2005 Ford F-350 SD complaints

1. DRIVING 2. CRUISE CONTROL DOES NOT DISENGAGE WHEN BRAKE IS APPLIED. IN FACT, WHEN BRAKE IS APPLIED, THE TRUCK TRIES TO COMPENSATE FOR REDUCED SPEED BY DOWNSHIFTING AND ACCELERATING. I HAVE HAD IT HAPPEN TWICE WHERE IT NEARLY CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. THE DEALERSHIP VERIFIED THE PROBLEM BUT COULD NOT FIX IT. THEY SENT ME AWAY WITH THE PROBLEM STILL OCCURRING AND IT IS SO DANGEROUS THAT I DO NOT USE CRUISE CONTROL AT ALL. 3. DEALERSHIP ATTEMPTED TO ADDRESS THE PROBLEM BUT COULDN'T FIX IT. THEY VERIFIED THE PROBLEM AND DOCUMENTED IT IN MY FILE WITH THEM. *TR

1. TRYING TO SHIFT TRUCK INTO 4X4 LOW 2. THE TRUCK WILL NOT SHIFT INTO 4X4 LOW. THERE IS A "SHIFT ON THE FLY" KNOB ON THE DASH AND YOU CAN SHIFT TRUCK INTO 4X4 HIGH, OR 4X4 LOW. IT WILL SHIFT INTO 4X4 HIGH BUT NOT 4X4 LOW. 3. I HAVE TAKEN THE TRUCK INTO THE DEALERSHIP TO ADDRESS THE PROBLEM. THEY VERIFIED THE PROBLEM BUT COULD NOT FIX. *TR

1. IF I DRIVE OVER A BUMP IN THE ROAD AT 50MPH OR FASTER. 2. FRONT END SHIMMY. THE FRONT OF MY TRUCK SHAKES VIOLENTLY AND THE BRAKES HARDLY WORK TO GET THE TRUCK SLOWED DOWN. THE SHAKING IS SO VIOLENT THAT I LOSE CONTROL OF THE TRUCK. IT HAS SHAKEN MY TRUCK SO VIOLENTLY THAT IT HAS DAMAGED MY TRUCK. I HAVE HAD IT HAPPEN ABOUT 12 - 15 TIMES. I CAN'T DRIVE OVER 50MPH OR IT STILL HAPPENS. I HAVE ALMOST CAUSED 3 ACCIDENTS AS A RESULT OF THIS HAPPENING. IT HAPPENED ONCE WITH MY WIFE DRIVING WITH OUR KIDS AND SHE WENT OVER THE CENTERLINE AND ALMOST HIT A SEMI HEAD ON. 3. I HAVE TAKEN THE TRUCK TO THE DEALERSHIP TO GET REPAIRED AND THEY TELL ME NOTHING IS WRONG WITH MY TRUCK. I PURCHASED THE TRUCK NEW IN 2005 AND IT FIRST STARTED HAPPENING AT 10,000 MILES. TRUCK CURRENTLY HAS 34,000 MILES AND THE PROBLEM IS STILL HAPPENING. I CALLED FORD CUSTOMER CARE TODAY BECAUSE I RECEIVED A LETTER FROM THEM ABOUT THE PROBLEM. THEY TOLD ME THAT THEY DOCUMENTED THE PROBLEM, BUT BECAUSE THE TRUCK IS OUT OF WARRANTY I WOULD HAVE TO PAY FOR IT TO BE FIXED. IT SHOULD BE NOTED THAT I STARTED TAKING MY TRUCK INTO THE FORD DEALERSHIP BACK IN 2006 TO HAVE THIS PROBLEM ADDRESSED. I HAVE ASKED FORD TO LOOK INTO THIS PROBLEM MAYBE 4 OR 5 TIMES BEFORE I GOT THIS LETTER. I ALSO DID A GOOGLE SEARCH TODAY ABOUT THIS PROBLEM AND YOU CAN SEE THAT MANY PEOPLE POST ONLINE ABOUT THIS VERY PROBLEM. HOPE THIS BECOMES A RECALL SO I CAN KEEP ME AND MY FAMILY SAFE. THANK YOU. *TR

MAJOR FRONT END SHIMMY OR OSCILLATION RESULTING IN TOTAL LOSS OF STEERING AND BRAKING. NEAR CRASH ON SEVERAL OCCASIONS. HAS BEEN CHECKED BY DEALER AND PRIVATE MECHANIC. FORD SAYS IT IS TIRE PRESSURE OR BALANCE MECHANIC SAYS TIRES ARE BALANCED AND INFLATED CORRECT. UNKNOWN WHY THIS HAPPENS? HAS HAPPENED MANY TIMES SINCE NEW AND CHECKED AS MANY TIMES. COST ALOT OF MONEY TO KEEP CHECKING. *TR

