2008 Hyundai Santa FE complaints

VEHICLE IS STATIONARY...I PURCHASED THIS USED VEHICLE A FEW YEARS AGO AND HAVE RECENTLY HAD A PROBLEM WITH THE BRAKE LIGHT SWITCH ALONG WITH OTHER PROBLEMS .KEY WILL NOT TURN WHILE IN PARK REQUIRING THE NEED TO PUSH IN SHIFT LOCK RELEASE BUTTON , MOVING TO NEUTRAL SO THE KEY WILL TURN AND START THE VEHICLE. I HAVE FOUND THAT THERE IS A RECALL FOR THESE EXACT PROBLEMS, BUT WHEN I ENTER MY VIN# THER IS NO RECALL LISTED. IS IT POSSIBLE THAT THIS RECALL WAS FIXED BY DEALER BEFORE I BOUGHT THE VEHICLE, AND IF SO, THE PROBLEM IS BACK CAN I STILL HAVE THE VEHICLE REPAIRED FREE UNDER THIS RECALL ? THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE EMERGENCY BRAKE WOULD ERRONEOUSLY ACTIVATE WHILE OPERATING THE VEHICLE. IF THE VEHICLE HAD NOT BEEN WARMED UP FOR AT LEAST 15 MINUTES, THE FAILURE WOULD OCCUR. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR IN COLD WEATHER TEMPERATURES. WHILE DRIVING APPROXIMATELY 35 MPH, THE EMERGENCY BRAKE AND ESC SUDDENLY ACTIVATED AND THE SPEED REDUCED TO 10 MPH. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. AN UNKNOWN DEALER IN JAMESVILLE, WI WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

MY FUEL GUAGE IN THE CAR SHOW NO FUEL AT TIME AND THEN 1/2 OR 1/4 TANK, CHECK ENGINE LIGHT IS ON, I HAVE HAD THE CHECK ENGINE LIGHT CHECKED AND WAS ADVISED THAT IT IS THE GAUGE IN THE FUEL TANK. THERE ARE OTHER FAMILY WITH 2008 HYUNDAI WITH THE SAME ISSUE?? HELP THE CHECK ENGINE LIGHT STAYS ON..

AS THE SAME AS EVERYONE ELSE, AT 70K MILES GAS GAUGE STOPPED WORKING PROPERLY AND CHECK ENGINE LIGHT IS STUCK ON. WE ARE VERY CONCERNED ABOUT NOT KNOWING THE AMOUNT OF GAS AND RUNNING OUT ON THE HIGHWAY. APPEARS TO BE A SAFETY CONCERN WITH THE VEHICLE SHUTTING DOWN. SHOCKED HYUNDAI HAS NOT RECALLED THIS PROBLEM. I HAVE OWNED SEVERAL HYUNDAI'S BUT THIS IS THE LAST.

TAKATA RECALL GAS GAUGE NOT WORKING.

THE CAR WILL NOT SHIFT INTO DRIVE. VERY HARD TO SHIFT AND WHEN I FINALLY GOT IT INTO "DRIVE", THE TRANSMISSION DOES NOT ENGAGE. UNABLE TO MOVE THE VEHICLE FORWARD. IT WILL GO INTO REVERSE, BUT NOT DRIVE. SHIFTER BECOMES HARDER TO MOVE AFTER ATTEMPTING TO MOVE IT SEVERAL TIMES. THE CAR WAS STATIONARY.

FUEL GAUGE ALWAYS READS AS EMPTY, REGARDLESS OF MOVEMENT OR AMOUNT OF GAS IN TANK, LEAVING DRIVER TO RUN OUT OF GAS IN UNDESIRABLE PLACES. REPAIR IS APPROX 600-800 DOLLARS. MANY COMPLAINTS SHOULD BE RECALLED. HAS TO DO WITH THE FUEL SENDING SENSOR OR SOMETHING I WAS TOLD.

FUEL LEVEL GAUGE BECOMES ERRATIC AND DOES NOT INDICATE CORRECT FUEL LEVEL IN GAS TANK. RECENTLY "CHECK ENGINE LIGHT" CAME ON AND DIAGNOSIS BY MECHANIC WAS "FUEL LEVEL SENSOR A, CIRCUIT INTERMITTENT". THIS IS A VERY EXPENSIVE REPAIR AND SHOULD NOT OCCUR ON A VEHICLE AT THIS STAGE. I HAVE NOW BECOME AWARE THAT THIS IS AN EXTREMELY COMMON DEFECT IN THE HYUNDAI SANTA FE LINE OF VEHICLES.

UNDER THE HOOD LATCH INOPERATIVE. I PULLED THE INSIDE LATCH TO GAIN ACCESS TO THE ENGINE AND THE HOOD WAS FREE TO OPEN. THE LATCH UNDER THE HOOD DID NOT SPRING BACK TO PROVIDE THE ADDITIONAL INTERLOCK. THIS WAS OBSERVED IN THE GARAGE WHILE STATIONARY.

