1997 Dorsey Trailer

Routine

Owners filed 1 complaints about this vehicle with federal regulators, most often about the tires. It has been recalled 2 times.

What fails

Component	Reports		Crashes	Fires	Injuries
Tires	1		0	0	0

2 safety recalls

Part 573 reports

Service Brakes, Air › Supply › Hoses, Lines/Piping, and Fittings98V126000

Filed Jun 8, 19981,534 vehiclesDorsey Trailers, Inc.

Defect. VEHICLE DESCRIPTION: PLATFORM TRAILERS AND DOLLIES. THE TUBING INSTALLED IN THE AIR BRAKE SYSTEM ON THE PLATFORM TRAILERS WAS NOT RECOMMENDED FOR USE WITH THE TUBING FITTINGS USED IN THE AIR BRAKE SYSTEM AND THE TUBING INSTALLED ON THE DOLLIES DOES NOT HAVE THE PROPER LABELING AND MINIMUM BURST STRENGTH. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 106, "BRAKE HOSES."

Risk. IF THE TUBING IN THE SUPPLY (EMERGENCY) LINE BURSTS OR BECOMES DISENGAGED FROM A FITTING, THE TRAILER CAN EXPERIENCE A PANIC STOP WITHOUT PRIOR WARNING TO THE DRIVER. IF THE TUBING IN THE CONTROL (SERVICE) LINE BURSTS, THE TRAILER CAN BE OPERATING WITHOUT SERVICE BRAKES.

Remedy. DEALERS WILL INSPECT THE BRAKE SYSTEM TUBING AND REPLACE THE NONCOMPLIANT TUBING INSTALLED IN THE BRAKE SYSTEM.

Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip97V238003

Filed Feb 17, 19982,021 vehiclesDorsey Trailers, Inc.

Defect. VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH ANTILOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL UNITS (ECU) FOR OVER-THE-ROAD TRAILER APPLICATIONS. THE COVER SEAL (O-RING) MAY HAVE BEEN IMPROPERLY INSTALLED IN CERTAIN EASY-STOP TRAILER ABS ELECTRONIC CONTROL UNITS. AN INCORRECTLY INSTALLED SEAL COULD PERMIT WATER TO ENTER THE ECU CAUSING A FAULT TO DEVELOP. THIS WILL CAUSE THE VEHICLE'S TRAILER ABS WARNING LAMP TO ILLUMINATE IMMEDIATELY WHEN THE WATER CONTACTS THE BOARD, DEACTIVATING ALL OR PART OF THE ABS.

Risk. IF THE WARNING LAMP SIGNAL IS IGNORED FOR A PERIOD OF TIME, CORROSION CAN DEVELOP EVENTUALLY LEAKING TO A COMPLETE LOSS OF ECU FUNCTION. THE SERVICE BRAKES WOULD CONTINUE TO BE FULLY FUNCTIONAL.

Remedy. ROCKWELL IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL. DEALERS WILL REPLACE THE ECU ON THESE TRAILERS. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ROCKWELL AT 1-810-435-8001 OR DORSEY TRAILERS AT 1-334-897-5711.

What owners reported

Newest filings

Tires

Filed Apr 30, 2007NC

1997 DORSEY TRAILER. CONSUMER WAS DRIVING 65 MPH ON THE HIGHWAY WHEN THE RIGHT REAR TIRE BLEW OUT. *MC (OHIO TRAFFIC CRASH REPORT) *JB A VEHICLE QUESTIONAIRE WAS MAILED TO CUSTOMER TO OBTAIN ADDITIONAL INFORMATION PERTAINING TO THE COMPLAINT. *TR

1 of 1 complaints, reproduced as filed.

Across model years

Worst on record: 1997

Year	Complaints	Recalls	Assessment
1999	0	1	Routine
1998	0	1	Routine
1997 — this page	1	2	Routine
1996	0	2	Routine

Compare every Trailer year →

Other Dorsey models

All Dorsey models →

Dorsey 3

Reading this record

No unusual pattern of severe incidents in the complaint record.

Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.

Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.

Most recent recall on file: Jun 8, 1998. Source: NHTSA Office of Defects Investigation.