2021 Ford Ranger complaints

The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal. The contact stated that the transmission unexpectedly downshifted before slamming into gear. There were no warning lights illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact was informed by the dealer to call the manufacturer for assistance. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 59,000.

The contact owns a 2021 Ford Ranger. The contact stated while reversing, the back over prevention system failed to function as intended. The contact stated that the message to “See the Dealer for Repair” was displayed. The back over prevention camera system had displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with a failed rear-aide back-over camera. The contact was informed that the back over prevention camera system needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall however, the VIN was not included in the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000. The VIN was unavailable.

Transmission needed to be replaced before 50000 miles. Finally got replaced at 53000. New transmission has 11500 miles in it and is having the same problems as before. Dealership couldn’t replicate the problem and Ford is unwilling to help. Truck rough shifts, clunks, and shudders. At times won’t go into gear at lower speeds. Turned a corner at a slow speed and hit the gas but the truck wouldn’t accelerate for 1-2 seconds and I was almost rear ended by the car behind me. Truck has failed to go into gear and accelerate in traffic more than one time. 4 years old with 64xxx miles and in need of a third transmission.

Transmission looses power when accelerating, usually between 2nd - 4th gears. This is an safe condition when I am entering traffic on highways. No warning lights have appeared.

Right rear leaf spring was found to be broken on vehicle 2ith 70,000 miles by Ford technician during oil change. I was informed that it was not a recalled defect, repair part was on back order and was not advised as to the safety of driving the vehicle.

It started moth my vehicle losing power and chugging , dealership diagnosed as transmission (10 speed ). After all of the Ford appointed tasks to fix said problem, valves were replaced , did not work then entire transmission was replaced . After 7 times in the shop and many missed work hours . Maybe 2 weeks later truck starts bucking as I enter the highway , was close to getting rear ended . Brought vehicle to dealership 2 weeks later diagnosed with the turbo going out in it . And then Friday 3/14 driving home from work the check engine light comes on. Says emission issues ? Also says need to service engine soon . Dealership says it is fine to drive they will call me when they can figure it out ? My vehicle ha less than 25k miles these issues started when I had 17k on it Started 8/5/24

2021 Ford Ranger Transmission slipping during driving . causes vehicle to jerk during shifting in gear 3, 4, 7, which causes the vehicle to jerk also during down shifting it shifts very hard. i looked online and apparently ford will not issue a recall because they will lose money on all the repairs they must do. if they changed the rings in the 2022 transmission they are aware of the issue obviously but refuse to address the problem. for us 2021 owners we are fucked. 9000$ repair for us.

Everyone that I have talked to that owns a 2021 Ford Ranger have transmission issues including me. Clunking/ jumping/ and very harsh shifting..

Transmission failed at 65000 miles on a one owner vehicle. Conveniently just after the warranty expired. Cost to fix transmission $9000.00. Those transmissions are faulty and many people are experiencing problems.

While driving the vehicle started to act like it could not find a its gears in the transmission and made a loud clunk then stopped moving attempted to put it in reverse and it sook a minute before it shifted and made another loud clunk then lost both forward and reverse. Currently at ford getting a new transmission. Vehicle stopped moving while driving and hard to get off the road, No warning lights came on in the vehicle.

It wearing tires on the inside quicker the it should. The dealer aligned and said it was with in specs.

The wrap material on the front driver side and passenger inside door handles is separating and is very sharp. I noticed it a couple of days ago when I went to get out of the vehicle and I reached to open the door, and it sliced open my finger. I told my passenger what had happened, and he checked the passenger side inside door handle, and he said that his was the same way.

