2005 Ford Escape Hybrid complaints

2005 ESCAPE HYBRID BRAKE FAILURE. I TRIED TO STOP AND BRAKES ONLY WENT HALF WAY DOWN. I RELEASED AND PUSHED AGAIN, HAD TO USE EMERGENCY BRAKE TO STOP OTHERWISE I WOULD HAVE GONE THROUGH A STORE FRONT WINDOW. TOOK TO FORD DEALER AND FOUND OUT IT WAS THE MASTER CYLINDER/SOLENOID. PER FORD'S TECHNICAL SERVICE BULLETIN 0585 ISSUED 8/5/05, THIS IS A KNOWN ISSUE CORRECTED BY INSTALLING A REVISED MASTER CYLINDER. THIS COULD HAVE KILLED ME AND THE PEOPLE INSIDE THE BUSINESS. IF THIS IS A KNOWN, VERY DANGEROUS PROBLEM, THERE SHOULD BE A RECALL. *TR

2005 FORD ESCAPE HYBRID - THE CAR WOULD BEGIN TO SKID AND SLIDE WHEN APPROACHING A STOP REGARDLESS OF THE VEHICLE SPEED OR ROAD CONDITIONS. THE ABS WOULD KICK IN AND THE INDICATOR WOULD COME ON TELLING THE DRIVER THAT THE CAR WAS SLIDING. THIS IS A DANGEROUS CONDITION AS THE CAR WOULD NOT STOP WHEN THE BRAKES ARE PRESSED. AFTER INVESTIGATING ONLINE, I DISCOVERED THAT THIS IS A KNOWN PROBLEM WITH THIS MAKE AND MODEL OF HYBRID VEHICLE. MANY OTHER DRIVERS HAVE EXPERIENCED THE SAME THING. THE SUGGESTION WAS THAT THE TONE RINGS WERE CRACKED OR BROKEN. MY REPAIR SHOP DISCOVERED THAT BOTH OF MINE WERE BROKEN AND ONE AXLE NEEDED REPLACED. INTERESTINGLY, WHEN THE MECHANICS TOOK THE CAR ON A TEST DRIVE TO DIAGNOSE THE PROBLEM, THE CAR WOULD REV BEYOND 4 RPMS, THEN THE ENGINE QUIT AND THE DASHBOARD READOUT STATED TO PULL OVER AND STOP THE CAR IMMEDIATELY. THE GAS ENGINE QUIT AND THE CAR WOULD NOT GO OVER 20 MPH. AFTER TURNING THE CAR OFF AND WAITING A FEW SECONDS, THE CAR WAS RESTARTED AND THE COMPUTER/CAR RESET ITSELF AND WOULD RUN AGAIN. THE SAME THING HAPPENED ON AN OPEN HIGHWAY GOING 60 MPH. THE INDICATOR LIGHTS WENT OFF AND THE WARNINGS TO PULL OVER AND STOP THE CAR IMMEDIATELY DISPLAYED. THIS IS A KNOWN ISSUE BY FORD AS THEY HAVE ISSUED DTC C1526. THIS PARTICULAR BLOG (HTTP://BLOG.YAGELSKI.COM/2010/01/MY-FORD-ESCAPE-HYBRID-BRAKE-REPAIR.HTML) EXPLAINS THE PROBLEM AS WELL AS THOSE OF MANY OTHERS WHO ARE ALSO EXPERIENCING THIS ISSUE, WITH GREATER DETAIL AND ACCURACY THAN I CAN. PLEAS

2005 FORD ESCAPE HYBRID - BRAKE FAILURE. CAR HAS NOT BEEN DRIVEN HARSHLY OR IN HARSH CONDITIONS. ON JULY 31ST, APPLIED BRAKES AT STOPLIGHT, ABS LIGHT CAME ON AND BRAKES FAILED. DEALER UNSURE HOW TO FIX. *TR

LOSS OF STEERING IN A FORD HYBRID ESCAPE ELECTRIC STEERING, COMPLETE LOSS OF STEERING IN A TURN AND NO ONE SEEMS TO CARE. *TR

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED WHEN DRIVING AT 65 MPH AND WITHOUT ANY WARNINGS THE VEHICLE WOULD STALL AND THE STOP SAFELY NOW WARNING LIGHT WOULD ILLUMINATE. THE VEHICLE WAS ABLE TO BE RESTARTED WITHIN SECONDS. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WOULD NOT GENERATE ANY DIAGNOSTIC CODES. THE MANUFACTURE ADVISED THEY WERE UNABLE TO PROVIDE ANY ASSISTANCE WITHOUT KNOWING THE EXACT FAILURE BASED UPON THE DEALER'S DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 88,837.

