2005 Mini Cooper S complaints

MY PASSENGER AIR BAG SENSOR LIGHTS GOES ON AND OFF. IT DOES NOT MATTER IF A PERSON IS IN THE SEAT. I DON'T KNOW IF THE AIR BAGS WILL WORK OR NOT. MY RESEARCH ON THE INTERNET SUGGEST THIS IS A COMMON PROBLEM WITH THE MININ PASSENGER WEIGHT SENSOR SIMILAR TO THE ONES IN BMWS. *TR

AT THE BEGINNING, THE STEERING PUMP MAKES SOME NOISES AND A FEW WEEKS LATER, MY POWER STEERING COMPLETELY WENT OUT, REALLY HEARD TO STEER ESPECIALLY AT THE LOWER SPEED AND AT THE CORNER. *TR

STEERING EFFORT INCREASED TREMENDOUSLY DURING LOW SPEED DRIVING AND AT ANY SPEED DURING TURNING. POWER STEERING APPEARS TO BE INOPERATIVE. *TR

WHEN PASSENGER EXITED VEHICLE, LIGHT AIRBAG OFF NOTIFICATION CAME ON. THIS HAPPENS EVERY TIME SOMEONE EXITS THE PASSENGER SEAT. ALSO AIRBAG WARNING LIGHT & SEATBELT NOT BUCKLED LIGHT COME ON. *TR

PULLED2005 MINI COOPER S IN GARAGE, BRAKES WORKED FINE. NEXT DAY, BACKED CAR OUT THE GARAGE AND THE BRAKE PEDAL WENT TO THE FLOOR. NO BRAKES AT ALL! NO FLUID IN THE RESERVOIR SO I REFILLED IT BUT STILL NO BRAKES AT ALL. HAD CAR FLAT BEDDED TO WALSH'S GARAGE 7 MILE RD REDFORD,MI 313-532-2823 REAR BRAKE LINES WERE TOTALLY RUSTED THRU WHERE THE BRAKE LINES ARE HELD UP TO THE FRAME. LINES WERE RUSTED THRU UNDER THE BRACKET THAT IS TACKED TO THE FRAME. I DO NOT DRIVE THE CAR IN THE WINTER AND HARDLY EVER IN THE RAIN SO I CAN JUST IMAGINE WHAT THE BRAKE LINES WOULD LIKE IF I DROVE IT IN THE WINTER IN MICHIGAN?? I CONTACTED MINI USA AND THEY DID NOT SEEM TO CARE ABOUT MY BRAKE FAILURE?? THE REP STATED: " WHAT DO U WANT MINI TO DO ABOUT IT? *TR

SRS LIGHT CAME ON...PASSENGER SEAT SENSOR ISSUE. *TR

THE AIR BAG LIGHT IS ON AND SAYS THE PASSENGER AIR BAG IS TURNED OFF. IT APPEARS THAT THERE IS A WEIGHT SENSOR IN THE SEAT AND IT IS DEFECTIVE. I HAVE RESEARCHED THIS ISSUE ON THE INTERNET AND HAVE FOUND THIS TO BE A COMMON PROBLEM. ONE OF MY CONCERNS IS THAT THERE IS CONFLICTING INFORMATION NOT THERE AS TO WEATHER THE AIR BAGS WILL WORK OR NOT IN THIS CONDITION. THE DEALER FIX COST BETWEEN 1000 AND 1200 DOLLARS TO FIX. THESE SAFETY ITEMS SHOULD LAST THE LIFE OF THE CAR AND NOT COST THIS MUCH TO REPAIR. WHY ISN'T BMW RECALLING THIS CAR AND FIXING AN OBVIOUS DEFECT? *TR

MY PROBLEM IS WITH A 2005 MINI COOPER S. WHY IS THEIR NOT A RECALL ON THE WATER PUMP? IT HAS BEEN KNOW FOR GOING OUT PREMATURE AND BMW HAS REDESIGNED THE NEW PUMPS WITH A METAL IMPELLER INSTEAD OF PREVIOUS PLASTIC. TALKING TO THE DEALER, THEY MADE ME FEEL FORTUNATE THAT MY WATER PUMP MADE IT TO 50,000 MILES STATING THEY REPLACE MANY WATER PUMPS IN THE 1ST GENERATION SERIES AROUND 20,000 MILES. I STRONGLY BELIEVE THIS IS DANGEROUS, AS THE FAILURE CAN CAUSE OVERHEATING AND REQUIRES YOU TO SHUT OFF THE CAR, AND SIT ON THE SIDE OF THE ROAD. CARS ARE NOT MADE TO OVER HEAT. THIS GREATLY INCREASES THE CHANCE OF A FIRE. BMW KNOWS THEY HAVE A PROBLEM BUT IS NOT RECALLING THE WATER PUMPS UNTIL 2006-2011. I THINK THE 1ST GENERATION MINIS SHOULD HAVE THE SAME RECALL AS MOST MINIS INCLUDING MINE HAS/HAD A WATER PUMP ISSUE AND WOULD LIKE OVER A THOUSAND DOLLARS TO HAVE IT REPLACED. I HAVE CAUGHT MINE EARLY BUT ONLY BECAUSE I JACK UP MY MINI TO CLEAN THE UNDERBODY ABOUT ONCE A MONTH. MINI COOPERS ARE WELL KNOWN FOR THEIR WATER PUMPS, THERMOSTATS, AND POWER STEERING, FAILING. I AM 18 YEARS OLD AND WOULD LIKE TO USE THIS CAR TO TRAVEL FROM SOUTH CAROLINA TO WISCONSIN IN THE FUTURE, YET IF MY COOLANT SYSTEM (WATER PUMP OR THERMOSTAT) COULD GO OUT AGAIN AT ANY TIME AND COST A FORTUNE TO REPLACE AND LEAVE ME STRANDED ON THE SIDE OF A HIGHWAY. I WILL BE TAKING A PLANE EVERY TIME I TRAVEL A FEW HUNDRED MILES AND RENT A CAR. THIS MUST BE ADDRESSED! I JUST PAID 1200 FOR MINI TO REPLACE A WATER PUMP

