISSAN DEALER AND RECONTACTED NISSAN CONSUMER AFFAIRS AND BEGAN THE PROCESS AGAIN. IN THE MEANTIM

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) AND THE ELECTRONIC CONTROL MODULE (ECM) FAILED, CAUSING THE VEHICLE TO STALL. IN ADDITION, FUEL LEAKED INTO THE CATALYTIC CONVERTER ABNORMALLY, CAUSING THE CATALYTIC CONVERTER TO BECOME INOPERATIVE. THE DEALER INSPECTED AND REPAIRED THE INTELLIGENT POWER DISTRIBUTION MODULE, THE ELECTRONIC CONTROL MODULE AND THE CATALYTIC CONVERTER. THE MANUFACTURER ASSISTED WITH THE COST OF REPAIRS OF THE INTELLIGENT POWER DISTRIBUTION MODULE AND THE ELECTRONIC CONTROL MODULE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 96,000.

MY 2006 NISSAN TITAN HAS AN AXEL SEAL FAILURE ON THE DRIVERS SIDE REAR, DIFFERENTIAL FLUID IS LEAKING ONTO THE REAR BRAKES CAUSING REDUCED BRAKING AND ALSO THE POTENTIAL FOR AXLE/DIFFERENTIAL FAILURE. NISSAN REFUSES TO ADDRESS THIS DESIGN FLAW. THEY HAVE A RE-ENGINEERED REPLACEMENT AXLE SHAFT AND SEAL AT A COST OF ABOUT $800 PER SIDE. THIS SHOULD BE A RECALL NOT $1600 OUT OF MY POCKET TO FIX. WILL NISSAN AND NTSB WAIT UNTIL THERE ARE FATALITIES BEFORE THEY ADDRESS THIS COMMON ISSUE WITH THE NISSAN TITANS? *TR

I OWN A 4X4 LOADED 2006 TITAN LE WHICH IS MY PRIMARY FAMILY VEHICLE. AROUND 80K, ECM MODULE WENT OUT CAUSING CAR TO STALL OUT AND LOSE ALL POWER IN THE MIDDLE OF TRAFFIC (WITH MY KIDS). LUCKY NOT TO BE NAILED BY AN ON-COMING CAR, I HAD THE CAR TOWED TO THE DEALERSHIP AND MODULE WAS REPLACED DUE TO RECALL. ONE WEEK LATER WHILE VACATIONING IN THE MOUNTAINS THE BATTERY RANDOMLY FRIED, WE REPLACED IT. HOWEVER IMMEDIATELY FOLLOWING, THE ANTI-THEFT ALARM WOULD RANDOMLY SOUND OFF, THE DVD PLAYER WOULDN'T WORK (HASN'T WORKED SINCE), THE SUNROOF WAS MALFUNCTIONING AND WOULDN'T OPEN AND CLOSE PROPERLY. ONCE WE RETURNED, THE DEALERSHIP COULDN'T FIND ANYTHING WRONG (EXCEPT THE DVD PLAYER, WHICH NO ONE COULD EXPLAIN). ABOUT TWO WEEKS LATER THE CHECK ENGINE LIGHT CAME ON AND WE FOUND THAT THE FIRST CATALYTIC CONVERTER ON THE PASSENGER SIDE HAD BLOWN..FOLLOWED NOT LONG AFTER BY CRACKED EXHAUST MANIFOLDS AND THE DRIVERS SIDE CATALYTIC CONVERTER BAD..DEALERSHIP WANTS $3000 JUST FOR THE CATALYTIC CONVERTERS!!! I SHOULD NOT BE RESPONSIBLE FOR THE COST OF REPLACEMENT! THIS CLEARLY IS A MANUFACTURERS DEFECT AND NOT A ISOLATED CASE, NISSAN MUST DO SOMETHING ABOUT THIS! I HEAR RUMORS OF A CLASS ACTION...IT IS A HUGE SAFETY HAZARD!! I'M HOPING THEY DO THE RIGHT THING AND JUST FIX IT, WITHOUT HAVING TO GET LAWYERS INVOLVED. *TR

