2021 Kia K5 complaints

The contact owns a 2021 Kia K5. The contact stated that fuel odor was entering the cabin of the vehicle. The contact stated that the rear passenger’s seat seemed to be inflated. While driving approximately 70 MPH, the contact became aware of fuel squirting out of the fuel filler neck. The fuel gauge fluctuated from full tank to half tank or empty. There was no warning light illuminated. The fuel odor became stronger, and the contact pulled over to the side of the road at a rest stop. A mobile service tech arrived to inspect the vehicle but found no failures. The contact continued driving to the residence. The vehicle was taken to the dealer, who found that the fuel tank and fuel line had failed and needed to be replaced. The dealer sent a photo to the manufacturer to confirm the necessary repair. The vehicle was not repaired. The manufacturer was informed of the failure and determined that the fuel tank and PCV valve were swollen and needed to be replaced. The manufacturer offered a buy-back for the vehicle and opened a case. The failure mileage was unknown.

No power at all all most in a accident with it when it lost power they said it’s the turbo l paid 33,000 for this car it had 35000 miles on it has 103000 on it when it lost power

The contact owns a 2021 Kia K5. The contact stated that while his daughter was driving approximately 15-20 MPH, the engine revved and the gears in the transmission unexpectedly failed. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. Due to the safety concerns, the vehicle was no longer driven and remained parked at the residence. The manufacturer was not informed of the failure. The failure mileage was unknown.

While driving, the check engine light came on. Soon after, the rear floor of my 2021 Kia K5 lifted upward, and I noticed the fuel tank underneath had swollen. When I opened the gas cap, it blew off with force and gasoline sprayed on me, soaking my clothes. This could have caused a fire or explosion. The car is now unsafe to drive, and the rear seat cannot be used because the floor is deformed. I discovered that Kia has a Voluntary Emissions Service Campaign SC288 addressing this exact issue (fuel tank swelling and excessive pressure due to a faulty PCSV valve and EVAP system), but this is clearly a safety hazard, not just an emissions problem. Many other owners have reported the same issue online. I believe this defect should be escalated to a safety recall before someone gets seriously injured or worse.

I have a Kia K5 and was not informed of the SC288 Service campaign Fuel tank Inspection & EMC update (VESC) expansion of fuel tank and explosions' of fuel tanks. My vehicle was not apart of the recall for the fuel tank expanding program. I took my vesical in for service for over heating and it failed the SC288 Service Campaign. my gas tank expanded and caused structural damage to my car. it has been 8 weeks and I have not have had any contact from Kia consumer affairs. I am now with out resolve and I now have to get a lawyer.

Kia has a known issue with the HVAC blower motor circuit on this vehicle model. They have issued a warranty extension related to relocating the blower motor fuse to another circuit in the fuse box, due to potential burning of fuse(s). After executing this extended warranty fuse-relocation-procedure, our blower motor relay burned and was replaced twice by separate Kia dealers. Kia is now claiming that our entire wire harness needs to be replaced at our own cost. It is quite obvious that any wire harness issue is now very dangerous (electrical arcing and melting) and was caused by the original motor circuit issue. (The two Kia dealers agree with our assessment but are saying that Kia will not repair because original warranty extension was limited to rewiring.) Safety issues: Electrical fire hazard (already demonstrated with burning/melting fuse-box before and after extended warranty procedure was executed). No A/C in 95 degree F conditions.

The car has a sudden loss of power but doesn't shut off. The drivers eat doesn't move towards or back and the back seat popped up for no reason whatsoever. We have taken it to the dealership and they say its not a recall but its doing the same things that others in the same year and model are doing. Why isn't this one on the list . Its paid off and haven't been able to drive it for a year now . Wasted money getting it towed to dealership and back . Ridiculous!!!!