I WAS DRIVING MY 2005 FORD ESCAPE HYBRID APRIL 1, 2010, WEST BOUND ON I-90 IN MASSACHUSETTS BETWEEN STURBRIDGE AND CHICOPEE WHEN THE FIRST INCIDENT HAPPENED. THE "CONTROL MODULE" DISPLAYED A "STOP SAFELY NOW" MESSAGE AND THEN PROCEEDED TO SHUT DOWN THE VEHICLE. I WAS FORCED, WITHOUT POWER, TO TRAVERSE 3 LANES OF HIGH SPEED, HIGH VOLUME TRAFFIC, TO THE SHOULDER. I WAS FRIGHTENED FOR MY LIFE AT THE TIME. SINCE THE FIRST OCCURRENCE, THE SAME "STOP SAFELY NOW" MESSAGE AND VEHICLE SHUT-DOWN REPEATED SEVERAL MORE TIMES, BEFORE I TOOK IT IN TO THE FORD DEALERSHIP WHERE I BOUGHT IT - SUNNYSIDE FORD, IN HOLDEN MA. THEY HAVE HAD IT NOW SINCE APRIL 14TH 2010 AND ARE UNABLE TO REPAIR. AFTER FIRST REPLACING A MOTOR ELECTRONICS (MEC) PUMP, THE PROBLEM HAS GOTTEN WORSE - INDEED, THE VEHICLE WILL NOT DRIVE AT ALL BEFORE RECEIVING THE "STOP SAFELY NOW" AND VEHICLE SHUTDOWN MESSAGE. MY INDEPENDENT ONLINE RESEARCH HAS PROVIDED MUCH INFORMATION FROM OWNERS OF THE SAME FORD ESCAPE HYBRID, WHO HAVE HAD THE SAME OR CLOSE TO THE SAME SET OF PROBLEMS. ON APRIL 30TH 2010, I WROTE A LETTER TO SUNNYSIDE FORD'S SERVICE MANAGER, OUTLINING MY FINDINGS AND ASKING FOR A FORD CERTIFIED HYBRID ENGINEER TO INTERVENE IN MY VEHICLE'S REPAIR. THERE HAVE BEEN MANY, NOW INCLUDING MYSELF, WHO FEEL THE UNDERLYING PROBLEM IS A DESIGN ISSUE. I HAVE ONLY 23,250 MILES ON IT, WAY TOO EARLY FOR THE CAR TO BE HAVING MECHANICAL FAILURE DUE TO USAGE ALONE. ITS THE FACT THAT WHEN THE PROBLEM ARISES, THAT THE CONTROL MODULE (PCM