THE AIRBAG LIGHT THAT WARNS OF THE PASSENGER AIRBAG BEING TURNED OFF COMES ON SOMETIMES WHEN NOBODY IS IN THE SEAT AND SOMETIMES WHEN A FULL SIZED ADULT IS IN THE SEAT. *TR FROM WHAT I HAVE READ THIS MEANS THE AIRBAG SENSOR IS DEFECTIVE AND THE AIRBAG COULD EITHER FAIL TO WORK OR DEPLOY WHEN IT SHOULD NOT. I HAVE LEARNED THAT BMW ISSUED RECALLS FOR MANY OF THEIR CARS BUILT WITH THIS PARTICULAR SEAT SENSOR BUT HAVE NOT DONE SO WITH THE MINI. ARE YOU AWARE OF A RECALL FOR THE MINI? WE ARE VERY WORRIED ABOUT USING THIS CAR TO CARRY A PASSENGER BUT WE HAVE TO DO SO EVERY DAY. YOUR HELP WILL BE GREATLY APPRECIATED.

POWER STEERING PUMP MAKING NOISE WHEN CAR IS OFF, DRAINING BATTERY. EMINENT FAILURE. *TR

THE AIRBAG LIGHT IN THE CAR SHOWS THAT THE AIRBAG IS OFF WHEN THERE IS SOMEONE SITTING IN THE FRONT PASSENGER SEAT. THE LIGHT COMES ON AND THEN GOES OFF, OVER AND OVER AGAIN, WHENEVER THE SEAT IS OCCUPIED. THIS INDICATES TO ME THAT THE PERSON SITTING IN THE SEAT HAS NO RELIABLE AIRBAG PROTECTION. THIS HAS BEEN GOING ON FOR OVER THREE YEARS IN MY CAR. ORIGINAL COMPLAINT WAS ON 5/31/11. STILL NO ACTION. EMAILED MINI USA AND THEY TOLD ME THERE WERE NO RECALLS AND OFFERED NO HELP. THIS WAS DONE ABOUT ONE MONTH AGO. DO WE HAVE TO WAIT UNTIL PEOPLE START DYING BEFORE THIS SAFETY ISSUE IS FIXED BY MINI? I AM NOT THE ONLY MINI OWNER HAVING THIS PROBLEM. BMW HAS RECALLED CARS HAVING THIS SAME PROBLEM. THEY DEEMED THIS A SAFETY ISSUE. WHY SHOULDN'T MINI? CAN YOU HELP WITH THIS PROBLEM? *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A SUDDEN LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 45,000.

FAILURE TO POWERSTEERING STARTED ACTING UP IN JANUARY OF 2014 AFTER I GOT MY O2 SENOR REPLACED. WAS TOLD TO CONTINUED TO DRIVE CAR BECAUSE THE O2 SENSOR NEEDED TO RECALIBRATE ITSELF. SO NOW IN APRIL 9TH 2014, WHILE GETTING READY TO TAKE OFF FOR WORK,I COULD NOT STEER THE CAR, CALLED AAA TO HAVE CAR TOWED TO DEALERSHIP. THIS IS WHEN I WAS INFORMED IT WAS IN FACT THE POWER STEERING PUMP, AND THAT IT WOULD COST ME 1700 TO REPLACE, IM OUTRAGED. *JS

