2022 Ford Maverick complaints

The whole car shut down while i was driving. I lost all power to the car and couldnt get it started again.

Both front cv axles failed at 55,000 miles causing shake while accelerating

Front CV axles causing Intense vibration through out front suspension/drivetrain

I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.

The rear brakes and rotors have prematurely worn out at only 28k miles, while the front brakes are like new. There is no way for me or any local repair shop to put it into brake service mode. The official Ford procedure does not work. NHTSA issued SSM 51217 acknowledging the issue, but the only solution is only to take it to a Ford dealer to do a simple procedure such as changing rear brake pads. This solution is unacceptable and causes an undue burden upon the customer in time and money for a known manufacturing defect. My closest dealer is 1 hour away. It can not pass my state safety inspection without this being done. Ford should be issuing a recall to address this defect, not simply driving people to the dealer network for basic safety maintenance.

In October 2023, we took our 2022 Ford Maverick to a local Ford dealership for a front airbag recall. However, after we picked up our Maverick and we got home we noticed a deep scratch across the top of the dash and the tool from the technician in the console. We contacted the dealership about this scratch. Our Maverick was taken to the dealership in January 2024 for this repair. Upon the completion of installing the dash, the technician scratched the outside of the driver’s side front door causing yet another delay. The Maverick was then taken to their body shop (on premises) to repair the scratch and repaint the door. Within a week of having our Maverick back, we started smelling a very foul odor in the truck. This smell made my throat and nose burn and was nauseating while riding in the truck even with the windows down. We went back to the dealership to meet with the owner about this odor. They removed the seats, carpet, and dash to locate the problem. They discovered a place at the bottom of the windshield that had not been sealed from the manufacturing production department. They discovered black mold in the insulation behind the dash near the firewall and under the carpet. They have discussed this with Ford Motor Company on how to handle this problem. Currently our Maverick is still on the lot at the local dealership, since the first week of April 2024. We have reservations about the mold/mildew odor as a health/breathing issue to continue driving this vehicle. Ford Mot

I’ve been noticing a frequent issue with my trailer not having the left blinker work per notification it gives. So I gave been checking the information screen for trailer lighting any time that I’m pulling a trailer just to make sure all of my lights are working. Today, the truck told me all lights were on and working with the trailer. Meanwhile, after getting pulled over and explaining the info the truck is giving and then unplugging and replugging the trailer from the truck to prove that the lights do in fact work I was finally dismissed from the traffic stop. So the truck was telling me that all lights are on and working on the trailer… meanwhile there wasn’t a single light on!!! The issue with the left turn signal light not blinking on a trailer is relative to the truck as well since it only does it on the truck and with a multitude of different trailers/magnetic trailer lights.

The contact owns a 2022 Ford Maverick. The contact stated while driving 35 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the message “Engine Power Reduced” was displayed. Additionally, the contact stated that the “BRAKE” warning light illuminated; however, due to the failure the computer system generated the failure code in error. The vehicle was taken to the dealer where it was diagnosed as a fractured well in the braking system. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was informed that the parts needed to be ordered to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. The VIN was unavailable.

In early April 2023 I opened my driver’s side door and the inside of my 2022 Ford Maverick was wet from the headliner down to the carpets. There WAS condensation throughout the interior of the vehicle even though the Repair Order stated there was none. The inside of the vehicle was damp. All windows were closed tightly. The headliner, back seat, front seat, carpets, and all the interior was damp. I had a book on my back seat that was damp and the pages were curled. There was MOLD underneath the floor mats. I contacted a MOLD specialist who stated that it is impossible to effectively rid a vehicle of MOLD. He stated that MOLD spores are in every crevice of the truck and it WILL return. On April 6, 2023 I took the truck to The Ford Store where I purchased it. There was 1294 miles on the odometer. They could not find the leak. My vehicle was there for several weeks and the interior was completely torn down from the headliner to the carpets. The Service Department finally said that they located the leak area and repaired it. The dealer guaranteed in writing that the MOLD was gone. On June 23, 2024 (today) I was getting ready to take the truck back to The Ford Store for tomorrow’s appointment. They will be addressing the three recalls. I just noticed MOLD under the mats again. The MOLD is on the floor board and is crawling up the footwells under the rubber mats. There is also MOLD on some of the plastic material close to the floor boards. My health and the health of all passengers

