2014 Fiat 500

Defect. Chrysler (FCA US, LLC) is recalling certain 2014-2019 Fiat 500 vehicles. The tire pressure monitoring system (TPMS) warning light may not illuminate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Risk. A TPMS warning light that fails to illuminate can result in the vehicle being driven with improperly inflated tires, increasing the risk of a crash.

Remedy. Dealers will reprogram the TPMS electronic control unit module, free of charge. Owners were mailed July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 80B.

Defect. DLT, LLC. is recalling certain CravenSpeed Fiat Short Shifter shafts sold for use in 2011-2019 Fiat 500 vehicles. The Shifter Shaft may have been improperly manufactured with a through hole for the set screw rather than a blind hole, which may lead to the breakage of the Shifter Shaft.

Risk. If the shifter breaks while the vehicle is in motion, it can increase the risk of a crash.

Remedy. DLT has notified owners, and will provide a complete replacement shifter assembly with an updated shaft, free of charge. The recall began July 24, 2019. Owners may contact DLT customer service at 1-503-505-6886.

Defect. Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. The clutch diaphragm spring may fracture and fail, causing an inability to switch gears.

Risk. If the clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.

Remedy. The remedy for this recall will include the installation of a clutch pedal limiter and a clutch pedal switch. The recall began on November 10, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S34.

Defect. Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Fiat 500 battery electric vehicles manufactured March 8, 2013, to March 7, 2015. The Electric Vehicle Control Unit (EVCU) of the affected vehicles may set a diagnostic trouble code (DTC) that may cause the transmission to unexpectedly shift to neutral.

Risk. If the vehicle unexpectedly shifts to neutral, the loss of drive could increase the risk of a crash.

Remedy. Chrysler will notify owners, and dealers will reprogram the EVCU, free of charge. The recall began June 19, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R20.

Message flashing "service power steering, hill climb and ESC" appears on an average of once a month for the last few years. No loss of control yet, but it came on three starts in a row for the first time. Usually goes away with a second start. Making an appointment with a dealer (Putnam) in Burlingame, Ca to diagnose. $250 to scan and who knows how much to repair.

While traveling on a PA interstate, I hit the brakes to avoid hitting a vehicle in front of me and the wheels locked up. The anti-lock system appeared to not work on my Fiat 500c. I hard steered L and avoided a head on collision hitting the trailer in front of me on the passenger side front of the car.

The contact owns a 2014 Fiat 500. The contact stated that while driving on a neighborhood street at 10 MPH, the transmission experienced an abnormal difficulty in the shifting gear. There was no warning light illuminated. The contact coasted to a stop on the side of the road, and had the vehicle towed to a local independent mechanic to be diagnosed. The contact was informed that the shifter cable assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 50,222.

Dealer saw me that is needing a battery replaced On February 14, I took my fiat 500 E to the dealer for repairs. They then told me that it has a bad main battery problems and has to be replaced they gave me a price of $17,000. As a City employee. We do not make that much money. I bought this vehicle for my daughter. She’s is an A honor student.

The contact owns a 2014 Fiat 500. The contact stated that while driving at an undisclosed speed, the check engine and TPMS warning lights illuminated and the vehicle began to hesitate while accelerating. The vehicle was diagnosed by an independent mechanic and the contact was informed that the powertrain control module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 126,000.

On 1/24/2024 the check engine came on. I went to auto zone the same day and they check the alert. They advised the code possibly could be the spark plugs or ignition coil. The engine light went off on 2/6/2024 and I went to the dealership for them to check the code information. The code that appear PCM P0301-00 Active Cylinder 1 Misfire-

The electric vehicle was previously recalled for battery malfunction but now the OBCM module malfunctioned making the vehicle unable to charge(receive power) leaving me stranded in the charging station and unable to go home. The module is the brain of the battery and should have been replaced with the battery if it's what's causing a similar issue. OBCMFAILED CAUSING BPCMAND EVCU NOT TO WAKE UP . NEED TO REPLACE OBCMAND PROGRAMTO VEHICLE

Vehicle was operating as normal. Came to a stop, shifted car into neutral to rest foot, light turned green, tried to shift back in to gear from a stop and the clutch pressure plate was all wrong, wouldn’t allow the car to go back in to gear. Luckily this happened at 3am and no traffic on the roads. The clutch it self did not go out, other clutch components are the issue. Lots of other fiat owner are all having the same issue. Gives out with no warning.

The contact owns a 2014 Fiat 500. The vehicle had previously been serviced under NHTSA Campaign Number: 16V302000 (Power Train) however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle was not able to downshift and the gear shifter was stuck in neutral(N). The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 35,000.

