2012 Ford F-250 SD complaints

THIS IS THE 4TH TIME THIS HAS HAPPENED WITH THIS VEHICLE. THE TRUCK FLASHES A CODE "SAFETY SHUT OFF". IT IS RELATED TO THE EGT EXHAUST TEMP SENSOR PART OF THE EMISSIONS CONTROLS. AFTER IT FLASHES THE TRUCK WILL SHUT OFF WITH NO WARNING, NO TIME TO MOVE OUT OF TRAFFIC. THE TRUCK WILL NOT RESTART AND THE STARTER WILL NOT ENGAGE. I HAVE HAD THIS HAPPEN 4 TIMES AND EACH TIME I WAS LUCKY TO AVOID AN ACCIDENT. THIS IS A PROGRAMMING ERROR I BELIEVE AND IS A PROBLEM FORD MUST ADDRESS. SOMEONE IS GOING TO DIE OR BE INJURED IF THIS IS NOT CORRECTED!! I REPEAT THERE WILL BE AN ACCIDENT! PLEASE UNDERSTAND THAT THIS IS PROBLEM THAT IS HAPPENING TO OTHER FORD TRUCK OWNERS. PLEASE RESPOND TO THIS. *TR

STOP SAFELY NOW: WHEN THIS HAPPENS THE ENGINE WILL SHUT OFF AND YOU HAVE TO ROLL AS FAR AS YOU CAN TO HOPEFULLY GET OFF THE HIGHWAY. I AM AN EXPERIENCED MECHANIC AND DRIVER OF "NOT SO GREAT RUNNING VEHICLES" AS I HAVE TEST AND TUNE THEM TO SEE WHAT THE ISSUE IS TO REPAIR THEM. E.G. NO BRAKES, NO POWER STEERING, NON WORKING FUEL PUMPS...ETC. WITH THAT SAID, I DO NOT THINK AN INEXPERIENCED DRIVER OF A NON WORKING VEHICLE WOULD DO SO WELL IN THIS SITUATION AND COULD END UP POSSIBLY HARMING OTHERS AS A RESULT. I JUST KNEW FOR SURE THIS WOULD BE ON THE RECALL LIST FOR SAFETY ISSUES AND TO FIND OUT FORD HAS ISSUED A RECALL FOR "EMERGENCY VEHICLES ONLY". MY QUESTION IS... WHO SAYS A PERSONAL VEHICLE IS NOT EVER GOING TO BE AN EMERGENCY VEHICLE FOR YOUR FAMILY, FRIEND OR A COWORKER. COME ON FORD, IF YOUR CUSTOMERS BUY A 65,000 TRUCK SHOULDN'T THEY HAVE THE COMFORT OF TRUSTING THE VEHICLE WILL NOT STRAND THEM DEAD IN THE MIDDLE OF A HIGHWAY OR STOP RUNNING IF THEY ARE TAKING SOMEONE TO THE ER... FORD DID REPAIR MY TRUCK UNDER WARRANTY, BUT, I THINK THIS COULD HAVE ALL BEEN AVOIDED IF THE RECALL WAS OUT FOR ALL VEHICLES WITH THIS ISSUE. *TR

DRAMATIC WHEEL AND FRONT END WOBBLE WHEN HITTING A BRIDGE TRANSITION. VEHICLE BECOMES UNCONTROLLABLE AND CONTINUES TO SHAKE VIOLENTLY UNTIL VEHICLE COMES TO ALMOST A COMPLETE STOP. I HAD THIS SAME ISSUE IN MY 2005 F250 AND HAD TO CHANGE ALMOST ALL THE COMPONENTS OF THE FRONT END TO FIX. THERE ARE HUNDREDS OF PEOPLE SPEAKING ABOUT THIS ON THE FORUMS AND STATE THAT THERE ARE TSBS THAT COVER THIS BUT THAT THE PARTS FAIL AGAIN IN ABOUT 25K MILES. I PULL A BOAT QUITE OFTEN AND IF THIS WOULD HAVE HAPPENED WITH A TRAILER BEHIND MY TRUCK THERE WOULD HAVE BEEN FATALITIES. AS IT WAS CARS WENT ALL OVER THE INTERSTATE TRYING TO GET AWAY FROM ME. THIS ISSUE HAS BEEN AROUND FOR A LONG TIME AND IT SEEMS THAT IT HAS NOT BEEN ADDRESSED BY THE MANUFACTURE. I LOVE AND NEED MY 3/4 TON TRUCK AND BELIEVE THAT FORD MAKES THE BEST TRUCK, BUT THERE WILL BE DEATHS CAUSED BY THIS, IF NOT ALREADY. NOW I WILL START THE LONG PROCESS OF GETTING THE DEALER TO FIX THE ISSUE. *TR