THE POWER STEERING PUMP ON MY 2005 MINI COOPER S FAILED, MAKING IT EXTREMELY DIFFICULT TO DRIVE THE CAR. A SERVICE SHOP INDICATED THIS IS A COMMON PROBLEM FOR THE MINI'S. MY IS OUT OF THE WARANTEE, HOWVERE IT ONLY HAS 45K MILES. WHEN I CALLED BMW/ MINI NORTH AMERICA TO DISCUSS A REMEDY BUT THEY TOLD ME THE VIN NUMBER FOR MY CAR WAS NOT ONE COVERED BY THE EXTENDED WARRANTY FOR THIS PROBLEM, WHILE MY CAR IS A 2005 WITH VERY LOW MILAGE THEY WILL NOT OFFER ANY ASSISTANCE WHATSOEVER TO HELP ME REPLACE THE PART AS MY CARS PRODUCTION DATE IS JUNE 2005, WHICH IS PAST THE PRODUCTION DATE FOR CARS GETTING THE EXTENDED WARANTEE ON P/S PUMPS. IT SEAMS UNSCROPLOUS TO HIDE FROM RESPONSABILITY OF FAULTY PARTS, ALSO POTENTIAL SAFTY ISSUE. WHILE MY CAR MAY BE PRODUCED A FEW MONHS AFTER THE PRODUCTION DATE FROM THE CARS THEY ARE WILLING TO WARANTEE, IT APPERARS I AM SUFFERING FROM SAME ISSUES AS THE OTHERES THEY ARE WARANTEEING. VERRY DISCURAGING BMW/MINI. *TR

MY POWER STEERING JUST TOTALLY WENT OUT IN THE MIDDLE OF A CORNER AND I CAME WITHIN INCHES OF PLOWING THROUGH ONCOMING TRAFFIC. I TOOK IT TO THE SHOP AND THEY SAID THAT THERE MIGHT BE A RECALL ON THIS SOON. POWERS STEERING WILL NOW COME ON INTERMITTENT. *TR

THE POWER STEERING PUMP STOPPED WORKING THE FIRST TIME WHEN I STOPPED TO GET A SANDWICH. WHEN I RESTARTED THE CAR TO DRIVE OFF THE STEERING WAS VERY HEAVY. I SHUT THE ENGINE OFF ONCE AGAIN SO I COULD LOOK UNDER THE HOOD TO CHECK THINGS OUT BUT EVERYTHING LOOKED FINE SO I RESTARTED THE ENGINE TO TRY TO DRIVE OFF AGAIN AND THE STEERING STILL WAS VERY HEAVY. NO POWER ASSIST. THIS HAS HAPPENED FOUR TIMES SINCE, ONE TIME WHILE I WAS DRIVING. *TR

THE POWER STEERING PUMP ON MY 2005 MINI COOPER S FAILED, MAKING IT EXTREMELY DIFFICULT TO MANEUVER THE CAR SAFELY IN TRAFFIC. I WAS ABLE TO GET THE CAR TO A SERVICE SHOP AND LATER DISCOVERED THAT THIS IS A VERY COMMON PROBLEM. I CALLED MINI, AND THEY TOLD ME THAT THE VIN NUMBER FOR MY CAR WAS NOT ONE COVERED BY THE EXTENDED WARRANTY FOR THIS PROBLEM, EVEN THOUGH MY CAR IS A MODEL YEAR 2005. THEY OFFERED NO FINANCIAL ASSISTANCE WHATSOEVER TO HELP ME REPLACE THE PART. A NEW PART WAS QUOTED AS 1300 DOLLARS, AND THAT WAS ASIDE FROM THE LABOR. FOR COST REASONS, IT LOOKS LIKE I WILL HAVE TO INSTALL A REFURBISHED PART INSTEAD, WHICH GIVES ME CONCERNS ABOUT FUTURE FAILURES. *TR

I WAS ON MY WAY BACK TO WORK FROM LUNCH IN MY 2005 MINI COOPER S AND MY POWER STEERING SUDDENLY AND WITHOUT WARNING FAILED IN THE MIDDLE OF A CURVE! I FORTUNATELY MANAGED TO REGAIN CONTROL OF THE VEHICLE AND LIMP TO THE PARKING LOT TO PULL OVER. THEN, I TURNED THE CAR OFF TO GET OUT, AND DISCOVERED MY POWER STEERING PUMP WAS STILL RUNNING EVEN WITH THE CAR COMPLETELY OFF!? I WAS AFRAID THAT THIS WOULD CAUSE A MELTDOWN OR FIRE, SO I QUICKLY CALLED A MINI DEALER TO ASK HOW TO SHUT THE PUMP OFF. I WAS TOLD THAT THE BATTERY HAD TO BE DISCONNECTED! THE BATTERY HAD TO REMAIN DISCONNECTED WHILE THE CAR WAS OFF OR THE PUMP WOULD RUN CONTINUOUSLY. I DID NOT FEEL THE CAR WAS SAFE TO DRIVE AT THIS POINT. MY POWER STEERING WAS NOW UNPREDICTABLY INTERMITTENT WHEN THE CAR WAS RUNNING. THE POWER STEERING WOULD SUDDENLY FAIL AND THEN SUDDENLY COME BACK ON, CAUSING A JERK-AND-SWERVE REACTION IN THE STEERING WHEEL FOR ME WHILE DRIVING. SO I CALLED MINI USA TO REPORT THE PROBLEM, AND I TOWED THE VEHICLE TO A MINI DEALER. THE MINI DEALER DIAGNOSED THE PROBLEM TO BE THE KNOWN POWER STEERING FAILURE COVERED BY THE EXTENDED WARRANTY ON THE POWER STEERING PUMP AND ASSOCIATED PUMP COOLING FAN FOR MODEL YEARS 2002-2005 FOR UP TO 13 YEARS/150,000 MILES. BUT MINI USA DENIED COVERAGE DESPITE MY CAR ONLY HAVING APPROX 70,000 MILES, CLAIMING THAT THEY STOPPED COVERAGE AFTER FEB 2005 BECAUSE THE NEWLY DESIGNED REPLACEMENT PARTS WERE INSTALLED AFTER FEB 2005. MY CAR WAS BUILT IN MAY 2005 AND WAS PROVEN BY TH