I was driving down the highway and my car made a loud bang noise. It would not accelerate over 50 mph no matter how hard I pressed the accelerator. Took to dealership and they told me I needed a new battery and charged me $365. Drove it and still won’t go over 50 mph. They kept it for a week and said it had a faulty valve that caused pressure to make the gas tank expand, pushing up back seat. Said it wasn’t a recall and would cost me $3600 to fix. Told me it was too dangerous to drive. Did research and saw that this was discovered over 2 years ago but I was never told. Now they say I have too many miles on my car to fix it. The gas fumes inside the car are intolerable and it still won’t go over 50.

At the beginning at the year I had to change my starter because my car would leave me stranded on the street, at a stop light or any time my car would stop. I was once in the car with my little brother and in the middle of the street it would not start again and left us stranded. Others around me had to help me push the car to the side of the road that way I wouldn't be rear ended. Now, I'm having other issues such as HVAC were my cars AC does not turn on. It doesn't even blow hot air. Some mechanics have told me it's probably my blower and resistor and other that it's a wiring issue. My car is only 4 years old and should not be having so many issues. I have tried reaching out to Kia but always get sent to voicemail or have told I would be charged for it to just be seen. If anyone could help me with my car that would be greatly appreciated.

HVAC is not working at all, not even blowing hot air. I've been told it could be a wiring issue or have to change my blower and resistor. KIA has told me they could not help because my car is over the 60,000 mile warranty. However, my car is 70,000 miles and about 4 years old. It has had other recall issues and just trying to be helped.

Just minutes before entering the highway, my son and I heard a very loud popping sound that startled us, like something large hit the car or a tire exploded. I immediately pulled into a gas station checked the exterior & all 4 tires, but everything appeared intact. Shortly after, while driving on hwy during morning rush hour at 65–70 mph in the far-left lane, the check engine light illuminated & almost immediately the car lost all engine power. My speed dropped quickly with cars behind me traveling at high speeds. I had to activate hazard lights & cut across 4 lanes of traffic to the shoulder, putting myself, my child passenger, & others at serious risk of a multi-car collision. While waiting for help, I plugged in my FIXD OBD-II reader later looking over diagnostics read code P0451 – EVAP System Pressure Sensor. 8 hours after car was towed & had been parked at my home & still not starting I researched the code to learn what that means & the possible cause for & found it is all emission related issues varying in reasons as simple as a gas cap replacement. Nothing of any engine failure while driving risking the lives of drivers & others so before sending my car to a mechanic, I went and checked the gas cap in case just a simple emissions type fix that is where I observed fuel still bubbling out of the tank have photos, my daughter, & sister, as witnesses. The next day car was towed to Kia Mall of Georgia on June 26, 2025. As of August 20, 2025, the dealership has confirmed the

The reverse braking feature registers cross traffic or movement that is not near the back of the vehicle. This cause the braking system to engage. I was doing a U turn on 4 lane main street with a center divider. I didnt fully clear the turn leaving me to reverse to complete to turn. When i put the car in reverse, the sensors picked up movement across the street, engaging the brakes and leaving me stuck in the middle of the road with oncoming traffic coming straight at me. It would not disengage when I tried accelerating and I had to quickly throw my car into drive and pull into a driveway, that was luckily there, just to avoid being T-boned by oncoming traffic. This is not the first occurance as it happens often in parking lots locking my brakes due to any movement from behind. There is a manual feature in the dashboard to turn it off but it automatically resets every time the car is turned off, requiring you to have to manually disengage the feature everytime and you cannot disengage while the brakes are locked.i took it to the dealers but they said since it is a "feature" it is not considered a safety issue since there is an option to disengage even though it has to be reset during every use. They could not help or remedy the issue and instructed me to file a complaint with Kia manufactures since they are only the Kia dealer.

