2006 Ford Five Hundred complaints

WHEN I AM DRIVING MY FORD 500 A WRENCH LIGHT COMES ON AT DIFFERENT TIMES AND LOCKS MY TRANSMISSION AND IT DECELERATES. I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME IT WAS THE THROTTLE BODY AND I HAD IT REPLACED, IT STILL SEEMS TO BE DOING IT. I HAS HAPPENED MANY TIMES SINCE THE FIRST INCIDENT. LOOKED IT UP AND MANY FORD 500S, FREESTYLES, AND MONTEGOS KEEP DOING THE SAME THING. SOMETHING NEEDS TO BE DONE BEFORE SOMEBODY GETS HURT. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE NOTICED THAT THE GEARS BECAME DIFFICULT TO SHIFT. IN ORDER TO GET THE GEARS TO SHIFT, THE CONTACT HAD TO GENTLY RELEASE THE ACCELERATOR PEDAL. NO WARNING LIGHTS ILLUMINATED TO INDICATE A FAILURE. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000. THE VIN WAS UNAVAILABLE.

2006 FORD FIVE HUNDRED, AT THE 86,000 MARK INSTRUMENT PANEL STARTED ACTING UP. ALL OR SOME OF THE WARNING LIGHTS (WRENCH, SEAT BELT, ENGINE, ETC.) WOULD ALL COME ON AND TURN OFF, AT DIFFERENT TIMES AND WEATHER CONDITIONS. WHEN THEY CAME ON THE RADIO SOUND WOULD LOWER TOO. THE SAFETY ISSUE IS ALL THE GAGES, EXCEPT THE AMOUNT OF GAS, WOULD GO TO ZERO AS WELL, MAKING IT IMPOSIBLE TO KNOW YOUR SPEED. CALLED AROUND AND FOUND IT WOULD COST $700 TO FIX. THIS SEEMS TO BE A FORD MANUFACTURE PROBLEM. I CONTACTED FORD AND WAS TOLD IN SO MANY WORDS THAT WAS MY PROBLEM SINCE THEY WERE NOT TOLD TO FIX IT BY NHTSA. *TR

I HAD A 2006 FORD FIVE HUNDRED AT FIRST I LOVED THAT CAR THEN THE BATTERY STARED GOING DEAD SO I REPLACED THE BATTERY BUT IT STILL DID IT SO I HAD IT LOOKED AT AND THEY TOLD ME THAT IT WAS THE ALTERNATOR GOING OUT SO I REPLACED THAT BUT COME TO FIND OUT AFTER 2 BATTERIES AND 3 ALTERNATORS IT WAS A WIRING PROBLEM AND FINALLY THE WIRING PROBLEM ENDED UP FRYING THE COM[UTER IN MY CAR AND IT WAS GOING TO COST ME A WHOLE LOT OF MONEY TO FIX IT AND I DIDN'T HAVE THAT TYPE OF MONEY IT WAS MORE MONEY THEN THE CAR WAS WORTH I HAVE TALKED TO SEVERAL PEOPLE WHO SAY THAT THEY HAVE HAD THE SAME PROBLEM SO A WORD TO THE WISE DO NOT BUY A FORD FIVE HUNDRED !!! *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ATTEMPTED TO INCREASE SPEED , BUT VEHICLE WOULD NOT ACCELERATE. THE CONTACT CONTINUED TO APPLY PRESSURE TO THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THE EGR VALVE, THE THROTTLE BODY AND THE MASS FLOW AIR SENSOR NEEDED TO BE REPLACED. THE TECHNICIAN STATED THAT HE COULD NOT GUARANTEE THAT THE FAILURE WOULD NOT OCCUR AGAIN AFTER THE REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

STARTING SINCE FEBRUARY 2010. MY CAR LUNGES FORWARD WHENEVER AT A DEAD STOP. WHEN SHIFTING TO DRIVE AND REVERSE. I HAVE HAD TO HAVE MY FOOT ON BRAKE AND EVEN ALMOST HAD AN ACCIDENT WHILE PARKING AND HIT THE WALL. WENT TO DEALERSHIP AND FIRST THEY SAID IT WAS MY ENGINE MOUNT THAT WAS CAUSING IT. THEN WENT AGAIN BECAUSE THE PROBLEM STILL OCCURRED AND THEY SAID I NEEDED A NEW BATTERY. THEN THEY CLAIMED IT WAS MY AIR FILTER WHICH IS A LIE. I CALLED THE FORD HEADQUARTERS AND ALL THEY CAN DO IS TAKE DOWN WHEN I CALLED AND WHAT IT WAS ABOUT. THEY ARE NO HELP WHAT SO EVER SO WHAT IS THE POINT OF THEM EVEN EXISTING IF THEY CANT HELP SOLVE THE PROBLEM. THEY CLAIM EACH DEALER IS INDEPENDENT AND THAT THEY CAN ADVISE THAT I GO TO A DIFFERENT DEALERSHIP. I HAVE WASTED A GOOD DEAL OF TIME AND MONEY. LUCKILY I WAS SMART AND BOUGHT THAT PREMIUM EXTENDED WARRANTY. I STILL HAVE SPENT CLOSE TO OVER $400 ON REPAIRS. EACH TIME I WENT I HAD TO PAY A DEDUCTIBLE OF $100.00. THE BATTERY I WENT TO SAMS CLUB TO GET BECAUSE THE DEALER WANTED $140 BUT I GOT MINE FOR $75. THEY ADVISED TO GET MY THROTTLE BODY CLEAN AND THAT WAS $95. THEY SAID I NEED TO HAVE MY TRANSMISSION FLUSHED WHICH IS ANOTHER LIE. I DIDN'T GET THAT DONE BECAUSE I ONLY HAVE 60,000 MILES ON THE VEHICLE. THE TRANSMISSION FLUID WAS AS RED AS CAN BE AND IS STILL GOOD FOR PROBABLY ANOTHER 40,000 MILES. THE POINT IS FORD KNOWS ABOUT THE PROBLEM AND THEY DO NOT WANT TO FIX THE PROBLEM IT APPARENTLY IS HAPPENING TO TONS OF FOLKS OUT THERE. THEY

