2004 Honda Pilot complaints

WHILE DRIVING IN APRIL OF 2009, THE DRIVE GEAR KEEP BLINKING. CALLED THE HONDA DEALER AND THEY SAID TO TURN OFF ENGINE AND IT SHOULD GO AWAY. IT DID GO AWAY, ONCE THE ENGINE IS OFF. THEN IN JULY 2009, IT BLINK AGAIN, AND IT GO AWAY ONCE THE ENGINE IS OFF. NOW THE DRIVE GEAR BLINKING LIGHT IS ON MORE FREQUENTLY THEN BEFORE. I CALLED THE HONDA DEALER AND THEY SAID THEY DON'T KNOW WHY THE D DRIVE IS BLINKING. *TR

ENGINE MOTOR MOUNT NEEDED REPLACED TO PASS PENNSYLVANIA INSPECTION. *TR

INFORMED BY THE DEALER THAT THE MOTOR MOUNTS ON MY 2004 PILOT WERE CRACKED AND THAT I WOULD START TO NOTICE THIS IN VIBRATION OF THE VEHICLE. DEALER TOLD ME THAT THIS WAS SOMETHING SEEN QUITE OFTEN IN THE PILOT AND ODYSSEY. 2004 PILOT WITH 91K MILES. *TR

BROKEN FRONT ENGINE MOUNT DETECTED ON MY 2004 HONDA PILOT WITH 45000 MILES. NOTICED A VIBRATION WHEN STARTING OUT FROM A COMPLETE STOP. FIRST NOTICED PROBLEM ABOUT A YEAR AGO BUT DEALER SAID THEY COULD NOT DUPLICATE PROBLEM. HAD VEHICLE SERVICED RECENTLY AND WAS INFORMED OF PROBLEM. HAVE SINCE LEARNED THAT MANY OTHER OWNERS HAVE HAD SIMILAR PROBLEMS WITH THEIR PILOTS. ALSO HAD FRONT LOWER CONTROL ARM BUSHINGS REPLACED AT 40000 AT DEALERS ADVICE. VEHICLE IS USED STRICTLY ON PAVED ROADS AND THOUGHT IT WAS ODD THAT THEY WOULD GO OUT SO EARLY. *TR

DEFECTIVE MOTOR MOUNTS IN HONDA PILOT. *TR

I HAVE 2004 HONDA PILOT EX-L WITH 100,000 MILES. TODAY I NOTICED THE DRIVE LIGHT BLINKING ON MY WAY HOME FROM WORK. AFTER I ARRIVED HOME, I STOPPED THE ENGINE AND RESTARTED AND I DID NOT BLINK AGAIN. WHAT SHOULD I DO WITH THIS? *TR

WAS A HEAD ON CRASH AT BOTH PARTIES GOING 60 MPH. THE DRIVERS SIDE AIRBAG DID NOT DEPLOY WHICH MY WIFE HAD MULTIPLE BRUISING FROM HITTING THE SIDE WINDOW AND B PILLAR. INJURIES BESIDES ABOVE 2 HOLES IN COLON, DAMAGED 6" OF SMALL INTESTINE MULTIPLE CUTS AND BRUISING AND ALSO PULLED TENDONS FROM LEFT FOOT. *TR

MY 2004 HONDA PILOT REQUIRES A NEW TRANSMISSION AT ~60,000 MILES WITH REPAIR FEE OF $4,000. I FOUND THIS RECALL INFORMATION. I DID NOT RECEIVE THIS RECALL INFORMATION IN THE PAST. I BELIEVE THE MANUFACTURER SHOULD ASSUME FULL RESPONSIBILITY FOR THE REPAIR. I AM READING THAT THE TRANSMISSION COULD HAVE LOCKED UP. THIS IS ALARMING AND I AM CONCERNED FOR THE SAFETY OF MANY OTHER FAMILIES (INCLUDING MY FRIENDS) WHO DRIVE THE PILOT. THE REASON WE PURCHASED THE PILOT WAS TO TRANSPORT OUR FOUR CHILDREN AND THEIR FRIENDS. NHTSA RECALL CAMPAIGN NUMBER: 04V176000 COMPONENT: POWER TRAIN:AUTOMATIC TRANSMISSION DETAILS: ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE. CONSEQUENCE: GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH. CORRECTIVE ACTION: ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECAL

BROKEN ENGINE MOUNTS FRONT & PASSENGER SIDE. *TR

DEALERSHIP SERVICE STAFF INFORMED ME THAT MY 04 HONDA PILOT NEEDS TWO MOTOR MOUNTS (FRONT AND RIGHT SIDE) REPLACED. I HAVE HEARD THAT MANY OTHER PILOT OWNERS HAVE HAD THE SAME ISSUE. WITH JUST 75K MILES, AND THE KNOWLEDGE THAT THIS SOUNDS LIKE A COMMON ISSUE, I WOULD THINK THAT A RECALL IS IN ORDER. I HAVE NEVER HAD TO REPLACE MOTOR MOUNTS ON ANY OTHER VEHICLES I'VE OWNED: 72 OPEL MANTA; 79 CHEVY MALIBU; 80 AND 88 TOYOTA COROLLA'S; 83 OLDS CUTLASS; 94 GEO PRISM; 98 TOYOTA CAMRY. I HAVE NOT HAD THEM REPLACED AS YET, BUT THE DEALERSHIP REPLACEMENT CHARGE IS ESTIMATED AT $547.00. *TR

