2025 Hyundai Santa FE Hybrid complaints

Driving home from church this morning, the vehicle experiences a sudden loss of power and the car went into “limp mode”. Even the pedal floored and the engine rpms high, the car would barely go about 25 or 30 mph. A message from the dash board told me to pull over and leave the engine running to charge the EV batteries. The batteries would charge enough for what I thought would get me home but quickly drained leaving repeat the action until I could limp the six miles home with flashers on and cars passing me to get around. No warning lights and no indication there was a problem until it happened leaving me baffled and frustrated. I was just thankful that I wasn’t going faster when it happened. If I had been going faster when this happened, it could have created a major accident. Dangerous! Since this happened on Sunday, the dealer wasn’t open. I hope to get it to the dealer tomorrow to find out what is going on and how to fix it. The car has only 14850 miles on it.

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving approximately 65 MPH, the vehicle unexpectedly decelerated to 25 MPH with a “Vehicle Will Shut Down” warning message displayed. The contact stated that the engine then began to shut down, and although the accelerator pedal was depressed, the vehicle failed to accelerate and stalled. The failure occurred on multiple occasions, requiring the vehicle to be towed each time. The vehicle was towed to the dealer; the vehicle was not diagnosed or repaired and the contact was informed that the failure could not be duplicated. The manufacturer was made aware of the failure and multiple cases were opened, The failure mileage was approximately 3,300.

Since February 2026 I have had daily incidents of the hybrid system error where the vehicle is only relying on the hybrid battery to move. I've had a few near miss accidents as my car crawls through an intersection. Was almost rear-end after leaving a stop sign and the hybrid system error popped up and the car doesn't accelerate. In order to temporarily fix the system, the car must be shut off and restarted. There is not always a safe place to be pulled over to perform this shut down. It is a driving hazard and not safe to drive. It has been to the shop now a 3rd time with no resolution. I have reached out direct to Hyundai Corporation with my concerns and they have documentation. The car is a 2025 model and has less than 5,000 miles. I fear a serious accident from this system error and Hyundai needs to resolve ASAP.

Any of the airbags failed to deploy during a significant crash. It is not available for inspection due to it being investigated by insurance. The driver and passengers' safety were affected in that more bodily damage could have occurred if they had hit the steering wheel or any other part of the car. I do not know if the problem has been reproduced or confirmed by a dealer, as i have tried to reach out to the dealer and they have not contacted me back. The vehicle is still being determined as if it can be repaired or it needs to be totaled. There were no indications of warning lamps, messages or other symptoms prior to failure.

The 2025 Hyundai Hybrid Santa Fe SEL has experienced two instances (Nov 2025, 11k miles & Apr 2026, 14k miles) where the combustion engine fails to provide power to the vehicle’s wheels. The engine continues to run, but only enough to maintain a charge to the hybrid battery system. When accelerating to speeds above 30 miles per hour or when traveling up inclines, the combustion engine’s rotations per minute (rpm) spiked, however the vehicle’s power-train still rapidly lost power and the hybrid battery drained significant charge. During one instance in November 2025, while attempting to accelerate to 55 mph up an incline, the hybrid battery drained enough that the vehicle was required to be pulled off the road to allow the battery to charge. During the April 2026 event, while containing a family of four (including to young children under six years of age), the vehicle failed to accelerate to 60 mph up an incline on an interstate freeway bridge. The vehicle rapidly slowed to between 20 and 30 mph, putting the family in grave danger from high-speed collisions. Following both instances, the on-board diagnostics computer was reset, “resolving the issue” and the Hyundai technicians elected to make no further repairs or replacements. The onboard diagnostics code P0191 was reported following the April 2026 event, however no codes or errors were identified by the Hyundai technician following the November 2025 event. No additional follow-up was performed, even though the vehicle remain

I had stopped and put gas in for a full tank. Pulled out onto the Hwy heading towards Houston TX and was accelerating up to speed limit of 50MPH when the warning on the instrument panel displayed HYBRID SYSTEMS DISABLED pull over and stop immediately. Which I did, but I could not accelerate and was losing speed in traffic. I got safely parked and turned the vehicle off. I let the car sit for a few minutes and started it back up. All warnings were gone and the vehicle has performed normally since up to the current mileage of 9374. I took the vehicle to Hyundai today, 4/13/2026 and they hooked it up to the diagnostic system and it showed NOTHING.