Increasingly the transmission, when cold, was experiencing difficulty shifting between 3-4-5 and not shifting into 9-10. When the weather started reaching zero degrees overnight, the vehicle was reluctant to move and, once it began moving, would not shift out of 1st. After allowing the vehicle to warm up, it would reluctantly shift from 3-4-5 and then, without any speed reduction, suddenly downshift with a shudder and bang. Vehicle is in the Ford dealer while they preform the TSB related to this universally known problem with the 10R80 transmission. Despite the TSB “approving” significant part replacements, including clutches, modules and converter, the dealer is required to proceed a few steps at a time and then test the vehicle to document the need to replace more components, before proceeding the the TSB. Ford is avoiding what should be a full recall involving providing the dealers with a rebuilt transmission and converter with the dealer’s responsibility only being the replacement of the transmission. Ford’s dealing with this very well know problematic transmission with a TSB is grossly unfair to the dealers and exceedingly unfair to the consumers who eventually bear the financial burden.

The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal. The contact stated that at first there were no warning lights illuminated; however, after a while the "Power Train Malfunction - Reduced Power" message was displayed. The dealer and an independent mechanic were notified of the failure and acknowledge that the defect was a common failure. The contact was provided an estimate for a new transmission. The manufacturer was also notified of the failure and the contact was offered financial assistance if the vehicle was serviced by a Ford dealer. The vehicle was not repaired. The failure mileage was approximately 37,000.

Wiring for back up camera failed and short circuited - will attempt to retain the components for inspection needs. Safety concern - when wire short circuited, it burned the wire at the control module in the dash board, causing the control module to also fail - according the the ford service advisor at my dealership. Issue was diagnosed and inspected by Titus Will Ford service center at 11503 Pacific Hwy SW, Lakewood, WA 98499 - phone # (253) 753-1253. No warning lamps/messages/symptoms.

Transmission issues that are known to the manufacturer. Backed out onto a road while there was no traffic, shifter into drive and the transmission made a banging noise and refused to shift. Cars started coming in behind me and I was blocking traffic. Was able to get it into neutral then into drive so I could pull away. This is a well known issue to Ford and they have only offered service bulletins that provide temporary fixes until vehicles are out of the factory warranty period and Ford no longer has to cover repair costs. Vehicle only has 50,000 miles and the transmission issues started around 30,000

Oil level 1/2 quart high, and smells like gasoline.? Actual mileage on truck is 8,544 last oil change @ dealership @ Wiscasset Ford on 5/6/24 in Wiscasset, Maine. 378 Bath Road 04578-9431 I was informed this is an issue. But what is the fix.?

We love Ford Rangers. This is my 4th. It has been wonderful, until [XXX]. We had to replace an A/C, but that's normal. We've also noticed a very few times that when the transmission shifted, there was a little jolt. But that was rare. But on [XXX], after stopping at a light at the intersection of [XXX] and [XXX] in Indianola, MS., we had a frightening experience. After crossing the busy highway I began to accelerate and suddenly the truck jolted forward and quickly accelerated to 70 mph. I hit the brakes, and after a couple of taps it slowed down. But when I gave it more gas, it only roared twice, and no power...with big trucks beside and behind me. That was frightening. Then it returned to normal, and I went on to Isola, MS. Upon leaving it didn't want to move forward, only roaring, but then quickly responded and was back to normal. I was scheduled for a 12:30 lunch meeting in Leland, MS and my wife and I proceeded. All normal. Upon leaving Leland, same thing. No power at first, then it moved forward, normally. We noticed it was a rough shift at 45 mph as we got out on freeway. I called the service department at Hallmark Ford, Batesville, and told mgr. my problem. Thought it might be fuel pump, filter, or transmission. Upon arrival at home, it wouldn't go in reverse. I sent it to dealer on wrecker. Got second opinion. Both say it needs a new transmission at $8900. My concern is will the new transmission have same problems...reading now on internet of other people who have ha

2021 Ford Ranger - 10R80 Transmission Failure while driving. Hard shifting, lurching, slipping gears then abrupt failure. It is available. Currently at Diehl Ford in New Brighton, Pennsylvania. - It went from being 90% drivable to coming to complete stop with no transmission engagement at all. Break down occured while climbing a grade and the complete stop happened over a blind crest with guard rails on either side. Leaving myself vulnerable to being struck from behind and another driver having minimal time to see then avoid me or potentially have no where to go but through me. Can I add documents later as I get them?