I HAVE SEVERE BRAKE SHUTTERING AND THE STEERING WHEEL SHAKES WHEN I APPLY THE BRAKES. IT STARTS OUT AS A MINOR SHUDDER AND SHAKE AT FIRST, AND THEN OVER TIME GETS PROGRESSIVELY WORSE, UNTIL IT IS QUITE VIGOROUS. A LITTLE BACKGROUND: THE CAR IS A HONDA CERTIFIED CAR- 2004 PILOT I BOUGHT 2 YEARS AGO. AS A CONDITION OF THE SALE, THE DEALER (SAM SWOPE IN LOUISVILLE, KY) SAID THEY WOULD FIX A SHIMMY IN THE STEERING WHEEL, AND A GRINDING OF THE BRAKES. THEY SAID IT WAS A MINOR PROBLEM. THE BRAKES WERE REPAIRED 2 WEEKS BEFORE I BOUGHT THE CAR. I BROUGHT THE CAR BACK 4 DAYS LATER AND THE ROTORS WERE RESURFACED. EVERYTHING WAS FINE FOR A COUPLE OF WEEKS, AND THEN THE PROBLEM STARTED COMING BACK- SLOWLY AT FIRST AND THEN GOT PROGRESSIVELY WORSE. 3 MONTHS LATER THEY RESURFACED THE ROTORS. THE SAME PROBLEM PROGRESSED AGAIN, AND 3 MONTHS LATER, THEY REPLACED THE REAR BRAKE PADS AND RESURFACED THE ROTORS AGAIN. I PUT UP WITH A SHIMMY IN THE WHEEL AS THE PROBLEM OCCURRED AGAIN . FINALLY, AFTER ABOUT 8 MONTHS, MY WIFE COULDN'T TAKE THE SHIMMY ANY MORE AND MADE ME TAKE IT IN AGAIN. I WAS RELUCTANT BECAUSE EACH TIME I TOOK IT IN NOTHING HAPPENED, AND I'D ALREADY SPENT OVER $700 TO NO AVAIL. ONCE AGAIN THE ROTORS WERE RESURFACED, THE FRONT PADS WERE REPLACED AND THE EMERGENCY BRAKE DRUM WAS TURNED. TWO MONTHS LATER I BROUGHT THE CAR IN FOR THE SAME PROBLEM, AND WAS TOLD THE ROTORS NEED TO BE RESURFACED AGAIN. I CALLED HONDA CUSTOMER SERVICE ON 4/21/09, TALKED TO TINA AND SHE SAID I WOULD LIKELY

DEFECTIVE MOTOR MOUNT 2004 HONDA PILOT - SEVERE STEERING WHEEL VIBRATION. *TR

THE WINDOW REGULATORS AND POWER DOOR LOCKS ON THE HONDA'S I OWN KEEP FAILING AND COST MORE THAN 300 DOLLARS TO REPAIR. THIS SEEMS TO BE A SYSTEMIC PROBLEM ON THE HONDA'S. I HAVE HAD THIS HAPPEN ON ALL 4 DOORS OF MY 2000 HONDA ACCORD AND 2 DOORS ON MY 2004 HONDA PILOT. HONDA NEEDS TO DO A RECALL AND FIX THIS ISSUE. PEOPLE SHOULDN'T HAVE TO PAY FOR A SYSTEMIC ISSUE IN THE CAR, WHICH CAN BE A SAFETY ISSUE AS WELL AS YOU CAN'T PUT THE WINDOWS DOWN OR UP ONCE THIS HAPPENS. *TR