Sudden loss of power (multiple incidences in the first 3000 miles, multiple service visits). While driving normally there was a sudden loss of power. Once at an interstate on ramp while attempting to merge, and three times while driving on city streets. The first dealer visit resulted in no action due to no codes and the problem not replicating. When I pulled into the dealer and shut off the car; I received an alert that the vehicle was officially transferred to me. When I restarted the vehicle, it operated normally. The consensus was that the vehicle was left in “dealer mode” and it was several days after I purchased the vehicle before the system was updated. The second insident was deemed to be a bad catalytic converter which was replaced by the dealer. The third incident was said to be due to a bad fuel rail sensor which also caused the catalytic converter from the second incident. The fourth incident occurred the day after the vehicle was repaired from the third instance. The vehicle was not safe to drive and was towed to the dealer, where it is today.

Gas Motor is not engaging to assist electric drivetrain on a hybrid AWD 2025 Santa Fe. This resulted in a dangerous situation crossing a busy road from a stop sign. The Santa Fe rolled into the intersection at the drivers request, but did not accelerate normally (only to a maximum of a few miles per hour) and felt like an eternity to cross the road. Fortunately oncoming drivers from left and right were paying attention and slowed down and in one case honked aggressively to point out we driving badly. Pulling over to the side of the road, turning the vehicle off and then back on again has sometimes made it run normally, but we limited our trips at that point to first getting safely home and then delivering it to the dealer. The 20 mile drive to the dealer required pulling over twice to reset the vehicle so the electric motor would assist. We have had repeated warnings from the onboard system including "Follow up checks required - Engine Management System" and "There may be a problem with the engine management system Contact your Dealer". I will note that we have 11,000 miles and 11 months experience with the vehicle with NO problems. It may not be relevant, but these new faults began 2 days routine service for oil and tire rotation when recall was performed including ECU Software Update for Recall 25-01-028-1. Dealer is uncertain of problem and referring with outside tech assistance from Hyundai but we were told to expect 2 weeks for parts and repair and uncertainty as to whet

Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that’s true—adjust if needed). Vehicle has approximately 28,000 miles. The vehicle is currently at a dealership for inspection and diagnosis, but the issue has not yet been confirmed or resolved at the time of this report.

Vehicle would not accelerate in high speed zone.

Vehicle went in to limp mode in the middle of driving. Would not accelerate past 30mph. Was able to turn around and pull in to a neighborhood when the vehicle stopped responding altogether and had an additional warning about letting the engine recharge the hybrid system. Restarting the car got it home. This would have been extremely dangerous had it happened on the highway, at highway speeds. Dealership replaced the high pressure fuel pump. Got it back yesterday, we will see if that fixes it.

The 2025 Hyundai Santa Fe Hybrid has had multiple occasions, most recently on February 3, 2026 with 12,330 miles on the car, where the gas-powered engine fails to provide any power to the drivetrain. The car experiences vast power loss and enters "limp mode" where only the small hybrid battery is powering the vehicle. Max speed ranges from 10 - 25mph and there is little, if any, acceleration, even when the gas pedal is pegged to the floor. It is necessary to pull over, engage the flashing safety lights and try to find a safe place to park. After turning the vehicle off and on several times, eventually, the gas engines re-engages. The first incident of this type for this vehicle was on August 7, 2025 with approximately 4,400 miles on the vehicle. It was taken to the dealer, Key Hyundai of Salem, who could not find any DTCs and could not replicate the problem. They said "bring it back if it happens again." They next time was on February 3, 2026 where it happened several times on a trip to and from a local restaurant. This time, at DTC code of P088000 POWERTRAIN / POWERLOSS was recorded and reported. However, by the time the car was seen by Key Hyundai of Salem on February 5, 2026, the code has cleared itself. Hyundai's corporate policy is that historical codes can not be used for Warranty claims. So, the dealer tried one potential fix, cleaning the TCM connectors under the driver's seat, and returned the vehicle stating that Hyundai corporate would not authorize warranty work u