The two rear brake rotors were 75% rusted through, this truck only had 5,642 miles on it at the time. Brake pedal was soft, went to the floor to stop. Asked local ford dealer to look at and they wanted to charge me for two rear rotors and brake shoes. I informed them that I thought this would be a factory defect, they determined it wasn’t. This was unexceptable to me. So I took it to dealership where I purchased truck and they agreed that this was a factory defect and replaced. The only reason I’m writing you is due to all the complaints listed on your site for this truck, not one issue about rusted (badly) rotors. Unless this is an issue but just not being found.? I did read quite a few complaints about soft brake pedals though

Excessive fuel in the oil. Oil smells of gas and is diluted. Almost a quart high at 3000 mile mark. Dealer and Ford admit this may be an issue on some engines but it is supposed to be normal??? We installed a pcv catch can and it will fill up with fuel in about 800-1000 miles. That is almost 8 ozs. The included photo shows oil at about 4000 miles. The second hole you see in the dipstick is above the full mark.

Water leaks into spark plug wells causing vehicle to lose power no cover is over the sparkplugs

I am, yet another of numerous Ford Ranger owners with the same brake issue. I completely concur with the November 3, 2023 complaint (NHTSA ID Number: 11553431) and everything stated in it. I must add that a few times I got pretty scared that I would not be able to stop in time as planned. The brake pedal travels (literally falls) far deep to the floor before ANY, however slight, breaking effort is achieved. Disturbingly, if I don’t keep the brake pedal firmly pressed the truck will move forward!

This is what is going on with my 2021 Ford Ranger automatic 10-speed transmission and the vehicle's drivability. When bringing the vehicle to a stop, the shifting down to a 1st gear is often executed so harshly that I can hear the driveshaft ringing in reaction to the transmission hard shift nearly locking the rear wheels. The whole act resembles "slamming" a shifter into a gear without disengaging a clutch that can be achieved on a standard (stick-shift) transmission "bangs" at a full stop feeling like being rear-ended. After a full stop, the take-off is “sluggish” - The truck gets moving in the 1st gear, the engine revs up to 2500 - 3000 RPM the transmission hesitatingly shifts into 3rd (always skipping 2nd), the noticeable sound of ‘gear grinding’ is heard when the 3rd gear is engaging. The whole process usually takes 2 to 3 seconds, the truck would literally "drift" before any noticeable acceleration is achieved. Lastly, since the day days of ownership, in the area around 2K miles and above, the truck, when the gas pedal is “floored” (ea. on the highway), would get a hard "mallet-like: kick with a significant audible, hard knock somewhere in the drivetrain and at times during this even the "explosion-like" could be heard from the engine compartment making the vehicle shudder.

Truck has hard shifting and loss of power, usually on startup and at low speeds (like in a parking lot) that cause lurching and no response from gas pedal. These events are not reliably repeatable, and result in no dash lights. Sequence of events, start truck, place in reverse, back out of parking spot, place in drive, apply throttle/gas pedal, while driving slowly, car will hard shift, sometimes resulting in a lurch forward, approach exit to parking lot, truck rolls down slight incline of parking lot entrance and throttle is unresponsive to gas pedal, no power, release pedal, wait a second or two, apply pressure and it works. Driving at low speeds in parking lots, truck cannot decide what gear to be in, and sounds horrible, 5-10 mph. Approaching stops on an incline, driving forward, release gas, start to apply brakes, truck will shift and apply power while under braking. Once, pulled in to parking space, backed out to straighten, placed in drive, wrench light came on, no power. Turned the truck on and off again, and that fixed the issue. All incidents between 20k and 40k miles.