While seated in my Car on09/03/2021 my vehicle instrument panels warning lights began to flicker and I would describe it as recycle. This occurred in another vehicle that was taken and towed , except for with that vehicle I jump started the vehicle and it restarted perfectly. I am not near the jump start cable, as I am leaving the country for school. I am currently trapped in a strange city. There are people who keep threatening to have the car towed, but I will be repairing the vehicle. the Battery is a Duracell ultra SL147H6M 12 VOLT SERIAL NUMBER 840821033760. The store was a Batteries plus in Los Angeles CA, the store owners were Hattian or East African , at the time it seems that I was the victim of a ubiquitous sexual harassment case, now being investigate. There are other elements to the circumstances as the car being altered possibly in transit by Car Max from Brooklyn Park Minnesota to Memphis Tennessee possibly by Hispanic individuals as the inventory from "Autozone" shows that the car was made in Mexico, not that it was not, it is just that I thought that the guys telling me this were doing so trying to entrap me, so that they could tow the car, that was what they bothered me about the entire time. Then all of the males were not Hispanic, some were other ethnicities, inc. Caucasian. The crime was online

THE CLUTCH IS MAKING HORRIBLE NOISES RATTLING ALL THE TIME SOUNDS LIKE FORK OR PRESSURE PLATE. SEEMS TO BE LINKED TO RECALL BUT THEY FIXED TOO LATE

AIR BAG DID NOT DEPLOY IN THE AMOUNT OF 4 FRONT END WRECKS.*DT *AS

KNOWN RETRACTABLE ROOF ISSUE WHERE THE ELECTRONIC MODULE CONTROLLING THE ROOF MALFUNCTIONS. THIS IMPACTS THE ABILITY TO OPEN THE TRUNK FROM THE OUTSIDE. UPDATE TO MODULE CONDUCTED BY MANUFACTURE IN 2015, HOWEVER ANY EARLIER MODELS ARE AT RISK FOR THIS TO OCCUR. FIX REQUIRES REWIRING PLUS NEW COMPONENT, COST IS $1100

BOTH PASSENGER AND DRIVER WINDOW REGULATORS FAILED ON MY 2014 FIAT 500GQ AT 21250 MILES WITHIN 1 WEEK OF EACH OTHER. THE FIRST FAILURE OCCURRED ON 06/14/2019. I REPLACED THE REGULATOR MYSELF ON 06/22/2019, BUT AS I WAS BACKING OUT OF MY DRIVEWAY I ROLLED UP MY DRIVER SIDE WINDOW AND THE EXACT SAME THING HAPPENED THERE AS WELL! NEEDLESS TO SAY I WAS ABSOLUTELY SHOCKED. THE FAILURE WAS THE SAME FOR BOTH. WHEN ROLLING UP THE WINDOW WHEN THE WINDOW REACHES THE TOP OF THE TRACK AND STOPS AGAINST THE DOOR FRAME THE REGULATOR MOTOR CONTINUES TO RUN FORCING TOO MUCH TENSION ON THE INTERNAL MECHANISM. IN BOTH INSTANCES THE SAME TYPE OF FAILURE OCCURRED ON MY VEHICLE, THIS EXTRA TENSION CAUSED THE CABLE TO BE PULLED FREE FROM THE TOP PULLEY OF THE REGULATOR. A CRUNCHING/GRINDING NOISE IS HEARD AS THE CABLED IS PULLED THROUGH THE INTERNAL STRUCTURE OF THE DOOR, FOLLOWED BY THE WEIGHT OF THE WINDOW FORCING THE WINDOW TO DROP FULLY OPEN. THIS COULD BE VERY HAZARDOUS IF IT HAPPENED WHILE DRIVING DURING ADVERSE WEATHER CONDITIONS AS THE DRIVER HAS NO ABILITY TO RAISE THE WINDOW. BOTH OF THESE INSTANCES OCCURED WHILE THE VEHICLE WAS RUNNING BUT STATIONARY, THE FIRST WHILE I WAS STOPPED AT A RED LIGHT ON A CITY STREET, THE SECOND WHILE IN MY DRIVEWAY.

