2020 Kia Telluride complaints

Oil consumption, I use full synthetic restore and protect . I change oil every 3500 miles .. after every 500 I have to check it and it’s been low have to add 2-3 quarts . Today started acting sluggish checked oil and my oil was low yet again low this is ridiculous. I’ll never own another kia telluride

My 2020 Telluride started burning excessive oil at 65,000 miles. When the car runs out of oil, it stalls electrical systems such as the ABS and power steering. My car has run out of oil, including during dealer initiated oil consumption tests, 4 times. One of these times I was stopped on a hill. I rolled into traffic, unable to brake or steer! Kia will not admit to this defect in their engines in spite of the thousands of people who have had issues. The Telluride has the same engine as the Hyundai Palisade. Hyundai produced a service bulletin related to oil consumption issues with this engine. Kia has not. My personal car, most recently, burned through 7 quarts of oil in 2,800 miles!

Failed windshield Available for inspection Unexpectedly Cracked across full length of windshield Blocking view of road causes glare There is a 2020 model class action suit and many complaints

My 2020 Kia Telluride has undergone three separate oil consumption tests through an authorized Kia dealership. Each test confirmed abnormal oil consumption, yet Kia declined to take corrective action beyond temporary monitoring. The issue has continued to worsen. The engine is now burning oil on the piston, and I am required to check my oil level daily and add oil weekly, even after a fresh oil change. This is not routine maintenance — it is a direct result of a defective engine design that is unable to properly retain or burn oil within acceptable limits. Because the oil burns so quickly, the oil light can appear unexpectedly while driving, creating a dangerous situation if the oil level drops too low. This poses a serious risk of engine seizure or power loss, which could lead to a crash or leave the driver stranded on the road. Manufacturer Response: Kia has acknowledged that the vehicle has a confirmed oil consumption issue but has refused to replace the engine because it is outside of warranty coverage. Instead, the dealership advised me to trade in the vehicle and purchase a new Kia, which is not an acceptable solution. When I questioned this suggestion, I was told that Kia could not guarantee the new vehicle would be free of oil consumption problems because the issue is related to the engine design itself. In other words, Kia is aware of a recurring engine defect but is not providing a remedy for affected vehicles. This is a manufacturer defect that should not be dismis

White paint is chipping on car

Excessive oil consumption causing monthly oil changes. No low oil indicator causing engine to rattle.

The engine is consuming oil

Oil Pan and gasket leak Oil Control Valve Harness leak The car leaked 5 quarts of oil without any engine or low oil light being illuminated to communicate this engine problem. The dealership identified the above components failed and caused the oil to leak and lead to potential engine damage

The paint on our white Kia started to peel on the roof and then the hood down to metal. The paint has continued to bubble and peel especially after long drives

High oil consumption

I am consuming excessive oil consumption and the oil consumption tests have failed twice. This usually leads to driving and hearing noises and the car shaking which could lock up the engine and or cause a safety concern if locks up while driving and sudden stop.

Sunroof wind deflector broke causing the track for sunroof to be off and sunroof won't close. This is a safety concern for the stability of the sunroof and apparently it is a common problem. Yes the problem was confirmed by the dealer.

AWD Coupler locking and wobbling jerks vehicle

The vehicle began burning oil around 61,000 miles, shortly after the 5-year/60,000-mile powertrain warranty period ended. The issue was confirmed by an independent mechanic, who identified leaking lower engine seals and excessive oil consumption. The mechanic advised that the engine will likely need replacement due to internal seal failure. This condition presents a potential safety risk if oil levels drop unexpectedly, leading to engine seizure or loss of power while driving. There were no dashboard warning lights or messages prior to discovering the problem; the only symptom was an oil smell and the dipstick reading consistently below normal levels between changes. The problem has been confirmed by an independent mechanic. The vehicle has been regularly maintained according to the manufacturer’s service schedule. The manufacturer has declined to offer assistance, citing warranty expiration and second-owner status, despite the failure occurring only 1,000 miles past coverage and appearing consistent with a latent manufacturing defect. The vehicle and documentation remain available for inspection upon request.