IN AN OFFSET FRONTAL ACCIDENT, BOTH FRONT AIRBAGS DEPLOYED EVEN WITH THE FRONT PASSENGER SEAT UNOCCUPIED. BASED UPON INFORMATION PROVIDED ABOUT THIS VEHICLE, THE PASSENGER SIDE AIR BAG SHOULD NOT HAVE DEPLOYED. THIS APPEARS TO BE A DEFECT RELATED TO THE OPERATION OF THE AIR BAG DEPLOYMENT SYSTEM. THE DRIVER OF THIS VEHICLE SUFFERED A SERIOUS SECOND DEGREE BURN APPROXIMATELY 2 INCHES IN DIAMETER TO THE INSIDE OF THE RIGHT WRIST. THE LONG SLEEVE SWEATER DRIVER WAS WEARING HAD A LARGE HOLE BURNED THRU IT IN THE LOCATION OF THE BURN TO THE WRIST. THIS BURN WAS CAUSED BY THE AIR BAG HOT GAS DISCHARGE. HANDS WERE BETWEEN THE 9 & 10 AND 2 & 3 O'CLOCK POSITIONS ON THE STEERING WHEEL. DRIVER WAS SITTING CORRECTLY POSITIONED RELATIVE TO STEERING WHEEL AND WAS PROPERLY WEARING THE SEAT BELT. *TR

THE AUTOMATIC CVT TRANSMISSION JUST DOWN SHIFTED AND NOW WON'T GO INTO HIGH GEAR. THIS WILL HAPPEN ON THE FREEWAY AND WILL SHIFT AND CLUNK INTO GEAR. BMW IS AWARE OF THE PROBLEM WITH THIS TRANSMISSION BUT WON'T STAND BEHIND THEIR PRODUCT. IT IS VERY DANGEROUS TO DRIVE. *JS

WHILE I WAS DRIVING, MY POWER STEERING SUDDENLY CUT OFF COMPLETELY. LUCKILY, I WAS CLOSE TO HOME, BUT IT WAS ALMOST IMPOSSIBLE TO PARALLEL PARK MY CAR. THE NEXT DAY, THE POWER STEERING WORKED AGAIN. *JS

AIR BAG INDICATOR CAME ON, AND THE "PASSENGER AIR BAG OFF" INDICATOR CAME ON SIMULTANEOUSLY. CALLED MINI COOPER OF PENSACOLA, FL AND THEY SAID THE CAR WAS NOT ELIGIBLE FOR REPAIR. THEY SAID THE BAG WOULD DEPLOY IF THEIR WAS AN ACCIDENT AT FULL FORCE. I BOUGHT THE CAR FOR MY GRAND DAUGHTER AND FEEL THE AIR BAGS SHOULD BE ACTIVE AND OPERABLE FOR THE LIFE OF THE VEHICLE. THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET ABOUT THIS ISSUE. I FEEL BMW IS NEGLIGENT IN NOT RECALLING THESE VEHICLES AND CORRECTING A MAJOR FLAW, AND INHERENT SAFETY ISSUE. *TR

THE AIRBAG LIGHT ON THE DASH AND ABOVE THE WINDSHIELD FOR THE PASSENGER SEAT USED TO GO ON AND OFF WITHOUT A PASSENGER IN THE SEAT. STARTING IN 2011, IT CONTINUES TO STAY ON, MEANING THE AIRBAG IS TURNED OFF. THE DEALERSHIP SAID THE AIRBAG SENSORS WERE BAD AND THE ENTIRE PASSENGER SEAT NEEDS TO BE REPLACED AT AN ESTIMATE OF $1,000. THE DEALERSHIP COULD NOT CONFIRM THAT THE AIRBAG WOULD OR WOULD NOT DEPLOY IF THE CAR FACED IMPACT AND SOMEONE WAS IN THE PASSENGER SEAT. THIS IS A SERIOUS SAFETY ISSUE AND NO FAULT OF THE CAR OWNER. PLEASE RECALL THIS PROBLEM BEFORE SOMEONE GETS INJURED OR DIES. *TR

