1997 Jaguar XK8

Defect. CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Risk. THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Defect. THE DIFFERENTIAL OUTPUT SHAFT RETAINING RINGS ON THE REAR SUSPENSION CAN BECOME DISPLACED ALLOWING THE OUTPUT SHAFT TO BECOME DETACHED FROM THE DIFFERENTIAL UNIT.

Risk. IF THE OUTPUT SHAFT SEPARATES, THE REAR SUSPENSION WOULD COLLAPSE ON THE AFFECTED SIDE RESULTING IN LOSS OF CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL INSPECT THE VEHICLE'S DIFFERENTIAL SERIAL NUMBER AND REPAIR OR REPLACE THE NECESSARY PARTS.

TL* THE CONTACT OWNS A 1997 JAGUAR XK8. WHILE DRIVING 40 MPH AND SLOWING TO MAKE A RIGHT TURN, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER APPROXIMATELY FIVE MINUTES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.

WHILE DRIVING THE VEHICLE THE DRIVERS SEAT SUDDENLY BEGAN MOVING FORWARD WITH THE SEAT BACK LEANING FORWARD AS WELL. THIS FORCED ME UP AGAINST THE STEERING WHEEL ALMOST CRUSHING ME. I TRIED TO USE THE SEAT CONTROLS TO STOP THE MOVEMENT AND RETURN THE SEAT TO IT'S PROPER POSITION BUT THE SWITCH OVERHEATED AND CAUGHT ON FIRE. THANKFULLY I WAS ABLE TO STOP BUT HAD I BEEN DRIVING AT HIGHWAY SPEEDS THIS COULD HAVE BEEN A DISASTER. *TR

WHILE DRIVING MY 1997 JAGUAR XK8 ON POLARIS PARKWAY @50MPH, THE CAR LOST TOTAL POWER. I HAD TO WEAVE OUT OF THE MIDDLE LANE IN ORDER TO REDUCE A POTENTIAL ACCIDENT.. *TR THE LOCAL JAGUAR DEALER TESTED AND REPORTED THAT THE THROTTLE BODY FAILED THUS CAUSING VEHICLE TO LOSE ALL POWER...DURING THE DEALER TEST DRIVE, THE CAR ALSO LOST POWER ON HIGHWAY #670.. DUE TO THE SAFETY ISSUE, JAGUAR SHOULD MAKE THE NECESSARY REPAIRS..

TL*THE CONTACT OWNS A 1997 JAGUAR XK8. THE CONTACT DROVE THE VEHICLE TO THE SHOPPING CENTER AND WHEN SHE ATTEMPTED TO RESTART IT, SHE WAS UNSUCCESSFUL. THE REPAIR SHOP INSPECTED THE VEHICLE AND FOUND THAT THE TENSION BAR FAILED, WHICH CAUSED THE ENGINE TO FAIL. THE VEHICLE WAS TOWED AWAY. THE ENGINE WILL NEED TO BE REPLACED AT THE COST OF $18,000. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE VEHICLE WAS OUT OF WARRANTY; THEREFORE, THEY WOULD NOT ASSIST WITH THE REPAIR. THE FAILURE AND CURRENT MILEAGES WERE 44,604. UPDATED 04/28/09.*JB

1997 JAGUAR XK8 RECALL FOR DEFECTIVE WHEEL BEARINGS. CONSUMER STATES THAT FRONT RIGHT TIRE LOCKED UP. CONSUMER WAS INFORMED OF THE DEFECTIVE WHEEL BEARING. HE WOULD LIKE MORE INFO AND INVESTIGATION OF THIS PROBLEM. *KB THE RIGHT FRONT ROLLER BEARING FAILED. *JB

TIMING CHAIN TENSIONER FAILED, BROKEN CHAIN, BENT VALVES. JAG SERVICE SAID '97 XK8 HAD FAULTY TENSIONERS. MOST WARRANTY REPLACED. MANY NHTSA COMPLAINTS & TSB'S ON THIS FAILURE. JAG. IS AWARE OF THIS DANGEROUS PROBLEM. JAG. AGREED TO PAY FOR 1/2 REPAIR, IF I BOUGHT A NEW JAG. NOT ACCEPTABLE! DOES SOMEONE HAVE TO BE KILLED ON THE FREEWAY FOR JAG TO TAKE NOTICE! THERE NEEDS TO BE A RECALL FOR THIS PROBLEM! NOT JUST SERVICE BULLETINS! BOTH SERVICE AND SALES SAID THAT THESE TENSIONERS WILL FAIL! REVISED TENSIONERS WERE USED ON LATER MODELS! *JB

INTERMITTENTLY WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. IT STALLED THREE TIMES IN TWO WEEKS. THERE WAS A RECALL FOR THIS PROBLEM, BUT ONLY FOREIGN VEHICLES WERE INVOLVED. *AK THE PROBLEM CONTINUED. *SC *JB

CAR STALLS (CUTS OUT) AT HIGHWAY SPEEDS. THE FIRST 2 TIMES I HAD TO LET IT STOP, TURN OFF AND RESTART. THE LAST INSTANCE JUST AS I WAS TRYING TO PULL OVER IT RESTARTED. *AK

