2005 Ford Ranger complaints

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THE INERTIA SWITCH MALFUNCTIONED, CAUSING THE VEHICLE TO STALL WHILE THE CONTACT ATTEMPTED TO PARK. THE VEHICLE WOULD ALSO SPORADICALLY FAIL TO START. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO ADVISED THE CONTACT THAT THE INERTIA SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE SWITCH REPLACED. THE FAILURE MILEAGE WAS 52,000.

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE PASSENGER SIDE TURN SIGNAL FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE STEERING COLUMN MULTI FUNCTION SWITCH WOULD NEED TO BE REPLACED. THE CONTACT WAS INFORMED OF A RECALL FOR NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED BUT STATED THE VIN WAS NOT PART OF THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 70,000.

AS A PASSENGER ENTERED MY TRUCK, THEIR FOOT HIT THE INERTIA SWITCH KILLING THE FUEL SYSTEM. THIS HAS NOW HAPPENED APPROXIMATELY 15 TIMES, 3 OF WHICH NO PASSENGER WAS EVEN IN THE TRUCK. THIS SWITCH IS PLACED IN A COMMONLY KICKED AREA AND ONCE TRIPPED THE FIRST TIME IT BECOMES EXTREMELY SENSITIVE TO VIBRATION. ONE TIME IT CUT OFF WHILE I WAS IDLING IN LINE AT A DRIVE-THRU. IT SHOULD BE RECALLED AND RELOCATED. *TR

HIT A PARKED VAN. *TR

VEHICLE ENGINES SHUTS OFF WHILE AT HIGHWAY SPEED. HAS HAPPENED BETWEEN 20 TO 30 TIMES OVER THE LIFE IF THE VEHICLE. HAS HAD 4 INERTIA SWITCHES INSTALLED. FORD HAS CLAIMED " INTERMITTENT PROBLEMS ARE NOT OUR PROBLEM." MULTIPLE FORD DEALERSHIPS HAVE ALSO SAID THAT IT DOESN'T "THROW A CODE" AND IS THEREFORE NOT IN NEED IF BEING FIXED JUST "A QUIRKY VEHICLE." I'VE ALSO BEEN TOLD THE ONLY WAY TO PERMANENTLY FIX THE PROBLEM IS TO BUY A NEW TRUCK. *TR

MULTIPLE SHUT OFFS FROM THE INERTIA SWITCH HAS BEEN GOING ON FOR 2+ YEARS AFTER DRIVING FOR 30-40 MINS TRUCK WILL JUST SHUT DOWN WHILE DRIVING HAS HAPPENED ON THE INTERSTATE, DRIVING AROUND TOWN OR SITTING AT STOP LIGHT. ENDED UP MELTING THE CONNECTION. HAVE REPLACED. *TR

MY VEHICLE (FORD RANGER) T-BONES ANOTHER VEHICLE THAT MAKES LEFT TURN RIGHT IN FRONT OF ME. MY VEHICLE MAKES DIRECT FRONTAL IMPACT INTO THE RIGHT SIDE OF THE OTHER VEHICLE AT APPROX 45 MPH. NO AIRBAG DEPLOYMENT FOR ME (DRIVER) OR THE ADULT PASSENGER THAT IS PRESENT IN MY VEHICLE. *TR

WHILE TURNING A CORNER THE TRUCK JUST SHUT OFF AND DIED. HAD TO PUSH IT OVER TWO LANES AND INTO A PARKING LOT ONLY TO FIND OUT THE FUEL PUMP INERTIA SWITCH WAS POPPED. RESET IT AND THE TRUCK STARTED FOR A FEW MINUTES BUT WHEN I WENT TO DRIVE OFF IT DIED AGAIN. RECHECKED THE INERTIA SWITCH AND THIS TIME IT WAS NOT POPPED. PULLED THE CONNECTOR OFF OF THE SWITCH AND JUMPED THE CONNECTOR AND THE TRUCK RAN FINE ALL THE WAY HOME. THIS IS NOT THE FIRST TIME THIS SWITCH HAS GIVEN ME TROUBLE. ABOUT SIX MONTHS AGO IT DID THE SAME THING BUT THOUGHT IT WAS THE FUEL PUMP AND REPLACED A $400.00 FUEL PUMP ONLY TO FIND OUT LATER THAT THE FUEL PUMP INERTIA SWITCH HAD POPPED. THIS SWITCH SEEMS TO POP IN SOME ODD AND BAD LOCATIONS WITH NO APPARENT REASON. NO BUMPS IN THE ROAD, NO HARD BRAKING, OR HARD ACCELERATION ETC. THIS TIME WHEN I PULLED THE SWITCH I FOUND THE CONNECTOR SLIGHTLY MELTED AND REALIZED THAT THERE WAS A LOOSE CONNECTION IN THE SWITCH ITSELF. HAD TO ORDER A SWITCH KIT WHICH RELOCATES IT INTO THE FUSE PANEL KICK PLATE OF THE TRUCK. FORD SHOULD RECALL THIS AS IT IS A GOOD WAY TO CAUSE AND ACCIDENT IF THE TRUCK WAS GOING HIGH SPEED AND ALL THE SUDDEN STALLS AND YOU LOOSE ALL POWER STEERING AND BRAKES ETC. COULD GET SOMEONE KILLED. THANKFULLY I CAUGHT MINE BECAUSE I AM A MECHANIC AND KNOW A LOT ABOUT FORDS. *TR

