2005 Ford Five Hundred complaints

OUT SIDE AIR TEMP WAS APPROX 96 DEGREES SO AC WAS ON . WHILE SHIFTING INTO REVERSE THE VEHICLE LUNGED SO HARD IT WAS UNCONTROLLABLE,AND UNSTOPPABLE, IF SOME ONE HAD STEPPED OUT BEHIND ME THEY WOULD HAVE DIED AS I COULD ONLY STOP REWARD MOVEMENT BY SHIFTING INTO DRIVE. THIS OCCURRED THREE TIMES TRYING TO GET OUT OF A PARKING SPACE AT A CROWDED MALL.THE VEHICLE THEN STALLED. THE LUNGING WAS SO FAST THE BRAKES COULD HARDLY HOLD THE CAR FROM MOVING IN REVERSE. IN CHECKING THERE IS A SERVICE BULLETIN TSB-05-25-13 FROM FORD MOTOR COMPANY ON THIS VERY ISSUE BUT NO RECALL, ALSO MANY INCIDENTS/ACCIDENTS RECORDED IN THIS REGARD. IF I WAS NOT PREPARED ENOUGH DURING THIS INCIDENT IN A CROWDED PARKING LOT SOME ONE WOULD HAVE DIED, THIS MUST BE ADDRESSED B-4 SOMEONE IS RUN OVER. CURRENTLY FORD HAS NO COMMENT. PLEASE CONTACT ME FOR FURTHER DETAILS. *TR

AFTER HAVING TURNED ONTO A 35 MPH STREET, HAVING ONLY REACHED 30MPH, THE RPM'S SHOT UP TO SIX AND THE CAR ACCELERATED TO ALMOST 40 WITHOUT THE GAS PEDDLE HAVING BEEN PRESSED. IF THERE WERE ANOTHER CAR STOPPED OR A PERSON IN FRONT OF US THEY WOULD HAVE BEEN HIT. ANOTHER TIME THE VEHICLE WAS AT A STOP LIGHT AND AGAIN WITH OUT WARNING THE CARS RPM'S SHOT UP TO ABOUT SIX. IF MY FOOT HAD NOT BEEN APPLIED COMPLETELY TO THE BREAKS I WOULD HAVE BEEN IN A BUSY INTERSECTION RESULTING IN THE CAR HAVING BEEN TOTALED, DEATH OF MORE THEN ONE PERSON. THIS IS NOT SAFE. *TR

THE ELECTRONIC THROTTLE BODY IS BAD IN MAJORITY OF VEHICLES IN MY CLASS YEAR. THIS COSTLY REPAIR CAUSES THE VEHICLE TO LUNGE FORWARD WHILE IN DRIVE AND LUNGE BACKWARDS WHILE IN REVERSE. IT IS WORST WHEN THE AC IS ON,,IT CAUSES THE VEHICLE TO IDLE HIGH AND LOW TO THE POINT OF ALMOST SHUTTING OFF THE VEHICLE IN TRAFFIC. *TR

THE CAR SUDDEN SURGES FORWARD OR BACK WHEN MOVING OUT OF PARK. IF YOUR FOOT IS NOT FIRMLY ON THE BRAKE IT WILL GO MOVE SIGNIFICANTLY. UPON RESEARCH ONLINE AND TALKING TO FORD DIRECTLY THIS IS KNOWN PROBLEM THAT IS NOT UNDER RE-CALL YET BUT SHOULD BE. OUR LOCAL FORD DEALER CARRIES THE THROTTLE BOTTLE IN STOCK BECAUSE THEY SELL SO MANY OF THEM. THEY AVERAGE 10 A YEAR. A SIMPLE RESEARCH OF THE PROBLEM SHOWS UP. IT IS EXTREMELY DANGEROUS. ALSO IF THERE IS QUICK STOP IT WILL GO TO A FAIL SAFE MODE AND BASICALLY SHUT OFF THE CAR COMPLETELY. THE CAR HAS TO BE SHUT OFF AND RESTARTED IN ORDER TO MOVE THE VEHICLE AGAIN. THE THROTTLE BOTTLE MUST BE REPLACED IN ORDER FOR IT TO BE SAFE AS A PARTS COST OF ALMOST $600.00. *TR

WE WERE DRIVING DOWN A HIGHWAY AND WENT TO GET BACK TO SPEED AFTER PASSING THROUGH A SPEED ZONE. I NOTICED A DECREASE IN POWER AND LOOKED AT THE INFORMATION SCREEN. THE FAIL SAFE MODE AND THE "WRENCH" ICON WAS ON. I PULLED THE CAR OVER AND TURNED IT OFF. I THEN TURNED IT ON AND THE CAR ACTED NORMAL. IT HAS HAPPENED TWICE SINCE THE FIRST INCIDENT. MY WIFE TOOK IT TO THE DEALERSHIP AND FORD CANNOT DUPLICATE THE PROBLEM AND THE ISSUE DOES NOT THROW A CHECK ENGINE CODE OR LEAVES ANY TYPE OF ELECTRONIC HISTORY OF THE ISSUE. I CANNOT ALLOW MY WIFE TO DRIVE THIS CAR BECAUSE SHE IS SEVEN MONTH PREGNANT AND CANNOT HAVE HER DRIVE IT IF THE CAR BREAKS DOWN DUE TO THIS ISSUE. *TR