FUEL GAUGE FREQUENTLY BOBS FROM EMPTY TO FULL WITHIN A MATTER OF SECONDS AND CAUSES THE CHECK ENGINE LIGHT TO GO ON WHEN THERE IS PLENTY OF FUEL

DRIVING DOWN A ROAD AT NIGHT AND THE SUNROOF SUDDENLY FLEW OFF THE TOP OF CAR. I HAVE BEEN DRIVING A RENTAL SINCE IT HAPPENS AND HAVE CONTACTED HYUNDAI CORP AND FINALLY RECEIVED A CALL FROM THEM ON FEB TUES 27TH BUT HAVE NOT RESOLVED WHAT THEY ARE GOING TO DO ABOUT THIS WITH ME OR CARSTAR COLLISION CENTER WHERE MY CAR IS SITTING NOW. THE CONSUMER STATED THE SUNROOF WAS REPAIRED UNDER THE RECALL, THE UNDER CARRIAGE HAD NOT. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE RENTAL CAR. *JS

THE FUEL SENSOR/GAUGE READS AS EMPTY ALL THE TIME NO MATTER HOW MUCH GAS IS IN THE TANK, THIS INCLUDES AFTER FILLING UP. THIS CAUSES THE CHECK ENGINE LIGHT TO COME ON AS WELL. ALTHOUGH THIS IS NOT A DIRECT SAFETY ISSUE, AFTER RESEARCHING ON LINE IT IS CLEAR THAT THIS ISSUE HAS BEEN GOING ON FOR SEVERAL MODEL YEARS OF THIS CAR. IF YOU WENT BY THE NUMBER OF COMPLAINTS ON THIS SITE, IT MIGHT NOT LOOK LIKE MUCH BUT AN INTERNET SEARCH WOULD INDICATE OTHERWISE. FOR SOME PEOPLE THIS CAN BE A SAFETY ISSUE DUE TO PROBLEMS WHEN LEGITIMATELY RUNNING OUT OF GAS ON A MAJOR HIGHWAY AND IN TRAFFIC WITHOUT KNOWING THE ISSUE. THE MANUFACTURER SHOULD NOT BE ALLOWED TO HAVE THIS CONSISTENT AND ONGOING PROBLEM WITH NO RECOURSE.

THE GAS ELECTRIC FLOAT DOESN'T WORK IT A 'LL WAYS SHOWS I HAVE NO GAS I HAVE TO FILL EVER 2 DAYS JUST SO I DON'T RUN OUT. BUT HAVE GOTTEN STUCK IN THE SIDE IF THE ROAD 5 TIMES SINCE PROBLEM HAPPENED. HAVEN'T GOTTEN IT FIXED DUE TO MO GET ISSUES FOR IT.

WHEN ATTEMPTING TO ACCELERATE TO MERGE ONTO HIGHWAY, THE CAR IS UNRESPONSIVE TO THE ACCELERATOR PEDAL CAUSING LONG DELAY AND INABILITY TO MERGE PROPERLY. IT IS A THROTTLE SENSOR FAILURE THAT OCCURS RANDOMLY AND FREQUENTLY. CAUSES A DRIVING HAZARD AND I HAVE NARROWLY ESCAPED COLLISION DUE TO ACCELERATOR FAILURE. ONGOING PROBLEM SINCE PURCHASE IN 2008.

TAKATA RECALL MY 2008 HYUNDAI SANTA FE HAS PAINT THAT CHIPPED AWAY ABOVE THE DRIVER SIDE, RIGHT ABOVE THE WINDSHIELD. THE PAINT STILL CONTINUES TO REMOVE ITSELF FROM THE BODY IN CHUNKS. THE ISSUE BEGAN ABOUT A YEAR AGO. AND I DO NOT EXPECT PAINT TO REMOVE ITSELF WITH ANY RUST/ ROCK CHIPS IN THE AREA OF PAINT MISSING. THE SUV HAS 136,800 MILES ON IT, BUT PAINT SHOULD NOT BE COMING OFF IN CHUNKS. I LOOKED ONLINE AND OTHER INDIVIDUALS HAD A SIMILAR ISSUE WITH THEIR HYUNDAI. IT'S NOT JUST A PROBLEM WITH THE SANTA FE. IT'S ALSO SONATA'S, ELANTRA'S AND OTHER HYUNDAI MODELS. THE MISSING PEARL WHITE PAINT NOW SHOWS BARE METAL AND IS NOW SHOWING SIGNS OF SURFACE RUST.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. UPON STARTING THE VEHICLE AND DRIVING AT UNKNOWN SPEEDS, THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (BENTLEY HYUNDAI, 3805 UNIVERSITY DR NW, HUNTSVILLE, AL 35816) WHERE IT WAS DIAGNOSED THAT THE AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 229,000.

WHILE NORMAL DRIVING DOWN A CITY ROAD GOING STRAIGHT THE VEHICLE WILL STALL WITHOUT ANY NOTICE OR ANY CHANGE IN CONDITION. YOU LOOSE ALL POWER, BRAKES AND STEERING WHEN THIS HAPPENS AND HAVE TO BRING IT TO STOP WITH EMERGENCY BRAKE AND PLACE IN PARK. THEN YOU CAN START THE VEHICLE ONCE AGAIN LIKE IT HAS NO ISSUES. THIS ISSUE PRODUCES NO ENGINE TROUBLE CODES AND HAS HAPPENED 3 OTHER TIMES IN THE 6 YEARS WE OWNED THE VEHICLE. THIS IS EXTREMELY DANGEROUS AND WE NEVER KNOW WHEN IT WILL HAPPEN.