The contact's daughter owns a 2021 Kia K5. The contact stated that while the contact’s son-in-law was driving, the fuel level indicator failed to function as intended. The contact’s son-in-law noticed that the miles available indicator stated that there were 430 miles until empty. The contact’s son-in-law stated that after driving for approximately 20 minutes, the miles available indicator indicated that the miles had decreased by 50 miles. The contact’s son-in-law drove the vehicle to a nearby gas station, and inspected the fuel tank cap, and confirmed that that fuel cap was sufficiently tightened. The contact's son-in-law proceeded to drive for another hour and the miles available indicator decreased by 200 miles. The contact stated that there were three occupants, including an infant, seated in the rear seat of the vehicle. The contact’s daughter, who was seated in the rear seat, noticed heat on the back of her legs. In addition, the contact’s daughter noticed an abnormal ticking sound and the rear seat independently raised up. The contact’s daughter stated that the failure was persistent. The vehicle was driven to the shoulder of the road. The contact’s son-in-law inspected the vehicle. The contact’s son-in-law and daughter switched seats. The contact stated that the daughter had driven a short distance, and the miles available dropped from 200 to 50 miles. The contact instructed the daughter to stop and exit the vehicle. The contact stated that the fuel tank level indica

Check engine light came on and when filling up my gas tank, gas spit back out at me which has happened with the fuel tank i had in it last year and has since been replaced. Forward collision, EBS, traction control and forward safety sensor lights came on the next day and the car is running extremely rough. It was towed to a shop to see if it has to do with the fuel tank recall. Multiple people in Roanoke, Virginia are having the exact same problem as is a large portion of people online complaining about the exact same thing. Some going back 30 weeks ago.

I am submitting this complaint regarding ongoing and unresolved safety issues with my Kia K5, which I believe are directly related to a known recall involving the ECM (engine control module) and/or fuel system. My vehicle continues to jerk and misfire during acceleration, and it has even stalled at idle on multiple occasions — creating a serious safety concern for myself and others on the road. I have already completed the recommended repairs, including new ignition coils and spark plugs, yet the problem persists. Despite these symptoms aligning with known recall-related issues, Kia of Orange Park (Florida) has refused to fully diagnose or investigate the matter, citing that the recall does not apply in my case. However, the symptoms match those outlined in other ECM/fuel system-related recalls, and this is not the first time this dealership has failed to properly address mechanical concerns. Previously, I had to escalate an A/C issue to Kia Corporate, which only resulted in a resolution after a recall was issued right before my vehicle was set to be returned with the same issue. That situation makes me extremely concerned that my current safety concerns are again being ignored and will only be addressed after a broader recall is issued. I am requesting that the NHTSA investigate this matter, as I am worried this defect may affect other vehicles and poses a safety risk that Kia and its dealerships are not taking seriously. Thank you for your attention and action.

AC blower stoped working

My fuel tank expanded while I was driving on the highway, causing my car to stall and would not respond to me pushing on the gas. I pulled over on the side of the highway and looked back and saw my rear seats were pushed up. Got it towed to the Kia dealership and they informed me that my car was totaled because the gas tank expanded so much it bent my frame. This has been an ongoing issue with Kia/Hyundai vehicles but they have still not issued a formal recall, only a voluntary callback even though this is a very dangerous defect.

Expansion of air tank, causing to pop up frame in backseat and total car deemed unsafe to drive. No warnings car had never been in the shop prayer happened while driving over rule Mountain area with two children in the backseat. Kia inspected diagnostic ran stated it was air in gas tank under a recall claim to fix it for free and then two weeks later stated it was going to Kia America for a case number. Kia America called and stated that it was not safe to drive and the car is totaled.

Air/hearing works intermittently. I’ve had fuses replaced and this seems to be a known and ongoing issue that Kia refuses to acknowledge. Many have reported that the wires are melting inside of the fuse box and I fear that this may result in a fire.

I was driving down the highway when I heard a loud explosion like a gunshot that caused me to slow down and almost getting into an accident. It was scary; I came to a stop and realized that my sunroof had exploded. There is a large hole in my sunroof bigger than a watermelon with glass particles everywhere.

Driving down highway, gas hand was on half a tank then all of a sudden gas hand drops to empty and light comes on, engine started sputtering. Heard a loud pop in the back seat looked back and back seat has popped up from base. Strong odor of gasoline poured into the car. Went to closest gas station to get off highway. Unable to put fuel into tank. Called Quality KIA of Greenwood they said get out of the car and do not drive it. Called for a tow, vehicle has been towed to Quality KIA of Greenwood.