BOUGHT MY FIAT FROM 1ST OWNER WITH 40,000 MILES ON THE ODOMETER. 2ND DAY OF HAVING THIS CAR MY FAMILY AND I GOT IN OUR VEHICLE & CLUTCH WENT ALL THE WAY TO THE FLOOR & WAS STUCK IN GEAR. 3 MONTHS LATER I FOUND THE RECALL ONLINE FOR MY VIN. WE HAD TO PUT DOT 3 BRAKE FLUID IN EVERY OTHER DAY IN THE BEGINNING AND AT THIS POINT WE PUT IT IN AT MINIMUM 3 TIMES DAILY JUST TO BE ABLE TO SHIFT GEARS PROPERLY. WE MADE AN APPOINTMENT WITH THE FIAT SERVICE CENTER TO HAVE THE RECALL SITUATION RESOLVED BUT THEY HAD TO ORDER THE PARTS WHICH HAS TAKEN 3 WEEKS FOR THEM TO ARRIVE. AFTER A WHILE WE COULD NOT SHIFT INTO 2ND GEAR. ABOUT 2 WEEKS AFTER LOSING 2ND GEAR, WE LOST 3RD GEAR. TRYING TO PULL ONTO THE HIGHWAY AND MERGE INTO TRAFFIC GOING 65 MPH IS VERY DANGEROUS. ALL THE WHILE DEALING WITH THE LOSS OF BRAKE FLUID FOR THE CLUTCH AND NEVER KNOWING WHEN IT WILL JUST NOT SHIFT INTO THE NEXT GEAR. THIS HAS HAPPENED TO US IN THE MIDDLE OF A 4 LANE HIGHWAY WHILE TRYING TO DOWNSHIFT TO TURN. THIS HAS HAPPENED AT STOP SIGNS AND STOP LIGHTS & TURNING IN THE MIDDLE OF TOWN. MY RECALL APPOINTMENT IS FOR 9AM FEBRUARY 26TH. THE EVENING OF THE 25TH I AM LEAVING MY HOME AND EXIT MY DRIVE IN 1ST GEAR WHILE I AM ABOUT TO START UP A HILL, I ATTEMPT TO SHIFT INTO 4TH GEAR-NOTHING. MY GEARSHIFT JUST TURNS IN CIRCLES FREELY. I AM STRANDED BETWEEN TWO HILLS IN PITCH BLACK WITH ONLY DITCHES FOR A SHOULDER. WE COULD NOT GET IT UP THE HILL BEHIND US SO WE PUSHED IT HALFWAY UP THE ONE IN FRONT OF US ACROSS THE ONCO

MY FIAT HAS BEEN HAVING A ISSUE WITH STALLING ON THE ROAD.. I HAVE TAKEN IT TO TWO MECHANICS FOR DIAGNOSTICS BUT NOT ONE CAN FIND THE PROBLEM. IT'S A SAFETY CONCERN

I HAD THE CLUTCH REPLACED ON THE MANUAL TRANSMISSION OF MY 2014 FIAT 500 SPORT DUE TO THE RECALL IN 2016. ON 1/15/19, I LOST USE OF THE TRANSMISSION IN 1ST AND 2ND GEAR JUST BEFORE I GOT HOME. AS THE CAR LIMPED TO THE CURB OUTSIDE MY HOUSE, I COULD SMELL THE CLUTCH BURNING. THE STICK SHIFT FELT COMPLETELY BROKEN AND JUST FLOPPED AROUND ON THE CENTER CONSOLE. I HAD THE VEHICLE TOWED VIA FLAT BED TO MY FIAT DEALER/SERVICE DEPARTMENT AND THE DIAGNOSIS WAS THAT THE SHIFTER CABLES BROKE AND THE CLUTCH DESTROYED. I HAD EVERYTHING REPLACE TO THE COST OF $2,436.60. THE INCIDENT OCCURRED ON A CITY STREET WHILE IN MOTION. THE VEHICLE HAS 40,507 MILES ON THE ODOMETER AND WAS PURCHASED NEW. I FIND IT VERY HARD TO BELIEVE THAT AFTER DUE DILIGENCE ON MY PART TO HAVE THE CLUTCH REPLACED VIA THE RECALL, THE CLUTCH AND TRANSMISSION WOULD HAVE TO BE REPLACED AT SUCH LOW MILEAGE.

