2004 Hyundai Santa FE complaints

STOPPED AT INTERSECTION, WITH MY FOOT ON THE BREAK, THE SUV LURCHES FORWARD AND JERKS. I PLACED IT IN PARK WHILE WAITING FOR THE LIGHT TO CHANGE. I WAS CONCERNED THAT I WOULD HIT THE CAR IN FRONT OF ME. I DROVE 2 HOURS AND NOTICED CONTINUED MISFIRING AND JERKING WHILE DRIVING. IT WAS OK WHEN THE ENGINE WAS COOL, BUT FELT UNSTEADY WHEN UP TO TEMP. AFTER BEING PARKED IN GROCERY PARKING LOT, WHILE BACKING UP THE CAR STALLED, I RESTARTED AND DROVE HOME. TOOK IT TO MECHANICS NEXT DAY. AT THE HYUNDAI DEALER NOW. THEY COULD NOT GET ANY CODES AND THE ENGINE FAILURE LIGHT NEVER SHOWED. THE MECHANIC, SAID THAT HE WAS 90% SURE THAT REPLACING THE TIMING BELT/CRANK SHAFT POSITION SENSOR/BALANCER SHAFT BELT/PICK UP PLATE WOULD CORRECT THE PROBLEM...THIS DIDN'T WORK AND THE DEALER ASKED TO KEEP IT A 5TH NIGHT. I HAVE NOT HEARD FROM THEM AS OF YET. I'M CONCERNED THAT MY CAR WILL NOT BE REPAIRED AND AM AFRAID TO DRIVE IT. *JS

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE COIL SPRING BROKE AND PUNCTURED THE TIRE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 104,000.

MY AIR BAGS LIGHT IS ALWAYS ON AND WILL NOT TURN OFF. THE SUSPENSION IS HORRIBLE, I TOOK IT TO A MECHANIC AND HE SAID" THERE WAS NOTHING HE COULD DO. AND SOMETIMES WHEN I TURN MY VEHICLE ON THE ENGINE REVELS UP AND SOUNDS AS IF THE ACCELERATION IS STUCK. SCARES ME TO DEATH. *TR

WHEN I PURCHASED THE CAR AS THE SECOND OWNER IN MARCH 2010, I NOTICED THAT THE AIRBAG LIGHT HAD BEEN A PROBLEM FROM THE PREVIOUS OWNER. HOWEVER, THE DEALER ASSURED ME THAT IT WAS FIXED. AFTER PURCHASING THE VEHICLE IN 2010 AND BEFORE I TOOK OWNERSHIP I HAD TO LEAVE IT WITH THE DEALER AS THE AIRBAG AND SEAT BELT LIGHTS WERE ON. I HAVE TAKEN THE VEHICLE BACK TO THE DEALER AT LEAST THREE TO FOUR TIMES FOR THE SAME PROBLEMS, HOWEVER WAS TOLD THAT THERE WERE DIFFERENT CODES EACH TIME. WAS TOLD THAT I NEEDED TO REPLACE THE SEAT BELT BUCKLE IN ORDER CORRECT THE AIRBAG LIGHT, HOWEVER, AS OF 4/3/12 WAS TOLD BY DEALERSHIP (HERB CONNOLLY HYUNDAI) THAT IN NEED TO REPLACE THE AIRBAG. ALSO THAT THE AIRBAG WAS NOT UNDER WARRANTY AND IT USUALLY HAS TO BE REPLACED AT 60K MILES. WHEN I PURCHASED MY VEHICLE IT HAD 81K MILES, GIVEN THIS FACT, THEY SHOULD HAVE REPLACED THE AIRBAG PRIOR TO ME PURCHASING IT. THE CODE THAT IS SHOWING NOW IS B1346 (AIRBAG HAS HIGH RESISTANCE). DEALER REFUSE TO CORRECT THE PROBLEM AT NO COST AFTER SEVERAL ATTEMPTS TO GET THE PROBLEM RESOLVED. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 5 MPH IN REVERSE, THE VEHICLE ABNORMALLY ACCELERATED. THE FAILURE RECURRED THREE SEPARATE TIMES. AS A RESULT OF THE FAILURE, THE CONTACT WAS INVOLVED IN A CRASH WHILE IN REVERSE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 110,000.

I BEGAN BACKING OUT OF MY DRIVEWAY WHEN I HEARD A CRUNCHING TYPE SOUND, AND THEN IT STOPPED BRIEFLY. I CONTINUED TO BACK UP AND THE SOUND HAPPENED AGAIN FOLLOWED BY A LOUD NOISE AND AIR GUSHING OUT OF MY PASSENGER SIDE FRONT WHEEL. THE TIRE WENT COMPLETELY FLAT. ONCE THE TIRE WAS REMOVED WE DISCOVERED THE COIL SPRING HAD BROKEN AND SLICED THE TIRE ALL THE WAY AROUND. IT APPEARS FROM MY RESEARCH THAT THIS IS A COMMON PROBLEM. LUCKILY I WAS NOT DRIVING DOWN THE ROAD WITH MY SMALL CHILDREN IN THE CAR. *TR

