2016 Nissan Titan XD complaints

I was driving the truck it started knocking extremely bad and shut off while driving and will not do anything now.

Driving down [XXX] between Hulbert, Ok and Wagoner, Ok. And the crankshaft broke in two. Common issue on these trucks! But it left me stranded on a narrow two lane road! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Without warning I had a loss of power while driving followed moments later by the engine completely shutting down and failure to restart causing vehicle to stop in the middle of the road because I had no power steering or breaking. Using an OBD2 scanner I was able to recover the following code "P0087 Fuel Rail Pressure/System -Too Low Bank ". Upon trying to restart the vehicle to no avail it gave this code "P00C6 Fuel Rail Pressure Too Low - Engine Cranking Bank 1". Using an Auto Agent EZ Lynk I was able to see the fuel pump was putting out 125PSI but the Injector pump has a desired output 4.5kPSI but was only putting out 0.3kPSI and wouldn't increase pressure during cranking. After talking to my local Nissan dealership service department I was told it appeared that either the injector pump or the motor had failed. The oil and filter was change on [XXX] and fuel filters were changed on [XXX]. And has always been changed at ORR Nissan in Searcy Arkansas. If this had happened as I was going down a major highway or interstate it could have resulted in a major accident with possible injury or death due to the loss of steering. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Broken crankshaft

I was cruising on highway at 65 miles per hour when engine start making noises and stop running engine will not start again i was lucky to make it out alive as truck steering wheel was not responsive had to tow it at mechanic to find out that truck had catastrophic engine failure broken crankshaft out of the blue

Went to pull out onto main road and the truck refused to accelerate instead it started to miss and lose power then the check engine light came on and the Reduce Engine Power warning was displayed. Shortly after that the truck died and will not start. A scan of the engine codes reveled a P0087 Fuel Rail/System pressure Too Low Bank 1 code. It appears that the Bosch CP4 Fuel Injector pump failed. Right before the engine died there was loud noises coming from the drivers side of the truck which sounded like it was coming from the engine compartment.

Engine suddenly shut off while on a short run with no load and couldn’t restart. Took it to the dealership and metal shaving's in the oil pan

While driving my 2016 Nissan Titan XD Cummins (86,000 miles) on the highway, the engine started making a loud clacking noise, followed by a loud breaking or displacement sound. The check engine light did not come on, and the truck did not go into limp mode. Possible issues might be crankshaft or bearing failure, piston or connecting rod damage, or a valve train problem. The vehicle is available for inspection upon request. There were no prior warning lamps, messages, or other symptoms before this failure. The problem has not yet been inspected or confirmed by a dealer or service center.

The contact owns a 2016 Nissan Titan. The contact stated that the vehicle was idling rough while being started. While driving at 5 MPH, the vehicle shut off unintendedly. The vehicle failed to restart. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the wiring harness and engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The manufacturer offered to assist with the cost of the repair. The failure mileage was approximately 85,000.

Driving on the intersate with no warning lights engine began to run rough, pulled over and shut engine off. Trailered it to a local shop, they found lots of metal in the oil. I tried to start it to drive it on the trailer but the engine had sized due to catastrophic engine failure. It has 89900 miles.

The Crankshaft snapped in at only 66k miles.

Hi, i was driving on the free way to work hauling a small 10ft. trailer and my engine started knocking Badly! i get off free way start to head home and slowly take off and rpms take off and Boom. engine done.. so spun bearings/boken crank i havnt taken engine out to inspect yet because you cant buy a new engine and used engines are 10-12k. come to find out this engine has broken crank problems. not only could i have wrecked if it had blew on free way. but now im out of a truck that insurance wont pay. and still owe 24k to the bank.. thanks. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failure -I was driving about 45-50 mph and as I was approaching a four way intersection with a stop sign approaching in my direction of travel. As I came to a stop, the engine locked up and could not be restarted. Leaving my truck dead in the middle of the road. After having it towed to a friend's shop I removed the oil pan, only to find a alot of copper colored metal shavings all throughout. I have an obd2 scan tool with live monitoring called a BlueDriver which connects via Bluetooth to my phone and allows me to monitor different sensors and checks for any trouble codes that the truck may currently have. I had this app open and was monitoring about 6 different sensors at the time. The truck never showed any signs of anything unusual or out of the ordinary. I also never had any warnings or the check engine light come on. After joining a few Facebook groups and online fourms, and I realized this was not a very rear occurrence and that many others have experienced similar engine failures as well.

