2021 Ford Bronco Sport complaints

We were told by the dealership that our 2021 Ford Bronco Sport with only 83,831 has a failed transmission and will need to be replaced.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving 15 MPH in traffic, the accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the vehicle was in Fuel Saver Mode, and the vehicle turned off unexpectedly and failed to restart. The check engine and the battery warning lights were illuminated. The vehicle was towed to a local dealer; however, a diagnostic test was unable to be performed because the parking brake independently engaged whenever shifted into neutral(N). The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 60,400.

The contact owns a 2021 Ford Bronco Sport. The vehicle was taken to Take 5 Oil Change for an oil change, and the contact was informed that the coolant reservoir was empty. The vehicle was taken to Ritchie Automotive, where it was diagnosed that the water pump had failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The manufacturer was not contacted. The failure mileage was approximately 80,000.

Catastrophic engine failure. Sudden. Started my car in the morning. Engine was running rough. Drove about 1/2 mile, engine continued to get worse. Returned home. decided to get engine codes checked. Check engine lights did not come on until this incident. Couldn't keep engine running. Kept trying to restart. Heard weird noise in engine and engine seized. Car had 62,800 miles on it, just over the 5 yr/60,000 warranty. Had the car towed to local Ford dealership. They verified that the engine was seized and that I needed a new engine. They found a lot of coolant in the engine oil along with a lot of metal flakes in the oil. They called it a catastrophic failure and speculated that it could be piston or valve destruction. They did not tear down the engine to determine the cause. They wanted an additional $2,000 to do that. (I kept the old seized engine). This failure could leave the owner stranded and in a very unsafe situation. I don't know what this failure would do to the drivability of the vehicle in traffic or on the highway.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving 78 MPH on the highway, the vehicle unintentionally decelerated and stalled. The vehicle was turned off, restarted, and driven as intended. No warning lights were illuminated. On another occasion, the vehicle stalled with the check engine warning light and other unknown warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 49,700.

If my car can burn up because of this issue, why isn't a replacement part available? Is Ford going to wait till it burns? Seems to me if the problem is known you'd rather fix it than pay out lawsuits.

Dragging, grinding, or rubbing noises from the rear of a 2021 Bronco Sport during low-speed turns are a known issue commonly associated with a faulty rear drive unit (RDU), often appearing around 40k-60k miles. This problem, sometimes described as a, shutter or chattering, is often tied to contaminated fluid caused by a defective or improperly designed vent hose that allows debris to enter the system.

The transmission failed to shift out of a forward gear when selected. Reverse was selected and the vehicle moved forward into a dangerous situation. It resisted stopping as the brakes were applied. There is no "key" to shut off. I was forced to vigorously apply the brakes to avoid a collision with a train. The car is undriveable. The dealer inspection and an independent inspection confirmed that the transmission was failing in a manner that they were both aware of. Replacement cost has proven to be prohibitive. Numerous warning lamps began to illuminate as the problem was discovered.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). While driving at an undisclosed speed, the check engine warning light was illuminated, and the vehicle began shaking and hesitated while accelerating. The vehicle was taken to a dealer, where it was diagnosed, and the failure was associated with DTC: P0456 EVAP (Very Small Leak in EVAP Emission Control System). The vehicle was not repaired. The manufacturer was notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 83,191.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while her husband was driving at 60 MPH and entering the base at 15 MPH, the overheating message was displayed. The driver pulled over, and the light turned off. After exiting the vehicle, he noticed the vehicle had caught fire. The driver disconnected the battery. There were no reported injuries. Another driver stopped with a fire extinguisher to assist with putting out the fire. The fire department was able to extinguish the fire. The vehicle was towed to the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The manufacturer was contacted, who initially was sending an inspector but changed to viewing the photos. The failure mileage was approximately 80,000.

On 2/19/26 the Vehicle would not go in reverse. This is the second time the vehicle has failed to reverse. The vehicle was towed and fixed by don chalmers ford the first time this happened. Now they stated the vehicle was one day past warranty and would not tow/fix issue. I dropped the vehicle at dc ford on Friday 2/20. Today they called and said they think it is the same issue that was fixed with the transmission and would charge 6-8 thousand to fix it. More if we wanted a new transmission. I have read several reports from other consumers that the ford 2021 bronco sport has transmission issues. This vehicle has also had several recalls that I have had fixed by ford. All maintenance has been performed by ford as well. This is an unsafe vehicle and ford has failed to insure its costumers are safe and treated fairly.