TOOK MY TRUCK FOR ITS NYS INSPECTION TO MY FORD DEALER-- TECH STATED HE COULD NOT PASS THE TRUCK BECAUSE OF EXCESSIVE RUST ON A PART OF THE FRAME. THIS VEHICLE HAS UNDER 39K MILES ON IT AND IS WELL- MAINTAINED. THE REST OF THE TRUCK IS PERFECT AND THE REST OF THE FRAME HAS AN EXPECTABLE AMOUNT OF RUST FOR THIS CLIMATE. I HAVE HAD FOUR OTHER FORD TRUCKS USED AND STORED UNDER SAME CONDITIONS AND NONE HAS HAD A PROBLEM WITH FRAME RUST. THE OFFENDING PART IS A FRONT CROSS MEMBER THOUGH WHICH SOME BOLTS PASS. THE HOLES AROUND THE BOLTS ARE "ROTTEN".

DRIVING ON I75 WHEN ENGINE STOPPED. I LOST ALL POWER. WAS ABLE TO COAST OFF THE ROAD AND ONTO THE SHOULDER. AFTER FIVE MINUTES, TRUCK STARTED AND DROVE HOME WITHOUT ANY FURTHER PROBLEM. CONTINUED TO HAVE SAME PROBLEM, DIDN'T MATTER WHAT SPEED I WAS DRIVING OR IF I WAS STOPPED AT A LIGHT, AND IT WOULD STOP REPEATEDLY IN ONE WEEK OR GO FOR MONTHS WITHOUT A PROBLEM. TRUCK WOULD STOP AND WOULD EVENTUALLY RESTART WITHIN A COUPLE MINUTES OR UP TO 30 MINUTES AFTER IT HAD STOPPED. I REPEATEDLY HAD TO COAST OR PUSH THIS TRUCK FROM THE ROADWAY WITHOUT ANY POWER STEERING. IN EARLY 2011, THE TRUCK STOPPED THREE TIMES IN ONE DAY. THE THIRD TIME, IT STOPPED IN FRONT OF FRIENDLY FORD, MONROE, MI. THEY KEPT IT FOR TWO WEEKS BUT IT ONLY STOPPED RUNNING FOR THEM ONE TIME AND IT REPAIRED ITSELF BEFORE THEY COULD FIND THE PROBLEM. IN MAY OF 2012, IT BEGAN STOPPING MULTIPLE TIMES IN ONE DAY. IT STOPPED AND WOULD NOT RESTART AND I HAD IT TOWED TO CREST FORD IN FLAT ROCK, MI. THEY DISCOVERED THE FUEL SHUTOFF INERTIA SWITCH HAD FAILED AND REPLACED IT AND THE PIG TAIL WIRING HARNESS. IT APPARENTLY HAD OVERHEATED FOR SOME TIME AND HAD MELTED THE WIRING HARNESS INTO THE SWITCH. I PAID $367.94 FOR THESE REPAIRS. AT THIS TIME THE TRUCK ONLY HAD 28,370 MILES ON IT. THE TRUCK WAS USED VERY LITTLE AND WAS ALWAYS KEPT INSIDE MY GARAGE. THE DEALER TOLD ME TO CONTACT FORD FOR POSSIBLE REIMBURSEMENT. FORD TOLD ME THEY DID NOT HAVE A RECALL FOR THIS PROBLEM AT THIS TIME BUT TO KEEP MY RECEIPT IN CASE OF A FUTURE

WHILE DRIVING DOWN THE HIGHWAY, THE HARMONIC BALANCER FAILED. THE PULLEY SEPARATED FROM THE REST OF THE BALANCER AND SLID BACK TO DESTROY THE CRANKSHAFT POSITION SENSOR. ONCE THE SENSOR FAILED, THE ENGINE STALLED. I WAS ABLE TO PULL OVER TO THE SIDE OF THE HIGHWAY, BUT THIS SUDDEN FAILURE IS DANGEROUS AND IF I WAS NOT ABLE TO GET TO THE SIDE OF THE HIGHWAY COULD CAUSE AN ACCIDENT. AFTER A LITTLE RESEARCH ON THE INTERNET THERE ARE SEVERAL OCCURRENCES OF THE SAME ISSUES ON THE FORD 4.0 ENGINE ON RANGER / EXPLORER. LOOKING AT THE NHTSA COMPLAINTS SITES THERE ARE ALSO SEVERAL OCCURRENCES OF THE SAME ISSUE (MORE THEN 1 YEAR, MORE THEN 1 MODEL): ODI ID NUMBER : 10356858, ODI ID NUMBER : 10356913. ODI ID NUMBER : 10450902, ODI ID NUMBER : 10383429, ODI ID NUMBER : 10243439, ODI ID NUMBER : 10168915, ODI ID NUMBER : 10351279, ODI ID NUMBER : 10390200, ODI ID NUMBER : 10302026, ODI ID NUMBER : 10279040. THERE MAY BE MORE, BUT I WAS TIRED OF LOOKING. *TR

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING 40 MPH, THE CONTACT ATTEMPTED TO ACCELERATE AND NOTICED THAT THE VEHICLE HAD CONTINUED TO ACCELERATE ON ITS OWN. THE CONTACT HAD TO SHUT THE VEHICLE OFF IN ORDER TO STOP THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHERE THE THROTTLE BODY WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 20,000. THE VIN WAS NOT AVAILABLE.