CAR SURGES FORWARD/BACKWARD WHEN ENGAGED IN GEAR FROM DEAD STOP AND BRAKE IS RELEASED WITHOUT HAVING EVEN TOUCHED THE ACCELERATOR. SEEMS TO BE WORSE WHEN HEATING/COOLING FAN IS ON, ESPECIALLY ON RECIRCULATE, AND RPMS WILL SURGE/RACE AT DEAD STOP WITH BRAKE FIRMLY APPLIED WHEN THE STEERING WHEEL IS TURNED TO EITHER SIDE. PROBLEM IS ESPECIALLY NOTICEABLE IN PARKING LOTS OR ANYWHERE IN LOW SPEED STOP/GO DRIVING CONDITIONS. CONCERNED FOR PEDESTRIAN SAFETY AS I HAVE HAD THE CAR JUMP UNEXPECTEDLY AND NEARLY HIT THEM. CHECK ENGINE LIGHT CAME ON A COUPLE OF WEEKS AGO AND CAR WENT INTO LIMP HOME MODE INDICATING ERROR CODES P061B & P2016 WHICH MEANS THE THROTTLE BODY NEEDS TO BE REPLACED AFTER DRIVING IN DEEP SNOW, EXTREMELY COLD TEMPERATURE AFTER CAR HAD BEEN SITTING FOR 3 DAYS, THE CHECK ENGINE LIGHT HAS CLEARED BUT THE CAR CONTINUES TO HAVE THE SURGING ISSUES THOUGH IT DOES SEEM WORSE IN WARMER WEATHER THAN COLD. SO FAR I HAVE NOT REPLACED THE THROTTLE BODY THOUGH I INTEND TO AS SOON AS I CAN GET AHOLD OF THE PART. *TR

I HAVE A 2006 FORD FIVE HUNDRED AND THE PROBLEM IS WHEN I AM DRIVING AT A NORMAL SPEED AND HAVE TO SLOW DOWN AND THEN TAKE OFF THE CAR MAKE A STRONG BUCKING HIT, I TOOK IT TO THE DEALER TO HAVE IT CHECKED OUT AND THEY TOLD ME IT WAS A MOTOR MOUNT, THEY REPLACED THE MOUNT BUT THE CAR CONTINUED TO DO THE SAME THING, THE WARRANTY WAS JUST ABOUT TO RUN OUT WHEN I TOOK IT THE SECOND TIME AND THEY TOLD ME IT WAS THE THROTTLE BODY, WHEN THE CHECKED WITH THE WARRANTY THEY TOLD ME IT HAD EXPIRED. I HAD TOLD THEM THAT THIS WAS A FOLLOW UP FROM THE FIRST TIME I TOOK THE CAR IN BUT THEY SAID THEY COULD NOT DO ANYTHING, IN SEARCHING I FOUND OUT THAT FORD WAS AWARE THAT THE CVT TRANSMISSION HAD PROBLEMS AND THEY REFUSE TO ACCEPT IT, THEY NEED TO RECALL THESE CARS FIX THE PROBLEM THAT THEY HAVE CAUSED. THANK YOU FOR HEARING ME OUT. *TR

2006 FORD FIVE HUNDRED LTD AWD, VEHICLE ACCELERATED TO 4000 RPM WHILE IN REVERSE. VEHICLE IN SHOP FOR THREE WEEKS WAITING FOR REPLACEMENT PART, THROTTLE BODY. DEALER STATED PART ON BACK ORDER AND HE HAD TWO OTHER VEHICLE IN AT SAME TIME WITH SAME DIAGNOSIS. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED LIMITED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BOX WAS THE CAUSE FOR FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000. THE VIN WAS UNAVAILABLE.

SEVERE SIDEWALL CRACKING OF CONTINENTAL CT95 TIRES. ISSUE WIDELY REPORTED ONLINE. TIRES AT 60% OF TREAD, 3.5 YEARS SINCE NEW. REMAINDER OF TIRE IS IN VERY GOOD CONDITION. *TR

2006 FORD FIVE HUNDRED. CONSUMER WRITES REGARDING PREMATURE PAD AND ROTOR WEAR *TGW THE CONSUMER STATED SHE HEARD A GRINDING NOISE AND/OR DRAGGING NOISE COMING FROM THE REAR WHEELS. THE LEFT AND RIGHT WHEELS NEEDED NEW BRAKES AND ROTORS. THE CONSUMER STATED AN EXTENDED WARRANTY HAD BEEN ISSUED FOR THE BRAKES IN 2007, BECAUSE FORD KNEW THERE WAS A PROBLEM. ALSO, THE BLOWER MOTOR BEHIND THE GLOVE BOX HAD TO BE REPLACED AND THE REAR WINDOW DEFROSTER WAS DEFECTIVE AND HAD TO BE REPLACED AS WELL. THE GASKET BETWEEN THE CRANK SHAFT SUPPORT HOUSING WAS REPLACED. *JB

2006 FORD FIVE HUNDRED THROTTLE BODY FAILURE CAUSED CAR TO STALL ON HIGHWAY. THEN IT SURGED FORWARD LATER THAT DAY GOING FROM PARK TO DRIVE. *TR