2005 FORD ESCAPE HYBRID CAR HAS 65,000 MILES ON IT WITH NO HISTORY OF BRAKE TROUBLE. COMING DOWNILL THE ABS/BRAKE LIGHTS CAME ON ALONG WITH AN ALARM AND IMMEDIATE LOSS OF THE BRAKES. HAD TO USE MECHANICAL EMERGENCY BRAKES TO STOP. CALLED DEALERSHIP NEXT MORNING TO TOW IT IN, THEN READ ON LINE TO TRY RESTARTING THE CAR THE NEXT DAY AND THE PROBLEM MIGHT BE GONE. CAR STARTED, NO BRAKE ISSUES APPARENT (NO LIGHTS, BRAKES FUNCTIONAL) SO DROVE IT TO DEALERSHIP FOR REVIEW/REPAIR. TOOK COPIES OF ONLINE RESEARCH SHOWING THIS IS AN ISSUE WITH THE CAR. DEALERSHIP CLAIMED IT WAS THE REAR AIR CONDITIONER (HOLE IN THE EVAPORATOR CORE) - THEY HAD REPAIRED THE AC 4 MONTHS PREVIOUSLY, WHICH ONLY LASTED FOR 6 WEEKS. PLANNED TO HAVE THEM REPAIR IT AT THE 65,000 MILE SERVICE ANYWAY. PAID $1033. DROVE CAR HOME THAT NIGHT AND THE ABS/BRAKE LIGHTS WENT ON, ALARM SOUNDED BUT THIS TIME NOT A TOTAL LOSS OF BRAKES. INSTEAD WHENEVER PRESSURE IS APPLIED TO THE BRAKE PEDAL, THERE IS A LOUD THUMPING NOISE FROM THE FRONT BRAKES AND SHUDDERING THROUGHOUT THE CAR. PLAN IS TO RETURN TO DEALERSHIP AFTER THE WEEKEND AND BRING LATEST RESEARCH SHOWING FAULTY HCU UNITS HAVE BEEN FOUND TO BE AN UNDERLYING CAUSE, WHICH FORD IS DENYING. *TR

1. DRIVING NORMALLY AND THEN BRAKING NORMALLY 2. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES "SLIP" (I.E., THE CAR SLOWS, THEN "SLIPS" FORWARD AGAIN BEFORE THE BRAKES RE-ENGAGE AND STOP THE CAR) OCCURS ONCE OR TWICE IN A 30-MILE STRETCH CONSEQUENCES: IF YOU NEED TO STOP COMPLETELY DUE TO A PEDESTRIAN OR CAR STOPPING IN FRONT OF YOU, THE CAR DOESN'T STOP FULLY. IT SLIDES AFTER YOU'VE PRESSED THE BRAKES AND THE ABS OVERRIDES YOUR BRAKING. 3. NO REPAIR HAS BEEN UNDERTAKEN YET. *TR

WE HAVE EXPERIENCED AN UNUSUAL PROBLEM WITH THE BRAKING SYSTEM IN OUT 2005 FORD ESCAPE HYBRID. THERE HAVE BEEN MAY EPISODES OF THE YELLOW ABS AND THE RED BRAKE WARNING LAMP LIGHTING UP AND THE ALARM SOUNDING OVER THE PAST YEAR. THIS WOULD HAPPEN FOR A COUPLE OF DAYS AND THEN AFTER SHUTTING-OFF THE VEHICLE AND RESTARTING, THE BRAKES RETURNED TO NORMAL OPERATION. WE SPOKE WITH THE SERVICE DEPARTMENT AT OUR DEALERSHIP ABOUT THIS AND BECAUSE THE WARNING LIGHT WASN'T ON AT THE TIME, THEY SAID THERE WAS NOTHING THEY COULD DO TO DETECT THE PROBLEM. THE LAST TIME THIS HAPPENED THE BRAKES REVERTED TO FAIL SAFE MODE REQUIRING A "PEDAL TO THE FLOOR" EFFORT TO SLOW THE VEHICLE TO A SAFE STOP LUCKILY WHILE PULLING INTO OUR DRIVEWAY . AFTER THIS WE HAD THE CAR TOWED TO THE DEALER AND WERE TOLD WE NEEDED A NEW "HCU" UNIT AND MASTER CYLINDER WITH A TOTAL REPAIR COST OF $4K+. I DECIDED TO DO SOME RESEARCH AND DISCOVERED MANY CASES OF THE EXACT SAME THING HAPPENING WITH THE SAME YEAR AND MODEL ESCAPE. WE ARE GOING TO WAIT A FEW DAYS TO THINK BEFORE MOVING FORWARD WITH THE REPAIR. *TR