ON HOT SUMMER DAYS AND ONLY ON HOT SUMMER DAYS WHEN STOPPED AT LIGHT OR STOPPED PERIOD CAR BEGINS TO SURGE FORWARD WHILE HOLDING BRAKE. WENT ASKED FORD WHY IS THIS HAPPENING THEY SAID THEY DON'T KNOW. THAT I SHOULD GET THE THROTTLE BODY AND MASS AIR FLOW SENSOR SERVICED IF NOT DONE ALREADY. I GUESS IT HAD TO BE DONE AT 90K BUT I DID NOT KNOW. WELL I DID WHAT THEY SAID, WENT HOME AND CAR IS NOW IDLING ROUGH WENT BACK AND THEY WANT TO CHARGE ME ANOTHER $90 DOLLARS ONTOP OF THE $105 THEY HAVE ALREADY CHARGED ME FOR THE THROTTLE AND MAFS. I HAVE ALMOST GOTTEN IN NUMEROUS ACCIDENTS BECAUSE OF THIS BUT FORD DOESN'T WANT TO ACKNOWLEDGE THAT THIS IS A PROBLEM WITH THIS CAR. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 155,000 AND THE CURRENT MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO JERK VIOLENTLY AND RESPONDED AS THOUGH IT WOULD STALL. THE FAILURE OCCURRED SPORADICALLY WHEN DRIVING AT LOW AND HIGH SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSIS. THE TECHNICIAN STATED THAT THE MOTOR MOUNT WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

THIS HAPPENS FREQUENTLY ALMOST DAILY IN THE SUMMER. BUT ON A HOT DAY (90+) WHEN MOVING FROM A STOPPED POSITION OUT OF A PARKING SPOT OR AROUND A CORNER, WHEN YOU LIGHTLY HAVE THE BRAKE PEDAL DEPRESSED IF YOU TURN THE WHEEL SLIGHTLY (IE BACKING OUT OF A TIGHT PARKING SPACE) THE CAR WILL LUNGE VIOLENTLY AND AGGRESSIVELY IN WHAT EVER DIRECTION YOU ARE TRAVELING, SOMETIMES SO AGGRESSIVELY IT WILL STALL THE VEHICLE OUT AND THEN GO INTO A FAILSAFE MODE. THIS IS VERY DANGEROUS AS YOU COULD UNEXPECTEDLY HIT SOMEONE WALKING AROUND THE CAR AT A STOP SIGN OR CROSSWALK. I HAVE ALSO FOUND NUMEROUS OTHER COMPLAINTS ON VARIOUS BLOGS, FORUMS, AND OTHER SITES. EVERYONE BASICALLY STATING THE DEALER GIVES THEM THE RUN AROUND. AND AS LONG AS IT IS A HOT DAY I CAN DUPLICATE THE RESULTS CONTINUOUSLY, AND WOULD BE MORE THAN WILLING TO SHOW THIS TO SOMEONE ELSE IF POSSIBLE. I AM TYPICALLY NOT ONE TO COMPLAIN, BUT I FEEL VERY STRONGLY ABOUT THE SAFETY OF THIS VEHICLE, ESPECIALLY SINCE I HAVE A 3YR OLD DAUGHTER. *TR

SO HERE I AM ANOTHER VICTIM OF A FAULTY THROTTLE BODY. THANKS FORD I LOVE WHEN MY CAR TAKES OFF ON ME WITHOUT NOTICE, ESPECIALLY WHEN YOU HAVE KIDS IN THE CAR. HOW MANY OF THESE DO I HAVE TO READ BEFORE ACTION IS TAKEN. DOES IT TAKE A DEATH OR SERIOUS ACCIDENT. COST ME 718 DOLLARS I EXPECT A RECALL SOON AND MY MONEY BACK I WILL NOT QUIT UNTIL THIS IS TAKEN CARE OF. IT'S SAD WHEN YOU GO TO A MECHANIC AND THEY SAY "WOW THERE IS STILL NOT A RECALL ON THIS". OH BY THE WAY IT IS SUCH A COMMON PROBLEM I DIAGNOSED MY OWN CAR ISSUE IN 5 MINUTES BY USING GOOGLE AND TYPING FAILSAFE ENGINE MODE. *TR

WHEN BACK UP THE CAR ACCELERATES LIKE YOU ARE ON THE GAS BUT THE GAS PEDAL IS NOT TOUCH. WHEN THE CAR COMES TO A STOP AND THE FOOT IS ON THE BRAKE, ONCE YOU TAKE THE FOOT OFF THE BRAKE THE CAR ACCELERATES WITHOUT WARNING. THIS HAS HAPPEN IF STOP AT A LIGHT, BACKING OUT OR EVEN WHILE IN PARK THE CAR WILL JUST ACCELERATE WITHOUT WARNING! MY DAUGHTER ALMOST HIT A COUPLE OF PEOPLE WALKING IN THE CROSS WALK AND ALL SHE DID WAS RELEASE THE BRAKE TO MOVE UP AFTER A CAR TURN AND ACCELERATED WITHOUT WARNING. I HAVE HAD THE CAR ACCELERATE AFTER JUST BEING STOP AT A LIGHT OR MOVING AT SLOW SPEED WITHOUT TOUCHING THE GAS, BUT IT DOES NOT HAPPEN ALL THE TIME. LAST OIL CHANGE AT FORD DEALERSHIP THERE WAS NOTHING WRONG WITH TRANSMISSION FLUID AND THERE WERE NO LEAKS...... *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE LIGHT BEGAN TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE VEHICLE WOULD NEED A NEW THROTTLE BODY. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 101,934.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE TRANSMISSION FAILED. UPON SHIFTING INTO GEAR, THE VEHICLE ACCELERATED ON ITS OWN EVEN WITH THE BRAKES APPLIED. THE VEHICLE WOULD THEN ENTER INTO FAIL SAFE MODE AND STALL. THE FAILURE WOULD RECUR UPON RESTART. THERE WERE NO LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION AND THEY STATED THAT THE FAILURE WAS DUE TO A THROTTLE BODY FAILURE. THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THEN VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT WAS UNABLE TO INCREASE SPEED AND EVENTUALLY, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE-HUNDRED. THE CONTACT STATED THAT WHILE REVERSING FROM A RESIDENTIAL GARAGE, THE VEHICLE LUNGED BACKWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 70,000.