I OWN A 2006 FORD FIVEHUNDRED. FROM THE VERY BEGINNING, MY CAR HAS LUNGED/SURGED FORWARD AND BACKWARDS. I CALLED FORD CORPORATE OFFICE ON THREE VARIOUS OCCASIONS TO FILE A COMPLAINT AND ASK FOR A REPAIR. EACH TIME I WAS TOLD THAT FORD WAS NOT RESPONSIBLE FOR DETERMINING THE PROBLEM. ON SEPT. 27, 2010, AT A STOP LIGHT, THE CAR SURGED TO 3000 RPM'S AND I WAS SCARED. I KEPT MY FOOT ON THE BRAKE, BUT I THOUGHT AT THAT SPEED, THE BRAKE MAY FAIL. I WAS GOING TO TURN THE CAR OFF, BUT INSTEAD, I TURNED THE AIR CONDITIONER OFF AND THE SURGING WAS REDUCED TO 1000 RPM'S. THIS IS A VERY DANGEROUS SITUATION. WHAT IS FORD WAITING FOR? THE CAR NEEDS TO BE RECALLED AND REPAIRS MADE, BEFORE A MAJOR ACCIDENT AND LAW SUITS ENSUE. *TR

2006 FORD 500 SEL WITH CVT. CAR BUCKS WHEN SLOWING DOWN TO 20 MPF. ALSO WILL NOT ACCELERATE SO I CANNOT PASS TRUCKS ON THE HIGHWAY. REAL DANGEROUS. TOOK IT TO THE DEALER WHILE STILL IN WARRANTY AND THEY COULD NOT FIND ANYTHING EXCEPT TO TRY TO SELL ME A MASTER CONTROL FOR $2100 AND THEY WOULD NOT GUARANTEE THIS WAS THE PROBLEM. THIS ISSUE NEEDS TO BE A RECALL. *TR

MY CAR STARTED LUNGING FORWARD AND DYING WHEN I WAS EITHER IDLE OR WHEN I STOPPED AND STARTED UP AGAIN. THE THROTTLE LIGHT AND ENGINE LIGHT CAME ON. SOMETIMES WHEN YOU WOULD TURN THE IGNITION OFF AND THEN RESTART THE THROTTLE LIGHT WOULD GO OFF. I HAVE NOTICED SOME DIFFERENCE IN FUEL MILEAGE. IF I DON'T HAVE MY FOOT ON THE BRAKE AND IT STARTS FORWARD SOMETIMES IT WOULD LUNGE, BUT NOT ALL THE TIME. I HAVE TAKEN IT TO GET THE COMPUTER FLASHED BY A GOODYEAR PLACE IN NORTH LITTLE ROCK, AR. IT HAS OCCURRED SEVERAL TIMES MORE SINCE THEY FLASHED IT. THAT WAS ABOUT THREE WEEKS AGO. THE DATE NOW IS SEPT. 20. I WANTED TO REPORT IT, BECAUSE WITH THE LUNGING IN HEAVY TRAFFIC, I AM AFRAID THAT I WILL REAR END SOMEONE ALL BECAUSE OF THE LUNGING, WHICH IS UNEXPECTED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT WAS BRAKING TO A COMPLETE STOP WHEN THE VEHICLE ATTEMPTED TO ACCELERATE ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THAT THE THROTTLE BODY WAS DEFECTIVE AND WOULD NEED REPLACING. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 48,600.

WHEN YOU SHIFT OUT OF PARK INTO EITHER REVERSE OR DRIVE THE CAR SURGES FORWARD VERY QUICKLY. IF YOU DON'T HOLD THE BRAKE TO THE FLOOR YOU CAN'T STOP IT. THIS IS VERY DANGEROUS! WHEN UNLOADING MY CHILDREN AT SCHOOL I ALMOST RAN OVER A CHILD DUE TO THIS DEFECT. WHEN I LOOKED ONLINE I FOUND THOUSANDS OF COMPLAINTS ABOUT THIS SAME ISSUE. FORD WON'T RECALL IT AND THE PARTS (THROTTLE BODY ASSEMBLY $800) ARE ON A 2 MONTH BACK ORDER! *TR

I BOUGHT MY 2006 FORD 500 USED IN 2009 AND ONLY A FEW MONTHS AFTERWARDS I EXPERIENCED "LURCHING" OF THE VEHICLE WHILE I WAS SLOWING ACCELERATING OR REVERSING. THIS ALMOST CAUSED ME TO CRASH INTO MY GARAGE AND IS VERY DANGEROUS WHEN I AM REVERSING IN A PARKING LOT AS THERE ARE PEDESTRIANS. THIS HAPPENED RANDOMLY FOR ABOUT 9 MONTHS WITH NO AFTEREFFECTS. NO LIGHT TURNED ON OR ANYTHING SEEMED TO WRONG OTHER THAN THE RANDOM LURCHING. HOWEVER, 9 MONTHS AFTER I PURCHASED THE VEHICLE I WAS STOPPED IN DRIVE TO LET MY FAMILY OUT OF MY CAR IN A PARKING LOT AND THE CAR LURCHED WHILE I HAD MY FOOT ON THE BRAKE AND THE GEAR IN DRIVE. THE WRENCH LIGHT THEN CAME ON AND THE CAR DROVE ODDLY (SOUNDED WEIRD AND DIDN'T ACCELERATE WELL) AFTER THAT. I EVENTUALLY PARKED IT AND WHEN I RETURNED AND TURNED THE CAR BACK ON THE LIGHT WAS OFF AND THE CAR SOUNDED FINE. THEN 2 MONTHS LATER I STARTED MY CAR AND PUT IT INTO REVERSE AND IMMEDIATELY NOTICED THE CAR SOUND WEIRD AGAIN AND WAS NOT ACCELERATING. I PUT IT INTO DRIVE AND BASICALLY COASTED TO THE SIDE OF THE ROAD BECAUSE THERE WAS NO ACCELERATION. THE WRENCH LIGHT WAS ON AGAIN. THIS TIME I HAD TO HAVE IT TOWED TO THE DEALERSHIP WHERE THEY TOLD ME I HAD TO REPLACE THE THROTTLE BODY ASSEMBLY. I HAVE NOT HAD IT REPAIRED YET AS I AM FIGHTING WITH THEM ABOUT THE WARRANTY I PURCHASED AND TRYING TO FIND THE BEST PRICE AS THIS SEEMS TO BE A RECURRING PROBLEM. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE STOPPED AT A LIGHT THE CONTACT NOTICED THAT THE VEHICLE HAD SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED AND THERE WERE NO PRIOR WARNINGS. THE FAILURE MILEAGE WAS 78000 AND THE CURRENT MILEAGE IS 80000. UPDATED 12/22/10 *BF UPDATED 12/23/10*JB