Hit pot holes lower control arm was replaced

AC system is interminably stops working for hours or days then starts working again. Have taken to dealer but every time I get it there unit starts working and they say they can’t check it if it’s working. This has been going on for over a month.

Back seat popped up due to fuel tank rising from under seat while driving

The contact owns a 2021 Kia K5. The contact stated while driving approximately 30-40 MPH, while the transmission was shifting gear, the vehicle started sputtering and jerking. The contact stated that the failure occurred while shifting from 1st gear to 2nd gear, and from 2nd gear to 3rd gear. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed the vehicle with an erratic gear shift with a grinding sound coming from the transmission. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

Having issues with the blower motor and harness which is a known issue with this car. I can’t keep my AC working plus my defroster doesn’t work either with the issue I am having with the blower motor. The issue is ongoing

Main wiring harness melted in my fuse box, had to pay $5000 to replace, turbo leaked into my engine and cause for the engine to blow! Hadn’t even had the car a year !! This is getting ridiculous.

I recently purchased a Kia k5 2021 gt line awd one month later I noticed there was recall I take to the dealership they let me know it will only take a few hours (3) and I can pick up later the same they call me 3h later and let me know sorry this case is going to take a few weeks and I should pick up rental car and they will pay for my rental so I did I come back one month later nothing as been done they just tell me to wait and they can’t release due to the safety recall the tank has swelled up it has been 3mont now and they still haven’t done anything to the car and I can’t sell the vehicle cause they won’t release it

My a/c has been giving me issues for about a year and a half to two years now. I have a 2021 Kia k5. When I first told Kia about it they told me it’s from the rain, if that’s the case then every car on the road would have this issue. Then they later told me it was my motor blower when I went back. There was a thousand dollar difference between two quotes they gave me for the same issue also. The air used to come on for a few hours or a day then go completely off. Now it’s sometimes will give off cold air if I put my hand to the vent but it’s nothing powerful to make a difference in the summer. I have read up on many other people having this issue. Kia also sent a recall to me last summer for a/c issues but the dealership told me that doesn’t apply to me because they are saying it’s my blower motor. I should not be held responsible for this malfunction at all. I want to request Kia give me an extended hvac warranty up to 180,000 miles at least!

The vehicle consistently pulls sharply to the right while driving, creating a serious safety hazard. As soon as I release the steering wheel, the car veers aggressively to the right, making it difficult to stay in the lane. The steering wheel does not center and requires constant correction. The issue feels mechanical and significantly impacts my ability to drive safely.

The contact owns a 2021 Kia K5. The contact stated while her daughter was driving 60 MPH, there was an abnormal sound coming from the engine, when the gas tank expanded, and the back seat popped up. The contact stated that two teenagers were in the back seat, and one was injured. The contact's daughter pulled over and waited for a short while. The vehicle was restarted; however, the vehicle drove slowly. The vehicle was taken to a dealer; however, the vehicle was not diagnosed. The vehicle was taken to another dealer; however, no cause for the failure was found. The contact was informed that the seat had moved two inches. The contact stated that the vehicle was not repaired because the frame of the seats could be damaged. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle remained at the dealer and had not been driven since. The failure mileage was approximately 86,000.