The critical level of FUEL DILUTION (Fuel% = 5.5) in the motor oil of this vehicle's 2.3L EcoBoost engine poses a Safety Hazard due to its system's Fuel Leaks and Fire Danger probability existing since the vehicle purchase. I am concerned for the safety of everyone because this vehicle has been evaluated to be a Fire Hazard with 104.5C via ASTM D93 Closed Cup Flash Point. The Motorcraft's Safety Data Sheet (SDS) is listed as >185C. Ford Motor Company (FMC) inspected the vehicle numerous times but safety issues remain. For this reason, I took it out of service and parked at my residence until this problem would be resolved entirely in according with the law. The vehicle mustn't be driven on its power.

The contact owns a 2021 Ford Ranger. The contact stated that while starting the vehicle and shifting into drive(D), the messages “Pre-collision Assist Not Available" and "Cruise Control Not Available" were displayed. Additionally, the passenger’s side air bag warning light was illuminated. The vehicle was not diagnosed or repaired by a local dealer or an independent mechanic. The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.

The contact owns a 2021 Ford Ranger. The contact stated while driving at approximately 40 MPH, the vehicle was not responding when the accelerator pedal was depressed. Additionally, the vehicle was shaking from left to right. The check engine warning light illuminated, and the contact pulled to the side of the roadway. The vehicle was towed to the dealer where it was diagnosed with a water leak that damaged the spark plugs and spark plug welds. The manufacturer was made aware of the failure. The failure mileage was approximately 13,000.

Harsh shifting into D, loss of power when accelerating while cold. Sometimes would start across an intersection then buck, loose power and slow down then SLAM back into gear and chirp the rear tires. Technical Service Bulletin 23-2350 was performed on 11/15/2023 which updated the trans tables and cleared some codes. This helped the issue for about a week but then truck was in again on 1/22/2024 for TSB 23-2350 a second time which replaced the CDF drum. A month later, 800 miles, 2/18/2024 truck shifted HARD while in cruise control on the turnpike in traffic and lost power. DTC P0766 check engine light came on and truck would no longer move. Transmission fluid sprayed under truck. Had to be towed to dealership. Clutch Valve D was replaced. Two months have gone by and the hard shifting into D and occasional complete loss of power still occurring. Waiting for the next check engine light to appear to take it in again. I now drive very conservatively because I don't know if it will stop moving half way across an intersection again.

The contact owns a 2021 Ford Ranger. The contact stated that while in the reverse gear, the rear cross-traffic warning did not alert the contact that the vehicle was close to an object. As a result, the contact crashed into a pole. No injuries were sustained. A police report was not filed. The vehicle was taken to the dealer where the bumper and the harness for the rear cross-traffic warning system were replaced. The manufacturer was aware of the failure and a case was opened. The failure mileage was approximately 14,850.

Brakes pedal is soft and keeps going down as you push on it. The peddle does not pump up. Ford dealer says that that’s the way Ford Ranger brakes feel. There are no warning lights and no noise coming from the brake system. Engine idle, the engine idles at 900+ rpm’s, if you don’t keep the break pedal firmly pressed the truck moves forward. I found myself in the middle of an intersection at a stop light this morning. Ford dealer says that is what Ford specifically requires that the idle be set at. I have found numerous similar complaints on the internet from Ford Ranger owners.

It is quite easy to depress the brake pedal in such a way that one's foot also engages the accelerator pedal. This has happened to me several times, causing the truck to lurch forward rather than stopping dead as is my intention. Looking online, I see this has also happened to many others on Ford trucks. I have been driving for over 50 years and this has never happened on any other vehicle.

The contact owns a 2021 Ford Ranger. The contact stated while driving 60-65 MPH, the message "Trailer Connected" was displayed; however, there was no trailer connected to the vehicle. The contact pressed OK and messages indicating that the driver's side and the passenger's side trailer bulbs were faulty were displayed. The contact pressed OK, and the message "Trailer Disconnected" was displayed, then disappeared after the contact pressed OK. The contact stated that the failure had been recurring intermittently while driving. The dealer was notified of the failure and informed the contact that the VIN was not included in a recall, and he would be charged a repair fee. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 35,600.