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 30-35 MPH THE VEHICLE ACCELERATED RAPIDLY. HE ENGAGED THE BRAKES IMMEDIATELY TO STOP THE VEHICLE FROM ACCELERATING. THE FAILURE OCCURRED 7 TO 8 TIMES AND THE FAILURE ALSO HAPPENED WHILE DRIVING IN REVERSE. HE CALLED THE DEALER AND WAS ADVISED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE WOULD ABNORMALLY STALL OR JERK VIOLENTLY WHEN DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO EXPERIENCED ABNORMAL SURGING, WHICH WOULD OCCUR FREQUENTLY. THE DEALER ADVISED THAT THE THROTTLE BODY HAD GONE INTO FAILSAFE MODE, CAUSING THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 96,000. UPDATED 12/7/10 *CN

I HAVE A 2006 FORD FIVEHUNDRED, IT HAS BEEN LUNGING WHEN PUT IN GEAR AND EVEN SOMETIMES JUST AS YOU LET YOUR FOOT OFF THE BRAKE. THIS IS VERY DANGEROUS SINCE I ALMOST REAR ENDED SOMEONE WHILE WAITING IN LINE AT THE DRIVE THROUGH. LAST WEEK IT STARTING TO ACT AS IF IT WANTED TO STALL. I TOOK IT TO THE FORD GARAGE AND THEY STATED I WILL NEED THE THROTTLE BODY REPLACED AND IT WILL COST $770 TO FIX IT AND THE PART IS ON BACK ORDER. AFTER SOME RESEARCH, I FOUND THAT ALOT OF PEOPLE WITH THIS CAR ARE HAVING THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE ATTEMPTING TO REVERSE OUT OF A PARKING SPACE WITH THE BRAKES APPLIED, THE VEHICLE ACCELERATED ABNORMALLY. THE FAILURE WOULD OCCUR INTERMITTENTLY WHILE IN REVERSE. THE DEALER DIAGNOSED THE FAILURE AT THE THROTTLE BODY ASSEMBLY, WHICH HE ADVISED WAS ON BACK ORDER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 83,000. UPDATED 11/16/10. *LJ

FORD NEEDS TO HAVE A RECALL REGARDING THE FIVE HUNDREDS LUNGING WHEN PUT IN REVERSE AND SOMETIMES WHEN PUT INTO DRIVE. MINE STARTED THIS ABOUT A YEAR AGO AND I DON'T HAVE TO PUT MY FOOT ON THE GAS TO GO IN REVERSE. EVEN WHEN PARKED DOWNHILL! MY HUSBAND AND I KNOW YOU MUST KEEP YOUR FOOT ON THE BRAKE ANYTIME YOU TAKE THE CAR OUT OF GEAR. IT'S VERY SCARY AND WE WILL NOT LET ANYONE DRIVE THE CAR FOR FEAR OF AN ACCIDENT. PLEASE LOOK INTO THIS! *TR

I HAVE A 2006 FORD 500 AND WHILE SITTING AT A RESTAURANT I PUT MY CAR INTO REVERSE TO BACK OUT OF THE PARKING SPACE WHEN IT SURGED BACKWARD AND I HAD NO CONTROL. SO I BRAKED AND PUT IN FORWARD. THEN IT SURGED FORWARD AND I HAD TO HARD BRAKE IT TO STOP THE CAR. IT HAD BEEN MAKING A NOISE LIKE THERE WAS SOMETHING WRONG WITH THE POWER STEERING. I CALLED THE DEALERSHIP AND A TOW TRUCK AND HAD IT TAKEN IN. THE DEALERSHIP RAN A DIAGNOSIS AND SAID IT WAS THE THROTTLE BOTTLE. SINCE I WAS ABOUT 50 MILES FROM HONE I HAD IT TOWED BACK TO MY CITY WHERE I AM HAVING THE THROTTLE BODY REPLACED. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHEN THE CONTACT ATTEMPTED TO STOP THE VEHICLE IT BEGAN TO LUNGE FORWARD. EXTREME PRESSURE WAS APPLIED TO THE BRAKE PEDAL IN ORDER TO KEEP THE VEHICLE FROM SURGING FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE MOTOR MOUNTS AND THROTTLE BODY NEEDED TO BE REPLACED. AN AUTHORIZED DEALER INFORMED HER THAT THIS WAS VERY COMMON FAILURE AMONG HER YEAR, MAKE AND MODEL VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 69,000 AND THE CURRENT MILEAGE WAS 74,000. UPDATED 11/05/10. *LJ