I WAS ON A SIDE STREET TURNING L ONTO A BUSY STREET. THERE WAS A LONG LARGE WHITE VAN BLOCKING MY VIEW FROM TURNING. I WAS AT A STOP SIGN. AS I STARTED TO MOVE OUT I DID LOOK BOTH WAYS FIRST. THERE WAS A RED AUTO OVER A BLOCK TO MY LEFT & RIGHT AN AUTO WAS WAY BEHIND TRACKS. WE HAVE A LONG SET OF TRACKS DUE TO BUSY STREET ON A SLANT. AS I TURN, ANOTHER CAR ON MY LEFT HIT MY CAR SO HARD THAT THE SEAT BELT DID NOT HOLD AND I WAS MOVED ALL THE WAY TO THE RIGHT OF CAR & THIS INTENSIFIED IMPACT ON MY LEFT SIDE HEAD TO LEFT DRIVER WINDOW. MY CAR WAS TOTALED. LOC MOMENTARILY, DISORIENTED, TAKEN TO ED VIA AMBULANCE, 2 INCH LACERATION TO SCALP. THIS INITIATED MANY SYMPTOMS OF ILLNESS THAT ED NEVER KNEW ABOUT. CT SHOWED IRREGULARITIES TO LEFT BRAIN, I WAS UNABLE TO WRITE LEGIBLE, MY TEXTS WERE NOT UNDERSTANDABLE, MY SISTER STATED SHE HATED TO CALL BECAUSE I WASN'T MAKING SENSE & I FELL CONTINUOUSLY FOR NO REASON. I CAUSED NUMEROUS BROKEN RIBS DUE TO FALLS & ONCE HAD TO BE HOSPITALIZED DUE TO RIB SEPARATING FROM STERNUM. MY PSYCHIATRIST PUT ME ON ADDITIONAL MEDICATION DUE TO DEPRESSION. HAD PT TO INCREASE MUSCLE TONE IN LEGS . JUST HAD A RADICAL MASTECTOMY 5 MO PREVIOUSLY AND I KNEW I WASN'T RIGHT. THE POLICE REPORT INDICATED OTHER CAR WAS GOING 25MPH WHICH CAN'T BE CORRECT. THE SPEED LIMIT WAS 30MPH & EVERYONE WHO LIVES IN AREA KNOW OUR TRAINS ARE SO LONG THAT YOU WANT TO CROSS THEM BEFORE A TRAIN COMES. MY CAR WAS NEARLY ON TRAIN TRACKS. I KNOW BY TURNING LEFT, I WAS AT FAULT BUT THE

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT REALIZED THAT THE PASSENGER SIDE LOW BEAM HEADLIGHT WAS NOT ILLUMINATED. THE VEHICLE WAS DRIVEN TO BENSON FIAT (500 A W HAMPTON BLVD, GREER, SC 29650) WHERE IT WAS DIAGNOSED THAT BOTH FRONT HEADLIGHT BULBS AND SOCKETS WERE MELTED AND NEEDED REPLACEMENT. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED TWO YEARS AGO BY THE SAME DEALER FOR THE SAME FAILURE. THE VEHICLE WAS REPAIRED BOTH TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,025. *TT*JB

WILL DRIVING ON A CITY STREET I WAS SIDE SWIPED ON DRIVER'S DOOR , FROM SIDE VIEW MIRROR TO END OF LEFT SIDE FENDER AND HOOD. NO AIR BAG DEPLOYED, CAME TO REST AT REAR OF ANOTHER CAR IN FRONT OF OF ME PARKED, NO AIR BAGS DEPLOYED. *DT*JB NO VIN AVAILABLE *JB

WHEN MAKING A TURN, FROM A COMPLETE STOP ONTO A ROAD THAT HAS A SLIGHT INCLINE, THE ESC LIGHT FLASHES ON THE EVIC, AND VEHICLE LOSSES ALL ACCELERATION. THIS IS ON DRY, EVEN, IN PERFECT CONDITION ROADS ACCELERATING FROM 0MPH TO 5MPH, BEFORE IT DROPS BACK DOWN TO 0MPH. HAVE ALMOST BEEN HIT 4X NOW AS CAR WILL NO LONGER ACCELERATE OR EVEN REV AS ONCOMING TRAFFIC IS COMING STRAIGHT FOR ME!

CLUTCH PEDAL STICKS TO FLOOR WHEN RELEASING IT. HAVE TO MANUALLY PULL IT UP. VEHICLE IS STATIONARY, AT A TRAFFIC LIGHT. INCREASING ENGINE RPM SEEMS TO POP THE PEDAL UP (NO LONGER AT THE FLOOR) THERE IS NO BRAKE FLUID LEAK ANYWHERE. SLAVE CYLINDER WAS REPLACED AND BLED PROPERLY.

THE TIRE PRESSURE MONITORING SYSTEM HAS BEEN IN A STATE OF MALFUNCTION SINCE JANUARY 2018, AND STILL IS AS OF THIS DATE 08/30/18. A COMPLAINT HAS BEEN FILED WITH FIAT CHRYSLER WITH NO RESOLUTION- FIAT CHRYSLER WILL NOT EVEN RETURN A PHONE CALL. THE VEHICLE HAS BEEN AT THE DEALERSHIP APPROX. 6 DIFFERENT TIMES FOR THE SAME ISSUE. IN MY OPINION, THIS IS A VERY POOR BUSINESS PRACTICE FOR A VEHICLE MANUFACTURER FOR A FEDERALLY MANDATED SAFETY SYSTEM.

HEAD LIGHTS OUT!

WHEN THE CAR IS STATIONARY IT MAKES ALOUD NOISE AND JUMPS.