2005 FORD RANGER EDGE. CONSUMER STATES PROBLEM WITH HARMONIC BALANCER IN ENGINE. *TGW

WHILE DRIVING AT APPROXIMATELY 35 MPH, WITH APPROXIMATELY 600 POUNDS OF WEIGHT IN THE BACK OR BED, ON A ROAD THAT REALLY WASN'T REAL SLICK SO I DIDN'T HAVE IT IN 4WD, AND SUDDENLY THE PICKUP VEERED TO THE LEFT AND HIT A CONCRETE JERSEY BARRIER. IT BOUNCED OFF AND WENT TOWARD THE RIGHT AND HIT A GUARD RAIL AND THEN ROLLED OVER ON TO ITS TOP. THE SHERIFF DEPUTY NOTICED THAT THE LEFT REAR WHEEL WAS MISSING AND THOUGHT IT WAS STRANGE THAT THE AXLE BROKE AT THAT LOW SPEED AND SITUATION. UPON INSPECTION OF THE BROKEN SURFACE ON THE PICKUP, HE NOTICED WHAT LOOKED LIKE RUST AS IF THE AXLE HAD CRACKED SOMETIME EARLIER AND FINALLY BROKE OFF. I LOOKED AT THE BROKEN SURFACES AND COULD SEE WHAT LOOKED LIKE POSSIBLE RUST AND SOMETHING WHITE. THE PICKUP NEVER HAS HANDLED SO STRANGELY SO I THOUGHT I WOULD TRY SEARCHING THE INTERNET FOR A SIMILAR OCCURRENCE. IT DIDN'T TAKE TOO LONG USING GOOGLE TO FIND ANOTHER INSTANCE WHERE A PERSON HAD REPORTED THE AXLE ON THE SAME SIDE ON, I BELIEVE, A 2004 RANGER HAD BROKEN AND THE PICKUP ROLLED. I TOOK SOME PICTURES OF THE BROKEN AXLE SURFACES, BUT IT IS NOT POSSIBLE TO ATTACH THEM TO THIS FORM. *TR

I WAS COMING DOWN OFF 57 IN RUSH TRAFFIC WHEN THE CAR DIED UNEXPECTEDLY. COMPLETELY SHUT OFF, NO WARNING, AND WOULD NOT START AGAIN. SEVERAL TRIES, MORE GAS, MORE SHUT OFFS,SCREAMING HORNS AND I GOT IT TO THE GAS STATION OFF THE HIGHWAY. IT WENT TO GARAGE. ITS EXHAUST VALVE, WIRES AND PLUGS WERE CHANGED. DIED ON DRIVE OFF THE GARAGE. WENT IN, HAD MORE REPAIRS. DIED IN PARKING LOT. HAD COMPUTER DIAGNOSTICS. 172 AND 174 WERE DIAGNOSED-FAILURE OF COMPUTER IN EXHAUST SYSTEM AND MASS AIR VALVE CONTROL. BASICALLY, THE EXHAUST SYSTEM FAILED AND SHUT OFF THE ENGINE. ONE OF THE HEADS IS ALSO SUSPICIOUS.EXHAUST LEAKS ARE BAD FOR THE ENGINE. ALL THIS, OVER $1,000 REPAIRS, ON TOP OF TRANSMISSION LEAK, TWO SETS OF BRAKE PADS AND TWO SETS OF TIRES, IN A TRUCK BETWEEN 39,000 - THAT IS WHEN IT STARTED- AND 50,000 MILES. IN CASE YOU DON'T KNOW THIS, RIGHT AFTER THE FACTORY WARRANTY EXPIRED, THE TRUCK FELL APART. I FOUND OUT THAT ONE PERSON DIED OF SUCH FAILURE IN WASHINGTON STATE AND 2 WERE INJURED IN OREGON. ALL IN RANGER TRUCK. TRUCK IS WELL SERVICED, TIRES ARE NOT WORN AT ALL, HAVE LESS THAN 12,000 AND IT IS A KILLER TRUCK. FORD IS NOT RESPONSIVE TO THE FACT THAT THEIR TRUCK IS A LEMON. THEIR SERVICE CENTER: I BROUGHT IT TO YORBA LINDA FORD DEALER AT 39,000 BECAUSE THE IDLE WAS ROUGH, WAS TOLD IT WAS IN MY HEAD AND 12,000 LATER THE IDLE IS STILL DYING, KILLING THE ENGINE. *TR

ENGINE DIED WHEN SLOWING FOR A TURNING VECHICLE AN BUSY CITY STREET. ENGINE WOULD NOT START AND WAS UNABLE TO MOVE VECHICLE OUT OF TRAFFIC LANE UNTIL TOW TRUCK ARRIVED. REPAIR FACILITY ENGINE ANALYSIS IDENTIFIED THE FUEL PUMP INERTIA SHUTOFF SWITCH WHICH AS THE FAULT. IT WOULD NOT RESET AND WAS REPLACED.

DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70 MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30-40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES ENGINE STARTS. *TR

DRIVING ON FREEWAY APPROXIMATELY 30 TO 40 MINUTES AT 55-70MPH AND ENGINE SHUTS DOWN WITH NO WARNING. PULL OVER WAIT A FEW MINUTES AND ENGINE STARTS. DRIVE ANOTHER 30 TO 40 MINUTES AND ENGINE SHUTS DOWN. PULL OVER WAIT A FEW MINUTES - ENGINE STARTS. WENT TO PUT GAS IN TRUCK AND ENGINE WOULD NOT START. RESET FUEL INERTIA/SHUT DOWN SWITCH AND TRUCK STARTED. *TR

I AM CURIOUS WHY THERE HAS BEEN NO RECALL ON THE FORD RANGER FRONT WHEEL BEARING ISSUE WITH THE HUNDREDS OF COMPLAINTS OUT THERE. WE THE CONSUMER DRIVING ON THE ROADS NEED TO BE PROTECTED BETTER. *TR

TL* THE CONTACT OWNS A 2005 FORD RANGER EQUIPPED WITH HANKOOK RADIAL H714 TIRES, TIRE SIZE 225/70/15. THE DOT NUMBER WAS 1GUUAPH. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A LOUD NOISE OUTSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND NOTICED THE FRONT PASSENGER SIDE TIRE EXPLODED. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2005 FORD RANGER EDGE. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE STALLED. THE CONTACT STATED THAT THE STALLING WAS CAUSED BY THE RESET BUTTON BECOMING TOO HOT AND STOPPING THE FUEL FLOW TO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP WAS FAULTY. THE DEALER REPLACED THE FUEL PUMP BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND THE DEALER REPLACED THE SECOND FUEL PUMP BUT TO NO AVAIL. THE FAILURE PERSISTED AND THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 77,000.

THE FUEL INERTIA SWITCH WOULD MALFUNCTION FOR NO REASON. THE CAR WOULD JUST DIE, LOSING ALL POWER (MANY TIMES HAPPENING AT 65 MPH ON FREEWAY). IT HAPPENED AT LEAST 15 DIFFERENT TIMES. THE "RESET" BUTTON WOULD HAVE TO BE USED TO GET VEHICLE STARTED AGAIN. EVENTUALLY, THE COMPONENT "MELTED," AND HAD TO BE REPLACED. I WAS TOLD AT THE DEALERSHIP NOT TO LET THE FUEL LEVEL GET LOWER THAN 1/4 TANK, TO PREVENT THIS FROM HAPPENING AGAIN. VERY DANGEROUS ISSUE, WHICH FORD IS AWARE OF< BUT DOES NOTHING! *TR

2005 FORD RANGER WITH A 2.3 L ENGINE. CHANGED OIL AT 33K AND RETRIEVED A VALVE KEEPER. SUBSEQUENT REMOVAL OF OVERHEAD CAMS AND TIMING CHAIN ASSEMBLY (5.8 HOURS OF LABOR) AND 500+ DOLLARS OUT OF MY POCKET REVEALED NO VALVE KEEPERS WERE MISSING. THE DEALERSHIP GAVE ME A 1-800 NUMBER TO ASK QUESTIONS. *TR

TWO TIMES IN 2 DAYS I WAS DRIVING WHEN THE VEHICLE SUDDENLY STALLED/SHUTOFF. FORTUNATELY BOTH TIMES I WAS ABLE TO PULL OVER OUT OF TRAFFIC. IT FELT LIKE MY PEDAL WENT DEAD, I LOST MY POWER STEERING AS WELL. SINCE I WAS ABLE TO CONNECT TO THE INTERNET THROUGH MY PHONE I WAS ABLE TO SEARCH "FORD RANGER SUDDENLY DIES WHILE DRIVING." AN OVERWHELMING AMOUNT OF RESULTS INDICATED TO RESET MY INERTIA FUEL SHUTOFF SWITCH. I FOUND IT, RESET IT AND THE TRUCK STARTED AGAIN. AFTER THE SECOND TIME THIS HAPPENED I RESEARCHED FORD RANGER RECALLS, ONLY TO FIND THIS WAS NOT ONE OF THEM. I FEEL VERY APPREHENSIVE ABOUT DRIVING MY TRUCK, NOT KNOWING WHY IT SUDDENLY DECIDES TO TRIP THE FUEL SHUTOFF SWITCH. THIS IS EXTREMELY DANGEROUS AND IT NEEDS TO BE RECALLED.

FUEL INERTIA SWITCH MALFUNCTION, SWITCH SHORTED OUT AND CAUGHT FIRE. THE INERTIA SWITCH WOULD TRIGGER AND SHUT OFF THE FUEL SUPPLY TO THE TRUCK, THIS HAPPENED ABOUT 25TIMES SINCE PURCHASING THE VEHICLE NEW, THE LAST TIME IT HAPPENED I WAS SITTING STILL IN BUMPER TO BUMPER TRAFFIC AND IT JUST SHUT OFF. I REACHED UNDER THE PASSENGER SIDE OF THE DASH BOARD TO RESET IT AND COULD FEEL THE HEAT FROM THE ELECTRICAL FIRE. I QUICKLY SHUT OFF THE VEHICLE AND THE FIRE DIED OUT. THE SAFETY SWITCH IS TOTALLY FRIED. *TR