PROBLEM OF POWER ASSIST FAILING CAUSING STEERING TO BECOME DIFFICULT. ONLY HAPPENS AFTER BEEN ON HIGHWAY FOR MORE THAN 15 MINUTES. VERY SIMILAR TO OTHER REPORTS ON 2004-2005 MINI COOPER S'S REPORTING THIS PROBLEM. *TR

MY AIR BAG LIGHT ON THE PASSENGER SIDE IS ON. MINI DEALER SAYS IT IS A BROKEN SENSOR IN THE SEAT. I CHECKED ONLINE FORUMS AND THIS IS A COMMON PROBLEM LOTS OF COMPLAINTS. MINI WILL NOT CORRECT THE PROBLEM UNLESS I PAY. IT SEEMS AS IF THIS IS A SAFETY ISSUE AND NOT AN ISOLATED CASE. I WOULD THINK BECAUSE OF THE NATURE OF THE PROBLEM THERE SHOULD BE A RECALL. *TR

TEMPORARY LOSS OF POWER STEERING. *TR

POWER STEERING PUMP FAILED WHILE DRIVING. IT IS A COMBINATION ELECTRO/HYDRAULIC PUMP. ELECTRICAL BURN SMELL WAS EVIDENT. I ALMOST GOT IN AN ACCIDENT, AND LUCKILY THERE WAS NO CAR IN THE OTHER LANE OR I WOULD HAVE HIT THEM. CANADA HAS MADE BMW MINI RECALL THESE AS IT IS A COMMON PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE TWO AIR BAG LIGHTS ILLUMINATED STATING THAT THE AIR BAGS WERE OFF DESPITE A PASSENGER BEING IN THE SEAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE PASSENGER SIDE AIR BAG MAT SENSOR WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT THEY OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 74,000.

WHILE DRIVING ON A 2 LANE 2 WAY (1 PER DIRECTION) RURAL ROAD VERY WINDY ON MY DAILY COMMUTE INTO MY OFFICE I LOST POWER STEERING. I WAS ON A STRAIGHTAWAY AND LUCKILY NOT IN A CURVE BECAUSE THE STEERING INSTANTLY BECAME TIGHT AND AT LOW SPEEDS IS ALMOST UNABLE TO STEER. I SAY ALMOST BECAUSE I I AM ABLE TO DRIVE WITH GREAT EFFORT AND ATTENTION HOWEVER ANY EVASIVE MOVEMENT FOR AN EMERGENCY MAY CAUSE ME TO BE INVOLVED IN AN ACCIDENT. I HAVE SEEN MIMI HAD A RECALL FOR THE EXACT ISSUE IN CANADA BUT HAS NOT HAD A RECALL IN THE USA WHILE WE ARE HAVING THE EXACT PROBLEMS. MINI ALSO CHANGED THE STEERING PUMP/FAN/WIRING IN THE 2006 MODELS WHICH IS THE LAST YEAR OF PRODUCTION ON THE EXACT MODEL I OWN. OBVIOUSLY THEY (MINI) IS AWARE AND TRIED TO FIX THE ISSUE ON THEIR END WITHOUT A RECALL.

PROBLEM WITH AUTOMATIC TRANSMISSION ON 2005 MINI COOPER S. NEEDS REPLACEMENT $8000+. ONLY 90K MILES. HUNDREDS OF COMPLAINTS ON LINE REGARDING CVT TRANSMISSION DEFECT. MINI COOPER/ BMW NOT ADMITTING PROBLEM TO PUBLIC. *TR

DURING THE FIRST INCIDENT I WAS DRIVING IN TOWN, SUDDENLY THE STEERING HAD A HARD RESISTANT MAKING IT DIFFICULT TO DO A RIGHT TURN. I HAD TO MUSCLE THE WHEEL IN ORDER TO KEEP FROM VEERING INTO ONCOMING TRAFFIC. WHEN I PULLED THE VEHICLE OVER TO DO AN UNDER THE HOOD INSPECTION AND CHECK THE STEERING FLUID LEVEL, I SAW NOTHING THAT INDICATE DAMAGE. ONCE I RESTART THE VEHICLE, IT SEEM TO CORRECT ITSELF. I THOUGH WAS IT WAS MAYBE A FLUKE. LATER ON, MY WIFE INDICATED SHE HEARD A WHINING NOISE THAT CAME FROM UNDER THE HOOD, AND ASK ME TO LOOK INTO IT. AFTER LOOKING IT OVER, I ADD SOME BELT DRESSING, BECAUSE I THOUGHT COULD HAVE BEEN THE PROBLEM. IN THE MEANTIME I MADE SEVERAL CALLS TO THE MINI DEALERSHIP IN TEMPE, AZ. THE SERVICE MANAGER STATED THIS NOISE COULD BE SEVERAL INDICATORS, SUCH AS AN AGING STEERING PUMP, A MIXTURE OF NON-RECOMMENDED FLUID IN THE RESERVOIR OR THE PUMP COULD BE GOING OUT. I DISMISSED THE MIX FLUID INDICATOR, BECAUSE THE LEVELS WERE ALWAYS WITHIN RANGE AND TO MY KNOWLEDGE WAS NEVER TAMPERED WITH OR TOPPED OFF. AS SEVERAL MONTHS WENT BY, THE VEHICLE CONTINUE TO OPERATE WITHOUT INCIDENT, OTHER THAN THE WHINING NOISE, WHICH WAS HEARD WHEN THE VEHICLE WAS STARTED FOR THE FIRST TIME OF THE DAY, OR WHILE THE VEHICLE WAS RUNNING IN IDLE. RECENTLY, MY WIFE CALL ME FROM WORK AND INDICATED WHILE SHE WAS DRIVING TO WORK FOR THE 2ND TIME, THE STEERING SEEM TO LOCK AND WAS DIFFICULT TO STEER. SHE MANAGE TO DRIVE HOME WITHOUT INJURY TO HERSELF OR OTHERS. THAT SAME DAY, W