My current 2021 Kia K5 FUEL TANK EXPLODED while driving. I’ve had this car for about 5 years and since driving it off the lot have experience issues with the vehicle and just a few hours ago, the fuel gas tank explode raising the back seat with passengers in the vehicle. It was extremely scary and something out of the blew. My friends and I were driving and I noticed the car engine light turn on (which was so odd to me as I keep a close eye to the car maintenance) and within 20 minutes we heard two EXTREMELY loud explosions sounds come from the car with the feeling of the car shake and rise a bit and felt as a tire exploded. I did not find this usual and we pulled over and the the seat my friend was sitting on was rose and unlatched. We then did some google searches and when looking into it, it appears there have been previous issues with this situation for other K5 Kia owners but KIA has done nothing regarding the matter. A few months ago I also went due to an internal thermostat exploding and causing the engine to overheat and smoke on the freeway and because they deemed it was not under the warranty, I left car-less for a week and a high bill. I don’t understand why I have to pay and endure these service costs when this is BASIC CAR FUNCTIONS. I do not appreciate the lack of empathy from dealer and service staff and feel unsafe and concerned for my safety for driving this vehicle. And now II have to endure the costs of being car less for 14 days per the dealer. Absurd.

Very bad antifreeze smell under hood dealer said normal not healthy to smell that its in all of this model car in multiple years needs a recall to force kia to fix this unhealthy problem. 3/1/25 is when i bought this car. thankyou

The steel trim running underneath the rear window is beginning to lift up There is a recall for this for vehicles produced sometime in 2023 but it doesn’t include my vehicle

Please review Kia Costumer Care case number [XXX] date 2/20/2025 @ 4pm New York time. Brake pads worn out ,easily broken and rusty. ??? Kia Company material defect or car dealership scam. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX] I took my automobile, a 2021 Kia K5 to Planet KIA of Charlotte NC located at 4700 E independence Blvd. I took it there to check what caused my engine light to activate. The initial diagnosis was a bad Sensor-Differential Pressure. Planet KIA repaired the Sensor-Differential Pressure at the cost of $501.17. My extended warranty company Route 66 covered $350.28 while I covered the remaining balance of $150.89. The engine light came on again the next day and while driving back to the dealership, I experienced the car slowing down and difficult to gain speed in highway traffic. I returned the automobile to Planet Kia of Charlotte and on [XXX}, I was informed that I had a valve failure which in turn caused my gas tank to swell. On [XXX] the warranty company denied request to pay for repairs due to their policy of not covering emissions which pertained to the valve. Kia refused to fix this problem due to a service campaign recall had been performed on the vehicle before I bought it. They found no issues with the vehicle pertaining to the valve or gas tank swelling. This is clearly a manufacturer’s defect, and it should have been repaired by the manufacturer. If you can, please help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Electric seats do not adjust due to failed motors. Electric mirrors do not adjust due to failed motors. Gas refuel door does not open due to faulty actuator. All things that make the care dangerous to drive. Online search reveals that all three issues are very common in the 2021-2023 KIA K5 cars. We believe they pose a danger. Also, they seem to break at about 40-60K miles. Often out of warranty and dealer will not fix even though they acknowledge that the items in question are an issue.

I've took my lease vehicle too dealer for the same problem 3 time car shake no matte what speed check engine light flashes code P0302 cylinder 2 misfire

Blower motor stops working, have to take fuse box cover off and move fuse assembly to regain function of blower motor. Replacing fuse only helped for a couple of months.

Hi I brought my 2021 kia k5 got line last February 2023 around 44k miles I have had coolant leak where nobody can tell me where is the leak coming from I look online and other Kia owner have had the same issues

For breaks: at 20k miles the steering wheel shakes like crazy when braking, and also the pedals: the rotors are very cheap for being a 0-mile purchase vehicle and Kia does not replace this under warranty. I saw a forum that this is an issue for all owners of this Kia K5 and Kia doesn't care and does not replace them. For Electrical issue: the fuse box melted a couple fuse because I used my rear defrost system. Kia extended the warranty for the HVAC motor fan only because was burning the fuses, but they did not wanted to replace my issue with the rear defrost because I was above 60k for only 1000 miles. This is a poor-quality system, Kia does not recognize it. This is a safety issue because 1. There is an electrical issue with a melted fuse box. Im driving around a car like this with 2 kids. 2. I don't have rear defrost working and I live in Chicago (wild winter). They want to charge +$6000 to repair the fuse box.