I OWN A 2006 FORD FIVE HUNDRED, LIMITED EDITION. WHEN THE CAR IS PUT IN GEAR, EITHER DRIVE OR REVERSE, WITH MY FOOT ON THE BRAKE, IT LURCHES FORWARD OR BACKWARDS 75% OF THE TIME. I BOUGHT MY CAR USED ALMOST TWO YEARS AGO WITH 71,000 MILES, AND THOUGHT THE LURCHING WAS NORMAL. I TOOK MY CAR TO A REPAIR SHOP, AND THEY SAID IT WAS THE TYPE OF TRANSMISSION. UPON FURTHER RESEARCH, I FOUND OUT THEIR THEORY WAS FALSE, AND IT TURNS OUT THE THROTTLE BODY GOES BAD AFTER ABOUT 30,000 MILES. THE LURCHING OCCURS AT LEAST ONCE A DAY, EVEN AFTER THE CAR HAS BEEN RUNNING FOR OVER 30 MINUTES. I HAVE BEEN LUCKY THAT I HAVE NOT INJURED ANYONE WITH THE SUDDEN LURCHING BECAUSE I WORK IN A BUSY DOWNTOWN CITY. SINCE I PARK IN CROWDED LOTS AND GARAGES, I HAVE COME EXTREMELY CLOSE TO HITTING OTHER VEHICLES WHILE I'M SIMPLY PUTTING MY CAR IN PARK. THE PROBLEM WASN'T AS BAD WHEN I FIRST BOUGHT THE CAR, BUT NOW THAT IT'S GETTING OLDER, I'M REALLY NOTICING THE LURCHING OCCURRING MORE FREQUENTLY. WHEN ANOTHER MEMBER OF MY FAMILY DROVE MY CAR RECENTLY, A FENCE ON OUR PROPERTY WAS STRUCK DUE TO THE LURCHING. THUS FAR, I HAVE NOT BEEN ABLE TO RECTIFY THIS ISSUE BECAUSE THE PART NEEDED (THROTTLE BODY) IS CURRENTLY ON BACK ORDER FOR A FEW MONTHS. I'M HOPING FORD IS FORCED TO RECALL THIS PROBLEM BECAUSE IT HAS THE POTENTIAL OF BEING DANGEROUS OR EVEN DEADLY. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP AND HAVING HIS FOOT ON THE BRAKE PEDAL AND THEN LETTING GO THE VEHICLE WOULD SURGE. THE CONTACT HAD TO FORCE PRESSURE ON THE BRAKES IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO THE DEALER TO HAVE IT DIAGNOSED AND THEY STATED THAT THE BODY THROTTLE CONTROL NEEDED TO BE REPLACED. THERE HAVE BEEN NO REPAIRS DUE TO THE BACK ORDER ON THE PART. THE FAILURE MILEAGE WAS 37200 AND THE CURRENT MILEAGE WAS 37419. UPDATED 10/25/10 *BF UPDATED 10/27/10 *JB

AFTER HAVING BEEN DRIVEN FOR 30-45 MIN, THE CAR WAS PARKED WITH MOTOR RUNNING FOR 5-10 MIN. GOT BACK IN CAR, PUT FOOT ON BREAK PEDAL, SHIFTED CAR INTO REVERSE, LIFTED FOOT OFF BREAK PEDAL AND CAR SUDDENLY LURCHED BACKWARDS. SLAMMED BREAKS ON AND CAR SHUT OFF. CAR HAD NO PROBLEM CRANKING RIGHT UP. DID THE SAME THING AGAIN, ONLY THIS TIME I HAD IT IN DRIVE. HIT THE BREAKS, CAR DIES AGAIN. THIS HAS HAPPENED A FEW TIMES WHILE SITTING IN LINE AT A FAST FOOD DRIVE-THRU AND HAVE ALMOST HIT CARS INFRONT OF ME WHEN I GO TO MOVE UP IN THE LINE. IF YOU TURN THE CAR ALL THE WAY OFF, IT WILL RESET AND NOT HAVE ANY PROBLEMS UNTIL THE NEXT TIME IT DECIDES TO DO IT AGAIN. I SEEM TO BE ABLE TO ELICIT THE PROBLEM BY DRIVING THE CAR FOR 30 OR SO MINUTES, STOPPING AND LETTING THE CAR SIT AND IDLE FOR 5-10 MINUTES. BINGO- IT HAPPENS. FORD DEALERSHIP SAYS IT IS THE THROTTLE BODY ON MY 2006 FORD FIVE HUNDRED AND I ACTUALLY HAD IT REPLACED IN 2007 AT APPROX 23,000 MILES (I NOW HAVE 69,500 MILES). CAR IS AWD. THANK GOD I HAVE AN EXTENDED WARRANTY UNTIL 75,000 MILES THAT WILL COVER THIS BUT IT SEEMS THE PART TO FIX IT IS ON BACKORDER AND THEY ARE NOT SURE WHEN IT WILL BE AVAILABLE (THAT IS RIDICULOUS CONSIDERING HOW MUCH I HAVE READ ABOUT "THROTTLE BODY ISSUES" WITH THIS CAR.) I THINK IT SHOULD BE A RECALL ISSUE SINCE YOU COULD EASILY HIT SOMETHING INFRONT OR BEHIND YOU. THANKS FOR LETTING ME INFORM YOU OF THIS PROBLEM. *TR