I AM THE CURRENT OWNER OF A 2005 MINI COOPER S. I PURCHASED THE VEHICLE IN 2006 FROM MINI OF IRVINE WITH 3,000 MILES. I HAVE RECENTLY BEEN EXPERIENCING ISSUES WITH THE CVT TRANSMISSION. THE CAR JERKS WHEN CHANGING GEARS AT ANY SPEED, AS WELL AS WHEN SWITCHING FROM DRIVE TO REVERSE. I HAVE TAKEN THE CAR TO MINI OF SAN DIEGO TO BE DIAGNOSED AND HAVE BEEN NOTIFIED THAT THE TRANSMISSION NEEDS TO BE REPLACED AT A COST OF $8,000. THE VEHICLE CURRENTLY HAS 73,000 MILES AND FIND IT COMPLETELY UNACCEPTABLE THAT THE TRANSMISSION IS FAILING SO EARLY ON. *TR

THE POWER STEERING IN MY CAR HAS FAILED CONTINUOUSLY. WE HAD THE ENTIRE RACK REPLACED IN 2011 - THE STEERING FLUID CONSTANTLY LEAKS, OR BURNS DRY - FOR THE LAST FEW MONTHS, THE POWER STEERING PUMP DOES NOT STOP RUNNING WHEN THE VEHICLE IS PARKED - REQUIRING FOR THE BATTERY TO BE DISCONNECTED AT EVERY STOP, OR RISK A DEAD BATTERY. *TR

I MADE A LEFT TURN AT A LIGHT AND THE POWER STEERING QUIT WORKING IN THE MIDDLE OF THE TURN. THE STEERING BECAME VERY HEAVY AND I THOUGHT I HAD A FLAT TIRE. I PULLED OVER AND CHECKED THE FLUID AND THE LEVEL WAS CORRECT. I CONTINUED DRIVING AND THE STEERING WAS FINE. *TR

AROUND 2 YEARS AGO, WHILE DRIVING WITH A PASSENGER IN THE FRONT PASSENGER SEAT AND WHILE DRIVING WITHOUT A PASSENGER IN THE FRONT SEAT, THE LIGHT COMES ON INDICATING THAT THE PASSENGER AIR BAG IS OFF. THIS IS EXTREMELY CONCERNING THAT THE CAR'S PASSENGER AIRBAG MIGHT NOT BE WORKING, PARTICULARLY WITH A PASSENGER IN THE FRONT SEAT. THIS MALFUNCTION HAS BEEN REPORTED ON OTHER FORUMS TO BE LINKED TO A FAULTY SENSOR IN THE CAR SEAT, AND A NHTSA SERVICE BULLETIN (ID NUMBER: 10043927) HAS BEEN FILED. I HOPE THAT NHTSA CAN CONDUCT AN INVESTIGATION INTO WHETHER A RECALL SHOULD OCCUR, GIVEN THE SAFETY CONCERN OF POTENTIALLY NOT HAVING A PASSENGER AIRBAG GO OFF IF A PASSENGER IS IN THE FRONT SEAT AND AN ACCIDENT OCCURS. *TR

THE MINI COOPER WAS SITTING IN THE GARAGE. MY FAMILY NOTICED A DISTINCT BURNING SMELL. WE DID NOT KNOW WHERE IS WAS COMING FROM. THE BURNING SMELL WAS TRACED TO THE GARAGE, BUT STILL DID NOT IDENTIFY THE SOURCE. THE NEXT DAY WHEN THE VEHICLE WAS DRIVEN, THERE WAS NO POWER STEERING. UPON INSPECTION AND REMOVAL OF THE POWER STEERING PUMP, ALL THE ELECTRICAL CONNECTIONS TO THE UNIT WERE MELTED. THE POWER STEERING UNIT AND THE WIRING HARNESS LEADING TO THE UNIT ARE DAMAGED AND MUST BE REPLACED. IN CONCLUSION THE UNIT DREW POWER WHILE THE CAR WAS OFF AND FRIED THE ELECTRICAL CONNECTIONS. *TR