TRUCK TENDS TO SHIMMY UNCONTROLLABLY AFTER HITTING BUMP 55 TO 70 MPH, WHEN THE TRUCK HAD 2500 MILES SHOCKS WERE REPLACED HELPED PROBLEM UNTIL 15,000 MILES RETURNED TO FORD. TSB FOR PROBLEM WAS TO INSTALL SHIMMY DAMPER ON LR OF TRUCK. NOT INSTALLED DUE TO CAMPER TIE DOWNS. PROBLEM CONTINUED TO GET WORSE, UNDRIVEABLE ABOVE 55 MPH AT 27,000 MILES. PROBLEM DOES NOT OCCUR WHEN HEAVILY LOADED ( CABOVER CAMPER) TIRE PRESSURE NOT A FACTOR LOADING IS. I ADDRESS THE PROBLEM AND THE SHIMMY WAS RELATED TO ONE PARTICULAR TIRE BEING MOUNTED ON THE FRONT. FURTHER INVESTIGATION REVEALED A BELT SEPARATION IN THE TIRE. ALL THE TIRES HAD SOME DEGREE OF BELT SEPARATION. REPLACED TIRES PROBLEM CURED SOMEWHAT. THE TRUCK STILL EXHIBITS THE TENDENCY TO SHIMMY ESPECIALLY WHEN LIGHTLY LOADED NO MATTER WHAT THE TIRE PRESSURE IS. I AM A ASE CERTIFIED MASTER TECH AND HAVE CURED 2 OTHER VEHICLES. ALL THREE VEHICLES STILL EXHIBIT THE SHIMMY TENDENCY BUT SELF DAMPEN WITH GOOD TIRES. ALL THREE VEHICLES HAD CONTINENTAL 275/70 18 TIRES OEM. THE SHIMMY TENDENCY SEEMS TO BE ENHANCED WITH THE CONTINENTAL TIRES FITTED AND GET WORSE WITH WEAR. THERE SEEMS TO BE A RESONANCE IN TRUCK FRONT SUSPENSION THAT GETS SYNCHRONIZED AS THE TIRES WEAR AND OR GET A BELT THAT IS NOT QUITE TRUE. THE VEHICLES WERE ALL 05 & NEWER F250 OR 350 4X4 SRW WITH THE 275/70 18 TIRES. ALL THREE VEHICLES HAVE BEEN MADE BETTER BY REPLACING THE CONTINENTALS WITH MICHELIN LTX AT 2 TIRES. THEY ALL STILL HAVE IDENTICAL CHARACTERISTICS AS FOLLOWS, T

I HAVE A SEVERE VIBRATION IN THE FRONT END AND STEERING ON MY TRUCK AFTER GOING OVER A BUMP OR DIP IN THE ROAD. I HAVE ONLY NOTICED THIS AT FREEWAY SPEEDS AND IT SEEMS LIKE ONE TIRE HITS THE BUMP OR DIP AND THEN THE OTHER AND IT GOES INTO SEVERE VIBRATIONS FOR SEVERAL SECONDS. *TR

STEERING JERKS TO RIGHT THEN PULLS LEFT AFTER CORRECTION THEN OSCILLATES LEFT AND RIGHT. WON'T CENTER AFTER MAKING A CORNER. OCCURS ALL THE TIME. TIRES WERE ROTATED, BALANCED AND PROPERLY INFLATED AND LUG NUTS TIGHTENED BALL JOINTS AND LINKAGES WERE INSPECTED TO NO AVAIL. *TR

2005 FORD F350 FUEL TANK LINING PEELED CLOGGING TOTAL FUEL SYSTEM CAUSED TRUCK TO BREAKDOWN AND LOOSE POWERSTEERING AT HIGH SPEED. FORD CLAIMS THERE IS NOTHING WRONG WITH GAS TANK BUT THERE HAS BEEN THOUSANDS OF THE SAME INCIDENT. *TR

2005 FORD F-350 SUPER DUTY. WHEN DRIVING AT HIGHWAY SPEEDS AND CROSSING ROUGH BRIDGE ABUTMENTS OR OTHER UNEVEN SURFACES, WHOLE TRUCK BEGINS TO SHAKE UNCONTROLLABLY AND SOMETIMES LASTS FOR SEVERAL MINUTES BEFORE SETTLING DOWN. THIS IS A SEVER PROBLEM AS I'M UNABLE TO STEER OR CONTROL THE TRUCK. I'VE COMPLAINED SEVERAL TIMES TO MY DEALER AND THEY SAY THERE'S NOTHING WRONG WITH THE TRUCK. I DISAGREE AND BELIEVE THIS IS A REAL SAFETY HAZARD. *TR

A WORSENING LATERAL SHIMMY IN THE FRONT SUSPENSION. THIS IS USUALLY BROUGHT ON WHEN AN INCONSISTENCE IN THE ROAD SURFACE IS CROSSED OVER. FORD HAS MADE NUMEROUS ATTEMPT TO CORRECT THIS ON OUR VEHICLE, BUT TO NO AVAIL. CORRECTIONS ONLY LAST A COUPLE OF THOUSAND MILES AND THEN RETURN. *TR