FORD HYBRID ESCAPE BRAKE LIGHT KEEPS COMING ON. I HAVE TO TURN IT OFF AND THEN BACK ON TO GET THE LIGHT OUT. DEALER SAYS IT'S A GROUND FAULT AND FORD HAS A NEW WIRING HARNESS, BUT I AM REQUIRED TO PAY FOR IT, IT'S AN '05 WITH LESS THAN 8,000 MILES ON IT, YET I AM TO PAY AND FIX FORD'S PROBLEM, AND WE ARE TALKING BRAKES HERE, THAT FORD KNOWS ABOUT AND HAS ALREADY IDENTIFIED AND HAS A FIX FOR. IT NEEDS A RECALL. THE ELECTRIC STEERING HAS ALREADY FAILED ONCE AND HAD TO HAVE A NEW COMPUTER FOR THIS. FORD IS HIDING PROBLEMS WITH THE CAR. *TR

MY 2005 FORD ESCAPE HYBRID HAVE 140,000 MILES ON IT FOR THE PAST 3 WEEKS THE ABS LIGHT AND THE RED TRIANGLE STOP THE CAR SAFELY COME ON WHEN I START THE CAT. I PULL OVER SHUT THE CAR OFF RESTART AND ALL IS WELL UNTIL THE NEXT TIME. *TR

2005 FORD ESCAPE HYBRID. PROBLEM IS FAILURE OF HYBRID REGENERATIVE BRAKE SYSTEM AS DESCRIBED IN FORD'S TECHNICAL SERVICE BULLETIN, TSB 05-8-5 (AUGUST 5, 2005) (NHTSA ID #10017553). PROBLEM HAD OCCURRED SPORADICALLY AFTER THE WARRANTY PERIOD, BUT WITHOUT ANY KNOWN INCIDENT TO HAVE TRIGGERED THE PROBLEM. REPAIR HAS REQUIRED REPLACEMENT OF THE MASTER CYLINDER AND THE BRAKE SYSTEM'S HYDRAULIC CONTROL UNIT ("HCU"). TOTAL COST HAS BEEN ABOUT $7,000. TO SUMMARIZE MY CORRESPONDENCE FROM FORD... "SINCE THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION ("NHTSA") IS NOT CONCERNED (I.E. NOBODY HAS GOTTEN KILLED BY THESE DEFECTIVE BRAKES) THERE IS NO NEED FOR A RECALL. THEREFORE, FORD HAS NO RESPONSIBILITY TO PAY FOR OR DEAL WITH MY PROBLEM." MY STORY IN MORE DETAIL AT HTTP://BLOG.YAGELSKI.COM/2010/01/MY-FORD-ESCAPE-HYBRID-BRAKE-REPAIR.HTML. *TR

TL*THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHEN DRIVING ABOVE 60 MPH THE OVERHEAT INDICATOR ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, THEN THE VEHICLE STALLED. AS A CONSEQUENCE HIS RISK OF A SERIOUS INJURY WAS INCREASED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIANS HAVE BEEN UNABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 70,000. THE CURRENT MILEAGE WAS 79,000. UPDATED 10/29/09 *CN THE PUMP FOR THE COOLING SYSTEM WAS DEFECTIVE. UPDATED 10/29/09.*JB

TL*THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 65 MPH, THE CONTACT NOTICED THAT THE MAINTENANCE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE ELECTRICAL MOTOR WAS OVERHEATING. THE CURRENT AND FAILURE MILEAGES WERE 77,000.

BRAKE SYSTEM FAILURE ON 2005 FORD ESCAPE HYBRID: HIGHWAY DRIVING, NO BRAKING DURING FAILURE - ABS LIGHT COMES ON WITH "SERVICE BRAKE SYSTEM" MESSAGE ON CONSOLE. TOOK TO DEALER WHERE THEY "DIAGNOSED" MASTER CYLINDER FAILURE. REPLACED MASTER CYLINDER. 06 JULY 09 BRAKE SYSTEM FAILURE ON 2005 FORD ESCAPE HYBRID: NORMAL CITY DRIVING UNDER 35MPH ABS LIGHT COMES ON WITH "SERVICE BRAKE SYSTEM" MESSAGE ON CONSOLE. *TR