While driving, the vehicle will suddenly fail to accelerate beyond approximately 45 mph, even with the accelerator fully depressed. During these events, the engines RPMs increase significantly without a corresponding increase in vehicle speed. When this occurs, the hybrid battery fails to hold or maintain a charge, and the vehicle appears to enter a reduced-power or limp mode condition. This condition makes the vehicle unsafe to operate, particularly in traffic, on highways, or when merging or passing is required. This issue has occurred multiple times and is ongoing. The vehicle has been taken to the dealership 5 separate times (currently in there now for the 5th time) for the same issue. Despite repeated repair attempts, the dealership has been unable to identify or permanently correct the problem, and the condition continues to occur. The safety impacts are as follows: -Vehicle cannot maintain normal traffic speeds -Sudden loss of acceleration -High RPMs without propulsion -Inability to safely merge or respond to traffic. This defect substantially impairs the use and safety of the vehicle. Yes, the problem has been reproduced and confirmed by the dealership on each occasion and the issue continues even after several repair attempts. No warning lights have ever been displayed. The first time in the dealership was 5/10/25 No injuries/accidents (the issue is still safety-critical even without a crash)

While driving at highway speeds (59–75 mph), the vehicle suddenly lost propulsion power and entered a reduced-speed “limp mode,” rapidly decelerating and creating a dangerous traffic situation. The dashboard displayed a “Hybrid Power Control Unit” warning along with audible alarms. During the second incident, the vehicle failed to shut off when the engine stop button was pressed. Multiple adult witnesses were in the vehicle on each dangerous traffic situation.

Sitting at stoplight and attempted to go. Car wouldn’t go above 10mph even with pedal all the way down. Drove for a bit trying to figure out what was wrong. Then flashing red lights and beeping telling me to pull over safely. Pulled over and turned the car off. Restarted and car said charge battery. Apparently this is called “limp mode” and happens when there is something seriously wrong with the car in order to prevent further damage. Very dangerous to not be able to go about 10mph on the highway. Took to dealership. Vehicle isn’t throwing any codes and blue link shows nothing of the incident. Dealership supposedly checked battery and connections. Nothing done

Supplemental Update – Ongoing Safety Concerns and Extended Loss of Use Since submitting my initial complaint, my leased Hyundai vehicle (VIN [XXX] ) has now been presented for service for the third time for the same unresolved safety-related issues. The vehicle has been held by the dealership for eight (8) consecutive days during this service visit with no resolution and no clear timeline for return. Safety concerns remain unresolved, including: Persistent toxic/chemical odor inside the cabin Random rear hatch opening while vehicle is parked and locked Repeated false “windows open” alerts Electrical/body control system irregularities To date, I have not been provided with documentation confirming that cabin air quality testing, exhaust intrusion testing, or comprehensive electrical diagnostics have been performed. These unresolved conditions present ongoing safety risks and loss of use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Started car, reading paperwork and suddenly my car went into Neutral bycitself and rolled backwards in a parking lot. Thank goodness no one was walking behind my car. This is the 2nd time it has happened. Additionally, twice previously, my car screen blacked off. 1 other time while sitting at a traffic light, the car shut off. I have been patient but now I'm afraid ti drive this car with only 2,650 miles on it.