TL* THE CONTACT OWNS A 2014 FIAT 500. WHEN THE VEHICLE WAS IN NEUTRAL OR PARK, THE ENGINE WOULD NOT "REV UP" AND, SOMETIMES, WOULD NOT GO INTO GEAR WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CAR PROS FIAT SEATTLE DEALER (700 S GRADY WAY, RENTON, WA) DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

I AM SEEKING ANSWERS FROM FIAT USA. THE TRANSMISSION DESIGN FOR THE FIAT 500L TREKKING IS UNSAFE. I HAVE HAD THREE TRANSMISSION SINCE I PURCHASED THE VEHICLE IN FEBRUARY 2015. THE FIRST TRANSMISSION BROKE APART WHILE I WAS DRIVING THE VEHICLE. THE SECOND AND THIRD STOPPED WORKING AFTER CLUTCH OVERHEATING, SHIFTING, AND COMMUNICATION LOSS. FIAT PLACED A FOURTH TRANSMISSION IN THE VEHICLE AND I REFUSE TO CONTINUE TO DRIVE IT. I HAVE BEEN IN SOME DANGEROUS DRIVING SITUATIONS BECAUSE OF THE FAULTY TRANSMISSIONS. FIAT RESPONSE "WERE GOING TO FIX YOUR CAR REGARDLESS IF YOU AGREE WITH US".

FIAT POP. CONSUMER WRITES IN REGARDS TO UNSUCCESSFUL ATTEMPTS WITH DEALERSHIP CUSTOMER SERVICE SCHEDULING AND REPAIRS OF RECALL 16V-302. *LD UPDATED 09/18/2017*JS

TL* THE CONTACT OWNS A 2014 FIAT 500. WHILE DRIVING AT UNKNOWN SPEEDS, THE HEADLIGHTS AND TAIL LIGHTS WERE TURNED ON, BUT FAILED TO RESPOND. ADDITIONALLY, THE VEHICLE MADE AN ABNORMAL WINDING NOISE, THE STEERING WHEEL WAS DETACHING, AND THE CRUISE CONTROL RANDOMLY ENGAGED. THE VEHICLE WAS TAKEN TO TWO LOCAL DEALERS (FIELDS FIAT LOCATED AT 131 N ORANGE AVE ORLANDO, FL 32801 AND GREENWAY FIAT LOCATED AT 9103 E COLONIAL DR ORLANDO, FL 32817). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS ADVISED OF THE FAILURE AND OPENED CASE NUMBER: 31796806. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2014 FIAT 500. WHILE CLEANING THE VEHICLE, THE KEY FOB ONLY UNLOCKED THE REAR HATCH DOOR; HOWEVER THE HATCH DID NOT OPEN AND THE SPRING AND THE LATCH BECAME DETACHED FROM THE HATCH DOOR. THE HATCH NEVER OPENED AGAIN. THE CONTACT DROVE THE VEHICLE TO EXPRESSWAY DODGE/FIAT IN EVANSVILLE, INDIANA, BUT WAS NOT REPAIRED THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. UPDATED 08/04/17*LJ *JS

TL* THE CONTACT OWNS A 2014 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

CAR HESITATES, UPON ACCELERATES AT TIMES. THIS PRESENTS A SAFETY CONCERN. THE DEALER COULD NOT DUPLICATE. SO THEY REFUSED REPAIR.

FIAT TOLD ME THE PROBLEM RELATED TO THE PRESSURE PLATE WHICH IS NOT RELATED TO THE SAFETY RECALL THAT FIAT ISSUED TO CONSUMER IN 2016. ALSO, THE FAIL SYMPTOM IS THE GEAR IS FAILED TO PROPULSION WHEN ONLY ENGINE IS ON BUT ITS NOT WHEN ENGINE IS OFF. FIAT TECHNICIAN DENY THIS CAUSE BY THE DEFECT OF THE CLUTCH DESIGN. MAY I HAVE EXPERT TO PROVIDE THE ADVICE ON THIS.

TL* THE CONTACT OWNS A 2014 FIAT 500. WHEN THE VEHICLE WAS PLACED INTO FIRST GEAR USING THE CLUTCH, THE RPMS INCREASED AND A BURNING ODOR OCCURRED BEFORE THE VEHICLE WOULD GAIN POWER. WHEN THE VEHICLE WAS SHIFTED INTO SECOND GEAR, IT FAILED TO SHIFT PROPERLY DUE TO THE CLUTCH SLIPPING. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE CLUTCH PRESSURE PLATE AND/OR DISK FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