On Thursday (June 13, 2024) my truck displayed a fault that states Rear Belt Monitor Fault Service Required, at the same time my air bag light came on. I proceeded to work and found a lot of people have had this issue with their Ford Mavericks but have all said it is actually their drivers seatbelt with the issue. My husband thought he would test it to see and while driving he took his seatbelt off, the airbag light and fault went away but also even driving at highway speeds it never told us the seatbelt was off. When he plugged the seatbelt back in my truck indicated that seatbelt 3 was actually plugged in and the fault and airbag light came back on.

I was driving on the freeway driving eastbound on 152 and I switch to the fast lane to pass a vehicle and the throttle stopped working, the truck lost speed and the truck turned off, a message popped on the screen saying that I needed to put it in park. I put it in park put the hazards on and attempt to restart it and it would crank but wouldn’t start. I did this until the allowed amount of times reached its limit. I attempted to put the gear in neutral but the knob was stuck. The truck was at a slight angle as I was going uphill and couldn’t get it to move. I find the release lever to make it neutral and it didn’t work but now that lever got stuck all this is going on while the traffic is at is heaviest. The truck stalled until 2 hrs later when a tow truck came to pick it up. I got dropped off at a safe location and the truck turned on and would shift into gear but it sounded bad. Info screen says something about not being able to park and the key is stuck on the truck still.

My vehicle sits at about 26k miles currently. I experienced extreme shaking coming from under the vehicle under acceleration. The issue happened while going up a hill with my whole family. I had to pull over to inspect the issue as it felt like a wheel was coming off. Upon visual inspection both CV Joints were leaking grease all over the undercarriage of my vehicle. A screeching grinding and clunking noise was heard as I continued to drive. This noise went away shortly after, however the shaking upon acceleration continued. It's important to note that I do not take my vehicle off road and is mostly driven on paved roads to and from work and has never been overloaded in anyway. After I took the vehicle to the Dealership, they confirmed that both half shafts were failing and were disintegrating. The passenger side bad enough that it had expelled most of the grease. Continued use would have led to complete failure and could've resulted in an accident. On a vehicle with under 26k miles.

Driving down I 90 at 65 mph, powertrain/ power malfunction light came on and power was reduced to 20 mph. Very dangerous . This happened at least 4 times until I was able to return home. shut truck off and would go until the warning light came back on. contacting dealer tomorrow

The contact owns a 2022 Ford Maverick. The contact stated that for two years from the end of November to April, he observed a burning odor in the cabin of the vehicle, that caused him to have a headaches and stomach aches. The vehicle was taken to a dealer on multiple occasions where the failure was not able to be replicated. The vehicle was then taken to a different dealer where it was diagnosed that the blower motor resistor needed to be replaced. The vehicle was repaired but the failure persisted. The contact believed that the failure was associated with NHTSA Campaign Number: 23V380000 (Engine). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 3,975.

See attached document for complaint

My truck started collecting water in the front passenger side floor. Took it to the dealer and they couldn’t find the leak at first. Then they claim it was coming from the window seal on the back passenger window. I refused to have it repaired for 950$. 600 dollars in now with leaky rear window. This has already started a mold issue under the carpet. This needs to be addressed by the manufacturer.

What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.

Manufacturing defect on the cowl deflector seal causes water to leak into the cabin and pool up on the floor of the passenger side front seat. Significant amount of water. This will result in damage to the carpets, mold issues (health and safety concern) along with possible damage to the electronics that is passes through right under and behind the glove box. Also passes through the cabin air filter box. Many Maverick owners have reported this problem in various internet forums, and yet there has not been a recall. I had to pay the local dealer to reseal this area with silicone due to a faulty design. Ford would not cover the expense. The dealer wanted $900 to dry the carpet.

The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.

Had front half shafts replaced under warranty at 12k miles. Currently at 22k miles and experiencing the same vibration/shudder at about 50mph. Vehicle is available for inspection upon request. Failure of a half shaft could leave the vehicle stranded or could cause loss of control. Problem was already confirmed by dealership and half shafts were replaced. Problem is presenting itself again 10k miles later. Problem is well known with other owners. No warning lamps.

