2006 Jeep Wrangler complaints

WHEN YOU FILL UP THE GAS TANK THE AUTOMATIC STOP DOESN'T WORK AND THE GAS SPILLS OUT ALL OVER THE PLACE. I BOUGHT THE JEEP USED ON JULY 11, 2014, AND I JUST HAVE NEVER DONE ANYTHING ABOUT IT. WHEN I BOUGHT IT, IT HAD 35,000 MILES, NOW I HAVE 70,666 MILES. I WENT ONLINE AND ON THE JEEP FORUM AND YOUTUBE SOME PEOPLE HAD FIXES BY BUYING A GM NEW FUEL FILLER HOSE PART #15131046 AND REPLACING IT AND IT SEEMS TO HAVE WORKED. ACCORDING TO WHAT I'VE READ THE WARRENTIES WERE EXTENDED FOR 2007 AND OVER BUT NOT THE 2006'S.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING OVER 50 MPH, THE VEHICLE SUDDENLY BEGAN TO SHAKE AND VIBRATE VIOLENTLY. THE CONTACT INDICATED THAT THE SHOCKS AND BRAKE ROTORS WERE REPLACED AND THE TIRES WERE ROTATED, BUT THE FAILURE CONTINUED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 36,000.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE ACCELERATING FROM A COMPLETE STOP, THE TRANSMISSION SHIFTED VIOLENTLY INTO SECOND GEAR. THE ENGINE BEGAN TO REV RAPIDLY. THE FAILURE OCCURRED ONLY AFTER THE VEHICLE WAS INITIALLY STARTED OR WHENEVER THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE PCM WAS REPROGRAMMED. THREE WEEKS LATER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE PCM WAS REPLACED; HOWEVER, THE FAILURE RECURRED NINE MONTHS LATER. THE VEHICLE WAS NOT REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

FUEL TANK FILLER NECK SPILLS GASOLINE FORCEFULLY OVER THE SIDE, FENDER FLARE AND GROUND, WHICH REQUIRES A SPILL KIT TO BE USED TO CLEANUP THE PUDDLE CREATED BY THIS SPILL. THIS PROBLEM HAS OCCURRED BEFORE AND WAS FIXED USING THE SAME FAULTY PARTS WHICH AT THAT TIME WAS UNDER WARRANTY. APPROXIMATELY 4000 MILES LATER THE SAME SPILLING OF GASOLINE OCCURRED BUT DEALERSHIP SAID THE VEHICLE WAS OUTSIDE THE WARRANTY PERIOD AND THAT IT WOULD COST ME $1000 TO REPAIR. I BELIEVE THIS IS AN EXTREME FIRE HAZARD AS WELL AS A POSSIBLY SEVERE INJURY TO MYSELF AS THE GASOLINE COULD FLY INTO MY EYES OR UNTO MY CLOTHES. I DEMAND A COMPLETE NEW FUEL TANK CONFIGURATION AND FUEL FILLER NECK PARTS. TWO EXACT PROBLEMS MEANS FAULTY EQUIPMENT PARTS AND SHOULD BE REPAIRED WITH UPDATED PARTS. THE FIRST TIME IT WAS FIXED IS LISTED BELOW.

GAS TANK OVERFLOWS WITH FUEL WHEN FILLING GAS TANK AND SPRAYS BACK ON YOU AND TO GROUND. I ATTACHED A LINK TO A YOUTUBE VIDEO. THIS IS NOT MY CAR BUT I HAVE THE EXACT SAME PROBLEM. HTTPS://WWW.YOUTUBE.COM/WATCH?V=ZOUVOKEOLO8

THE PLASTIC PART, YES PLASTIC, THAT ALLOWS THE TRANSMISSION TO BE SHIFTED INTO PARK BROKE AND I WAS UNABLE TO SHIFT INTO PARK. THIS PART IS PART OF THE GEAR SHIFTER ON AN AUTOMATIC TRANSMISSION AND THERE ARE SEVERAL COMPLAINTS ON THE ON-LINE CHAT SPACES.