I was stopped at a red light. When the light turned green, I proceeded to apply the gas and accelerate. I quickly noticed that the vehicle began accelerating at a faster rate than I was intending. The vehicle continued to accelerate without me applying my foot to the gas pedal. Nothing would stop the continued acceleration (application of brake). I crashed into the rear of a vehicle in my lane going approximately 50-60mph (estimate). I am unsure what the issue was that resulted in this crash. In doing some internet searching, it seems it could have something to do with the transition from electric to gas when I was stopped temporarily at the intersection. It could have been a faulty sensor (throttle position) or software glitch. These components have not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The crash resulted in the airbags being deployed, I was taken to the hospital with a likely concussion and moderate injuries to my chest and hand. The vehicle that I rear ended was a [XXX] woman with a [XXX] old in the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Description of the Problem: I own a 2025 Hyundai Santa Fe Hybrid Limited with approximately 3 months of use. While driving on highway, the vehicle suddenly stalled displaying “Hybrid System Failure-Stop by side”. I had to stop on shoulder and restart, drove it couple of days and it happened again. Engine would not start, leaving the vehicle stuck in EV mode only with no ability to accelerate properly, Vehicle wouldnt go beyond 35mph. The vehicle then stalled and became unsafe to operate on a public road. After restarting, the vehicle displayed a Check Engine Light. Tookk it to the dealer and the dealer reported DTC P1122000, but did not provide clear evidence of an internal system fault. The dealer claimed the event was caused by “20% ethanol in the fuel,” which is inconsistent with U.S. pump labeling laws. When I checked my credit card entries around the time for refuel, all of them are reputed gas stations with nothing lower than "87" gas which is in alignment with car manufacturer's recommendation. This sudden stall created a serious safety hazard, and I am concerned this may be a broader issue with the 2025 Hyundai Santa Fe Hybrid drivetrain, fuel system sensors, or hybrid control module. I am requesting NHTSA to look into whether similar complaints exist, as this failure mode can result in loss of propulsion at speed, putting occupants at risk.

On August 8, I was traveling to work on the interstate. The car started losing speed even though my foot was on the accelerator. I was unable to get the car above 30 mph despite having my foot on the accelerator. I exited the interstate to try and find a safe place to pull over. I parked the car, turned it off, restarted it and attempted to drive it. The problem continued. There were no icons or alerts showing up on the dashboard of the car to alert me that there was an issue. The vehicle has been at the dealership for repair for over 100 days. They will not communicate with me about the issue or provide updates.

SantaFe Hybrid Calligraphy 2025 with about 9000 miles purchased new from Hyundai dealer. Several times and unpredictably, the vehicle loses power while driving mostly on highway 60-70 mph. operator can push the gas pedal to the floor and the car does not accelerate more than about 25 mph. My wife was on an off ramp with no shoulder to pull off. Very dangerous situation. A message on the dash states to "park and let battery charge". The battery is suppose to charge itself while the gasoline engine is operating.A search engine query reveals many folks are experiencing this same situation.

My 2025 Hyundai Santa Fe Hybrid has experienced repeated, dangerously abrupt power loss while driving at highway speeds, causing the vehicle to go into "limp mode" without any warning or prior indication. This safety hazard occurred on three separate occasions: First Incident: 7/29/25; Mileage: 9,205. Situation: While traveling at 70 MPH on the interstate, the vehicle suddenly decelerated to 35 MPH and entered "limp mode" without any warning lights or notifications. Dealer Repair: Replaced ignition coil assembly (Parts: 27301R1H, 27301-2M417). Second Incident: 8/27/25; Mileage: 12,898 Situation: While accelerating to 65 MPH on the interstate, the same loss of power and abrupt forced deceleration occurred, again with no warning. This sudden loss of speed created a serious safety hazard for me and other drivers. Dealer Repair: Replaced fuel pump & O Ring Assy-High Pressure (Parts: 35326-2M500, 35305-2m414 LH). Third Incident: 9/25/25; Mileage: 14,830. Situation: Traveling at 70 MPH on the interstate, the car abruptly decelerated, again entering limp mode. This caused surrounding vehicles to swerve to avoid rear-ending me, putting myself and others at risk. Dealer Repair: Replaced High Pressure Sensor (3534202M400), Packing Fuel Pump (31115-0W000), and Fuel Pump and Tube Assy (31119-L1400). In all three cases, there was never any warning light, check engine notification, or app alert before the incident. Hyundai and my dealership confirmed and replicated the issue during each re