ON JULY 17, 2010, MY 2006 FORD 500 BEGAN TO LURCH/SURGE FORWARD/ BACKWARD DEPENDING ON WHETHER I WAS IN DRIVE OR REVERSE. TOOK THE CAR TO FORD IMMEDIATELY. THEY REPROGRAMMED THE PCM. IT WAS NOT COVERED BY THE EXTENDED WARRANTY. YESTERDAY, AUGUST 6, 2010, MY CAR BEGAN DOING THE SAME THING. TOOK CAR BACK TO SAME DEALER. THEY SUGGESTED IT MIGHT BE THE THROTTLE BODY. RESEARCH SHOWING THIS IS A COMMON PROBLEM WITH THIS VEHICLE (AND HAS BEEN FOR SOME TIME). *TR

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING AT 45 MPH. THE CONTACT DEPRESSED THE BRAKE PEDAL AND WHEN RELEASED, THE VEHICLE BEGAN TO ABNORMALLY ACCELERATE. IN ADDITION, THE VEHICLE WOULD ABNORMALLY JERK WHEN ATTEMPTING TO PARK. THE DEALER ADVISED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 44,000. THE CONSUMER STATED THE TRANSMISSION WOULD BANG INTO DRIVE AND REVERSE. THE DEALER FOUND THE THROTTLE BODY CAUSING THE ISSUE, WHICH WAS REPLACED. UPDATED 10/26/10

PURCHASED A FORD FIVE-HUNDRED BRAND NEW IN 2006. AT LESS THAN 45K MILES THE A/C NO LONGER IS FUNCTIONAL, UNLESS DRIVEN AT HIGHER SPEEDS (SUCH AS THE CASE ON HIGHWAYS). I HAVE HAD BOTH LOW AND HIGH SIDE PRESSURE VALVES CHECKED, THERMOSTAT REPLACED, AND A/C UNIT FLUSHED TO NO AVAIL. *TR

MANY MONTHS AGO MY 2006 FORD FIVE HUNDRED BEGAN JERKING FORWARD (ACCELERATING) WHEN SWITCHING GEARS FROM REVERSE TO DRIVE. OVER THE MONTHS THE PROBLEM HAS GOTTEN WORSE AND ACCELERATES VERY QUICKLY WHEN GOING INTO DRIVE GEAR. IT ACCELERATES SO QUICKLY IT COULD EASILY CAUSE ME TO RUN INTO SOMETHING. TOOK TO FORD SERVICE STATION AND TOLD THE THROTTLE (THROTTLE BODY MAYBE?) NEEDED TO BE REPLACED AND THAT IT WAS UNSAFE TO DRIVE UNTIL FIXED. THE PART IS ON BACK ORDER FOR TWO MONTHS! THE PART IS $800. NOW I'M PAYING FOR A CAR THAT I CAN'T EVEN DRIVE FOR TWO MONTHS. MANY PEOPLE HAVE COMPLAINED ONLINE ABOUT THE SAME TYPE OF PROBLEM AND APPARENTLY THERE IS A BIG PROBLEM WITH IT IF THE PART IS ON BACKORDER FOR 2 MONTHS SINCE SO MANY PEOPLE HAVE ORDERED IT. *TR

MY 2006 FORD 500 LUNGES INTERMITTENTLY WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE. THE CAR WAS TAKEN TO A REPAIR SHOP WHO COULD NOT REPRODUCE THE LUNGING AND SAID NOTHING APPEARED WRONG. SINCE IT ONLY OCCURS INTERMITTENTLY, IT IS DIFFICULT TO EVEN GET IT FIXED. IT APPEARS MANY OTHER FORD 500'S ARE HAVING THE SAME PROBLEM. *TR

I OWN A 2006 FORD FIVE HUNDRED. CAR SURGES FORWARD EVEN WHEN THE BRAKE PEDAL IS PRESSED. IT DOES THIS IN REVERSE ALSO - EVEN WHEN THE BRAKE PEDAL IS PRESSED. I HAVE FOUND THAT THE CAR DOES THIS MAINLY WHEN THE AIR CONDITIONING IS TURNED ON. IT IS EXTREMELY DANGEROUS TO TRY TO PARK THE CAR WHEN THE AIR CONDITIONING IS ON. THE CAR SURGES FORWARD AND I HAVE ALMOST RUN INTO OTHER CARS WHEN TRYING TO PARK. THE DEALER RETRIEVED THE CODE FROM THE COMPUTER. THEY APPLIED THE LATEST UPDATES TO THE COMPUTER AND CLEARED THE CODE. THE DEALER TOLD ME IF THAT DID NOT SOLVE THE PROBLEM, I WOULD HAVE TO GET A NEW THROTTLE BODY AT APPROX. $400. SEVERAL WEEKS HAVE GONE BY AND THE PROBLEM IS GETTING WORSE. IT IS SCARY! I CALLED THE DEALER AND ASKED THEM TO ORDER A NEW THROTTLE BODY. IT APPEARS TO BE ON BACKORDER UNTIL 8/31/10. SO I AM ON A WAITING LIST. THIS IS A MAJOR SAFETY PROBLEM THAT FORD MOTOR COMPANY NEEDS TO TAKE CAR OF. THIS SHOULD BE A RECALL!!! FORD MOTOR COMPANY SHOULD MAKE THIS RIGHT. I AM DISAPPOINTED IN FORD. I HAVE OWNED FORD VEHICLES FOR 20 YEARS AND HAVE NEVER BEEN SO DISSATISFIED. *TR