SO MANY THINGS GOING WRONG BACK SEAT BELTS DON'T WORK, WASHER PUMP DON'T WORK TRIED TO ORDER PART FROM DEALER DO NOT HAVE ANY IN US THE CAMSHAFT SENSOR PIGTAIL DISINTEGRATED FROM BEING TO CLOSE TO THE ENGINE AND NO ONE SELLS THE PART HAVE TO BUY THE COMPLETE ENGINE WIRING KIT FOR ONE LITTLE PLASTIC PIECE THERE SHOULD BE A RECALL ON THIS I READ ONLINE THAT EVERYONE WITH THIS CAR HAD THE SAME PROBLEMS. *TR

WAS HAVING WINTER TIRES PUT ON MY CAR WHEN MEHANIC SAID HAD A GAS TANK LEAK...HE SAID IT WAS THE 5TH CAR OF HYUNDAI WITH THE SAME PROBLEM THAT HE SAW...SAID HE NEVER SAW A CAR THIS YOUNG (7YRS) WITH THIS PROBLEM...AM A SINGLE MOTHER WITH THIS CAR..I HAVE HAD NO OTHER PROBLEMS..I SMELL GASOLINE WHEN I WALK AROUND THIS CAR AND WHEN I ENTER MY CAR...PLEASE TELL ME THERE IS HELP...I DO NOT HAVE MONEY AND I DO NOT FEEL SAFE..PLEASE HELP ME. *TT

CAR WAS IS GARAGE. WENT TO BACK OUT AND HAD BARELY MOVED AN INCH IN REVERSE WHEN I HEARD A POP AND A WHOOSHING NOISE OF THE FRONT LEFT TIRE DEFLATING. CAR WAS THEN SLANTED/LOPSIDED TO THE LEFT BECAUSE THE TIRE WAS SO DEFLATED. TRIED TO REMOVE TIRE AND COULDN'T GET IT OFF. DISCOVERED THAT THE FRONT LEFT COIL SPRING HAD SNAPPED OFF AND IT WAS LODGED IN THE TIRE. THE SHARP JAGGED END OF THE SPRING IS WHAT POPPED THE TIRE. LUCKY I WASN'T DRIVING WHEN THIS HAPPENED! *TR

I ARRIVED AT WORK AND TWO PEOPLE MENTIONED THAT THEY SMELLED GASOLINE UPON WALKING BEHIND MY CAR..NEVER THOUGHT ABOUT IT UNTIL I NOTICED TWO DAYS LATER THAT I SEEMED TO BE GOING THROUGH ALOT OF GAS..I DRIVE 6 MILES FROM MY HOME TO WORK EVERY DAY...I NOW SMELL GAS IN THE DRIVER SIDE REAR EVERY DAY..WAS TOLD TO CHECK IF THERE WAS A RECALL ON MY TANK OR FUEL LINE...DO NOT KNOW WHO TO CHECK WITH INREGARDS TO THIS PROBLEM..AM A SINGLE MOTHER OF TWO BOYS SO I WOULD LIKE TO GET THIS FIXED..ANY HELP WOULD BE GREATLY APPRECIATED. *TR

UNINITIATED ACCELERATION WHILE DRIVING, TRYING TO STOP AND IDLING. *TR

ON 9/13/2011, IN SAN JUAN, PR, AT APPROXIMATELY 4:00 P.M., MY MOTHER (74 YEARS OLD) WAS DRIVING HER 2004 HYUNDAI SANTA FE AT A VERY SLOW RATE OF SPEED ON A WET CONCRETE ROAD. WHILE APPROACHING A RED LIGHT, AND WHILE STILL FAR AWAY FROM IT, SHE APPLIED HER VEHICLE'S BRAKES WITH NO AVAIL. THE VEHICLE CONTINUE MOVING FORWARD AND STOP ONLY AFTER HITTING A CAR WAITING FOR THE LIGHT TO CHANGE GREEN. THAT IMPACT CAUSED THIS VEHICLE (V-1) TO MOVE FORWARD AND HIT ANOTHER VEHICLE (V-2) WHICH WAS ALSO WAITING FOR THE LIGHT TO CHANGED. MY MOTHER RECEIVED A HEAVY IMPACT FORCE TO HER CHEST, SHOULDERS, AND NECK AREA PRODUCED NOT ONLY BY IMPACTING THE VEHICLES IN FRONT OF HER BUT ALSO BECAUSE HER VEHICLE'S AIR BAGS WERE DEPLOYED. HER SANTA FE WAS ALSO BADLY DAMAGED. *TR

WHILE SITTING IN TRAFFIC AT A LOCAL GAS STATION, MY 2004 HYUNDAI SANTA FE SURGED TO THE POINT WHERE I COULD BARELY CONTROL THE VEHICLE FROM CRASHING INTO THE CAR IN FRONT OF ME. I IMMEDIATELY PLACED THE CAR IN NEUTRAL AND THE ENGINE SPEED SURGED TO NEARLY 6000 RPM. I TURNED THE VEHICLE OFF. THE CAR WAS ABLE TO BE STARTED AGAIN WITHOUT INCIDENT. THERE WAS NO COLLISION, BUT IT WAS A VERY SCARY AND UNCONTROLLED MANNER FOR THE VEHICLE TO BE OPERATED IN. *TT

TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. WHILE DRIVING AT LOW SPEEDS, THE CONTACT STATED THAT THE POWER STEERING WOULD DEACTIVATE. THE DEALER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE. UPDATED 08/31/11 *BF UPDATED 2/21/12 *CN

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED WHILE APPLYING THE BRAKES BETWEEN 3 AND 12 MPH THE BRAKE PEDAL BEGAN TO VIBRATE AND THE ABS LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE MANUFACTURER ADVISED THE CONTACT THAT HER VEHICLE WAS NOT A PART OF NHTSA RECALL CAMPAIGN ID NUMBER: 04V131000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE). THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE WAS 67,268.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT NOTICED THAT THE STRIKER PLATE THAT CONNECTS TO THE TAPING PLATE WAS NOT PROPERLY WELDED ONTO THE DOOR FRAME; AS A RESULT, THE LEFT REAR PASSENGER DOOR WOULD NOT REMAIN CLOSED. THE DEALER ADVISED THE CONTACT THAT SINCE HER VEHICLE WAS NO LONGER UNDER WARRANTY THAT SHE WAS RESPONSIBLE FOR THE REPAIRS. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 100,289. THE APPROXIMATE FAILURE MILEAGE WAS 97,580.