The driver assistance warning system continuosly goes into shutdown mode. Eye monitoring system always states that you are not keeping your eyes on the road. I have tried using different glasses or no glasses. Changing the steering wheel settings also seem to have no effect. This is very dangerous as it will start decelerating and stopping in the middle of a freeway in heavy traffic when this warning is activated. This only happens with the lane keeping assistance and adaptive cruise control are on. Hyundai issued Technical service bulletin 25-GI-001H, but they did not solve the problem

Vehicle was in driveway for 3 days. When I got into vehicle to drive I saw the windshield had a large crack on driver’s side approximately 16” long. No vandalism or rock damage caused this problem. Has to be a stress fracture.

Driver attention warning system constantly gives aggravating notices of "suggest take a break" with chiming sound when driving with or without sunglasses or other glasses. I cannot use cruise control. I have tried several different sunglass types with no success. After first warning, goes off every 4 minutes, either cancelling cruise control when I am using it or just causing annoying aggravation which takes my attention off the road. I cannot turn this feature off. It is so aggravating that it draws my attention from the road ahead and impacts my patience while driving. Due to eye condition, I must use sunglasses while driving in sun. Hyundai did not make this limitation clear when I was buying the vehicle, and they refuse to do anything about it now.

My wife was parking our vehicle near the front of our home, simply rolling forward toward the car in front of her to complete parking on the left side of the street when the vehicle unexpectedly accelerated on its own. The vehicle turned hard to the right, struck the bumper of the parked car she was pulling up behind, continued right across the traffic lane where it hit two parked cars on the other side of the street with significant impact, lifting and turning one onto the sidewalk, at which point our vehicle went across the sidewalk and stopped after hitting a fence. The forward collision avoidance that we have experienced engaging previously, never engaged, despite hitting multiple vehicles on the lefft side and then right side of the street. The collision avaoidance alarms that we have experienced sounding previously, also never went off. The airbags never deployed, despite hitting 3 cars at two different sides of the street, as well as an iron fence that never moved. The vehicle went from traveling less than 5 mph while completing the last few feet of parking to a high rate of acceleration within a path of less than 40 feet, as evidenced by the significant damage it left. Had my wife not come to a stop as quickly as she did, she could have been seriously injured. If anyone had been on the sidewalk - there are 3 shcools on this block that children are often present - someone could have been killed. The vehicle is currently at a body shop being evaluated by insurance adjus

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while his wife was driving at an undisclosed speed, the Forward Attention Warning (FAW) system activated. Shortly afterward, the message "System Shutting Off" was displayed, and the Automatic Emergency Braking System briefly engaged, jerking the vehicle and dramatically reducing its speed of the vehicle but not to a complete stop. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the vehicle was functioning as designed but informed the contact that his wife's glasses may be interfering with the Forward Attention Warning (FAW) system's eye detection ability to monitor her eyes. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 13,000.

The “consider taking a break” warning comes on far too much and has almost made me wreck twice due to being startled.

Vehicle unable to recognize face when wearing sunglasses and disables all driver assist aids, including turning off the cruise control

I purchased a new 2025MY Hyundai Santafe Hybrid. Since the day of my purchase there has been a constant error message that is displayed on dash saying "Driver attention warning system failure". this light stays on constantly and disables cruise control and adapative cruise system. This affects the usability of the vehicles. WHen asked Hyundai they say, drivers arent expected to wear sunglass if this system has to work properly, they even say constant blinking will cause system to fail and disable cruise control. This is a serious concern. How can people drive a car without blinking and how can a new car have disabled cruise control all the time.

