2006 Ford Fusion complaints

MY DOOR HANDLES HAVE SNAPPED AND BROKE OFF...DRIVER SIDE AND DRIVERS BACK DOOR...THEY ARE PLASTIC WITH A FAKE CHROME COATING. IM THE ONLY DRIVE NO KIDS AND BACK SEAT IS RARELY USED CAR HAS 30,000 MILE ISSUE BEGAN @ 20,000 BOUGHT CAR BRAND NEW. *TR

IN 2006 I BOUGHT A 2006 FORD FUSION. I HAVE HAD PROBLEMS SINCE I GOT IT BLOWING BULBS IN THE TURN SIGNALS. I NOW FIND OUT THAT IT IS MY SMART JUNCTION BOX CAUSING THIS AND FORD MOTOR WILL DO NOTHING ABOUT IT. PART OF THE SMART JUNCTION BOX IS MELTED TOGETHER. THIS IS FORD'S FAULTY DESIGN AND THEIR FAULT. *TR

2006 FORD FUSION V6.... MY WIFE WAS DRIVING ON THE EXPRESSWAY WITH MY TWO YEAR DAUGHTER IN THE BACK SEAT WHEN THE TRANSMISSION SLIPPED OUT OF GEAR AS IF IT WENT INTO NEUTRAL GOING 60MPH. SHE LET OFF THE GAS PEDDLE AND THE TRANSMISSION ENGAGED . TRYING TO GET BACK UP TO SPEED SHE STEPPED ON THE GAS PEDDLE AND THE CAR JERKED VIOLENTLY AND CAUSED IT TO SLOW DOWN EVEN MORE. SHE WAS ABLE TO GET IT BACK UP TO SPEED BY SLIGHTLY PUSHING DOWN ON THE GAS PEDDLE.. AFTER READING ALL THE COMPLAINTS, HOW IS THERE NOT A FORCED RECALL!!!! THIS IS EXTREMELY DANGEROUS! THE 2010 FUSION HAS A RECALL FOR UNSAFE TRANSMISSION ISSUES, WHY NOT THE 2006? *TR

WHEN DRIVEN IN TOWN CAR WILL STALL FOR ABOUT 10 TO 15 SECOND THEN JERK FORWARD AROUND SPEED BETWEEN 25- 40MPH WITH A SUDDEN INCREASE IN SPEED UP TO 10MPH. WHEN ENTERING HIGHWAY AND MERGED INTO TRAFFIC. I BEGAN SPEEDING UP TO 60 MPH THE TRANSMISSION HESITATEDTHE STALL FOR 10 SECONDS THEN JERKED,LIKE IT FINALLY SHIFTED BUT THEN TURN AROUND AND STALL GAIN. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL AND WAS STUCK IN 2ND OR 3RD GEAR ONE OF THEM. I TOOK THE CAR TO THE DEALER SEVERAL TIMES AND THE DON'T KNOW WHAT THE PROBLEM, THIS SUDDEN INCREASED IN SPEED IS VERY DANGEROUS DURING RUSH HOUR WITH TRAFFIC I NEARLY HIT THE CAR INFRONT OF ME, THE CAR STALLING IS VERY FLIGHTING WHEN ENTERING HIGHWAY. THIS CAN CAUSE A MAJOR HIGHWAY ACCIDENT. *TR

ENTERED HIGHWAY AND MERGED INTO TRAFFIC. BEGAN SPEEDING UP TO AROUND 55 MPH AND TRANSMISSION HESITATED AND JERKED, CAUSING ME TO SLOW DOWN TO AROUND 45 MPH. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL BEING PUSHED AND WAS STUCK IN 2ND OR 3RD GEAR. I COASTED TO THE NEXT EXIT WHERE I EXITED THE HIGHWAY AND DROVE TO A SAFE PLACE TO STOP. THE TRASMISSION LIGHT CAME ON AND I HAD THE CAR CHECKED AT A NEARBY AUTOZONE TO SEE IF SAFE TO DRIVE. THEY COULD NOT DUPLICATE PROBLEM BUT AFTER STOPPED AND RESTARTING CAR, IT DID NOT HAPPEN AGAIN AND TRANSMISSION LIGHT WENT OUT. 63,000 MILES ON THE VEHICLE...I HAD MY 3 CHILDREN, ALL UNDER 5 YRS OLD WITH ME...DEFINITELY A SERIOUS SAFETY ISSUE. *LN

IN VERY NORMAL, IF NOT GENTLE USE THE INTERIOR DOOR HANDLES ON OUR 2006 FORD FUSION ALL BROKE IN THE LATTER PART OF 2010, WITH THE EXCEPTION OF THE DRIVERS SIDE REAR DOOR. THE CAR HAS APPROX. 68,000 MILES ON IT AND IS A KNOWN DEFECTIVE PART THAT HAS BROKEN IN THOUSANDS OF THESE CARS AS CAN BE RESEARCHED. THE ONLY WAY ONE CAN EXIT THE VEHICLE IS TO LEAVE THE CAR RUNNING AND OPEN THE WINDOW WHILE REACHING OUTSIDE TO USE THE OUTER DOOR HANDLE, THEN OPEN THE DOOR AND ROLL THE WINDOW BACK UP AND THEN SHUT OFF THE CAR. THIS PRESENTS A SERIOUS SAFETY HAZARD WHEN THE OCCUPANTS MIGHT HAVE TO EXIT THE VEHICLE QUICKLY TO AVOID IMMINENT DANGER. AFTER PAYING CLOSE TO $6,000 FOR EXTENDED WARRANTIES, THE DEALERSHIP REFUSED TO OFFER REPLACEMENT OF ANY SORT, STATING THAT THERE HAD BEEN NO SAFETY RECALLS ON THIS ISSUE. I HAVE NEVER BEEN UNABLE TO EXIT A CAR NORMALLY AND THIS TRULY COULD BE A DEADLY ISSUE THAT THE MANUFACTURER SHOULD CONSIDER THE RAMIFICATIONS OF TURNING A BLIND EYE TO. *TR