The engine crankshaft failed and broke in half while driving. I was driving on the New Jersey turnpike on cruise control with a trailer and a mower and all of a sudden the motor is making [XXX] noises and I lose engine power completely. This is a huge defective part and one of the main components of a motor that should not fail and break in half like it did. It’s a major catastrophic failure that should be resolved with a recall. The danger and risk that involves this issue is ridiculous and it should be resolved immediately. I have kept up on my services like I should the truck has been well taken care of. After research I have seen there has been alot of people with the same issue with very low miles. Even with higher miles this issue should not happen. The cost of this repair is outrageous no vehicle owner should pay that on their own specially when they still owe a lot of money on the vehicle. There were no fatalities in my incident but there could have been and it could have been bad. The manufacturer needs to take responsibility with this issue and fix it and prevent future incidents and hopefully save a life if it occurs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am the owner of a 2016 Nissan Titan xd, which has a 5.0 diesel engine. I have concerns reading about the current status of a preliminary investigation by your agency regarding the crankshaft breakdown while driving without or warning. My vehicle has 57,000 miles, and while I still have not suffered breakdown I do Have concerns on the safe driving this Titan XD. I purchased this vehicle to travel towing a travel trailer, and traveling with our grandchildren. I reading what other Titan owners have indicated, I now have concern on the safety of traveling in highways and suffering such a breakdown. I also travel on mountain roads to reach vacation sites around our area, and having no control in such conditions make me unsure of the safe travels. I worry on my $52,000 investment may be non dependable, or unsafe to use. i am requesting a your agency find a conclusion to the investigation as soon as possible, as the safety of owners, and other drivers could be in danger. I welcome updates of the progress of the investigation via email [XXX] , or mail box [XXX] . I also welcome phone contact at [XXX] . Thank you for your agency service to protect the welfare and safety of Highway, and vehicle hazards. Respectfully [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased this vehicle in 2022 with 62000 miles on it for $45000, cash first newer vehicle ever paid for in cash, 1st day i drove it, check engine light for turbo failure came on, i normally put 80-100k miles on a vehicle per year, ive owned over 200 diesel vehicles in last 25 years, never have i had one stay in the shop more than driving it. Not only does it stay in the shop, but you have to locate a shop that still has a diesel technician employed. Two turbo actuator replacements, lift pump replacement, 18 shop visits for check engine lights, 5 times in a row at buford ga nissan, drove away and light came back on before making it home. [XXX] my family and I was driving to florida , doing 55mph, No check engine lights, no noises, no warnings, motor shut down in 21 degree weather, side of [XXX] in tucker georgia for 4 hours waiting for a tow truck, only thing on screen was DEF error see dealer immediately, $550 to tow vehicle back to my house because closest dealership did NOT have a diesel tech, spent two months to find a company that would tow my truck 55 miles from gainesville georgia to roswell georgia to regal nissan, the girl called me and said it needed a starter for $900plus dollars, i laughed and said there's no way in hell a starter caused this motor to die, i informed her that if starter did Not work i was not paying, two days later she calls me back up and informs me the motor is locked up, does not know why, but pay them $178 diagnosis fee, and for $1300-$2000

Bad crankshaft reported by dealership Only 70000 miles and well kept maintenance No warning lamps prior to failure