Hyundai disabling critical vehicle safety systems if people wear sunglasses. I brought MY2025 hyundai santafe hybrid, this has driver attention monitoring system. Since the day i brought this vehicle i have been getting issues related to driver attention warning system. This error is being caused for no reason, this comes on when vehicle comes on and stays on (sometimes for days sometimes for weeks and sometimes for hours). HYundai says this issue is because i have a dash cam in car, error wont go away even when dash cam is removed. Recently hyundai engineers said its because you may be wearing sunglasses. What? Wearing sunglasses will disable AEB and cruise control !!!OMG. I removed sunglasses and tried still wont work. Hyundai sent me list of things not to do, including not to laugh, not to shorten your eyes and not to wink. this is a major safety concern, not allowing drivers to wear sunglass which will disable safety critical systems.

Purchased new 2025 Hybrid AWD Santa Fe with 47 miles on 8/3/25 at 6pm. By 6:30am on 8/4/25 I noticed an occasional knocking when coming to a stop, reversing, turning and at times driving forward. The knocking became more frequent and noticeable as the day went on with more driving and not once did a service message or warning light display. At 1pm on 8/4/25 with an added 100 miles, I drove it to Hyundai Service Department to have them diagnose the issue which they immediately heard. After 8 days, I was told it was a control arm issue which them lead to a complete suspension rebuild on the driver side. I could have lost total control of the vehicle due to the bad control arm. They claimed the passenger side was fine and I picked up my car on 8/12/25 4pm. By 6:30am on 8/13/25 the knocking was back and car is pulling to the right. Car is back in the service shop to further investigate the knocking. I believe Hyundai is trying to cover up this issue as the service report they initially gave me had no mention of the control arm or suspension rebuild. I refused to sign and asked for another service report stating what the issue was and how it was repaired.

Hyundai's Forward Attention Warning is so aggressively annoying it makes me want to drive off a cliff to shut it up. Driving with an arm in the 12 o'clock position? "BEEP! Keep your eyes on the road!" Polarized sunglasses? "BEEP! I can't see your eyes!" Oh, there's a setting! Let's turn it off..."BEEEEEP! WHERE ARE YOUR EYES!". I just purchased and cannot use Cruise control I need to wear glasses It has a hard time seeing my eyes I cannot turn off I have tried many positions on steering wheel to no avail.

Check emergency, stopping function alert. Check hybrid system stop safely. Both alerts came on the dash the steering wheel vibrated 11 other alerts popped up in the car steered me to the side of the road. It would not start again and This has happened four times in the 7 months I’ve had the car Hyundai cannot figure out what the issue is. In fact they tell me there is no issue because it’s not happening to them while it’s been there for almost a month.

Occasionally, the vehicle acts like I am not looking at the road and I’m not sure if it is because of my hair, glasses, hat, or my lazy eye. On three different occasions in nearly 8000 miles it will randomly hard break on the interstate. Initially, I had thought this was something I was doing. When I was finally able to speak with the service staff, they confirmed that this is a common issue with people wearing glasses or any other items the vehicle does not register as normal. At this point, I am afraid to drive a vehicle once I learned that this is a safety setting I cannot control. I have been told by Hyundai that the vehicle is operating as it should however it is extremely concerning that this could cause an accident on the interstate and someone could get killed.

I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, uneven and premature wear — all within low mileage. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. It also appears that the it's the MS, verde and AS Plus 3 from pirelli that have these issues. You can find additional complaints regarding these with a google search. They will be on reddit and facebook.