Recall 25S76 announced on 7/16/25 is still not completed. Ford states parts still not available. After 7 months, there seems to be no sense of urgency on Ford's part or their supplier's part. when will parts be available?

This vehicle is subject to NHTSA Recall 25V467 involving potential fuel injector cracking and risk of fuel leaking onto the engine, creating a fire hazard. The recall status shows “Remedy Not Yet Available,” leaving the defect unresolved. While driving, the vehicle suddenly displayed an engine overheating warning and immediately entered limp mode, causing abrupt loss of power. The vehicle decelerated unexpectedly and was not able to maintain normal driving speed. This created a dangerous situation in active traffic and required a safety tow. The sudden power reduction could have resulted in a rear-end collision or loss of vehicle control. There were no prior overheating warnings immediately before this incident. The failure occurred abruptly. A warning message appeared at the time of the event, followed by limp mode activation. The vehicle had to be towed to a dealership for inspection. Given that the open recall involves fuel injector cracking and potential fuel accumulation near hot engine components, there is concern that the unresolved recall condition may be related to engine overheating and loss of power. The vehicle remains under an active fire-risk recall, yet no repair remedy is available. Owners are left operating vehicles with a known safety defect and no corrective action timeline. The defect has not been remedied because parts are not available. The vehicle was inspected by a dealership after the overheating event. The primary safety concern is the combination of

Since my car hit 40000 miles it has had nothing but issues. I've had it in the shop at least 10 times. My brakes went out while driving with my [XXX] old, I've had loss of power, smell of exhaust in the cabin for the last 3 months and dealership says it can't be fixed, yesterday I had complete engine failure while on the freeway. Stalled and wouldn't start back up for 5 min. The dealership has never fully fixed anything but has only updated the computer system. I feel very unsafe in this vehicle. We still owe on this vehicle so trading it in is not an option since its not even worth the down payment I put down. It has a fuel injector recall that can't be fixed yet due to not having the parts available. What are we suppose to do if we can't drive the vehicle and can't buy a new one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car check engine light came on, I came home parked the car, in about 5 minutes the cars embarked in flames, the car burned down to the ground. The safety of my entire home (flames caught onto house) and neighbors home was at risk. The burning car was inspected by Fire Chief of Christiana Fire Company

I am experiencing pulsing and lunging while accelerating and cause loss of power and unsafe driving.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at 25 MPH, the vehicle started jerking abnormally. There were no warning lights illuminated. The contact had received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The vehicle was taken to the local dealer, where it was diagnosed, and it was determined that the failure was due to the torque converter. The contact was informed that the transmission fluid needed to be flushed and refilled. The vehicle was not repaired. The manufacturer was contacted and offered to cover 60 percent of the cost of the repair. The failure mileage was approximately 85,000.

LOSS COMPLETE POWER WHILE DRIVING IN RUSH HOUR TRAFFIC. THE DASHBOARD LIT UP BUT NO POWER. THE TOW TRUCK DRIVER TRIED TO CHARGE BATTERY IT WAS NOT THAT. HE WAS DUMBFOUNDED ON WHAT HAPPENED. I SAT IN A VEHICLE ON A BUSY ROAD IN RUSH HOUR FOR OVER AN HOUR BECAUSE i HAD NO SAFE PLACE TO GO. NO WARNING SIGNALS PRIOR, NO NOISES. JUST DIED WHILE IN USE. WAS TOWED TO FORD DEALERSHIP, WAS TOLD 48 HRS LATER ITS DRIVING FINE. THEY CANT FIND AN ISSUE. I AGAIN EXPLAINED I LOSS COMPLETE POWER AND WAS PUT IN A VERY DANGEROUS SITUATION AS WELL AS THE FACT THE TEMPERATURE OUTSIDE WAS IN THE 20S. THE VEHICLE IS STILL AT SERVICE WITH NO ANSWERS, THIS IS THE 4TH SERVICE IN LESS THAN 60 DAYS WITH ISSUES. 2 WHERE TRANSMISSION, 1 WAS A GAS VALVE

My passenger seat heater caught on fire, it was very scary but I was able to put it out with sugar after I pulled over and figured out where the smell was coming from. I took it to my dealer for an inspection but I feel as though they were just trying to cover their side of everything and said “the seat heater did not cause the fire unfortunately”. I am currently in contact with ford and my insurance company. My insurance so far just says they need to investigate more but also that my claim is closed so I’m honestly just at a loss and confused about that and will be reaching out to them again soon. There was no warning at all and I’m glad I caught it when I did because I had glasses cleaner in my passenger side door that is very flammable.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and there was an abnormal sound coming from the vehicle while driving. The contact was unable to determine the location of the sound. The vehicle was taken to the local Auto Zone, where an undisclosed system failure had occurred. No further information was available. The failure mileage was 77,000.

