2015 Grand Design Momentum

Defect. Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.

Risk. An electrical arc increases the risk of a fire.

Remedy. Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.

Defect. Grand Design RV (Grand Design) is recalling certain model year 2015-2016 Momentum toy haulers and Solitude recreational trailers manufactured July 8, 2014, to August 31, 2015, equipped with certain aluminum black ladders manufactured by Christianson Industries. These ladders have retractable hinges, each with a welded 'top hat' that can separate from the hinge.

Risk. If the hinges separate from the ladder while in use, the ladder may fall from the vehicle, increasing the risk of injury.

Remedy. Grand Design will notify owners, and dealers will install a bracket over the back of existing hinges, free of charge. The recall began on December 16, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910008.

Potential frame failure. First noticed [XXX]. Grand Design contacted, but no appointment due to "Customer Care Center" being moved. Referred to Royal RV in Middlebury, IN. Appt. set for Mid May. No concern by GD that we would be traveling 1500 miles. Visual inspection @ Royal RV suggested potential frame failure. Appt. set for June 18th for full inspection. Both Grand Design {case# XXX} and Lippert Components {case# XXX) where notified of the situation and offered opportunity to visit Royal RV while the RV was there. During the time before returning to Royal RV a YouTube video was discovered showing the same RV as ours with the exact same issues had been shared with GD on March 28th, 2018. RV returned to Royal RV XXX, 2022. Their inspection identified broken welds same area as shown on the above mentioned video. After much effort, Lippert arrived XXX 2022 to make repairs. Lippert Tech noted that delamination under bedroom slide was most likely caused by broken welds but he could not correct. Contacted Grand Design but could not schedule an appointment due to "rally appointments". Appointment set for our return in May, 2023. No concern by Grand Design on our 3000 mile round trip. RV returned to Grand Design on XXX, 2023. Very little detail on what corrective action taken other than to repeat "your frame flex" problem corrected. Much more detail on the bedroom slide issue. A section of the outside wall removed as well as the complete slide to repair broken welds. We picked up R

I have developed a severe case of Frame Flex in my RV. When the RV is put on the hitch and the weight of the RV is transferred to the truck, there is a lot of flex in the upper deck of the RV. This flex is outside of the suggested tolerance of the manufacturer. This could be a result of frame failure inside the upper deck.

The front frame of my rv is broken in the pin box area

Mounting bolts from frame to Rv front sidewall are in 3/8” lag bolt mounted in pine wood (all are striped, won’t tighten). This allows the complete front Rv wall to move allowing further frame issues. Holes in frame rail are 1/2” , grand design installed smaller lag bolts 3/8” this has caused the bolts to eventually fail. This is happening on approximately 30% or more of Grand Design RVs. The factory needs to provide a recall on this problem.

Front frame failure, yes, trailer is sagging in the front, inspected by insurance co., no warning