TL* THE CONTACT OWNS A 2012 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING AT SPEEDS OVER 60 MPH THE FRONT WHEELS OF THE VEHICLE WOULD SUDDENLY BEGAN TO SHAKE AND WOBBLE. THE CONTACT INDICATED THAT THE STEERING WHEEL WOULD ALSO VIBRATE AND THE VEHICLE WOULD BECOME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE STEERING STABILIZER AND THE TRACK BAR BUSHINGS WERE REPLACED BUT THE DEFECT WAS NOT REMEDIED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 22,000.

TL* THE CONTACT OWNS A 2012 FORD F-250 EQUIPPED WITH A SET OF CONTINENTAL CONTITRAC TIRES, SIZE: 275/65/R18. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE THEY STATED THAT THE FRONT DRIVER'S SIDE TIRE EXHIBITED TREAD SEPARATION. THE TIRE WAS REPLACED BUT THE FAILURE OCCURRED ON THE FRONT PASSENGER'S SIDE TIRE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 28,000. THE DOT NUMBER AND VIN WAS UNAVAILABLE. *TR

VEHICLE STALLED AND STOPPED RUNNING IN TRAFFIC ON HIGHWAY 231 IN MONTGOMERY AL. ABOUT AN HOUR AFTER, SECOND INCIDENCE OF VIOLENT FRONT END OSCILLATION [SEE PREVIOUS COMPLAINT (ODI NUMBER) IS: XXX59219. CALLED FORD ROADSIDE ASSIST. I HAVE 125K EXTENDED WARRANTY AND HAD VEHICLE TOWED TO NEAREST FORD DEALERSHIP. THERE WERE NO WARNINGS OF ANY KIND FROM ON BOARD DIAGNOSTIC SYSTEMS . VEHICLE WAS DIAGNOSED WITH "EVIDENCE OF WATER IN FUEL SYSTEM" . THERE WAS NO WATER PRESENT IN SYSTEM , NO "WATER IN FUEL SYSTEM" WARNING LIGHT ,HAS NEVER LIT UP ON THIS VEHICLE , HAD IT CHECKED IN THE PAST ,WAS TOLD WAS FUNCTIONAL], WAS TOLD REPAIRS WERE "NOT COVERED " .ALL SERVICE HAS BEEN DONE TO FORD SPECIFICATIONS AND AT FORD FACILITY. THESE REPAIRS WOULD NOT BE NECESSARY IF THE WARNING SYSTEM WAS OPERABLE . I AM IN A BUSINESS THAT SELLS, OPERATES AND USES DIESELS EVERY DAY AND ALL MODERN DIESELS HAVE WATER IN FUEL SENSORS . CASE IS STILL OPEN WITH FORD CUSTOMER CARE . THIS NEEDS DOCUMENTATION . THERE WOULD HAVE NEVER BEEN AN ISSUE IF THE TRUCKS SYSTEMS WERE OPERATING PROPERLY. THE REPAIRS ARE MORE THAN I CAN AFFORD FOR A TRUCK THAT IS UNDER WARRANTY. THIS IS CLEARLY A SYSTEM FAILURE . *TR

WHILE DRIVING MY TRUCK ON A BUSY SIDE ROAD, THE MESSAGE CENTER FLASHED A WARNING, "STOP SAFE SOON". A AUDIBLE CHIME WAS HEARD AND THE TRUCK SHUT OFF. COMPLETE LOSE OF POWER BRAKES, POWER STEERING. I WAS NOT ABLE TO GET THE TRUCK OFF THE ROAD COMPLETELY SINCE IT HAPPENED SO FAST. TRAFFIC WAS STOPPED IN BOTH DIRECTIONS WHILE WE DID OUR BEST TO PUSH THE 7,500 POUND TRUCK TO THE NARROW SHOULDER. SINCE THE SHOULDER WOULD NOT FIT THE ENTIRE TRUCK, IT WAS BASICALLY HALF IN THE ROAD. TRAFFIC HAS BACKED UP AND WE HAD TO WAIT CLOSE TO AN HOUR FOR A TOW TRUCK. AFTER SPEAKING WITH THE DEALER, HE TOLD ME THE TRUCK HAS A BULLETIN OUT ABOUT A FAULTY EGT EXHAUST GAS TEMPERATURE SENSOR. THIS SMALL SENSOR FAULT SHUTS THE TRUCK DOWN AND WILL NOT ALLOW THE ENGINE TO RUN. *TR