JUST REPLACED THE REAR SEALS FOR A NISSAN TITAN 2006. PROBLEM BEGAN AT 65,000 MILES. I WAS TOLD THAT LACK OF FLUID DUE TO LEAKING COULD CAUSE THE VEHICLE TO LOCK-UP WHILE DRIVING. THE INTERNET IS FILLED WITH COMPLAINTS REGARDING THIS ISSUE. THIS SEEMS TO BE A MAJOR SAFETY PROBLEM. ALSO HAD TAILPIPE ISSUES (DROPPING FROM THE TRUCK) WHICH IS ALSO WELL DOCUMENTED ON THE INTERNET AND, AGAIN, A SAFETY PROBLEM. NEEDS TO BE RECALLED. *TR

I JUST WENT INTO THE DEALERSHIP LAST THURSDAY THE 27TH OF SEPTEMBER TO HAVE A ROUTINE OIL CHANGE PERFORMED. AS PART OF THE INSPECTION THE TECHNICIAN NOTICED THAT MY REAR AXLE SEALS ON MY TRUCK WERE SEEPING/LEAKING AGAIN. THE DEALER HAD REPLACED THE REAR AXLES AND SEALS UNDER POWERTRAIN WARRANTY AT 46520 MILES ON THE ODOMETER. THE TRUCK NOW HAS A LITTLE OVER 54K MILES AND THEY ARE GOING OUT AGAIN. SO ESSENTIALLY 14 MONTHS AFTER THE DEALER REPLACED EVERYTHING IT IS OUT AGAIN. I AM GOING TO CONTACT NISSAN DIRECTLY AGAIN TO GET THIS REPAIRED EVEN THOUGH I AM OUT OF WARRANTY BY LESS THAN A MONTH. THIS IS A SERIOUS SAFETY CONCERN FOR BOTH MY FAMILY AND OTHER DRIVERS ON THE ROAD AS THESE SEALS CAN LEAK OIL ONTO THE BRAKES AND COULD CAUSE A REAR END FAILURE AT DRIVING SPEED WHICH COULD ENDANGER LIVES. THIS TRUCK HAS LOW MILES FOR A 2006 AND TOWS A LIGHT TRAILER WITH ATVS A FEW TIMES A YEAR. ALL MANUFACTURE MAINTENANCE IS PERFORMED ON TIME BY A CERTIFIED MECHANIC. *TR

2006 NISSAN TITAN ONLY 35,000 MILES AND BOTH EXHAUST MANIFOLDS CRACKED AND WERE LEAKING EXHAUST GASES THAT COULD NOT BE FED INTO CATALYTIC CONVERTERS..DEALER REPLACED UNDER EMISSIONS WARRANTY SINCE EXHAUST MANIFOLD/CATALYTIC CONVERTER ARE A SOLID 1 PIECE UNIT. THEY REPLACED WITH IDENTICAL DEFECTIVE PIECES THAT I AM POSITIVE WILL CRACK LIKE THE ORIGINAL ONES..PLEASE CHECK ONLINE TITAN FORUMS AND YOU WILL SEE IT IS A VERY COMMON PROBLEM WITH ALMOST EVERY TITAN..MY LOCAL DEALER SAYS THEY "AUTOMATICALLY CHECK EVERY TITAN" FOR THIS ISSUE..I BELIEVE THIS SHOULD BE A RECALL CAMPAIGN BECAUSE IT IS SO COMMON AND NOT FROM DRIVER ERROR/ABUSE, AND ONCE ANY TITAN IS OUT OF THE 8 YEAR/80000 MILE COVERAGE IT IS A VERY EXPENSIVE REPAIR TOTALING OVER 2,000 DOLLARS! MOST TITAN OWNERS REPORT A TICKING SOUND FROM UNDER THE HOOD ESPECIALLY UNDER COLD START UP-I DIDN'T NOTICE THIS ON MINE SO I HAD NO IDEA MINE WERE CRACKED THAT'S WHY I BELIEVE THERE SHOULD BE A RECALL TO INSPECT AS MANY TITANS AS POSSIBLE FOR THIS EMISSIONS ISSUE. *TR