5/25/2011, APPROX. TIME 8:45 A.M. 2004 SANTA FE LX, 38,828 MILES ON VEHICLE. ORIGINAL OWNERS, BOUGHT NEW. VEHICLE WAS SITTING IN OUR DRIVEWAY, GOT IN TO LEAVE FOR DOCTORS APPT., MOVED ABOUT TWO FEET, WHEN WE HEARD THIS LOUD NOISE AND AIR GUSHING SOUND FROM THE RIGHT FRONT OF OUR CAR. WENT OUT TO INVESTIGATE AND FOUND THE COIL SPRING HAD RUPTURED AND CUT THROUGH THE SIDEWALL OF THE TIRE. THANK GOD WE WERE NOT TRAVELING ON ANY ROAD OR INTERSTATE HWY., I WOULD NOT BE TELLING THIS. HYUNDAI MOTORS OF AMERICA, CORPORATE OFFICE WAS NOTIFIED OF MY ISSUE, AND THE FACT THE LEFT SPRING COULD RUPTURE AT ANY TIME. THEY OFFERED IN GOOD FAITH TO PAY FOR RIGHT SPRING AND TIRE, BUT WOULD NOT REPLACE LEFT FRONT SPRING. HYUNDAI MOTORS OF AMERICA SHOULD BE RESPONSIBLE FOR THESE DEFECTED COIL SPRINGS AND RECALL ALL 2004 SANTA FE TO REPLACE FRONT COIL SPRINGS AND ANY OTHER MECHANICAL SYSTEMS THAT WERE AFFECTED BY THE RUPTURED COIL SPRINGS. MANY OWNERS OF 2004 SANTA FE ARE NOT AWARE OF THIS ISSUE, HOPEFULLY HYUNDAI WILL TAKE FULL RESPONSIBILITY BEFORE THEIR ARE ANY FATALITIES, GOD BLESS US, AND I PRAY HE WILL KEEP US SAFE!!!!! *TR

TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE DRIVER WAS INFORMED BY SOMEONE DRIVING NEARBY THAT THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS MANEUVERED ONTO THE EMERGENCY LANE AND TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE FUEL PUMP ASSEMBLY HAD FRACTURED AND WAS LEAKING FUEL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 60,000.

WHILE DRIVING ON A STRAIGHT, SMOOTH SECTION OF INTERSTATE HIGHWAY MY WIFE AND I HEARD A VERY LOUD BOOM, AS IF WE HAD HIT A LARGE ROCK OR SOMETHING. THERE WAS NO VIBRATION THAT AN IMPACT WOULD HAVE CAUSED. WE DIDN'T KNOW WHAT HAD CAUSED THE NOISE. 2004 HYUNDAI, SANTA FE DROVE FINE. TWO DAYS LATER, WHEN MAKING A LOW SPEED RIGHT TURN, THE RIGHT FRONT TIRE BLEW OUT. WHEN THE TIRE WAS REMOVED IT WAS DISCOVERED THAT THE COIL SPRING HAD BROKEN, MADE CONTACT WITH THE TIRE AND RIPPED IT ABOUT THREE QUARTERS AROUND COMPLETELY THROUGH. AFTER RESEARCHING THE TOPIC I WAS APPALLED AT HOW MANY COMPLAINTS THERE WERE ABOUT BROKEN SPRINGS ON 2004 SANTA FES. IT SEEMS TO BE A RECURRENT PROBLEM WITH THIS VEHICLE AND SHOULD BE RECALLED. IF THE SPRING HAD RUPTURED THE TIRE WHEN IT APPARENTLY BROKE, ON THE HIGHWAY I HESITATE TO THINK WHAT WOULD HAVE HAPPENED, OR HOW MANY LIVES WOULD BE AT RISK. I BELIEVE IT IS TIME HYUNDAI STEPPED-UP AND RECALL THE SPRINGS. *TR

2004 HYUNDAI SANTA FE. CONSUMER STATES WHILE PULLING OUT OF THE DRIVEWAY, THE DRIVERS SIDE FRONT COIL SPRING BROKE, POKING A HOLE THROUGH THE SIDEWALL OF AN 8 MONTH OLD TIRE *TGW

ON APRIL 21, 2011 WENT TO BACK SUV OUT OF MY DRIVEWAY WHEN THE FRONT LEFT TIRE WENT FLAT. AFTER REMOVING THE TIRE FOUND TIRE HAD A HOLE ON INSIDE WALL OF TIRE . THIS WAS CAUSED BY THE COIL SPRING PROTRUDING OUT. UPON FURTHER INSPECTION FOUND THE COIL SPRING BROKEN. THE CAR HAD TO BE TOWED TO A REPAIR SHOP. I FEEL VERY LUCKY THIS DID NOT HAPPEN WHILE DRIVING AT A HIGH RATE OF SPEED. *TR