DURING HOT ( 95 DEGREES) AFTERNOON, WITH A/C ON HIGH, VEHICLE REVS AND LURCHES WHILE VEHICLE IS IN GEAR. HARD PRESSURE ON THE BREAK WILL STOP THE VEHICLE, BUT ENGINE REVS STILL CONTINUE. ENGINE THEN DIES AND ' ENGINE FAIL SAFE MODE ' APPEARS. TURNING THE VEHICLE OFF AND WAITING TO RESTART RESETS THE FAIL SAFE MODE. ALLOWING VEHICLE TO COOL DOWN CLEARS THE SHORT TERM PROBLEM. REPORTED TO LOCAL FORD DEALER WHO CLAIMS TO HAVE NOT HEARD OF THE PROBLEM. *TR

WHILE PARKING, WITH FOOT ON BRAKE THE CAR SURGED FORWARD. THE A/C WAS ON AS WELL. IT HAS NOW HAPPENED 7 MORE TIMES ALL WHILE THE A/C IS ON EITHER PARKING OR REVERSING FROM A PARKING SPOT. *JS

DURING WARM WEATHER WITH THE A/C OPERATING, THE RPMS SURGE AND THE VEHICLE LUNGES IN THE DIRECTION OF THE TRANSMISSION LEVER SELECTION (FORWARD OR REVERSE) WHEN MOVING THE SHIFT LEVER FROM PARK TO DRIVE OR FROM PARK TO REVERSE WITH DRIVER'S FOOT ON THE BRAKE. ENGINE RPMS SURGE UP TO APPROX. 1,500 FROM IDLE AT A DEAD STOP WITHOUT INPUT FROM ACCELERATOR PEDAL. DIFFERENT INDICATOR LIGHTS COME ON AND OFTEN THE ENGINE DIES AFTER THE SURGE. IF DRIVER DOES NOT KEEP APPROPRIATE PRESSURE ON BREAK PEDAL WHILE SHIFTING FROM PARK, THE VEHICLE WILL ACCELERATE WITHOUT INPUT FROM GAS PEDAL. THIS SURGE ALSO HAPPENS WHEN DECELERATING TO A STOP. VEHICLE SLOWS DOWN AND RPMS DECREASE TO APPROX 600 (IDLE), AND WITH PRESSURE APPLIED TO BRAKE PEDAL, ENGINE RPMS WILL INCREASE, WITHOUT INPUT FROM ACCELERATOR PEDAL, FORCING THE DRIVER TO INCREASE PRESSURE ON BRAKE PEDAL OR RISK UNCONTROLLED FORWARD MOVEMENT. INITIAL REPORTS INDICATE A FAULTY THROTTLE BODY AS REFERENCED IN NHTSA INVESTIGATION # PE110818. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED LTD. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STARTED TO LUNGE FORWARD AND BACKWARD BEFORE STALLING. THE CONTACT MERGED THE VEHICLE TO THE SHOULDER, TURNED THE ENGINE ON AND OFF AND THE VEHICLE STARTED IMMEDIATELY. THE FAIL SAFE MODE WARNING LIGHT STARTED TO ILLUMINATE. THE DEALER WAS NOTIFIED OF THE ISSUE BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000. THE CONSUMER STATED BEFORE SHE STARTED DRIVING ON THE ROAD, SHE BACKED OUT OF A PARKING SPACE. SHE HAD HER FOOT ON THE BRAKE SLIGHTLY AS SHE WAS BACKING UP, WHEN THE VEHICLE TRIED TO LUNGE FORWARD THEN BACKWARD. SHE APPLIED THE BRAKE ALL THE WAY, STOPPED THE VEHICLE, BUT DID NOT TURN IT OFF AND THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED. SHE TRIED TO BACK UP AGAIN, BUT IT STILL WASN'T RUNNING CORRECTLY, BUT SHE MANAGED TO FINISH BACKING OUT AND STRAIGHTENED OUT THE VEHICLE. THE FAIL SAFE MODE LIGHT STAYED ON. SHE SAT FOR A MINUTE AND BEGAN TO EXIT THE PARKING LOT. SHE ONLY DROVE 500 FEET, WHEN THE INCIDENT HAPPENED AGAIN. UPDATED 10/01/12