FUEL SHUT OFF SWITCH - THE WIRE HARNESS CONNECTING TO THE FUEL SHUT OFF SWITCH ARE MELTED. FORD REPLACED ONE OF THESE SWITCHES DURING MY WARRANTY PERIOD AND SINCE THEN I HAVE REPLACED THIS SWITCH TWICE. I NOW NOTICE THAT THE HARNESS CONNECTED TO THIS SWITCH HAS WIRES THAT ARE MELTED. THIS SWITCH HAS ACTIVATED NUMEROUS TIMES WHILE I HAVE BEEN DRIVING AND WHEN THIS HAPPENS THE VEHICLE FUEL IS INTERRUPTED AND VEHICLE STALLS. I HAVE HAD THIS HAPPEN ON INTERSTATE 4 AND ON VARIOUS OTHER ROADS. I FIND IT HARD TO BELIEVE THAT MY VEHICLE IS THE ONLY ONE THIS HAPPENS TO. I RECENTLY PICKED UP A NEW SWITCH WHICH HAS BEEN REVAMPED WITH AN ADDITIONAL WIRING HARNESS AND A NEW CONNECTION BRACKET. THE PROBLEM IS THAT THE OLD HARNESS THAT THIS WILL BE ATTACHED TO HAS BARE WIRES EXPOSED WITH NO INSULATION COVERING THEM. I AM CONCERNED THAT THIS CONSTITUTES A FIRE HAZARD. I HAVE SPOKEN TO THE FORD SERVICE DEPARTMENT IN LAKELAND, FL. BUT HAVE HAD NO REASONABLE EXPLANATION ON THIS PROBLEM. *LN

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FUEL CUTOFF SWITCH CONTINUOUSLY CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE CONTACT WAS ABLE TO RESET THE SWITCH AND RESUME DRIVING. THE DEALER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,000.

2005 FORD RANGER EDGE. ENGINE STALLING DUE TO FAULTY FUEL CUTOFF SWITCH WHICH GOT HOT ENOUGH TO MELT THE PLASTIC SWITCH ITSELF. TRUCK STALLED 20-30 TIMES TOTAL WITH HALF OF THOSE TIMES AT FREEWAY SPEEDS. *TR

THE VEHICLE WILL SHUT DOWN AND YOU LOSE TOTAL CONTROL. POWER STEERING GONE. ENGINE GONE. IT WILL HAPPEN AT ANY TIME. THE REASON IT IS SO DANGEROUS IS BECAUSE I HAVE HAD IT SHUT DOWN ON THE FREEWAY GOING 65MPH. I WAS LUCKY ENOUGH NEVER TO HAVE GOTTEN HIT BUT IT WAS A CLOSE CALL. 1. THE VEHICLE WOULD JUST STALL LIKE IT WAS RUNNING OUT OF GAS. 2. WHEN THE PART WAS GOING BAD IT WOULD OCCUR EVERY DAY. WHEN THE PART WAS TOTALLY MALFUNCTIONING IT WOULD NOT EVEN START. 3. THE FIRST TIME I HAD THE DEALER REPLACE THE PART VIA THE WARRANTY. THE SECOND TIME I PAID TO HAVE IT REPLACED. THE THIRD TIME I REPLACED IT MYSELF. IT LASTS ABOUT A YEAR THEN IT GOES BAD. *TR

I WAS DRIVING 65MPH ON THE FREEWAY (WHICH WAS SMOOTH) AND MY INERTIA SWITCH WENT OUT. THIS SHUT OFF MY POWER STEERING, MY POWER BRAKES AND I WAS ALMOST KILLED BY A SEMI TRUCK BECAUSE OF THIS. IT HAPPENED 10 TIMES TODAY, USUALLY WHEN COMING TO A STOP. THIS HAS HAPPENED MULTIPLE TIMES, AND FORD HAS NOT YET ISSUED A RECALL. ABOUT TWO WEEKS AGO, THE SAME THING HAPPENED (ON THE FREEWAY), AND ONCE AGAIN ALMOST CAUSED AN ACCIDENT. THEY HAVE ALREADY TRIED FIXING THIS BEFORE AND IT CONTINUES TO OCCUR. I HAVE READ MULTIPLE INSTANCES OF THIS OCCURRING AND BELIEVE THIS IS AN EXTREMELY DANGEROUS DEFECT, AND ALMOST COST ME MY LIFE. I HAVE A 2005 FORD RANGER. THANK YOU FOR READING MY PROBLEM, I AM VERY DISTURBED BY THIS AND HOPE FORD WILL FIX THIS. *TR

MY FORD RANGER (2005) LOST POWER GOING DOWN THE FREEWAY. AFTER MUCH INVESTIGATION, TIME, SAFETY ISSUES (QUITTING AT 55 + MPH) AND MONEY IT TURNED OUT TO BE THE INERTIA SWITCH. *TR

MY 19 YEAR OLD SON OWNS A 2005 FORD RANGER WE PURCHASED THROUGH A DEALER LAST YEAR. FOR THE LAST MONTH OR SO HE HAD TO RESET THE FUEL PUMP INERTIA SWITCH TO GET THE VEHICLE STARTED AGAIN. THIS IS VERY DANGEROUS SINCE ONE TIME HE WAS ON THE EXPRESSWAY GOING 65 AND THE TRUCK TURNED OFF ON HIM. IT'S HAPPENED TO HIM ABOUT 5 TIMES AND NOW HE IS AFRAID TO DRIVE IT. DON'T KNOW IF THE INERTIA SWITCH IS BAD OR IF SOMETHING ELSE IS CAUSING THIS. I HATE TO TAKE IT TO THE DEALER SINCE THEY TEND TO THROW PARTS AT IT AND NOT FIX THE PROBLEM. I THINK THIS IS SO DANGEROUS IT SHOULD BE RECALLED BY THE FORD DEALER. *TR

I HAVE A 2005 RANGER TRUCK AND IT OCCASIONALLY FEELS LIKE IT IS RUNNING OUT OF GAS. I HAD MY MECHANIC CHECK ALL PHASES OF WHAT COULD BE WRONG AND HE FOUND NOTHING. I NEVER HEARD OF THE INERTIA SWITCH UNTIL READING ON HERE. I WILL MENTION THIS TO MY MECHANIC TODAY. THANKS FOR THE INFO. I DID NOT WRITE DOWN DATES AND TIMES. *TR

