1999 Mazda B-Series Truck complaints

TIRE TREAD SEPARATION. *AK( DOT NUMBER: W2UU IPO TIRE SIZE: P22570R15 )

SPARE TIRE IS THE WRONG SIZE TIRE FOR THIS VEHICLE, ITS DIAMETER IS 2 INCHES SMALLER. WHICH CAUSE WHEN USING THE SPARE TIRE, ABS BRAKING SYSTEM WILL NOT WORK. PLEASE PROVIDE FURTHER INFORMATION.

THIS TRUCK IS MANUFACTURED BY FORD, IT IS IDENTICAL TO THE FORD RANGER WITH THE EXCEPTION OF A FEW EXTERIOR BODY PANELS. THIS TRUCK HAS A MECHANICAL FLAW IN THE DRIVE LINE THAT FEELS AS IF THE TRANSMISSION BOUNCES OR "THUMPS UP AND DOWN" WHEN MODERATELY ACCELERATING FROM A STAND STILL. MY SERVICE CENTER HAS ATTEMPTED 4 REPAIRS AS PER MAZDA SERVICE BULLETINS, ALL HAVE FAILED. EACH TIME I CONTACT MY SERVICE CENTER REGARDING A REPAIR SOLUTION I AM TOLD THE SAME THING" MAZDA IS WORKING ON A FIX". I HAVE CONTACTED MAZDA CUSTOMER SERVICE NUMEROUS TIMES AND GAINED NO INFORMATION. I HAVE BEEN RESEARCHING THE CHARACTERISTICS OF THIS DEFECT. IN A VERY SHORT PERIOD OF TIME I HAVE LOCATED OTHER FORD RANGER OWNERS WITH THE SAME PROBLEM, SOME MODELS DATING BACK TO 1994. WHEN THEY TURNED TO FORD FOR A REPAIR, THEY TOO WERE PUT ASIDE. WHAT ALARMS ME IS NHTSA HAS MANY BULLETINS WHERE FORD ACKNOWLEDGES MY SAME COMPLAINT, SOME BULLETINS DATING BACK TO 1997 MODEL YEAR. I FIRMLY BELIEVE THAT FORD HAS SOLD 100'S TO 1000'S OF RANGER AND RANGER EQUIVALENTS WITH THIS DESIGN DEFECT AS FIRST QUALITY, WHILE KNOWING THEY ARE NOT. TODAY, SEPT. 18,2000 A MAZDA REPRESENTATIVE HAS CONTACTED ME FOR THE FIRST TIME SINCE THIS PROBLEM BEGAN. HE SAID THEY DO NOT KNOW HOW TO FIX IT. I NEED HELP IN DIRECTING FORD TO AKNOWLEDGE THIS PROBLEM AND RELEASE A FIX. I HAVE TOLERATED THIS DEFECTIVE VEHICLE FOR 25000 MILES AND I AM APPROACHING THE END OF MY WARRANTY. ANOTHER CONCERN OF MINE IS WHAT LONG TERM EFFECT THIS WILL

PE00-020; AFTER INSPECTING TIRES HAD FOUND OUT OF TREAD SEPARATION. MAZDA, B2500, 1999, FIRESTONE WILDERNESS HT, P225/70R15, DOT W2QU1TO78. *AK THE CUSTOMER REPLACED THE TIRES AND DECLINED THE $60 THAT THE FIRESTONE DEALER OFFERED FOR THE TWO FAILED TIRES. *YH

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

ENGINE DEVELOPED ROUGH IDLE AT APPROX. 12000 MILES. DEALER SAYS FUEL PROBLEMS, HOWEVER I HAVE TRIED SEVERAL GAS STATIONS AND THE PROBLEM CONTINUES. ENGINE EXPERIENCES SLIGHT HESITATION ON TAKE OFF FROM STOP. ALSO ENGINE HAS STALLED WHEN TRUCK IS IN DRIVE POSSIBLY DUE TO SLOW AND ROUGH IDLE. HAVE ALSO EXPERIENCED SURGING UPON VIGOROUS ACCELERATION.

