2023 Ford Bronco complaints

I have a 2.7l V6 Bronco with an automatic transmission. There is a steep downhill road (22% grade) a couple blocks from my house that ends at a stop sign for a major cross street. I apply the brake pedal to slow down for the stop sign and the Bronco behaves normally and comes to a full stop, but then with no change in brake pedal pressure by me nor any pedal feedback, i notice the Bronco starts creeping forward a few feet, then abruptly stops again. When the Bronco starts creeping downhill and then abruptly stops again, there is no brake pedal feedback or movement, and the engine does not change RPM. The only sound I hear is something that sounds like service brakes releasing pressure then suddenly reapplying full pressure. I compensate by stopping early, so I don’t drift into the intersection, or a vehicle in front of me, or pedestrian. It can startle any pedestrian that starts to cross in front of my “stopped” Bronco and it suddenly starts creeping down on them. I have noticed this for months but have not taken it to a dealer for resolution yet. The problem appears to not happen after I have been driving for a few minutes. Because this is a problem that occurs on hills in the first few minutes of driving, it likely will be hard to demonstrate to a dealership for diagnosis because there are no hills near my local Ford dealership. The incident occurrence date entered below ([XXX]) is just today’s date - this problem has been present for many months, if not since new. Other us

There are reports of Ford Broncos rolling forward under braking, after a full stop. This occurs most often on a hill. To be clear, the brakes are already fully depressed, the vehicle is stopped, and THEN the vehicle suddenly rolls forward while the brakes are depressed, endangering pedestrians and others. This is NOT caused by driver error. Here are some vehicle owner complaints about this issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Ford Bronco. The contact stated that after opening the driver's side door and then closing the door, the passenger's side hard top fractured into several pieces. The dealer was contacted and informed of the failure. The dealer confirmed that the repair would not be covered for free. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the repair would not be covered. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 11,000.

My rear shocks have been corroding on the external resevior attached to the lower shock body and is rusting really bad in the exact place where the manufacturer of this vehicle says that it's breaking down ( rusting ) at. I called the dealership and the service department and they REALLY gave me the impression that they really don't want to repair my vehicle and is why I'm filling this report with NHTSA . I want the dealership of the manufacturer to replace my rear shocks with new shocks and not put RTV sealant and a retention clamp on this external resevior as stated as one of the remedies the manufacturer has listed in a letter sent out to all of it's dealerships about the manufacturers recall on the rear shocks . In the manufacturer's letter it does state that one of the remedies is replacing the shocks but ONLY if the shocks are leaking oil from the shock resevior/ flange damper area . The corrosion on my shocks are bad . The manufacturer is not SERIOIS about fixing this problem and is why I trust NHTSA to help me and thank you NHTSA .

The contact owns a 2023 Ford Bronco. The contact stated that upon starting the vehicle, the message "Parking Brake Fault - Service Now" message was displayed. The vehicle was taken to a local dealer to be diagnosed; however, the contact was informed that further diagnostic test was needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,990.

Rear tailgate on the bronco gives off a very loud rattling noise when driving

I am sending a complaint as I purchased this vehicle brand new from the dealer in June. They have not been able to give me my vehicle because Ford has not come up with a fix on these two recalls. My complaint is how long does Ford have to make this right? They keep extending the recall dates out from a month or so to now 4th quarter. I am paid for a vehicle that I can't use because of Ford's Delay. I am hoping you all as a government agency will give back some feedback and push Ford to fix the issue a bit more timely.

The contact owns a 2023 Ford Bronco. The contact stated that while driving at an undisclosed speed and flat towing an RV, the Flat-Tow mode inadvertently disengaged and the contact smelled a burning odor permeating the interior of the vehicle with the message "Stop vehicle immediately, excessive temperature detected" displayed. The transmission temperature warning light was illuminated. The vehicle was taken to the dealer, who determined that there was damage to the transmission and turbocharger due to the Flat-Tow mode not being engaged properly during towing. The contact was informed that the transmission and turbo charger needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 22-7086. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The contact was later informed that the manufacturer concluded that the disengagement of Flat-Tow mode was the result of user error. The manufacturer declined to cover the cost of the repair. The contact contested the manufacturer’s findings as inconceivable, stating that the Flat-Tow mode was still engaged after arriving at his destination. The failure mileage was 50,200.