THE POWER STEERING PUMP SUDDENLY WENT OUT ON MY 2005 MINI COOPER S. FORTUNATELY FOR ME (ALTHOUGH THIS EASILY COULD HAVE BEEN TRAGICALLY UNFORTUNATE FOR SOMEONE ELSE) THIS HAPPENED IN A SCHOOL ZONE, WHICH MEANS I WAS DRIVING VERY SLOWLY. BUT WITH LITTLE CHILDREN AROUND THIS COULD HAVE BEEN EXTREMELY DANGEROUS. IN DOING SOME RESEARCH I FIND THIS SUDDEN POWER STEERING FAILURE IS A COMMON PROBLEM ON EARLY MINI COOPERS. THE PUMP HAS BEEN RECALLED IN CANADA, BUT WHY NOT IN THE U.S.A? CAN YOU TELL ME WHY THIS IS NOT A RECALL ITEM HERE? *TR

POWER STEERING FAILED AS I WAS MAKING A RIGHT HAND TURN FROM ONE STREET TO ANOTHER. WHILE 1/2 WAY INTO THE TURN THE STEERING NO LONGER RESPONDED AND STARTED TO GO STRAIGHT INTO ONCOMING OPPOSING TRAFFIC. IT TOOK QUITE A BIT OF EFFORT TO YANK THE STEERING WHEEL AND AVOID A CRASH (MUCH MORE EFFORT THAN STEERING MY 54 CHEVY PICK UP TRUCK). HAD CAR TOWED TO BMW/MINI DEALER - DIAGNOSED AS "POWER STEERING PUMP SHORTING". COST OF REPAIRS TO REPLACE POWER STEERING PUMP (INCLUDING NEW P/S HOSES): $1977.62. *TR

POWER STEERING FAILED AT FREEWAY SPEED. DRIVER NARROWLY ESCAPED ACCIDENT AT FREEWAY SPEED. POWER STEERING PUMP TOTAL FAILURE. SOMEONE WILL DIE UNLESS THIS ISSUE IS ADDRESSED. *TR

WAS DRIVING ALONG THE ROAD AND CAME UP ON A TURN WHEN THE STEERING LOCKED UP. PUT ALL OF MY WEIGHT INTO THE STEERING WHEEL TO KEEP FROM JUMPING THE MEDIAN. SCARED THE LIFE OUT OF ME. IMMEDIATELY PULLED OVER TO FIGURE OUT WHAT HAPPENED. TURNED THE CAR OFF, THEN BACK ON AND IT SEEMED FINE. THEN GETTING ON THE FREEWAY, I WAS ON THE CLOVER-LEAF AND IT LOCKED UP AGAIN SO I PUT ALL OF MY WEIGHT INTO IT AGAIN, THEN IT SUDDENLY RELEASED. WITH THE SUDDEN JERK/MOVEMENT (AND IT HAS DONE THIS A FEW TIMES) SOMEDAY I KNOW IT WILL CAUSE THE CAR TO FLIP. THE POWER STEERING SEEMS TO WORK IN PHASES: IT WILL BE FINE FOR A COUPLE DAYS, THEN ITS INTERMITTENT/GONE FOR A WEEK OR 2. THE PAST FEW DAYS, IT HAS SOUNDED LIKE THE ENGINE FAN WAS ENGAGED EVEN THOUGH I HAD NOT BEEN FOR A STRENUOUS DRIVE. I THINK IT WAS ACTUALLY THE PUMP NOT TURNING OFF WHEN THE CAR WAS TURNED OFF. THIS MORNING I GOT TO MY CAR TO FIND THE BATTERY COMPLETELY DRAINED... AN APPARENT SHORT IN THE POWER STEERING PUMP (AND/OR FAN) KILLED IT. *TR

WHILE DRIVING MY MINI COOPER S '05, I SUDDENLY LOST POWER STEERING, WHICH MADE IT EXTREMELY DIFFICULT TO STEER. I FEEL THREATENED DRIVING MY CAR. *TR