10 speed transmission issues: hard shifts, feels like slipping while in gear and driving, transmission "lunged" at a STOP sign jerking the truck forward, transmission "bangs" during some upshifts, transmission "bangs" at a full stop feeling like being rear-ended. Erratic shifting and unexpected forward lunging are a safety issue of myself and other drivers. Have not asked dealer to investigate yet. No warning lamps or messages. Unable to reliably replicate the issues.

The contact owns a 2021 Ford Ranger. The contact stated that the vehicle had previously been involved in a crash due to unintended acceleration, which caused the contact to rear-end another vehicle. The vehicle had body and paint repairs performed; however, the vehicle later experienced jerking, and the transmission was seized while driving. The transmission warning light was illuminated. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The dealer confirmed that there was no recall associated with the VIN. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 79,000.

A few day ago I noticed a knocking sound coming from the read driver side suspension when driving over speed bumps. After a visual inspection nothing was found. After a few days of the issue continuing, the vehicle was taken to a garage with a hydraulic lift. The vehicle was lifted and a full inspection of the suspension system was done. What was discovered was a bit nerve racking. The front mount of the driver side leaf spring assembly was connected to the frame of the vehicle with a single bolt and nut. The bolt was hanging lose roughly 3/4 of the way out from it's original position and not nut was in sight. I checked the passenger side leaf spring mount and discovered that the bolt and nut were in place but the nut was finger tight. I was able to unscrew the nut off the bolt with no tools. If the bolt would have come completely lose and fallen out, this would cause the leaf spring/ rear axle to disconnect from the frame of the vehicle. The results of that could be mild to catastrophic. That would all depend on the speed the vehicle would be travelling at during the failure. This vehicle is factory original. No after market work/parts have been installed on this suspension. No off road driving was done on this vehicle.

The surface of the drivers side interior door handle has peeled and created a dangerously sharp edge that WILL cause physical harm to the drivers hand. The middle finger on my left hand was sliced open on 06/15/2023. I made an appointment with the dealer to have to handle inspected/replaced and a service done. The vehicle is available for inspection and I have photos of the faulty door handle and my injury. I came across a post on the internet that shows ford has had an issue with this on other vehicles. I read GM also had an issue with this as well. https://blueovalforums.com/forums/index.php?/topic/54795-ouch-peeling-fusion-doorhandle-cuts-me-deep/ In 42 years on this earth, I have never had a vehicle do this. The handles are clearly made of poor quality materials.

The contact owns a 2021 Ford Ranger. The contact stated that while driving at highway speeds, the Pre- Collision warning light illuminated, and the vehicle would abruptly decelerated. The contact stated that the failure had occurred on several occasions. The contact stated that during the failure, there were no objects or vehicles nearby. The vehicle was taken to the local dealer on several occasions and the ECM and PCM were replaced; however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 11,000.

The contact leased a 2021 Ford Ranger. The contact stated that while driving at an undisclosed speed, he noticed a cloud of white smoke coming from the exhaust. The contact then stated that while driving at various speeds, the vehicle failed to shift into the intended gear. Additionally, the contact stated that while shifted into drive(D) or reverse(R), he heard a clunking sound and while shifted into park(P), the vehicle rolled several inches further than normal. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed; however, the contact was not informed of what needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that while driving at an undisclosed speed, he noticed a cloud of white smoke coming from the exhaust. No warning lights illuminated. The dealer was notified of the failure and the vehicle was then towed from the residence back to the dealer where the contact was then informed that the transmission was previously replaced. The vehicle was then towed to a different dealer where it remained. The contact stated that service was denied. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

The backup camera on my truck washes out at night when the lights are turned on and backing up, rendering it useless. The washout is not as severe with just putting in reverse without lights, but still dangerous. The local Ford dealer states this is inherent in all Rangers, Broncos and other vehicles.

On Monday 15th of May the ford ranger was involved in a front end collision. The air bags did not deploy and the engine compartment caught fire. I was un able to open door and other doors would not unlock from inside switch. Finally able to kick door open will the truck filled with smoke and people put out fire.