UNDER COLD CONDITIONS (25 DEGREES F) AND FIRST STARTUP OF THE DAY, WHEN DRIVING VEHICLE IN CITY DRIVING THE VEHICLE'S THROTTLE RESPONSE WILL STOP WORKING INTERMITTENTLY. THE ISSUE TYPICALLY OCCURS AFTER STARTING THE VEHICLE IN THE MORNING IN SUB-FREEZING TEMPERATURES AND THEN DRIVING IN 1ST AND 2ND GEAR TO EXIT RESIDENCE AND ENTER TRAFFIC. UPON STOPPING AT A STOP LIGHT OR SIGN, AND THEN PROCEEDING TO ACCELERATE, THE VEHICLE'S THROTTLE WILL MALFUNCTION AND THE GAS PEDAL WILL NOT RESPOND WHEN PRESSED. THE RPMS WILL DROP TO ABOUT 1300RPMS AND ENTER WHAT FEELS LIKE LIMP MODE MOMENTARILY UNTIL THE GAS PEDAL IS PUMPED A FEW TIMES AND THEN IT WILL RESUME ACCELERATING AS NORMAL. NO ERROR CODES ARE THROWN AND THE LOCAL FIAT STUDIO CANNOT GET THE ERROR TO DUPLICATE. THIS IS A SAFETY ISSUE AS IT TYPICALLY HAPPENS WHILE ENTERING INTO TRAFFIC AND THE VEHICLE BECOMES UNRESPONSIVE. 2014 FIAT 500L TREKKING WITH MANUAL TRANSMISSION. THIS HAS HAPPENED EACH WINTER I HAVE DRIVEN THE VEHICLE. VIDEO EVIDENCE HAS BEEN SUBMITTED TO FIAT WITH NO RESOLUTION. *TR

THE FIAT 500L 2014 MODEL SUDDENLY LOSES POWER. THIS HAS HAPPENED THREE TIMES IN TRAFFIC. THERE IS NO ACCELERATION. ONCE THE CAR IS SHUT OFF AND RESTARTED IT SEEMS TO BE FINE. I TOOK THE CAR TO A LOCAL MECHANIC WHO SAID HE COULD NOT IDENTIFY WHY THIS IS HAPPENING. HE DID SUGGEST THIS MAY BE AN ELECTRIC CONTROL UNIT ERROR WHICH CAUSES THE VEHICLE TO LOSE POWER. APPARENTLY, THIS IS NOT AN EASY FAULT TO IDENTIFY. IF THIS IS THE SOURCE (ECU) IT IS DETECTING AN ERROR WHEN NONE EXISTS. IT IS TELLING THE ENGINE TO LOSE POWER OR STOP TO AVOID AN ACCIDENT. IN NONE OF THE THREE CIRCUMSTANCES WHERE THE CAR LOST POWER WAS THERE ANY NEAR COLLISION. IN THE FIRST OCCASION, I WAS MAKING A LEFT TURN ON A CITY STREET AT A LOW SPEED. THE VEHICLE LOST POWER AND I WAS ABLE TO COAST IT TO THE CURB. AFTER TURNING IT OFF AND RESTARTING IT, IT RAN FINE. IN THE SECOND INCIDENCE ABOUT ONE WEEK LATER, I WAS IN VERY HEAVY DOWNTOWN TRAFFIC IN TAMPA WHEN IT LOST POWER. I WAS NEARLY REAR ENDED. I TURNED THE CAR OFF AND RESTARTED IT AND AGAIN IT RAN FINE. IN THE THIRD INSTANCE, I WAS MAKING A LEFT TURN ONTO A CITY STREET AT A LOW SPEED. THE CAR AGAIN LOST POWER. I TURNED IT OFF. IT RESTARTED AND RAN FINE TO GET ME HOME. I AM NOW FEARFUL OF DRIVING THE VEHICLE AND WILL BE HAVING IT TOWED TO A FIAT DEALER TO SEE IF THEY CONCUR THAT THIS IS AN ELECTRONIC CONTROL UNIT ERROR. *TR

IN MOTION ON A HIGH WAY HIT CAR, AIR BAGS DEPLOYED GIVING ME EXTREME LEG TRAUMA THAT HAS GOTTEN WORSE EACH DAY. THE PAIN IS VERY SEVERE. NONE OF THE MEDICAL CARE PERSONNEL HAS SEE SUCH BAD LEG TRAUMA. *TR

TL* THE CONTACT OWNS A 2014 FIAT 500. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V302000 (STRUCTURE: BODY) WAS RECEIVED IN JUNE. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE VIN WAS INVALID. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TR

TL* THE CONTACT OWNS A 2014 FIAT 500. WHILE DRIVING, THE VEHICLE WOULD SHIFT INTO THE NEUTRAL GEAR AND THE VEHICLE WOULD DECELERATE. THE DEALER DISCOVERED THAT THE AUTOMATIC TRANSMISSION FAILED, BUT THERE WERE NO FAILURE CODES TO VERIFY THE SPECIFIC ISSUE WITH THE AUTOMATIC TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 26,640.

TL* THE CONTACT OWNS A 2014 FIAT 500. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE TRANSMISSION FAILED TO SHIFT INTO FIRST OR SECOND GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE ACTUATOR CLUTCH RELEASE, THE CLUTCH PRESSURE PLATE AND THE DISC WERE REPLACED. THE CONTACT INDICATED THAT APPROXIMATELY 25,000 MILES LATER, THE FAILURE REOCCURRED. THE CONTACT ALSO INDICATED THAT THE VEHICLE HAD EXPERIENCED A HEAD CYLINDER FAILURE AND WAS REPAIRED. NO FURTHER INFORMATION WAS AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 26,000.