I WAS TRAVELING DOWN THE HIGHWAY AT 70MPH WHEN, ALL OF A SUDDEN, I HEARD A BANG AND THE CAR VEERED OUT OF CONTROL. IT WAS A TERRIFYING EXPERIENCE. I REGAINED CONTROL OF THE CAR I WAS ABLE TO SAFELY PULL TO THE SIDE OF THE ROAD TO INVESTIGATE AND I NOTICED THAT THE COIL SPRING BROKE. THE FOLLOWING DAY I BROUGHT MY VEHICLE TO THE HYUNDAI DEALER AND THEY CHARGED AN OUTRAGEOUS AMOUNT TO REPLACE. NOT VERY LIKELY THAT I WOULD PURCHASE ANOTHER HYUNDAI. *TR

THE DRIVER'S SIDE COIL SPRING BROKE ON MY 2004 HYUNDAI SANTA FE AT 40,000 MILES. I WAS DRIVING DOWN A STREET AND THERE WAS A LOUD EXPLOSION TYPE SOUND, MY VEHICLE ACTUALLY FELT LIKE IT JUMPED, ALL THE DASH LIGHTS CAME ON AND THE ENGINE DIED. I WRESTLED WITH THE WHEEL TO GET THE CAR OVER TO THE SIDE OF THE ROAD BUT I WAS STILL IN THE ROAD. THERE WAS A WOMAN IN FRONT OF ME GETTING OUT OF HER CAR WITH A TODDLER AND I CAME CLOSE TO HITTING THEM AS I TRIED TO CONTROL MY TRUCK. I'M SO GLAD I WASN'T GOING FASTER THAN 10-15 MPH. THE REPAIR AGENT SAID HE'D NEVER SEEN THIS HAPPEN AT LESS THAN 100K+ MILES, AND IT TOOK OUT THE BRAKE LINE AND FUEL LINE ON THAT SIDE AS WELL. TOTAL COST WILL BE $1500. AS THE TIMING BELT ALSO NEEDS CHANGING. NOT HAPPY. I SEE MANY OTHER COMPLAINTS OF THIS SITUATION (COIL SPRING GOING ON HYUNDAI SANTA FE AT LOW MILEAGE), BUT I DON'T SEE ANY KIND OF REPARATION OFFERED BY THE COMPANY OR ANY RECALL. THERE SHOULD BE - THIS IS NOT ACCEPTABLE. I'M NOT LIKELY TO BUY A HYUNDAI AGAIN. *TRW

I PARKED MY VEHICLE IN A PARKING LOT AT 8AM AND THEN BY 1PM MY COIL SPRING BROKE DESTROYING MY TIRE AND RESULTING IN MY GETTING TOWED. HAD MY COIL SPRING BROKE ON THE HIGHWAY I WOULD HAVE CRASHED *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THE VEHICLE WOULD NOT START. THE CONTACT WOULD WAIT FOR SEVERAL MINUTES BEFORE BEING ABLE TO RESTART THE VEHICLE. THE DEALER WAS CONTACTED AND ADVISED THAT THE PROBLEM COULD BE CAUSE BY THE EMISSION SYSTEM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE FAILURE MILEAGE WAS 85,500.

2004 HYUNDAI SANTA FE HAS SUDDEN ACCELERATION AND SURGING NO TROUBLE LIGHTS ON. DEALERSHIP TOLD ME THE THROTTLE SENSOR HAD TO BE REPLACED, SO WE DID THAT. ABOUT A MONTH LATER, SAME THING HAPPENED. DEALERSHIP REPLACED THROTTLE SENSOR AGAIN, AT NO CHARGE. SAID IF IT HAPPENS AGAIN WE WOULD NEED A NEW THROTTLE BODY. HAPPENED AGAIN, SO HAD THE THROTTLE BODY REPLACED. HAPPENED AGAIN AND WAS TOLD IT WAS WIRING THAT HAD TO DO WITH CRUISE CONTROL. WHICH I NEVER USE. HAPPENED AGAIN TODAY 3/16/2011. NOTIFIED THE DEALERSHIP THAT I WAS DROPPING OFF TONIGHT IN THE NIGHT DROP. I HAVE ALREADY PAID OVER $1000.00 FOR SOMETHING THAT HAS NOT BEEN FIXED. WE WILL SEE WHAT HAPPENS TOMORROW. WE MAXED OUT OUR TOWING WITH AAA, SO MY HUSBAND, WHO WORKS SECOND SHIFT AND HOUR AND HALF AWAY FROM WHERE WE LIVE HAS TO DRIVE IT BACK TO THE DEALERSHIP TONIGHT. IT STARTED TODAY WHEN HE WAS ABOUT 15 MINUTES AWAY FROM WORK. ALSO THIS IS OUR ONLY CAR, AND DEALERSHIP ALWAYS SAYS THEIR LOANER CARS ARE ALL OUT. JUST WANTED THIS DOCUMENTED AND AM PRAYING MY HUSBAND GETS BACK TO THE DEALERSHIP OK. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLES WERE DESIGNED AS CHROME OVER PLASTIC AND THE CHROME FRACTURED.. THE FAILURE WAS CAUSING THE EDGES TO BE EXPOSED, WHICH WERE EXTREMELY SHARP. WHEN THE CONTACT'S ATTEMPTED TO EXIT THE VEHICLE SHE CUT HER HAND WHEN SHE GRABBED THE DOOR HANDLE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR INSPECTION OR REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 52,000. UPDATED 05/03/11*LJ THE CONSUMER STATED THE DOOR HANDLES WERE DESIGNED AS CHROME OVER A NON-METALLIC SUBSTRATE. OVER TIME, THE CHROME CRACKED AND CURLED UP, THUS FORMING RAZOR SHARP EDGES WHICH COULD NOT BE OBSERVED WHEN THE HANDLE WAS IN ITS NORMAL POSITION. UPDATED 05.11.11