MILLAGE AND DATE ARE APPROXIMATE BUT VERY CLOSE. THE DRIVERS DOOR INSIDE DOOR HANDLE BROKE, THIS FAILURE MADE IT IMPOSSIBLE TO OPEN THE CAR DOOR FROM THE INSIDE. I HAVE PICTURES DOCUMENTING THE FAILURE WHICH SHOW THE LOCATION OF THE FAILURE. THIS COULD BECOME VERY DANGEROUS IF THE HANDLE BROKE IN A SITUATION WHERE AN EMERGENCY EXIT WAS NEEDED. I HAVE CALLED FORD AND REGISTERED A COMPLAINT WITH THEM ABOUT THIS, I HAVE ALSO DONE SOME RESEARCH ONLINE AND FROM TALKING TO MY LOCAL DEALER I HAVE FOUND THAT THIS IS AN ENTIRELY ALL TO COMMON OCCURRENCE. I AM JUST NOW GETTING AROUND TO FIXING THIS BECAUSE THE DOOR LATCH HAS NOW STOPPED WORKING (2/13/2011, ~38.000MI), I AM ASSUMING THE FAILURE OF THE DOOR LATCH IS A DIRECT RESULT OF THE BROKEN INTERIOR HANDLE AND LETTING IT GO WITHOUT BEING REPAIRED.

2006 FORD FUSION. CONSUMER STATES THAT THE TRANSMISSION IS NOT SHIFTING CORRECTLY. MECHANIC INFORMED THE CONSUMER THAT THERE WERE TSB'S OUT FOR THIS ISSUE. *KB THE CONSUMER STATED AFTER PAYING $3,408.45 FOR THE REPLACEMENT TRANSMISSION, A FEW WEEKS LATER SHE STARTED HAVING THE SAME PROBLEM AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THEY CONCLUDED A DEFECTIVE VALVE BODY WAS INSTALLED IN THE VEHICLE DURING A PREVIOUS VISIT. *JB

INTERIOR DOOR HANDLES BREAK OR CRACK. WHEN ATTEMPTING TO OPEN DOOR HANDLE BROKE, PREVENTING MY WIFE FROM BEING ABLE TO EXIT THE VEHICLE WITHOUT LOWERING THE WINDOW. IF SHE WAS IN AN ACCIDENT SHE MAY NOT BE ABLE TO EXIT THE VEHICLE. PASSENGER SIDE DOOR APPEARS CRACKED AND IS VERY LIKELY TO BREAK. PAID TO REPAIR OUT OF POCKET. *TR

2006 FORD FUSION S 2.3 L WITH 5SP AUTOMATIC TRANSMISSION... WITH LESS THAN 20,000 MILES I BROUGHT MY CAR TO A FORD DEALER AND WAS TOLD NOTHING WAS WRONG WITH THE TRANSMISSION... NOW I KNOW IT SOUNDS HUGE, BUT 3 YEARS LATER HARD SHIFTING AND SOMETIMES REFUSING TO SHIFT FOR A CAR WITH AN MSRP OF 19800 AND 100000 MORE MILES OF EXTREMELY IRRITATING SHIFTING (CLUNKING) I AM UP A CREEK WITHOUT A PADDLE FOR A KNOWN FAULTY TRANSMISSION. SO EITHER I PAY ON THIS CAR FOR NEARLY 2 MORE YEARS FOR A YARD ORNAMENT OR PAY OUT 4000 TO FIX IT. THIS IS A KNOWN AND QUITE COMMON PROBLEM. I WAS TOLD IT WAS NORMAL AND NOTHING WAS WRONG... REALLY? I HAVE HAD 10 YR OLD CARS WITH 200,000 MILES THAT SHIFTED BETTER THAN THIS CAR DID AFTER 15000 MILES. RIDICULOUS....... FORD KNOWS OF THIS PROBLEM AND HAS REFUSED SERVICE AND REPLACEMENT DUE TO COST. THEY KNEW OF THIS PROBLEM 4 YEARS AGO AND STILL THOUSANDS ARE PAYING THOUSANDS OF DOLLARS TO REPAIR A FAULTY TRANSMISSION. *TR

WHILE DRIVING MY 2006 FORD FUSION SE V6 WITH 6 SPEED TRANSMISSION, THE TRANSMISSION STARTED SLIPPING AT 40MPH IN A SNOW STORM AND I ALMOST LOST CONTROL OF MY VEHICLE FROM THE LOSS IN POWER. IT NOW RANDOMLY SLIPS OUT OF GEAR AT ALL SPEEDS AND DOWNSHIFTS HARD LURCHING THE CAR OUT OF THE LANE. *TR