For a while now i have had to add extra oil about a quart every so often (didnt chart mileage )between oil changes and I thought its just burning some oil. Last few months it went up to adding 2 quarts and recently I had to add 3 quarts of oil and I had just checked it 2 weeks ago. There is never a light or any kind of notice on dash panel about low oil. I have a epiletic daughter that requires a safe vehicle to get her to the hospital. So this is a real safety concern. I have been reading this is problem with Tellurides. Because of the oil consumption problem tellurides have been stalling while driving. This could be a life threatening situation with my daughter not to mention for anyone driving the vehicle. The dealer will not do an oil consumption test since I'm at 113,000 miles. I paid $40,000.00 for a quailty vehicle. It should not have these kind of problems. KIA manufacurer said call the local dealer, so its just a run around Please help us figure this out.

My sunroof will not close all the way. I have read different threads and it seems I am not the only person with this make and model having the issue.

The contact owns a 2020 Kia Telluride. The contact stated that the sunroof failed to close after being opened. The vehicle was taken to the dealer, who diagnosed that the cables for the sunroof had fractured and needed to be replaced. The vehicle was not repaired. The dealer secured the sunroof using duct tape as a temporary fix. The contact found information on Technical Service Bulletin, NHTSA ID: 10239743 (Visibility, Structure), which was related to the failure. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 45,000.

Subject: Ongoing Issue with Excessive Oil Consumption – 2020 Kia S V6 To Whom It May Concern, I am writing to formally express my concern and frustration regarding a recurring issue with my 2020 Kia S V6 related to excessive oil consumption. Despite multiple visits to the dealership and attempted repairs, the issue remains unresolved and continues to affect the safety and reliability of my vehicle. Vehicle Information: Year: 2020 Make: Kia Model: S V6 VIN: [XXX] Current Mileage: Approximately 85,808 miles Timeline of Events: September 6, 2024 – Oil change completed at Kia dealership in Easton. No prior issues reported at this time. [XXX] – After about a week of shaking and stuttering during acceleration, the vehicle shut off completely at a stoplight. Upon checking, the oil level was found to be empty. I added 6–7 quarts of oil. No oil warning light appeared on the dashboard at any time. January 14, 2025 – Brought the vehicle to the Easton Kia dealership. Diagnosed with a broken and leaking oil filter housing, which was replaced. Another oil change was completed. [XXX] – After the engine light came on, I checked the oil at 77,021 miles and found it to be low again. I added 1 quart of oil. The engine light was later determined to be due to a loose gas cap. Once again, no oil warning light appeared. [XXX] – At 78,000 miles, I checked the oil, as advised by Kia, to monitor consumption. The oil level was completely empty. I added another 6–7 quarts of oil. No warning light appear

Oil consumption, consuming too much oil , need it recalled please it’s too much already

Oil consumption- I have had to keep oil in the car to top off my oil in between oil changes. It will get low before I can make to another appointment and start shaking or making a loud noise when driving or braking. Oil consumption test says I’m burning 2 qt /1000 miles. Checking online and different forums this is a know issue for these models of vehicles

Kia replaced oil filter adapter and now it burns through excessive amounts of oil. 3qts over 1000 miles. KIA wanted to do an oil consumption test but by the end it would have been out of warranty. Engine replacement would then not be covered.

Vehicle engine is using 1-2 quarts of oil every month or so. Vehicle only has 85k miles. Engine also has a rattle/tick when accelerating. I believe this is due to the excessive oil usage.

Oil consumption- I have had to keep oil in the car to top off my oil in between oil changes. It will get low before I can make to another appointment and start shaking or making a loud noise when driving or braking. Oil consumption test says I’m burning 2 qt /1000 miles. Checking online and different forums this is a know issue for these models of vehicles

My 2020 Kia Telluride consumes oil.at an alarming rate. About 2 quarts for every 1000 - 1500 miles. It currently has 125,000 miles.

High oil consumption. Oil needs added frequently or it gets low and car doesn’t run correctly. Transmission slips daily at low speed first thing in the morning. When making slow turns tires tires don’t seem to remain steady/grip. The car is hoppy like there is a traction problem. Tires have been replaced and issue remains.

Engine burns over a quart of oil every week. Kia states it's normal.

Right at 100k miles both our engine began burning oil at an extremely high rate with no clear resolution for the issue. We are adding 1-2 quarts ever week. Simultaneously, we received transmission solenoid codes from a check engine light. The sealed factory transmission had burn looking transmission fluid and after replacement the light continue to show and now the transmission is slipping and hesitating and we are being told it needs replaced.