WHEN FUELING THE VEHICLE, THE FUEL SPLASHES BACK AT NEAR FULL. THE FUEL LEAKS DOWN THE PLASTIC FUEL DOOR AREA AND ONTO THE PAINTED FINISH ON THE BODY. I HAVE HAD IT SPLASH BACK ONTO MYSELF, ALSO. THERE IS SUPPOSEDLY A FAULTY FLAPPER VALVE INSIDE THE FILLER HOSE BEFORE THE FUEL ENTERS THAT TANK. THIS IS A KNOWN ISSUE ON THE 97-06 WRANGLERS.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING 60 MPH, THE STEERING WHEEL VIBRATED AND SHOOK WHEN THE VEHICLE DROVE OVER A BUMP. THE CONTACT HAD TO HOLD THE STEERING WHEEL AGGRESSIVELY, SLOW DOWN, AND STOP THE VEHICLE. THE DEALER DIAGNOSED THAT THE SHOCKS AND TIRES NEEDED TO BE REPLACED. THE PARTS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER RUNNING AN ERRAND. THE CONTACT ALSO HEARD AN ABNORMAL NOISE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEERING COLUMN PREMATURELY FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN OF WHEN THE RECALL REPAIR WOULD BE COMPLETED FOR SEVERAL MONTHS. THE MANUFACTURER WAS NOTIFIED. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V322000 (AIR BAGS); HOWEVER, THE PARTS FOR THE RECALL WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

WHEN SITTING STILL WITH THE ENGINE OFF AND PUTTING GAS IN MY 06 JEEP WRANGLER, THE GAS PUMP DOES NOT KICK OFF QUICK ENOUGH WHEN THE TANK IS FULL AND SPILLS GAS DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND CREATING A VERY DANGEROUS FIRE HAZARD - IF YOU ARE NOT STANDING BACK, IT WILL SPLASH GAS ONTO YOUR CLOTHES WHICH COULD BE A DANGEROUS PERSONAL HAZARD WITH THE POTENTIAL OF BURNS TO A PERSONS BODY. GETTING IN AND OUT OF A VEHICLE PRODUCES STATIC ELECTRICITY AND COULD BE ENOUGH TO START A FIRE WITH THE JEEP AND POTENTIAL DANGER TO PEOPLE AND PROPERTY. THE JEEP WILL "BURP" GAS EVERYTIME THAT YOU FILL IT - THIS HAS HAPPENED ON NUMEROUS OCCASIONS. I DO NOT EVEN FILL THE TANK AND LET THE PUMP KICK OFF ANYMORE FOR THIS REASON - IT IS A DANGEROUS SITUATION IF YOU WAIT FOR THE PUMP TO KICK OFF.

I CALLED MCDONALD CHRYSLER IN CLARE MICHIGAN(624 W. 5TH ST., CLARE MICHIGAN 48617, 1-989-386-7779) I CALLED THEM ABOUT 6-7 MONTHS AGO WHEN I FIRST GOT MY FIRST RECALL NOTICE IN THE MAIL AND THEY TOLD ME THAT THEY HAD THE PART SO I SCHEDULED AN APPOINTMENT WITH THEM AND WHEN I GOT THERE THEY TOLD ME THAT THIS WAS THE FIRST THAT THEY HAD HEAD OF THIS RECALL AND SAID THAT THEY WOULD HAVE TO ORDER THE PART AND WOULD CALL ME WHEN THEY GOT THE PART IN. WELL ON 22 FEBRUARY 2016 I RECEIVED A 3RD NOTICE AND STILL HAVEN'T HEARD BACK FROM THEM. YOU WOULD THINK THAT WITH THIS BEING A SAFETY RECALL THAT THEY WOULD GET OFF THEIR BUTTS TO FIX THIS ISSUE. MY RECALL IS ABOUT THE CLUTCH INTERLOCK SWITCH(R13/NHTSA15V-22). I DO PLAN TO TAKE MY VEHICLE TO A DIFFERENT DEALERSHIP.

SUBMITTED REPAIR COPIES FOR REFUND IN SEPTEMBER 2015. FOLLOW UP CALLS TO FCA STATED CHECK IN MAIL, CHECK HAS BEEN CANCELED, SOMEONE WILL FOLLOW UP WITH YOU. TODAY FEBRUARY 18, 2016 AND STILL TOLD SOMEONE WILL CONTACT ME ABOUT REFUND.

