2006 Ford Fusion complaints

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE FOAM WAS PROTRUDING FROM BENEATH THE HOUSING OF THE AIR BAG. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 44,000.

AFTER SLOWING DOWN JUST BEFORE THE STOP SIGN, MY CAR STARTED TO SPUTTER AND WHEN I TRIES TO ACCELERATE AFTER THE INTERSECTION IT STOPS ACCELERATING. I HAD TO LIMP ALONG TO GET HOME. LUCKILY, I WAS JUST ABOUT 1.5 MILES FROM HOME. I HAVE DONE FOR THIS CAR ALL SCHEDULED MAINTENANCE AND NEVER MISSED THE RECOMMENDED PERIODICAL OIL CHANGES. I DRIVE LESS THAN 5000 MILES A YEAR WITH THIS CAR AN IT HAS LESS 59,000 MILES ON IT. THIS MUST BE DUE TO A DEFECTIVE PART FROM THE FACTORY AND I SHOULD NOT PAY FOR IT. I HAVE LEFT IT PARKED ON MY DRIVEWAY UNTIL I HEAR FROM YOU AND BY WAY OF YOUR GOOD OFFICES HOPEFULLY FROM FORD. THANK YOU FOR KIND ASSISTANCE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE INTERIOR DOOR HANDLE BREAKS, INCASE OF CRASH OR FIRE YOU CANNOT EXIT. I WAS TOLD BY THE DEALER OTHER CARS WITH THE SAME DOOR HANDLE, HAS THEM RECALLED FOR THE SAME REASON.

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE DRIVER SIDE DOOR FAILED TO OPEN FROM THE INSIDE BECAUSE THE HANDLE WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WAS EXPOSED THROUGH THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 09/10/15*LJ UPDATED 12/11/2015*JS

IN 2013 I EXPERIENCED A LOSS OF SPEED/POWER ON MY 2006 FORD FUSION. I PULLED INTO A PARKING SPACE AT A SHOPPING CENTER AND TURNED THE CAR OFF. WHEN THE INCIDENT HAPPENED THE WRENCH LIGHT AND THE TRACTION LIGHT WHERE LIT ON THE DASHBOARD DISPLAY. WHEN I STARTED THE CAR BACK UP THE LIGHTS WERE OFF ON THE DASHBOARD AND THE CAR SEEMED TO RUN FINE. I DID NOT HAVE ANOTHER INCIDENT UNTIL 2014. THIS TIME THE CHECK ENGINE LIGHT CAME ON AS WELL AS THE WRENCH AND TRACTION LIGHTS. I TOOK IT AND HAD A DIAGNOSTIC DONE AND WAS TOLD IT WAS THE P CODE INDICATING THE THROTTLE. I DROVE THE CAR BACK HOME AND LOOKED UP THE P CODE AND FOUND HUNDREDS OF COMPLAINTS REGARDING THIS PART. IT WAS ALSO BEING SAID THAT THIS PART WAS DEFECTIVE AND THAT FORD HAD ISSUED A 10 YEAR EXTENDED WARRANTY (FROM TIME OF PURCHASE) ON THE PART. AGAIN, AFTER STARTING THE CAR THE NEXT DAY IT WAS RUNNING FINE, NO CHECK ENGINE LIGHT OR ANY OTHER LIGHTS ON. IT RAN FINE UNTIL JUNE 2015. AT THIS POINT I HAD HAD ENOUGH AND CALLED THE FORD DEALERSHIP WHERE I PURCHASED THE CAR. MIND YOU, MY CAR ONLY HAS 51K ORIGINAL MILES. I MADE AN APPOINTMENT AND DROPPED IT OFF ON JUNE 24TH, 2015. I WAS CALLED THAT DAY AND TOLD THAT FORD WOULD NOT BE COVERING THE THROTTLE BODY BECAUSE MY VIN# WAS NOT ONE LISTED. I QUESTIONED THIS BECAUSE THE INFORMATION I FOUND REGARDING THE WARRANTY FOR THE PART DIDN'T MENTION SPECIFIC VINS ONLY. THE SERVICE PERSON STATED THAT THEY WOULD FIX IT BUT ONLY IF I PAID FOR THE PART AND LABOR. I PICKED THE CAR UP TO

WAS ON THE FREEWAY IN TRAFFIC. CAR STARTING SURGING AND WAS HARD TO KEEP IT IN A STOPPED POSITION. ONCE TRAFFIC STARTED FLOWING, I STEPPED ON GAS AND WOULD HAD NO POWER COULD NOT ACCELERATE PAST 20 MILES AN HOUR. CAR WAS TOWED TO SHOP. DEALER SAID IT WAS THE THROTTLE BODY. I RESEARCHED AND FORD HAS HAD THIS PROBLEM ON THEIR CARS, BUT SAID MINE IS NOT INCLUDED EVEN THOUGH I FELL INTO THE 10 YEAR UNDER 150,000 MILES. THEY SAID MY VIN IS NOT COVERED.