WHEN ACCELERATING, MERGING INTO TRAFFIC, THE TRANSMISSION POPS OUT OF GEAR AND THE ENGINE WILL CONTINUE TO ACCELERATE WHILE THE CAR COASTS, AND SLOWS. THE TRANSMISSION WILL EVENTUALLY ENGAGE A LOWER GEAR WHEN IT HAS SLOWED DOWN, BUT ONLY IF YOU ARE PATIENT AND IGNORE THE URGE TO ACCELERATE AS TRAFFIC BEARS DOWN ON YOU FROM BEHIND. THIS IS TERRIBLY FRIGHTENING AND DANGEROUS AS THE VEHICLES WHICH REQUIRE THE MOST ROOM TO STOP, USUALLY TRAVEL IN THE SAME LANE ONE IS MERGING ON TO. THIS OCCURS NOT ONLY ON FREEWAY ENTRANCES, BUT ON LONG UPHILLS AND ANYTIME ONE LETS OFF THE THROTTLE AND THEN TRIES TO ACCELERATE AGAIN QUICKLY. A DIAGNOSTIC FROM AN AUTO REPAIR SHOP REVEALS NOTHING. I HAVE CONTACTED ABOUT 30 OTHER SAME MODEL CAR OWNERS WHO DESCRIBE THE SAME PROBLEM. THE FORTUNATE FEW WHO HAVE BEEN ABLE TO GET TO THE ROOT OF THE PROBLEM HAVE SAID THAT THE DEFECT IS IN THE "VALVE BODY". MOST HAVE THIS PROBLEM AFTER THE 50,000 MILE MARK. MANY, LIKE MYSELF, HAVE HAD THIS PROBLEM FOR A LONG TIME. IT IS A MATTER OF TIME BEFORE ONE OF US GETS REAR ENDED AND CRASH, OR WORSE! *TR

DOOR HANDLES BROKEN ON DRIVERSIDE, PROBLEMS WITH LATCHES LOCKS LINKAGE, MUST ROLL DOWN WINDOWS TO OPEN BOTH DOORS,THAT IS THE ONLY WAY TO GET OUT OR THIS CAR. TO REPAIR DOORS ON DRIVER SIDE COST $460.00 MILES ON VEH IS 32,600 2006 FORD FUSION I ORDER THIS CAR 2006. *TR

MY 2006 FORD FUSION TRANSMISSION STARTED SLIPPING AT 34,000 MILES. DEALER SAID THERE WAS NOTHING THEY COULD DO SINCE MY CAR WAS MADE IN THE FIRST PART OF 2006, NO ADDITIONAL WARRANTIES WERE AVAILABLE. I BOUGHT THE CAR UNDER THE ASSUMPTION THAT THERE WAS A WARRANTY STILL AVAILABLE. NOW MY TRANSMISSION IS GOING OUT, I STILL OWE 11,000 ON MY CAR. AFTER TALKING TO ALOT OF FUSION PEOPLE, THIS APPEARS TO BE A VERY VERY COMMON PROBLEM. IT'S ALSO VERY DANGEROUS, THE CAR SLIPS OUT OF GEAR REVS UP AND THEN POPS BACK INTO GEAR JUST AS YOU ARE TRYING TO GET INTO A LANE. VERY DANGEROUS, I HAVE ALMOST WRECKED SEVERAL TIMES AND HAD TO PULL OVER. *TR

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE KEYS WOULD NOT RELEASE FROM THE IGNITION UNLESS THE BUTTON ON THE GEAR SHIFT WAS PUSHED IN TO RELEASE THE KEY. THE CONTACT HAD TO REMOVE A PIECE OF PLASTIC IN ORDER TO REMOVE THE KEY FROM THE IGNITION SWITCH. THE CONTACT NOTICED NUMEROUS COMPLAINTS REGARDING THE FAILURE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 34,000.

2006 FORD FUSION FAILING TO SHIFT DURING ACCELERATION, SHIFTING SUDDENLY AND VIOLENTLY, FAILING TO DOWNSHIFT AND RUNNING EXTREMELY HIGH RPM CREATING VERY DANGEROUS CONDITIONS WHEN PASSING, MERGING AND SLOWING. DEALER FAILED TO RESOLVE THE ISSUE DURING 3 SEPARATE REPAIR VISITS 2008 TO 2009. SEVERAL ATTEMPTS TO REPROGRAM TCM & PCM WERE UNSUCCESSFUL. PCM REPLACED IN 2009 BUT HAS NOT RESOLVED THE ISSUE. RESEARCH INDICATES THAT FORD IS AWARE OF DEFECTIVE TRANSMISSION VALVE BODY CAUSING THE ISSUE BUT HAS NOT DONE A RECALL. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT WAS DRIVING APPROXIMATELY 38 MPH WHEN SHE HEARD A NOISE COMING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE MECHANIC ADVISED HER THAT THE SUB FRAME WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. SHE THEN CALLED THE MANUFACTURER AND WAS ADVISED THAT THE SUB FRAME WAS NOT A WARRANTY ISSUE AND WOULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 51,000 AND THE CURRENT MILEAGE WAS 53,027.

TRANSMISSION WOULD SHIFT OUT OF A GEAR, CAR WOULD REV UP TO HIGH, THEN TRANSMISSION WOULD SHIFT VIOLENTLY BACK IN JERKING THE CAR AROUND FEELING LIKE YOU HAVE BEEN REAR ENDED. THE TRANSMISSION WILL SLAM SO HARD INTO GEAR WHEN TRYING TO ACCELERATE( I HAVE HAD THIS EXPERIENCE ACCELERATING AT 45MPH AND AT 65MPH) ENGINE LIGHT COMES ON STAYS ON FOR A FEW DAYS GOES OFF PROBLEM COMES BACK A FEW DAYS LATER. ONLY SOLUTION WHEN THIS HAPPENS IS TO PULL OVER AND SHUT THE CAR OFF. ONCE CAR IS TURNED BACK ON THE GEAR SHIFTER (AUTOMATIC) IS VERY TIGHT TO PUT IN REVERSE OR DRIVE. *TR