THE JEEP HAS WHAT HAS BEEN TERMED THE JEEP DEATH WOBBLE. THE JEEP IS ALL STOCK, NOT LIFTED AT ALL. I HAVE FIRED THE PARTS CANNON AT THE JEEP...ALL THE WORK HAS BEEN PERFORMED BY FACTORY TRAINED TECHNICIANS USING OE PARTS. I HAVE CHANGED THE TIRES TWICE IN 20,000 MILES. THE JEEP GETS A TERRIBLE WOBBLE ON THE HIGHWAY AT 55MPH (SPEED LIMIT ON 465 IN INDIANAPOLIS) AND CAN ONLY BE BROUGHT UNDER CONTROL BY STOPPING THE VEHICLE. EVEN THOUGH I HAVE NEVER BEEN IN AN ACCIDENT CAUSED BY THE EXCESSIVE WOBBLE, IT IS DEFINITELY NOT SAFE TO COME TO A COMPLETE STOP ON THE HIGHWAY. IT'S NOT ALWAYS EASY TO PULL OVER TO THE SIDE OF THE ROAD ON A BUSY INTERSTATE HIGHWAY. THE FUEL FILLER NECK OFTEN OVERFLOWS WHEN FILLING THE FUEL TANK ALSO. THERE WAS A RECALL ON SOME JEEPS FOR THIS SAME PROBLEM. HOWEVER, THE JEEP DEALERSHIP SAID MY SPECIFIC JEEP DOESN'T QUALIFY FOR THE FIXING OF THE ISSUE. IT IS DEFINITELY NOT SAFE TO HAVE A FUEL FILLER NECK THAT DOESN'T STOP THE FUEL NOZZLE FROM FLOWING.

WHEN FILLING THE FUEL TANK THE FUEL FILLER HOSE FAILS TO STOP THE FLOW OF FUEL COMING BACK OUT OF THE TANK. THIS RESULTS IN FUEL SPILLING ON THE GROUND AND DOWN THE SIDE OF THE VEHICLE.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

FUEL PUMP DOES NOT SHUT OFF WHEN FULL CAUSING ABOUT 10 OUNCES OF FUEL TO SPRAY ON ME AND ON THE GROUND. IT ALSO DRIPS DOWN THE PAINT WHICH CAN CAUSE ISSUES DOWN THE ROAD OVER TIME

WHILE FUELING AND BEFORE THE PUMP AUTOMATICALLY SHUTS OFF, FUEL SPRAYS OUT OF THE FILLER NECK, RUNS DOWN THE FENDER AND ONTO THE GROUND. THIS IS NOT JUST RANDOMLY IT HAPPENS AT EVERY FILL UP.

WHEN FILLING UP TANK, FUEL COMES POURING OUT WHEN TANK IS DONE BEING FILLED

2006 WRANGLER UNLIMITED (RUBICON) OVERFILLS WITH GASOLINE BEFORE THE PUMP STOPS. ABOUT A CUP OF FUEL, DOES NOT MATTER WHICH GAS STATION OR HOW FAST THE TANK IS FILLED. IT HAS BEEN DOING THIS SINCE I PURCHASED IT FROM JEEP DEALER IN 2013.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN); HOWEVER, THE PARTS NEEDED WERE NOT AVAILABLE. THE CONTACT BELIEVED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED AND SCHEDULED AN APPOINTMENT TO HAVE THE REPAIRS PERFORMED. THE CONTACT WENT BACK FOR THE REPAIRS, BUT THE TECHNICIAN ADVISED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. ...UPDATED 02/19/16 *BF UPDATED 4/25/18*JB *TR

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN), HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