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

I was driving on the back of my property and a loud pop and clanking sound occurred right where the rear shocks are ; also there was/is a thin oil film all around the area where the shocks are . FORD is not fixing this problem is why I'm filing this report . I've also tried reaching out to Ford a few times with no success. THIS has been a problem for four years with Ford and no one has held Ford accountable. Lawsuits it seems are the only method that works I hope NHSTA proves me wrong. Sincerely [XXX] , thank you NHTSA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While attempting to back up I was checking my backup camera and it showed that nothing was behind me, as I started to turn while backing up I felt a bump, there was a car right behind me, I couldn’t see it in my mirror and apparently the camera was frozen on my Bronco.

After Avis Ford replaced my seatbelt on the driver’s side, my vehicle began to rattle from underneath the same area and in the front. The seatbelt side was serviced twice, and now the car feels unsafe. The dealership refused to re-inspect and told me to fix it out of pocket. I’m concerned this may be a structural or safety-related defect caused by improper repair.

We have 3 Diono 3QXT car seats in our 2023 Bronco back seat. I noticed today that two of the car seat's vehicle seatbelts were unlatched. The middle car seat and the passenger-side car seat were loose because the securing seatbelt in the Bronco was unlatched. My concern is that one of the car seats activated the seat belt release button in the Bronco. I will monitor my car seats to see if the issue occurs again, but I thought it was important enough to report, in case there are any other similar complaints regarding either the Diono car seat or the Ford Bronco's rear seatbelts.

Engine began to leak air in intake where this is a faulty problem in the previous two models years and is an active recall on them also, 23 Ford Bronco, began to misfire causing to have to get engine replaced

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V273000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The contact stated that several dealers were contacted and informed the contact that the parts were no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Hello, I previously wrote about this problem under ID#116588898 however i feel as though it did not explain what happened correctly. As I was backing out of my garage, I stopped my vehicle putting it in park. After putting my vehicle in reverse and looking in my mirrors I didn't see anything behind me. (a blind spot) I was on an angle. My radio was on and as I proceeded in reverse, I hit a car that was in my driveway. There was no damage to my vehicle however there is about $3900 damage to the car behind me where the spare tire crushed the trunk lid and rear left qtr. At no time did I hear any warning lights, the radio did not lower, and warning lights and sounds were not doing the job of what they were supposed to do. As I thought about it, I'm not even sure the camera was on. I hope this explains this a little better than ID# 11658898. Sorry for the inconvenience of reporting this twice. If the other can be deleted that would be appreciated.

Driving down the interstate with cruise control set to 65mph, I went over a seam in the pavement and the vehicle began to swerve violently. I had to fight to maintain control as the TCS kicked in. I was able to regain control, but upon getting home saw the driver's rear shock has blown and lost all the fluid inside. I have contacted Ford over this near crash and they have told me that my only option on this open recall is to wait or pay to fix this myself. The part is available, I can buy it, but Ford is claiming there is no part available and that patience is the best course of action on this safety issue.

Backing out of the garage then stopping for a minute and putting it in park then in drive afterwards I forgot there was a car behind me in my driveway. After looking in my side mirrors i saw nothing. I hit the vehicle behind me. With the radio on and playing music at no time did the radio lower in sound and the avoidance system sound off. If the avoidance system sounded off the music was louder. I hit the vehicle behind me. I guess i should have turned my head to check behind me but if the sounds were going off it might have helped me to avoid this. I really can't remember either if the camera was on. Usually if the sounds start chirping i look towards the screen. There was no damage to my vehicle only the vehicle i hit. It was my rear spare tire that caused the damage on the other vehicle. I will need to take the family vehicle to get an estimate.

Rear window defogger electrical connection broke off leaving a connector and wire hanging. this could cause an accident from running over someone or something, since you can't see out of a fogged up window.

Battery suddenly went dead, only 7 months old. And 13k miles.