I OWN A 2006 FORD FUSION SE WITH THE 3.0 V6 ENGINE. AT JUST OVER 55,000 MILES, VEHICLE WOULD COME OUT OF GEAR WHILE SHIFTING BETWEEN 30-60MPH, ROUGHLY 2ND-3RD, OR 3RD-4TH GEAR. VEHICLE WOULD GO INTO A HIGH REV AND NOT MOVE. AFTER LETTING OFF GAS, YOU HAVE TO WAIT 5 SECONDS FOR IT TO "RE-ENGAGE", THEN SOMETIMES IN A HIGH GEAR AT LOW SPEEDS CAUSING VEHICLE TO SHAKE VIOLENTLY. THIS IS A VERY SERIOUS AND DANGEROUS MECHANICAL FLAW WITH THIS TRANSMISSION! IT IS THE AISIN TRANSMISSION USED IN A VARIETY OF FORD, LINCOLN, AND MERCURY VEHICLES. (2005-2006 FORD FIVE HUNDRED, 2006 FORD FUSION, 2006 MERCURY ZEPHYR, 2006 MERCURY MILAN, 2005-2006 MERCURY MONTEGO) THERE ARE 100'S TO 1000'S OF COMPLAINTS ON THESE AND MULTIPLE TSB (TECHNICAL SERVICE BULLETINS) THROUGH FORD MOTOR COMPANY, ETC. (TSB 07-26-9, TSB 08-24-1) CALLING IT AISIN TRANSMISSION HARSH SHIFTING. HARSH BEING AN EASY TERM TO DESCRIBE THIS PROBLEM. AND STILL NO RECALL ON THIS OR COMPENSATION FROM DEALER OR MANUFACTURER. IF YOUR VEHICLE IS OUT OF WARRANTY, YOU ARE ON YOUR OWN WITH THIS $1,500 PLUS REPAIR ON A DEFECTIVE VALVE BODY ACCORDING TO FORD MOTOR CO. THIS IS A TREMENDOUS SAFETY ISSUE ESPECIALLY WHEN NEEDING TO MERGE OR ACCELERATE RAPIDLY TO GET ONTO A FREEWAY SYSTEM OR OVERTAKE AND PASS ON THE HIGHWAY! I GUESS IT WILL TAKE A SERIOUS INJURY OR FATALITY TO CAUSE A LAW SUIT FOR ANYTHING TO BE DONE EXCEPT A TSB! WITH ALL THE DOCUMENTATION AND COMPLAINTS I HAVE SEEN ON THESE, I HOPE THE MANUFACTURERS HAVE A STRONG LEGAL TEAM!

TL*THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING APPROXIMATELY BETWEEN 15-30 MPH, THE CONTACT STATED THAT THE TRANSMISSION SLIPPED IN AND OUT OF GEAR CONTINUOUSLY. IN ADDITION, THE VEHICLE WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 01/11/2011*LJ

TRANSMISSION SLIPS IN AND OUT OF GEAR WHILE DRIVING AT ANY SPEED. THESE ARE VERY HARD GEAR SHIFTS AND THE ENTIRE CAR SHAKES. SOMETIMES IT WON'T GO INTO ANY GEAR AT ALL, INCLUDING REVERSE. THE CAR HAS UNUSUALLY HIGH RPM DURING SOME GEAR SHIFTS...PARTICULARLY WHEN SHIFTING GETS "STUCK" BETWEEN 4TH & 5TH GEARS. MY CAR WAS STUCK IN THE MIDDLE OF AN INTERSECTION BECAUSE THE TRANSMISSION FROZE AND WOULDN'T SHIFT GEARS. THE CAR CANNOT ACCELERATE AT A NORMAL SPEED ANYMORE WHICH DOESN'T ALLOW FOR NORMAL HIGHWAY DRIVING, AND IS DANGEROUS DUE TO THE FACT THAT THE TRANSMISSION IS SLIPPING GEARS OR STICKING IN A GEAR. *TR

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE DOOR LATCHES SEPARATED FROM THE HINGES INSIDE THE VEHICLE AT LEAST THREE TIMES. THE DEALER REPLACED THE HANDLES UNDER WARRANTY BUT THEY HAD BROKEN AGAIN. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MILEAGE WAS 72,400.

WHEN DRIVING ON THE INTERSTATE UNDER CRUISE CONTROL, THE ENGINE SUDDENLY DROPPED TO IDLE AND WOULD NOT RESPOND TO THE THROTTLE. FORTUNATELY I WAS ABLE TO COAST TO THE SIDE OF THE ROAD WITHOUT BEING HIT FROM BEHIND. THE CAR SHOWED TWO WARNING LIGHTS: TRACTION CONTROL AND THROTTLE CONTROL. THE CAR WOULD STILL NOT RESPOND TO THE THROTTLE. AFTER TURNING OFF THE CAR AND RESTARTING IT, THE LIGHTS WENT OUT AND THE CAR WAS DRIVABLE AGAIN. I TOOK THE CAR TO THE DEALER, WHO CLEANED THE THROTTLE BODY, FLUSHED THE FUEL INJECTORS AND REPROGRAMMED THE PCM. WHATEVER ACTUALLY HAPPENED, THE FAIL SAFE CONDITION SHOULD NOT BE TO SHUT THE ENGINE DOWN TO IDLE WITHOUT THE ABILITY TO CONTROL THE ENGINE SPEED. IT WAS JUST FORTUNATE THAT THE CAR WAS NOT HIT FROM BEHIND. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND ATTEMPTING A RIGHT TURN WHEN THE TRANSMISSION EXHIBITED A HESITATION AND BEGAN JERKING ABNORMALLY. THE RPM GAUGE DISPLAYED AN EXTREMELY LOW READING. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. AFTER WAITING A FEW MOMENTS, THE VEHICLE RESUMED AT A LOW SPEED WITHOUT EXPERIENCING THE PREVIOUS FAILURES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE COMPLETE BRAKE SYSTEM WAS REPLACED. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE FAILURE WAS RELATED TO THE TRANSMISSION AND THE TECHNICIAN DETECTED THE THAT THE GEARS WERE STICKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TRANSMISSION SHOP FOR A SECOND OPINION WHERE THEY STATED THE SAME DIAGNOSIS AS MENTIONED BY THE DEALER. THE CONTACT WAS WAITING UPON A RESPONSE FROM THE MANUFACTURER REGARDING THE TRANSMISSION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.