THE REAR WINDOW OF MY 2005 FORD ESCAPE HYBRID SHATTERED FOR NO APPARENT REASON WHILE I WAS DRIVING IT THIS MORNING. I WAS TRAVELING ON A PAVED ROAD DOING APPROXIMATELY 70 KMS/HOUR. I DID NOT HIT ANYTHING NOR WERE TEMPERATURES EXTREME. THE SOUND WAS LIKE A RIFLE GOING OFF AND GLASS SHATTERED EVERYWHERE. *TR

HAVE HAD THE "SERVICE BRAKE SYSTEM" MESSAGE AND THE DASH "BRAKE" INDICATOR LIGHT GO ON RANDOMLY WITHOUT BRAKING FOR A COUPLE OF MONTHS (BEGAN IN MAY 2008) IT HAS BEEN TO THE DEALER TWICE (IN JUNE 2008) AND IS NOW DOING IT AGAIN. THE DEALER REPLACED AN ELECTRICAL HARNESS THIS FIRST TIME AND CLEANED CONTACTS ACCORDING TO A FORD SERVICE ALERT THE SECOND. I ALSO HAD A SIMILAR PROBLEM IN THE FALL OF 2007. THE "SERVICE BRAKE SYSTEM MESSAGE" APPEARED AND THE DASH "BRAKE" INDICATOR LIGHT CAME ON OVER A THREE WEEK PERIOD FOLLOWED BY THE 4X4 SYSTEM AND ABS SYSTEM MAKING NOISE, JERKING THE CAR SEVERAL TIMES AND THEN SHUTTING DOWN WHILE I WAS DRIVING (NOVEMBER 2007). THIS WAS FIXED BY THE DEALER BUT NOW THE CAR'S INDICATOR LIGHTS ARE TURNING ON AGAIN AND THE PROBLEM DOES NOT SEEM TO ABLE TO FIXED. I AM WORRIED THE BRAKE SYSTEM WILL FAIL AGAIN. *TR

SERVICE BRAKE SYS MESSAGE ON 2005 FORD ESCAPE HYBRID ALONG WITH BRAKE WARNING LIGHT. *TR

2005 FORD ESCAPE NEVER RECEIVED ANY RECALL FOR THE PROBLEM. CONSUMER STATED THAT THE VEHICLE WAS ALMOST IN AN ACCIDENT DUE TO A PROBLEM WITH THE WIRING HARNESS. CONSUMER NEVER RECEIVED ANY RECALL. DEALER TOLD THEM THERE WERE NO RECALLS. *KB

LOUD HIGH PITCHED CYCLICAL SQUEALING NOISE COMING FROM AXLE WHEN TRAVELING 1-40 MPH USUALLY AFTER DRIVING FOR OVER 30 MINUTES. BROUGHT VEHICLE FOR SERVICE ON 03/24/05 WITH 4201 MILEAGE AND MECHANIC DID NOT FIND ANYTHING WRONG. HOWEVER, REMOVED TIRES AND INSPECTED ALL BRAKES. ON 10/13/05 WITH 10119 MILEAGE AGAIN MECHANIC DID NOT FIND ANYTHING. HOWEVER, REMOVED TIRES AND INSPECTED ALL BRAKES. 04/13/06 WITH 16081 MILEAGE INSPECTED VEHICLE AND DID NOT FIND ANYTHING. REMOVED TIRES AND INSPECTED ALL BRAKES. ON 03/23/07 WITH 28565 MILEAGE INSPECTED VEHICLE AND HEARD NOISE FROM FRONT SOFT FRAME, RETORQUED ALL BOLTS. *AK

PROBLEM: SHIFTER GETS STUCK IN PARK AND WOULD NOT T RELEASE WHEN BRAKE PEDAL WAS DEPRESSED. DATES BROUGHT IN FOR SERVICE: 04/11/07 MILEAGE 28972, AND REPLACED STOP SWITCH. ON 04/19/07 WITH MILEAGE 29102 REPLACED SHIFTER ASSEMBLY. ON 05/16/07 WITH MILEAGE 29653 DID NOT FIX IT. *AK

PROBLEM: AIRBAG WARNING LIGHT ON. DATE BROUGHT VEHICLE FOR SERVICE WAS 03/07/06 WITH MILEAGE 15239 AND REPLACED BOTH FRONT AIRBAGS. *AK