I bought a 2022 Maverick on 12 JAN 2022. The car broke down on the highway six months after (23 JUL 2022). Ford service department claimed it was a fuel injector issue and by replacing the part, the truck should be as good as new. Fast forward to Sat 30 DEC 2023 and the truck breaks down on the highway again with the engine light flashing. Ford service department informed me that the engine has to be replaced because several parts are broken/shattered and they do not know how. I am inclined to believe that the issue was never fixed to begin with and Ford put my safety and the lives of the people I care about at risk. I was sold a lemon with major engine issues and I am terrified of driving the truck again. All the service reports are currently at the dealership; I can acquire copies when needed.

Engine shut down at speed. Power totally went off. No power steering. Service engine light came on. I was able to restart vehicle but it kept shutting off. Vehicle starts with engine warning light but cannot be derived without shutting down. this has happened twice. Once with about 200 miles and the second time with 3,500 miles

I was driving back home from errands and during a stop, the entire car suddenly powered off and became unresponsive. I couldn’t even flash my hazards and was stuck in the middle of a busy intersection. Also couldn’t put it in neutral since the gear shifter is electronically powered. Some bystanders tried to jump my car, but it took 6 solid tries before they could restore power. I drove it another 1000 ft, trying to head to a service center and this time it completely powered off while in motion. I had to fight with the steering wheel to pull it to the shoulder as the power steering went out and the car started making clicking noises. The entire car was completely dead, once again. A tow truck diagnosed the battery as still healthy and suspects a deeper electrical fault with the car. It has been towed to the dealer for service under warranty, but I am reading that I am not the only one with this issue. A lot of folks are getting battery swaps and having the issue recur later. Could this be a wiring harness fault, or a much more pervasive electrical issue? The entire episode was terrifying, and I could have gotten into a major accident if this was on a busier road.

This vehicle was purchased in 2021 with a 3 year 36k mile warranty. At 39k miles the truck has started to shut off randomly while driving. It has put us in very dangerous situations and it happens multiple times every day. The vehicle will be driving down the road and suddenly shut off. It will not switch to neutral so cannot be pulled off the road. It will not turn on for at least 20 minutes so we get stuck in the middle of the road. Sometimes it will turn back on but other times it has to be jumped. Ford is telling us that any repairs will not be covered because this brand new car is out of warranty.

The passenger side footwell is accumulating water. Windows are closed, no significant rainfall. Perhaps associated with the AC. Mold spores have formed on the carpet causing a health hazard. I am too worried to pull up the carpet to see what it is like underneath. After drying it several times, it continues to form puddles, again with no rain.

Multiple instances of Auto Hold function sucking brake to floor and haulting vehicle at low speeds causing danger of a rear collision. Recommend adding a 1 second delay to current system before engaging auto hold function.

I pulled my 2022 Maverick into my parking spot at work and everything went dead. I had to use my key to open my tailgate. The tow service jumped the battery and it started, however, when they went to take it off the tow truck at the Ford dealership, it had to be jump started again. I was told the battery was bad and they changed it. The vehicle worked fine for three days and on the morning of the fourth day I had difficulty starting the vehicle. The first three times I turned the key all I heard was clicking and it started on the fourth try. I then drove it straight to the dealership where it has been for the past 8 days.

The contact owns a 2022 Ford Maverick. The contact stated that after she parked the vehicle, her daughter unlatched the rear passenger's seat belt; however, the shoulder strap that she had placed behind her was twisted and inadvertently retracted. The seat belt then seized while tightly wrapped around the contact's daughter's waist, causing her breathing difficulty. The contact had to cut the rear passenger's seat belt with a scissor to release her daughter. The contact's daughter sustained bruising on her stomach and waist; however, medical attention was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 34,115.

I have a 2022 Ford Maverick, 2.0 ecoboost engine, awd. I have been having brake problems since the beginning. The problem is the front brakes do not back out enough to leave a proper air gap between the brake pad and rotor when deactivating the service mode. Therefore the pads keep riding on the rotors causing glazing and grabby brakes when coming to a stop behind a vehicle. Turning off the active breaking did help with the grabby brakes when stopping behind a vehicle, but did not resolve the glazing issue. I took the truck into two dealerships and the techs. could not find a solution. the front calipers, front brake hoses and the brake master cylinder have been replaced with no success. Maybe the solution is to adjust the air gap settings somewhere in the software.