Rear Belt Monitor Fault continues to be an issue. We received this warning light and supposedly had this repaired in October of 2024. The dealership replaced the rear seat belt buckle and reset the codes. This worked for a while but now is happening again. Additionally, we are receiving an airbag warning related to the rear belt monitor. When driving even short distances the warning light appears on screen maybe 5 or 6 times. If a seat belt is disconnected there is no audible warning alert or light to let the driver know that it is not in use. I believe this may be a faulty restraint control module rather than an actual seat belt issue. This is definitely a safety issue regarding restraints and airbags. I've heard of this issue in several Bronco sports, and Mavericks.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was a grinding sound coming from the engine compartment. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, parts for the recall repair were not yet available. The vehicle was taken to a dealer, but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 39,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving approximately 45 MPH, there was a loud scraping sound coming from the engine compartment, and the vehicle jerked abnormally. The vehicle was taken to an independent mechanic, and the failure was associated with the torque converter. The manufacturer was notified of the failure. The failure mileage was 91,000.

The contact owns a 2021 Ford Bronco Sport. The contact received notifications of NHTSA Campaign Numbers: 25V019000 (Electrical System) and 25V467000 (Fuel System, Gasoline). The contact stated that while stopped at a traffic light, there was an abnormal sound coming from underneath the passenger-side of the vehicle, and the vehicle stalled. No warning lights were illuminated. The contact stated that approximately a minute later, the vehicle restarted independently. The contact stated that upon shifting to drive(D) and depressing the accelerator pedal, the vehicle failed to accelerate. The contact shifted to reverse(R), and the vehicle accelerated forward unintendedly. No warning lights were illuminated. The contact test-drove the vehicle in a parking lot, and the failure persisted. The contact stated that while the hand brake was off, the brakes failed to function and seized. The vehicle was towed to the residence, where the contact test-drove the vehicle, and the vehicle operated as intended. However, the contact was concerned about the failure, and the vehicle was towed to the dealer, where the recall repair of the 12-volt battery was completed, and the PCM software update were performed. Additionally, the contact was informed that the DTC codes found indicated that the transmission had failed. The transmission was not repaired due to cost. The contact picked up the vehicle and drove the vehicle back to the residence with no issues. The contact stated that the battery faile

I bought my 2021 Ford Bronco at Morrie's Grand Ledge Ford. I live 10 minutes away from Morrie Ford Okemos. I received a recall notice from Ford Motor Company in August of this year regarding a recall of my specific vehicle. The issue is: "there is a possibility that a fuel injector may crack, which may result in fuel accumulating on the top of the engine. Liquid fuel and/or fuel vapor that accumulates near a hot surface, such as a hot engine or exhaust components may ignite resulting in an under-the-hood fire, increasing the risk of injury." I spoke to the Morrie's Okemos Ford Service Manager and was told "Ford Motor Company has not authorized this repair" and "there's nothing I can do about it." And, then he told me to call Ford Motor Company if I had a complaint. I am out of my mind furious with his response to a required repair that, if not done, could result in "injury" or death. I told the service manager not to return my Bronco until the fuel injectors are replaced, and he gives me back my original ones to prove the service has been completed. Imagine being on the road, going to work, or shopping, or on vacation and having your Bronco Sport start on fire. It's horrifying! So this is the boilerplate and impersonal reply I received from Morrie's Okemos Ford: "Hello, it appears that our team did handle the recall that was affecting your vehicle. This specific recall does have a possible extended policy for fuel injector replacements; however, in order to replace the fuel i

The main symptom is chatter/shudder during low speed turning events. This is due to a faulty rear differential unit. The problem has been confirmed by the dealer. No lamps or other warnings present prior to the failure. The manufacturer has issued multiple TSBs, latest being TSB 25 2351.