COMPLETE BRAKE FAILURE. FIRST TIME IT OCCURRED WAS ON THE INTERSTATE - 65 MILES AN HOUR AND THE BRAKE LIGHT AND THE ABS LIGHT CAME ON AND THERE WAS A BEEP. THERE WERE THEN NO BRAKES AT ALL. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND COAST TO A STOP. TURNED OFF THE TRUCK AND STARTED IT AGAIN AND IT HAD BRAKES. ON THIS LAST INCIDENT, THE SAME THING IN THE SAME ORDER HAPPENED. THANKFULLY, MY WIFE WAS ABLE TO GET THE VEHICLE TO COAST TO A STOP WITHOUT HITTING ANYONE OR ANYTHING. THIS PROBLEM IS VERY DANGEROUS. IT IS INTERMITTENT THUS MAKING IT HARD TO DIAGNOSE. *JB CONSUMER STATED VEHICLE WAS TRADED IN 2015. UPDATED 6/8/18*JB

2005 FORD ESCAPE HYBRID : ELECTRIC POWER STEERING. POWER STEERING FAILED, WHILE IN A TURN TWICE. AND CAME WITHIN INCHES OF HITTING A WALL, BECAUSE IT REVERTED TO MANUAL STEERING. IF NOT FOR QUICK THINKING AND REFLEX'S. I WAS A PASSENGER AND GRABBED THE WHEEL AND WRESTLED IT IN THE TURN TO AVOID THE WALL. TOOK IT TO THE DEALER AND THEY ACTED LIKE IT WAS A NO BIG DEAL. *JB

I OWN A 2005 FORD ESCAPE HYBRID. WHEN I BOUGHT IT (BRAND NEW) I NOTICED AN AIR BAG ISSUE WHERE DURING DRIVING, IF THE PASSENGER MADE A SLIGHT SITTING ADJUSTMENT, THE AIRBAG WOULD DEACTIVATE. SOMETIMES IT WOULD NOT REACTIVATE, OR TAKE A LONG TIME (5, 10 MINUTES). I TOLD FORD ABOUT IT, AND THEY REPLACED THE AIRBAGS SEAT GEL PAD SENSOR. THE SYMPTOM IMPROVED, BUT STILL HAPPENS. MY FIANCE IS 120LBS AND SHE SITS NORMALLY IN HER SEAT. IF SHE MAKES A MOVE TO READJUST (AS ONE WOULD ON A ROAD TRIP, OR LONG DRIVE) THE AIRBAG MAY STILL DEACTIVATE. INITIALLY IT WAS FREQUENT (75% OF THE TIME) HOWEVER NOW IT IS 50/50 (SINCE THE REPLACED GEL PAD). HOWEVER, IT IS TROUBLING TO KNOW THAT WHEN I AM DRIVING, SOMETIMES MY FIANCEE''S AIRBAG IS DEACTIVATED. WE FEEL VULNERABLE THAT THE SAFETY ITEMS WE PURCHASED TO PROTECT US ARE NOT ALWAYS THERE FOR US. I TRIED COMMUNICATING WITH FORD TELLING THEM IT STILL PERSISTS, BUT THEY JUST DON'T "GET IT". I DON'T UNDERSTAND THAT WHEN A PASSENGER SITS IN THE SEAT AND THE CAR KNOWS IT - HOW CAN THE CAR DEACTIVATE THAT AIRBAG WHILE WE ARE DRIVING 60 MPH? THAT SEEMS LIKE A DESIGN FLAW - AS OBVIOUSLY THE PASSENGER CANNOT EXIT THE VEHICLE WHILE THE CAR IS IN MOTION, OR EVEN BEFORE THE DOOR OPENS. IN MY OPINION, IF THE CAR SENSES A PASSENGER WHEN STARTING TO MOVE, THEN THE AIRBAG SHOULD STAY ON - AT LEAST UNTIL IT STOPS MOVING (COMES TO A COMPLETE STOP). SO *MOTION* WOULD BE A CHECK POINT AND NON-MOTION WOULD BE ANOTHER POINT TO *REEVALUATE* - BUT DEFINITELY NOT IN T