MY 06 FUSION HAS BEEN SHIFTING FUNNY, BUT I DIDN'T KNOW WHAT IT WAS. WHILE HAVING MY OIL CHANGED, I HAD A 6 POINT INSPECTION DONE, AND NOTHING CAME BACK EXCEPT MY TIE-RODS NEEDING REPLACED. ONE NIGHT, WHILE DRIVING HOME, SUDDENLY MY CAR HAD A HESITATION WHEN SHIFTING INTO SECOND GEAR. IT WOULD REV UP TO 3 RPM, THEN SHIFT HARD INTO 2ND GEAR AND RUN FINE. TWO STOP LIGHTS LATER, THE SHIFT BEGAN TO GET HARDER. I FINALLY MADE IT HOME, BUT LATER HAD TO RUN AN ERRAND. THE SHIFTING GOT WORSE. NOW, IT WAS AS IF I WAS ABOUT TO GET A NECK INJURY FROM THE SHIFTING FROM 1ST TO 2ND GEAR. I REALIZED THAT I NEEDED TO GET HOME, BECAUSE IT WAS TOO LATE TO GO TO THE DEALERSHIP. WHEN HEADING TO WORK THE NEXT MORNING, THE WRENCH LIGHT POPPED UP ON THE DASHBOARD. LIVING ONLY 7 MINUTES FROM WORK, I THOUGHT I WAS FINE. BUT NOW, I NO LONGER MADE IT TO 2ND GEAR. IT STAYED ON FIRST, AND REMAINED REVVED UP TO THE POINT IT WAS LOSING POWER. I WAS SCARED THAT I WAS GOING TO GET STUCK IN THE MIDDLE OF THE ROAD. NOW, WITH MY VEHICLE IN THE SHOP, I'M BEING TOLD THAT THE TRANSMISSION NEEDS AN OVERHAUL. THE COST IS $2800. WHEN IS THE RECALL GOING TO COME INTO PLAY?

INTERIOR DOOR LOCK RELEASE HAVE REPLACED 4 TIMES ALL FOUR DOORS! TO EXIT CAR I HAVE TO PUT THE WINDOW DOWN AND USE THE OUT SIDE HANDLE TO OPEN THE DOOR TO EXIT VEHICLE . THIS COULD BE A SAFETY ISSUE IF AFTER AND ACCIDENT THERE WAS NOT POWER TO PUT THE WINDOW DOWN TO OPEN THE DOOR!

DRIVER'S SIDE DOOR LATCH - I PAID 448.13 TO HAVE REPAIRED. WHILE TRYING TO DRIVE AND HOLD ON TO DOOR TO KEEP IT FROM OPENING INTO ON-COMING TRAFFIC I COULD HAVE HAD AN ACCIDENT. I HSVE THE NEWS ARTICLE RECALLING FORDS WITH DOOR LATCH PROBLEMS. PLEASE HELP THE LEFT HAND TURN SIGNAL WILL NOT OPERATE AND THE COST TOO REPAIR IS OVER $1000.I AM UNABLE TO HAVE THIS REPAIRED AS I AM RETIRED AND ON A LOW INCOME. *TR.. ..UPDATED 04/13/17 *BF

AFTER PARKING MY CAR OUTSIDE MY HOUSE, I OPENED MY DOOR AND THE HANDLE SHORT CIRCUITED AND EXPLODED BLOWING OUT A PIECE OF THE DOOR HANDLE OFF EXPOSING THE THE HANDLES SPRINGS AND WIRING. *TR

CAR DIES WHILST DRIVING. THIS IS A SAFETY ISSUE. AUTHORIZED FORD DEALER SERVICE DETERMINED ISSUE WAS CAUSED BY A DEFECTIVE THROTTLE BODY. *TR

MY BRAKE LIGHTS AND REAR BLINKERS ARE NO LONGER WORKING. ONE DAY THEY JUST WENT OUT. OF COURSE I TOOK IT TO MY MECHANIC RIGHT AWAY SINCE IT IS EXTREMELY DANGEROUS DRIVING AT NIGHT WITH NO BRAKE LIGHTS AND I HAD RECENTLY ENROLLED INTO NIGHT CLASSES FOR MY FALL SEMESTER. I LEFT MY CAR WITH MY MECHANIC FOR NEARLY A WEEK BECAUSE HE THOUGHT THE SWITCH NEEDED TO BE REPLACED. HE ORDERED A NEW ONE, BUT WHEN IT ARRIVED HE CALLED TO TELL ME THAT IT WASN'T WHAT HE THOUGHT IT WAS. HE LET ME KEEP THE NEW SWITCH FREE OF CHARGE SINCE HE WASN'T ABLE TO HELP ME AT ALL. I HAD TO WALK TO THE SHOP TO PICK UP MY CAR BECAUSE MY MECHANIC WAS JUST AS BAFFLED AS I WAS. SINCE SOMEONE WHO WENT TO SCHOOL FOR THIS KIND OF STUFF COULDN'T HELP ME, I FIGURED I WOULD GOOGLE THE ISSUE TO SEE IF THERE WERE ANY ANSWERS OUT THERE. I FOUND WEBSITES FULL OF PEOPLE HAVING SIMILAR ISSUES. ( HTTP://WWW.CARCOMPLAINTS.COM/FORD/FUSION/2006/LIGHTS/TURN_SIGNALS_DO_NOT_WORK.SHTML ; HTTP://WWW.FORDFUSIONFORUM.COM/TOPIC/4304-PARKLAMPSTURN-SIGNAL-ISSUES/ ) *TR