I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, and premature/uneven wear — all within low mileage. They stated that it was still an inherent issue with the tires and I would need new ones. Thus I requested to have a different set tires given the issues with these. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. I understand that it is the Scorpion MS, AS Plus 3 and the Verde with these similar issues. Unfortuneately for some reason your site won't let me post my photo, but I was able to file it under the same VIN under my report for the Santa Fe.

Stopped for gas, vehicle started but would not go into gear, engine lights indicated 'Check hybrid system', warning lights shown. 1/2 hr on the phone with dealership to assist. No problem detected when returning to home dealer. Second episode occurred, vehicle at dealer for the past 4 weeks. Episode repeated at dealership yet "no abnormalities are detected with diagnostics ".

I've been having a few issues with my 2025 Calligraphy Hybrid I bought in November related to the main screen, sometimes when I start the vehicle it doesn't properly initialize and it will show me some of the icons and nothing else. No HUD, no speedometer, no remaining fuel, no hybrid information. It's a huge safety issue, it seems to happen every couple of weeks. I thought it was the digital key not working properly so I disabled that but still having issues. I have to let the car sit for a few hours or overnight and then when i turn it on then it's back to normal. I realized that when the main screen is off, it doesn't capture the mileage so the mileage is off by close to 300 miles right now. Huge issue, I've had it happen on my way home from work (25 miles) at least 4 times, and once on a road trip (150 miles). Also when this happens because I can't see the speedometer, I have to use Waze on the infotainment screen (which works without issue) to see my actual speed because the built-in navigation only shows me increments of 10 mph on the screen (this is just stupid).

The cruise control system cuts of with message on screen stating that , system camera can’t see my face and the system de-activates. This is especially dangerous at highway speeds. The vehicle behind me doesn’t see a brake light as my vehicle suddenly looses speed. This is from Hyundais Driver Attention Warning (DAW) function. This function cannot be de-activated by myself or my dealership which is Webb Hyundai of Merrillville Indiana.

Car was unused for less than a week and upon going to use it the vehicle was dead. Jumped vehicle and next day was dead again. In researching the problem, many other Santa Fe Hybrid owners have run into this same issue. Dealership admitted many hybrids from Hyundai face this issue and recommended installing a trickle charger for when not using the vehicle for a couple days which seems ridiculous for a brand new vehicle. Likely something draining battery slowly in car

I was on a semi residential-commercial street that turns on to a freeway entrance. I was turning right and unavoidably entered the freeway when the sudden loss of power occurred. The car slowed down to about 20 mph and pressing on the gas medal didn't yield any more power. I immediately pulled over to the emergency lane upon entering freeway to let fast moving vehicles pass me on the left side. I turned off the vehicle and turned it back on. It seemed to turn on as normal so I proceeded to drive home slowly, staying on the slow right lane of the freeway driving under the speed limit until I took my exit to get to my home. All seemed ok until I turned onto residential street near my home. Again the car slowed down suddenly to 20mph and giving it more gas did not make a difference. The time difference between the first and second (recorded) incident was 25 minutes apart, having driven the vehicle only 140 total miles. The dashboard flashed a 20mph speed limit even though I never set those parameters, didn't set cruise control, and I didn't have auto stop or hold buttons engaged. The car simply slowed down to a 20mph speed limit without my input to the vehicle settings.

Car did dashboard update on 4/10/25. Had less than 4300 miles. Unable to unlock car due to dead battery. Car unlock service opened door for tow company to jump battery and advise that the new 2025 Santa Fe Hybrid battery needs to be replaced. May need other service (alternator or Hybrid battery too) but the 12v battery had been drained. Interior lights would not turn on prior to this happening.

The driver assist program will not work if the driver is wearing sunglasses. If you are using driver assist, which includes cruise control, and are wearing sunglasses, the vehicle gives a driver attention warning. The vehicle will them cut off the cruise control causing the vehicle to rapidly drop its speed. This is incredibly dangerous at highway speeds way speeds. Hyundai and its dealerships are aware of this issue but have not offered a solution. Also you cannot disable the driver camera that cause the driver attention warning. We have also had this occur while driving at night without sunglasses. My understanding is that this issue is across all model lines.