THIS REPORT IS FOR THE THIRD OCCURRENCE (THERE HAVE BEEN 2 PRIOR OCCURRENCES IN THE PAST 6-8 WEEKS). THIS VEHICLE HAS ROUGHLY 17,900 MILES AND KEEPS SHUTTING ITSELF DOWN WITHOUT MUCH (IF ANY) WARNING. THIS TIME, I HAD ABOUT 2-4 SECONDS WARNING (WHICH WOULD NOT BE ADEQUATE IF THE VEHICLE HAD BEEN ON A HIGHWAY OR BUSY ROAD). I WAS IN A PARKING LOT ABOUT TO PULL OUT INTO TRAFFIC WHEN THE YELLOW WRENCH LIGHT CAME ON. BEFORE I COULD DO ANYTHING, THE VEHICLE SHUT ITSELF OFF. AT ABOUT 16,000 MILES, THE "HIGH MOTOR TEMPERATURE" WARNING CAME ON. I WAS ABLE TO GET OFF THE HIGHWAY AND GET IT TOWED. THE DEALERSHIP TOLD ME IT WAS A BAD ELECTRIC WATER PUMP AND REPLACED IT. (I WAS LATER TOLD BY THE DEALER THAT THE WATER PUMP THAT FAILED WAS A KNOWN PROBLEM AT FORD - APPARENTLY A TRUCK CARRYING THESE WAS IN AN ACCIDENT AND BOXES OF THESE PUMPS LITERALLY FELL OUT OF THE TRUCK. FORD SUPPOSEDLY TESTED THEM AND DECIDED TO USE THEM ANYWAYS). ABOUT A WEEK LATER, I COULD TELL THERE WAS STILL SOMETHING WRONG WITH THE VEHICLE. (IT HAD BEEN "SURGING" FORWARD WHEN COMING TO A STOP WITHOUT WARNING AND HAD MANY OTHER NOISES/ISSUES THAT WERE A SIGN THAT SOMETHING WAS STILL WRONG). I BROUGHT IT BACK - AND AFTER THEY EXAMINED IT THEY ASSURED ME THAT EVERYTHING WAS FINE. WITHIN 2 WEEKS, WE WERE DRIVING ON THE HIGHWAY WHEN THE "HIGH MOTOR TEMPERATURE" LIGHT CAME ON AGAIN. MY HUSBAND GOT OFF AT THE FIRST EXIT AND TRIED TO GET IT TO THE FORD DEALERSHIP THAT WAS 2 BLOCKS AWAY. UNFORTUNATELY, WITHOUT WARNING, IT

2005 FORD ESCAPE HYBRID, 9500 MILES, DROVE 20 MILES IN 5 DEGREE WEATHER. SHUT CAR OFF FOR 15 MINUTES. WHEN RESTARTED POWER STEERING FAILED. DROVE 5 MILES WITH POWER STEERING OFF. RESTARTED CAR AFTER 2 HOURS. POWER STEERING WORKED FINE. *NM

I PULLED OUT OF A PARKING LOT DRIVING OUR NEW 2005 FORD ESCAPE HYBRID AND APPROACHED THE FIRST INTERSECTION WHEN A MESSAGE FLASHED ON THE DASH "PULL OVER SAFELY NOW." BEFORE I COULD PULL OVER THE ENGINE TURNED OFF. AFTER A FEW TRIES, I WAS ABLE TO MOVE THE CAR ON THE BATTERY POWER THROUGH THE INTERSECTION (VERY SLOWLY) TO A BUSY BUS STOP. I COULDN'T START THE CAR AGAIN RIGHT AWAY. HOWEVER, ON BATTERY POWER AGAIN, I WAS ABLE TO GET BACK TO THE PARKING LOT. WE HAD THE CAR TOWED TO A FORD DEALERSHIP FROM THERE. IT TOOK THEM TWO WEEKS TO FIGURE OUT WHAT WAS WRONG AND FIX THE CAR. WHEN THE INCIDENT HAPPEND, THE CAR HAD 260 MILES ON IT.