I OWN A 2006 FORD FUSION, WHEN DRIVING ON THE HIGHWAY WHILE TRYING TO PASS ANOTHER VEHICLE, THE CAR WILL DROP OUT OF GEAR. THE CAR WILL NOT REENGAGE UNTIL THE TACHOMETER RETURNS TO AN IDLE. EVEN THEN THE CAR MAY NOT ENGAGE THE GEAR AGAIN. WITH ONCOMING TRAFFIC OR OTHER CARS BEHIND THIS CAUSES AN UNSAFE CONDITION. *TR

ON THE INTERSTATE AND GAVE CAR THE GAS TO GO AROUND A TRUCK AND THE CAR REVVED THE ENGINE AND THE TACHOMETER WENT ALL THE WAY DOWN. LET OFF THE GAS AND THE CAR WAS STUCK IN HIGH GEAR AND WOULD NOT SHIFT TO A LOWER GEAR. HAD TO DRIVE THE CAR THAT WAY IN STOP AND GO TRAFFIC IN ABLE TO PULL OFF THE ROAD. ONCE THE CAR WAS TURNED OFF AND RESTARTED IT RESET ITSELF AND HAD LOWER AND UPPER GEARS IN TRANSMISSION. THE CAR STILL JERKS AND DOESN'T WANT TO GO INTO DIFFERENT GEARS WHEN DRIVING. TOOK CAR TO DEALER SHOP AND WAS TOLD THAT IT HAD A TSB BULLETIN ABOUT THE TRANSMISSION VALVE BODY. THERE IS A PROBLEM WITH THIS AND THEY WOULD NOT ADMIT TO A PROBLEM WITH THE TRANSMISSION. SEARCHING THE INTERNET I AM NOT THE ONLY ONE WITH THIS PROBLEM (100'S OF PEOPLE). *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHEN TRAVELING AT ANY SPEED AND DOWNSHIFTING, THE VEHICLE WOULD BEGIN TO SHAKE AND VIBRATE VIOLENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE. THE CURRENT MILEAGE WAS 41,000 AND THE FAILURE MILEAGE WAS 38,000.

2006 FORD FUSION, WITH 65000 MILES, TRANSMISSION GETTING STUCK BETWEEN SECOND AND THIRD GEAR. WHEN THE TRANSMISSION IS STUCK, THE CAR WILL REV TO 5-6K RPMS AND DROP SEVERELY IN SPEED. WHEN MOVING FROM A STOP POSITION THE CARE THEN TAKES ABOUT 40-60 SECONDS TO GET UP TO 25MPH (BECAUSE IT IS STILL IN SECOND OR THIRD GEAR). THIS OCCURRED WITH ME ENTERING AN ON RAMP TO A FREEWAY AND DRIVING FROM A STOP LIGHT IN A BUSY BUSINESS DISTRICT. I TOOK THE CAR INTO THE DEALERSHIP WHERE THE CAR WAS PURCHASED AND SERVICED SINCE PURCHASE 12/31/2005. AFTER THE FIRST DAY IN THE SHOP THE DEALER TOLD ME THE TRANSMISSION IS BEYOND REPAIR AND I NEED A NEW (REBUILT) FORD TRANSMISSION. THEY WANTED $80 FREIGHT FOR DELIVERY OF TRANSMISSION AND APPROX. $4500 FRO THE TRANSMISSION AND INSTALLATION. WHEN I BOUGHT OUT MY LEASE LAST YEAR I PURCHASED AN EXTENDED WARRANTY ON MY CAR (THE ORIGINAL ENDED AT 36000 MILES). IT HAS NOW BEEN FIVE DAYS WITH MANY PHONE CALLS, A RENTAL CAR (ONLY COVERED FIVE DAYS UNDER MY WARRANTY), AND A VISIT FROM A PRIVATE INSPECTOR/ADJUSTER. THE WARRANTY COMPANY IS STILL "REVIEW THE CLAIM" AND HAS NOT YET AUTHORIZED THE REPAIR. WITHOUT AUTHORIZATION FROM THE WARRANTY CO I CAN NOT BEGIN REPAIRS. IT WILL TAKE 2-3 DAYS TO GET THE TRANSMISSION SHIPPED AND 2-3 DAYS FOR THE REPAIR. I BELIEVE FORD SHOULD BE RESPONSIBLE AND RECALL THE TRANSMISSIONS. NOT ALL OWNERS HAVE THE EXTENDED WARRANTY LIKE I DO. THE FAILING TRANSMISSIONS ARE A HUGE SAFETY DEFECT AND COULD LEAD TO EXPENSIVE REPAIRS, AC

MY 2006 FORD FUSION SEL V6 STARTED VIOLENT JERKING WHILE DRIVING. I AM AFRAID TO DRIVE IT BECAUSE I HAVE ALMOST REAR ENDED ANOTHER CAR WHEN ACCELERATING AND THE JERKING HAPPENED. MY HUSBAND THINKS IT IS THE TRANSMISSION BUT IT IS OUT OF WARRANTY AND WE DON'T HAVE THE MONEY TO REPAIR IT. IT SEEMS LIKE THERE ARE MANY OTHER OWNERS OUT THERE (DUE TO THE MASS FORUMS AND THE TSB'S) THAT ARE EXPERIENCING THE SAME PROBLEM. FORD IS DOING NOTHING ABOUT IT EVEN THOUGH THERE ARE PLENTY OF DOCUMENTATIONS THAT IT IS AN ONGOING SITUATION. IT OCCURS EVERYTIME THE VEHICLE IS DRIVEN. I DON'T FEEL SELLING IT TO SOMEONE ELSE IS THE ETHICAL SOLUTION. FOR SHOULD BACK/STAND BEHIND THERE PRODUCT. NOT RUN FROM THE PROBLEM. PEOPLE COULD BE SERIOUSLY HURT, IN FACT, I WOULDN'T BE SURPRISED IF THERE AREN'T REPORTED INJURIES. *TR