TL* THE CONTACT OWNS A 2014 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN). THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

RECEIVED A RECALL NOTICE FOR A REQUIRED REPAIR ON MY MANUAL TRANSAXAL CLUTCH PEDAL. RECALL STATES "CLUTCH COVER DIAPHRAGM SPRING ...MAY FATIGUE AND OR FRANCTURE..POTENTIAL FOR A LOSS OF MOTIVE POWER, COULD CAUSE A CRASH WITHOUT WARNING" WHEN I CALLED BILL LUKE FIAT TO SCHEDULE THIS RECALL REPAIR, I WAS GIVEN A DATE OF FEBRUARY 20!!!! DEALER TOLD ME THEY "COULD ONLY ORDER A FEW PARTS AT A TIME." JEOPARDIZING THE CONSUMER'S SAFETY!!!!

TL* THE CONTACT OWNS A 2014 FIAT 500. WHILE DRIVING VARIOUS SPEEDS, THE GEARS FAILED TO SHIFT OR WOULD DELAY IN SHIFTING WITHOUT WARNING. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE HAZARD WARNING LIGHTS ILLUMINATED AND THE RADIO FAILED. THE DEALER WAS UNABLE TO DUPLICATE ANY OF THE FAILURES. THE RADIO WAS REPLACED ON TWO DIFFERENT OCCASIONS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.

2014, FIAT 500 L POP, HATCHBACK , AUTOMATIC SINCE I BOUGHT THIS CAR IN FEB 2015, WITH 12,000 MILES ON IT, I'VE HAD THE FOLLOWING PROBLEM. WHILE DRIVING THE TRANSMISSION IS SLOW TO RECEIVE THE INTENDED GEAR SELECTION WHICH IN TURN BRINGS A RUNNING CAR ON THE ROAD TO A NEAR COMPLETE STOP WHILE DRIVING. THIS CONDITION CAN CAUSE A FATAL ACCIDENT ON A BUSY HIGHWAY. I HAVE TAKEN IT TO THE FIAT SERVICE STATION NUMEROUS TIME SINCE THE PROBLEM WAS DETECTED. THEY HAVE CHANGED THE TRANSMISSION, REPROGRAMMED VARIOUS MODULES AND THE PROBLEM STILL REMAINS. I HAVE CONTACTED THE FIAT HEADQUARTERS NUMEROUS TIMES AND STATED MY CASE AND TOLD THEM THAT THE SERVICE STATION HAS DONE EVERYTHING AS PER THEIR RECALLS AND THE PROBLEMS STILL EXISTS AND THEY SHOULD REPLACE MY CAR WITCH IS AT 32,000 MILES AND VERY MUCH UNDER WARRANTY. THEY HAVE REFUSED TO DO SO. THEY ONLY WANT TO TRY TO FIX THE PROBLEM BUT AS GOOD AS THAT OFFER SOUNDS , ALL HAS BEEN DONE ALREADY AS PER THEIR REPAIR THEY SUGGESTED IN THEIR RECALL. I HAVE ALL THE REPAIR DOCUMENTS.

IT SUDDENLY LOSES POWER. NOT THE ELECTRICAL COMPONENTS BUT AS IN IT WILL SUDDENLY AND WITH NO WARNING, STOP DRIVING. I CAN BE DRIVING DOWN THE ROAD AND THE ACCELERATION WILL CEASE TO WORK. THERE IS NO SOUND. THE CAR IS RUNNING, THERE AREN'T ANY WARNING LIGHTS, NO INDICATION AT ALL THAT SOMETHING IS WRONG ACCEPT YOU CAN PUSH THE PETAL TO THE FLOOR AND THE CAR WON'T MOVE. OR IT WILL SUDDENLY MOVE VERY VERY SLOWLY. THE SCARIEST INCIDENT WAS ON 11-8-16. I WAS ON OLD ALEXANDRIA TRNPK TRYING TO CROSS 2 LANES OF TRAFFIC ON LEE HWY TO MAKE A LEFT TURN AND GO NORTHBOUND. WHEN THERE WAS A BREAK IN TRAFFIC, I ACCELERATED TO CROSS THE ROAD. AS I WAS CROSSING THE FIRST LANE, MY CAR STOPPED MOVING. I PRESSED FRACTICALLY ON THE ACCELERATOR, MASHING IT TO THE FLOOR WITH NO RESPONSE AS I WATCHED THE ONCOMING TRAFFIC THAT I WAS CURRENTLY SITTING HORIZONTALLY IN FRONT OF; HIT THEIR BREAKS AND SWERVE TO MISS ME. I TURNED THE STEERING WHEEL TO THE RIGHT AS HARD AS I COULD AND LET THE CAR ROLL OVER TO THE SIDE OF THE ROAD. THE TAIL END OF MY CAR WAS STILL SITTING OUT IN TRAFFIC WHEN IT ROLLED TO A STOP. I PUT IT IN PARK AND TURNED IT OFF THEN IMMEDIATELY TURNED IT BACK ON. IT STARTED WITH NO PROBLEM AND THE ACCELERATOR WORKED AS IT SHOULD. I TURNED THE CAR AROUND AND STARTED BACK ON THE ROAD WHEN IT HAPPENED AGAIN. AT THAT POINT I CALLED A TOW TRUCK. IT WAS TOWED TO THE DEALER WHERE IT WAS PURCHASED LESS THAN 2 YRS AGO. AFTER 2 DAYS IN THE SHOP THE DEALER MECHANIC TOLD ME THAT THEY COULDN'T SAY FO