WHILE FUELING MY 2006 JEEP WRANGLER, THE FUEL FAILED TO STOP DISPENSING WHEN THE TANK WAS FULL. THIS RESULTED IN FUEL SPEWING OUT FROM THE TANK. THE FUEL GOT ON ME AS WELL AS THE JEEP AND THE IMMEDIATE SURROUNDING AREAS. I HAVE FUELED THE JEEP AT MULTIPLE GAS STATIONS WITH THE SAME RESULT. FUEL SPILLING OUT FROM THE TANK IS A SERIOUS FIRE, ENVIRONMENTAL, AND HEALTH HAZARD. AFTER REVIEWING THE NHTSA'S WEBSITE AS WELL AS OTHER REPUTABLE SOURCES, THIS SEEMS TO BE A VERY COMMON PROBLEM/COMPLAINT. I'M AWARE THAT THE 2007 AND NEWER JEEPS HAVE A RECALL TO FIX THIS PROBLEM. I FAILED TO REALIZE HOW SUCH A COMMON AND SERIOUS PROBLEM CAN BE IGNORED IN THE 2006 JEEPS.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE HEATER FAN SPEED SWITCH STARTS FAILING BY ONLY WORKING ON HIGH SPEED. THEN IT QUITS COMPLETELY. I HAVE HAD THE WHOLE UNIT REPLACED BEFORE ABOUT 3 YEARS AGO. IT JUST DID EXACTLY THE SAME THING AGAIN AND I HAVE HAD IT REPLACED AGAIN. THIS TIME THE REPLACEMENT UNIT DOESN'T ALLOW ME TO CHANGE THE LOCATION OF WHERE THE HEAT COMES OUT. IT IS STUCK ON THE DEFROSTER.

JUST PURCHASED THIS JEEP FROM A DEALERSHIP AND WHEN I FILL UP THE TANK WITH GAS IT OVERFLOWS EVERY TIME SPILLING GAS ALL OVER THE GROUND AND OVER THE DRIVERS REAR QUARTER PANEL. IT IS HARD TO STOP THE OVERFLOW DUE TO THE GAS COMING OUT, DANGER OF FUEL GETTING ON MY CLOTHES WHICH THEN MAKES ME FLAMMABLE AND SMELL LIKE FUEL. THERE IS ALWAYS THE DANGER OF FUEL GETTING IN MY EYES AS WELL, I DO NOT FEEL SAFE WITH THIS FLAW. I DON'T BELIEVE THAT ALL OF THE 2005 AND 2006 JEEP OWNERS SHOULD HAVE TO DISH OUT $900 FOR A NEW FUEL TANK THAT WILL FAIL AGAIN ANYWAY BECAUSE THE ICV VALVE WILL JUST FAIL AGAIN. THIS IS A STATIONARY ISSUE WHEN FILLING THE GAS TANK. CAN'T BELIEVE THAT SPILLING GAS ON THE GROUND EVERY TIME IS THAT GOOD FOR THE ENVIRONMENT.

FUEL SPILLS OUT OF THE FILLER PORT DUE TO INCORRECT ENGAGEMENT OF THE STOP ON FUEL PUMP NOZZLES. THIS IS DUE TO A MALFUNCTIONING ICV. THE JEEP HAS BEEN DOING THIS SINCE I HAVE OWNED IT AND THE PREVIOUS OWNER STATED IT DID THE SAME THING SINCE HE AND HIS WIFE BOUGHT IT IN 2008 -WHEN THE VEHICLE WAS ONLY TWO YEARS OLD.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIMEFRAME TO SCHEDULE THE RECALL REPAIR FOR MONTHS. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT WAS EXPERIENCING A FAILURE WITH THE CLUTCH SLIPPING OUT OF GEAR AND THE CONTACT HAD TO MANEUVER THE GEARS EACH TIME THE FAILURE RECURRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

WAS DELIVERING MAIL STARTED TO SMELL SOMETHING GOT OUT TO CHECK PACKAGE GOT BACK IN SMOKE WAS COMING FROM VENTS AROUND DASH AREA WENT FOR HELP WHEN RETURNING TO VEHICLE IT WAS IN FLAME TRIED TO SALVAGE AS MUCH MAIL AS POSSIBLE AND IT BURNED COMPLETELY