I was traveling on the freeway at 75 miles per hour, the truck began to bog down for a few seconds then started to shake violently as if a tire was falling off, a few seconds later the engine shut off at maybe 60 miles per hour. I was unable to steer or brake properly and had very little control of where I was able to pull over. I had no power at all and the truck would not start. I was stuck on [XXX] in central Utah with drivers side tires of the truck in traffic on the right lane unable to pull over more or move the truck to a safe location. My wife and daughter were in the vehicle and I made them exit the vehicle and find a somewhat safe place to sit on the side of the freeway. It failed completely without and check engine light, the engine temperature never spiked until after it failed. The vehicle was obstructing traffic for 45 minute to an hour while I waited for a small town mechanic to come and tow it. This incident occurred the end of May 2023 and the truck is still not functioning as I cannot afford the $18-22,000 engine replacement for a broken crankshaft. The vehicle has 77,000 miles on it. It failed without any warning signs and definitely put my life, my families life, and 1000's of passing motorists at risk for an hour straight as the vehicle was incapacitated and obstructing traffic. I have read 100's of forum posts an articles concerning this same issue with zero concern from Nissan. The local dealerships claim they have never heard of this issue, but it is a

Crankshaft broke while driving

Crank shaft failure premature 113,000 miles

Was driving at highway speed when truck started to misfire and run rough. I pulled over immediately to avoid any further damage. Truck was towed to local dealership and was diagnosed as an internal engine failure related to crankshaft or bearings.

Driving down the interstate at roughly 80mph. Truck started to shake violently almost causing me to loose control of truck and an enclosed trailer. Truck then shut down. No check engine lights or warnings. I coasted to a stop to find small fire in the engine bay. Got it towed to a mechanic, he drained the oil and found the oil pan was full of metal fragments. Suspected crank failure.

Broken crank issue. This is ridiculous. The truck only has 140,000 miles on it.

My crankshaft broke on me in the middle of a major highway and nissan would not do anything tried to give me a 42000 dollar bill that I can’t pay which is a complete rip off because this is happening to a lot of people that I have talked too

While driving to work on hwy 19 in new port richey fl. Motor started shaking and knocking really bad. Towed home and parked almost two months trying to get someone who could work on it. Dealership said needs new engine that cost as much as the truck is worth. Finally found a deisel mechanic that took it apart and said crankshaft was broken. It’s still at the shop til I can afford to repair/replace motor

When worn, both rear passenger seat belt inertia reels constantly lock the seat belt into position prematurely and will not release without unfastening the seat belt.

Cam shaft and bearings failure Can not find a replacement Nissan estimate for new engine 32000

Multiple Occasions of Driving on Road and the Engine shuts off. I have had to safely coast the truck off the road, after several minutes the truck starts again and drives fine. This is occurring Regularly. I may go a week with the Truck driving fine, then all of a sudden it powers down and shuts off.

I was driving at 45mph when the truck came to a stop and mechanic diagnosed as a bad engine truck would crank but wouldnt start

While traveling home from work, at approx. 35mph my truck engine stopped working. I tried to restart it several times, with no success. I had the truck towed home, and was informed by my mobile mechanic that the crankshaft In my engine was broken. This incident placed me in danger of being hit by other vehicles, and stranded for a couple of hours. My truck only has 105330 miles on it.

While driving at 70 mph the engine stalled and bound up causing my vehicle to almost crash upon bringing it the dealership and after diagnosis they discovered the crank shaft and the bearings had exploded inside the engine causing it too cease also this dstroyed both turbos, the repairs to fix the vehicle are between 28-30k dollars and vehicle only had 88k on it and was babied and meticulous service records, nissan wanted to assume no responsibility for the failure at all and come to find out this is happening to alot of 5.0 Diesel nissan truck, there is word out there of a class action law suit and this needs to happend i could have been in a serious accident nissan is well aware of this terrible motor they put in the trucks so much they stopped production for diesel trucks, the parts are obsolete and they are not made any more so even the repairs are tough to come by they shouls atleast buy the vehicles off us or pay to get us out, many customers still had loans and the truck is no good