AIR CONDITIONER ELECTRICAL FIRE AND TRANSMISSION NOT SHIFTING OR MOVING WHILE ON IDLE. *TR

TRANSMISSION OVERHEATS, CAUSING AN ALERT ON THE DISPLAY TO PLACE THE TRANSMISSION IN NEUTRAL THEN BACK TO DRIVE. VEHICLE IS UNRESPONSIVE UNTIL THIS IS ACCOMPLISHED AND LACKS POWER. /THIS OCCURED AT VARIOUS SPEEDS FROM 35 TO 5 MPH. ACCORDING TO MESSAGE BOARDS, THIS IS A KNOWN PROBLEM. EVEN RECEIVED INFORMATION FROM THE FIAT DEALER THAT THEY WERE OFFERING SPECIAL INCENTIVES TO REPLACE VEHICLES WITH THIS TRANSMISSION. THIS WAS A SALES PITCH AND NOT AN HONES OFFER TO CORRECT THE PROBLEM.

WHILE IN A DRIVE THROUGH, SMOKE BEGAN POURING FROM THE HOOD. HAD VEHICLE INSPECTED , WAS TOLD THIS IS NORMAL FOR FIAT, AND CLUTCH WAS IN PROCESS OF BURNING OUT. THIS IS A 2014 WITH 20K MILES. THE FACT THAT A CLUTCH BURNING OUT IS "NORMAL" AT THIS LOW OF MILES IS SHOCKING. NOW EXPERIENCING ACETONE SMELL FROM EXHAUST, WHICH I AM STILL BEING TOLD IS A SIGN OF THE 'NORMAL' CLUTCH BURNING SMELL.

WHEN GOING FROM MEDIAN INTO HWY IN 2ND GEAR,NO WARNING CAR DIES WILL NOT START BACK. FIGURED IT WAS RECALL ON CLUTCH SAID THEY CHECKED IT AND THAT IT WAS GOOD BUT VALVES WERE BENT AND NEEDED A NEW HEAD. STILL WON'T START BUT NOW THEY ARE BACK TO CLUTCH/TRANSMISSION. THEY HAVE HAD MY CAR 7 WEEKS AND NEVER RESTARTED IT. I HAD PURCHASED THE VEHICLE AND DROVE IT MAYBE 3 MONTHS WASN'T EVEN TIME FOR AN OIL CHANGE, UNDER 40,000 MILES. WAS TOLD GREAT VECHILE ONLY TRADED DUE TO PREGNANCY. YA, RIGHT. STILL DON'T KNOW WHEN IT WILL BE FIXED AND APPARENTLY I AM GOING TO HAVE TO PAY THOUSANDS MORE AND NOTHING THEY HAVE DONE IN 7 WEEKS HAS WORKED. AFTER LOOKING ONLINE I HAVE SEEN MANY OTHER PROBLEMS. UNHAPPY CUSTOMER.

"TAKATA RECALL" I JUST BOUGHT THIS VEHICLE MAY 2016. IT HAS A HYBRID MANUAL/AUTOMATIC TRANSMISSION. I NOTICED THE PAST COUPLE WEEK MY AUTOMATIC TRANSMISSION WAS ACTING A LITTLE WEIRD. IT'S SHIFTING RIGHT WHEN IT'S IN AUTOMATIC. IT'LL STAY ON THE FIRST GEAR AND REV MY ENGINE RPM TO LIKE 5 O 6, JUST A FEW DAYS AGO I HAD A SCARY INCIDENT I WAS ENTERING THE HIGHWAY MY TRANSMISSION SHIFT DOWN 2 GEARS AND I COULDN'T ACCELERATE; I DROVE OFF THE ROAD. LUCKILY, NO ONE HURTS.