THROTTLE BODY MALFUNCTION. ENGINE REVES UP WHILE PLACING THE CAR IN DRIVE OR REVERSE WITHOUT TOUCHING THE GAS PEDAL, UP TO 1.5 ON THE RPM'S ON THE SPEEDOMETER. THIS IS VERY SCARY, A CHILD CROSSED IN FRONT OF ME WHILE I WAS WAITING AT A STOP SIGN. FOOT WAS ON THE BRAKE BUT ALL OF A SUDDEN IT JUST REVED UP. IT LUNGED FORWARD AND I HD TO REALLY PUT THAT BREAK ON. SCARED ME AND THE CHILD TO. I BOUGHT THE CAR NEW AND HAD ALL SERVICE DONE FROM THE FORD DEALER IN THE SERVICE PERSON THERE TOLD MY HUSBAND THAT THIS PART "THROTTLE BODY" WAS MADE BY THE SAME MANUFACTURER THAT MADE THE TOYOTA PARTS THAT WENT BAD "STICKING GAS PEDALS" ? AND THAT TOYOTA RECALLED THIS DANGEROUS ISSUE AND FIXED IT. UNLESS MY HUSBAND MISUNDERSTOOD THIS GENTLEMAN, WHICH I DON'T THINK HE DID. I SPOKE TO FORD AND PLACED A COMPLAINT AND THEY TOLD ME THAT THERE HAD BEEN COMPLAINTS, BUT THERE WAS NO RECALL ISSUED AS YET, BUT HOLD ONTO MY RECEIPT IN CASE THERE IS A RECALL ISSUED IN THE FUTURE. THIS WILL COST $850.00, "WHICH I FEEL SHOULD BE PICKED UP BY FORD". PRESSING NORMALLY ON THE BREAKS IS NOT GOOD ENOUGH, YOU HAVE TO ALMOST PUT IT TO THE FLOOR SO THAT YOU DO NOT MOVE AND PRAY THAT IT DOESN'T LUNGE FORWARD IN THE TRANSITION FROM BREAK TO GAS PEDAL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT

WHILE STUCK IN RUSH HOUR TRAFFIC, CAR WAS AT A COMPLETE STOP AT A RED LIGHT. WHEN TRYING TO LET OFF THE GAS, THE CAR LURCHED FORWARD ALMOST PLOWING INTO THE CAR IN FRONT OF ME. THIS OCCURRED ON 06/20/2012. DURING SUMMER 2011, THIS SAME TYPE OF BEHAVIOR OCCURRED 4 DIFFERENT TIMES. THE ENTIRE PROCESS BEGINS WITH THE CAR BEING AT A COMPLETE STOP, THEN WHEN LETTING OFF THE GAS, THE CAR'S ENGINE REV'S AND THE CAR LURCHES FORWARD REQUIRING THE DRIVER TO SLAM ON THE BREAKS FROM HITTING OTHER DRIVERS/PEDESTRIANS. WHEN THE VEHICLE DOES THIS LURCHING FORWARD MOTION, SEVERAL RED LIGHTS COME ON THE INSTRUMENT PANEL AND ALSO THE COMPUTER READS AN ERROR OF "FAILSAFE ENGINE MODE". POWER STEERING, POWER BRAKES HAVE BEEN LOST WHILE THIS EVENT OCCURS AS WELL. SEEMS AS IF IT COULD BE AFFECTED BY WARMER WEATHER BECAUSE I HAVE OWNED THE VEHICLE TWO YEARS AND HAVE ONLY HAD THIS HAPPEN DURING WARMER (90 DEGREE OR MORE) WEATHER. DURING SUMMER 2011, TWO OCCURRENCES HAPPENED THAT ALSO ALMOST CAUSED COLLISIONS. THE FIRST TIME WAS ON A SUMMER NIGHT IN A PARKING GARAGE. AS I WAS COMING INTO A STOP IN A PARKING SPACE, THE ENGINE LURCHED FORWARD AND CAME APPROXIMATELY 4-5 INCHES FROM HITTING A CONCRETE WALL. DURING THE OTHER OCCURRENCE, I WAS STOPPING AT A RED LIGHT AND CAME CLOSE TO RUNNING OVER A PEDESTRIAN DUE TO LURCHING FROM CAR. WHEN CAR ENTERS "FAILSAFE ENGINE MODE' AND LURCHES FORWARD, CAR MUST BE PARKED AND RESTARTED FOR THE VEHICLE TO RUN NORMALLY AGAIN. ALSO, IT ONLY HAPPENS AT LOW SPEEDS (I.E.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE DOWN SHIFTED AND LOST ENGINE POWER. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE DEALER REPROGRAMMED THE COMPUTER, BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR A DIAGNOSTIC TEST, WHICH LOCATED THE FAILURE AT THE TRANSMISSION VALVE BODY. THE TRANSMISSION VALVE BODY WAS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 67,407.

VEHICLE SHIFTS HARD WHEN HITTING PASSING GEAR ON HIGHWAY LIKE TRANSMISSION IS SLIPPING OR GOING OUT. LOSE ALL POWER AND CAR WILL BUCK BACK AND FORTH. ALSO DOES IT WHEN TRANSMISSION DOWN SHIFTS AND THEN TRIES TO UPSHIFT WHEN ACCELERATING AND ENGINE WARM. *TR

WHILE CHANGING A TIRE THE JACK COLLAPSED UNDER MY VEHICLE. FORTUNATELY I WAS NOT UNDER THE CAR AND THE WHEEL WAS STILL ON THE CAR. IT APPEARS THAT THE FEMALE THREADS ON THE JACK STRIPPED AWAY. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FAIL SAFE MODE ACTIVATED, CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS MERGED TO THE SHOULDER, TURNED OFF AND THEN RESTARTED AFTER SEVERAL MINUTES, AS IT RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING A FULL DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 126,000.