MY BACK DOOR LOCK ON MY DRIVER SIDE STOPPED AUTOMATICALLY LOCKING AND UNLOCKING UNLESS I DO IT MANUALLY. IT WASN'T A HUGE ISSUE SINCE I DON'T HAVE A LOT OF PEOPLE IN MY BACKSEAT. LAST NIGHT, WHEN I GOT HOME FROM WORK, I REACHED TO OPEN MY DOOR AND NOTHING HAPPENED. I THOUGHT I WAS TIRED ENOUGH TO BE MISTAKEN, BUT IT HAPPENED. MY DOOR WILL NOW ONLY OPEN FROM THE OUTSIDE. THE LOCK STILL LOCKS AND UNLOCKS AUTOMATICALLY WHEN I USE THE BUTTON, BUT I HAVE TO ROLL DOWN MY WINDOW TO GET OUT. THIS CAN BE HAZARDOUS IF SOMEONE IS LOCKED IN THE CAR DURING A WRECK, FIRE, GAS LEAK, ETC. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE FRACTURED AND PREVENTED THE CONTACT FROM EXITING THE VEHICLE. THE CONTACT STATED THAT THE PART WAS REPLACED THREE TIMES ON BOTH THE DRIVER AND PASSENGER SIDE DOOR HANDLES. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DOOR HANDLE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF FAILURE. THE FAILURE MILEAGE WAS 48,000.

I STARTED HAVING ISSUES WITH MY CAR IN 2008. MY CAR THEN WOULD NOT GO ANY FASTER THAN 50 MPH WOULD NOT ACCELERATE ON THE FREEWAY ON RAMP , AND COULD NOT GO UP HILLS. SO I REPAIRED IT OR SO I THOUGH. NOW BRING ME TO LAST YEAR 2014 I STILL EXPERIENCE ALL THAT PULL WHEN TRAVELING BUT NOW MY SPEEDOMETER WAS GOING CRAZY AND WOULD JUST GO UP TO 100 MPH AS I WAS SITTING AT A STOP LIGHT/SIGN. FAST FORWARD TO AUGUST 2014 WHEN I HAD THE SPEED SENSOR CHANGED...AND NOW I'M IN MARCH 2015 AND AGAIN MY CAR PULLS, ME SPEEDOMETER GOES CRAZY. WELL AS I WAS DRIVING WITH MY TWO CHILDREN IN THE CAR AGES 5 YEARS, AND 7 MONTH OLD. I WAS REAR ENDED WHILE PULLING UP TO A STOP SIGN!!! LUCKILY IT WAS JUST ENOUGH TO SCARE MY DAUGHTER AND I WAS JUST A BIT SORE THE WHOLE DAY BUT THINGS COULD HAVE BEEN WORSE! AFTER READING UP ON THE SURE MY ISSUE I AM HAVING I JUST ABOUT HAD ENOUGH! FORD NEEDS TO TAKE RESPONSIBILITY FOR FAULTY TRANSMISSIONS AND FAULTY VEHICLES!!! *TR

WHEN VEHICLE REACHES 65 MPH A BUFFETING OF THE REAR WINDOW IS SO LOUD THAT IT SEEMS AS IF IT WILL BREAK . DOES NOT HAPPEN ALL THE TIME. IT HAPPENS EVEN WITH THE WINDOWS RAISED. I HAVE A BLANKET STUFFED BETWEEN THE REAR DASHBOARD AND THE WINDOW TO QUIET THE BUFFETING. OWNERS MANUAL REFERS TO THE PROBLEM AND HOW TO REMEDY IT IF THE WINDOWS IN THE FRONT COMPARTMENT ARE DOWN , BUT NOTHING IF THE WINDOWS ARE UP. NEVER HAD THIS HAPPEN IN THE PAST WITH ANY VEHICLE . VERY UNUSUAL . *TR

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE SPEED WOULD DECREASE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE VARIABLE VALVE SOLENOIDS, THE IGNITION COILS, THE PCM REFLASH AND THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH ATTEMPTING TO ENGAGE THE BRAKES, THE BRAKES FAILED TO STOP THE VEHICLE CAUSING IT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THE AIRBAGS FAILED TO DEPLOY AND THE SEAT BELT DID NOT LOCK. THE CONTACT SUSTAINED UNKNOWN INJURIES AND MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000.

MY DAUGHTER NOTICED BOTH FRONT TURN SIGNALS WERE NOT FLASHING WHILE BOTH REAR ONES WORKED FINE. ALL INDICATORS FROM INSIDE THE CAR SHOWED FRONT TURN SIGNALS WORKING WHEN THEY WERE NOT. I REPLACED BULBS TO NO AVAIL. I WENT ON INTERNET AND DISCOVERED OTHER OWNERS WHO HAD THE SAME OR SIMILAR PROBLEM WITH TURN SIGNALS. PEOPLE ON THE INTERNET RECOMMENDED REPLACEMENT OF THE SMART JUNCTION BOX AT THE DEALER FOR APPROXIMATELY $600. I TOOK CAR TO LOCAL DEALER FOR REPLACEMENT OF SMART JUNCTION BOX. TURN SIGNALS BEGAN TO WORK FINE. WHAT I AM CONCERNED ABOUT, IS THAT THIS SAME SMART JUNCTION BOX CONTROLS SEVERAL OTHER FUNCTIONS OF THE CAR. SEVERAL COMMENTS FOUND ON THE INTERNET SAID THAT FORD FUSIONS HAD ACTUALLY LOST POWER ON THE HIGHWAY WHEN BEING DRIVEN AT NORMAL SPEEDS. THE ENTIRE CAR WENT DEAD IN HIGHWAY TRAFFIC. WITHOUT POWER STEERING, THEY COULD HARDLY GET CAR OUT OF THE HIGHWAY. THIS WAS REPORTED SEVERAL TIMES. AGAIN, THE REASON FOR THE LOSS OF POWER WAS THE FAILURE OF THE SMART JUNCTION BOX. I DO NOT UNDERSTAND HOW FORD CANNOT BE HELD ACCOUNTABLE TO A SAFETY RECALL FOR THIS ISSUE. *TR

TRANSMISSION STARTED SLIPPING AND THEN FAILED COMPLETELY.HAD TO HAVE CAR TOWED TO DEALER.THEY SAY IT NEEDS TRANSMISSION REPLACED.THEY SAY RUST CAUSED A HOLE IN TUBING AND FLUID RAN OUT.CAR HAS JUST MORE THAN 73,000 MILES ON IT.CAR SERVICED ROUTINELY,NOT DRIVEN IN BAD WEATHER MUCH.