Engine has went out 2times in 6k miles first one made it just over 100k miles

1. The Crankshaft failed. The vehicle is available for inspection. Nissan has confirmed Crankshaft and engine to be unrepairable. 2. Event happened on a weekend late afternoon on a busy highway bridge. The titan was driving in the far left lane at 65-70 mph. Had to maneuver 2 lanes over down the bridge with no power to the engine. Safety for myself and many others on the highway bridge were put into danger as they had to maneuver out of my way while also driving around 65-70mph. Tow truck company also put in danger due to the busy nature of the highway when picking up vehicle. 3. Yes the problem cannot be reproduced because the vehicle is un-drivable. It has been confirmed by a dealer. 4. Yes the vehicle has been inspected at the local Nissan dealership. They stated the Crank shaft failed which led to the engine becoming unrepairable. 5. There were zero warning signs. I did not receive a single warning lamp, message or symptom. The vehicle experienced violent shaking followed by complete loss of power on the highway bridge, causing the engine to shut down. The titan had received all routine maintenance at the local Nissan dealership.

Loud noise and engine kept running but was unresponsive. Was traveling about 70 mph just coasted off the interstate. Was pulling my pontoon boat back to the lake during rush hour if I hadn’t been at an exit might have turned out different. Had it towed to nearest Nissan dealership and was told right away camshaft was broken and engine would have to be replaced.

CRANKSHAFT FAILURE LUCKILY MADE IT TO THE SIDE OF THE ROAD AND HAD TO HAVE IT TOWED HOME UNTIL THE DEALERSHIP COULD GET IT IN AND THEN TOWED TO THE DEALEREDHIP - EXTENDED WARRANTY WON'T PAY FOR THE NEW ENGINE CLAIMING IT IS OWNERS FAULT. NISSAN DEALERSHIP SAYING IT ISN'T OWNERS FAULT IT IS A FAILURE BECAUSE THE TRUCK HAD OIL AND LUBRICATION. SEEMS TO BE AN ISSUE ON THIS MODEL AND NO ONE WANTS TO TAKE THE BLAME. NOW OUT A TRUCK AND STILL HAVE A TRUCK PAYMENT CERTAINLY DON'T HAVE $35000 FOR A NEW ENGINE.

I HAVE A 2016 NISSAN TITAN XD PRO 4x. that had engine failure at 106k miles due to bearing and crank shaft damage. this is a non engine and was denied repair from Nissan. A engine should last longer than this. Took over 2 years for parts and $20k out of my pocket. Now the turbo has bearing issue that's been failing since day one and Nissan failed to remedy the issue. This truck was a lemon from day one. Thousand of customer have the same issue. Nissan needs to stand behind the product.

Good Afternoon, My brother was driving my Nissan Titan XD 5.0 Cummins Diesel from Naples, FL to Ft . Lauderdale FL , and the truck was running fine at around 70-80 mph with no issues .As soon as he proceeded to the exit in Lauderdale around 60mph, all of a sudden truck flashed all kinds of warning lights came on randomly and motor shut down . Smoke coming from starter and solenoid below the fuse box. He is an engineer for North Collier Fire and put out the flames immediately . I took the motor in to shop and they found the motor was seized up and burned harness near starter. I went to a few mechanic shops including Nissan and no one could give me a solid answer on what had happed with the truck , besides that it just seized up . No one would take blame. I was trying to do some research on these trucks and found numerous owners had the same problems as me. I hope no one gets hurts further from the malfunction of these vehicles . My brother was very lucky to get off off the road. Please look into these safety matters and find out who/or what companies should be held responsible. Thank you for your consideration with this matter, [XXX]

The contact owns a 2016 Nissan Titan. The contact stated that while driving approximately 45–50 MPH and hauling 2,000 additional pounds, the vehicle experienced a catastrophic failure with the turbo and the turbo became inoperable. Several unknown warning lights were illuminated. The driver was able to drive approximately 4–6 MPH to the residence. The vehicle was towed to the local dealer, where it was diagnosed and determined that the turbo needed to be replaced. The vehicle was repaired. Additionally, while receiving routine maintenance, the lift pump failed. The vehicle was repaired. The manufacturer was notified of the failure, but no additional assistance was provided. The approximate failure mileage was 73,646.