06 FORD FUSION TRANSMISSION SLIPS OUT OF GEAR AROUND 25-35 MPH. THIS HAPPENED ON THE HIGHWAY RESULTING IN 4 CARS ALMOST HITTING US & ALMOST CAUSING 2 OTHER ACCIDENTS. IT HAS BEEN GETTING PROGRESSIVELY WORSE FOR A MONTH NOW. IT'S @ THE DEALERSHIP NOW ,THEY SAID THERE IS NOTHING WRONG WITH IT @ 1ST,NOW THEY SAY THEY HAVE DUPLICATED THE PROBLEM & I NEED A NEW TRANSMISSION $4700. THE CAR HAS 54K MILES ON IT. I HAVE READ NUMEROUS OTHER COMPLAINTS ONLINE @REPAIRPAL.COM. SOMETHING NEEDS TO BE DONE,THIS IS A VERY HAZARDOUS PROBLEM. *TR

2006 FORD FUSION REAR PASSENGER INTERIOR DOOR HANDLE BROKE WHEN EXITING THE CAR. IT LOOKS LIKE THE CHROME PLATING ON THE INTERIOR DRIVERS DOOR IS BEGINNING TO CRACK. *TR

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT A PLASTIC PIECE OVER THE BUTTON ON THE GEAR SHIFT BROKE INSIDE THE SHIFTER. THE BROKEN PIECE CAUSED THE VEHICLE NOT TO ACKNOWLEDGE THAT THE VEHICLE WAS IS IN PARK AND CAUSED THE KEY TO BECOME STUCK IN THE IGNITION. THE DEALER STATED THAT THE ENTIRE GEAR SHIFT NEEDED TO BE REPLACED. THE CONTACT WAS CONCERNED ABOUT NUMEROUS COMPLAINTS REGARDING THE GEAR SHIFT AND THE KEY FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE CONTACT STATED THAT THIS WAS A SAFETY CONCERN SINCE IT MAY BE DIFFICULT TO DETECT THAT THE BROKEN PIECES WERE DAMAGING THE GEAR SHIFT. THE FAILURE MILEAGE WAS 40,000. UPDATED 11/05/10. *LJ

AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR DURING ACCELERATION. WHEN DOWNSHIFTING IT SLIPS AND SOMETIMES SLAMS ITSELF INTO GEAR. STARTING FROM A STOP SOMETIMES THE TRANSMISSION DOESN'T SEEM TO KNOW WHICH GEAR TO START IN AND SLAMS INTO 1ST. THE MOST FREQUENT PROBLEM IS THAT OF THE TRANSMISSION DROPPING OUT OF GEAR UPON ACCELERATION OR TRYING TO TOP A GRADE. IF YOU ARE NOT CAREFUL THE RPMS WILL REACH 5000+ RPMS. THIS ISSUE BEGAN AROUND 50K MILES. FORD DEALERSHIP IN STERLING HEIGHTS MICHIGAN CHECKED THE TRANSMISSION IN APPROX MAY OF 2008 AND THEY ONLY OFFERED A COMPLETE TRANSMISSION REPLACEMENT AT A COST OF 4K+, THEY COULD NOT DETERMINE WHAT THE PROBLEM WAS. *TR

AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR WHEN GOING UP A HILL OR WHEN PASSING ANOTHER VEHICLE. THE CAR MAKE A ROUGH NOISE AND YOU HAVE TO BRAKE IN ORDER TO GET THE CAR TO CHANGE GEARS. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH THE CAR APPROACHED A SMALL HILL AND THE GEAR WOULD NOT CHANGE AND MADE A AWFUL NOISE. I TOOK THE CAR TO A FORD DEALERSHIP FOR DIAGNOSTIC CHECK AND IT REVEALED THAT I NEED A TRANSMISSION. THE COST WAS QUOTED AT 4900.00. THIS STARTED APPROX 2 MONTHS AGO AND IS STILL HAPPENING. *TR

I HAVE A 2006 FORD FUSION AND EVERY SINGLE DOOR HANDLE IS BROKEN AND NO LONGER WORKS PROPERLY. I HAVE CONTACTED THE FORD DEALER TO HAVE THEM REPLACED WITH NO RESPONSE. THEY ARE MADE OF PLASTIC AND COVER WITH CHROME TAPE. *TR

TRANSMISSION FAILS TO RESPOND MOSTLY DURING SHIFTS IN THE RANGE FROM 2ND TO 5TH GEAR. THE CAR FAILS TO ACCELERATE, TRANSMISSION/ENGINE WINDS AND BECOME USELESS UNTIL YOU LET THE CAR RETURN TO FIRST GEAR. THIS DOESN'T ALLOW FOR PROPER PASSING MANEUVERS. THE TRANSMISSION ALSO CLANKS WHEN DOWNSHIFTING. *TR