WHEN DRIVING ON THE HIGHWAY AND ROADWAY, SUCH AS BRIDGES THIS SUMMER, MY VEHICLE STALLED SEVERAL TIMES, LOST POWER COMING ALMOST TO A COMPLETE STOP, PUTTING MY FAMILY AND I AT RISK. WHEN I PRESSED ON THE GAS TO ACCELERATE, THE ENGINE BEGIN TO RACE, CAUSING THE "CHECK ENGINE LIGHT" TO COME ON. IT ALSO JERKED AND SKIDDED AS I TRIED TO MANEUVER THE STEERING. TO AVOID ACCIDENTS ON THESE OCCASIONS, THE VEHICLE HAD TO BE PULLED OVER AND SUBSEQUENTLY, PARKED. HIGHWAY DRIVING WAS ALSO AVOIDED MOST OF THE SUMMER FOR SAFETY AND CONCERN. THERE IS ALSO AN ISSUE WITH THE FRONT DRIVER SIDE AIRBAG, AS RECENT AS THIS SUMMER, THE SEAL BECAME DISTORTED, TWISTED AND CRACKED IN THE DASHBOARD. LASTLY, ABOUT 2 WEEKS AGO, THE REAR DOOR LOCK ON THE DRIVER SIDE NO LONGER WORKS, THE DOOR MUST BE OPENED MANUALLY FROM THE INSIDE OF THE CAR. THESE ARE VALID VEHICLE DEFECTS AND SAFETY ISSUES AND FORD MUST STEP UP AND DO THE RIGHT THING FOR ALL PARTIES OF INTEREST. *TR

PASSENGER SIDE AIR BAG BULGING OUT OF THE CONSOLE AFRAID IT IS GOING TO DISCHARGE AT ANYTIME AND HURT MYSELF OR PASSENGER THIS IS DANGEROUS. ALSO FRONT DRIVER SIDE LOCK DECIDED TO BREAK AND ONLY WAY TO EXIT IS TO ROLL DOWN WINDOW ALSO HAS POTENTIAL TO BE DANGEROUS. WHY IS THERE NOT A RECALL ON ALL THESE DANGEROUS ITEMS THAT SEEM TO REAPPEAR ON EVERY COMPLAINTS LISTED. *TR

THE POWER STEERING ON MY CAR FAILED TODAY. ON MY WAY TO WORK THE STEERING BECAME DIFFICULT. AT LUNCH, THE STEERING STARTED TO REALLY BE DIFFICULT AND LOCKED UP AS I PULLED INTO THE LOT. WE CHECKED THE POWER STEERING FLUID AND IT WAS FULL. AFTER WORK, I HEADED HOME. THE CAR WAS OKAY TO BEGIN WITH BUT THE LONGER I DROVE THE HARDER THE STEERING BECAME- IT BECAME INCREASINGLY HARD TO TURN CORNERS. I STARTED HAVING TO USE TWO HANDS TO TURN THE WHEEL. FINALLY, WHILE TURNING RIGHT, THE POWER STEERING FAILED.THE STEERING WHEEL LOCKED UP WOULDN'T TURN THE WHEELS AT ALL. I GOT VERY LUCKY AND HAPPENED TO BE TURNING INTO MY DRIVEWAY WHEN THE STEERING LOCKED FOR GOOD. ONCE THE CAR COOLED, WE WERE ABLE TO MOVE MY CAR COMPLETELY INTO THE DRIVEWAY AND PARK. HAD I BEEN ON A STREET OR THE HIGHWAY WHEN MAKING THAT TURN, THERE WOULD HAVE BEEN NO WAY FOR ME TO COMPLETE THE TURN AND A CRASH OR ACCIDENT WOULD HAVE BEEN A VERY VERY GOOD POSSIBILITY. *TR