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE OIL CHANGE. THE MECHANIC INFORMED THE CONTACT THAT WHILE ATTEMPTING TO PERFORM THE OIL CHANGE, THE ENGINE BLEW. THE MECHANIC STATED THAT THE CAM-SHAFT PULLEY SEPARATED AND CAUSE THE TIMING TO JUMP AND LOCK THE ENGINE. THE FAILURE WAS SO SEVERE THAT THE ENGINE WAS UNABLE TO BE REBUILT. THE DEALER ADVISED THE CONTACT THAT THEY WERE NOT LIABLE FOR THE FAILURE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 112,000. UPDATED 9/13/10 *CN UPDATED 09/15/10

DRIVING EAST ON I-10 NEAR ONTARIO, CAL AT 70 MPH 5/22/2010 9PM, TRUCK DIED THE INERTIA FUEL SWITCH WAS OPEN . HAD TO DRIVE WITH SON HOLDING DOWN ON THE BUTTON TO KEEP TRUCK RUNNING TO GET OFF FREEWAY AT 4TH ST. INERTIA SWITCH IS DEAD USED A PAPER CLIP ON WIRES TO DRIVE HOME. ALSO THE WIRE CONNECTOR TO THE INERTIA WAS MELTING SOME. FIRST TIME THIS HAPPEN IS IN OCT 14 2005 AND 4 OR 5 TIMES SENSE. *TR

THE TRUCK WOULD SUDDENLY STOP RUNNING. IT OCCURRED RANDOMLY, SOMETIMES WEEKLY, SOMETIMES MONTHLY, I NEVER KNEW WHEN IT WOULD HAPPEN. IT WOULD EVENTUALLY RESTART. AFTER REPLACING THE FUEL FILTER AND THE FUEL PUMP (TWICE) TO NO AVAIL, I ASKED MY NEIGHBOR TO LOOK AT THE INERTIA SWITCH (FORD WOULD NOT; THEY SAID THAT "COULDN'T BE THE PROBLEM"). THE SWITCH WAS ALL FRIED OUT INSIDE, AND THE CONNECTOR AND THE WIRE LEADING TO IT WERE MELTED. APPARENTLY, THE CONNECTOR WAS BAD. HE SAID THAT IT SHOULD HAVE CAUGHT FIRE ALREADY. HE REPLACED THE SWITCH AND PUT IN A DIFFERENT CONNECTOR AND I'VE HAD NO FURTHER PROBLEMS. I CAN'T BELIEVE THAT I NEVER HAD AN ACCIDENT, AS I MOSTLY DRIVE ON THE FREEWAY AND IN THE MOUNTAINS. *TR

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE TRAVELING AT SPEEDS OF 5 MPH, THE CONTACT APPLIED THE BRAKES AND THE BRAKES WOULD NOT ENGAGE. IN ORDER TO BRING THE VEHICLE TO A STOP, THE CONTACT HAD TO SHUT OFF THE ENGINE, CAUSING THE BRAKES TO LOCK. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE BRAKE BOOSTER, ROTORS, AND FRONT DISC WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 46,000.

MY 2005 FORD RANGER STALLED ON ME WHILE DRIVING DOWN HIGHWAY AT 65MPH AND HAS DONE THIS BEFORE DRIVING AROUND TOWN WHENEVER THE FUEL KILL SWITCH IS BUMPED BY SOMEONE'S FOOT WHILE SITTING IN PASSENGER SEAT. WHENEVER FUEL KILL SWITCH GETS BUMPED IT STOPS THE FUEL PUMP THEN TRUCK STALLS.(VERY DANGEROUS SOMEONE'S GOING TO GET HURT IF NOT FIXED) THE FUEL KILL SWITCH IS LOCATED ON PASSENGER SIDE FIRE WALL WHERE YOUR RIGHT FOOT IS. IF YOU STRETCH YOUR LEG YOU WILL HIT THE SWITCH. FORD SHOULD RECALL THIS PROBLEM. RELOCATE SWITCH BEFORE SOMEONE GETS HURT. VERY DANGEROUS WHEN DRIVING AND YOUR TRUCK STALLS CAUSE SWITCH GETS BUMPED. IT DON'T TAKE MUCH TO SET SWITCH OFF. I HAVE BEEN TO TASA FORD IN R.I. AND EXPLAINED THIS PROBLEM TO THEM AND THEY SAID THEY HAVE HAD THIS PROBLEM WITH OTHER VEHICLES AND FORD KNOWS ABOUT THIS PROBLEM BUT HAS NOT HAD A RECALL!! SOMETHING NEEDS TO BE DONE. HOPE YOU CAN HELP THANK YOU. *TR

THE INERTIA SWITCH ON MY 2005 FORD RANGER CUT THE FUEL SUPPLY AT 55 MPH ON A BUSY HIGHWAY. AFTER PULLING THE SWITCH OUT AND PULLING OUT THE CONNECTOR, I FOUND EVIDENCE OF TEMPERATURES HIGH ENOUGH TO MELT THE PLASTIC. THIS PROBLEM FIRST STARTED IN NOVEMBER OF 2008 AND HAS GOTTEN STEADILY WORSE SINCE THEN. THIS EVIDENTLY A DESIGN FLAW THAT NEEDS TO BE FIXED BY FORD. *TR