WHEN YOU ARE DRIVING THE VEHICLE WILL STOP ACCELERATING AND A FAIL SAFETY MODE LIGHT COMES ON, IF YOU PULL OVER AND RESTART IT, IT WILL RESTART AND HAPPENS A FEW MINUTES LATER. *TR

VEHICLE SLIPPED OUT OF DRIVE INTO NEUTRAL WHILE ASCENDING HILL. I HAD TO PULL OVER COMPLETELY AND STOP, SHIFT INTO LOW AND SLOWLY BACK INTO DRIVE. THE CAR BEHIND ME ALMOST REAR ENDED ME AS I HAD LOST POWER WITH NO WARNING. CAR ONCE WARMED STARTS TO BUCK VIOLENTLY WHILE DRIVING AT AN EVEN SPEED, BUCKS VIOLENTLY WHEN COMING TO A STOP AND RANDOMLY SLIPS OUT OF GEAR WITH NO WARNING. I HAVE HAD THIS CAR SINCE 2009 AND HAVE POT LESS THEN 20000 MILES ON IT. THE DEALER TELLS ME THE COMPUTER DOES NOT READ ANY PROBLEMS. *TR

ENGINE RANDOMLY ACCELERATES DURING HOT WEATHER AND COLD STARTS. TOOK TO FORD GARAGE WHO REPORTED DEFECTIVE SPARK PLUG WIRE. DID NOT FIX PROBLEM WHICH HAS RECURRED. GT ERROR CODE FROM PARTS STORE. FORD DEALER DECLINED EXISTENCE OF SUCH CODE. ONLINE SEARCH REVEALED REPORTS OF THROTTLE BODY MALFUNCTION WHICH CAN BE TREATED WITH FUEL ADDITIVE. SEEMED TO STOP IT FOR A WHILE BUT HAS RECURRED ON SEVERAL OCCASIONS. ANOTHER NON DEALER REPAIR SHOP COULD NOT FIND DEFECT. PROBLEM HAS AGAIN RECURRED WITH FIRST HOT(OVER 90) WEATHER. *TR

MY WIFE, SON AND I WERE DRIVING. THE VEHICLE HAD RANDOM ACCELERATION WHILE AT FULL STOPPED. ABOUT 10 MINUTES LATER AFTER A FULL STOP THE VEHICLE HAD ANOTHER ACCELERATION WHILE FOOT ON BRAKE AND THE VEHICLE STALLED OUT. ONCE STALLED OUT THE COMPUTER DISPLAYED THE FOLLOWING ERROR "FAIL SAFE ENGINE". AFTER DOING AN ONLINE REVIEW I NOTICED THAT MANY OTHER FORD FIVE HUNDRED OWNERS HAVING THE SAME ISSUE AND SEEMS TO BE CAUSED BY "THROTTLE BODY". PLEASE NOTE THAT WHENEVER THE VEHICLE IS ON PARK AND PUT INTO REVERSE, THE HIGHER ACCELERATION TAKES PLACE. I ALWAYS HAVE TO BE EXTRA CAREFUL. I HAVE TO BE EXTRA CAREFUL WHILE DRIVING AS I AM AFRAID FOR ACCELERATION AND STALLING OUT IN THE MIDDLE OF THE ROAD. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE OIL PRESSURE AND BRAKE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE TURN SIGNALS FAILED AND THE REVERSE LIGHTS ILLUMINATED ON THEIR OWN. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

I HAD THE NEED TO AVOID AN ACCIDENT BY SUDDENLY CHANGING LANES BUT WHEN I STEP ON THE GAS PEDAL MY TRANSMISSION FAILED TO SHIFT TO HIGHER SPEED. INSTEAD TWO CLUNKING SOUNDS TOOK PLACE BEFORE FINALLY SWITCHING INTO HIGHER GEAR .I WAS ABLE TO AVOID THE CAR IN FRONT OF ME , BUT NOW THE CAR BEHIND ME ALMOST REAR ENDED US. THIS WOULD HAVE CREATED A FATAL CHAIN REACTION WE COULD HAVE BEEN CRUSHED IN. I FOUND OUT THIS CARS HAVE A GREAT AMOUNT OF FAILURES ON RECORD FORD 500 2005 PLEASE HELP *JS

I HAVE AN ONGOING ISSUE WITH THE TRANSMISSION DE-ENGAGING WHEN THE TEMPERATURE OF THE TRANSMISSION WARMS UP. WHEN I ACCELERATE WHEN PASSING OR USING THE CRUISE CONTROL THE TRANSMISSION WILL DIS-ENGAGE LEAVING ME WITH NO FORWARD POWER, I MUST PUT THE CAR IN NEUTRAL AND HOPE IT ENGAGES ALL THE WHILE ALMOST BEING RUN OVER BY TWO SEMI-TRUCKS. THIS HAPPENED ALMOST A DOZEN TIMES DOWN AND BACK ON MY TRIP FROM BUFFALO TO PEAPACK NJ ON MONDAY 4/16/2012. THIS IS A KNOW PROBLEM THAT FORD IS AWARE ON THE FIVE HUNDRED MODEL, MONTEGO AND SOME FUSION MODELS. MANY START TO FAIL AT LESS THAN 30,000 MILES AND HAPPENED AT 65,000 MILES ON MY VEHICLE. I CONSIDER THIS AN EXTREMELY DANGEROUS SITUATION AND AMAZED NO ONE HAS BEEN KILLED DUE TO THESE DEFECTIVE TRANSMISSIONS. THE FORD FORUM HAS OVER 10 PAGES OF COMPLAINTS REGARDING THIS PROBLEM. FORD TOLD ME THEY WOULD NOT DO ANYTHING UNLESS THERE WAS A RECALL.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN A LOUD POP WAS HEARD AND SUDDENLY, THE SUN ROOF GLASS EXPLODED. THE GLASS SHATTERED INSIDE OF THE VEHICLE AND THE CONTACT SUFFERED INJURY TO THE EYE FROM SMALL FRAGMENTS OF GLASS ENTERING THE EYE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE REAR TRUNK AND REAR BUMPER SUSTAINED SEVERE SCRATCHES. THE WAS TAKEN TO A COLLISION CENTER FOR REPAIR. THE TECHNICIAN ALSO INFORMED THE CONTACT THAT THE FRONT DRIVER SIDE WINDOW GLASS EXHIBITED SPIDER CRACKS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 32,724.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WHILE DEPRESSING THE ACCELERATOR PEDAL. ALL OF THE LIGHTS ON THE INSTRUMENT PANEL FAILED AND THE REVERSE LIGHTS ILLUMINATED ERRONEOUSLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THE CONTACT THAT THE PCM MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE ENTERING THE VEHICLE, HE NOTICED THAT SMOKE FILLED THE INTERIOR. THE CONTACT THEN NOTICED THAT THE TRUNK LIGHT WAS ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT WAS NOT CALLED AND NO ONE WAS INJURED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.