FUEL GAUGE AND RANGE TILL EMPTY FLUCTUATE NEVER KNOW HOW MUCH FUEL VERY HUGE SAFETY ISSUE EVERYTIME IT IS DRIVEN OR WHEN FIRST STARTED FILL TANK AND WILL READ ANYTHING FROM EMPTY TO 3/4 TANK VERY SELDOM ON FULL. ALSO CHECK ENGINE LIGHT IS ON CODE SAYS SENDING UNITS SMELL OF FUEL

ON 9/26/2017 AT 3:55 P.M. I WAS INVOLVED IN A SINGLE CAR ROLLOVER ACCIDENT. I WAS TRAVELING ON HWY 97 IN CALIFORNIA AT APPROXIMATELY 55-60 MPH. NO MORE THAN 10 MILES OUTSIDE THE CITY OF WEED. I HIT SOMETHING IN THE ROAD OR BLEW A TIRE. THE CAR FIRST WENT LEFT AND THEN RIGHT. THE BREAKS FELT AS THOUGH THEY LOCKED. WHEN THE CAR HIT AN ASPHALT CURB IT WENT AIRBORNE (THERE WERE NO GUARD RAILS) AND WENT INTO A SMALL EMBANKMENT. THE VEHICLE ROLLED BUT LANDED UPRIGHT. NONE OF THE AIRBAGS DEPLOYED. I ALSO BELIEVE THE SEATBELT DID NOT LOCK AS IT IS SUPPOSED TO WHEN A CRASH OCCURS. I SAY THAT BECAUSE THE RIGHT SIDE MY HEAD HIT THE ROOF OF THE VEHICLE AND I RECEIVED A LARGE HEMATOMA. INITIALLY I THOUGHT IT WAS BECAUSE THE ROOF HAD CAVED IN. WHEN I SAW THE VEHICLE THE NEXT DAY IT WAS THE LEFT SIDE OF THE ROOF THAT HAD CAVED IN. WHAT ALSO MAKES ME BELIEVE THERE IS A SEATBELT ISSUE IS I WAS INVOLVED IN A ROLLOVER IN 1985 AND DID NOT SUFFER ANY HEAD INJURIES AS THE SEAT BELT KEPT ME TIGHTLY IN THE SEAT.

PEELING PAINT ON ROOF GAS TANK DOESN'T REGISTER IF TANK IS EMPTY OR FULL.

2008 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO DESIGN FLAW WITH AIRBAG. *LD THE CONSUMER STATED THE VEHICLE WAS INVOLVED IN AN ACCIDENT CAUSING THE AIRBAGS TO DEPLOY. THE PROPELLANT THE DEPLOYS THE AIRBAG THE CONTAINED A CHEMICAL THAT LEFT THE CONSUMER WITH TWO SECOND DEGREE BURNS ON THE ARM. UPDATED 09/18/2017*JS *JS

THE FUEL GAUGE HAS BECOME ERRATIC. IT GOES TO EMPTY EVEN WHEN FULL. WILL SOMETIMES POP BACK TO PARTIALLY FULL. HAS CAUSED ME TO RUN OUT OF GAS WHEN ON THE HIGHWAY WHEN I THOUGHT I HAD ENOUGH FUEL LEFT. I HAVE FOUND NEARLY 200 SIMILAR COMPLAINTS ON LINE. PROBLEM STARTED AT ABOUT 60,000 MILES AND IS ONGOING.

FUEL GAUGE PROBLEMS. THE FUEL GAUGE GOES UP AND DOWN SPORADICALLY REGARDLESS OF HOW MUCH GAS IS IN THE TANK. YOU CAN'T DETERMINE HOW MUCH GAS IS LEFT WHICH HAS POSED A SAFETY ISSUE LEAVING ME STRANDED IN AN UNSAFE AREA.

A FEW DAYS AGO AFTER STARTING THE IGNITION ON THE COMPUTER PERFORMED ITS NORMAL CHECK, HOWEVER, THE AIR BAG LIGHT REMAINED CONTINUOUSLY ON. THIS CONTINUES TO STAY ON EACH TIME I TURN ON THE CAR. THE AIRBAG LIGHT DOES NOT BLINK, IT REMAINS CONSTANTLY ON. PASSENGER AIRBAG LIGHT WORKS ACCORDING TO THE LIGHT ABOVE THE RADIO; IT INDICATES "OFF" WHEN NO ONE IS SITTING IN THE PASSENGER SEAT AND THE LIGHT TURNS OFF WHEN SOMEONE SITS DOWN. THE HORN DOES WORK, HOWEVER THE BUTTONS ON THE STEERING WHEEL DO NOT WORK. THE BUTTONS ON THE STEERING WHEEL BEGAN TO NOT WORK PRIOR TO THE AIRBAG LIGHT COMING ON. THERE IS A RECALL FOR THE CLOCK SPRING CONTACT ASSEMBLY UNDER NHTSA CAMPAIGN NUMBER: 11V472000. THIS RECALL ONLY INCLUDES SANTA FE'S MANUFACTURED UP TO MARCH 20TH, 2008. MY SANTA FE WAS MANUFACTURED AFTER ON APRIL 24TH, 2008. REQUESTING INVESTIGATION TO EXTEND THIS RECALL DUE TO THERE ARE MULTIPLE COMPLAINTS REGARDING THIS MALFUNCTION ON THE CLOCK SPRING FOR THE SANTA FE ON VEHICLES MADE AFTER THE DATE OF MARCH 20TH, 2008. MULTIPLE COMPLAINTS REGARDING THIS ARE FOUND ON THE NHTSA WEBSITE WITH THIS SAME MALFUNCTION FOR VEHICLES AFTER THE DATE OF THE RECALL.