TOLD BY HONDA TECHNICIAN THAT TWO OF THE FOUR MOTOR MOUNTS ARE DAMAGED AND NEED REPLACEMENT. *TR

MY 2004 HONDA PILOTS FLOORBOARDS ARE SOAKED WHEN I TOOK IT TO JOHNSON CITY HONDA THEY SAID THEY HAVE NEVER SEEN IT BEFORE AND THAT WAS THE FIRST OF JANUARY THEN I LOOKED AT AN AUTO CLUB THAT HAD A FORUM ABOUT LEAKS IN HONDA PILOTS THERE WHERE FOUR DIFFERENT PLACES THEY HAD FOUND LEAKS AND AFTER HAVING THEM FIXED STILL HAD SOAKED FLOOR BOARDS I HAVE A DAUGHTER SHE IS FOURTEEN MONTHS WHO RIDES IN THIS VEHICLE AND RIGHT AFTER I FOUND THE LEAK SHE GOT SICK FOR THE FIRST TIME SINCE SHE WAS BORN AND HAS BEEN SICK THREE TIMES SINCE DECEMBER AND SO HAS MY WIFE AND I GOT SICK FOR THE FIRST TIME LAST YEAR I HAD A BACTERIA INFECTION AND BRONCHITIS AND I GOT SICK AGAIN TWO DAYS AGO AFTER DRIVING IT SO NOW ITS JUST SITTING IN THE DRIVEWAY MY WIFE AND I ALTERNATE DRIVING THE 1996 HONDA ACCORD THE WHOLE REASON WE BOUGHT THE PILOT WAS BECAUSE WE WHERE PLANNING ON STARTING A FAMILY AND WANTED OUR DAUGHTER TO BE SAFE EVERYTIME IT RAINS THE FLOOR BOARDS GET MORE WET THE PEOPLE ON THE FORUM HAD A HONDA PILOT SERVICE BULLETIN THAT STATED HONDA HAS KNOWN ABOUT THIS PROBLEM FOR A LONG TIME IN THE A-PILLAR BUT HAVE FOUND SEVERAL OTHER ONES I AM SO IRRITATED THAT I RAN OUT IN TWO INCHES OF SNOW TO GET MY REGISTRATION AT TEN O CLOCK AT NIGHT PLEASE HELP ME! *TR

2 ENGINE MOUNTS REQUIRING REPLACEMENT AT 85K MILES ON 04 HONDA PILOT. HONDA DEALERSHIP COST TO REPAIR IS $499. DISCOVERED MANY OTHER HONDA PILOT OWNERS WITH SAME PROBLEM AND QUESTIONING WHETHER THIS IS A DEFECTIVE PART AND SHOULD BE A RECALL. *TR

TL*THE CONTACT OWNS A 2004 HONDA PILOT. WHILE DRIVING 45 MPH, THE VEHICLE BEGAN SHAKING AND MAKING NOISE. THE DEALER TEST DROVE THE VEHICLE AND STATED THAT THE TRANSMISSION WAS THE CAUSE OF THE FAILURE. THE DEALER ALSO STATED THAT THEY WOULD PARTIALLY REPAIR THE FAILURE. THE CONTACT STATED THAT HE DOES NOT HAVE THE OTHER HALF AVAILABLE TO PAY. THE FAILURE MILEAGE WAS 97,000. UPDATED 01/07/09. *LJ UPDATED 01/08/09.*JB

EVERY TIME IT RAINS EVEN IF CAR IS NOT MOVED, IT LEAKS TO FLOORBOARDS OF DRIVERS SIDE AND PASSENGER SIDE. HONDA PILOT IS FREE FROM ANY WRECKS OR DAMAGE. *TR

WATER LEAKING INTO FRONT DRIVER AND PASSENGER FLOOR.*TR

OPSD (OCCUPANT POSITION DETECTION SYSTEM) AND REARWIPER MOTOR FAILED AT THE SAME TIME WITHOUT PREVIOUS ACCIDENT. HONDA DEALER SAYING THIS ITEMS ARE NOT COVERED UNDER HONDA CERTIFIED USED CAR CONTRACT. I NEED TO POCKET OUT ABOUT $900.00 TO REPLACED BOTH PARTS. *TR

I'VE BEEN HAVING PROBLEM WITH THE STICKY ACCELERATOR PEDAL SINCE I PURCHASED IT. THE FIRST TIME THAT THE PROBLEM OCCURRED WAS AT 19K MILES. THE ACCELERATOR PEDAL GOT SO BAD ON THE HIGHWAY I HAD TO PULL TO THE RIGHT SIDE TO PREVENT FROM CAUSING AN ACCIDENT BECAUSE THE ACCELERATOR PEDAL GOT STUCK AND IT COULD NOT ACCELERATE. THE VEHICLE HAD TO BE TOWED TO THE DEALERSHIP. I WAS INFORMED THAT THERE IS A PROBLEM WITH THE THROTTLE. THE DEALERSHIP REPLACED THE THROTTLE AT LEAST 5 TIMES AND ALSO CLEANED IT BUT MADE IT WORST. THE LAST TIME THAT THE DEALERSHIP REPLACED THE THROTTLE WAS IN APRIL 7, 2008 AND AGAIN I AM HAVING THE SAME PROBLEM. I'VE CALLED THE MANUFACTURER AND WAS INFORMED THAT THERE REALLY IS NOT MUCH THEY CAN DO AT THIS POINT. I REFUSED TO PAY FOR SOMETHING THAT IS ONLY A TEMPORARY FIX AND WOULD LIKE SOME RESOLUTION TO THE PROBLEM. IT IS OBVIOUS THAT THERE IS A PROBLEM AND I AM ASKING FOR THIS TO BE RECALLED. MY VEHICLE IS NOT THE ONLY ONE THAT IS HAVING THE SAME PROBLEM. I'VE GONE TO THE HONDA PILOT FORUM AND READ THAT I AM NOT ALONE. I REALLY AM ASKING NHTSA TO CONSIDER A RECALL FOR THE HONDA PILOT. YES, I UNDERSTAND THAT I DID NOT EXPERIENCE AN ACCIDENT NOR INJURIES BUT I BELIEVE THAT A NEAR ACCIDENT SHOULD WARRANT A RECALL. THANK YOU! *TR