THE CAR PERIODICALLY LURCHED AND SURGED. FINALLY, IT WOULD NOT START. THE DEALER DETERMINED THAT THE ELECTRONIC THROTTLE BODY WAS DEFECTIVE. BASED ON INFORMATION FROM THE DEALER AND FROM THIS WEBSITE, IT APPEARS THAT THIS IS A COMMON PROBLEM ON CERTAIN FORD MODELS. IF THIS PROBLEM IS AS WIDE-SPREAD AS IT APPEARS, THERE SHOULD BE A RECALL. *TR

BEING STOPPED AT AN ATM, MY CAR BEGAN TO SMOKE. PULLED OVER INTO THE BANK PARKING LOT TO SEE IF IT WAS OVER HEATING. THE WHITE SMOKE WOULD NOT SUBSIDE AND BEGAN GETTING WORSE. DIALED 911 AND A FIRETRUCK CAME OUT OPENED THE HOOD AND EXTINGUISHED A FIRE UNDER THE HOOD. PRIOR TO THE TRUCK ARRIVING, A LOUD BANG OCCURRED UNDER THE HOOD. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT ALL OF THE GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION AND THE REVERSE LIGHT WAS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WERE NO RECALLS FOR THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 109,102.

I NOTICE YEARS AGO THAT WHEN I WOULD BE BACKING UP OR PULLING INTO A PARKING SPOT THAT MY CAR WOULD WANT TO ACCELERATE OR JUST SPEED UP. I WOULD BE BARELY PRESSING ON THE BRAKE BECAUSE I WAS LETTING THE CAR USE IT'S IDLENESS SPEED TO BACK OUT OF THE SPACE OR PULL INTO THE PARKING SPACE. MY HUSBAND THOUGHT IT WAS BECAUSE I WAS USING THE ADJUSTABLE FOOT PEDAL. HE DOES NOT DRIVE THE CAR VERY MUCH. SHORTLY AFTER THIS ALL STARTED WE PURCHASED ME ANOTHER CAR, I STOP DRIVING MY FORD 500 VERY MUCH. IT SITS IN THE GARAGE A LOT. I LET MY DAUGHTER USE THE CAR ONCE AND SHE COMPLAIN OF THE SAME THING HAPPENING TO HER AND HOW IT SCARED HER. I AM ALSO SCARED OF IT AND ONLY DRIVE IT IN EMERGENCY AND I ALWAYS TRY TO BE PREPARED TO EXPECT THIS TO HAPPEN. IT HAS NO PATTERN OF WHEN OR HOW IT HAPPENS IT ALL UNEXPECTED, WORKING PROPERLY ONE MINUTE AND SPEEDING UP THE NEXT. THIS CAR HAS ONE OTHER ISSUE WHEN IT RAINS IT LEAKS WE FIND WATER IN THE FLOOR ON THE DRIVER SIDE FLOOR. THIS CAR IS AVAILABLE FOR TESTING IF NEEDED BECAUSE WE HAVE A 2ND CAR THAT I DRIVE BECAUSE OF THIS ISSUE. WE KEEP IT BECAUSE IT IS PAID FOR. *TR

WHILE STOPPED AT A RED LIGHT, THE CAR STARTED TO JERK AND THE MOTOR RACED/IDLED UP HIGH. *TR

SINCE 2007 THE CAR INTERMITTENTLY WILL PERIODICALLY LUNG FORWARD AND IT IS ALMOST IMPOSSIBLE TO CONTROL THE CAR. THIS HAS HAPPENED SEVERAL TIMES SINCE JUNE 2007 (88,000 MILES). EVEN HARD BRAKING DOES NOT NECESSARILY STOP THE CAR...I HAVE HAD TO PUT THE CAR IN NEUTRAL THE ENGINE REVS UP AS IF I AM TOUCHING THE ACCELERATOR (AND MY FOOT IS NOT ON THE PEDAL) AND I SHUT THE CAR OFF. TURNING THE CAR BACK ON DOES NOT NECESSARILY REMEDY THE PROBLEM. IN ADDITION, THE CAR ROUTINELY GOES INTO FAIL SAFE ENGINE MODE OR CUTS OFF WHILE I AM DRIVING AT A REASONABLE RATE OF SPEED BOTH ON RURAL ROADS AND HIGHWAYS. THIS CAR IS A HAZARD TO DRIVE, MORE SO IN THE WARMER MONTHS...MY THOUGHT IS SOMETHING MUST GET OVERHEATED BUT WHAT I DO NOT KNOW. *TR