This car is burning oil at an outrageous amount. 2 to 3 quarts in 1000 miles. This is a hazard to drive myself and my two young children in

My 2020 Kia Telluride, the oil housing unit started leaking earlier this year and was replaced it was low on oil. The oil light never came on.after that it started consuming oil. It consumes a quart of oil about every 100 to 200 miles. I’ve spoken to Kia about this and they said it’s common. They can do a consumption test, and if it fails, it’ll need a new engine but kIA will not replace it because the car is out of warranty. This has been an ongoing issue since the oil housing unit started leaking, which is also a common problem.

Oven taken my car to jiffy line for more than regular oil changes and they always end up kinda jokingly saying man he’s always low on oil. I just blew a rod thru my block due to lack of oil and how fast it was burning. I feel so cheated out of my money. I’m stuck with a vehicle that I cannot drive and Kia refuses to replace it.

Windshield cracked from minor item being thrown up by car in front of me. Engine burns out no oil on dipstick with regular maintenance engine tick transmission slips axle boot ripped oil pan cracked due to it being faulty

My vehicle has an oil consumption problem that the dealership and every other Kia dealership knows about. They are Facebook groups about the Kia Telluride oil consumption problems. I’ve had my vehicle in the shop countless times and it’s cost a lot of money. It now needs a new engine along with every other Kia Telluride on the social media groups, complaining about the oil consumption and their engines going bad and needing replaced. The dealership refuses to replace my engine because there’s no recall.

I had the AWD coupler replaced at 66000 under warranty due to a TSB and hesitation when turning at slow speeds. I'm at 110000 and the AWD coupler is failing again and needs replacement but Kia warranty won't cover it again. Very frustrated

For the past year to year ½ I have brought my car in for concerns with idle, hesitation when accelerating, stalling out, etc. This has put me in compromised situations when in traffic, at stop lights and when trying to accelerate to get on the highway. I was told it was fine, until it was not. Now my engine needs to be replaced. What I discovered in my car was their worksheet on issues that they never shared with me. Identified issues on this report: Fault Code 6, PO300400 - history, cylinder misfire, PO30500 - history, cylinder misfire PO34100 When going back for a 'simple' 1000 mile oil check, I was told there was not enough oil loss to identify concern. When I checked my own oil after another 1000 miles, KIA then pursued. In researching, there is a history of these engine problems and engines needing to be replaced with KIA. This is unacceptable and has compromised safety and any value I hoped to have with my car.

My torque converter is failing on my 2020 Kia Telluride. This is a known issue among other owners of this model year, and I believe Kia knows about it and is refusing to acknowledge because of how expensive it is.

Rear shocks failed prematurely

Paint peeling on the roof of vehicle, 5 years old, known problem to KIA. White Pearl Vehicles, KIA will do nothing to remedy this problem. It has been well known of an issue.

Sunroof plastic arms broke off and now sunroof will not close. Looking this up, it is a very common issue. I have only used my sunroof about 10 times since I bought my vehicle.

When starting vehicle during warm weather conditions, all dashboard alarms light up and beep. Initially, when put into drive mode, steering is extremely difficult. When accelerating, no speed is displayed. During driving there is no speedometer, no operating turn signal and the odometer does not record driving miles.

The infotainment system which includes the backup video system has turned to a green screen intermittently on these models. We just started experiencing this issue in the past week. After searching the Kia user forums, it appears that many people are having a similar issue. When we took it to Kia they stated that car is out of warranty and the part cost alone was over $5000 to repair the head unit. It seems they know they have an issue but don't want to acknowledge it and quickly revert to the warranty. I'd like someone to investigate this as it's a safety risk when you a backing up the car.

Sunroof could not be retracted due to track breaking during normal operation. Repairs have been made and part is not available for inspection. Passenger safety put at risk due to exposure to rain and cold in the passenger compartment. Problem confirmed at an independent service center. Vehicle was inspected at the service center. This happened without warning. Other owners have experienced the same problem.