Broken crankshaft at 99,400 miles

The truck down shifted twice and then shut completely off while I was driving down the interstate. I was towed to Nissan in Springfield Missouri (closest to me) and they could not figure out the issue and charged me $500. I then towed the truck to Nissan of Jefferson city, Missouri, where I bought it. They inspected the motor and told me it was a complete loss. Metal in the oil pan from internal parts. They quoted me $39k for it to be replaced and I currently owe $30k on the truck. I only had this truck for 10 months when this failure occurred and left me and my family stranded. No check engine lights, odd noises or anything. Nissan has been reluctant to help and from what I've been reading this is a very normal occurrence for these trucks. I'm not sure what I'm going to do to get through this but I don't want it to happen to anyone else, so hopefully NHTSA can sort out this issue. Thank you.

Engine stopped smoking no power turbo out motor blown truck is junk since we bought it .

Bearings and crankshaft failure 96,000 miles always had service done. Never miss treated on the interstate when it failed ..luckily we were able to coast of the road had to wait six hours for a tow truck to pick me the wife and the kids up end up costing us $800 to get towed home 210 miles :(

Crank snapped at 93,000 miles. Nissan would not cover it and I had to repair it out of pocket. A lot of people have had this problem.

I recently had a crankshaft failure in my 2016 Nissan Titan XD with only 87,000 miles. Nissan did not honor the 5yr/100k mile warranty due to me being over the time limit. This cost me nearly $11,000 out of pocket to buy a used replacement engine. Nissan is fully aware of the defect because they have revised components in the 2018/2019 trucks. There are hundreds if not in the thousands of us Titan XD owners who have suffered this costly error with no help.

My crank shaft snapped and I’m stuck paying for a truck that I can’t pay 42 thousand dollars to fix and Nissan won’t do anything about it

Complete engine failure randomly on the highway. Was unsafe and left me stranded. Well maintained truck that will cost tens of thousands to repair

Vehicles engine crank shaft and fuel system. Was on the highway when the vehicle started loosing power and finally shut down in traffic. Confirmed that vehicles crank was seized and fuel system failure by an independent shop. Was confirmed by extended warranty. No warning lights before incident.

Ever since I purchased this truck in 2017 I've had problem after problem Turbo actuator has been replaced twice and and is out again and not at cost on Nissan refused to pay for recall after it was replaced . coolant level sensor also replaced and is out yet again and have to replace reservoir also because sensor not sold seperatly EGR is leaking and out as is engine low oil light on and mechanic is beliving engine has blown up not sure cause yet until engine removed at my cost and replaced .These issues have had me in heavy traffic several times putting truck in limp mode making it unsafe for others and my self twice with grand children on board also dealer found melted wires in box harness that they wanted to replace indicated trailer wiring malfunction also a fire risk for truck .steering pump has always been sluggish since I've owned dealer refused to address it said it was working fine yet there has been issues with similar trucks .there have been several engine codes regarding coolant .EGR codes turbo codes and low oil pressure codes with good oil quantity before engine failure .I have always changed oil on this vehicle every 4000 miles fuel filters twice a year since owned have kept vehicle in best maintenance since owned .I also would like to note dealer Billion automotive is a absolute nightmare to work with all warrantee work with myself and my son who owns same truck he has had similar problems with his truck as well EGR turbo also turbo actuator DEF system replace

While driving at highway speeds the vehicle began shaking violently. As I started to pull over, I lost all power, had difficulty steering and the brakes were barely effective. As I came to a stop, the engine locked up completely. The Nissan dealer confirmed that the engine was locked up due to either a main bearing seizure or completely broken crankshaft.

I was driving down the road at 55mph when there started to become a loud knocking noise from the engine. After about a mile message came across the dash that said reduced engine power and 2 seconds later the entire engine shut off wouldn't turn back on or crank. There were about 20 different check engine codes at the time. I had the vehicle towed to the dealer where they did an inspection the following week and said the motor blew due to a snapped crank shaft and would need an entire new engine.