Forward attention warning system sounds when driver is facing forward, eyes open, hands not blocking camera. Very distracting for driver and can lead to car decelerating itself.

Washer nozzles are non adjustable, and spray too low on windshield to effectively clean glass, especially at highway speeds. Severe visibility issue. I have reported the problem to Hyundai corporate customer service, who are escalating the issue to upper management. I have also brought the vehicle to my local dealer where it was purchased and made them aware of the issue. Dealer agreed with me, and has heard same complaint from many other owners of this model. This should be a simple fix by swapping in an adjustable nozzle.

This is a concern about the Driver Assistance Warning Consider Taking a Break 5 bell warning system. While we understand and appreciate the many safety features on new cars, we feel this feature is a safety distraction and hazard. We have turned this feature off in the Driver Assistance Warning section and we have turned off the bell. Despite this, this warning with its 5 loud distinct bells sounds very frequently and often automatically disengages our cruise control while we are driving on the highway. In a recent vacation road trip of over 3,000 miles, the enjoyment of our trip and our new car was greatly compromised. During that time we tried to discern what actions we were doing to cause it to go off. It would go off when looking at the gauges so we would try to look quick and then eyes back on the road. We tried driving without sunglasses (which is a hazard itself), making sure our hands were at the 11 and 2 position, looking straight ahead. Nothing seemed to make a difference, it would go off randomly and often. Careful and safe driving requires a driver to scan the rear view and side mirrors, the gauges, be aware of other drivers proximity to your vehicle and avoid staring only straight ahead. I am aware that there may be consideration of a mandate for all cars with this feature in the future, however, as of the time of purchase of this vehicle, this law did not exist and as such, we should have the right to choose to use this feature or not. We have contacted Hyundai

12V battery discharges and SUV has to be junp started. Hyundai removed the battery reset button that existed until 2023 model year. Manufacturer should do recall to change the 12V battery charging characteristics for 2024/2025 model years.

Our car had 2149 miles on it. Engine started to stalled on [XXX] on [XXX] from OKC to Tulsa. We made it to Tulsa. The car was towed to Tulsa Hyundai dealership on 12/25/2024. After diagnostic on 12/26/24, we were told the car had bad gas. The dealership performed the necessary work including replacing 4 fuel injectors in order to fix the problem. It cost $3991.52 and it took a week. We were told since this was not a manufacturer problem that we are responsible for the repair. We paid for the repair. We always get our gas from Costco. So we filed a report with Costco stating that we got bad gas from them. Costco turned it into their adjuster at Gallagher Bassett. He investigated and told us that his findings indicated that Costco did not have bad gas in the month of December according to their quality reports. No other cars filed complaints regarding gas issue. Our claim was denied. The question remained where the bad gas came from. Was it truly a bad gas problem or did the car have fuel injector issues and that bad gas was a cover up. We bought a new car, we purchase gas from a reputable company and we ended up with this problem that we were responsible for through no fault of our own. We are filing a report to see whether there are other cars of this model that had similar issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

[XXX] - On re-entering the highway, after getting gas. accelerating slowly on ramp (passing 35-40 mph) - I crossed a patch of snow, the brakes locked up briefly! (Fraction of a second) I was about 2/3 up the ramp. No other vehicles near. 1000 miles on 2025 Sante Fe. Arriving home and searching on line I find others have experienced similar brake events on a range of Hyundai products. 29 degrees light snow, some slush, mostly clear road. Cruise control had been on prior to stop. I didn’t notice status during ‘event’ but noticed it was on when I was back on the highway. Lane keep and centering indicators on. Adaptive cruise was not on. No other events in the 20 miles home. No prior similar incidents INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)