The Ford Maverick rear view camera is dangerously laggy - it will freeze several times during backing. It also washes out in bright sun. I consider this a dangerous feature that should be addressed.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: NHTSA Campaign Number: 22V594000 (Air Bags) and 22V730000 (Exterior Lighting, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The truck is leaking rain water into the cabin driver's side floor. Technicians have not been able to find the leak and the carpet is moldy and smells. The truck has been in the shop two times now and Ford has not offered to replace the moldy carpet under warranty.

Wind’s go through the door around 70 mph and feels like the windows are open and the front door click to open twice in each door and the computers right away, shows the next door open.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The consumer stated because the vehicle was not purchased at the dealer parts were not available.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at 75 MPH, another vehicle side-swiped the contact's vehicle on the passenger's front side; however, the side curtain air bag failed to deploy. There were no injuries. A police report was filed. The vehicle was towed to an auto repair center. The contact related the failure to NHTSA Campaign Number - 22V594000 (Air Bags). The dealer was made aware of the failure; however, the parts to repair the recall are not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,000.

When starting out driving or cornering at low speeds the horn would randomly honk steadsily and eventually time out.

I was hit by another car in between the passenger side front door and the passenger side back door. I was hit with enough force to push me off the road. There was no side airbag deployment.

(there is a brake system malfunction. When braking sometimes the brakes would skip and I could feel the brakes not grabbing the rotors the way they should. the problem has not been reproduced or confirmed by a dealer because the dealership could not figure out what was causing the problem with the brakes. the dealership inspected the brakes. there was no warning lamps or messages of the brake problem.) I first started to hear a intermittent rubbing noise when braking and driving slow a couple months after I purchased the vehicle. I took it the vehicle into the dealership and they could not figure out what was wrong. I was told perhaps i was to aggressive on the brakes. the problem continued so i went to another dealership and they looked at the brakes and could not figure out what was causing the noise. the rotors looked glossy (glazed) So I decided to replace the rotors and brakes at my cost because I was told the truck was out of warranty. one week after the repairs were made, I started to hear the rubbing noise again. I was furious! I couldnt believe this was happening on a brand new vehicle, especially on a ford. So I continued to drive until the rotors got so bad that the steering wheel was shaking when I braked.the rotors were warped. So I decided to take matters into my own hands and replace the brake pads and rotors using the ford manual for the 2022 maverick. This time I decided to only drive eco mode on the highway and normal mode in the city. I also turn off the ac

I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.

I know there are issues with the Hybrid versions, but this one is not a hybrid. I have had the battery die 4 separate times resulting in me being stranded due to no fault of my own. This Ford Maverick was purchased through the Military Auto Sales at Ramstein AB Germany. It is US-spec and owned/operated by a US Military member stationed overseas. The first time it happened at the Frankfurt airport after owning it for a week and driving it from the Port of Bremerhaven (port of entry). Once I got it jumped and back to Ramstein I did not have an issue for 3 weeks. It died after sitting for three days over New Years. I jumped it and drove it around for over an hour to charge the battery. I then left it for a few days to see if it occurred again. One week later it died. I then jumped it and drove it around again to charge the battery. At this point I suspected the Ford Pass Connect, bluetooth or wifi to be the cause so I turned all of those off. After going on a work trip for a week I came back to discover it was dead again. Something is wrong with teh battery or electrical system. It should automatically go to a deep sleep mode if lower voltage is detected. I don't know what is running (it is not something the driver selected) but it is killing the battery. The last time my Duracell jump pack registered an error and could not jump it. This is a serious defect that can leave people stranded without warning.

The main fuel line feeding the fuel pump ruptured without warning, causing gas to spray across the engine compartment. The hot engine caused the gas to start cooking off, resulting in a fire in the engine compartment. The fuel line rupture has been confirmed by my Ford dealership.