IN MAY 2007, U-HAUL OF KINGSTON, NY INSTALLED A TRAILER HITCH ON MY 2004 HONDA PILOT. ON APRIL 4,2008, MY TURNING SIGNALS STOPPED WORKING AND I SMELLED A BURNING ELECTRICAL SMELL. I SCHEDULED A SERVICE APPOINTMENT WITH MY LOCAL HONDA DEALER FOR APRIL 8, 2008. I STOPPED USING THE VEHICLE. THE CAR ALARM BEGAN TO GO OFF INTERMITTENTLY, WITHOUT PROVOCATION. WHEN WE TRIED TO START THE CAR TO BRING IT TO THE SERVICE APPT., IT WOULD NOT START. IT WAS TOWED TO THE DEALERSHIP. THE SERVICE TECH'S LOCALIZED THE SMELL TO THE REAR OF THE CAR AND BEGAN INVESTIGATING THE TRAILER HITCH INSTALLATION. THE "HIGH ENERGY 3 TO 2 TAILLIGHT CONVERTER" HAD OVERLOADED AND THE CASING AROUND THE UNIT HAD MELTED THROUGH. *TR

TL*THE CONTACT OWNS A 2004 HONDA PILOT. WHILE DRIVING SPEEDS RANGING FROM APPROXIMATELY 25 TO 55 MPH, THE VEHICLE BEGAN PULLING TO THE RIGHT. THE VEHICLE CHANGED LANES WITHIN SECONDS. THE CONTACT HAD TO USE EXTREME FORCE TO STEER THE VEHICLE BACK INTO THE CORRECT LANE. THE FAILURE CAUSED THE TIRES TO WEAR BEFORE THE NORMAL MILEAGE. THE DEALER REPLACED THE TIRES AT 27,000 MILES DUE TO THE EXTREME WEAR. THE STEERING IN THE VEHICLE WAS REPAIRED BY TWO MECHANICS; HOWEVER,THE FAILURE CONTINUED TO OCCUR. THE VIN, NUMBER OF CYLINDERS, AND ENGINE SIZE ARE NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 33,000.

WE HAVE TWO HONDA PILOT 2004 AND 2005. APPROXIMATELY 6 MONTHS AGO THE AIR BAG (SRS) LIGHT ON THE 2005 CAME ON, TODAY THE LIGHT ON THE 2004 IS ON. *TR

I HAVE A 2004 HONDA PILOT EX THE DRIVER'S SEAT RIGHT SIDE GETS EXTREMELY HOT WHEN THE SEAT HEATER IS TURNED ON. THERE HAS NOT BEEN ANY INJURY OR ACCIDENT DUE TO THIS ISSUE BUT I HAVE SEEN WHERE IT HAS ONLINE DURING MY RESEARCH OF THIS PROBLEM. I AM TRYING TO BE PROACTIVE AND REMEDY A POTENTIAL PROBLEM BEFORE IT BECOMES A HAZARD. *TR

SEAT WARMER BURNED A HOLE IN DRIVERS SEAT WHILE I WAS DRIVING THE VEHICLE. IT IS A VERY COLD DAY HERE AND I HAVE LOTS OF LAYERS ON SO I DID NOT FEEL THE BURN FOR A WHILE. WHEN I FELT IT BURN ME AND SMELLED THE LEATHER BURNING I SHUT OFF THE SEAT WARMERS. THE DEALER TELLS ME IT WILL COST $800 TO BE REPLACED. YIKES - WHAT IF THE SEAT WARMER ACCIDENTALLY GETS TURNED ON WHEN I AM OUTSIDE MY VEHICLE - WHEN IT IS BELOW ZERO OUTSIDE I WARM UP MY CAR FOR ABOUT 20 MINUTES -WILL MY CAR CATCH ON FIRE? *TR

VTM-4 LIGHT AND CHECK ENGINE LIGHT ILLUMINATING. WAS TOLD THAT GAS CAP BEING LOOSE MAY CAUSE THIS TO HAPPEN BUT I HAVE BEEN ENSURING THAT IT IS PROPERLY SEATED EVERY TIME I REFIL THE VEHICLE.*CN

HEAD LIGHTS BURN OUT EVERY 2-3MO.S DARREL WALTRIP TELLS ME THERE IS NOTHING THEY CAN DO AND THAT THEY KNOW OF NO RECALLS ON THE VERY EXPENSIVE HALOGEN LIGHTS. I HAVE SPENT APPROX. 200.00 DOLLARS ON HEADLIGHT REPLACEMENT. I THINK THIS WOULD WARRANT A FREE CHECK AND REPAIR OF THE PROBLEM. *TR