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

RECALL NUMBER R13/NHTSA15V-222 CLUTCH INTERLOCK SWITCH - THE PROBLEM I AM HAVING IS WE MADE AN APPOINTMENT WITH WESTBURY JEEP NEW YORK TO HAVE THIS TAKEN CARE OF THEY KEPT THE CAR FOR THREE DAYS AND COULD NOT REPAIR IT. WE WERE TOLD THAT THEY COULD NOT GET THE PART. THE SERVICE DEPARTMENT OF WESTBURY JEEP INEPT IN PROVIDING THE REQUIRED SERVICE TO CORRECT THIS, HAD A TOTAL DISREGARD FOR THE NEEDS OF THE CUSTOMER TO GET THIS REPAIRED IN A TIMELY FASHION AND WHAT WAS DISAPPOINTING THEY HAD NO IDEA ON A PART THAT THEY MANUFACTURED HOW TO GET A HOLD OF IT. AS A RESULT WE TOOK THE CAR HOME WITH OUT GETTING THIS REPAIRED. AS SUCH I WOULD LIKE TO REPORT THIS DEALERSHIP FOR FAILING TO REMEDY AND PROVIDE PROPER CUSTOMER SERVICE!

WHEN I FIRST BOUGHT THE 2006 JEEP WRANGLER, AND DROVE IT HOME, WHEN I GOT UP TO BETWEEN 50-55 MPH, THE WHOLE FRONT END OF THE JEEP SHIMMIED OR WOBBLED VIOLENTLY. I LOOKED UP THE PROBLEM ONLINE TO FIND OUT IF THIS WAS A COMMON COMPLAINT, AND EXACTLY WHAT THE CALL WHAT MY JEEP WAS DOING. THIS IS WHEN I FOUND OUT WHAT IT WAS DOING WAS CALLED, "THE DEATH WOBBLE". I THEN TOOK THE JEEP BACK TO CARMAX WHERE I BOUGHT IT USED, AND SHOWED THE CARMAX MECHANICS WHAT I HAD PRINTED OUT FROM ON LINE. THEY THEN, AND I QUOTE, FIXED THE PROBLEM. WELL THIS FIX ONLY LASTED ABOUT A 2 YEARS AND IT IS NOW BACK TO DOING THIS DEATH WOBBLE AGAIN. APPARENTLY THE "FIX" WAS NOT A PERMANENT ONE, AND OF COURSE MY 2006 JEEP IS NO LONGER UNDER THE 12 MONTH LIMITED WARRANTY ANY LONGER. I NEED TO KNOW IF THERE WAS EVER A SAFETY RECALL ON THIS PROBLEM AT THE MANUFACTURER'S EXPENSE, OBVIOUSLY THIS IS A DESIGN FLAW, WHICH I HAVE FOUND OUT THAT SUPPOSEDLY CAN BE PERMANENTLY FIXED. THE PROBLEM FOR ME IS, I CAN'T AFFORD THE COST TO DO THE FIX. THANK YOU FOR YOUR TIME. *TR

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 55 MPH OVER A BUMP IN THE ROAD, THE FRONT OF THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING DAMPER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 22,000. UPDATED 11/09/15*LJ, 03/28/18*JB *TR

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN) HOWEVER, THE PART WAS UNAVAILABLE TO PERFORM THE REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN); HOWEVER, THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE PART TO DO THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE PART TO DO THE RECALL REPAIR. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I BOUGHT MY 2006 JEEP WRANGLER RUBICON NEW FROM A DEALERSHIP. AFTER FEW YEARS I STARTED HAVING ISSUES WITH FUEL SPITTING OUT OF THE GAS FILLER WHEN FILLING UP AT A GAS STATION. ABOUT 1/4 TO 1/2 CUP AT A TIME. DOESN'T MATTER WHICH STAION OR WHICH PUMP I USE. THE PUMP I USE WOULD CLICK OFF,BUT ALWAYS A SECOND TOO LATE. THIS IS A VERY DANGEROUS PROBLEM IN THAT NOT ONLY IS IT DAMAGING MY PAINT AND WHEEL WELL FLARES BUT ALSO SPILLING GAS ON THE GROUND CREATING AN ENVIRONMENTAL HAZARD AS DEFINED AND REGULATED BY THE ENVIRONMENTAL PROTECTION AGENCY, AS WELL AS SPLASHING ONTO THE PERSON FILLING THE JEEP COVERING THEM IN FLAMMABLE CHEMICALS AND EXPOSING THEM TO LONG-TERM HEALTH ISSUES THROUGH INHALATION AND SKIN ABSORPTION AS ADDRESSED BY THE NATIONAL INSTITUTES OF HEALTH. NOT TO MENTION WITH THE FUEL SPILLING OUT LIKE THAT, IT ALSO CREATES A LOT OF FUEL VAPORS. WITH JUS A STATIC SPARK, IT COULD VERY WELL INGNITE THE FUEL. I CONSIDER THAT A VERY DANGEROUS SITUATION.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V222000 (POWER TRAIN); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS NOT MADE AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE PART TO DO THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE PARKED, THE GEAR LEVER FAILED TO SHIFT INTO THE PARK POSITION. THE EMERGENCY BRAKE WAS ENGAGED TO PREVENT THE VEHICLE FROM ROLLING AWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE SHIFTER ASSEMBLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V46000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,277.