A WEEK AGO, THE RED LAMP ON MY DASHBOARD FOR AIR BAG BEGAN TO STAY LIT, WHILE DRIVING, PARKED, ANYTIME THE VEHICLE WAS RUNNING. THEN A FEW DAYS AGO, WHILE MY 275 LB SON WAS SITTING IN THE PASSENGER SEAT, THE PASSENGER AIR BAG LIGHT STAYED LIT, SAYING OFF, INDICATING IT WAS NOT WORKING, DESPITE HAVING A PASSENGER IN THE SEAT. BOTH OF THESE HAVE HAD RECALLS, (12V354000) AND 11V472000, BUT I HAVE NOT RECEIVED NOTIFICATION TO HAVE SERVICED. ONE I SUSPECT IS BECAUSE MY VEHICLE WAS MANUFACTURED MARCH 27TH, AND THE RECALLED INCLUDES DATES THOUGH MARCH 21 (2008) BUT IT IS THE SAME PROBLEM, SO MY VEHICLE SHOULD BE REPAIRED WITHOUT COST TO ME. THIS IS A SAFETY CONCERN FOR BOTH DRIVERS AND PASSENGERS IN THIS VEHICLE. I ALSO HAVE A SPECIAL NEEDS SON, WHO CANNOT COMPREHEND SAFETY ISSUES....

THERE HAVE BEEN 3 INSTANCES WHERE AFTER TURNING ON MY VEHICLE, THE POWER IS THROTTLED AND I CAN ONLY DRIVE A COUPLE MILES PER HOUR. I RAN A DIAGNOSTIC SCAN, AND OBTAINED THE CODES P2106, P1295,AND P2135. I SEARCHED ONLINE AND FOUND THIS TO BE A COMMON PROBLEM. THERE APPEARS TO BE A TECHNICAL SERVICE BULLETIN OUT FOR THIS ISSUE (TSB 09-FL003-2). IF THIS IS A COMMON ISSUE, SHOULD THERE BE A RECALL? THANK YOU.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING UNKNOWN SPEEDS, THE DRIVER SIDE AIR BAG INDICATOR ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (PLAZA HYUNDAI LOCATED AT 2740 NOSTRAND AVE STE A BROOKLYN, NY 11210) WHERE IT WAS DIAGNOSED THAT THE DRIVER'S SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: 10473827. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 45,000. ...UPDATED 10/19/17 *BF

I ACTUALLY HAVE 2 ISSUES OCCURRING. ONE OF THESE WAS DEEMED TO HAVE BEEN FIXED BY A PREVIOUS RECALL (CAMPAIGN 105/110 - FIXED /CLOSED JUN 23, 2014). HOWEVER, MY ESC OFF LIGHT AND ABS LIGHT ARE AGAIN LIGHTING UP. I HAVE (LUCKILY) NOT YET HAD LOSS OF ENGINE POWER OR CONTROL. THE SECOND ISSUE IS IN REGARDS TO CAMPAIGN 936. I'VE HAD THE FRONT ENGINE VALVE GASKET COVER FIXED, ALONG WITH MY ALTERNATOR REPLACED (AFTER MY HUSBAND AND I DID IT OURSELVES AFTER LOSING ALL POWER ON CHRISTMAS EVE IN THE MIDDLE OF ROAD BEFORE BARELY COASTING INTO A NEARBY PARKING LOT WHERE WE WERE ABLE TO SORT OF PARK OUT OF THE WAY). WE CHANGED MY OIL THIS WEEKEND, HAVE HAD NO OTHER WORK DONE ON THE CAR SINCE (EXCEPT OIL CHANGES) AND MY HUSBAND NOTICED THAT THE ALTERNATOR IS AGAIN COVERED IN OIL. BETWEEN THE 2 ISSUES, IT IS MOST LIKELY A MATTER OF DAYS (IF I'M LUCKY) BEFORE MY CAR LOSES POWER IN SOME FORM AND I AM POTENTIALLY IN A WRECK WITH MY FAMILY IN THE CAR. I DON'T KNOW HOW MUCH THE DEALERSHIP WANTS TO "RE-FIX" THE FIRST 2 CAMPAIGNS THAT SHOULD HAVE ALREADY BEEN FIXED, BUT FOR JUST THE VALVE GASKET WORK, IT WOULD BE AT LEAST $500, NOT INCLUDING THE ALTERNATOR THAT WILL NEED TO BE REPLACED WHEN THE CAR DOES GO OUT. APPARENTLY THE GASKET THAT IS LEAKING THIS TIME ISN'T THE FRONT ONE, IT IS THE REAR ONE. MY PERSONAL THOUGHTS ON THIS ARE THAT IF THE FRONT ONE IS FAULTY, THEN IT'S NOT A STRETCH TO GET TO THE REAR ONE BEING FAULTY. MY HYUNDAI DEALERSHIP EVEN WARNED ME WHEN REPLACING THE FRONT ONE THAT MY

THE FUEL GAUGE DOES NOT ACCURATELY READ THE AMOUNT OF FUEL IN THE TANK. IT CONSTANTLY MOVES FROM EMPTY TO FULL. THE PROBLEM IS KNOWN TO BE A FAULTY FUEL LEVEL SENSOR. EXPENSIVE TO REPAIR. HYUNDAI SHOULD OWN UP TO THIS PROBLEM AND RECALL AFFECTED VEHICLES. NHTSA WON'T DO ANYTHING ABOUT IT BECAUSE NO ONES GOTTEN KILLED YET DUE TO THIS ISSUE.