INERTIA SWITCH TRIPPED WHILE DRIVING 55 MPH ON SMOOTH ROAD. *TR

INERTIA SWITCH TRIPPED IN 2008 WHILE PARKED!? WALKED HOME, LOOKED UP ON INTERNET, FOUND OUT HOW TO RESET. FEBRUARY 2010 THE INERTIA SWITCH TRIPPED AGAIN WHILE COASTING DOWN SMOOTH ROAD. PULLED OVER AND RESET SWITCH. DAUGHTER REPORTS INERTIA SWITCH TRIPPED A COUPLE OF WEEKS LATER, FORTUNATELY I TOLD HER HOW TO RESET IT. THIS COULD BE VERY DANGEROUS AND LIFE-THREATENING, ESPECIALLY IF IT HAPPENED ON A CROWDED FREEWAY! I FEEL THAT FORD KNOWS THIS IS A PROBLEM, HAVE CREATED A RELOCATION KIT. FOR A HUNDRED BUCKS! I FEEL FORD SHOULD PAY FOR IT. I HAVE ONLY 7K MILES ON THIS TRUCK, IN FIVE YEARS! *TR

TL*THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT SMELLED PLASTIC BURNING IN THE ENGINE. HE TOOK THE VEHICLE TO THE DEALER WHO ADVISED HIM THAT HE NEEDED TO REPLACE THE ALTERNATOR AT HIS EXPENSE. THE MANUFACTURER STATED THAT THEY WERE UNABLE TO OFFER HIM ANY ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 50,000. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. UPDATED 02/26/10 *BF UPDATED 06/14/10.*JB

CONTINENTAL TIRES.....I OWN 2 VEHICLES THAT HAVE COME EQUIPPED WITH CONTINENTAL TIRES AND FOUND THAT OVER TIME BOTH SETS OF TIRES HAVE WORN OUT DUE TOO POOR QUALITY OF THE TIRE. I HAVE GONE ON LINE AND LOOKED UP ON THE WEB SITE UNDER CONTINENTAL TIRE AND CLICKED ON COMPLAINTS ABOUT THESE TIRES AND IT IS ALARMING HOW MANY PEOPLE ARE FINDING THAT THE TIRES FROM CONTINENTAL ARE POORLY MADE AND THE QUALITY OF THESE TIRES IS PUTTING PEOPLE IN HARMS WAY , DUE TO BLOWOUTS , TREAD SEPARATION, PREMATURE WARE . I LIVE IN TUCSON AZ AND JUST ABOUT EVERY TIRE DEALER WITHIN 20 MILES OF ME WONT EVEN RECOMMEND A TIRE BUILT BY CONTINENTAL. REPLACING THESE TIRES WITH SOMETHING DIFFERENT IS THE ONLY OPTION TO BE SURE YOU DON'T HAVE HAPPEN TO YOU ,WHAT MOST PEOPLE HAVE HAD HAPPEN TO THEM , AFTER YOU READ THE COMPLAINTS POSTED ON THE WEB SITE OF CONTINENTAL TIRE, I FIND IT NECESSARY TO FILE A COMPLAINT ABOUT THESE TIRES AND THE COMPANY. I FEEL THAT SOMEONE NEEDS TO READ THE COMPLAINTS ON THE WEB SITE, AND TAKE A LOOK TO SEE IF THERE IS SOMETHING THAT CAN BE DONE , TO GET ANSWERS AS TO WHY CONTINENTAL FEELS THAT THERE'S NO PROBLEM WITH THERE TIRES. ON MY 2005 FORD RANGER THE TIRES HAD 30,000 MILES ON THEM AND IN THE OWNERS MANUAL , THE TIRES HAD A 6 YEAR PRO-RATED WARRANTY ON THEM. THE TIRE DEALER HERE IN TUCSON WAS TOLD BY CONTINENTAL THAT THEY DIDN'T COVER THE TIRE FROM NORMAL WEAR. THE DEALER EXPLAINED TO CONTINENTAL THAT THE TIRES IN QUESTION WERE PRE-MATURELY WEARING OUT ON THE INSIDE EDGES A

2005 FORD RANGER PICKUP TRUCK. THE FUEL PUMP INERTIA SWITCH TRIPS ON SMOOTH ROAD WITH NO BUMPS. IT SHUTS DOWN THE ENGINE. IT HAPPENED EIGHT TIMES THIS MONTH. ONCE ON A BUSY INTERSTATE BELTWAY. I'VE RESEARCHED MANY OTHERS WITH THIS PROBLEM. IT SHOULD BE RECALLED AND FORD SHOULD FIX IT FREE. *TR

MY 2005 FORD RANGER TRUCK IS SEVERELY RUSTED ON THE UNDERSIDE. I HAD A 1992 RANGER PREVIOUS TO THIS ONE, AND NEVER HAD THIS AMOUNT OF RUST ON SUCH A CRITICAL AREA. EVERYTHING IS ATTACHED TO THE FRAME AND IT APPEARS TO BE PREMATURELY FAILING, ALTHOUGH NOTHING HAS FALLEN OFF AS OF YET. THE REST OF THE TRUCK LOOKS IMMACULATE, BUT UNDERNEATH...LOOKS 100 YEARS OLD! THIS IS A PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 FORD RANGER. HE STATED WHILE DRIVING AT 50 MPH HE NOTICED THAT HIS CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN A DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT NUMBER FOUR CYLINDER WAS FAILING AND IN ORDER TO MAKE THE REPAIR THE VEHICLE WOULD NEED TO HAVE THE VALVE SEATS REPLACED. THE CONTACT WAS IN THE PROCESS OF CONTACTING THE MANUFACTURER. HE FEELS THAT THERE SHOULD BE A RECALL ON THE ALUMINUM HEAD VALVE SEATS BECAUSE THEY LOSE COMPRESSION WITH THE METAL THAT THE MANUFACTURER IS USING FOR THE ALUMINUM HEAD VALVE SEATS. THE FAILURE MILEAGE WAS 84,000 AND THE CURRENT MILEAGE IS 87,000. BL UPDATED 10/5/09 *CN UPDATED 10/07/09