MY FORD 500 HAS BEEN LUNGING FORWARD AND BACKWARD WHILE IN DRIVE AND REVERSE. IT HAS DONE IT SEVERAL TIMES IN DRIVE ALMOST CAUSING ME TO HIT THE CAR IN FRONT OF ME. IT DOES ESPECIALLY WHEN THE AIR CONDITIONER IS ON. I HAVE NOT HAD THE CARE REPAIRED AS OF THIS DATE. RESEARCH SHOW THAT THIS CURRENTLY HAPPENING TO MORE THAN A NORMAL AMOUNT OF FORD 500 OWNERS. I HAVE EMAIL FORD ABOUT THIS PROBLEM AND I AM WAITING ON A RESPONSE. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE SURGED FORWARD WHILE HIS FOOT WAS ON THE BRAKE PEDAL. THE RPMS ALSO INCREASED AND CAUSED THE VEHICLE TO LUNGE FORWARD. WHEN THE VEHICLE BEGAN TO SLOW DOWN THE RPMS INCREASED AND CAUSED THE VEHICLE TO STALL. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE THROTTLE BODY. THE DEALER ALSO STATED THAT AT THIS TIME FORD DOES NOT HAVE THE PART TO REPAIR THE VEHICLE. THE CONTACT DID NOT HAVE THE VIN WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 74000.

WHEN SHIFTING INTO GEAR, OR WHEN TAKING FOOT OFF OF BRAKE AFTER SITTING FOR A BRIEF PERIOD, CAR LUNGES FORWARD (OR BACKWARDS) WITHOUT TOUCHING THE GAS PEDAL. THIS HAS CAUSED MANY NEAR ACCIDENTS INVOLVING BUILDINGS, OTHER AUTOS, AND PEDESTRIANS, VERY VERY DANGEROUS. FORD DEALERS CLAIM THEY CAN NEVER DUPLICATE THE PROBLEM WHILE IT IS IN THEIR SHOP. SOMEONE IS GOING TO GET HURT DUE TO FORD AND THEIR INABILITY TO DO THE RIGHT THING AND MAKE PROPER REPAIRS AT THEIR EXPENSE. *TR

TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE SHIFTING INTO REVERSE OR DRIVE, THE ENGINE WOULD REV AND MOVE BACKWARD AT A QUICK RATE. ALSO WHEN IDLING IN TRAFFIC, IF THE CONTACT TURNED THE STEERING WHEEL LEFT OR RIGHT, THE ENGINE WOULD ALSO REV AND SHE WOULD HAVE TO DEPRESS THE BRAKE PEDAL WITH GREAT FORCE TO KEEP THE VEHICLE FROM HITTING ANOTHER ONE. THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000. THE CURRENT MILEAGE WAS APPROXIMATELY 99,000.

REFERENCE ORIGINAL VOQ#10301954. MY CAR HAD A FIRE IN THE TRUNK WHILE WE WERE DRIVNG. THE TRUNK WAS LOADED WITH CLOTHES AND OTHER ITEMS. A FIRE OCCURED AND TOTALED THE CAR. UPON INSPECTION BY A FIRE FORENSIC INVESTIGATOR, IT WAS DETERMINED THE FIRE ORIGINATED FROM A WIRING HARNES ON THE RIGHT REAR SIDE OF THE TRUNK THAT GOES TO THE REAR LIGHTS. THE WIRING HARNESS CHAFED AGAINST THE BODY CAUSING A SHORT TO GROUND THAT LED TO THE FIRE.

WHENEVER IT RAINS, THE REAR DOORS FILL UP WITH WATER. YOU CAN ONLY GET SO MUCH WATER OUT SO IT PROBABLY IS FORMING MOLD AND RUSTING THE CAR DOOR FROM THE INSIDE. THIS HAS BEEN GOING ON FOR THE LAST COUPLE YEARS WHENEVER IT RAINS OR THE CAR IS WASHED IN THE CARWASH. *TR

EVERY TIME IT RAINS, MY REAR PASSAGE DOOR FILLS WITH WATER. WHEN THERE IS A HEAVY RAIN, WATER ALSO GOES INTO THE PASSENGER FRONT FLOOR PAN AREA. *TR

THE 2006 FORD 500 WE OWN HAS PROBLEMS WITH BOTH REAR DOORS. WHENEVER IT RAINS, THE DOORS FILL UP WITH WATER AND IT'S ALMOST IMPOSSIBLE TO GET THE WATER OUT. SOME CAN BE RELEASED BY SHAKING THE DOOR BUT MOST STAYS IN THE DOOR. I AM WORRIED ABOUT MOLD FORMING AS WELL AS FAILURE OF THE ELECTRONIC WINDOWS AND DOOR LOCK MECHANISMS. THIS HAS BEEN OCCURRING FOR SOME TIME. *TR

THE REAR PASSENGER DOOR OF MY 2006 FORD 500 FILLS WITH WATER EVERYTIME IT RAINS. I CANNOT FIND WAY TO RELEASE THE WATER AND THE DOOR IS VERY HEAVY NOW. I AM WORRIED THE DOOR WILL BE DAMAGED AND MY BABY'S CAR SEAT IS NEXT TO IT. I ACTUALLY NOTICED WATER IN THE DOOR QUITE SOME TIME AGO, BUT JUST REALIZED HOW BAD IT HAS GOTTEN AFTER OUR LATEST BAD THUNDERSTORMS/HEAVY RAINS. *TR