MY 2006 FORD FUSION WITH A 3.0 V6 AND AUTOMATIC TRANSMISSION HAS HAD THE FOLLOWING SAME ISSUES OVER THE PAST 18 MONTHS: - LOSES POWER AT CITY, HIGHWAY AND PARKING LOT SPEEDS WITHOUT WARNING .... AT LEAST A HALF-OF-DOZEN TIMES - ENGINE STILL IDLES/RUNS ROUGH, BUT WILL NOT ACCELERATE BEYOND 15-20 MPH - WRENCH LIGHT INDICATOR COMES ON, (SOMETIMES ENGINE LIGHT TOO). WHEN I TURN THE ENGINE OFF AND RESTART THE VEHICLE, IT WILL OPERATE FINE MOST THE TIMES. IT HAS DONE IT REPEATEDLY A COUPLE OF TIMES. THE WRENCH LIGHT INDICATOR WILL GO OFF AFTER RESTART, BUT THE CHECK ENGINE LIGHT WILL REMAIN ON FOR A COUPLE OF DAYS THEN GO OUT. - FORD CLAIMS THAT THE 2006 FUSION IS NOT COVERED UNDER CUSTOMER SATISFACTION PROGRAM #13N03 WHICH COVERS NEWER FUSIONS AND OTHER FORD MODELS. FORD ADVISE TO HAVE THE REPAIR MADE AND THEY WILL REIMBURSE CUSTOMERS OF THE REPAIR EXPENSE AT A FUTURE DATE, IF FORD SHOULD EVER ISSUE A CSP PROGRAM FOR THE 2006 FUSION. - I HAVE HAD THIS HAPPEN AT HIGHWAY SPEEDS ON INTERSTATE HIGHWAYS AND RURAL HIGHWAYS WITHOUT SHOULDERS TO PULL OVER. THIS IS OBVIOUSLY A DANGEROUS SITUATION AND NEEDS TO BE RECTIFIED ASAP. - I HAVE HAD SEVERAL INCIDENTS WHERE I WAS ALMOST HIT FROM BEHIND DUE TO THIS ISSUE AND IT'S JUST A MATTER OF TIME BEFORE SOMEONE IS SERIOUSLY INJURED DUE TO THIS ISSUE. MY RESEARCH SHOWS THAT THIS IS AN ONGOING PROBLEM FOR PEOPLE WITH CERTAIN FORD PRODUCTS. - FORD.....DUE THE RIGHT THING AND MAKE IT RIGHT FOR ALL! *TR

THIS VEHICLE LOSE POWER AND SLOWS DOWN, IT HAPPENED ON THE EXPRESS WAY MORE THAN 5 TIMES. I WAS ALMOST REAR ENDED BY A SEMI TRUCK. I ONLY DRIVE IT ON SIDE STREETS NOW. IT POPS INTO GEAR VERY HARD, THE WRENCH LIGHT AND THE CHECK ENGINE LIGHT IS ON. IT GETS STUCK IN SECOND GEAR AND BURNS A LOT OF GAS. IT STARTED SOON AFTER THE WARRANTY RAN OUT. I HAD A LOT OF REPAIRS DONE AND THE POWER TRAIN AND ENGINE IS NOT WORKING RIGHT AS OF YET, SOMETHING IS WRONG WITH THIS FORD FUSION 06 AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEMS WITH IT. WHY DOES IT TAKE THE DEATHS OF MANY INNOCENT PEOPLE FIRST BEFORE THERE'S A RECALL? *TR

WHILE DRIVING ON THE SUNCOAST PKWY AT 60 MPH MY VEHICLE SUDDENLY SLOWED TO ONLY 20 MPH CAUSING ME TO BE A ROAD HAZARD. I WAS NEARLY KILLED BY THE OTHER CARS IN THE FLOW . IT WAS A FRIGHTENING EXPERIENCE. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY DECELERATED AND FAILED TO ACCELERATE OVER 20 MPH. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN NOTICED THAT THE WRENCH WARNING LIGHT ILLUMINATED AND DIAGNOSED THAT THE DRIVE TRAIN AND THE THROTTLE BODY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

WHILE SHIFTING FROM HIGHER GEAR TO LOWER GEAR WHILE CLIMBING A HILL, TRANSMISSION JUMPED BETWEEN GEARS, SLAMMING THE GEARS AS IF POPPING A CLUTCH (IT'S AN AUTOMATIC TRANSMISSION). ON ANOTHER HILL, THE VEHICLE DID NOT ENGAGE IN THE LOWER GEAR, REVVING UP TO ABOUT 4000 RPM AS IF IN NEUTRAL, LEAVING THE CAR DECELERATING ON THE UPHILL STRETCH AMONG SPEEDING TRAFFIC. I HAD TO MOVE THE GEAR SHIFT TO NEUTRAL AND BACK TO DRIVE, EASE ON THE ACCELERATOR, AND THE LOWER GEAR ENGAGED, AFTER SLOWING TO ABOUT 35 ON 65 MPH SPEED LIMIT FREEWAY. FORD LISTS THE REPAIR IN TSB 08-24-1 AS "TRANSMISSION HARSH SHIFTING" AND RECOMMENDS REPLACEMENT OF THE MAIN CONTROL. THIS PART HAS BEEN IDENTIFIED AS FAULTY AND COMMON WITH THE TRANSMISSIONS INSTALLED ON MY VEHICLE AND MANY OTHER MAKES AND MODELS. IT PRESENTS A CLEAR DANGER TO DRIVERS AND PASSENGERS WHO RISK BEING REAR-ENDED DUE TO SUDDEN DECELERATION OR STRANDED DUE TO "HARSH SHIFTING" DAMAGE TO THE TRANSMISSION AND DRIVE TRAIN. I HAVE NO CONFIDENCE DRIVING THE CAR OUT OF TOWN OR NEAR ANY HILL, AND THE VEHICLES SHOULD BE RECALLED. *TR

I WAS TRYING TO ACCELERATE TO MERGE ON TO THE FREEWAY. MY 2006 FORD FUSION REFUSED TO RESPOND. THE REVS WENT UP TO 4000 RPM AND THE CAR JUST STAYED THERE GOING VERY SLOWLY. AFTER A FEW SECONDS, IT JERKED FORWARD, SO I PULLED BACK ON THE SIDE OF THE ROAD AND LET THE "TANTRUM" PAST. I'VE HAD SEVERAL CLOSE CALLS SINCE-- THE MOST SCARY ONE OCCURRING IN STOP-AND-GO TRAFFIC. WHEN ACCELERATING AFTER SLOWING DOWN, THE FUSION WILL REV UP AND CREEP SLOWLY FORWARD UNTIL ONE REMOVES ONE'S FOOT FROM THE GAS PEDAL AND ALLOW IT TO SETTLE BACK IN GEAR. LUCKILY, I'VE AVOIDED BEING REAR-ENDED BY FAST APPROACHING CARS. RECENTLY, FORD CLEANED THE THROTTLE BODY AND CHARGED $232.00, I STILL HAVE THE SAME PROBLEM AND AM STILL WAITING FOR A RECALL ON THIS VEHICLE. INCIDENTALLY, THE STALLING ALSO HAPPENS AFTER MAKING A RIGHT OR LEFT HAND TURN. *TR