WHILE DRIVING, THE CAR WENT IN TO FOUR-WHEEL DRIVE AND MALFUNCTION INDICATOR LIGHT WENT ON, AND STAYED ON EVEN AFTER THE CAR WAS RESTARTED. I TOOK IT IN TO THE DEALER, WHO REPLACED THE KNOCK SENSOR HARNESS WIRING DUE TO RODENT DAMAGE. *TR

IN APPROXIMATELY EARLY 2006, I NOTICED THE FRONT WHEELS WOULD SHIMMY WHEN I APPLIED THE BRAKES AT HIGHER SPEEDS. TYPICALLY IT WOULD OCCUR AS I WAS DRIVING DOWN STEEPER GRADES IN THE MOUNTAINS. I BROUGHT THIS TO THE ATTENTION OF THE HONDA DEALER IN APRIL 2006 WHEN THE VEHICLE HAD 35,418 MILES. THE HONDA DEALER DISMISSED IT AND SAID IT WAS PROBABLY DUE TO THE FRONT WHEEL STILL WANTING TO PROVIDE POWER WHILE THE BRAKES WERE APPLIED. CONSEQUENTLY, THE BRAKE SYSTEM CHECKED OUT FINE DURING THEIR INSPECTION. UNFORTUNATELY, THE PROBLEM STILL PERSISTS AND IS GETTING WORSE. I'VE ALSO NOW NOTICED THE PROBLEM WHEN I DRIVE ON FLATTER SURFACES AS WELL. THE PROBLEM IS MOST NOTICEABLE WHEN STOPPING AT SPEEDS OVER 50 MPH AND IS EVEN MORE PRONOUNCED WHEN DRIVING DOWN HILLS. MY CONCERN AT THIS POINT IS THAT THE VEHICLE WILL BECOME UNSTABLE BECAUSE OF THE EXCESSIVE SHIMMY THAT OCCURS IN THE FRONT WHEELS WHILE BRAKING AT HIGHER SPEEDS OR ON AN INCLINE. *TR

ON SUNDAY NIGHT MY 9 YEAR OLD CHILD WAS SITTING IN THE BACK SEAT OF MY HONDA PILOT. WHEN SHE TRIED TO PUT HER SEAT BELT ON IT GOT CAUGHT AROUND HER NECK. SHE THEN TURNED TO TRY AND FIX IT AND IT GOT WRAPPED AGAIN. IT LOCKED AROUND HER NECK AND WOULD NOT RELEASE. EVEN AS I TRIED TO LIFT HER TO GET ROOM AROUND HER NECK THE BELT KEPT TAKING IN THE SLACK. SHE HAD TO BE CUT OUT OF THE SEAT BELT BY A ONLOOKER WHO HAD A KNIFE. BY THAT POINT SHE HAD QUIT BREATHING. SHE HAD TO BE HOSPITALIZED AND HAVE NUMEROUS TESTS RUN ON HER TO ACCESS HER CONDITION. SHE HAS MASSIVE SWELLING TO HER FACE AND HER RIGHT EYE WAS SWOLLEN COMPLETELY SHUT. SHE HAS BROKEN BLOOD VESSEL FROM HER NECK UP ALL OVER HER FACE AND EVEN IN THE BACK OF HER THROAT. SHE HAS SO MANY BROKEN BLOOD VESSEL IN HER EYES THAT YOU CANNOT EVEN SEE THE WHITES OF HER EYES. AT THE TIME ALL OF THIS HAPPENED THE TRUCK WAS AT A STAND STILL IN A FAST FOOD DRIVE THROUGH. *TR

TL*THE CONTACT OWNS A 2004 HONDA PILOT. WHILE DRIVING 10 MPH, ANOTHER VEHICLE CRASHED INTO THE REAR DRIVER SIDE OF THE CONTACT'S VEHICLE. AS A RESULT, THE RETRACTABLE REAR SEAT DISLODGED AND SLASHED THE FACE OF THE REAR PASSENGER. THE REAR PASSENGER SUSTAINED A CONCUSSION. A POLICE REPORT WAS FILED. AS OF OCTOBER 3, 2007, THE DEALER AND MANUFACTURER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 72,000.

I BUCKLED MY 3 MONTH OLD SON INTO HIS BRITAX MARATHON CAR SEAT. I MADE A WIDE LEFT TURN AND ALL OF A SUDDEN HE STARTED TO SCREAM. I PULLED OVER AND PARKED MY CAR AND GOT OUT TO CHECK ON HIM. HE HAD SLID OUT FROM UNDER THE STRAP AND WAS LAYING PERPENDICULAR TO HIS SEAT. HE WAS UNINJURED, BUT WHEN I CALLED BRITAX TO TELL THEM, THEY WERE UNCONCERNED AND BLAMED ME. I KNOW HOW TO PUT HIM IN HIS CAR SEAT. I KNOW I TIGHTENED THE STRAPS, THEY SOMEHOW LOOSENED AND HE WAS ABLE TO SLIDE UNDER THEM. *JB