WHEN FUELING THE VEHICLE, WHEN THE TANK IS FULL AND THE GASOLINE NOZZLE SHUTS OFF, APPROXIMATELY ONE CUP OF GASOLINE COMES OUT OF THE VEHICLE FILLER TUBE AND SPRAYS THE AREA AROUND THE FILLER INLET AND DOWN THE SIDE OF THE VEHICLE. THIS EVENT OCCURS REGARDLESS OF THE RATE OF FUEL FLOW. THIS EVENT OCCURS WHEN THE FILLER NOZZLE TURNS OFF AUTOMATICALLY OR WHEN THE USER MANUALLY CONTROLS THE RATE OF FUEL. THIS PROBLEM HAS BEEN DIAGNOSED BY FCA AS A DEFECT IN A PLASTIC VALVE LOCATED IN THE VEHICLE'S FUEL TANK THAT REACTS NEGATIVELY WITH GASOLINE ADDITIVES, SPECIFICALLY ETHANOL. FCA DOES NOT CONSIDER THIS TO BE A SAFETY ISSUE. AS THE VEHICLE OWNER, I CONSIDER THE FACT THAT THE VEHICLE SPEWS GASOLINE OUT AT ME WHILE REFUELING TO BE A SAFETY ISSUE AND REQUEST THAT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION TAKES STEPS TO REQUIRE FCA TO RESOLVE THIS ISSUE BEFORE SOMEONE IS BURNED. THANK YOU. *TR UPDATED 9/15/15*CW *CN

I BOUGHT MY 2006 JEEP WRANGLER RUBICON NEW FROM A DEALERSHIP. AFTER ABOUT TWO YEARS I STARTED HAVING ISSUES WITH FUEL SPITTING PUT OF THE GAS FILLER WHEN FILLING UP AT A GAS STATION. THIS IS MY WIFE'S VEHICLE AND SHE COMPENSATED BY NOT FILLING IT FULL BY SHUTTING THE FUEL PUMP OFF BEFORE THE HANDLE WOULD CLICK. OVER THE YEARS I HAVE MENTIONED IT TO DEALERSHIPS AND REPAIR SHOPS AND NO ONE EVER HEARD OF IT. IT IS AT A DEALERSHIP NOW FOR ANOTHER ISSUE AND AGAIN I MENTIONED THE GAS SPITTING OUT OF THE GAS NECK AND RUNNING DOWN THE JEEP SIDE AND GETTING ME WET. THEY SAID THEY KNOW ABOUT THE ISSUE AND THAT JEEP AND NHTSA HAD ADDRESSED THE ISSUE IN A COMPROMISE BY JEEP OFFERING AN EXTENDED WARRANTY ON 2007 AND 2008 MODELS AND JEEP SENT OUT COMMUNICATIONS TO THAT EFFECT. SINCE I HAVE A 2006, I NEVER RECEIVED ANY NOTIFICATION ABOUT THE FUEL OVERFLOW PROBLEM, UNTIL NOW. I CONTACTED JEEP AND THEY ACKNOWLEDGED THE ISSUE BUT REFUSED TO ADDRESS IT. THIS IS A VERY DANGEROUS PROBLEM IN THAT NOT ONLY IS IT DAMAGING MY PAINT AND WHEEL WELL FLARES BUT ALSO SPILLING GAS ON THE GROUND CREATING AN ENVIRONMENTAL HAZARD AS DEFINED AND REGULATED BY THE ENVIRONMENTAL PROTECTION AGENCY, AS WELL AS SPLASHING ONTO THE PERSON FILLING THE JEEP COVERING THEM IN FLAMMABLE CHEMICALS AND EXPOSING THEM TO LONG-TERM HEALTH ISSUES THROUGH INHALATION AND SKIN ABSORPTION AS ADDRESSED BY THE NATIONAL INSTITUTES OF HEALTH.