OVER THE LAST YEAR, OUR HYUNDAI SANTA FE HAS DEVELOPED A VERY TROUBLING STALLING PROBLEM THAT HAS ONLY INCREASED IN FREQUENCY. THE VEHICLE LOSES POWER WHILE DRIVING REGARDLESS OF SPEED, OFTEN SEVERAL TIMES IN THE SAME TRIP REGARDLESS OF DISTANCE TRAVELED. IT STALLS ON LOCAL, LOW-SPEED ROADS AS WELL AS FREEWAY DRIVING. WHEN IT STALLS, ALL STEERING IS LOST. THIS IS POTENTIALLY DANGEROUS. A SIMPLE GOOGLE SEARCH INDICATES THAT THIS IS A KNOWN ISSUE AMONG HYUNDAI CUSTOMERS AND DEALERSHIPS AND YET I AM NOT ABLE TO LOCATE ANY INFORMATION ABOUT A RECALL TO CORRECT THIS ISSUE. THIS IS A POTENTIALLY FATAL PROBLEM THAT SHOULD BE ADDRESSED BY HYUNDAI. I DID CONTACT THEM. TODAY, I RECEIVED A RESPONSE INDICATING THAT HYUNDAI HAS NO EXPLANATION FOR THE ISSUE AND WILL OFFER NO ASSISTANCE TO REPAIR IT. THEIR ONLY SUGGESTION WAS THAT I CONTACT A LOCAL DEALERSHIP FOR REPAIR. AS I INDICATED, THIS IS A PROBLEM KNOWN TO HYUNDAI, SOME OF THEIR CUSTOMERS AND DEALERSHIPS. SINCE NHTSA IS THE AGENCY OVERSEEING ISSUES OF THIS TYPE, I WOULD RESPECTFULLY REQUEST AN INVESTIGATION INTO THIS STALLING ISSUE BEFORE SOMETHING TRAGIC HAPPENS.

TAKATA RECALL. OVER 200 COMPLAINTS HAVE BEEN FILED WITH HYUNDAI DEALERSHIPS ON THIS DEFECT. FUEL LEVEL SENSORS FAIL AFTER WARRANTY, USUALLY AROURND 80,000 MILLES. FUEL GAUGE LEVELS DROP TO ZERO AND CHECK ENGINE LIGHT COMES ON. EVEN WITH FULL TANK.VEHICLE FAILS INSPECTION AND DEALER CORRECTION IS UP TO $800. SOME VEHICLES HAVE RUN OUT OF FUEL ON THE HIWAY. DEALERS HAVE ACKNOWLEDGED FLAW ENDEMIC TO THIS MODEL.

MY CAR HAS STALLED SEVERAL TIMES THIS PAST WEEK WITHOUT WARNING OR INDICATION THAT ANYTHING IS WRONG. THE VEHICLE WILL SUDDENLY STOP AND LOSE POWER COMPLETELY WHILE I ANXIOUSLY TRY TO RESTART IT. IT HAS PUT ME AT RISK WITH OTHER DRIVERS WHERE I'VE HAD TO PUT MY HAZARDS ON AND HOPE VEHICLES ARE ABLE TO STOP IN TIME SO THEY DON'T HIT ME. I'VE TAKEN IT IN FOR SERVICE AND THEY CAN'T SEEM TO REPLICATE THE PROBLEM. THE CAR IS A SAFETY HAZARD AND NO ONE SEEMS TO BE HELPING ME. I FOUND INFORMATION ONLINE ABOUT HYUNDAI GETTING SLAPPED WITH A CLASS ACTION SUIT FOR THE SAME PROBLEMS I'M REPORTING, BUT THE SUIT APPEARS TO ONLY COVER 2010-2012 MODELS, MINE IS 2008. I DON'T KNOW WHAT TO DO!

HYUNDAI'S SLAVE CYLINDER IS A FAULTY PART KNOWN ABOUT ONLINE AND IN MECHANIC SHOPS. IT HAS FAILED TWICE IN 65,000 MILES AND CAUSED ADDITIONAL DAMAGE. IT RECENTLY FAILED WHILE DRIVING AS THE VEHICLE SLOWED TO TURN AND SHIFTED TO ACCELERATE AGAIN. THE CLUTCH WAS DAMAGED BY THIS PART AND WE HAD A $2,000 BILL. THERE WAS NOTHING WRONG WITH THE CLUTCH PRIOR TO THIS AND THE DEALERSHIP EVEN INFORMED US IT WAS DAMAGED BY THE SLAVE CYLINDER. HYUNDAI DOESN'T CONSIDER THE SLAVE CYLINDER "PART OF THE POWERTRAIN WARRANTY" AND IS DENYING OUR CLAIM FOR REIMBURSEMENT.