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE STALLED AS SOON AS IT WAS STARTED. SHE WAS ABLE TO RESTART THE VEHICLE THE FOLLOWING DAY YET THE VEHICLE ABNORMALLY ACCELERATED WITH AN UNUSUAL INCREASE IN ENGINE RPM AS SHE DEPRESSED THE BRAKES. THE VEHICLE WOULD NOT STOP AND SHE THEN SHIFTED INTO NEUTRAL AND SHUT THE VEHICLE OFF. THE VEHICLE WAS TOWED TO THE DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED. THE FAILURE WAS LOCATED AT THE THROTTLE BODY ASSEMBLY WHICH THE CONTACT WAS ADVISED TO HAVE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 76,000.

WAS JUST PULLING THE CAR DOWN THE DRIVE WAY AND THE FRONT PASSENGER SIDE TIRE BLEW OUT. I STOPPED THE CAR AND A FRIEND WAS GOING TO CHANGE THE TIRE. HE NOTICED THE SPRING HAD BROKEN LOOSE AND PUNCTURED THE TIRE. THE CAR HAD BEEN SITTING IN THE DRIVE WAY FOR 12 TO 15 HOURS BEFORE WE WENT TO DRIVE IT. WE HAD NOT EVEN MADE IT ON THE ROAD AND WAS ONLY GOING A COUPLE MILES PER HOUR AND ABOUT 15 TO 20 FEET. WE WERE ON OUR WAY, GOING OUT OF TOWN AND WERE THANKFUL THAT WE DID NOT HAVE THIS HAPPEN GOING 65 MPH ON THE HIGHWAY WERE WE COULD HAVE BEEN HURT OR HURT SOME ONE ELSE. SEVERAL TIMES A WEEK WE HAVE A NEW BORN AND A TWO YEAR OLD IN THIS VEHICLE. THANKFULLY THEY WERE NOT WITH US. THIS FRONT END SUSPENSION PROBLEM NEEDS TO BE LOOKED AT, SOMEBODY IS NOT GOING TO BE AS LUCKY AS WE WERE. FOR US IT WAS THE DRIVE WAY AND NOT DRIVING ON THE HIGH WAY AT A HIGH SPEEDS WITH OUR FAMILY. *TR

DRIVERS SIDE COIL SPRING BROKEN. STRUT MOUNT ALSO NEEDED TO BE REPLACED. I BOUGHT THIS CAR NEW IN 2004. AS THE MILEAGE WILL TELL YOU, I DON'T DRIVE IT MUCH. MY CAR HAD BEEN SITTING IN THE DRIVEWAY FOR A COUPLE OF DAYS WHEN I WENT TO GO TO WORK. AS I STARTED BACKING OUT OF THE DRIVEWAY I HEARD A VERY LOUD NOISE WHEN I TURNED THE WHEEL. I DECIDED NOT TO TRY DRIVING IT. MY HUSBAND TOOK IT TO THE DEALER AND THEY FOUND THE SPRING BROKEN. THEY SAID I WAS NO LONGER UNDER WARRANTY. FORTUNATELY, I WAS NOT DRIVING IT AT THE TIME AS IT COULD HAVE PUNCTURED THE TIRE AND CAUSED A BLOWOUT. SINCE THIS INCIDENT, IT HAS HAPPENED AGAIN, ON THE PASSENGER SIDE. THIS TIME IT HAD BEEN SITTING FOR ABOUT 4 DAYS IN THE DRIVEWAY AND WHEN I WENT TO BACK OUT, I HEARD IT. WE IMMEDIATELY TOOK IT TO A NEARBY GARAGE AND FOUND THE SPRING HAD BROKEN AND WAS RUBBING ON THE TIRE. THIS TIME THE MILEAGE WAS ABOUT 25,000 MILES. HYUNDAI DOES NOT SEEM TO THINK THERE IS A PROBLEM WITH THESE SPRINGS. I THINK IT NEEDS TO BE LOOKED INTO BEFORE SOMEONE GETS KILLED. I DON'T KNOW IF IT IS PERTAINING TO THIS COMPLAINT, BUT I DO WANT TO MENTION THAT AT 27,000 MILES I ALSO HAD TO REPLACE BOTH REAR CONTROL ARMS. THERE SEEMS TO BE A REAL PROBLEM WITH THE SUSPENSION SYSTEM ON THE VEHICLE. PLEASE LOOK INTO IT.