History of engine randomly lurching/ hesitation when shifting. Have brought car in when it stalled out while driving, or at light. Largest problem now is oil leaking excessively. KIA has not been forthcoming on their history with this issue on 2020 Tellurides. Have been dealing with this the past couple of months and needed to bring it in for 'checks'. Service tech said that ½ Quart of low oil after 1000 miles was not enough for KIA to flag; told me to come in at oil change time. He said I did not need to worry as it was still covered under 100,000 warrantee. After checking it myself after driving another 1000 miles, I found that it was low. I brought this in for immediate concerns. I was told to 'wait' as my Service Tech was not there that day. He called me the next day to tell me I should bring in when I can so they can write up an 'approval ticket' for KIA. I brought in the following week. Again he was off. I spoke with another tech who told me it was low 2 ½ Q of oil - this was a week later. I now have to wait for KIA to 'approve'. I was told this could take a week or longer.. I need my car. I asked for a rental and was told I may have to pay for it. This is frustrating and disturbing. I am told by other tech that I will probably need a new engine and I should not drive my car until it is addressed. This car is 4 ½ years old and has less than 70k miles.

Vehicle burns oil, current mileage at 169k. User manual indicates 7500-10000 miles between changes, I am original owner. Dealership service set for 5k intervals since purchase and done on time. At 99k noticed noises from engine, light rattling but couldn't replicate and couldn't pinpoint at dealership service. At 112k noticed burning oil and rattling noises when accelerating from stop. Changed to 3k oil change intervals, began using premium fuel. 1quart of oil at 0-1000 miles from oil change (had a consumption test at dealership and confirmed "normal" at 112k), sub sequential mileage burns more than 1quart between 1k intervals, can easily burn through 4-5quarts between 3k oil changes. Oil smells slightly like gasoline closer to oil change time. Outside mechanic confirmed rattling as detonation. Concerns of oil not "burning" but mixing with fuel either through oil vapors getting through PCV valve and diluting fuel octane causing rattling. Knock sensor suppresses from causing engine damage, but still happens. Fuel may be getting into the oil, not sure how, but wouldn't explain detonation. No codes, no other issues. Only check engine light since rattling noticed at 99k was failing O2 bank 2 sensor which was replaced by licensed mechanic with OEM parts. The amount of additional oil maintenance and changes were not disclosed on expected maintenance costs sheet posted on vehicles, nor is it communicated in the users manual. Personal opinion is the additional maintenance between cha

Sunroof malfunctioned on opening, went off the tracks and is now stuck in an open position. There were no obstructions causing the sunroof to be lifted and dislodged from the tracks. The integrity of the vehicle and its passengers are compromised due to being openly exposed to the elements. Risk of theft, further damage, and injury. Dealership unable to service the vehicle in a timely manner. Problem has been confirmed and inspected by an independent servicer. No warnings or other symptoms.

Wind deflector snapped on Sun roof causing. Sun roof to get lodged and get off track. Unable to close Sun roof now opening it to all types of weather. Safety issue not being able to close the Sun roof while transporting passengers especially children. Kia dealership aware and refusing to help. Wind deflector is a known issue for the 2020 telluride sunroof as found by the NHTSA bulletin on this defective part. Dealership refusing to help since out of warranty even though it is a known issue.

We bought this brand new and have the paint peeling off. It’s a 2020 so paint should not be pealing off. I have read that they are aware of this paint issue but nothing is done yet about it.

The contact owns a 2020 Kia Telluride. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the dealer was performing an oil consumption test. In addition, the contact was advised by the dealer that further diagnostic testing was needed to diagnose the failure, which could result in the engine being disassembled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the valve cover gasket was replaced. In addition, the oil housing was replaced two times. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 161,000.

Only owner of a 2020 Kia Telluride SX Prestige that just crossed 60,000 miles. We don't use the sunroof but yesterday 7/30/25 we opened it, the wind deflector arms had broke which caused the sunroof glass to come off the track. Now it won't close at all. This can put my family at risk due to excessive heat in Texas, fumes that should not be getting inside the vehicle and rain water. This has been reproduced and inspected by the Kia dealership. Since I'm over 60,000 miles this is not covered under warranty. No warning lamps or notifications since it's the sunroof. We just wanted to cool down the car quicker by letting the heat out - so totally normal operation that ended up with a sunroof being stuck open. Very frustrating!

Sunroof would not open or close properly. Dealer said arms broken. Need entire new sunroof at over $5000 plus labor! To replace just these small pieces. The glass is out of the track and taped down. It is a dangerous fix. I cannot understand why Kia won’t fix with it being a known malfunction of sunroof mechanism assembly according to TSB. I am out of warranty by 6 months. I contacted Kia and this was their response. Need help please.

Folding outside mirrors get stuck randomly, Back up Camera functions erratically, and worst of all, the Sun Roof jammed open.