TIRE SHOWS SIGNS OF TREAD SEPERATION. FIRESTONE HAS NO REPLACEMENT AT THIS TIME.( DOT NUMBER: 25377UR TIRE SIZE: 235/75/R15 )

HAD NOT EXPERIENCED ANY PROBLEM WITH FIRESTONE WILDERNESS AT TIRES, SIZE 245/75R16, WHERE CONSUMER BELIEVED THAT THERE SHOULD HAVE BEEN A RECALL. *AK FIRESTONE IS NOT RESPONSIVE TO EMAIL AND TELEPHONE INQUIRIES. THE CUSTMER FEELS THAT FIRESTONE AT EAST GIVE PRO-RATA CREDIT FOR BUYING ANOTHER MODEL. *YH

VEHICLE SUSTAINED EXTENSIVE FRONTAL DAMAGE AT A IMPACT ESTIMATED AT 30-40MPH THAT RESULTED IN STATE FARM INSURANCE DEEMING THE VEHICLE A TOTAL LOSS. MY SON WAS THE DRIVER OF THE VEHICLE AND HE RECEIVED A BROKEN NOSE AND IS GOING TO REQUIRE SURGERY AND IS HAVING HEADACHES . NEITHER OF THE AIRBAGS: DRIVER OR PASSENGER DID DEPLOY!!! IF ANY FUTHER INFORMATION REGARDING THIS IS NEEDED AS TO CURRENT LOCATION OF VEHICLE ETC. PLEASE FEEL FREE TO CONTACT ME AT ANYTIME. WHEN I CALLED MAZDA CORPORATION BY PHONE I WAS BASICALLY TOLD THAT "THEY DO NOT LOOK INTO THINGS LIKE THIS". I AM CONVIENCED IF THE AIRBAGS WOULD HAVE OPERATED PROPERLY MY SON 'S INJURIES WOULD HAVE BEEN MUCH LESS AND MAY NOT HAVE RECEIVED ANY INJURY AT ALL. ANY HELP IN THIS MATTER WOULD BE GREATLY APPRECIATED.*AK

VEHICLE WAS IN PARKED IN FRONT OF THE HARDWARE STORE WITH CONSUMER'S FOOT ON BRAKE, AND VEHICLE STILL ON. TOOK FOOT OFF BRAKE, AND VEHICLE LUNGED FORWARD, HIT THE CURB, WENT UP ON THE SIDEWALK, AND STRAIGHT INTO THE STORE. *AK

WINDSHIELD WIPERS COME ON SPONTANEOUSLY WHILE DRIVING AT ALL SPEEDS (MPH); ALSO STEERING WHEEL LOCKED UP AFTER WINDSHIELD WIPERS EON AT SPEED OF 65MPH PULLING CAR TO RIGHT RESULTING IN CRASH. THE AIRBAGS ON THE DRIVER SIDE AND THE PASSENGER SIDE FAILED TO DEPLOY.*AK

WIND TUNNEL AFFECTS DRIVING AND RAIN IS COMING THROUGH DRIVER'S DOOR. TRUCK HAD BEEN PREVIOUSLY DAMAGED AND REPAIRED, UNKNOWN TO THE OWNER--FENDER AND DOOR ARE OUT OF ALIGNMENT, AND THERE IS A GAP BETWEEN DRIVER DOOR AND BODY, ALLOWING RAIN AND WIND TO COME IN. HOOD HAS ALSO BEEN REFINISHED. DEALER HAS NOT BEEN ABLE TO CORRECT PROBLEM, STILL EXISTS. *AK *ML

FUEL SYSTEM SHUT DOWN WHILE DRIVING ON HIGHWAY. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

WINDOW HAS POOR VISIBILITY AT NIGHT, ESPECIALLY WHEN CONSUMER IS BACKING OUT. DIFFICULT TO SEE THROUGH THE TINTED WINDOWS AT NIGHT. *AK *ML

REPORTED TO MAZDA, THEY STATE THAT THEY WILL DO NOTHING UNLESS INSURANCE COMPANY REPORTS IT TO THEM. FARM BUREAU INSURANCE HAS DOCUMENTED FAILURE BUT WILL NOT REPORT TO MAZDA. HAVE PICTURES AND DOCUMENTS AVAILABLE. NO SAFETY DEFECT LISTED IN SUMMARY. *AK

I WAS MAKING A LEFT HAND TURN INTO A PARKING LOT, SLID ON SOME GRAVEL AND STRUCK THE RIGHT FRONT RIM OF MY TRUCK ON THE CURB. THE AIRBAGS DEPLOYED, WARPED THE STEERING WHEEL, DESTROYED THE HORN AND CAUSED OVER $2500 DOLLARS OF DAMAGE TO MY VEHICLE. NO BODY DAMAGE OCCURRED TO THE VEHICLE. MY QUESTION IS, IS THIS NORMAL. *AK

RIGHT FRONT DOOR DIFFICULT TO OPEN-IT STICKS FREQUENTLY, AND THEN RELUCTANTLY OPENS. I NOTIFIED DEALER DURING PREPURCHASE FOR REPAIR- AT TIME OF SALE WAS TOLD THEY LUDRICATED IT AND THAT IT WOULD GET BETTER AS THE VEHICLE BROKE-IN. THE PROBLEM INITIALLY DID GET BETTER, BUT NOW IT'S WORSE THAN BEFORE.