OCCASIONALLY, AT INTERSTATE SPEEDS ONLY (65 - 75 MPH), FRONT END SHAKES VIOLENTLY WHEN CROSSING OVER A SMALL CHANGE IN SURFACE ELEVATION. (FOR EXAMPLE: TRANSITION FROM ROAD SURFACE TO BRIDGE SURFACE) IT IS NOT PREDICTABLE. VEHICLE STEERING IS COMPROMISED AND THE ONLY WAY TO REGAIN PROPER CONTROL IS TO ALLOW THE TRUCK TO SLOW TO APPROXIMATELY 50 MPH WHEN VIOLENT SHAKING WILL SUBSIDE. VEHICLE HAS BEEN INSPECTED BY ONE INDEPENDENT SHOP AND ONE FORD DEALERSHIP (WHERE VEHICLE WAS PURCHASED). NEITHER COULD IDENTIFY THE SOURCE OF THE PROBLEM. TRUCK IS STOCK WITH NO MODIFICATIONS. MOST RECENT EVENTS OCCURRED TWO CONSECUTIVE DAYS TRAVELING INTERSTATE 65 BETWEEN NASHVILLE AND SOUTHERN KENTUCKY. TWO DIFFERENT LOCATIONS, ONE NORTHBOUND AND ONE SOUTHBOUND. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY. THE ENGINE MUST BE TURNED OFF IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY REPLACED THE SWAY BAR. THE FAILURE CONTINUED AND THE DEALER STATED THAT THEY COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER IS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 83,000.

I WAS SLOWING DOWN TO A STOP LIGHT WHEN MY DRIVERSIDE REAR TIRE WAS SMOKING PROFUSELY. I STOPPED TO CHECK THE PROBLEM OUT AND THE REAR BRAKE WAS LOCKED UP. I SPOKE TO WORKERS AT THE FORD DEALERSHIP AND THEY TOLD ME THIS IS A NORMAL OCCURRENCE WITH THIS PARTICULAR MODEL TRUCK. I REPLACED THE DRIVERSIDE REAR CALIPER AND WENT ON MY WAY. TWO WEEKS LATER THE SAME THING HAPPENED TO THE PASSENGER SIDE REAR CALIPER. THE DEALERS I HAVE SPOKEN TO ONCE AGAIN SAID THIS IS A NORMAL OCCURRENCE AND THAT YOU ONLY GET ABOUT A YEAR OUT OF THE CALIPERS. AT OVER $250 A CALIPER THIS IS VERY EXPENSIVE. I DON'T TOW WITH MY VEHICLE OR ABUSE IT IN ANY WAY. I AM STRICT WITH MAINTAINING IT. *TR

I HAVE A 2005 FORD F350 SUPERDUTY(DIESEL). THE TRUCK HAS AN UNCONTROLLABLE FRONT END VIBRATION/OSCILLATION, WHENEVER I HIT A BUMP IN THE ROAD, USUALLY 50MPH OR FASTER. WHEN IT DOES THIS THERE IS NOTHING THAT I CAN DO TO STOP IT. THE ONLY THING THAT MAKES IT GO AWAY IS TO SLOW DOWN, ALMOST TO A COMPLETE STOP. THIS IS VERY DANGEROUS ESPECIALLY ON THE FREEWAY. I HAVE BECOME AFRAID TO DRIVE ON THE FREEWAY. AS I HAVE DONE SOME RESEARCH ON THIS SUBJECT, I HAVE FOUND THAT MANY PEOPLE ARE HAVING THIS PROBLEM WITH THIS MODEL TRUCK. I AM WORRIED ABOUT MY SAFETY AND THAT OF MY FAMILY. *TR

I OWN A 2005 F350 4X4 CREW CAB POWER STROKE DIESEL TRUCK. I HAD THE TRUCK IN FOR SOME WARRANTY WORK JUST BEFORE IT REACHED OVER 100.00 MILES. I HAD TO HAVE INJECTORS REPLACED. I LATER FOUND OUT THAT THE FUEL TANK WAS DELAMINATING. SILVER PARTICLE AND RUST IS GETTING INTO THE INJECTERS AND CLOGGING FILTERS. I BEEN TOLD THAT FORD IS NOT COVERING THIS PROBLEM AT ALL. THE TRUCK NOW HAS 109,000 MILES AND I NO LONGER HAVE A WARRANTY ON THE INJECTOR. THEY NEVER TOLD ME TILL AFTER THE WARRANTY WAS UP THAT THE FUEL TANKS WHERE FAILING. NOW FROM WHAT I CAN TELL EVERYONE IS HAVING PROBLEMS WITH THERE FUEL TANKS. FORD HAS CLAIMED THAT IT IS THE CAUSED FROM BIO-FUELS BUT I HAVE NEVER PUT A DROP OF BIO-FUEL IN MY TRUCK BEFORE. I ALSO BEEN TOLD THAT IF YOU BUY A NEW TANK IT WILL HAVE THE SAME PROBLEM. MY TRUCK WILL NOT RUN ALL THE TIME AND DIES ON ME OFTEN. I HAVE BEEN CHANGING FILTERS AND NOW THE INJECTORS ARE ACTING AS IF THEY ARE DAMAGED. CAN YOU PLEASE HELP? RICK *TR