PASSENGER AIRBAG OFF WARNING LIGHT ON. DEALER WANTS $1800 TO FIX DEFECTIVE SYSTEM. *TR

DRIVING TO WORK IN THE AM. I SMELL SOMETHING IN THE CAR. WHEN I LOOK AT MY PASSENGER SIDE SEAT I SAW SMOKE. PULL OVER AND GOT A BETTER LOOK AT IT. I HAVE A HOLES IN MY CAR SEAT AND THE TWO VEST THAT I PLACE ON THE SEAT. IT APPEARS THE HEATED SEAT HAD A ELECTRICAL FAILURE. TOOK CAR TO MINI DEALER. THEY SAID IT REAL ODD THIS HAPPEN. THEY ALSO NICE TO SAY I WOULD HAVE TO PAID TO FIX IT. LOOK AT MANY SITE ON INTERNET AND SEEN BMW/MINI AND OTHER COMPANY HAVE ISSUES WITH HEATED SEATS. IT DO NOT SEEM TO ODD TO ME. I DID NOT EVEN HAD THE HEATED SEAT ON BECAUSE NO ONE WAS SEATING THERE. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT WHILE ATTEMPTING TO TURN, THE STEERING WHEEL FAILED TO RESPOND. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WERE IT WAS FOUND THAT THE POWER STEERING PUMP FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 59,895. UPDATED 1/29/13 *CN UPDATED 2/7/2013 *JS

PASSENGER AIRBAG, FRONT SEAT, SENSOR HAS A FAULT OR SHORT IN IT. INTERMITTENTLY, WHILE ADULT PASSENGER IS IN SEAT, THE WARNING LIGHT TURNS ON, AND PASSENGER AIRBAG "OFF" WARNING LIGHT COMES ON--THUS SHUTTING OFF THE PASSENGER AIRBAG. THIS A KNOWN ISSUE WITH THE 2005 AND 2006 MINI COOPERS AND A SERIOUS SAFETY ISSUE. IN THIS PAST MONTH THE FREQUENCY HAS INCREASED TO APPROXIMATELY 99% WHERE THE PASSENGER HAS NO SAFETY PROTECTION AS AIR BAG IS SHUT OFF. TO DATE MINI IS NOT WARRANTYING THIS DEFECT AND IT IS A VERY EXPENSIVE REPAIR. I THINK A SAFETY RECALL SHOULD BE ISSUED ASAP. *TR

AIRBAG LIGHT ON CENTER DISPLAY AS WELL AS YELLOW AIRBAG OFF LIGHT ON OVERHEAD CONSOLE INTERMITTENTLY APPEAR AND DISAPPEAR FOR NO APPARENT REASON. MINI WANT OVER $1500 TO REPLACE A SEAT BOTTOM PAD SENSOR. *TR

STARTED VEHICLE IN THE MORNING OF 11/14/2012. THE SHIFT INDICATOR ON THE DASH SHOWS EP MODE INSTEAD OF D,R,N,ETC. THE CAR SEEMED TO DRIVE FINE BUT THERE'S SOMETHING WRONG WITH THE SHIFTER ELECTRONICS. THE CAR DOES NOT SEEM TO KNOW WHAT DRIVE MODE IS IN. PUTTING THE AUTO MANUAL TRANSMISSION INTO SPORTS MODE DOES NOT CHANGE THE SHIFT INDICATOR ON THE DASH. IN SPORTS MODES IT STILL SHOWED EP. IN EP MODE THE CAR DOES NOT REV BEYOND 3000RPM AND DRIVES ROUGH AT CERTAIN SPEEDS. THIS MAY BE A MANUFACTURER DEFECT WITH A TRANSMISSION SENSOR, OR THE SHIFTER ELECTRONICS. *TR

PASSENGER SIDE "AIR BAG" OFF LIGHT IS ON ALL OF THE TIME AND THUS, THE PASSENGER AIR BAG WILL NOT BE DEPLOYED IN AN COLLISION. HAVE HAD SENSOR WORKED ON, SYSTEM FLASHED BY BMW, ETC TO RESOLVE ISSUE. BMW UNABLE TO RESOLVE WITHOUT EXTENSIVE COST. *TR

THE POWER STEERING WENT OUT AND WAS VIRTUALLY IMPOSSIBLE TO STEER. *TR

I WAS DRIVING DOWN THE FREEWAY ATTEMPTING TO CHANGE LANES WHEN I NOTICED THAT MY STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN AND MANEUVER, AS IF THE POWER STEERING FEATURE HAD BEEN DISABLED. INITIALLY, I THOUGHT IT WAS JUST THE SURFACE OF THE ROAD MAKING HANDLING OF THE CAR DIFFICULT, BUT THE PROBLEM CONTINUED TO PERSIST EVEN AFTER I EXITED THE FREEWAY. WHILE PERFORMING LEFT-TURNS AND RIGHT-TURNS ON THE SIDE STREETS, I HAD TO EXERT TREMENDOUS LABOR TO COMPLETE THE TURN, AND ON A COUPLE OF OCCASIONS I ALMOST HIT ADJACENT CARS ON THE ROAD BECAUSE I COULDN'T FORCIBLY TURN THE STEERING WHEEL ENOUGH. WHEN I ARRIVED AT MY DESTINATION, I TURNED OFF MY ENGINE, RE-STARTED IT, AND TO MY RELIEF AND AMAZEMENT, THE STEERING WHEEL BECAME EASY TO MANEUVER AGAIN, WITHOUT A TRACE OF THE STEERING PROBLEMS THAT HAD JUST OCCURRED. *TR