AFTER SPOTTING FLUID ON THE FLOOR, I CHECKED THE LEVELS IN THE CAR AND FOUND THAT THE POWER STEERING FLUID WAS LOW. AFTER FILLING THE PS RESERVIOR, I TOOK THE CAR TO THE NEAREST FORD DEALER, SINCE THE JAGUAR DEALER WAS 225 MILES AWAY. THEY FOUND A LEAK IN THE HIGH PRESSURE POWER STEERING HOSE. I WAS TOLD IT WAS A GOOD THING I DIDN'T DRIVE IT VERY FAR, SINCE IT COULD HAVE CAUSED THE PUMP AND RACK-AND-PINION STEERING TO FAIL. A REPLACEMENT HOSE WAS INSTALLED, BUT IT WAS A NEW DESIGN THAT, COINCIDENTALLY, ROUTED THE HOSE AWAY FROM THE ENGINE MOUNT, WHICH WAS WHERE THE OLD HOSE HAD WORN THROUGH A FELT PAD AND STARTED TO LEAK. I CONTACTED JAGUAR REGARDING MY CONCERNS WHY THE DEALERS OR OWNERS WERE NOT ADVISED OF THIS POTENTIAL PROBLEM, AND THEY TOLD ME THE DESIGN CHANGES ON THE HOSE WERE PROPRIETARY, GIVING ME NO REASON WHY THE HOSE WAS RE-ROUTED AROUND THE PROBLEM AREA. THE COST OF THE HOSE REPLACEMENT WAS $412.94. *MR

WHILE DRIVING 50 MPH THE TIMING CHAIN BROKE WHICH CAUSED THE VEHICLE TO STALL. THE DRIVER WAS ABLE TO COAST TO THE SIDE OF THE ROAD OUT OF TRAFFIC. THE CONSUMER STATED THAT THE TIMING CHAIN IS MADE WITH A PLASTIC COATING THAT IS PRONE TO FAILURE. THE FAILURE WAS CORRECTED IN LATER MODELS. *AK *NM

NORMAL CRUISING HIGHWAY SPEED, LET OFF THE ACCELARATOR AND CAR STALLS. HAVE TO WEAVE MY WAY OUT OF TRAFFIC AS CAR IS DECELERATING. HAD TO COME TO FULL STOP AND THEN ATTEMPTED RESTART WITH NO PROBLEMS. HAS HAPPENED FOUR TIMES AT HIGHWAY CRUISING SPEEDS, LUCKILY LIGHT TRAFFIC ON HIGHWAY AT ALL TIMES.

JAGUAR HAS 40,000 L997 MODEL XK8 SOLD FOR $75,0000. NEEDS NEW ENGINE! DEALER WONT TAKE OF EXPENSE OF REPLACING IT. WEB SAYS THEY HAVE FAULTY TENSIONERS, AND CYLINDER LINERS. *LA

WHILE DRIVING VEHICLE STALLED. DRIVER TRIED TO RESTART VEHICLE, BUT VEHICLE WOULD NOT RESTART. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THROTTLE NEEDED TO BE REPLACED DUE TO A WORN OUT SHUT OFF VALVE PART. *AK

PLASTIC GUIDE ON TIMING CHAIN BROKE,WHICH BROKE TIMING CHAIN,WHICH BROKE 2 VALVES AND SCOURED THE PISTON AND CYLINDER WALL.

REAR VIEW MIRROR HAS TURNED BLACK, AND CANNOT BE USED SAFELY. VEHICLE HAD BEEN TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE "FLUID" IS BAD IN THE MIRROR. THE MANUFACTURER HAS BEEN NOTIFIED.*AK *PH *NLM

THE 1/4" THICK STEEL BRACKETS THAT ARE WELDED TO THE DRIVER'S SEAT FRAME AND HAVE HOLES FOR THE SEAT FRAME TO BE BOLTED TO THE FLOOR OF THE CAR SHEARED OFF (I.E. COMPLETELY FAILED) WHILE DRIVING. THE SEAT BECAME UNATTACHED AT THE FRONT CAUSING THE SEAT TO ROCK BACKWARD LEAVING THE HEADREST ON THE BACK SEAT.*AK

WHILE DRIVING AT LOS ANGELES FREEWAY AT 55MPH AND WITH NO WARNING VEHICLE GOT SHUT OFF, CAUSING CONSUMER TO PULL OFF THE ROAD. THIS PROBLEM WAS INTERMITTENT. DEALER HAS INSPECTED VEHICLE SEVERAL TIMES, AND PROBLEM STILL OCCURRING. *AK

1997 JAGUAR XK8 SUDDENLY STALLS OUT COMPLETELY DURING FREEWAY DRIVING. OTHER LISTINGS AT NHTSA REGARDING THIS. POTENTIALLY FATAL ISSUE AS THE CAR CANNOT BE STEERED OFF THE ROAD EASILY. NO WARNING OF FAILURE - RESULTING IN FOLLOWING TRAFFIC HAVING TO BREAK LANE SUDDENLY TO AVOID THE STALLED JAG. THIS IS REALLY SERIOUS STUFF.*AK

FRONT LEFT AND RIGHT UNITS REPLACED - ABS AND TRACTION CONTROL MODULE REPLACED ECM UNIT TO BE REPLACED - CAR NOW AT DEALER 11/11/02. DT

WHILE DRIVING ON DUAL HIGHWAY THE ENGINE SIMPLY STOPPED! WITH NO POWER ASSIST, THE CAR WAS DRIVEN TO THE SIDE SHOULDER. I WAITED A SHORT TIME THEN RESTARTED AND CONTINUED ON. DEALER COULD FIND NO REASON FOR THE FAILURE. DT