I TRIED TO START MY 2004 SANTA FE BUT THE ENGINE WOULD NOT TURN OVER (IT CRANKED FINE SO WE KNEW IT WAS NOT THE BATTERY). WHILE IT WAS BEING DRAGGED ONTO THE TOW TRUCK THE DRIVER'S SIDE FRONT TIRE DEFLATED. THE WHEEL DID NOT TURN WHILE BEING DRAGGED UP THE TRUCK RAMP. THE REPAIR SHOP SAID THAT THE FRONT SPRING HAD SNAPPED AND TRIGGERED A KILL SWITCH TO THE FUEL LINE WHICH PREVENTED THE CAR FROM STARTING. I NEVER HEARD ANY AWFUL SOUNDS WHILE DRIVING SO THE THE FRONT DRIVER'S SIDE COIL SPRING MUST HAVE SNAPPED WHILE PARKED IN THE DRIVEWAY. THE SPRING NEEDS TO BE REPLACED, AS DOES THE TIRE. *TR

I WENT INTO GARAGE TO MOVE MY 2004 HYUNDAI SANTA FE OUT SO MY HUSBAND COULD PUT OUR 2009 HYUNDAI SONATA INTO IT. THE SANTA FE HAD BEEN SITTING IN THE GARAGE FOR ABOUT 4 DAYS UNDRIVEN. WHEN I STARTED TO BACK UP, IT WAS MAKING A LOUD NOISE. I GOT OUT OF THE VEHICLE TO MAKE SURE THERE WAS NOTHING IN THE WAY. NOT SEEING ANYTHING IN MY WAY, I CONTINUED TO BACK THE SANTA FE OUT TO THE STREET STILL HEARING A LOUD NOISE. MY HUSBAND CAME OVER TO SEE WHAT WAS MAKING THE NOISE AND NOTICED THAT THE WHOLE FRONT PASSENGER SIDE FENDER WAS RESTING ON THE TIRE. UPON RAISING IT WITH THE JACK, HE NOTICED THAT THE FRONT PASSENGER SUSPENSION COIL WAS BROKEN. I EVEN TOOK PICTURES OF IT WHILE IT WAS JACKED UP. THE UPSIDE TO THIS WHOLE THING IS THAT WE WEREN'T DRIVING IT AT A HIGH SPEED WHEN THIS HAPPENED. I'M SURE WE WOULD HAVE FLIPPED THE VEHICLE AND BEEN SERIOUSLY INJURED OR EVEN KILLED. WE HAVE 84,647 MILES ON IT AND WERE ALWAYS VERY METICULOUS WITH MAINTENANCE. WE WILL CALL THE DEALERSHIP TOMORROW, BUT FROM WHAT I CAN SEE, IT LOOKS LIKE AN EXPENSIVE REPAIR. *TR

I HAVE A 2004 SANTA FE AND JUST THE OTHER DAY MY DRIVER SIDE COIL SPRING BROKE, LUCKY I WASN'T DRIVING IT AT THE TIME HOWEVER IT GOING TO COST ABOUT 1250.00 TO FIX. *TR

FAILURE OF FRONT COIL SPRING WHILE DRIVING. COIL SPRING SUDDENLY BROKE AND PUNCTURED TIRE. *TR

AT 84,360 MILES OUR SUV WASN'T SHIFTING INTO 2ND GEAR, WOULD GO FROM 1ST TO 3RD. A BIG KLUNK WOULD OCCUR AROUND 20 MPH. TOOK INTO DEALERSHIP (WITHNELL HYUNDAI, SALEM, OR) IN JUNE 08, AND THEY RESET THE COMPUTER. HUSBAND ARGUED WITH SERVICE DEPT., SAYING HE WANTED A NEW TRANSMISSION, GUY SAID IF IT WENT BAD AGAIN THAT WOULD PROBABLY HAPPEN, AND HE SAID IF IT WENT BAD, WOULD GO BAD BY 100000 MILES. TOOK SUV BACK IN 8-2010 WITH 99960 MILES, WAS SHIFTING HARD AGAIN, WAS TOLD IT WAS THE REAR MOTOR MOUNT, AND THEY REPLACED THAT. THEN AT 105000 MILES JAN. 2011, SHIFTING HARD AGAIN, TOOK BACK TO DEALERSHIP THEY AGAIN RESET THE COMPUTER..AT NO CHARGE TO US, AND TOLD US "TRANSMISSION WAS FAILING".

I TOOK MY CAR INTO MY NEW LOCAL DEALER WALLACE HYUNDAI , STUART FL. MY AIR BAG LIGHT STARTED STAYING ON ALL THE TIME. AT THE TIME I BROUGHT IT IN, MY VEHICLE WAS STILL COVERED UNDER THE BUMPER TO BUMPER WARRANTY. THIS DEALER TOLD ME I HAD TO PAY $100.00 TO INSPECT THE VEHICLE FOR THE ISSUE. I HAVE NEVER IN THE LIFE OF OWNING 2 HYUNDAI SANTE FE'S (THIS BEING MY 2ND) DID I EVER HAVE TO PAY UP FRONT FOR BUMPER TO BUMPER ISSUES. I AM DISABLED AND DID NOT HAVE THE $100.00 SO I LEFT AND THEN THE WARRANTY RAN OUT, SO MY ISSUE HAS NEVER BEEN TAKEN CARE OF. TO THIS DAY, MY AIRBAG LIGHT IS STILL ON AND I AM CONCERNED IT WILL EITHER DEPLOY OR NOT DEPLOY AT ALL IN AN ACCIDENT. UPDATED 03/23/11