THE EXHAUST MANIFOLDS ARE NOTORIOUS FOR CRACKING ON TITANS, CAUSING EXHAUST FUMES TO ENTER THE TRUCK CAB. VERY DANGEROUS, LOUD AND OBNOXIOUS. UN CONVERTED EXHAUST IS LEAKING INTO THE ATMOSPHERE SO THIS EFFECTS THE EMISSIONS LAWS. THE MANIFOLDS ARE ONE-PIECE WITH THE CATS BY THE WAY. THEY SHOULD ALL BE REPLACED DUE TO EXTREMELY POOR DESIGN AND FAILURE RATE ON MANY TITANS ON FORUMS SUCH AS TITANTALK.COM. *TR

AXLE SEALS ON REAR OF VEHICLE LEAK EXCESSIVELY. *TR

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT A TIRE DETACHED FROM THE VEHICLE AHEAD OF HIS. THE CONTACT DEPRESSED THE BRAKES BUT THE VEHICLE WOULD NOT COME TO A COMPLETE STOP AND THE CONTACT CRASHED INTO THE VEHICLE PRECEDING HIS. THE BRAKE WARNING LIGHT WAS ALSO ILLUMINATED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE MANUFACTURER AND DEALER DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,000.

REAR AXLE SEALS HAVE NOW FAILED FOR THE 3RD TIME. NISSAN DEALERS TELLS ME NISSAN WILL NOT PERMIT THEM TO REPLACE SEALS ALONE. NISSAN CORPORATE HEADQUARTERS FIX IS TO REPLACE ENTIRE AXLE ASSEMBLY AT A COST OF APPROXIMATELY $800 EACH AXLE. NISSAN IS OBVIOUSLY AWARE OF A DESIGN PROBLEM, BUT WILL NOT TAKE THE LEAD TO FIX, BUT PUT THE COST OF A DEFECTIVE DESIGN ON THE BACK OF THEIR CUSTOMERS. NISSAN SERVICE REPRESENTATIVE TOLD ME THERE IS A FLAW IN THE MATERIALS USED IN THE DIFFERENTIAL AND DIFFERENTIAL IS NOT VENTING PROPERLY THUS CAUSING THE SEALS TO PREMATURELY FAIL. I FAIL TO UNDERSTAND WHY A RECALL HAS NOT BEEN ISSUED SINCE THIS IS A COMMON PROBLEM ON NISSAN TITAN TRUCKS THAT NISSAN WILL NOT FACE. SOUNDS LIKE NISSAN IS HAVING A TOYOTA MOMENT AND BURYING THEIR HEAD IN THE SAND. *KB

AT 38,000 MILES THE DRIVE SIDE REAR AXLE SEAL ON MY 2006 NISSAN TITAN STARTED LEAKING SPREADING GREASE ALL OVER THE INSIDE OF THE WHEEL. THIS WAS NOT IN ANY WAY DUE TO NEGLECT OF THE VEHICLE, OFF ROAD 4-WHEEL DRIVE DRIVING OR VIA AUTO ACCIDENT AS I DRIVE EXCLUSIVELY ON PAVED ROADS AND THE TRUCK HAS NEVER BEEN IN AN ACCIDENT. I FEEL THIS COULD EASILY HAVE COVERED MY BRAKES WITH GREASE AND OIL AND CAUSED LONGER STOPPING DISTANCES WHICH OF COURSE COULD LEAD TO ACCIDENTS. *TR

NOTICED LOUD BANGING IN REAR OF TRUCK. FOUND THE EXHAUST TAILPIPE BROKE OFF NEAR THE MUFFLER AND WAS HANGING BY A MOUNTING POST. UPON INSPECTION AFTER REMOVAL OF THE TAILPIPE FROM THE UNDERSIDE OF TRUCK, IT LOOKED LIKE A JUNCTION OF THE TAIL PIPE TO THE MUFFLER PIPE HAD COMPLETELY RUSTED THROUGH. *TR