TL*THE CONTACT OWNS A 2004 HONDA PILOT. WHILE THE CONTACT'S WIFE PULLED INTO A PARKING SPACE AT 5 MPH, WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE LUNGED FORWARD AND THE ENGINE REVVED. THE CONTACT DROVE OVER A CURB AND CRASHED INTO A WALL. THE AIR BAGS DEPLOYED AND TWO OCCUPANTS WERE INJURED. A POLICE REPORT WAS FILED. THE CONTACT HAS YET TO TAKE THE VEHICLE TO THE DEALER OR A MECHANIC. THE CURRENT AND FAILURE MILEAGES WERE 22,000. THE BRAKES WOULD NOT STOP THE VEHICLE. THE VEHICLE HAD A DEFECTIVE AIR CONTROL VALVE AND THROTTLE. THE CONSUMER STATED HE EXPERIENCED THE PROBLEM 1 YEAR PRIOR TO THE ACCIDENT. THE VEHICLE WAS TOTALED. UPDATED 09/18/07. *JB

ON EVENING OF 3-25-07, AIRBAG LIGHT CAME ON. 3-27-07, WENT TO DEALER -COMPUTER OUT. PART ORDERED-TO BE IN 3/29. COME PICK UP CAR. DID SO - DROVE IN FEAR. 3/29- PART NOT IN UNTIL 4/3. TOLD NO RENTAL CAR AS CAR IS DRIVABLE (UNDER WARRANTY). CALLED NATIONAL/ZONE - AGREED WITH THIS. TOLD CAR IS DRIVABLE. WOULD NOT TELL ME CAR IS SAFE BUT THAT IS HONDA'S POLICY. THAT IF THE CAR IS DRIVABLE - THEY DO NOT GIVE A RENTAL. SO- TO ME - HONDA IS SAYING MY LIFE AND THAT OF MY FAMILY IS NOT THEIR PROBLEM AND IT'S UP TO ME TO GET A RENTAL. THE CAR IS DRIVABLE BUT NOT SAFE AND POSSIBLY DANGEROUS. I AM THE MEDICAL PROVIDER FOR A LARGE BRAIN INJURY REHAB FACILITY. I DON'T WANT TO HAVE MORE CLIENTS DUE TO HONDA'S POLICY!!! IF THE CAR IS UNSAFE OR DANGEROUS - IT IS NOT DRIVABLE!!!! A RENTAL CAR SHOULD BE SUPPLIED. I WOULD LIKE TO SEE HONDA HELD ACCOUNTABLE FOR THEIR POLICY AND FEEL THAT IT GOES AGAINST NHTSA BELIEFS. AIRBAGS ARE THEIR FOR A REASON BUT HONDA DOESN'T FEEL THEY ARE NECESSARY. *JB

WHILE DRIVING ON THE HWY, 4 WHEEL DRIVE ON HONDA, PILOT 2004, AUTOMATICALLY ENGAGED. WHEN I TRIED TO SLOW DOWN AND PULL OVER, THE CAR JERKED AND STARTED TO KNOCK. I HAD TO SPEED UP AGAIN TO 60 MPH AND THE SOUND WENT AWAY. I PUSHED THE 4 WHEEL DRIVE BUTTON ON THE DASHBOARD AND NO HELP. I FINALLY SLOWLY SLOWED DOWN THE CAR. THE 4 WHEEL DRIVE (VT-4) LIGHT WENT OFF, BUT THE AUTOMATIC TRANSMISSION LIGHT IS STILL ON. *NM

TL* - THE DRIVER THOUGHT SHE PUT THE A 2004 HONDA PILOT IN PARK, IN A DRIVEWAY WHICH SITS ON A HILL. THE DRIVER REMOVED THE KEY FROM THE IGNITION. THE CONTACT LATER FOUND THAT THE VEHICLE HAD ROLLED DOWN THE HILL AND HIT AN OBJECT. THE CONTACT DISCOVERED THAT THE VEHICLE WAS IN NEUTRAL. THE CONTACT DROVE THE VEHICLE TO THE DEALER. THE VEHICLE WAS DIAGNOSED AS HAVING A BAD IGNITION SWITCH. THE CONTACT STATED THE KEY SHOULD NOT HAVE BEEN ABLE TO BE REMOVED FROM THE IGNITION WHILE THE VEHICLE WAS IN NEUTRAL. *AK UPDATED 2/22/2007 - THE MANUFACTURER REFUSED TO FIX THE VEHICLE FREE OF CHARGE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. *NM

THERE IS A AUDIBLE VIBRATION IN MY '04 HONDA PILOT WHEN I DRIVE AT ABOUT 1400 RPM. IT SOUNDS LIKE A STRONG WIND NOISE, LIKE SOME SORT OF COVER VIBRATING. IT IS INTERMITTENT. ONCE THE RPM GOES BEYOND 1600RPM, THESE VIBRATIONS RARELY HAPPEN. I TOOK THE CAR TO THE DEALER AND THEY REPLACED THE ENTIRE EXHAUST LINE, INCLUDING THE CATALYTIC CONVERTER. THE VIBRATIONS CONTINUE TO HAPPEN. THE VIBRATION SEEMS TO COME FROM THE UNDERBELLY OF THE CAR, RIGHT IN FRONT OF THE PASSENGER COMPARTMENT. *JB