Vehicle has a hard shift and jerks when shifting up and down

Ford Ranger XLT VIN [XXX] Ford File CAS [XXX] opened 02/08/23 Contact: [XXX], [XXX] Ext [XXX] Acceleration Incidents on trips between Mobile and Dallas. 1. Vehicle purchased March, 2021. Current mileage 6400 +/- 2. In July, 2022, after driving 6 hours at interstate speeds using cruise control, we exited interstate and drove secondary streets to hotel. On entering parking lot we idled toward parking space and I applied brake to slow and throttle went wide open. I braked and shifted to neutral to stop forward motion. No recurrence on remainder of trip to Mobile or in subsequent city driving. 3. On 02/04/23, after driving 6 hours at interstate speeds using cruise control, we exited interstate and drove secondary streets to hotel. On entering parking lot, we paused with engine running to punch in gate number. When gate opened, we idled forwarded toward parking space. I touched brake to slow and throttle went wide open. I applied brakes and shifted into neutral. 4. On 02/05/23, we left hotel and stopped for gas. We drove four hours at interstate speed, intentionally without using cruise control. After exiting interstate, we drove to apartment and stopped at entrance with engine running before idling through parking lot gate. I touched brake to slow and throttle went wide open. Applying brakes did not stop truck and I shifted into neutral and turned off ignition. At least three nearly identical incidents found reported on internet dating from 10/2020, at least one of which Ford ope

The contact owns a 2021 Ford Ranger. The contact stated while driving in the morning at an undisclosed speed and depressing the brake pedal, the brake pedal would depress below the gas pedal. The contact stated that the brake pedal was soft while attempting to slow down and stop the vehicle. The contact stated there was no warning light illuminated. The contact was able to continue driving to his destination. The contact took the vehicle to the local dealer, but the mechanic found the brakes tested within Ford recommended specifications(Mechanics can only test per Ford prescribed method). The contact continued to experience failure. The contact took the vehicle to another local dealer: Varsity Ford (3480 Jackson Ave, Ann Arbor, MI 48103: (734) 996-2300) but the mechanic was unable to duplicate the failure. The contact continued to experience a failure. The manufacturer had not been informed of the failure. The failure mileage was 19,408.

The contact owns a 2021 Ford Ranger. The contact stated that while driving at highway speeds, the vehicle hesitated while depressing the accelerator pedal on four separate occasions, with the check engine warning light illuminated. Despite the failure, the contact managed to drive the vehicle to a local dealer where a mechanic discovered a misfire in one of the cylinders; caused by water found in the spark plug well. The dealer managed to drain the water from the spark plug well; however, corrosion was found in the spark plug well. The manufacturer was notified of the failure and the contact was given a case number. The vehicle was repaired. The failure mileage was 9,952.

On multiple occasions the transmission has slipped when changing gears .This has happened when trying to merge into traffic . One time almost causing someone to rear-end me . It also fails to downshift some times when stopping , causing me to brake much harder than normal . I will be taking it to the dealer soon , to see if this can be fixed . These issues can be a little scary at times . There have been no warning lights or messages . This has happened at least a dozen times now . The first incident with the transmission I think started in 10/2022 . it was sporadic at first , but seems to happen almost daily now .

The contact owns a 2021 Ford Ranger. The contact stated while driving at an undisclosed speed, the brakes made an abnormal sound. The vehicle was taken to a dealer, where the brakes were inspected. The dealer informed the contact that the brakes were in good condition; however, the failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

There is gasoline in my oil. I had an oil analysis from a lab, and they confirmed there is too much gasoline in my oil.

The engine has a squeaking noise, unknown where it is from. The noise is upon start up and while driving, I do not know if the issue will lead to engine failure. Which if the engine locks up and cause drivability failure.

2021 FORD RANGER. CONSUMER WRITES IN REGARD TO SAFETY RECALL RELATED TO CRUISE CONTROL FEATURE. THE CONSUMER FEELS AS THOUGH THE CRUISE CONTROL FEATURE PUTS HIM TOO CLOSE EVEN IN THE 4BAR RANGE SETTING .