REAR AXLE SEAL FAILURE BOTH SIDES. CONTAMINATED BRAKES CAUSING FAILURE OF REAR BRAKES. REPLACEMENT OF SEALS AND BRAKE COMPONENTS NECESSARY FOR REPAIR. ACCIDENT AVOIDED. *TR

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES, THE BRAKE PEDAL AND STEERING WHEEL WOULD SHAKE VIOLENTLY. THE VEHICLE WOULD ALSO EXHIBIT A LOUD NOISE WITH THE ILLUMINATION OF THE BRAKE WARNING LIGHT. THE DEALER DIAGNOSED THAT THE BRAKE BOOSTER STROKE SENSOR FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER DENIED THE FAILURE AND DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 79,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 30 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE PROBLEM MIGHT HAD BEEN CAUSED BY A DEFECTIVE FUEL FILTER OR BATTERY. AS A PRECAUTION THE CONTACT REPLACED BOTH PARTS. THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO REFERRED HIM TO THE DEALER TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 136,000.

DRIVER SIDE REAR AXLE SEAL LEAKING OIL AND FAULTY AXLE BEARING AT 50K MILES. VERY COMMON FAILURE IN EARLY MILEAGE LIFE OF VEHICLE, MANY OWNER COMPLAINTS. REPLACE SEAL AN BEARING AT COST OVER $700. THE DRIVER SIDE REAR AXLE FAILURE IS MOST COMMON AND IS NOT THE DOMINANT DRIVE WHEEL. NOW THE PASSENGER SIDE AXLE SHOWING SIGNS OF LEAKAGE. VEHICLE DOES NOT TOW ANYTHING AND DOES NOT CARRY HEAVY LOADS. DEALER ADVISED NOT TO DRIVE IT ANY FURTHER OR CATASTROPHIC DAMAGE MAY OCCUR TO REAR DIFFERENTIAL ASSEMBLY ESPECIALLY AT HIGHWAY SPEEDS. REPAIRS HAVE BEEN DONE.

DRIVER SIDE REAR AXLE SEAL LEAKING OIL AND FAULTY AXLE BEARING AT 50K MILES. VERY COMMON FAILURE IN EARLY LIFE OF VEHICLE, MANY COMPLAINTS. REPLACE SEAL AN BEARING AT COST OVER $700. THE DRIVER SIDE REAR AXLE FAILURE IS MOST COMMON AND IS NOT THE DOMINANT DRIVE WHEEL. *TR

2006 NISSAN TITAN SE REAR LEFT SEAL LEAKING FIXED UNDER WARRANTY. NOW THE SAME ISSUE ON THE LEFT REAR SEAL IS LEAKING AGAIN AND ALSO THE RIGHT REAR SEAL IS STARTING TO LEAK. BASED ON ALL MY RESEARCH I HAVE DONE THIS SEEMS TO BE AN ONGOING ISSUE AND SHOULD BE CONTINUED TO BE COVERED AFTER THE WARRANTY HAS EXPIRED. WHAT ARE MY OPTIONS. MY TRUCK IS NOW AT THE DEALER AND I SHOULD NOT HAVE TO PAY FOR REPAIRS. MY TRUCK HAS ONLY 88,000 MILES. *TR

CATALYTIC CONVERTER FAILURE MANY NISSAN TITANS ARE EXPERIENCING PREMATURE CATALYTIC CONVERTER FAILURE. SOME FAILURES ARE CAUSING THE ENGINE TO SEIZE, AS PARTICLES OF THE CORE OF SUCKED UP INTO THE ENGINE. THIS HAS CAUSED FAILURES WHILE DRIVING, AND AS OF YET HAS NOT CAUSED ANY CRASHES OR FIRES. I BELIEVE IT IS AN ISSUE THAT NEEDS TO BE ADDRESSED. THERE ARE ARE LARGE NUMBER OF FAILURES BEFORE 80,000 MILES, AND A LARGE NUMBER OF FAILURES RIGHT AFTER 80,000 MILES WHICH LEAVES IT UP TO THE CONSUMER TO PAY $1700+ TO HAVE THE REPAIR DONE. NISSAN IS SAYING IT'S NOT AN ISSUE, BUT INTERNET REPORTS OF THE FAILURES WOULD SAY OTHERWISE. PLEASE LOOK INTO THIS ISSUE. THANKS *TT