VEHICLE HAS BEEN DIFFICULT TO START, RUNNING ROUGH AND BUCKS AND OFTEN STALLS WHILE DRIVING. VEHICLE WAS RECENTLY TAKEN TO FORD CERTIFIED SERVICE DEPARTMENT FOR FOREMENTIONED ISSUE, AND WAS TOLD THE FUEL TANK LINER HAS DELAMINATED AND RELEASED PARTICLES CAUSING DAMAGE TO THE FUEL PUMP, EIGHT INJECTORS, AND CLOGGED ALL FILTERS. COST OF REPAIRS ARE $5600.00. SERVICE DEPT. ADVISED THERE IS NO RECALL FOR THIS ISSUE EVEN THOUGH THIS IS A COMMON PROBLEM WITH MANY OF THESE TRUCKS. I HAVE ALSO SEARCHED MANY DISCUSSION FORUMS AND FOUND THERE ARE MANY PEOPLE WHO ARE HAVING SAME ISSUES SOME WHO HAVE REPLACED 3 OR 4 TANKS AND OTHER FUEL RELATED PARTS IN THE SAME TYPE VEHICLES. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 55 MPH, THE CONTACT DROVE OVER A BUMP IN THE ROAD AND THE STEERING WHEEL BEGAN TO SHAKE VERY BADLY. THE BRAKE PEDAL HAS TO BE DEPRESSED IN ORDER TO STOP THE SHAKING. THE FAILURE OCCURS WITHOUT WARNING AND ALMOST CAUSED A CRASH. THE DEALER INSPECTED THE VEHICLE, BUT FOUND NO FAILURES. THE FAILURE MILEAGE WAS 31,000.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. IN JANUARY OF 2006, WHILE DRIVING APPROXIMATELY 35 MPH OR MORE, THE VEHICLE BEGAN TO SHIMMY AND JUMP ON THE OPPOSITE SIDE OF THE ROAD WHEN MAKING LEFT TURNS. THE DEALER STATED THAT BOLTS WERE MISSING AND THE SHOCK MOUNTS FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. HE RETURNED THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE TIRES NEEDED TO BE REPLACED. AFTER REPLACING THE TIRES, A FRONT STABILIZER WAS INSTALLED ON THE FRONT END OF THE VEHICLE; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE HAS NOT BEEN REPAIRED SINCE THE LAST INCIDENT. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS AND THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 61,635 AND FAILURE MILEAGE WAS 4,000. UPDATED 10/21/08. *JB

STEERING WHEEL SHIMMY/OSCILLATION (BACK AND FORTH MOTION), IMMEDIATELY FOLLOWING FRONT OR REAR WHEEL IMPACTS (PAVEMENT JOINTS, FROST HEAVES, ROUGH ROADS, ETC). NEAR LOSS OF CONTROL. MUST PULL OFF OF THE ROAD TO SLOW THE VEHICLE TO STOP SHIMMY. *TR

FRONT END SHAKE VIOLENTLY WHEN A POT HOLE OR SETTLED TRENCH IN THE ROAD IS HIT. IT DOESN'T EVEN HAVE TO BE A DEEP OR LARGE POT HOLE. I HAVE TAKEN MY TRUCK INTO THE SHOP AND THE TECH SAID THE FRONT END COMPONENTS LOOK GOOD (TIE-ROD ENDS ECT...). I HAVE CHANGED THE SHOCKS AND STEERING DAMPER AND IT DID NOT HELP. *TR

ODOMETER 23400 WHEN DRIVING ON ROUGH ROAD, CROSSING RR TRACKS, ECT. VEHICLE FRONT END SLAMS UPPER STOP TO LOWER STOPS VIOLENTLY. YOU MUST SLOW TO APX.30-40 MPH. TO REGAIN CONTROL. THERE IS NO LOSS OF STEERING CONTROL, OR BRAKING JUST A VIOLENT "HOPPING OF FRONT WHEELS" . THE VEHICLE SHAKES WILDLY. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,726.

THE A/C CONTROL DOESN'T SWITCH OFF OF THE DEFROST SETTING. COULD CAUSE THE WINDSHIELD TO FOG UP AND POSSIBLY CAUSE AN ACCIDENT. THE A/C CONSTANTLY BLOWS OUT OF THE DEFROST VENTS. *TR

PULLING OUT OF PARKING AREA INTO MAIN HIGHWAY. ENGINE STALLED ALMOST CAUSING ACCIDENT. EGR COOLER LEAKING FLUID INTO AIR INTAKE CAUSING ENGINE TO STALL. REPLACED EGR COOLER, CLEANED INTAKE SYSTEM. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SD. WHEN ATTEMPTING TO START THE VEHICLE, IT WOULD NOT START. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED WHITE SMOKE. SHE TOOK THE VEHICLE TO THE DEALER ON NUMEROUS OCCASIONS, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURES. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING); THEREFORE, SHE WOULD HAVE TO REPLACE THE FUEL INJECTION CONTROL MODULE AT THE COST OF $1,133.52. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 69,000 AND CURRENT MILEAGE WAS 119,000.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK SO VIOLENTLY THAT HE LOST CONTROL. WHILE DRIVING 65 MPH, HE WAS INCAPABLE OF CONTROLLING THE STEERING. IT WOULD MOVE FROM LEFT TO RIGHT AND HE UNSUCCESSFULLY COMPENSATED FOR THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER TWICE, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE DEALER STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 95,000 AND FAILURE MILEAGE WAS APPROXIMATELY 93,000.