THE POWER LOCKS, AND INTERIOR DOOR HANDLES TO OPEN THE DOOR IN BOTH THE FRONT AND REAR/DRIVER AND PASSENGER SIDES MALFUNCTION REGARDLESS OF USE/FORCE. THE INTERIOR DOOR HANDLE WARPS/BENDS AND BREAKS. THE LOCKING MECHANISM ALSO MALFUNCTIONS MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INTERIOR. IN ONLY WAY TO EXIT THE VEHICLE IS TO ROLL DOWN THE WINDOW AND OPEN THE DOOR FROM THE OUTSIDE DOOR HANDLE. ONCE THE LOCKING MECHANISM HAS MALFUNCTIONED, IT IS IMPOSSIBLE TO LOCK THE VEHICLE VIA THE REMOTE ALARM OR WITH THE PHYSICAL KEY. THIS PRESENTS A MAJOR PROBLEM AS 1:IN THE EVENT THAT THE DRIVER AND OR PASSENGERS NEED TO EXIT THE VEHICLE IT IS IMPOSSIBLE UNLESS WINDOWS ARE ROLLED DOWN. 1B: IN THE EVENT THAT A CRASH OR WINDOWS MALFUNCTION, ALL OCCUPANTS ARE TRAPPED IN VEHICLE 2:THE VEHICLE IS WITHOUT PASSIVE ANTI-THEFT AS THE DOORS ARE UNABLE TO LOCK. *TR

VEHICLE IS HESITANT TO START AND GET UP PAST 5 MPH AND ENGINE LIGHT CAME ON. TOOK CAR TO LOCAL PEP BOYS WHERE THEY PLACED IT ON ENGINE MACHINE. PER PEP BOY CAR THROUGH THROTTLE BODY STUCK OPEN CODE. LOCAL DEALER CLOSED DROPPED CAR OFF FOR LOOK OVER. DEALER CONFIRMED MONDAY THAT THROTTLE BODY IS STUCK BUT STATE THAT THIS VEHICLE IS NOT A PART OF CURRENT THROTTLE BODY RECALL...IM WRITING THIS HERE SO IF FORD SHOULD DECIDE TO COVER THIS AT A FUTURE TIME I'LL BE ABLE TO FILE FOR A REFUND. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE PARKED, THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE FAILED TO OPEN THE DOOR. THE FAILURE OCCURRED ON ONE OCCASIONS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTERIOR DRIVER SIDE DOOR HANDLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

AS REPORTED MULTIPLE TIMES THESE TRANSMISSIONS BEGIN TO SLIP VERY BADLY. WHILE TRYING TO MERGE INTO TRAFFIC ALMOST 90% OF THE TIME HOT OR COLD AT ABOUT 40MPH WHEN YOU PRESS THE GAS THE TRANSMISSION WILL SLIP LEAVING YOU HANGING OUT TO DRY(THIS IS EXTREMELY DANGEROUS)...WHEN DOWNSHIFTING SOMETIMES AROUND 20MPH THERE WILL BE A LOUD BANGING UNDER THE DRIVERS SIDE AREA...THE TSB WAS ISSUED WAY BACK IN 2007 REGARDING ALL THESE ISSUES BUT NO RECALL...THE FLOOR MATS WERE RECALLED? BUT NOT THIS ISSUE. ALL OVER THE INTERNET YOU SEE THE INSANE AMOUNT OF PEOPLE HAVING THIS SAME ISSUE DUE TO THE AISIN TRANSMISSION THEY USED....SAME PROBLEM OCCURRED IN MULTIPLE MAKES AND MODELS OF VEHICLES WITH SAME TRANSMISSION COMPONENTS. THEY SAY REPLACE THE TRANSMISSION "VALVE BODY" OR AKA CONTROL ASSEMBLY...ITS ONLY $2,000 IF YOU HAVEN'T ALREADY BURNT UP THE WHOLE TRANSMISSION THEN ITS $4-5K. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE DOORS BECAME INOPERABLE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

RIGHT DIRECTIONAL SIGNAL DIDN'T WORK. *TR

I HAD A PASSENGER IN THE REAR PASSENGER SIDE SEAT THAT COULD NOT OPEN THE DOOR TO GET OUT. I HAD TO GO TO THE OUTSIDE DOOR HANDLE TO OPEN THE DOOR. ON INSPECTION IT APPEARS THE INTERIOR REAR DOOR HANDLE HAS STARTED TO CRACK AT THE PIVOT POINT(SPRING RETURN ATTACHMENT POINT). THE BREAK CAUSES INTERFERENCE WITH THE REAR DOOR HANDLE BEZEL AND LIMITS TRAVEL OF DOOR HANDLE (DOOR WON'T OPEN). IT APPEARS THE SAME THING IS STARTING TO HAPPEN ON THE OTHER REAR DOOR. CAR ONLY HAS 85000 MILES. IT APPEARS TO BE A DESIGN/MANUFACTURING DEFECT. I WILL BE GOING TO FORD TO GET A REPLACEMENT WHICH I HOPE HAS HAD A DESIGN CHANGE TO FIX THIS. THE REAR DOORS HAD BEEN USED VERY LITTLE SO ITS NOT A USAGE ISSUE. THIS IS A REAL SAFETY CONCERN FOR REAR PASSENGERS. *TR