STEERING WHEEL SHAKE. BOUNCES IN HAND. CABIN NOISE/VIBRATION. *NM

SMOKE FROM THE DASH WAS NOTED. IT CAME FROM THE JUNCTION OF THE INSTRUMENT PANEL AND THE UPPER PART OF THE STEERING COLUMN. THE SMELL OF BURNT PLASTIC REMAINED IN THE CAR FOR ~4 HOURS. THE CAR WAS TAKEN TO A HONDA DEALER (FAIRFEILD HONDA - WILLIAMSPORT, PA). IT HAS BEEN THERE FOR 4 1/2 WEEKS AND THEY HAVEN'T BEEN ABLE TO FIND THE CAUSE? *JB

AS A CHILD PASSENGER SAFETY INSTRUCTOR I WANT TO INFORM YOU ABOUT THE SAFETY BELT SYSTEMS IN THE HONDA PILOT, ACURA MDX, TOYOTA SIENNA AND ANY OTHER VEHICLE WITH THE CENTER SEATING POSITION LAP/SHOULDER BELT EXTENDING FROM THE INTERIOR ROOF OF THE VEHICLE. ALTHOUGH LAP/SHOULDER BELTS PROVIDE UPPER BODY PROTECTION, THESE BELTS DO NOT FIT CHILDREN AND SOME ADULTS PROPERLY. EVEN CHILDREN USING BACKLESS BOOSTERS DO NOT FIT PROPERLY IN THE BELT SYSTEM. I DO NOT HAVE EVIDENCE OF ANY INJURIES OR DEATHS AT THIS TIME. IT IS MY OBSERVATION, BOTH PERSONALLY AND PROFESSIONALLY, THE MANUFACTURERS NEED TO REDESIGN THIS SEAT BELT SYSTEM. *NM

CONSUMER WOULD LIKE REIMBURSEMENT FOR TWO TIRES REPLACED ON A 2004 HONDA PILOT. *KB THE CONSUMER MECHANIC NOTICED UNEVEN TREAD WEAR ON THE REAR TIRES. THE VEHICLE WAS TAKEN TO THE TIRE DEALER FOR INSPECTION. THE TECHNICIAN INFORMED THE CONSUMER THAT SHE DEFINITELY NEEDED NEW TIRES BUT THAT THERE WAS NOTHING THEY COULD DO OTHER THAN SELL HER NEW TIRES. THE TIRE WERE ONLY TWO YEARS OLD. THE CONSUMER PURCHASE NEW TIRES ELSEWHERE FOR A BETTER PRICE. THE CONSUMER MECHANIC STATED THAT LOW TIRE PRESSURE COULD CAUSE WEAR. THE MECHANIC CHECKED THE OTHER TWO TIRES PRESSURE AND DISCOVERED THAT THE TIRES WERE UNDERINFLATED AT 32 PSI. THE PRESSURE IN THE DOORJAMB OF THE VEHICLE ALSO INDICATED 32 PSI. THE MECHANIC LOOKED ON THE TIRE AND SAW THAT THE MAX PSI WAS 44 AND INFORMED THE CONSUMER THAT SHE SHOULD MAINTAIN 40 PSI, NO LESS. *NM

SEVERE BRAKE SHUDDERING AND STEERING SHAKE WHEN BRAKING FROM HIGHWAY SPEEDS (WITHOUT ENGAGING ABS). RESURFACED ROTORS, PROBLEM PERSISTS AND HAS MAGNIFIED. *JB

MY 2004 HONDA PILOT HAS A CONTINUOUS VIBRATING PROBLEM AT 75 MPH. SEVERAL SOLUTIONS HAVE BEEN ATTEMPTED, BUT NOTHING FIXES THIS PROBLEM. *NM

2004 HONDA PILOT. STEERING WHEEL VIBRATION AT SPEEDS 75 MPH. CAN'T BE REMEDIED WITH BALANCE OF TIRES. MANY PILOT OWNERS ARE COMPLAINING ABOUT THE SAME ISSUE. *JB