The windshield wipers switch to intermittent without warning. It happens when it is raining and the wipers are on fast or slow. This is distracting because visibility is impacted and you need to fumble with the wiper switch while struggling to see to in an effort to reset the wipers. The reset works for a short while and then goes back to intermittent. There was no crash. The issue is dangerous and annoying… but I do not drive the car often and just reached out to the dealer for a fix. The dealer denies the “customer satisfaction program” as I think that program for this issue expired in December 2024. This is dangerous and should be a recall without an expiration date.

Despite many attempts Ford or any of its local dealers will not assist in providing me a remedy for this issue. This is a rental vehicle that has been decommissioned indefinitely due to the recall. Ford and its dealers will not provide me any fair way to trade the vehicle in for one without a recall. They will not provide me any sort of rebate to counter the discount in value I am getting with any dealer.

Ford has issued a recall for my Bronco but states in the recall that the remedy is anticipated to be available Q3 2025 because parts are not available. We rent our car out on Turo to help offset the payments and now it has been unlisted from Turo because of the recall. I am expected to continue making payments to Ford even though they are stating that it will take 5-8 months for the remedy to be available. This is totally unacceptable on Ford’s part, as they should be able to come up with a remedy and/or parts in a more timely manner. A major corporation like Ford cannot simply issue recalls and then in the same breath say that there is no fix on the horizon for it so the consumer must just deal with it.

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that upon inspecting the rear shock absorbers, the contact became aware that the rear shock absorbers were leaking. The contact had previously noticed that the front shock absorbers were leaking. Additionally, the contact stated while driving at various speeds, the vehicle was bouncing, and the ride was rough. The local dealer was contacted and advised the contact to take photos of the failure and send the pictures to the manufacturer. The manufacturer was contacted, and a case was opened; however, the manufacturer declined to receive the photos of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 12,842. VIN tool confirms parts not available.

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was bouncing while driving. The contact stated that the failure was more pronounced while driving over potholes or on uneven pavement. The dealer was contacted. The manufacturer was made not aware of the issue. The failure mileage was 14,000. VIN tool confirms parts not available.

I am respectfully requesting that MHTAS submit to Ford an alternative Ford parts subsitution to nullify the recall for my Bronco and others to whom this applies. The recall states that replacement parts will not be available until 3rd quarter of 2025. I have been informed by the dealership service manager that these defective rear shocks could be replaced with Ford heavy duty shocks which should exempt the need for a recall. This alternative was submitted to Ford by my dealer and was refused with no explaination.

Factory hard top developing cracks around the corner of the back window on the passenger side. Vehicle is still under the 3-year / 36,000 mile factory warranty. This is the first instance that I have experience with this type of cracking on the factory hard top, and appears to be a known issue to Ford Motor Company since they have issued a General Service Bulletin (23-7004) regarding this type of issue. I am in the process of having the vehicle inspect by local Ford dealership for warranty claim. As a consumer, I do have concern about the long term durability of the hard top or any factory replacements. There are numerous examples of owners that have had multiple hard top replacements under the factory, in some cases 3-4 hard top replacements, prior to exhausting the 3 -year /36,000 mile factory warranty. These cracking issues associated with this hard top can present at different points in the part lifetime; In some cases within a few hundred miles and in others, not until the vehicle has surpassed the factory warranty. Regardless of lifespan, which does appear to be much short than a consumer would expect, The greatest concern I have as a consumer is the potential for this part to suddenly and unexpectedly fail without warning, and potential risk that could have on the vehicles' occupants or other vehicles on the roadway. The inner core of these factory hard tops are made come a cardboard composite material; Ford has stated the cracks are generally cosmetic in nature, but m

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (SUSPENSION); however, the part to do the recall repair was not yet available. The contact stated that the manufactured had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

“Check brake system” notification came up on dash screen. Called dealer and scheduled appt. On the way to the dealer at 70mph the brake pedal locked, pedal was incredibly hard to press and I had to kick the brake pedal to engage the brakes. Brake pedal then felt normal, but has been squishy and hard since that point. Car has 40k miles

Right turn signal in front and rear went out

While traveling out of town the key fob unpaired from the vehicle while stopped at a gas station. We were locked out of the vehicle and the key fob would not unlock the vehicle. We were able to use the app to unlock the vehicle, but the vehicle would not detect the key. We replaced the batter in the key fob, but the issue persisted. Luckily we used Youtube to find a solution, which is to place the key in the bottom of the center console. The key fob will intermittently unpair from the vehicle. I believe this to be a common problem with Ford vehicles given that we found a solution on Youtube and there are a number of online forums where this issue is discussed. Had we not had the app, we would have been stranded hours from home with no way to access our vehicle.