THE REAR ALE BEARINGS IN MY 2006 4X4 NISSAN TITAN HAVE FAILED. NO PARTS MANUFACTURER EXCEPT NISSAN IS OFFERING THE PARTS AND ONLY AS A WHOLE DIFFERENTIAL UNIT. *TT

THE FRONT DIFFERENTIAL CARRIER BEARING HAS FAILED CAUSING SEVERE BACKLASH IN THE DRIVES SHAFT AND A FAILURE OF THE PINION. ALSO THE FRONT LEFT SEAL HAS FAILED CAUSING A LEAK TO PROGRESSIVELY GET BIGGER ALLOWING MORE AND MORE LUBRICANT TO ESCAPE.

WHILE CHECKING TIRE PRESSURE TPMS BROKE - FILED BY JIFFY LUBE. *TR

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL 2006 NISSAN TITAN *KB

BOTH EXHAUST MANIFOLDS ARE CRACKED REQUIRING REPLACEMENT. THEIR FAILURE EMITTED RAW ENGINE EXHAUST INTO THE ENGINE COMPARTMENT POTENTIALLY ENDANGERING THE LIFE/HEALTH OF THE VEHICLE OCCUPANTS DUE TO CARBON DIOXIDE EXPOSURE THROUGH CABIN AIR INLETS WHEN THE WINDOWS ARE DOWN. AT THE VERY LEAST, AIR POLLUTION IN VIOLATION OF THE EPA OCCURRED MULTIPLIED BY THE VAST NUMBER OF DOCUMENTED NISSAN EXHAUST MANIFOLD FAILURES ACROSS THE COUNTRY.

POORLY CONSTRUCTED EXHAUST MANIFOLD(S) EQUIPPED IN 2004-2007 NISSAN TITANS CRACK UNDER NORMAL DRIVING CONDITIONS. NEARLY ALL TITANS ON THE ROAD (UP UNTIL ABOUT 2008) ARE EFFECTED BY THIS MANUFACTURING DEFECT. 2008+ TITANS ARE SAID TO BE EQUIPPED WITH STRONGER MANIFOLDS, BUT THOSE CRACK AS WELL. THIS CRACK, IF NOT TAKEN CARE OF, MAY THROW ERROR CODES WHICH WILL CAUSE THE ENGINE TO LEAN OUT AND POSSIBLY DESTROY THE CATALYTIC CONVERTER. ASIDE FROM POSSIBLE ENGINE MALFUNCTION DUE TO THIS CRACK, EXHAUST GASES TO NOT PROPERLY EXHAUST OUT THE REAR OF THE VEHICLE AND SUBSEQUENTLY EXIT THE MANIFOLDS WITHIN THE ENGINE BAY AND ENTER INTO THE PASSENGER CABIN. AS THE EXHAUST MANIFOLDS ARE ATTACHED TO THE CATALYTIC CONVERTERS, THEY CAN BE REPLACED BY THE 8Y/80K MILE FEDERAL EMISSIONS WARRANTY. HOWEVER, MANY DEALERS WILL NOT LOOK AT THE MANIFOLDS TO DIAGNOSE THE ISSUE UNTIL AFTER THIS POINT. REPLACING THE MANIFOLDS USING OEM PRODUCTS IS QUITE COSTLY. *KB

TAIL PIPE RUSTED AT FLANGE NEXT TO MUFFLER AND NOTICED LIQUID LEAKING FROM AROUND THE CENTER OF MY RIGHT REAR WHEEL. I TOOK IT TO NISSAN, THEY CONFIRMED REAR SEAL LEAKAGE. SCHEDULED TO BE FIXED TOMORROW.

TL* THE CONTACT OWNS A 2006 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 TO 70 MPH, HE COULD HEAR A LOUD WHISTLING NOISE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THE CONTACT WAS ADVISED TO REPLACE THE RACK AND PINION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 34,000.