DT*: THE CONTACT STATED AFTER BACKING OUT OF THE DRIVEWAY, THE VEHICLE WAS PUT IN DRIVE AND THE ACCELERATOR PEDAL WAS DEPRESSED MULTIPLE TIMES. WHEN THE VEHICLE RESPONDED IT SURGED FORWARD. THE ACCELERATOR PEDAL CONTINUED TO STICK. AT 1034 MILES, THE DEALERSHIP DETERMINED THE PEDAL WAS STICKING AND CLEANED THE THROTTLE BODY. THE DEALERSHIP STATED THE MANUFACTURER WAS MAKING AN UPGRADE FOR THE COMPONENT. WHEN THE UPGRADE WAS AVAILABLE, IT WAS INSTALLED. TWO MONTHS LATER THE ACCELERATOR PEDAL STARTED STICKING AGAIN. THE DEALERSHIP REPLACED THE GASKET AND CLEANED THE THROTTLE BODY AT 3395 MILES. THE VEHICLE WORKED PROPERLY IN WARMER CONDITIONS. THE ACCELERATOR PEDAL BEGAN STICKING WHILE DRIVING 9 MONTHS AFTER THE PREVIOUS REPAIR. THE THROTTLE BODY WAS CLEANED AGAIN, THE MECHANIC STATED THE VEHICLE WAS NOT REPAIRED, BUT THE VEHICLE WAS TO BE TAKEN HOME. THE VEHICLE BEGAN TO ACCELERATE ON A BRIDGE AND THE CONTACT HAD TO DRIVE IN ONCOMING TRAFFIC TO AVOID HITTING OTHER VEHICLES. WHEN THE VEHICLE WAS OFF THE BRIDGE, THE CONTACT DEPRESSED THE BRAKE PEDAL AND TURNED THE IGNITION OFF. THE MECHANIC FROM THE DEALERSHIP RETRIEVED THE VEHICLE FROM THAT LOCATION AND DETERMINED IT TOOK 2 FEET TO STOP THE VEHICLE. A NEW THROTTLE BODY WAS INSTALLED. THE MANUFACTURER DETERMINED IT WAS AN ENVIRONMENTAL PROBLEM AND THE THROTTLE BODY WOULD HAVE TO BE CLEANED EVERY 15,000 MILES. THE THROTTLE BODY HAD BEEN REPLACED TWICE IN 16,000 MILES. IN AN EFFORT TO IMPROVE THE VEHICLE, A NEW CABLE WAS INSTALLED

WHILE GOING AT ABOUT 20 MPH IN LIGHT RAIN, CAR IN FRONT OF ME BROKE SUDDENLY CAUSING ME TO HIT THE BRAKES. UPON STEPPING ON THE BRAKES, I HEARD A CLICKING SOUND. THE CAR KEPT ON ROLLING AND DID NOT STOP. I TRIED MOVING LEFT ONTO A TURNING LANE TO AVOID HITTING THE CAR IN FRONT. THE CAR SKIDDED OFF THE MEDIAN, AND CAR JUMPED THE MEDIAN WITHOUT LOSING VELOCITY. THE CAR WOUND UP ON INCOMING TRAFFIC, AT WHICH POINT A CAR COLLIDED WITH ME RESULTING IN INJURIES TO THE THAT DRIVER AND MYSELF. PROBLEM IS SIMILAR TO COMPLAINT ON FILE ODI ID NUMBER : 10117818. PROBLEM WILL BE REPORTED TO HONDA AS A POSSIBLE DEFECT. *NM

I AM THE ORIGINAL OWNER OF A 2004 HONDA PILOT. WE WERE DRIVING DOWN THE HIGHWAY ABOUT 65 MPH AND HAD WHAT WE THOUGHT WAS A BLOWOUT. HUGE BANG AND THUD. WE WENT TO PUT THE SPARE ON AND SAW THAT THE RIM HAD SPLIT IN TWO RIGHT DOWN THE CENTER GROOVE, WITH TWO FIST SIZE HOLES ON EACH SIDE. THE DEALER SAID I MUST HAVE HIT SOMETHING BIG, BUT I WAS IN THE CAR AND KNOW THAT WE DIDN'T. DEALER SAID THAT HE WOULD COVER IT JUST THIS ONCE AND PUT A NEW RIM AND TWO NEW TIRES ON THE CAR. DEALER SAID THAT HE WAS SENDING THE RIM BACK TO HONDA. DEALER SAID HE HAD NEVER SEEN ANYTHING LIKE IT IN THE 25 YEARS OF WORKING WITH CARS. I HAVE NEVER HEARD OF A RIM SPLITTING IN TWO AND I KNOW THAT IF I WAS DRIVING THERE WOULD HAVE BEEN AN ACCIDENT. *NM

2004 HONDA PILOT DEVELOPED PROBLEMS WITH SUDDEN ACCELERATION, BRAKING AND THE STEERING VIBRATES.*MR WHILE EXITING THE HIGHWAY THE CONSUMER NOTICED THAT THE BRAKES WERE NOT RESPONDING AS THEY NORMALLY DID. THE STEERING WHEEL ALSO VIBRATED VIOLENTLY AND THE RPM'S WENT UP BETWEEN 1800 AND 2100. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *NM

FRAME AND STRUCTURE TENDS TO SHAKE AND MAKE NOISE WHENEVER VEHICLE IS DRIVEN AT ABOUT 50 MPH. THE NOISE SOUNDS LIKE A HELICOPTER OVER THE VEHICLE. *AK THE CONSUMER WAS TOLD THAT WAS HOW THE VEHICLE WAS DESIGNED. *JB