I HAVE A 2005 FORD RANGER 4 WHEEL DRIVE WHICH I PURCHASED NEW. ON A RECENT TRIP A TRAILER TRUCK CHANGED LANES ON THE PA TURNPIKE WITHIN FEET OF MY FRONT END. IN ORDER TO AVOID AN ACCIDENT I HIT THE BRAKES VERY HARD. THE INERTIA SWITCH STOPPED THE FUEL PUMP AND SOME HOW I WAS ABLE TO COAST ACROSS 2 LANES TO THE BERM. I CALLED THE FORD DEALER AND THEY SAID THAT THE GUARANTEE WAS 3 YEAR OR 36,00 MILES AND AT THE TIME I HAD ABOUT 37,500 MILES ON THE TRUCK AND WAS OBVIOUSLY OVER THE THREE YEARS. I HAD THE SWITCH REPAIRED AT A COST OF OVER $200.00. AFTER THE OCCURRENCE ABOVE THE SWITCH WENT OFF 5 TIMES DURING NORMAL DRIVING. I HAVE THE BAD SWITCH IN MY POSSESSION IF YOU ARE INTERESTED. THIS WAS A VERY SERIOUS SITUATION WHICH I THINK FORD SHOULD PAY FOR. LOOSING ALL POWER ON A SUPER HIGHWAY IS DANGEROUS TO SAY THE LEAST. *TR

I HAVE A 2005 FORD RANGER. I WAS INVOLVED IN A VERY CLOSE TO AN ACCIDENT ON THE PA TURNPIKE WHEN A TRAILER TRUCK CHANGED LANES IN FRONT OF ME WITHIN INCHES. I HIT THE BRAKES VERY HARD IN ORDER TO AVOID HITTING HIM. THE INERTIA SWITCH WHICH SHUT OFF THE FUEL PUMP ACTUATED WHICH IT IS DESIGNED TO DO. MY PROBLEM IS THE INERTIA SWITCH CONTINUES TO ACTUATE FOR NO REASON. I CALLED FORD AND THEY SAID VEHICLE WAS OUT OF WARRANTY SO I WOULD NEED TO PAY UPWARDS OF $200.00. I WOULD THINK THIS IS A SERIOUS SAFETY PROBLEM. MY WIFE REFUSES TO DRIVE THE TRUCK. *TR

TL*THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THE TIE ROD WAS WEARING. HE ALSO HEARD A LOUD CLANGING NOISE WHILE DRIVING VARIOUS SPEEDS. THE DEALER LUBRICATED THE TIE ROD, BUT THE FAILURE CONTINUED. THE NOISE HAS GOTTEN WORSE AND FORD REFUSES TO ASSIST. THE FAILURE MILEAGE WAS 6,000 AND CURRENT MILEAGE WAS 7,200.

THE FUEL INERTIA CUTOFF SWITCH IN OUR '05 FORD RANGER PICKUP HAS HAD TO BE REPLACED TWICE SINCE IT'S PURCHASE IN AUG. OF '05. ONE MONTH AFTER PURCHASE WAS THE FIRST FAILURE WHEN DRIVING OVER A SPEED BUMP AT 5MPH. THE TRUCK WAS TOWED TO THE DEALERSHIP, THE DEALERSHIP ADJUSTED THE SENSITIVITY. THE FOLLOWING SPRING THE FICOS TRIPPED AGAIN WHEN DRIVING ON A TWO LANE ROAD AT 25MPH. THE DEALERSHIP REPLACED THE SWITCH. DEC. '08 THE FICOS AGAIN TRIPPED WHILE PARKED FOR 8 HOURS. JAN. '09 THE FICOS TRIPPED WHILE ON A TWO LANE ROAD AT 40MPH CAUSING THE NECESSITY TO COAST TO THE SIDE OF THE ROAD BUT NOT OFF THE ROAD, ON A BLIND CORNER. DURING THE DEC. '08 AND JAN. '09 INCIDENT THE EMERGENCY FUEL INJECTION PUMP, UNDER THE DASH, WAS IMPLEMENTED. AFTER SEVERAL ATTEMPTS OVER A DURATION OF 30 MIN. THE FICOS RESET AND ALLOWED THE PICKUP TO START. IN FEB. '09 THE FICOS TRIPPED AGAIN AFTER THE PICKUP WAS PARKED OVERNIGHT. THE PICKUP WAS AGAIN TOWED TO THE DEALERSHIP. THE FICOS HAD TO BE REPLACED AGAIN. MY CONCERN IS THIS WILL CONTINUE TO HAPPEN AND AT SOME POINT I WILL NOT BE IN A POSITION TO AVOID AN ACCIDENT AS OTHERS HAVE FOUND THEMSELVES IN. HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2005/FORD/RANGER. *TR