1) FUEL TANK GAUGE IS INACCURATE. STARTS TO DROP RAPIDLY AFTER DRIVING 75-100 MILES AND EMPTY FUEL TANK LIGHT COMES ON AFTER ~125-150 MILES. WHEN I REFILL THE TANK, IT IS ONLY HALF EMPTY. NORMALLY, CAR WILL DRIVE 270-320 MILES BEFORE EMPTY. 2) CHECK ENGINE LIGHT COMES ON AND OFF. NOTHING SEEMS TO BE WRONG WITH THE CAR(HAVE HAD IT CHECKED.) 3) ESC LIGHT COMES ON AND OFF; SOMETIMES AT THE SAME TIME AS THE CHECK ENGINE LIGHT, SOMETIMES BY ITSELF. I HAVE HAD IT CHECKED, NO PROBLEM; AND RESET. GOES ON - OFF AGAIN A FEW DAYS LATER. THESE EVENTS HAVE BEEN OCCURRING OVER THE LAST 6 MONTHS, APPROXIMATELY.

I WAS DRIVING AT A LOW SPEED, MAKING A LEFT-HAND TURN WHEN THE CAR LOST ALL POWER. NO BRAKES, NO STEERING. I WAS ABLE TO GET THE CAR INTO A DRIVEWAY. I WAS ABLE TO RESTART . ABOUT 1 HOUR LATER THE SAME THING, ONLY THIS TIME I WAS MAKING A LEFT-HAND TURN ACROSS A VERY BUSY CITY STREET.. I WAS ALMOST HIT BY AN ONCOMING VEHICLE. THIS IS VERY DANGEROUS AND WILL PROBABLY SELL THE CAR & TELL THE NEW OWNERS ABOUT MY ISSUE. I HAVE NOT TAKEN IT TO A GARAGE, AS THE CLOSEST HYUNDAI SHOP TO ME IS AN HOUR AWAY. I DO NOT FEEL SAFE DRIVING THAT FAR.

AFTER TURNING RIGHT TO ENTER AN ON-RAMP FOR THE HIGHWAY, THE TURN SIGNAL (NOW IN NEUTRAL POSITION) STARTING MAKING THE FAST CLICKING NOISE. IN ADDITION, SMOKE STARTED COMING OUT OF THE TURN SIGNAL STICK AND YOU COULD SMELL (WHAT APPEARED TO BE) ELECTRICAL BURNING. THIS CONTINUED FOR 20 MILES UNTIL I GOT HOME AND BEGAN TO RESEARCH IF THIS HAS HAPPENED TO OTHERS (WHICH IT HAS). I AM WORRIED OF A FIRE DANGER ALONG WITH THE ANNOYING NON-STOP NOISE. IS THERE A RECALL ON SOMETHING LIKE THIS IF OTHERS HAVE ALSO REPORTED IT?

FUEL GAUGE IS INCONSISTENT AND KEEPS GOING UP AND DOWN AFTER PUTTING GAS IN. NO IDEA HOW MUCH GAS IS REALLY IN THE TANK.

AFTER EXPERIENCING MY FUEL GAUGE GOING UP AND DOWN MY CHECK ENGINE LIGHT CAME ON. I THEN TOOK IT TO AUTOZONE AND THE CODE SAID IT IS THE FUEL GAUGE SENDING UNIT THAT NEEDS TO BE REPLACED. I'VE READ SEVERAL COMPLAINTS ABOUT THIS SAME ISSUE

FUEL SENSOR DOES NOT WORK WHEN IDLING OR DRIVING! FUEL GAUGE SHOWS EMPTY WHEN FULL. DIGITAL DISPLAY DOES NOT SHOW DISTANCE RANGE. A REAL HAZARD TO NOT KNOW HOW MUCH FUEL IS IN YOUR TANK. THIS IS A BASIC NEED IN AN AUTO OR AN AIRCRAFT. THIS BASIC NEED SHOULD BE THE MANUFACTURER'S RESPONSIBILITY. THE MANY BLOGS AND FORUMS ON THIS ISSUE SHOW REPAIRS OF FROM $300 TO $900 FOR FIXING WHAT SHOULDN'T NEED FIXING. I'D HATE TO HAVE MY WIFE OR DAUGHTER STUCK ON SOME ROAD AFTER RUNNING OUT OF GAS. IF YOU CAN CHECK THE ONLINE FORUMS FOR VALIDATION AND HAVE HYUNDAI RECALL THIS SAFETY ISSUE IT WOULD BE WONDERFUL.