REAR BRAKES PREMATURELY WEAR DOWN TO LESS THAN 2MM OF PAD REMAINING AFTER 11K MILES. *TR

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE THROTTLE BODY DOES NOT OPERATE NORMALLY WHEN DRIVING AT 30 MPH. THE VEHICLE WILL DRAG AND WHEN THE ACCELERATOR PEDAL IS DEPRESSED THERE IS NO ACCELERATION. AT 15 MPH A WARNING LIGHT WILL ILLUMINATE BEFORE THE VEHICLE REDUCES SPEED. THE CHECK ENGINE LIGHT STAYS ON ALL THE TIME. THE VEHICLE WAS TAKEN TO THE DEALER TWICE AND THEY STATED THEY HAVE CHECK AND RECHECKED AND ARE UNABLE TO REMEDY THE FAILURE. THE VEHICLE WAS ALSO TAKEN TO TWO ANOTHER DEALER AND THE CONTACT WAS TOLD THAT IT IS THE THROTTLE BODY AND IT WILL COST $1000 FOR REPAIRS. THE FORD MANUFACTURER WAS NOT CALLED IN REGARDS TO THIS FAILURE. THE FAILURE MILEAGE WAS 68,000 THE CURRENT MILEAGE IS 88,000. UPDATED 4/23/10 *CN THE CONSUMER STATED THE ACCELERATION PROBLEMS WERE NOT CORRECTED BY CHANGING THE THROTTLE. UPDATED 05/28/10. *JB

TRAVELING SOUTH ON I-26 ACROSS THE TN/NC BORDER THROUGH SAM'S GAP ON A SNOWY DAY LED ME TO DRIVE VERY SLOW AND COME TO A STOP AT THE TRUCK INFORMATION AREA AT THE TOP OF THE HILL. WHEN I SAW A LARGE TRANSFER TRUCK PULL OUT ONTO THE ROAD AND PROCEED DOWN THE HILL I FELT IT WAS SAFE TO FOLLOW. THIS TRUCK WAS MOVING A LOT FASTER THAN I WAS AND I WAS "COVERING THE BRAKE" AND TAPPING IT OCCASIONALLY DOWN THE STEEP INCLINE, BUT THERE WAS ICE ON THE ROAD AND WHEN I TAPPED THE BRAKES THE CAR BEGAN TO SPIN AND HIT THE CONCRETE MEDIAN ON ALL 4 CORNERS OF THE VEHICLE WITH PRETTY STRONG FORCE. THE SEAT BELT CORRECTLY LOCKED DOWN ON THE DRIVER SIDE, BUT THE AIR BAG DID NOT DEPLOY PROPERLY. THE AIR BAG LIGHT WAS ILLUMINATED AND I COULD SMELL LIKE SOMETHING WAS BURNING. I ASSUMED THIS WAS THE COMPOUND USED IN THE AIR BAG. WHEN THE POLICE ARRIVED, I WAS GIVEN A CITATION FOR DRIVING TOO FAST FOR THE CONDITIONS AND ANOTHER BECAUSE THE INSURANCE RECENTLY LAPSED. THE TOW TRUCK DRIVER TOOK THE CAR TO THE BOTTOM OF THE HILL (DRIVING TOO FAST FOR THE CONDITIONS BY THE WAY) AND DECLARED THE CAR DRIVABLE SINCE THERE WERE NO FLUIDS LEAKING AND THE CAR WOULD STILL CRANK. THE FUEL SYSTEM HAD TO BE RESET, BECAUSE IT CORRECTLY SHUT OFF DUE TO THE IMPACT. THE SEATBELT WAS LOCKED DOWN COMPLETELY AND WOULD NOT RELEASE. SINCE THERE WAS NO SNOW BEYOND THE SAM'S GAP AREA, I DECIDED TO DRIVE HOME AND PARK THE CAR BECAUSE I DID NOT HAVE MONEY FOR A HOTEL OR FOR ADDITIONAL TOWING AND THE PERSON AT THE NC WELCOME C

1. TRAVELING OUT OF TOWN ON A SPECIAL 40TH ANNIVERSARY CELEBRATION IN A 2006 FORD 500( HAS APPRX. 64,000 MILES ON IT). 2. WHILE TRAVELING WE NOTICE THE SMELL OF SMOKE, THOUGHT IT WAS COMING FROM A SOURCE OUTSIDE, NO SMOKE IN VEHICLE, PULLED OVER TO INVESTIGATE, LOOKED UNDER THE HOOD AND THERE WAS NO SMELL OF SMOKE, PROCEEDED TRAVELING AND THE SMELL OF SMOKE CONTINUE, PASSENGER NOTICE A SMALL AMOUNT OF SMOKE COMING FROM THE TRUNK WHILE LOOKING AT THE REAR WINDOW, DRIVER PULLED OVER AND POPPED THE TRUNK, THE VEHICLE BECAME ENGULFED IMMEDIATELY...80-85% OF CAR WAS DESTROYED. 3.NOTHING. FORD DEALERSHIP THAT HAS SERVICED THE VEHICLE ( OVER 25 TIMES DURING OWNERSHIP) IS DENYING ANY RESPONSIBILITY. *TR UPDATED 05/26/10 *BF ACCORDING TO THE FIRE REPORT, THE FIRE'S ARE OF ORGIN WAS IN THE REAR SECTION OF THE VEHICLE. UDATED 06/17/10 *JB

TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY BETWEEN 45-50 MPH HE APPLIED PRESSURE TO THE ACCELERATOR PEDAL, BUT THE VEHICLE WOULD NOT ACCELERATE. THEN THE VEHICLE BEGAN TO RAPIDLY ACCELERATE. THE FAILURE OCCURRED FREQUENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS RELATED TO THE THROTTLE BODY. THE TECHNICIAN STATED THE PART WAS UNAVAILABLE UNTIL JANUARY 22,2010. THE FAILURE MILEAGE WAS 45,800. THE CURRENT MILEAGE WAS 46,200.