2018 Harley-Davidson Fxlr

Defect. Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2018-2019 Softail FXBB Street Bob and 2018-2019 Softail FXLR Low Rider motorcycles. The front tire inflation pressure on the VIN label may be less than the stated front gross axle weight rating (GAWRs). As such, these motorcycles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other than Passenger Cars."

Risk. Incorrect tire pressure information may result in overloading the front tire, increasing the risk of a crash.

Remedy. Harley-Davidson will mail labels with installation instructions and owner's manual inserts to owners, free of charge. Letters informing owners of the safety risk were mailed November 13, 2024. Owner notification letters were mailed December 30, 2024. Owners may contact Harley-Davidson customer service at 414-343-4056. Harley-Davidson's number for this recall is 0628.

LIQUID GASOLINE EXPELS FROM FUEL TANK OVERPRESSURE VENT TUBE, AT A RATE >5 DROPS/SEC, ANYTIME WHEN THE ENGINE IS RUNNING AND THE TANK IS AT OR BELOW 1/2. DEALER WARRANTY REPAIR, 2ND ATTEMPT, SOLUTION WAS TO REVERSE THE VENT LINE CHECK VALVE SO THE FUEL LEAK OUTFLOW STOPPED BUT NOW THE FUEL TANK BUILDS CONSIDERABLE PRESSURE WITH AMBIENT OR OTHER TEMPERATURE RISES LEAVING THE ONLY VENT PATH AS THE GAS CAP REMOVAL. VIDEO AVAILABLE OF BOTH FUEL LEAK AND FUEL TANK PRESSURE RELIEF. THE FUEL LEAK ISSUE WAS FIRST NOTICED ON 07/09/2018; HOWEVER IT WAS NOT RECOGNIZED TO BE A CONSTANT ISSUE AS THE FUEL TANK WAS NORMALLY KEPT BETWEEN FULL AND 5/8 DUE TO COMMUTE PATTERN. ON 04/07/2019 IT WAS NOTICED AGAIN AND VIDEO OF THE FUEL EXPELLING WAS CAPTURED AND SENT TO DEALER ALONG WITH OBSERVATION OF 1/2 TANK OR BELOW REQUIREMENT FOR THE FUEL LEAK TO OCCUR. THE FUEL TANK OVERPRESSURE ISSUE WAS REALIZED AFTER 05/03/2019 AND VERIFIED SEVERAL TIMES SINCE.

FOR SOME REASON THE FUEL CAP VIBRATES QUITE LOUD AT CURTAIN RPM. I ALSO HAD ISSUES WITH THE BRAKES. THE REAR BRAKE WAS SQUEALING A LOT AND AT ONE POINT MY FRONT BRAKE WAS GOING SOFT ON ME. THE FIRST TIME I HAD IT IN THERE FOR THAT REASON THEY CALLED ME THE NEXT DAY AND TOLD ME THAT THEY DIDN'T HEAR ANYTHING, THE BRAKES OF THE CAP. OF COURSE I WAS NOT HAPPY WITH THIS AND TOOK IT BACK THE FOLLOWING WEEK. THIS TIME THEY SAID THE SAME THING, THAT IT COULD BE HEARD AND NOTHING IS WRONG WITH THE BIKE. AFTER THAT I CONTACTED HARLEY DIRECTLY AND WITHIN 2 HOUR RECEIVED A CALL FROM ROMMEL HARLEY AND ALL OF A SUDDEN IT TURNS OUT THAT THE PART NUMBER AS MY GAS CAP WAS FOUND TO BE DEFECTIVE AND THE NEW MODEL WAS ORDERED, ALSO THEY BROKE MY BRAKES DOWN TO PIECES TO FULLY INSPECT THEM AND HAND FILE THEM. THE ISSUE WITH THE FRONT AND REAR BRAKES ARE BETTER BUT I CAN TOLERATE IT, AS FOR THE GAS CAP IT STILL IS DOING THE SAME THING. WHEN I CONTACTED THEM I WAS TOLD NOTHING MORE CAN BE DONE SO AGAIN I CONTACTED HARLEY DIRECTLY AND ASKED WHAT COULD BE DONE. THEY CALLED ROMMEL AND SPOKE WITH THEY. I WAS CALLED BACK AND INFORMED THAT NOTHING WOULD BE DONE AND I HAD TO DEAL WITH IT BECAUSE ROMMEL SAID NOTHING WAS WRONG. ALSO HAD THE CHECK ENGINE LIGHT CAME ON. CODES P1510H P2127H P2138H. REDUCED POWER MODE ALONG WITH RANDOM THROTTLE FROM ALMOST STALLING TO THE BIKE DECIDE TO GIVE ITSELF FULL GO REQUIRING EITHER TAKING THE BIKE OUT OF GEAR OR PULLING THE CLUTCH IN. NOTHING WAS DONE BECAUSE "WE NEED