The 2022 Ford Maverick has a design flaw the harms the environment and places driver and passengers at risk. Specifically the vehicle does not have a metal skid plate which places the Evap System at risk for damage. If the system is damaged the vehicle is still driveable, but doing so allows gas vapors into the environment and worse, possibly into the passenger compartment. Looking under the vehicle, one finds some sort of fabric or mesh material which is definately not robust enough to protect the evap system components from damage. Driving on paved roads....no problem. Using this vehicle as a truck involves driving on farm land, pastures, lightly wooded areas,etc. This is where the damage may occur. There is no warning posted on the vehicle or in the owners manual that warns drivers to avoid these areas. The solution is simple. A recall to replace the fabric or mesh material with a metal skid plate. Most trucks and off-road vehicles have metal skid plates as standard components. Why the 2022 Maverick does not is beyond my understanding.

The side curtain airbags in my 2022 Ford Maverick have been recalled, but the replacement parts will not be available for 5-6 months. This is a Massive safety concern for me as I drive the truck with my 1 and 3-year-old daughters. This is a dangerous situation that I am being told can not be remedied in a timely manner. I can not be expected to cover the added cost of a rental vehicle for close to half of a year and I refuse to put my children and myself in danger by continuing to use this faulty vehicle.

The contact owns a 2022 Ford Maverick. The contact stated that NHTSA Campaign Number: 22V193000 (Electrical System) was repaired at the dealer. The contact was stopped by the police and informed that the brake light on the trailer was illuminated. The vehicle was taken to the dealer for the Ford Tech to reprogram the brake module. The contact was informed to no use the trailer brakes. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 9,000.

Transmission Failure. Following a 550 mile road trip over two days. The transmission would fail to engage in Drive and Reverse until the engine was throttled to 4000-4500RPM. Transmission felt like a Manual with failing clutch, would slip until slowly engaging after running at high RPMs for a few seconds. The condition appeared after the first day of the trip, and was intermittent, occurring only during standing starts. Once the vehicle was moving, there was no problem maintaining speed. Over the next two days the condition deteriorated to the point where it was occurring almost every time the vehicle was started and an attempt was made to start from a stand still. It began to become noticeable shifting from 1-2, 2-3, 3-4 as well, where it felt like the transmission was slipping during acceleration. There were no warning lamps or indications from the vehicle that there was a failure. This caused a loss of power and acceleration, which endangers the vehicle occupants in situations where power and acceleration is needed, such as merging, crossing intersections, or making defensive driving maneuvers. This vehicle was towed to a dealer, where the dealer validated the concern, and the transmission was replaced under warranty. Repair notes state that the transmission converter had failed. The transmission was returned to the manufacturer during the service visit. There are multiple instances online of other vehicles with this transmission having the same problem.

Mavericks with Integrated Trailer Brake Controllers are not sending any voltage to the trailer brakes when the brake pedal is pressed. Customers are at risk of not having the anticipated additional braking ability of their trailers and will be putting the entire braking load on the truck alone. A Ford dealership had my vehicle for 2 weeks with no repairs done or guidance on when it would be repaired.

The backup camera has been freezing off and on since buying the truck. When backing up, the camera will lag and then jump to the current picture the camera is showing. Earlier today, while backing up towards my trailer, the camera lagged causing me to run into the trailer. There was no damage to the truck or trailer, but is a safety issue if anyone crosses behind you while in reverse.

Driving down road at 45 mph as usual. Car suddenly shudders and as I pull to a stop car is stuck in neutral. Will not receive gas. Suddenly lurches into first gear, almost making me hit who is in front of me. I pull into center lane and the car is frozen and won't move. I restart the car and it stays stuck in first gear revving high. I limp it home given I'm a few minutes away. Could have caused a serious incident.

EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.

Since the date of purchase (10/29/21) I am unable to change/set FM stations. Apps (ie: iHeart, Spotify) and voice command work intermittently. Apps will not work unless phone is plugged in. 911 assist will not work if not paired and connected to a Bluetooth enabled and compatible cell phone (see pg. 59 2022 Maverick owner’s manual). Unsure if lane keeping assistance is working properly. Vehicle was brought to Sam Galloway Ford on 10/30/21. Per Sam Galloway Ford: “Ford is aware of these problems. It is a ‘hardware’ issue.”