I WAS ON THE HIGH WAY I CHANGED LANES AND WHEN I DID I NEEDED TO ACCELERATE TO CHANGE LANES. AFTER CHANGING LANES I HAD TO HIT THE BREAKS TO SLOW DOWN, THE BREAK SEEMED TO ACT LIKE A GAS PEDAL. THE CAR WOULD NOT SLOW DOWN THE BREAKS WOULD NOT SLOW THE CAR IT ACCELERATED TO 80MPH. I WAS NOT HITTING THE ACCELERATOR BY MISTAKE. THERE WAS NOTHING STUCK UNDER THE PEDALS. I BELIEVE IT WAS THE THROTTLE POSITIONING SENSOR,TPS. I LOOKED THIS UP ON THE INTERNET THERE ARE MANY INSTANCES OF THIS HAPPENING WITH THE SAME MAKE AND MODEL VEHICLE. THIS IS A SERIOUS SAFETY HAZARD I THOUGHT ME AND MY UNBORN CHILD WERE GOING TO DIE. I HAVE YET TO CONTACT MY DEALERSHIP HOWEVER AS FAR AS I AM AWARE THERE ARE NO RECALLS ON THIS VEHICLE. AND THERE SHOULD BE! THE CAR HAS 104800 MILES ROUGHLY. THE CAR ACCELERATED TO 80 MILES PER HOUR ON ITS OWN PRIOR TO THAT I WAS GOING ABOUT 55 MILES PER HOUR. IT ASKED FOR THIS INFORMATION ON THE NEXT PART OF THIS FORM HOWEVER IT WAS NOT ALLOWING ME TO TYPE IT.

TOOK MY CAR TO A TWO MECHANICS WHO BOTH SAID THERE IS A GAS LEAK IN THE EVAPORATOR OF THE EMISSION CONTROL SYSTEM. I READ ONLINE THAT THIS ISSUE IS COMMON WITH SANTA FES AND I BELIEVE THE COMPANY SHOULD ISSUE A RECALL AND GET THIS DANGEROUS ISSUE FIXED.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A WHINING NOISE. ALSO, WHEN THE CONTACT SHIFTED FROM FIRST TO SECOND OR FROM THIRD TO FOURTH GEAR, THE TRANSMISSION SHOOK VIOLENTLY AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE REPAIR, THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 41,432.

WHEN THE VEHICLE IS FILLED UP WITH GAS THE FUEL GAUGE GOES TO ZERO AND THE ENGINE SERVICE LIGHT COMES ON AND THE CODES GENERATED ARE P2067, P0463 AND P0464. AT SOME POINT THE GAUGE BEGINS WORKING PROPERLY AGAIN BUT THE ACCURACY OF THE GAUGE IS IN QUESTION. THERE IS A SAFETY CONCERN SINCE THE VEHICLE COULD RUN OUT OF GAS AT ANY TIME LEAVING THE USER STRANDED IN BAD WEATHER OR IN A DANGEROUS TRAFFIC SITUATION. THIS PROBLEM IS NOT ISOLATED, JUDGING FROM SIMILAR COMPLAINTS ON THE INTERNET, IT APPEARS THAT THE PARTS USED FOR THE FUEL LEVEL INDICATION ARE UNRELIABLE AND A RECALL IS NEEDED TO RESOLVE THIS SAFETY ISSUE. THE PROBLEM OCCURS AT FILL UP AND DRIVING HAS NO EFFECT ON THIS ISSUE AND HAS BEEN HAPPENING TO MY VEHICLE OVER THE LAST COUPLE OF MONTHS BUT SEEMS TO BE GETTING WORSE AS TIME GOES ON. .

ON A TRIP THIS PAST WEEKEND, I EXPERIENCED AN ALARMING SITUATION. I WAS DRIVING 65 MPH ON A HIGHWAY, WHEN THE FUEL GAUGE SUDDENLY REGISTERED EMPTY AFTER MY HAVING FILLED THE TANK ONLY 40 MILES PREVIOUSLY, AND THE CHECK ENGINE LIGHT CAME ON. I IMMEDIATELY EXITED THE HIGHWAY, STOPPED, AND CALLED THE DEALERSHIP AND TALKED TO A MECHANIC, WHO SAID THE LIKELY EXPLANATION WAS A FAULTY FUEL SENSOR. WHILE WE WERE TALKING, THE NEEDLE BEGAN TO RISE AND FALL. WHEN I DETERMINED IT WAS NOT IMMEDIATELY DANGEROUS, I CONTINUED MY TRIP. THE GAUGE EVENTUALLY RETURNED TO NORMAL, BUT THE PROBLEM REAPPEARED THE NEXT TIME I FILLED UP; AGAIN, THE GAUGE EVENTUALLY BEGAN BEHAVING NORMALLY, AND THE CHECK ENGINE LIGHT WENT OUT. THIS MORNING I TOOK THE CAR TO THE DEALERSHIP, AND THEY CONFIRMED THE FAULTY FUEL SENSOR. COST TO REPAIR WAS $612 ' AN OUTRAGEOUS AMOUNT. I DECIDED TO DECLINE THE REPAIR AND JUST TRACK MY NEED FOR GAS FROM THE TRIPOMETER. STILL THIS COULD BE A DANGEROUS SITUATION IF THE GAUGE WERE SHOWING ADEQUATE FUEL BUT THE TANK WAS REALLY EMPTY. HYUNDAI SHOULD ISSUE A RECALL.