A little over 10000 miles, the "Check Brake System" and "Parking" Brake Lights came on after starting the vehicle. Both Ford and the dealership were contacted and was advised that the coding through the system showed brake fluid level low with possible indication of brake fluid leaking. I asked if the vehicle was safe to drive and neither Ford or the dealership would say either way. The vehicle was taken to the dealership. For the first visit, the vehicle was at the dealership for an entire day and was told by the service advisor there wasn't anything wrong and to take it home. After leaving the dealership, the lights came on again. I took my vehicle to the dealership a second time and it sat there for another two days. Upon picking up my vehicle on the 2nd visit, I was told that the brake fluid level switch needed to be replaced and was resolved. The next day, the light comes on once again while driving. I called the dealership to talk to a service manager and was advised she would have an experienced technician dedicate their time to try and resolve the issue. The vehicle was at dealership for two days and upon pickup of the vehicle was told that the issue was due to an air bubble in the brake line and issue was resolved. I requested that the vehicle be test driven before pickup. Upon five minutes into my drive home, the lights come on once again. I've taken my vehicle to the dealership 3 times now and the dealership has had it for about 6 days during that time without reso

My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could not restart my engine. I ended up being towed to a dealership and am awaiting diagnosis.

My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue but they won't fix it unless it has a catastrophic failure this is unacceptable to me as they just want the vehicle to fall out of warranty when the engine finally gives way and doesn't turn on anymore. There are multiple Ford vehicles that have this issue and Ford does not seem to look into it and fix it please investigate the issues with knocking on all the Ford vehicles with the EcoBoost engines.

See attached document for complaint.

The contact owns a 2023 Ford Bronco. The contact stated while the vehicle was parked, the contact noticed that the hard top was detaching. The vehicle was driven to the dealer but was not diagnosed nor repaired. The manufacturer was notified of the failure. The failure mileage was 45,000.

We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fix the problem. This creates a safety hazard as the engine program can't be updated and could cause damage to the engine and cause it to fail. The dealer then stated that they could not return the vehicle to us with the new tires and wheels we purchased and we had to put our old tires and wheels on. We counted on the old tires for a spare since we already blew one tire out. So in addition to a safety hazard we are currently out $2,500 we spent on new tires and wheels, and now have to purchase another tire of the exact same original size to have a spare, costing us another $300.

I have owned my Bronco for a little over a year now, the Check Brake System light has been coming on the whole time. I have taken it to Ford 4 times now with no result of it being repaired. The dealership has no idea how to fix this issue. From reading other posts, I'm not the only owner experiencing this issue. Being its the brakes that are affected it is a serious issue.

Been having problems with ford pass took vehicle to dealer a week ago and they say that has to do something with the computer of the car so that's mean is something serious computer control every single sensor engin3 etc..

The front flares at highway speeds blow off-Ford has known about this issue and refuses to acknowledge this issue that is very well documented on the Ford Bronco Raptor forums. The do not warranty these even though there is only a few thousand miles, they will not even give a reason why they deny the warranty. This is a safety issue as they are only held on with a few clips. these are oversize flares and the wind from hwy speeds causes the flimsy clips to break making the oversized tire flares to fly off

Front pinion seal leak is detected at where the front drive shaft meets the front differential. Ford attempted to fix it with a pinion seal replacement and the leak is still unresolved, second attempt was done by changing the front differential fluid which also did not resolve the issue. This issue is fairly common amongst bronco owners on forums and will be hard to come to the users’ attention unless the user checks under the vehicle so the problem may be more widespread than reported. The undetected loss of front differential fluid may cause overheating of the front differential over time as the fluid levels become low and potentially cause a lockup at high speed when the vehicle is used in 4A AWD mode. The leak can also be a fire hazard.

Was driving on the highway, when the vehicle popped up the message and it caused either the emergency brake or the automatic collision detection brake to engage. It turned of when I applied gas. The brake issues remain, when I restarted the vehicle after 15 minutes of being off, no brake error was detected evening after pumping the brakes.