On Mon, Nov 18, 2025, I was driving at 60 mph with cruise on. Suddenly cruise was cancelled and check engine and low oil pressure lights came on. I pulled off road at earliest point possible. Seemed to be running ok. Drove slowly to a convenience store and turned off engine. I checked oil and it was low. When I was walking out to car after buying some oil, I saw oil under car. I called tow service and had it delivered to dealership. Upon inspection, the dealership determined the oil drain plug had fallen out and the engine needs to be replaced. The oil had been changed by an independent shop at 75085 miles. This incident happened at 78,887 miles. I feel the drain plug would have fallen out before 3002 miles if it was put in loose. This issue needs to be made into a recall with reimbursements for engine replacements and towing. If this had happened on a busy road and engine seized, there could have been a wreck trying to get off road.

AC System faulty . Cannot defog windows. Fusebox connection is malfunctioning Changed blower motor, resistor, fuse, relay. Many vehicles are having the same issue. It needs to be recalled.

Issue with electrical wiring for HVAC. Air conditioner and heater goes out with no power. You have to pop the hood and press on the fuse box to get it to come back on.

While driving on my way home from work my , brakes became extremely hard to press down on and then my service engine light came on this all occurred on 7/31/2024. So the very next day I took my vehicle to a Kia dealership which was 8/1/ 2024 to find out what was causing this to happen. The technician stated that they would have to put it on a machine and run a diagnostic on it. I asked the technician while they were doing that to change the oil. I also realized that the oil light for my vehicle has NEVER came on since I purchased the car. So the technician did the diagnostic and stated that my vacuum pump had went out but he couldn’t tell me why or how this had happened. I then took the vehicle to my parents house and left it there in the garage for a few weeks to have second opinion done. I then took it to another Kia dealership and they stated there was no vacuum to the brake booster and said there was a broken camshaft and metal pieces were in the engine and the engine needed to be replaced. Again I asked what caused all of this and no one could give me an answer. I had only had the car a 1 1/2 years and don’t understand what caused all of this and I now have a car that I can no longer drive.

Have had issues with a/c since I bought the car. Has been inspected 3 times, apparently it was just the actuator doors not working. But not I have no a/c, and my dealer refused to fix it. On reddit there's a thread going around saying fuses are melting and that it's causing everyone's a/c to not work. My fuses for this particular spot are burnt looking. This is a safety issue in regards to living in Arizona, the heat is deadly. I will be trading my car in if this isn't recalled.

Air conditioning was fine then would suddenly cycle levels by itself. One day the air stopped blower. Tested the resister, it was bad. Replaced it and less than one week later the air stopped again. Resister and blower motor test fine. Fuses and relay are fine. No ac/hest causing driving concerns with window fog.

While driving home from work, traveling on a state route at 55 mph, the cover under the engine just snapped off on the passenger side of the vehicle. It just started making a loud noise like I had blown a tire! I pulled over and noticed it was hanging down on the road. I had not hit anything, the bracket had it fully broken, it could have caused me to wreck or put any other drivers at risk for an accident. This isn’t the only Kia K5 I’ve seen with the engine dust cover hanging beneath the vehicle.

I have 2021 Kia k5 gt line I am having similar problem as other who own a Kia k5 get line 2020,2021, 2022 and 2023. Ac works one time next I turn the car off and the next time I start it up it doesn’t work anymore and now my ac does not work now and it is off completely

Purge control valve but pressure in my gas tank and it has expanded. Kia will not replace my tank. Heard 2 loud bangs going down the road I started smelling gas. Check engine light came on. Pulled over and gas is pushing up and out behind my tank flowing down my wheel well. Opened the gas cap and it sprayed gas all over me. I have 2 small children and this could have been a extremely worse situation than it was. On another note I took my car to the dealership they did the update and confirmed my gas tank had expanded. They are not replacing my tank they said bc kia has "no remedy". And tried to sell me a bunch of other services on my vehicle instead. I've contacted kia and they basically told me the same thing they at this time will not be replacing my tank. I've picked the car up they cleared the codes and the car is still running rough.