PASSANGER SIDE SPRING SEPERATED CAUSING TIRE DAMAGE. *TR

I DRIVE A USED, 2004 HYUNDAI SANTA FE GLS. VERY RECENTLY, I WAS JUST LEAVING WORK WHEN A SEEMINGLY VERY ORDINARY THING HAPPENED TO MY CAR. I WAS STOPPED AT A STOP SIGN, WAITING TO TAKE A LEFT TURN. AS SOON AS I ACCELERATED AND BEGAN TO TURN, MY VEHICLE SUFFERED A BLOWN-OUT FRONT-PASSENGER SIDE TIRE. AS THE TIRE BLEW OUT, I HEARD A LOUD "CLUNK"AND THEN A "POP". SURPRISED, I PULLED THE CAR OVER AS SOON AS I COULD, OFF OF THE MAIN ROAD. I HAD ROADSIDE ASSISTANCE COME OUT TO CHANGE THE TIRE, BECAUSE I FOUND THAT I DID NOT HAVE THE TOOLS REQUIRED IN MY CAR TO CHANGE A TIRE. AFTER THE TOW TRUCK DRIVER PUT ON THE SPARE, I PAID HIM FOR HIS SERVICES AND WENT TO LEAVE. AS I TURNED THE WHEEL TO LEAVE, MY VEHICLE SUFFERED ANOTHER BLOW-OUT, SAME SIDE. MY CAR THEN HAD TO BE TOWED TO THE NEAREST SHOP TO BE LOOKED AT. TURNS OUT, MY FRONT-RIGHT COIL SPRING SNAPPED AND PIERCED MY TIRE(S). I CURRENTLY HAVE 73,000 MILES ON MY CAR, WHICH IS A GOOD AMOUNT, BUT AT THE SAME TIME, COIL SPRINGS DO NOT JUST SNAP FROM NORMAL WEAR AND TEAR. THE VEHICLE IS 7 YEARS OLD, NOT TWENTY. HOW COULD THIS HAPPEN? I FOUND OUT THAT WHEN THE COIL SPRING SNAPPED, IT ALSO SNAPPED THE STRUTS AND THE STRUT MOUNT, ON TOP OF MY TWO TIRES. THE TOTAL AMOUNT FOR THE DAMAGE WAS ABOUT $1200.00, AS BOTH SIDES NEEDED NEW PARTS TO ENSURE THE BEST HANDLING OF THE CAR. ALL I CAN THINK ABOUT IS, WHAT IF I WAS ON THE EXPRESSWAY DOING 65? IT'S A SCARY THOUGHT TO KNOW THAT I MAY NOT HAVE COME OUT OF THIS ALIVE. I AM VERY LUCKY IT HAPPENE

BOTH FRONT COIL SPRINGS ON MY 2004 HYUNDAI SANTA FE BROKE THE RIGHT AT 22,000 MILES AND THE LEFT AT 32,000 MILES. LUCKILY THE VEHICLE WAS PARKED BOTH TIMES. *TR

2004 HYUNDAI SANTA FE DRIVER'S SIDE SUN VISOR BROKEN - HANGS IN FRONT OF DRIVER. INTERNET RESEARCH SHOWS THIS IS A VERY, VERY COMMON PROBLEM FOR ALL HYUNDAI MODELS FROM 2000 - 2010. *TR

I AM NOW AFRAID TO DRIVE MY HYUNDAI SANTE FE. WHILE DRIVING HOME FROM WORK (ABOUT 30 MILES FROM HOME) MY VEHICLE STARTED ACCELERATING RAPIDLY AND SURGING WHEN I WAS TRYING TO KEEP IT FROM LUNGING FORWARD. I HAD TO USE THE EMERGENCY BRAKE AND THE BRAKES TO STOP IT AND THAT STILL DID NOT STOP THE ACCELERATION FROM CONTINUING. I DROVE IT DIRECTLY TO THE SHOP WHERE I WANTED TO HAVE IT FIXED. IT COST OVER $500 TO HAVE A THROTTLE SENSOR REPLACED AND NOW IT'S DOING IT AGAIN? I HAD IT TOWED LAST NIGHT BECAUSE I COULD NOT STOP IT AGAIN WITHOUT ALMOST PUTTING IT IN A DITCH. WHEN IT STOPPED IT THEN STARTED NOT WANTING TO GO AT ALL. THIS IS A DANGEROUS CONDITION FOR SURE WITH THIS VEHICLE. SINCE LAST MONTH WHEN THIS HAPPENED, I HAVE BEE READING LOTS OF INFO FROM OTHER DRIVERS WITH THE SAME ISSUE. HYUNDAI DOES NOT WANT TO GIVE ME ANYTHING FOR THIS DANGEROUS REPAIR AS THEY DON'T WANT TO ADMIT ANY FAULT. *TR

TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THIS WAS THE FORTH TIME THEY HAD TO REPLACE THE OXYGEN SENSOR. THE CHECK ENGINE LIGHT CAME ON WHEN THE FAILURE OCCURRED AND THE VEHICLE OVERHEATED. DURING THE LAST FAILURE, THE MAIN CIRCUIT BOARD ON THE VEHICLE BURNED AND WAS REPLACED THREE TIMES IN THE PAST TWO YEARS. THE FAILURE MILEAGE WAS NOT KNOWN, BUT THE CURRENT MILEAGE WAS 135000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 5 MPH SHE APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT STOP UNTIL CRASHING INTO ANOTHER VEHICLE. AFTER CRASHING, SHE SHIFTED THE VEHICLE INTO PARK. ONCE THE VEHICLE WAS IN PARK THE ENGINE BEGAN TO EXHIBIT AN ABNORMAL INCREASE IN RPMS AND THE ENGINE ROARED EXTREMELY LOUDLY UNTIL SHE REMOVED THE KEY OUT OF THE IGNITION. THE POLICE APPEARED ON THE SCENE BUT NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 70,600.