While 400 miles from home on vacation, driving in rain, the windshield wipers quit working. As rain picked up from a sprinkle to a more steady rain, I increased the wiper speed. After adjusting a time or two to match the rain coming down, the wipers stopped in the up position. When I change the speeds on the wiper control nothing happens, and it also will not spray washer fluid for the front windshield. The rear wiper and fluid spray work as expected. I checked the fuse identified in the manual, and it looks good. I even swapped the fuse with the rear wiper fuse, and the front ones still do not work. The two dealerships in the area are not able to do much, so I'm facing a 6.5 hour drive home with rain in the forecast and no working windshield wipers on a 1.5 year old vehicle.

The main issue is the airbag light, it is available for inspection. Warning indicator on Ford app states safe to drive without a passenger. Dealer repaired a couple parts got better for a while but continued. Was told they had a wiring harness ordered, but canceled and told to call Ford about a buyback, dealt with Ford, Better Business Bureau about lemon law, but still have not giving me a price for the buyback even though they agreed to buy it back. The vehicle had been in an accident [XXX], it was repaired at the Ford dealer And completed 6/7, was dropped off to have a new aftermarket bumper and winch, lights installed. The first time airbag light came on was [XXX]. At first, I could turn the vehicle off and then back on, and the light would go away, did not get consistent enough to take to dealer till [XXX]. Warning light was on when I dropped it off, which was witnessed by the associate but off by the time it made it to repair bay. Back to ford on [XXX]. Did get a code to change an airbag indicator and sensor in the rear seat. Picked up after repairs February 16. No warning lights, next day the warning light was back on contacted Maria at Ford. Dropped off to Ford again on 2/26. Call the dealer not being done in a timely manner on 3/15. I was told to request a buyback on March 18. The vehicle status changed on 3/20 showing no alerts on my Ford pass app. They had a wiring harness ordered, but canceled. Picked up my vehicle on March 29. I asked if the vehicle failsafe that

3 separate times while driving on the on the interstate doing between 70-75 mph the vehicle completely lost power and an alert was displayed saying “Powertrain Malfunction”, the most recent incident was 07/26/24, before was 06/16/24 and 06/22/24. The vehicle speed dropped down to 35-40 and wouldn’t go any faster, and we had cars behind us, this created a major safety issue for me and my family. We had to pull over on the interstate, turn the car off and back on. We took it into the Ford service department, they said nothing was wrong with it and claimed they reset the computer.

I turned on the car and the airbag light was on. I took to a Ford dealership they said this was not under warranty. The sensor to the airbag is not working and will not go off if I'm actually in an accident. The sensor needs to be properly installed as this was an issue with many Ford Broncos years 2021-2022.

The rear tailgate latch malfunctioned. When the doors are locked using the key fob or auto door locks the tailgate pops open. When you get up to speeds over 11mph triggering the door auto-locks, the tailgate pops open and swings out.

The contact owns a 2023 Ford Bronco. The contact stated that during inclement weather, there was moisture leaking inside the vehicle through the rear windshield. The vehicle had been taken to the dealer on several occasions for the failure. The contact was informed that the rear gasket located by the rear windshield needs to be frequently cleaned and cleared to prevent failure. The dealer also stated that the windshield could not be replaced at the dealer. The manufacturer was also notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 6,000.

When the vehicle downshifts in the lower gears, specifically 3rd to 2nd, and 2nd to 1st, the vehicle will often dangerously accelerate, sometimes doubling the speed for a few seconds. This happens fairly consistently when using the lower gearing offroad mode but I've had it happen in normal modes too. There is a TSB that may deal with the issue (TSB 23-2352), but Ford service has not been cooperative with addressing it because they claim to not be able to reproduce the issue despite my having video evidence. I can provide videos if you'd like. I posted about this issue on a Facebook group and apparently it is widespread. The contact took the vehicle to another dealer who was able to reproduce the issue. The dealer stated that it's not a problem because the new Bronco behaves the same manner.

When driving or breaking at slower speeds, the car feels as if the transmission is “slipping” and the car jerks forward. The same thing happens when braking the car.