My Check Engine Light came on today. I went to Advance Auto Parts and had them check the code (P0171). I took my vehicle to University Ford in Huntington and expressed concern that my fuel injector may cause a fire and I am not comfortable driving the car. They could not diagnose my car or loan me a safe vehicle. They sent me away in an unsafe vehicle. I am to bring the car back in the morning at 8am. I believe this problem is due to the open recall. I also believe all of the damaged parts that my car came with have depreciated the value of my car. I’ve driven Fords exclusively for 20 years. I’ve never had a Ford like this Bronco. Nothing but a nightmare. Tomorrow I hope the dealership fixes my problem or loans me a safe vehicle to pick my grandsons up from school in. Thank you.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The car has been dying repeatedly and then decides to work again, got a new battery and new alternator and it still died. Ford techs had it and drove it for 200 miles and couldn’t replicate the issue. Now less than a month after that the car is completely dead and won’t even start with a jump. We are towing it to ford.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle hesitated after fueling. There was no warning light illuminated. The contact became aware of a gasoline-like odor while entering and exiting the vehicle. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and confirmed that the part was not yet available and that a notification letter would be sent when the part was available. The approximate failure mileage was 69,398.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while starting the vehicle, the message "Faulty Battery and Charging System" flashed on the screen, and the vehicle failed to immediately start. The contact stated that while driving later, several messages, including the messages "Faulty Power Steering" and "Faulty ABS" were displayed, and the vehicle suddenly stalled and failed to restart. The vehicle was towed to the local dealer. The vehicle was not yet diagnosed or repaired. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V267000 (Electrical System, Power Train), which the contact related the failure. The manufacturer was not yet contacted. The failure mileage was 56,000.

For over a year now my car has been making a chatter/shudder noise during low speed turning. The car even shut off completely on me once while turning on a busy highway. There is a recall out (21S02) for my exact car, but built between 10/29/2020-12/11/2020. My build is not within the range however after getting it inspected, I have this exact issue with my axle having lubricant below the minimal fill level. I am worried that I will lose control of my car again and end up in a life-threatening accident.

The contact's son owns a 2021 Ford Bronco Sport. While the contact's son was driving at an undisclosed speed, the driver heard an abnormal grinding sound coming from the rear differential. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed vent tube and water intrusion. The contact was informed that the water intrusion damaged the clutch and gears. The contact was informed that the rear differential and vent tube needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was provided a discount on the cost of the part. In addition, the contact was informed that the failure was a known failure with the model vehicle; however, a recall had not been initiated. The failure mileage was approximately 81,421.

On or about 1/16/2025 I started to have issues battery would get display on the display screen it said to turn off ignition or draw Cato conserve battery and on the ford a] it said all or some options would be disabled to save battery and also the vehicle would shudder upon slow acceleration going forward straightforward I took it to the for inspection and they said it was OK. On 11/19 -2025

While driving my 2021 Ford Bronco Sport, I experienced a strong chemical/fume smell entering the cabin, which caused headache and nausea. I later found that the battery installed in the vehicle had vent holes with visible liquid residue indicating leakage. I did not authorize or install this battery — it appears the battery was changed without my knowledge while the vehicle was in a lender’s possession. This created a serious safety concern because the fumes entered the HVAC system and the vehicle became unsafe to operate. I had the vehicle towed to two separate Ford dealerships. Both refused to inspect the HVAC system or provide a proper safety diagnosis. One dealer admitted the battery had “traces of leaking fluid,” but no diagnostic inspection was performed, and they attempted to close the repair order without documenting the safety concern. I was forced to replace the battery out of pocket just to safely drive the vehicle, but the original leaking battery and the exposure incident should still be investigated. My safety was put at risk, and the dealerships refused proper inspection or remediation.

We purchased this vehicle 02/2025. The salesman stated there was a 5 point inspection and the car was good on fluids oil and brakes. We questioned the rough idle and odd sound the car made and we were told that it was normal. 07/2025 a mobile mechanic came out and repaired a recall. He stated in his notes that the car had an oil leak but he could not determine where. Fast forward to now, my car has been needing oil more than usual since we have got the car. There is a leak but it does not leak on the ground. 11/11/2025, I contacted Big Valley Ford in Stockton CA with concerns about the oil depleting rapidly and how my check engine light comes on which tells me my car has absolutely no oil. I mentioned a recall I saw online 22S21 and Greg (the man I spoke with) stated that was never a recall for my car. He saw the oil separator was replaced in 2022 but it was not for a recall. Greg then told me to make an appointment to bring the car in for a diagnostic and then an oil change. They would then mark my car where the oil is and have me come back in a few days to see how far the oil went down. I asked how much and he said 225 for the diagnostic and 135 for the oil change. Convinced he was lying to me, I called Ford in Tracy, CA and they confirmed there was a recall 22S21 for the oil separator. This car has given me so many problems and this issue clearly was never fixed and they sold me the car this way.