REAR BRAKE DRUM FAILURE - BACKER PLATE OF MY FORD F350 HAS CORRODED TO THE EXTENT THAT THE REAR BRAKE SHOE RETAINER PINS FELL INWARDS AND THE BACK BRAKE SHOE TWISTED AROUND GRINDING IN THE REAR DRUM. UPON HEARING A NOISE SLOWED AND THE REAR WHEEL LOCKED AND SPUN THE TRUCK SIDEWAYS ON THE ROAD. THIS IS A LONG WHEEL BASE,K CREWCAB PICKUP WITH AN 8FT BOX. THE DISC ROTOR COVER HAS ALSO RUSTED THROUGH LEAVING A HOLE ALLOWING SMALL STONES TO JAM BETWEEN THE ROTOR AND BRAKES CAUSING THE VEHICLE TO PULL (ECENTUALLY START TO BRAKE ON ONE WHEEL - PROBLEMATIC ESPECIALLY WHEN BRAKING ON WET OR ICY ROADS. *TR

MY VEHICLE HAS BEEN TO THE FORD SERVICE DEPT. SERVERAL TIMES THIS YEAR FOR A PROBLEM WITH MY ACELERATOR. IF I DECELERATE OR STOP AND GO TO GIVE IT GAS AGAIN THE PEDAL PUSHES DOWN BUT THE VEHICLE WILL NOT ACCELERATE. *TR

I RENTED A TRUCK FROM U-HAUL IN ELK GROVE, CA AT 4:50PM ON 8/28/08. ONCE THE VEHICLE WAS ABOVE 45MPH IT STARTED TO SHAKE VIOLENTLY AND ONCE IT WAS DARK, THE TAIL LIGHTS ON THE RIGHT SIDE WERE SHOWN TO BE NON-FUNCTIONING. THE REPRESENTATIVE DID NOT DO A VEHICLE INSPECTION WITH ME, IN FACT, HE TOOK OFF BEFORE I EVEN PULLED OUT OF THE DRIVE-WAY. I CALLED THE REPAIR SERVICE BECAUSE I FELT THE VEHICLE WAS UNSAFE AND WAS TOLD BY THE MECHANIC THEY SENT OUT THAT THE REAR END WAS COMING APART AND THAT THE POWER BRAKE SYSTEM HAD NO POWER WHEN I CAME TO A COMPLETE STOP. I INFORMED U-HAUL AND THEY INSISTED THAT I STILL DRIVE THE VEHICLE BACK TO THEIR FACILITY. I REFUSED, CITING THAT IT WAS UNSAFE AND ILLEGAL TO DRIVE A VEHICLE WITHOUT THE WORKING TAIL LIGHTS. THEY THEN CHARGED MY CREDIT CARD FOR THE RENTAL AND MILEAGE EVEN THOUGH THE VEHICLE STILL SAT IN MY DRIVE-WAY WITHOUT THEM KNOWING WHAT THAT MILEAGE WOULD BE. *TR

TO BRUCE YORK AND RICHARD BOYD I AM SO THANKFUL SOMEONE IS DOING SOMETHING ABOUT THIS PROBLEM. I KNOW FOR A FACT THIS SITUATION WITH THIS STEERING PROBLEM FAR EXCEEDS ANYTHING FORD IS WILLING TO ADMIT. MY CASE; I HAVE OWNED MY 2005 FORD F-350 KING RANCH 4X4, VIN #, SENSE FEBRUARY 11, 2005. THIS TRUCK HAS EARNED ITS TWO NICKNAMES, RHUBARB EXPRESS AND #!*% PIECE OF #@^%$. THIS TRUCK HAS BEEN NOTHING BUT A NIGHTMARE FOR OUR FAMILY. MY WIFE AND I CAN'T BEGIN TO COUNT HOW MANY TIMES THIS TRUCK HAS GONE OUT OF CONTROL AND LEFT US IN THE DITCH. WE HAVE LOST CONTROL OF THIS TRUCK NEARLY EVERY TIME EITHER ONE OF US HAS DRIVEN IT. TYPICAL SITUATION, WE ARE DRIVING ALONG THE FREEWAY AT A SAFE SPEED. WE MIGHT FEEL A LITTLE BUMP ON THE ROAD THEN THE STEERING WHEEL STARTS TO SHIMMY THEN BEGINS TO PULL FROM YOUR HANDS IN A HARD SHIMMY. FROM THE TIME YOU HIT THE BUMP TO THE TIME THE TRUCK IS RIPPING YOUR HANDS FROM THE STEERING WHEEL IS LESS THE 2 SECONDS. THE OSCILLATIONS ARE MORE THE 90 DEGREES FROM SIDE TO SIDE ON THE STEERING WHEEL. THESE OSCILLATIONS WILL CONTINUE FROM YOUR ORIGINAL DRIVING SPEED UNTIL THE TRUCK IS BROUGHT TO A COMPLETE STOP. THIS USUALLY MEANS DRIVING OFF THE SIDE OF THE FREEWAY OR ROAD ONTO THE SHOULDER. ON MANY OCCASIONS THERE IS NO SHOULDER AND WE HAVE STOPPED IN THE ROAD. ON OTHER OCCASIONS WE HAVE HAD TO STOP IN THE MIDDLE OF THE FREEWAY AS THERE WERE SEMI TRUCKS IN THE SLOW LANE. I MEAN 65 TO 0 MILES AN HOUR IN THE MIDDLE OF A LOS ANGELES FREEWAY! WE ALSO HAVE CO