WHEN FILLING THE GAS TANK, IT WILL OVERFLOW, SPILLING GAS ON THE SIDE OF THE JEEP WRANGLER, THE TIRE AND THE GROUND. IT SEEMS LIKE THE FLAPPER VALVE IN THE FILLER NECK ISN'T PREVENTING SPILLS. IT HAPPENS EVERYTIME I'VE FILLED UP, SO I TRY NOT TO FILL THE TANK ANYMORE. I BELIEVE IT'S A SERIOUS SAFETY AND FIRE HAZARD. ONE SPILL WAS SO BIG, THE GAS STATION EMPLOYEES HAD TO USE KITTY LITTER TO SOAK IT ALL UP

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE REFUELING, THE FUEL PUMP FAILED TO SHUT OFF AND CAUSED FUEL TO SPEW OUT WITH FORCE AND SPILL ONTO THE GROUND. THE CONTACT STATED THAT THIS WAS A RECURRING FAILURE. THE VEHICLE WAS NOT TAKEN IN FOR DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 10/19/15 *BF

WHEN REFILLING MY GAS TANK THE GAS PUMP DOES NOT SHUT OFF AND GAS SPILLS OUT WITH FORCE CAUSING GAS TO SPILL ALL OVER THE PLACE (MYSELF, JEEP & THE GROUND). THIS IS A VERY COMMON PROBLEM WITH 2006 WRANGLERS (TJ & LJ) & JEEP FINALLY NEEDS TO DO SOMETHING ABOUT THIS FOR THESE MODELS AS WELL. THESE WERE THE WRANGLERS THAT TESTED SOME OF THE NEW PARTS FOR THEIR JK MODELS THAT CAME OUT IN 2007 TO PRESENT. A RECALL HAS BEEN ISSUED FOR THE 2007 & NEWER MODELS FOR THIS SAME PROBLEM. HOW ABOUT FIXING WHERE THE PROBLEM STARTED AT ORIGINALLY. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

VERY RANDOMLY, THE VEHICLE STARTS TO SHIMMY VIOLENTLY. HAVE SEEN THIS COMPLAINT ON SEVERAL WEBSITES. THANKFULLY WE HAVE BEN ABLE TO SLOW DOWN AND PULL OFF THE ROAD. HAVE BEEN TOLD THERE IS NO CLEAR CUT RESOLVE TO THIS ISSUE WITHOUT SPENDING A LOT OF MONEY BECAUSE IT COULD BE VARIOUS THINGS. WANT TO GET RID OF THIS VEHICLE BEFORE SOMETHING TRAGIC HAPPENS, BUT AM AFRAID BECAUSE OF THIS, WILL NOT GET WHAT VEHICLE IS WORTH AND SOMEONE ELSE MIGHT DIE NOT KNOWING THE ISSUE. FROM WHAT I UNDERSTAND, THE NAME FOR THIS CONDITION IS A "DEATH RATTLE"

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE PUMPING FUEL INTO THE VEHICLE, THE FUEL WOULD OVERFLOW REGARDLESS OF THE AMOUNT WITHIN THE VEHICLE. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 5,000.

IN ONE EXAMPLE OUT OF MANY ENGINE CUTS OUT COMPLETELY, VEHICLE SLOWS DOWN THEN CUTS BACK IN. 15 TIMES, THEN ENGINE CUTS OUT AND STALLS. LEAVING ME IN AN EMERGENCY SITUATION ON THE FREEWAY. ALL THIS DURING A 40 MILE TRIP.