We experienced premature failure of the rear differential, which was told to us to be a "know defect" by our dealership service department. Ford has been made readily aware of this failure point and potential safety concern-- it is well-documented on the internet, including this NHTSA website, yet fails to issue the proper and appropriate recalls. Consumers are expected to foot the bill for this known manufacturing failure point, which is not only inappropriate, but also extremely dangerous. Failure of the rear differential carries a known potential risk of catastrophic failure-- an immediate recall should be issued for any models affected.

On November 11, 2025, my 2021 Ford Bronco Sport experienced a complete brake system failure while driving. The brake pedal suddenly became extremely hard, and there was no braking power at all. The vehicle had to be stopped using the parking brake. This same issue occurred previously in July 2025, when the brake vacuum booster failed and was replaced at the Ford dealership. The problem has now recurred less than six months later. The vehicle is not safe to drive and is available for inspection upon request. My safety and the safety of others were put at risk because the brakes failed completely without warning while the vehicle was in motion. If traffic conditions had been heavier, a collision could have occurred. The issue has not yet been confirmed by the dealership for this most recent occurrence, but the same Ford dealer that repaired it in July handled the prior failure. The vehicle will be towed there again for inspection. No warning lamps or dashboard messages appeared before or during either failure. The only symptom was a sudden loss of brake assist and a hard, unresponsive brake pedal. This appears to be a repeated failure of the brake vacuum or brake assist system, which I understand has been part of a previous Ford recall (21C31) affecting 2021 Bronco Sport models. But my VIN number was not included in the Recall. This is my second reporting and needs to be recalled.

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

When I try to pump gas, I often will start the gas pump and then it will stop after only filling up about a third of a gallon. It doesn’t happen with every gas pump, but it happens frequently enough that it has become very frustrating. I end up not being able to put gas in my car at times and I have to drive to another gas station. I thought there had been a recall on this issue before and it had been resolved, but I have still been experiencing issues.

In 2024, we had our battery replaced in our 2021 Bronco Sport by the Ford certified dealer in response to Recall Number 24S24. We did not have any issues with the previous battery. They replaced the original battery with the AGM battery, which they represented would prevent the issues that necessitated the recall - catastrophic degradation of the battery and complete loss of drive power. In mid-October 2025, my wife experienced unexpected and complete loss of drive power when exiting the interstate in the car, and was stuck in the freeway exit lane as oncoming traffic was exiting at high speeds with minimal time to avoid the stalled car. It was a dangerous situation and the car was almost struck numerous times. No warnings or messages appeared - even the hazards did not work. After about 20 minutes, we were finally able to obtain assistance from a police officer and had the car towed to a Firestone a few blocks away. Firestone confirmed that the AGM battery had failed which caused the complete loss of drive power. They replaced the battery and reprogrammed the car as best they could, but the failure of the battery also destroyed a few computer chips that needed to be replaced by Ford in order to fully reprogram it. We took it to the Ford dealership that initially replaced the battery (10 miles away) the next day, and Ford refused to refund us the costs for towing the car and replacing the battery at the Firestone, claiming our situation did not constitute an "emergency" since

I am submitting this letter to report a potentially widespread safety defect in the 2021 Ford Bronco related to the rear differential assembly. Many owners, including myself, have experienced or are concerned about premature failure of the rear differential under normal driving conditions. This issue can lead to loss of vehicle control and represents a significant safety risk on public roads. Ford Motor Company appears aware of the recurring nature of this defect but has not, to date, issued a recall or extended coverage for affected vehicles. I am requesting that NHTSA investigate this issue as a possible design or manufacturing defect that warrants a formal recall or technical action from Ford. Description of Issue: Premature rear differential failure / widespread owner reports Problem has been reported to Ford Motor Company as well as Sutton Ford Dealership. They did the inspection and diagnosed it. I took my vehicle to that dealership numerous times and told them about the noise I was experiencing and it came back no problems found. This truck has had several recalls and problems since it rolled off the assembly line.