SHIMMY IN THE FRONT END AFTER TRAVELING OVER BUMPY ROADWAY, CAUSING A TEMPORARY LOSS OF STEERING CONTROL. THE LOSS OF CONTROL CAUSED THE VEHICLE TO TRAVEL INTO THE ONCOMING LANE OF TRAFFIC. PRIMARILY OCCURS OVER 35 MPH. HAPPENED OVER 10 TO 15 TIMES SINCE THE VEHICLE WAS NEW. *TR

08/2007 AT 27,127 MILES FORD F350 SUPERDUTY WAS TAKEN IN TO DEALER FOR REPAIR DUE TO THE FOLLOWING: HESITATION UPON ACCELERATION AND TRANSMISSION CATCHING AND LOUD BANG, LIKE IT IS JERKING INTO GEAR. DEALER REPAIRED UNDER WARRANTY. 08/2008 AT 36,800 MILES (JUST OUT OF WARRANTY) TAKEN IN AGAIN FOR SAME PROBLEM AND DEALER WANT TO CHARGE US TO REPLACE TRANSMISSION. THE VEHICLE HAS NEVER BEEN USED TO PULL TRAILERS OR HEAVY EQUIPMENT SO THERE IS NO REASON FOR THE TRANSMISSION TO BE FAILING WITH SO LITTLE MILEAGE. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 55 MPH AND HIGHER, THE FRONT END OF THE VEHICLE SHAKES VIOLENTLY AND BECOMES UNCONTROLLABLE. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 20,049 AND FAILURE MILEAGE WAS 500.

MY 2005 F350 6.0 DIESEL OVER HEATED, WAS TOLD BY FORD DEALER THAT THE EGR VALVE & EGR COOLER WENT OUT, THEY REPLACED UNDER WARRANTY. ONLY HAVE 56,963 MILES ON TRUCK. WAS ALSO TOLD THAT FORD HAS A LOT OF PROBLEMS WITH THIS. WHY DON'T THEY LET US KNOW ABOUT THIS OR HAVE A RECALL. I WAS ON A MOUNTAIN ROAD AND IT COULD HAVE CAUSED AN ACCIDENT WHEN I LOSS POWER. I'VE ALSO HAD THE NHTSA ACTION # EA08007 HAPPEN TO MY TRUCK 2 TIMES NOW. *TR

I HAVE A 2005 FORD F350 SUPER DUTY, WITH DANGEROUS FRONT END PROBLEMS. WHEN GOING AT HIGHWAY SPEEDS (55-70MPH), AND HITTING A BUMP IN THE ROAD(EVEN WORSE WHILE GOING THROUGH A SLIGHT CURVE) THE FRONT END STARTS TO SHAKE VIOLENTLY. THIS OSCILLATION IS SO STRONG, THAT IT ALMOST YANKS THE STEERING WHEEL OUT OF MY HANDS. THE ONLY THING THAT MAKES IT STOP IS TO SLOW DOWN TO ABOUT 20MPH. VERY DANGEROUS TO DO ON THE INTERSTATE!!! AFTER DOING SOME RESEARCH AND READING SOME OF THE ONLINE FORUMS FOR FORD TRUCK OWNERS, I FIND THAT THIS IS A MAJOR PROBLEM AND ALSO A VERY COMMON ONE TO BOOT. THE MOST WORRISOME PART OF THIS PROBLEM, IS THAT IS VERY UNPREDICTABLE. SOMETIMES I CAN GO A MONTH OR SO WITH NO PROBLEMS. HOWEVER, THIS PAST WEEKEND, IT DID THIS THREE TIMES DURING A 10 MILE TRIP HOME FROM A RESTAURANT. THIS IS A MAJOR PROBLEM THAT FORD MOTOR CO. SHOULD BE RESPONSIBLE FOR CORRECTING. IF SOMETHING IS NOT DONE SOON MANY PEOPLE COULD GET HURT, AND GOD FORBID, BE KILLED. *TR

WHILE DRIVING AT HIGHWAY SPEED (65-70 MPH) I HIT A POTHOLE OR BUMP THE WHOLE FRONT END OF THE TRUCK (2005 FORD F-350) STARTED TO SHAKE VIOLENTLY. I HAD TO SLOW DOWN TO 50 MPH WHERE THE SHAKING STOPPED. I WAS ALMOST REAR ENDED BY A SEMI BECAUSE OF MY SUDDEN DECELERATION. THIS HAS HAPPENED 4 TIMES. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SD. WHILE DRIVING 65 MPH, THE CONTACT LOST CONTROL OF THE STEERING AND THE VEHICLE SWERVED ALL OVER THE ROAD. WHEN DRIVING OVER ROUGH PAVEMENT, A BRIDGE EXPANSION, OR A SLIGHT BUMP, THE STEERING WORSENS. HE HAS TAKEN THE VEHICLE TO THE DEALER FOUR TIMES AND WAS INFORMED THAT THE TIRES NEEDED TO BE ROTATED, THE BUSHING NEEDED TO BE CHANGED, AND THE TIRE PRESSURE WAS INCORRECT. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 36,674 AND FAILURE MILEAGE WAS 10,000. THE ENGINE LIGHT ILLUMINATED. UPDATED 02-12-08 *BF