THE FACTORY IGNITION COILS BEGAN TO SHORT AGAINST THE INTERIOR WALLS OF THE ENGINE HEAD ABOVE THE SPARK PLUGS. AS THEY SHORTED IT BURN THE POWER CONTROL MODULE (PCM). WITH NO PCM MY SPARK PLUGS FAILED TO LIGHT, CAUSING MY ENGINE BECOME FLOODED WITH GASOLINE, WHICH WASHED AWAY THE LUBRICANTS ON MY CYLINDER AND HEADS CAUSING ALL OF MY CYLINDERS AND HEADS TO BECOME DAMAGED. AS THIS HAPPENED BEFORE I WAS ABLE TO PULL OVER MY ENGINE SHUT OFF. CAUSING ME TO LOSE POWER STEERING AND ALL OF THE OTHER ELECTRICAL FUNCTIONING COMPONENTS. LUCKILY I WAS ON A FAIRLY QUIET ROAD AND AT SOMEWHAT LOW SPEEDS, BUT FOR THE MANY OTHERS THAT HAVE OR COULD EXPERIENCE THE SAME PROBLEM MIGHT NOT HAVE BEEN OR BE AS LUCKY. 2006 FORD FUSION 3.0L V6. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE IDLER PULLEY FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

THE DASHBOARD IS BULGING/BUCKLING AGAINST THE PASSENGER SIDE AIRBAG. THE BUBBLE APPEARS TO BE CAUSED BY THE DASH MATERIAL SURROUNDING THE AIRBAG BECOMING DETACHED OR UNGLUED. THE POSITION OF THIS BULGING AND SEPARATION CAUSE CONCERN THAT THE AIRBAG MAY MALFUNCTION UPON DEPLOYMENT. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD WAS SEPARATING WHICH COULD POSSIBLY EXPOSE THE AIR BAG. THE CONTACT MENTIONED THAT THE PASSENGER SIDE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.

THE DASHBOARD IS SEPARATING FROM THE PASSENGER AIR BAG AREA AND SEEMS TO BE STRETCHED BY SOMETHING, UNSURE AS TO CAUSE AS NOTHING IS APPARENT. ALSO THE FRONT LEFT DEFROSTER AIR VENT NEAR THE WINDSHIELD STARTED TO DETACH FROM THE DASHBOARD AS IF IT WAS UNDER SPRING PRESSURE TO DO SO. THE LOCAL DEALER SAYS THERE IS NO FIX FOR THIS TO HIS KNOWLEDGE , EXCEPT TO REPLACE THE ENTIRE DASHBOARD. THE DASHBOARD DOES NOT APPEAR TO BE MADE OF MATERIAL THAT STANDS UP TO UV LIGHTING AS TO WEAR AND NOW APPEARS TO BE EITHER POOR QUALITY MATERIALS OR WAS FACTORY INSTALLED IMPROPERLY. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT NOTICED A PROTRUSION ON THE PASSENGER SIDE DASHBOARD WHERE THE AIR BAG WAS LOCATED. IT APPEARED AS IF THE AIR BAG WOULD DEPLOY AT ANY MOMENT. THE VEHICLE WAS TAKEN TO TWO MECHANICS WHO BOTH STATED THAT THE PROTRUSION WAS NOT CAUSED BY THE AIR BAG. THE VEHICLE WAS TAKEN TO A BODY SHOP AND THE MECHANIC STRETCHED THE MATERIAL TO REPAIR THE DASHBOARD AND CLOSED THE OPENING THAT WAS CREATED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 62,000. UPDATED 09/15/14*LJ

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE SEATBELT LIGHT ILLUMINATED AFTER SECURING THE SEATBELT. IN ADDITION, THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE MADE TO UNLATCH THE SEATBELT BUT FAILED. THE CONTACT HAD TO CUT THE DRIVERS SEATBELT TO RELEASE FROM THE SEAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

MOTOR MOUNTS: ALL THREE MOUNTS HAVE BEEN REPLACED. 6 TOTAL. ONE HAS BEEN REPLACED TWICE. ONE THREE TIMES. ELECTRIC DOOR LOCKS & WINDOW REGULATORS: FRONT DRIVER AND REAR RIGHT PASSENGER HAVE FAILED. DRIVER FLOOR MAT: SLIDES. *TR

CAR STARTED KNOCKING GO SLOW THAN WOULD SPEED UP, BRAKES WOULD WORK THAN NOT! GOT HOME CHECKED THE OIL IT WAS LOW, WHICH WAS FINE A WEEK BEFORE THAT. PUT OIL IN IT, MY SON SAW IT LEAKING AROUND OIL PAN. SO HAD IT TOWED TO A CAR REPAIR CHECKED IT OUT, THEY ARE TELLING ME IT'S THE TIMING CHAIN, NOW THEY SAY THE CODES COMING OFF THE MACHINE THEY ARE HOOKING IT UP WITH SAY IT NEEDS A NEW ENGINE. I DON'T EVEN HAVE A 100 THOUSAND MILES ON IT AND TAKE GOOD CARE OF MY CAR! *TR