Vehicle is experiencing issues with shuttering from the rear differential and a 4wd fault code with vehicle just out of warranty. Rear differential speed sensor has failed and possibly need entire rear differential unit relaxed I’m told. Also water pump on engine has failed prematurely with ford avoiding responsibility

I took my vehicle into my local ford dealership to get three active recalls remedied. Within 24 hours, my check engine light reappeared as well as "service engine soon" on my way into work. Upon leaving work, the dash lights were gone. They would come and go periodically. After about a week, it would pop up "service engine soon" and within ten minutes, regardless of speed, the RPMs would fly all the way up and the vehicle would act as if I took my foot off of the gas, almost immediately stopping on the highway. I would have to almost immediately pull off of the road and my vehicle would stall, flashing "shift system failure" as well as failing to let me put the vehicle into park or any other gear. Taking it into the shop, they told me that was due to a software bug WHICH THEY JUST "FIXED" with a recall update. They also proceeded to tell me there is metal debris in my oil and I need my transmission rebuilt, quoting me $13,000.

On 7/22/2025 Luther Ford, When asked to drive the vehicle into the service area, the car would not go in to drive. It would not move at all. The service advisor stated we need to have the transmission taken out and taken apart to see what the issue is. He said that the transmission was needing to be replaced, and with the transmission, it is mostly because of an issue with the motor as well, but this cannot be diagnosed until the transmission issue is corrected. The vehicle is still at Luther Ford in Fargo waiting on repair. Ford offered limited financial assistance for this. With myself still owing $5758.38. There have been multiple times that I have requested the dealership drive the vehicle because of the vehicle shifting hard or cutting out when stepping on the gas. On 3/3/2023 20,991 miles I had taken the vehicle in to RM Stoudt in Jamestown, ND because the car was shifting hard, and was cutting out while in low gear/speeds. I do have documentation of this. Nothing was done at this time by the dealership. 10/3/2024 46,277 miles I had the bronco into Devils Lake Cars for an issue with the CV Shaft and warranty work. I also asked them to drive the vehicle because it is STILL not driving correctly and is not shifting correctly and wanted it to be corrected before warranty was up. Nothing was done at the dealership. Before 60,000 I called Devils Lake Cars. I stated that the vehicle is still having issues. I was not going to be able to get to the dealership as I live in a rem

After Ford completed Recall 25S76 on my 2021 Ford Bronco Sport (VIN [XXX] ), which involves replacing high-pressure fuel injectors due to the risk of cracking and fuel leaks, the check engine light returned immediately after the road test. The Ford dealer’s diagnostic confirmed: “After installing high-pressure fuel injectors, cleared codes, road tested and check engine light came back on, performed further P/P test, found high-pressure fuel pump with internal fault which caused a back-pressure concern and took out low-side fuel pump.” The high-pressure fuel pump and low-side fuel pump both failed immediately following the recall injector replacement, which appears to indicate a related fuel-system failure. Ford has stated these are not related issues and has only offered partial goodwill assistance, leaving a significant cost for the customer. Component/system that failed: Fuel system – high-pressure fuel pump and low-side fuel pump (available for inspection). Safety risk: A fuel-system failure can cause stalling or loss of power while driving, increasing the risk of an accident. Confirmed by dealer: Yes – documented in the Ford dealer’s diagnostic notes. Inspected by manufacturer: Yes – Ford dealer completed the diagnostic under Ford’s guidance. Warning lamps or symptoms: Check engine light returned immediately after recall work. No prior symptoms before recall repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car would "skip" while driving. If paused at a light/stop sign, I would hit the gas and the RPMs would increase, but the car would not drive, then it would jerk and go. When driving, my foot would be at a consistent pressure on the gas, but the car would slow down as if I lifted by foot. Then the car would jerk and increase in speed again. There were no warning lights or messages at any of those moments. Due to concerning safety, I was driving to the shop to have it evaluated when I broke down at a stop light. 5 minutes before breaking down, the first light came on with a message in the Ford app stating "powertrain malfunction". When at a light, the automatic break kicked on and would not let me drive. When evaluated at the local dealership they said "there are multiple DTCs for internal transmission issues: DTC P0751/P2700 for a clutch mechanical fault, and P07E4 indicating the vehicle is unable to engage park. The A clutch is dragging, causing it to intermittently creep forward in neutral. The transmission will need to be replaced to correct the issue." The cost to replace it is $10,000+.

Car is shuddering below 35 mph. The RPM gauge is bouncing. Had the transmission fluid drained and filled. Took it to our local repair shop and there are metal shavings in the transmission fluid.

Infotainment screen randomly goes black and/or disconnects from Android Auto.

Keeps cutting off and my screen aswell.