PURCHASED 2006 FORD FUSION SEL 6 CYL., WITH ROUGHLY 48K ON IT AND CURRENTLY HAVE 62K ON IT NOW, IN/AROUND OCTOBER OF 2009, AND ABOUT 3 MONTHS AGO STARTING HAVING TRANSMISSION PROBLEMS. UPON ACCELERATING BETWEEN 25-40, THE TRANSMISSION JUMPS IN AND OUT OF GEAR, OFTEN MAKING A LOUD BANGING NOISE AND TAKING AWAY ALL ACCELERATION. IN ORDER FOR IT TO GET BACK INTO GEAR, YOU HAVE TO COMPLETELY LET OF THE GAS AND IT WILL EVENTUALLY GO BACK INTO GEAR. THIS ALLOWS FOR MINIMAL ACCELERATOR AT BEST WHEN TRYING TO SPEED UP. THIS FAILURE OCCURS RANDOMLY EVERYTIME I DRIVE THE VEHICLE. IF NOT FIXED, THE TRANSMISSION IN MY CAR WILL EVENTUALLY GO BAD. I TOOK IT IN TO ADVANCED AUTOMOTIVE IN ANN ARBOR TO HAVE IT FIXED. THEY TOLD ME, AFTER DOING EXTENSIVE RESEARCH DUE TO NO CODES SHOWING UP ON THE COMPUTER, THAT ON THE FORD BULLETIN IT WAS GOING TO NEED A NEW VALVE BODY, TRANSMISSION FLUSH, AND REPROGRAMMING. THIS IS GOING TO COST ROUGHLY $2200. THE VALVE BODY, FROM FORD, WAS $1400. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THE AIR CONDITIONING UNIT FAILED. THE DEALER DIAGNOSED THE VEHICLE AND DETERMINED THAT THE A/C WAS NOT RECEIVING A CONNECTION FROM THE PANEL BOX. THE FAILURE MILEAGE WAS 78,000.

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THEY WERE UNABLE TO REMOVE THE KEY OUT OF THE IGNITION. THE RING AROUND DRIVE SHIFT WAS BROKEN AND GAVE THE APPEARANCE THAT THE VEHICLE WAS IN PARK WHEN IT WASN'T WHICH ALSO MADE IT IMPOSSIBLE TO REMOVE THE KEY FROM THE IGNITION. WHEN THE BROKEN RING WAS REMOVED, THE CONTACT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION; HOWEVER, THE TRANSMISSION CONTINUED TO MALFUNCTION. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 50000.

2006 FORD FUSION - NORMAL DRIVING UNTIL I HIT 59,500 MILES. TRANSMISSION WOULD SLIP AFTER REACHING APPROXIMATELY 40 MPH AND THE EMISSIONS LIGHT WOULD TURN ON. IT WAS TAKEN TO THE DEALER ON 5/14/10, AND I WAS TOLD IT WAS THE TRANSMISSION WHICH WAS COVERED UNDER THE EXTENDED WARRANTY. AFTER TRANSMISSION WAS REPAIRED, THE CAR WAS PUT ON DIAGNOSTICS AND NOW THE POWER MODULE NEEDED TO BE REPLACED. THE CAR WAS BROUGHT IN ON 5/14/2010 AND IT IS 7/28/10 AND I STILL HAVE NOT RECEIVED THE CAR. THEY ARE WAITING FOR THE PART WHICH THEY SAY WAS RECEIVED TODAY. AND BECAUSE I BROUGHT MY CAR IN FIRST, I GET THE PART FIRST. THERE IS ANOTHER 06 FUSION WITH THE SAME ISSUE, WAITING FOR THE SAME PART. WAS THE PART ON BACK ORDER FOR SO LONG BECAUSE FORD NEEDED TO REPLACE SO MANY OF THEM? MY GUESS IS YES. I WAS TOLD THE PART WOULD BE IN JULY 15 AND IT WAS JUST RECEIVED TODAY (7/28/10). *TR

I AM UNABLE TO REMOVE MY KEY FROM MY IGNITION UNLESS I REMOVE A PIECE OF THE SHIFTER ON MY TRANSMISSION. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE INTERIOR FRONT AND REAR DRIVER SIDE DOOR HANDLES HAD FRACTURED. IN ORDER FOR PASSENGERS TO EXIT THE VEHICLE, THE WINDOW WOULD HAVE TO BE OPENED AND THE CONTACT OR PASSENGER WOULD HAVE TO PUT THEIR ARM THROUGH THE WINDOW AND OPEN THE DOOR USING THE EXTERIOR DOOR HANDLE. THE MANUFACTURER AND AUTHORIZED DEALER WERE NOTIFIED WHICH THEY INFORMED THAT THERE WAS NOT A SAFETY RELATED RECALL AND WERE UNABLE TO PROVIDE FURTHER ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT HAD SIGNIFICANT CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 68,000.

EVENTS LEADING: NORMAL DRIVING OPERATION. FAILURE:TRANSMISSION SLIPS AFTER REACHING 35 MPH+, OCCURS ANYTIME I AM ON THE HIGHWAY GOING UPHILL OR TRYING TO PASS. HAVE SEEN MANY FORUMS WITH OTHERS THAT ARE HAVING SIMILAR ISSUES. CAUSES MY CAR TO SLIP OUT OF GEAR UNTIL I LET OFF THE ACCELERATOR OR CAUSES A VERY HARD SHIFT CAUSING THE TRANSMISSION TO BANG REALLY LOUD. WHAT HAS BEEN DONE TO FIX: NOTHING CURRENTLY, HAVE ONLY DONE RESEARCH INTO THE ISSUE AND FOUND MANY FORUMS WITH INDIVIDUALS THAT HAVE SIMILAR ISSUES AND HAVE HAD THEIR VEHICLES IN TO THE DEALER ONLY TO HAVE THEIR CAR WORKED ON AND STILL HAVE PROBLEMS. *TR