THIS HAS HAPPENED MULTIPLE TIMES (MEANING MORE THAN 5 TIMES) DURING THE SUMMER OF 2011. DRIVING ON HIGHWAY AT POSTED SPEED LIMITS AND CAR SUDDENLY LURCHES THEN DROPS INTO FAILSAFE MODE (AS INDENTIFIED BY ALERT POSTED ON THE DASH). PULL OVER, READ OWNER'S MANUAL. FOLLOW DIRECTIONS HOW TO CLEAR FAILSAFE AND IMPLEMENT THEM. A FEW TIMES IT WORKED FOR SHORT PERIODS OF TIME. OTHER TIMES, IT WOULD NOT WORK AT ALL. TWICE THE CAR WAS RUNNING AT APPROXIMATELY 65 MPH AND SUDDENLY GO INTO FAILSAFE MODE THEN STALL OUT. ESPECIALLY DURING STREET/CITY DRIVING, CAR SUDDENLY KICKS FORWARD THEN FAILSAFE AND WILL SOMETIMES STALL OUT IN MIDDLE OF STREET. UNABLE TO RESTART. LAST TIME THIS OCCURRED CAR REQUIRED TOWING TO LOCAL FORD DEALER. INITIALLY SAID IT WAS THE THROTTLE SENOR FOR A COST OF $300. WHEN I OK'D THAT REPAIR, THE DEALERSHIP CALLED BACK LATER AND STATED IT WAS THE ENTIRE THROTTLE BODY AND REPAIR WOULD COME AT A COST OF $1000. THE CAR NOW SITS IN MY DRIVEWAY WHERE IT WAS TOWED TO AND SITS FOR SAFETY REASONS. AFTER RESEARCHING THE INTERNET, I HAVE COME TO FIND THAT THIS IS A COMMON OCCURRENCE WITH FORD AND AN ANNOUNCED RECALL SHOULD BE IMPLEMENTED IMMEDIATELY. *KB

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR WOULD NOT LATCH PROPERLY AFTER INCLEMENT WEATHER SUCH AS ICE, SNOW OR RAIN. THE CONTACT WOULD HOLD OPEN THE DOOR HANDLE AND SHOVE IT A FEW TIMES IN ORDER TO ENTER ON THE PASSENGER SIDE TO ENSURE THAT THE DOOR WOULD REMAIN SHUT WHILE OPERATING THE VEHICLE. THE DEALER ADVISED THE CONTACT THAT HER VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 74,000 AND THE FAILURE MILEAGE WAS 71,000.

WE BOUGHT MY CAR IN JULY 2011, ITS WAS GARAGED BY THE 1ST OWNER SO IT WAS LIKE BRAND NEW!! LOW MILES JUST 12,850 , START WHAT NOW SEEMS TO BE THE ENDLESS DRIVES IN A RENTAL CAR AND WITH EMPTY WALLETS TOTALING NOW APPROX; CLOSE TO AN ADDITIONAL $3,500 NOW IN REPAIRS FROM THE BATTERY IN AUG 2011 TO NOW TO HAVING THE THROTTLE BEING REPLACE ALONG WITH A SET IF TIRES AND THE 2ND SET OF BOTH REAR AND FRONT BRAKES IN LESS THEN A YEAR , ALL DUE TO THE CONSENT STOPPING AND GOING OF THE CAR BY HITTING THE BRAKES TOO MUCH AND HAVING TO ACCELERATE, BECAUSE THE CAR WOULD WHILE TEMPTING TO PULL OUT OF MY GARAGE AT WHAT SHOULD OF BEEN A MERE 3MILES PER HOUR; RESULTED IN FLYING BACKWARDS SUDDENLY WHILE FOOT WAS APPLYING PRESSURE ON THE BRAKES TO KEEP FROM MOWING DOWN MY TEENAGE SON AT 15 MILES A HOUR ON ITS OWN WITH THE MP RISING RAPIDLY , WAS THE SCARE OF MY LIFE!!!! PLEASE SOMEONE RECALL THIS CAR , BEFORE SOMEONE REALLY DOES GET KILLED OR HURT!!! AS OF TODAY THE TOTAL THIS TIME TO REPAIR MY CAR IS AT A TOTAL IF$ 1,585.00; TO REPLACE THE THROTTLE AND TIRES & BRAKES AGAIN, AND FORD WOULDN'T EVEN COMP, US A RENTAL CAR THIS TIME ON OUR 5 TRIP DOWN TO THE SERVICE DEPT OF FORD!!!! *TR