CONSUMER RECEIVED A RECALL LETTER . ORIGINALLY ANOTHER DEALER SOLD THE BUSINESS TO PRESENT DEALER. CONSUMER CALLED DEALER, AND HE SAID PARTS WERE NOT IN, AND TO CALL BACK IN A FEW MONTHS. CONSUMER CALEED BACK ON 15TH OF NOV 1999, DEALER SAID THEY WOULD PUT IN ORDER. DEALER NOW IS TELLING CONSUMER THAT THEY NEED A SPECIFIC VIN #. CONSUMER FEELS DEALER SHOULD HAVE SAID THIS FROM THE BEGINNING. CONSUMER HAS NOT BEEN ABLE TO USE CRUISE CONTROL SINCE JULY BECAUSE THE RECALL LETTER SAID IT MAY STICK . *AK

#1 AT APPROXIMATELY 1000 MILES THE DIFERENTIAL PINION GEARS WERE REPLACED DUE TO A GRINDING NOISE FROM THE REAR END, #2 AT 9,500 MILES I TOOK THE TRUCK BACK TO THE DEALER AND COMPLAINED OF NOISES IN THE REAR END AND FRONT END VIBRATION. THEY DISREGARDED THE NOISES IN THE REAR END AND REPLACED THE TWO FRONT TIRES. SINCE THEN THERE HAVE BEEN SEVERAL ATTEMPTS BY MAZDA TO BALANCE THE FRONT TIRES, I STILL HAVE THE VIBRATION IN THE FRONT DURING NORMAL DRIVING. 18 OCTOBER 1999 WITH APPROXIMATELY 12,000 MILES ON THE VEHICLE, I TOOOK IT BACK, THIS TIME THERE IS A VERY DISTINCTIVE NOISE FROM THE REAR END AND FRONT END VIBRATION. MAZDA ORDERED A COMPLETE REAR AXLE ASSY AND ONCE AGAIN BALANCED THE FRONT TIRES. I WAS TOLD BY SERVICE MANAGER THAT THE TRUCK IS SAFE TO DRIVE. NOTE: THE REAR AXLE ASSEMBLY WILL MOVE ABOUR ONE INCH FROM SIDE TO SIDE WHEN I SHAKE THE REAR TIRES. I BELEIVE THE FRONT END PROBLEMS ARE BEING CAUSED BY THE REAR AXLE ASSEMBLY FLOATING WHEN THE VEHICLE IS DRIVEN.( DOT NUMBER: W2UU TIRE SIZE: P225/70R15 )

WINDSHIELD WIPERS ARE WORKING INTERMITTENTLY. *AK

NO SUMMARY

WHEN DRIVING OVER 40 MPH ON ROUGH ROAD PAVEMENT THE REAR WHEEL BOUNCES OFF THE ROAD, FORCING DRIVER TO CHANGE LANES TO CONTROL THE TRUCK. ALSO UNDER HEAVY BRAKING THE BACK END OF THE TRUCK SPINS AROUND. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

ALTHOUGH THERE WAS A REPAIR MADE FOR THIS PROBLEM, IT IS STILL NOT FIXED AS OF 8/23/1999. AN ADDITIONAL TSB WAS INSTALLED BUT STILL NO DIFFERENCE. THE BEAT GOES ON.

EMERGENCY PARKING BRAKE LOCKED UP, CAUSING VEHICLE TO LOSE CONTROL. PLEASE PROVIDE FURTHER INFORMATION. *AK

POSSIBLE ELECTRICAL SYSTEM FAILURE CAUSED THE STARTER TO RUN REGARDLESS OF THE KEY POSITION (SHUT OFF AFTER 5-7 MINUTES) VEHICLE WOULD NOT START AND TOWING WAS NECESARY, AC COMPRESSOR WILL NOT SHUT OFF REGARDLESS OF CONTROL SETTINGS. NLM

THE RIGHT FRONT DOOR ON THIS TRUCK DOES NOT SOUND TIGHT WHEN IT IS CLOSED. (I ORIGINALLY REPORTED LEST, WRONG DOOR.) THE DOOR DOES NOT SOUND "SOUND" WHEN IT IS SHUT. THE SOUND IS A TINNY SOUND, ALMOST AS IF INSULATION HADE BEEN LEFT OUT OR WHATEVER PRODUCT IS USED BETWEEN THE DOORS....

CONSUMER WAS IN A FRONT END ANGLED ACCIDENT AT 45MPH, HIT THE REAR PASSENGER'S SIDE OF THE OTHER VEHICLE, AND DRIVER'S OR PASSENGER'S AIR BAGS DID NOT DEPLOY. DEALER NAS BEEN CONTACTED. *AK