WHILE DRIVING, HEARD A BANG, DID NOT NOTICE ANY DAMAGE AT FIRST. LATER ONCE THE TRUCK WAS PARKED AT HOME SEEN THE DRIVER SIDE REAR LEAF SPRING WAS PUSHED THROUGH THE BED OF THE TRUCK. (HAVE PICTURES, IF NEEDED) THE PART PUSHED THROUGH THE METAL OF THE BED AS WELL AS THE SPRAY ON BED LINER. TOOK TRUCK TO THE LOCAL GARAGE, WAS AFRAID TO DRIVE ANY FURTHER THAN JUST A COUPLE MILES. THE MECHANIC STATED THAT HE COULD NOT BELIEVE THAT THIS HAPPENED GIVEN THE YEAR OF THE TRUCK. UPON FURTHER EXAMINATION HE RECOMMENDED THAT THE PASSENGER SIDE BE REPLACED AS WELL, BEFORE IT BROKE ALSO, HE STATED THAT IT WAS VERY THIN METAL. THE REPLACEMENT PART WAS PURCHASED AT THE A DEALER AND I WAS TOLD THAT THEY HAVE HAD NUMEROUS INCIDENTS WHERE THIS PART HAS BROKEN CAUSING SIMILAR DAMAGE. REPAIRS TO THE TRUCK WILL ALSO REQUIRE REPLACING THE TRUCK BED POSSIBLE. THIS TRUCK HAS NOT BEEN TAKEN OFF ROAD NOR HAS IT BEEN USED TO HAUL ITEMS, IT HAS A FIBERGLASS BED COVER ON IT.

I HAVE A 2006 NISSAN TITAN. I WAS ON VACATION WITH MY WIFE AND GRANDDAUGHTER THIS PAST WEEK WHEN I NOTICED THE BRAKING ON MY TRUCK FELT WRONG. IT TOOK MUCH FURTHER TO STOP THAN IT SHOULD. IT COULD HAVE CAUSED AN ACCIDENT. I PULLED OVER TO A REST AREA AND NOTICED A BURNING SMELL COMING FROM THE REAR OF THE VEHICLE. I CHECKED THE FLUIDS AND EVERYTHING LOOKED OK. I WENT TO A GARAGE TO HAVE IT LOOKED AT. THE MECHANIC SHOWED ME WHERE THE REAR AXLE SEALS WERE LEAKING DIFFERENTIAL FLUID INTO THE BRAKE DRUMS ON BOTH REAR WHEELS AND SPINNING FLUID INTO THE WHEELS. THEY TOLD ME I NEED TO GET IT OVER TO THE NISSAN DEALER TO HAVE THEM LOOK AT IT. I CALLED NISSAN AND THEY TOLD ME THIS IS A COMMON ISSUE WITH TITANS. THEY CONSIDER IT SAFE. BUT THEY TELL ME I NEED TO GET IT FIXED RIGHT AWAY. THE REAR BRAKES HAVE DIFFERENTIAL FLUID LEAKING INTO THEM. WHICH MEANS I MAY EVEN HAVE TO REPLACE THE REAR BRAKES BECAUSE THEY ARE BEING DAMAGED! THEY ALSO TOLD ME THE REAR AXLE COULD LOCK UP CAUSING MORE DANGER AND DAMAGE. THEY ADMIT THIS IS A COMMON ISSUE BUT THEY WILL NOT LET THE OWNERS KNOW IN WRITING. THAT IS PROBABLY BECAUSE THEY WOULD RATHER THE OWNER ENCURE THE HUGE EXPENSE OF REPAIRING THIS ISSUE AFTER THEIR WARRANTY HAS EXPIRED. THEY WILL NOT CONSIDER THIS A RECALL. I WILL HAVE TO SPEND $3000 TO REPLACE THE REAR AXLE. I AM FURIOUS AND DISAPOINTED THAT NISSAN WILL NOT ISSUE A RECALL ON THIS. WHILE RESEARCHING THIS ONLINE I SEE HUNDREDS OF POST.WHY IS THIS NOT BEING ADDRESSED? IT HASN'T EVEN BEEN