DRIVING FROM SJ TO LA, CALIF. 200 MILES INTO MY JOURNEY WITH WIFE AND 3 KIDS, PULLED OFF HIGHWAY FOR GAS. SLOWED DOWN AND NOTICED THE WRENCH AND CHECK ENGINE LIGHTS ON AND CAR WOULD ONLY GO 10 TO 15 MILES PER HOUR AND REVVED AT MORE THAN 3000 RPMS. THE CAR CLUNKED HARD WHEN PUT INTO DRIVE OR REVERSE. TURNED OFF THE ENGINE, SEVERAL TIMES AND RESTARTED. SOMETIMES FIXED PROBLEM, OTHER TIMES DID NOT. I HAD CAR TOWED TO HANFORD, CALIFORNIA, AND THEN AGAIN TO LOS ANGELES-ANOTHER 198 MILES TO FORD DEALERSHIP. I HAD TO RENT A CAR AND DRIVE THE REST OF THE WAY TO LA AND DRIVE BACK - 198 MILES-TO HANFORD-TO RETURN THE RENTAL CAR. I TESTED THE CAR A FEW TIMES IN HANFORD AND WHEN IT WAS AT THE FORD DEALER. FROM A COLD START, THE CAR WORKED FINE. DROVE AND SHIFTED WELL WITH NO PROBLEMS. BUT ONCE THE CAR WARMED UP, IT WENT BACK INTO LIMP-MODE, CLUNKED HARD WHEN YOU SHIFTED INTO DRIVE OR REVERSE, AND WOULD GO ONLY 10-15 MPH AT 3000 OR MORE RPMS. THE DEALER TEST DROVE IT AND HAD THE SAME RESULT. THE DEALER GOT CODES P0701, P0871, AND P0961 AND SAID THAT MEANT THE TRANSMISSION HAD INTERNAL PROBLEMS. THEY SAID THEY CALLED FORD ENGINEERS WHO TOLD THEM THE LIKELY PROBLEM WAS WHEN THE TRANSMISSION FLUID WARMS UP, IT IS NOT PROPERLY CIRCULATING DUE TO LEAKS IN WHAT THEY CALLED TWO VARIATORS INSIDE THE TRANSMISSION. THEY QUOTED THE COST TO REPLACE THE VARIATORS AS $3600 FOR PARTS AND LABOR OF $1200 FOR A TOTAL OF $4800 AND THAT IS MORE THAN THE COST TO REPLACE THE TRANSMISSION FOR WHICH THEY QUOTED

DRIVING IN TOWN, AT APPROX 25MPH. CAR JERKED/LURCHED SUDDENTLY, THEN ENTERED LIMP HOME MODE. PULLED OVER, TURNED OFF CAR. RESTARTED AND CHECK ENGINE LIGHT CAME ON. TURNS OUT IT IS A THROTTLE BODY FAILURE. SHOP SAYS THIS IS A VERY DANGEROUS SITUATION - THE CAR COULD SUDDENLY ACCELERATE/DECELERATE WITHOUT NOTICE. LOOKING AT ONLINE FORUMS - IT SEEM A FAIRLY COMMON FAILURE, AND SOMETHING FORD SHOULD ISSUE A SAFETY RECALL ON. *TT

I WAS DRIVING DOWN A RESIDENTIAL STREET WHEN ALL OF THE SUDDEN THE ENGINE STALLED ON ME AND I RECEIVED A "FAILSAFE ENGINE MODE" MESSAGE IN THE MESSAGE CENTER. I STOPPED THE CAR AND SHUT OFF THE ENGINE, THEN WAITED A COUPLE OF MINUTES AND STARTED IT AGAIN AND HAD NO PROBLEMS. I WAS THEN DRIVING DOWN A RESIDENTIAL STREET AGAIN A COUPLE OF DAYS LATER AND THE SAME THING HAPPENED WHERE THE ENGINE STALLED ON ME. THE ONLY WARNING SIGNS THAT I CAN RECALL WERE THAT AT TIMES, I WOULD EXPERIENCE SLUGGISH ACCELERATION. THIS IS A HUGE ISSUE TO ME AND VERY DANGEROUS SINCE I HAVE A CHILD AND WHAT IF I WAS TRAVELING ON THE HIGHWAY AND THIS HAPPENED TO ME? *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE GAUGES ON THE INSTRUMENT PANEL WOULD BECOME INOPERATIVE AND ALL OF THE WARNING LIGHTS WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE REAR REVERSE SENSOR WOULD ONLY OPERATE WHILE THE VEHICLE WAS IN DRIVE AND THE REVERSE LIGHTS WOULD CONTINUOUSLY ILLUMINATE WHILE IN DRIVE. THE DEALER PERFORMED A HARD RESET ON THE VEHICLE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT PANEL WOULD SHUT ON AND OFF INTERMITTENTLY WITHOUT WARNING. IN ADDITION, THE CHECK ENGINE AND AIR BAG WARNING LIGHTS WERE ILLUMINATED SPORADICALLY. SHE BELIEVED THAT THE ENTIRE ELECTRICAL SYSTEM WAS FAULTY SINCE A RECENT FAILURE OF THE ODOMETER READING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT MILEAGE WAS 42,000 AND THE FAILURE MILEAGE WAS 41,500.

I PURCHASED THIS 2005 FORD FIVE HUNDRED AS A GIFT FOR MY WIFE,11/26/11 WITHIN A WEEK AFTER OWNING IT THE AWD MALFUNCTION LIGHT CAME ON. IN LOOKING OVER THE INTERNET I'M FINDING OTHER FORD OWNERS ARE EXPERIENCING THE SAME PROBLEM AND THAT FORD DOES NOT WANT TO DO ANYTHING ABOUT IT OR TAKE RESPONSIBILITY FOR A DEFECTIVE PRODUCT THAT POTENTIALLY COULD BE VERY COSTLY OVER AND ABOVE THE HIGH COST OF THE VEHICLE ITSELF. IT SEEMS THE CONSUMER SHOULD HAVE ''SOME'' RECOURSE OR HELP WITH THIS RECURRING PROBLEM AND MAKE FORD OWN UP AND REPAIR THE DEFECT AND PROBLEMS MANY OF US ARE DEALING WITH... OUT OF POCKET!!! *TR