MY 2006 FORD FUSION 3.0L V-6 IS EXPERIENCING SEVERE PROBLEMS WITH THE TRANSMISSION. THIS ALL STARTED AT 55,000MI. IT WILL SLIP OUT OF GEAR AT ACCELERATION AND CLUNKS AND THUDS WHEN IT IS DOWNSHIFTING. THIS IS AN EXTREME SAFETY HAZARD, ESPECIALLY IF YOU DECIDE TO TURN QUICKLY IF FRONT OF ON COMING TRAFFIC. THE TRANS JUST MAY NOT CATCH. FORD ENGINEERS KNOW WHAT THE PROBLEM IS. IT IS THE TRANSMISSION WHICH FORD PURCHASED FROM "AISEN" IN GERMANY. THEY HAVE A DEFECTIVE CONTROL BODY WHICH HAS EXTREME SPOOL BORE WEAR. SOMEONE BETTER REQUIRE FORD TO FIX THIS ISSUE BEFORE SOMEONE GETS HURT.... I HAVE MANY CLOSE CALLS SINCE I OWNED THIS CAR. THE DEALER WANTS TO CHARGE ME 5000.00 TO FIX THEIR ISSUE. WHY IS FORD SO HUSH HUSH? *TR

THE PUSH BUTTON ON THE GEAR SHIFT WILL NOT FULLY COME OUT, THUS ALLOWING SHIFTING WITHOUT THE NEED TO DEPRESS THE BUTTON. THIS ISSUE HAS ALSO RESULTING IN NOT BEING ABLE TO REMOVE THE KEY. SINCE THE LOCKING/UNLOCKING REMOTE IS INTEGRATED INTO THE KEY ITSELF, I CANNOT LOCK THE CAR WITHOUT THE SECOND KEY. NOT ONLY IS LEAVING THE KEY IN THE IGNITION AKIN TO GIFT WRAPPING THE CAR FOR THIEVES, THE SHIFTING ISSUE IS ABSOLUTELY A SAFETY CONCERN! I SEARCHED THE PROBLEM AND IT APPEARS VERY COMMON, SO MUCH SO THAT A TSB HAS BEEN ISSUED. FORD NEEDS TO OWN UP TO THIS ISSUE. *TR

2006 FORD FUSION. CONSUMER STATES TRANSMISSION HAS SLIPPED *TGW THE CONSUMER SENT IN A TSB THAT WAS ISSUED REGARDING TRANSMISSION PROBLEMS ON CERTAIN VEHICLES.. *JB

HIGHWAY OR REGULAR ROAD DRIVING TRANSMISSION GIVES OUT. THE TRANSMISSION RED LINES AND THE CAR FAILS TO RESPOND MOSTLY ON SLIGHT TO MODERATE INCLINES. YOU MUST LET UP OFF THE GAS AND ALLOW THE RPMS TO DROP TO NORMAL AND ALLOW FOR THE CAR TO CHANGE GEARS. DEALERSHIP CLAIMS NO ISSUES BUT THEY DO HAVE A TSB ON THE PROBLEM BUT CLAIM THAT CUSTOMER NEEDS TO PAY $2500 TO FIX THE PROBLEM. *TR

I HAVE HAD MY 2006 FUSION FOR TWO YEARS. MY TRANSMISSION STARTED SLIPPING AROUND 60,000 MILES. AT FIRST IT ONLY SLIPPED WHEN I TRIED TO ACCELERATE QUICKLY, BUT OVER THE LAST FEW MONTHS IT HAS GOTTEN WORSE. I AM AFRAID TO DRIVE IT ON THE HIGHWAY BECAUSE WHEN IT SLIPS IT JUMPS OUT OF GEAR AND I CAN'T ACCELERATE AT ALL. I JUST PRAY THAT THE PERSON BEHIND ME CAN SLOW DOWN IN TIME NOT TO HIT ME AND MY CHILDREN. IT TAKES A FEW MILES FOR IT TO JUMP BACK INTO GEAR. I HAVE HAD TO PULL OVER ON THE SIDE OF THE ROAD TO WAIT FOR IT TO GET BACK INTO GEAR. I CANNOT AFFORD A NEW TRANSMISSION! THIS CAR REPLACED MY FORD ECONOLINE WHICH I DROVE FOR OVER 200,000 MILES BEFORE ITS TRANSMISSION WENT OUT. IF I WANTED TO BUY A TRANSMISSION I WOULD HAVE BOUGHT ONE FOR THE VEHICLE I WAS REPLACING. THIS IS THE ONLY CAR I HAVE TO GET MY KIDS AND MYSELF TO WORK AND TO SCHOOL. I CANNOT AFFORD EXPENSIVE REPAIRS ON A RELATIVELY NEW CAR; AND I SHOULDN'T HAVE TO. THESE CARS ARE DANGEROUS. *TR

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE KEY WAS STUCK IN THE IGNITION. HE HAD TO USE THE SPARE KEY TO LOCK AND UNLOCK THE DOORS. SINCE THE KEY WAS STUCK IN THE IGNITION HE LEFT IT THERE. EVENTUALLY THE CONTACT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE DEALER WAS CONTACTED AND STATED THAT THEY COULD REPLACE THE KEY FOR $180.00 AT THE OWNERS EXPENSE OR REPLACE THE ENTIRE SHIFT ASSEMBLY FOR APPROXIMATELY $500.00. THE DRIVERS SIDE DOOR HANDLE WAS ALSO DEFECTIVE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 92,000.

RIGHT FRONT SIDE TURN SIGNAL LIGHT FAILED INSPECTION REPLACED BULB AND ELECTRICAL HARNESS, STILL NO POWER. DIAGNOSED AS DEFECTIVE SMART BOX FORD ESTIMATES IT AT $800 TO REPLACE. *TR 4 YEAR OLD FORD FUSION (SUMMER 2006)