3RD TIME CRANK SHAFT SENSOR WENT IN 1 YEAR/5 MONTHS. CAR ONLY HAS 60,000 MILES. ALL 3 TIMES, CAR WOULD NOT ACCELERATE, CHECK ENGINE LIGHT THEN APPEARS AND SECONDS LATER THE CAR SHUTS OFF. TWICE WE WERE ON THE HIGHWAY WHEN THIS HAPPENED AND LUCKY WE HAD ENOUGH TIME TO GET OVER TO THE BREAKDOWN LANE BEFORE THE CAR SHUT DOWN. 3 TIMES IN A YEAR AND 5 MONTHS, THIS SHOULD NOT HAPPEN... ALSO, THE AIR BAG LIGHT HAS BEEN COMING ON FOR THE LAST YEAR. *TR

TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. WHILE THE CONTACT WAS DRIVING BETWEEN 3-15 MPH ON AN ICY ROAD SURFACE, THE CONTACT APPLIED THE BRAKES, FOLLOWED BY RESISTANCE AND CAUSED A BOUNCING IN THE BRAKE PEDAL. SUDDENLY, A GRINDING NOISE OCCURRED WITH THE ANTI-LOCK BRAKE SYSTEM ENGAGING UNINTENDENTLY WHICH RESULTED TO AN INCREASE IN THE STOPPING DISTANCE. THE AUTHORIZED DEALER WAS NOTIFIED OF THE BRAKE FAILURE. THE FAILURE WAS INTERMITTENT AND PROGRESSED TO WHENEVER THE VEHICLE WAS IN MOTION UNDER ANY ROAD CONDITIONS. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 04V131000 (SERVICE BRAKES, HYDRAULIC: ANTI-LOCK: CONTROL UNIT/MODULE). THE VIN WAS EXCLUDED THE FROM THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 35,000. UPDATED 11/05/10. *LJ

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THE POWER STEERING FAILED. THE CONTACT ATTEMPTED TO MAKE A LEFT TURN YET THE VEHICLE PROCEEDED TO PULL TO THE RIGHT ABNORMALLY. THE DEALER ADVISED THAT THE POWER STEERING HOLD RETURN LINE AND TRANSMISSION LINES WERE SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 77,000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 20 MPH IN HEAVY TRAFFIC, THERE WAS AN ABNORMAL INCREASE IN ENGINE RPMS AND THE VEHICLE STALLED. IN ADDITION, THE TEMPERATURE GAUGE WOULD FLUCTUATE UP AND DOWN AS THE FAILURE OCCURRED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING FURTHER DIAGNOSTIC OF THE FAILURE. THE FAILURE MILEAGE WAS 21,900 AND THE CURRENT MILEAGE WAS 22,000.

TL*THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE ELECTRONIC CONTROL MODULE WAS REPROGRAMMED. APPROXIMATELY FOUR MONTHS LATER THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE ELECTRONIC CONTROL MODULE WAS AGAIN REPROGRAMMED. THE FOLLOWING DAY WHILE DRIVING AT APPROXIMATELY 55 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE IT WAS BEING EXAMINED FOR THE CAUSE OF FAILURE. THE VEHICLE HAS NOT BEEN SERVICED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 78,000.

WE WERE BEHIND A CAR GOING APPROXIMATELY 5 MPH IN A PARKING LOT WAITING FOR THE CAR AHEAD OF US TO TURN INTO A LANE AND INTO A PARKING SPOT WHEN OUR CAR - A HYUNDAI 2004 SANTA FE - SUDDENLY ACCELERATED ONCE AND THEN AGAIN HITTING THE CAR IN FRONT OF US, TWICE. AFTER WE HIT THE CAR THE FIRST TIME WE TRIED TO BRAKE BUT EVEN THOUGH HE HAD HIS FOOT ON THE BRAKE THE CAR ACCELERATED AGAIN. WE REPORTED THE ACCIDENT TO THE INSURANCE COMPANIES - TOOK THE SUV TO THE HYUNDAI DEALERSHIP - REPORTING THE INCIDENT TO THEM - THEY DID SOME KIND OF A TEST AND TOLD US THERE WAS NOTHING WRONG WITH THE CAR. WHEN THE CAR IS IN NEUTRAL THE RPMS RACE HIGH - AND SINCE THAT ACCIDENT I HAD THE CAR IN REVERSE AND IT STARTED TO ACCELERATE FORWARD AGAIN. WE LOOKED ON THE IN INTERNET AND THERE ARE MANY OF THESE SAME COMPLAINTS SO WHY IS HYUNDAI DENYING THIS HAPPENS TO THE CAR? *TR

MY HYUNDAI SANTA FE WAS PARKED WITH ENGINE IDLING WHEN A FIRE OCCURRED IN THE ENGINE COMPARTMENT. FIRE COMPLETELY ENGULFED FRONT OF VEHICLE BEFORE FIRE DEPARTMENT EXTINGUISHED THE BLAZE. VEHICLE IS A TOTAL LOSS. CAUSE OF THE FIRE NOT DETERMINED. VEHICLE RECEIVED PERIODIC SERVICE ONE MONTH EARLIER. *TR