TL*THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING 40-60 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT STATED THAT HE WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. AS OF JANUARY 2, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THERE IS A RECALL FOR THE ELECTRICAL SYSTEM: WIRING (NHTSA CAMPAIGN ID # 05V270000) HOWEVER, THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 37,000 AND CURRENT MILEAGE WAS 38,757.

BOUGHT F-350 WITH 7200 MILES ON IT. VEHICLE HAS A VIOLENT FRONT END SHAKE WHEN YOU HIT A BUMP. IT IS WORSE AT HIGHWAY SPEEDS AND IT IS SO UNCONTROLLABLE THAT YOU FEEL YOU ARE GOING TO LOOSE CONTROL OF THE VEHICLE. THE ONLY WAY TO STOP IT IS TO SLOW DOWN AND AT HIGHWAY SPEEDS THIS IS NOT WISE. I HAVE TAKEN IT TO THE DEALERSHIP SEVERAL TIMES AND THEY TELL ME IT IS TIRE PRESSURE AND OR TIRES. I HAVE BOUGHT NEW TIRES, HAD FRONT END ALIGNED AND CHECK PRESSURE CONSTANTLY AND IT DOES NOT HELP. I WILL NOT LET OTHERS DRIVE THIS VEHICLE AND ALSO ADVISED THE DEALERSHIP THE VEHICLE IS UNSAFE TO DRIVE. I HAVE ONLY 31,000 MILES ON VEHICLE NOW AND OTHER THAN BUYING A NEW VEHICLE DO NOT KNOW WHAT TO DO NEXT. *TR

OSCILLATION OF FRONT SUSPENSION. MY 2005 F350 HAVE BEEN IN FOR REPAIRS SEVERAL TIMES BOTH BY THE DEALER UNDER WARRANTY AND SINCE BY OTHER VEHICLE SERVICE AGENCIES. IT CONTINUES TO GIVE ME PROBLEMS AND AT ITS WORSE, CAUSED THE VEHICLE TO MOVE SIDEWAYS SLIGHTLY INTO THE NEXT LANE. BASICALLY I HAVE BEEN TOLD THAT ?THIS IS NORMAL? *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 65 MPH, THE VEHICLE SHUT OFF AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND IT WAS TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT COULD NOT WAIT FOR THE WORK TO BE PERFORMED ON THE VEHICLE AND TRADED IT IN FOR A 2008 MODEL. THE CURRENT AND FAILURE MILEAGES WERE 20,392. UPDATED 12/18/07 *TR

2005 FORD F-350 WITH FAULTY INTEGRATED BRAKE CONTROLLER. CONSUMER STATES THAT NO MATTER HOW HARD THE BRAKE PEDAL IS PRESSED SOMETIMES IT DOES NOT SEND A SIGNAL TO THE TRAILER TELLING THE TRAILER TO STOP. *KB THE CONSUMER STATED THE INTEGRATED BRAKE CONTROLLER HAS BEEN REPLACED 3 TIMES. THE BRAKE SWITCH WAS REPLACED, HOWEVER THE PROBLEM REMAINED THE SAME. *JB

FRONT END SHIMMY ON FORD F350 4X4 CREW CAB DULLY, PRODUCTION YEAR 2005. AT ABOUT 40 MPH WHEN THE VEHICLE HITS A BUMP THE FRONT END STARTS TO SHAKE. THE FEED BACK THROUGH THE STEERING WHEEL TRIES TO SHAKE THE STEERING WHEEL OUT OF THE DRIVERS HANDS. THIS VEHICLE HAS HAD THE FRONT STABILIZER SHOCK CHANGED, THE LEFT SIDE DRAG LINK CHANGED AND THE FRONT END RE-ALIGNED. THIS PROBLEM HAS BEEN CONTINUING SINCE THE VEHICLE AS HAD APPROX 40,000 MILES. CURRENTLY THE VEHICLE HAS 90K. I HAVE BEEN TOLD THAT THE SHIMMY IS CAUSED BY THE TIRE PRESSURE, TIRES WORN, FRONT END WEAR, ECT. *TR

I HAVE 2005 FORD F350 6.0L DIESEL. TRUCK STALLS ON THE ROAD AND WILL NOT RESTART. I HAD TRUCK TOWED TO FEDUKE FORD 3 TIMES. WILL NOT FIX BECAUSE THEY CAN'T DUPLICATE PROBLEM. ALMOST HAD SERIOUS CRASH WHEN STALLED, TRACTOR TRAILER ALMOST TOOK ME AND FAMILY OUT. FORD HAD RECALL FOR THIS DEFECT. RECALL#-05S34.NHTSA#-05V270000 I CALLED FORD AND THEY TOLD ME MY VIN# WAS NOT INCLUDED IN RECALL,I TOLD THEM MY TRUCK HAS SAME ISSUE AS RECALL. I NEED HELP. *JB