WHILE AT A STOP IN A CONSTRUCTION ZONE, MY FOOT WAS ON THE BRAKE, WHEN THE VEHICLE SUDDENLY ACCELERATED INTO THE VEHICLE IN FRONT OF ME. ALTHOUGH MY FOOT WAS PLANTED HARD ON THE BRAKE, THE ENGINE CONTINUED RACING, AND IT FELT LIKE MY CAR WAS GOING TO PUSH HIS CAR DOWN THE STREET! I SHIFTED INTO PARK AND TURNED THE CAR OFF. LUCKILY THERE WAS ONLY $4,000 WORTH OF DAMAGE TO MY CAR, AND NO ONE WAS HURT. I REFUSED TO DRIVE IT, AND HAD IT TOWED TO THE DEALER. THEY SAID THE COMPUTER SHOWED NO MALFUNCTION, AND IT HAD TO BE DRIVER ERROR. THREE MONTHS LATER, IT DID IT AGAIN TO A LESSER DEGREE, IN AN OPEN AREA. I TURNED THE CAR OFF AGAIN, AND IT WAS FINE UNTIL YESTERDAY. IT HAS BEEN 4 MONTHS SINCE THAT LAST INCIDENT, BUT THIS ONE EVEN WAS WORSE THAN THE FIRST. ONLY THING IS, NOW I KNOW TO PUT ALL MY WEIGHT ON THE BRAKE, SHIFT TO NEUTRAL AND TURN THE CAR OFF AS FAST AS I CAN. THIS ONE FRIGHTENED ME SO BADLY, I WILL NOT DRIVE IT AGAIN. IT IS GOING TO SIT AT THE DEALER UNTIL THEY FIND OUT WHAT TO DO. I CANNOT IN GOOD CONSCIENCE DRIVE IT, SELL IT OR EVEN TRADE IT IN UNTIL I KNOW IT IS SAFE! EVERY TIME IT HAPPENED, THE CAR WAS ON A CITY STREET, STATIONARY, AND HEADING STRAIGHT. THE ENGINE REVS UP SO LOUD, IT SOUNDS LIKE AN AIRPLANE! YESTERDAY I COULD TELL THE PEOPLE IN THE CAR STOPPED NEXT TO ME HEARD IT AND LOOKED AT ME! I HAVE OWNED THIS SANTA FE SINCE IT WAS BRAND NEW, AND PEOPLE TELL ME IT LOOKS LIKE A NEW CAR. I KEEP UP WITH THE RECOMMENDED MAINTENANCE AND ALWAYS TAKE IT TO THE DEALER F

WHILE ACCELERATING TO MERGE WITH TRAFFIC THE ENGINE STARTING MAKING A STRANGE NOISE. IT CONTINUED TO RUN AND THE NOISE DECREASED, AND SOMETIMES EVEN QUIT. THE NEXT DAY THE NOISE WAS BACK AND WHILE DRIVING DOWN A HILL THE ENGINE DIED AND MY WIFE WAS ABLE TO COAST ONTO AN EXIT RAMP. I WAS ABLE TO GET IT RESTARTED AND DROVE IT TO THE DEALER. THE DEALER STATED WITH THE KNOCKING SOUND AND THEY FOUND METAL IN THE OIL IT WOULD NEED A NEW ENGINE. I COULD NOT AFFORD THE OVER $7,000 ESTIMATE SO I LOADED THE CAR ON A TRAILER AND TOOK IT HOME TO REPAIR MYSELF. WHEN I DISSEMBLED THE ENGINE I FOUND ONE OF THE CONNECTING ROD BEARINGS HAD SPUN AND ALL THE MAIN BEARINGS HAD SIGNIFICANT DAMAGE CONSISTENT WITH METAL DEBRIS ON THE BEARING SURFACE.

FUEL SENSOR MALFUNCTION

LOW FUEL LIGHT STAYS ON REGARDLESS OF FUEL LEVEL. THIS IS AN ONGOING COMPLAINT ON THIS MODEL AND NEEDS TO BE RECALLED FOR THE SAFETY OF DRIVERS. THE GAUGE HAS BEEN MOVING PERIODICALLY BUT NOW HAS STAYED AT A CONSTANT "EMPTY STATE" WITH THE WARNING LIGHT ON. LUCKILY WE WERE ABLE TO FILL THE TANK. WE NOW ARE GOING TO MOVE IT THE TANK FROM USING G THE TRIP MILES.

FUEL GAUGE PROBLEM: WHEN FILLING THE CAR, THE FUEL GAUGE IN THE CAR WILL SHOW EMPTY, EMPTY LIGHT IS ON DESPITE FILLING THE CAR WITH PLENTY OF GAS. ADDITIONALLY, IN 2009 MY CAR STOPPED SUDDENLY WHILE WE WERE ON A BRIDGE IN 4 LANES OF TRAFFIC. THE FUEL TANK HAD TO BE PULLED AND REPLACED. NOW, WHEN I'M DRIVING(KNOWING THAT I HAVE ENOUGH FUEL TO CONTINUE) THE FUEL GAUGE IS NOT REGISTERING PROPERLY AND WILL 'WAG' BETWEEN FULL AND EMPTY. DANGEROUS!

THE FUEL GAUGE DOES NOT READ CORRECTLY UNLESS THE TANK IS 100% FULL. EVEN THEN IT OCCASIONALLY WILL READ INCORRECTLY. WHEN FILLING THE TANK IT OCCASIONALLY SHUTS OFF AS IF FULL DESPITE NOT BEING FULL. THIS IS A MAJOR ISSUE BECAUSE IT IS IMPOSSIBLE TO TELL HOW MUCH GAS IS IN THE TANK AT ANY GIVEN TIME WHICH IS A SAFETY CONCERN WHEN DRIVING LONG DISTANCES.