THE MOTOR MOUNT AND BRACKETS BROKE AS I DROVE ON A LOCAL STREET AT SPEED OF 25 MPH. IT WAS THE WRONG DESIGN FOR THIS VEHICLE BUT THEY INSTALLED IT ANYWAY. LATER THEY DESIGNED THE CORRECT PART WHICH WAS THE ONE THE SERVICE TECH PUT IN THE CAR THAT SAME DAY,THE BILL WAS $400. *TR

DRIVING ON INTERSTATE 5 EVENING COMMUTE, GOING UP A HILL WHEN THE ENGINE LOST POWER, REACHING A MAXIMUM SPEED OF 20MPH WITH THE ACCELERATOR PEDAL PRESSED DOWN FULLY. THE ESC LIGHT AND A "WRENCH" LIGHT BOTH ILLUMINATED. WAS ABLE TO SAFELY EXIT THE INTERSTATE AND TURNED THE CAR OFF. AFTER A FEW MINUTES I RESTARTED WITH THE AFOREMENTIONED LIGHTS REMAINING OFF. VEHICLE RAN FINE. TOOK IT TO THE FORD DEALER THE NEXT DAY AND WAS TOLD THE THROTTLE BODY WOULD HAVE TO BE REPLACED, WHICH I REJECTED AT THE TIME. THE VEHICLE RAN FINE UNTIL 1 DAY PAST A YEAR FROM THE FIRST INCIDENT (JUNE 26, 2014). THE SAME THING HAPPENED TWICE, ONCE AT 60MPH AND AGAIN AT 40MPH. IT OCCURRED AGAIN ON JUNE 27, 2014, HOWEVER THIS TIME FROM A STOP. I BEGAN TO ACCELERATE FROM THE STOP SIGN AND BARELY MADE IT ACROSS THE INTERSECTION. EACH OCCURRENCE I TURNED THE ENGINE OFF AND RESTARTED, THE VEHICLE RAN FINE. I DID A WEB SEARCH ON THE ISSUE AND FOUND NUMEROUS OTHER FORD OWNERS ARE EXPERIENCING THE SAME THING WITH MODEL YEARS 2005, 2006 AND 2007. *TR

WAS DRIVING DOWN A BUSY HIGHWAY WHEN THE CAR JUST CHUGGED AND DIED. THE TOOL LIGHT CAME ON AFTER IT FAILED TO GO BY GIVING IT GAS.THIS IS THE SECOND TIME THIS HAS HAPPENED TO MY CAR. I TOOK IT TO MY FORD DEALERSHIP AND IT TURNED OUT TO BE THE THROTTLE BODY. I AM VERY UPSET AND BEING A WOMEN I HAD NO IDEA HOW TO HANDLE THIS SITUATION WHEN IT HAPPENED. IT HAS COST ALOT OF MONEY TO REPLACE AND IT IS VERY DANGEROUS. IS THERE A RECALL ON THIS PART ? IF SO I WOULD LIKE TO KNOW ABOUT IT. *TR

WHEN I WAS DRIVING 55 MPH, THE CAR DID A LITTLE JERK LIKE IT HAD MISSED. NO LIGHTS CAME ON AND I DROVE TO THE NEAREST SIDE ROAD OFF THE HIGHWAY AND STOPPED. I TRIED TO GO FURTHER BUT ONLY MADE IT ABOUT 100 YARDS BECAUSE I LOST ALL POWER INCLUDING STEERING. MY CAR WAS HALF IN THE ROAD SO I WAS THANKFUL THIS WAS NOT A HIGH TRAFFIC ROAD. THE ENGINE LIGHT CAME ON AND THERE WAS A SMELL. IT WASN'T THE SMELL OF OIL BUT WAS A FLUID SMELL. THE CAR WOULD NOT TURN OVER AND HAD TO BE TOWED TO THE DEALERSHIP. IT CAME UP AS A MISFIRE 3 AND THEY TOLD ME THAT THEY HAD TO REPLACE THE COIL. THIS DID NOT FIX THE PROBLEM AND THEY SAID THE 3 COIL WHEN IT BLEW IT TOOK OUT THE OTHER COILS AS WELL AS THE 6 SPARK PLUGS AND THE PCM. THIS WAS A $2250 REPAIR. I ONLY HAVE 68,000 ON THE CAR. AFTER READING OTHER TSB, SOME STATED THAT IF UNDER 80,000 MILES/8 YEARS THAT IT WAS COVERED UNDER THE MANUFACTURE WARRANTY. I CALLED FORD AND WAS TOLD I MISSED THE 8 YEAR MARK BY EXACTLY 30 DAYS. THERE WAS NOTHING THAT I COULD DO BUT HOLD ON TO MY RECEIPTS IN CASE THERE WOULD EVER BE A RECALL. THIS IS THE ONLY MAJOR ISSUE I HAVE HAD. I HAVE NEVER HAD ANY OTHER ENGINE ISSUES WITH THE CAR. I'VE ONLY HAD 2 MINOR ISSUES BEFORE THIS AND THEY WERE THE LUMBAR GOING OUT IN THE DRIVER'S SEAT ($300 REPAIR THAT I DID NOT REPLACE) AND 2 DOOR HANDLES BREAKING FROM THE INSIDE THAT WERE $160 TO REPLACE EACH. I DID REPLACE BC OF THE SAFETY ISSUE OF NOT BEING ABLE TO GET OUT OF THE CAR. AFTER READING THE TSB, I SEE THAT THE PCM AND CO