I HAVE A 2005 FORD 350 SUPERDUTY 6.0 DIESEL TRUCK. I PULL A LARGE 5TH WHEEL UNIT. IT IS WITHIN THE WEIGHT RANGE INDICATED BY FORD. I HAVE INSTALLED A THERMOCOUPLE GAUGE TO MONITOR THE ENGINE EXHAUST TEMPERATURE. I WAS TOLD BY FORD DEALER THAT THE NORMAL EXHAUST GAS TEMPERATURE (EGT) SHOULD BE BETWEEN 750 AND 900 WHILE PULLING THE UNIT. UNDER A NOMINAL HILL CLIMB, I NOTED THE EGT NEVER GOT BELOW 1000, EVEN WHEN THE TRANSMISSION SHIFTED TO A LOWER GEAR. IT WAS HARD KEEPING THE EGT UNDER 1400. I HAD TO TRAVEL AT 55 MPH AND IN 4TH GEAR TO MAINTAIN THE 1000 DEGREE TEMPERATURE BOOST WAS BETWEEN 24 AND 28 PSI. NEAR THE TOP OF A CLIMB, THE TURBO HOSE BLEW. THE DEALER SAID IT WAS A DIRTY GATE VALVE OR DIRT IN THE VANES OF THE TURBO. DURING THE VACATION THEY REPLACED THE GATE VALVE AND THE TURBO. AFTER VACATION AND WITHOUT THE 5TH WHEEL ATTACHED, I NOTED THE EGT, UNDER NORMAL STREET DRIVING, RUNS AT 800 TO 1000 DEGREES. IF THIS IS AN INDICATION OF THE ENGINE/TURBO DESIGN, THIS ENGINE IS DOOMED TO FAIL. I BELIEVE FORD SHOULD HAVE KNOWN THESE ISSUES BEFORE THEY SOLD THESE TRUCKS. I KNOW THE TURBO WILL FAIL AGAIN. IF THERE IS RECOURSE, I WOULD LIKE TO KNOW. *JB

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE LOSES POWER INTERMITTENTLY AND WITHOUT WARNING. THE VEHICLE STALLS WHILE ACCELERATING AND DECELERATING. ONCE IT LOSES POWER, THE VEHICLE IS ABLE TO BE RESTARTED. THE FAILURE OCCURS AT SPEEDS BETWEEN 30 AND 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY CANNOT FIND ANYTHING WRONG. THE CONTACT STATED THAT THE FAILURE OCCURS APPROXIMATELY 20-30 TIMES PER DAY AND IS PROGRESSIVELY GETTING WORSE. THE CURRENT MILEAGE WAS 127,058 AND THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 01-14-08. *KB UPDATED12/12/07. *JB

I PURCHASED A NEW 2005 F-350 . SINCE DAY ONE IT HAS HAD A VIOLENT FRONT END SHAKE. IT DOESN'T MATTER IF YOU HIT A BUMP OR NOT. I WILL NOT DRIVE IT ANY MORE. I HAVE TAKEN IT TO THE DEALERSHIP 15 TIMES AND THE HAVE REPLACED THE STEERING BOX, FRONT COIL SPRINGS, DAMPER, SHOCKS AND ADJUSTED THE TIRE PRESSURE. NOTHING SEEMS TO FIX THE PROBLEM. THEN I TOOK IT TO AN OFF ROAD SPECIALTY STORE AND SPENT $6200.00 ON A 4INCH SUSPENSION LIFT, NEW 35" TIRES ,DUAL STABILIZING BARS AND NEW COIL SPRINGS. THE TRUCK STILL SHAKES , BOUNCES , SHIMMIES AND HOPS. I AM FORCED TO BUY ANOTHER VEHICLE (NEVER FORD AGAIN). I AM VERY CONCERNED FOR THE SAFETY OF EVERYONE ON THE ROAD IF FORD DOES NOT FIX THE PROBLEM IMMEDIATELY. *TR

FIRST TIME TRUCK QUIT ON NORTH I-25, WE WERE DRIVING AND THE TRUCK JUST QUIT, WOULD NOT RECRANK, STRANDED ON THE SIDE OF THE ROAD FOR 8 HOURS, FINALLY A TOW TRUCK TOWED US 80 MILES TO THE NEAREST FORD DEALERSHIP, WE PAID A TOWING BILL OF $250 ALSO 2 DAYS IN THE HOTEL. *TR

2ND TIME WAS WHITE SMOKE COMING OUT EXHAUST, THEN IT OVERHEATED AND OIL WAS MIXED WITH ANTIFREEZE, STRANDED FOR 5 HOURS, TOWED 18 MILES TO NEAREST FORD DEALERSHIP, COST US 4 DAYS IN A HOTEL. *TR

3RD TIME IN LESS THAN A MONTH....WOULD NOT START????? STRANDED FOR 12 HOURS, TOWED 30 MILES TO DEALERSHIP AND PAYING AGAIN FOR A HOTEL AND CAR RENTAL.... *TR