2000 Dodge Intrepid

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.

Risk. IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Defect. VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES (NON-SUNROOF ONLY) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

Risk. IN THE EVENT OF A CRASH, THERE IS A POTENTIAL FOR INJURY IF THE OCCUPANT'S HEAD WERE TO CONTACT THE B-PILLAR.

Remedy. OWNERS WILL BE SENT A STORAGE BIN ACCESSORY UNIT THAT CAN BE ATTACHED TO THE B-PILLAR ALONG WITH INSTALLATION INSTRUCTIONS. HOWEVER, IF AN OWNER WISHES, THE DEALER CAN PERFORM THE INSTALLATION. OWNER NOTIFICATION BEGAN DECEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Defect. VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.

Risk. IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Remedy. OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.

Defect. VEHICLE DESCRIPTION: NON-ABS EQUIPPED PASSENGER VEHICLES. THE BRAKE MASTER CYLINDER PISTON RETAINER SNAP RING MAY HAVE BEEN BENT INWARD DURING THE ASSEMBLY PROCESS. THE MASTER CYLINDER PISTON MAY BE IN A "BRAKE APPLIED" POSITION DUE TO THE DAMAGED PISTON RETAINER SNAP RING. WHEN THE PISTON IS IN THE APPLIED POSITION, THE FLUID COMPENSATION PORTS ARE CLOSED WHICH RESULTS IN A BRAKE DRAG CONDITION.

Risk. IF THE BRAKE OVERHEAT, BRAKE FADING COULD LEAD TO AN INCREASE IN NEEDED STOPPING DISTANCE. SHOULD A DRIVER NOT ANTICIPATE THE EXTRA STOPPING DISTANCE, THIS CONDITION COULD CAUSE A CRASH.

Remedy. DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE MOLDING FLASH ON THE PRIMARY LEVER MAY PREVENT THE OPERATION OF THE G-LOCK AND TILT LOCK FUNCTIONS ON SOME OF THE DRIVER'S SIDE RETRACTORS.

Risk. IF THIS OCCURS IN A FRONTAL CRASH SITUATION, DRIVER PROTECTION FROM THE SEAT BELT MAY BE REDUCED, INCREASING THE RISK OF INJURY.

Remedy. DEALERS WILL REPLACE THE LEFT FRONT RETRACTOR ASSEMBLIES.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.

Risk. THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.

Remedy. DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.

Defect. VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE PASSENGER AIR BAG INFLATOR ASSEMBLY CONTAINS AN INCORRECT INFLATOR CHARGE AMOUNT.

Risk. THIS CONDITION COULD INCREASE THE RISK OF A PASSENGER OCCUPANT INJURY UNDER CERTAIN ACCIDENT CONDITIONS.

Remedy. DEALERS WILL REPLACE THE AIR BAG MODULE WITH A CORRECT MODULE.

Based on the low failure rate, the absence of failures over the past year, the absence of injuries, and odi's field investigation of incident vehicles, a safety-related defect trend has not been identified at this time.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.the agency will take further action if warranted by the circumstances. See attached report for additional information.

Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with …

Valve Body. These may cause over drive cycling.

SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN

SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT

ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. WHEN THE CONTACT ENTERED THE VEHICLE, A FUEL ODOR WAS DETECTED. THE CONTACT LIFTED THE HOOD AND NOTICED THE ODOR AS WELL AS FUEL LEAKING FROM UNDER THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT A NEW MANIFOLD NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000.

I OWN AN AUTO REPAIR SHOP AND I HAVE SEEN THIS PROBLEM ON THESE VEHICLES MORE THAN ONCE AND CANNOT FIGURE OUT HOW DODGE IS GETTING AWAY WITH NOT RECALLING THESE VEHICLES FOR A FUEL LEAK ON THE PRESSURE LINE AT THE BACK OF THE ENGINE. IT HAS A STEEL LINE THAT COMES FROM THE TANK UP TO THE ENGINE AND THE LAST APPROX. 8 INCHES TURNS TO PLASTIC. THE PLASTIC PART CRACKS AFTER TIME AND IT SPRAYS FUEL ONTO THE EXHAUST SYSTEM WHICH SEEMS TO ME THAT SHOULD FALL UNDER A RECALL. IF YOU SEARCH THE INTERNET YOU WILL SEE THIS IS AN ONGOING PROBLEM WITH THESE VEHICLES FOR SEVERAL YEARS. THE VEHICLE I HAVE HERE CAME IN DOING THIS AND I COULDN'T FIND ANY RECALL FOR THIS PROBLEM. I DO BELIEVE THIS SHOULD BE ADDRESSED AS IT COULD VERY EASILY CATCH FIRE. THANK YOU FOR YOUR TIME

CAR WON'T GO INTO PARK. HAS TO BE STARTED IN NEUTRAL. CAR HAS TENDENCY TO ROLL. WHEEL(S) HAS TO BE BLOCKED. STATIONARY.

AS I SAT IN MY CAR TO DRIVE, THE DRIVER'S SEAT LEANED BACK UNEXPECTEDLY. IT CAN NOT BE RAISED. I HAVE A BUCKET AND BOX BEHIND THE SEAT TO HOLD IT IN PLACE, BUT IT IS STILL NOT IN AN UPRIGHT POSITION. THIS IS A SAFETY ISSUE.

TAKATA RECALL

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE CRASHED INTO A BRICK WALL AND SEVERELY DAMAGED THE FRONT PASSENGER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY AND THE FRONT PASSENGER SEAT BELTS MALFUNCTIONED. THE DRIVER SUSTAINED A BACK INJURY AND BODY BRUISES AND THE FRONT PASSENGER SUSTAINED BROKEN RIBS. THE REAR PASSENGER SUSTAINED MULTIPLE LACERATIONS. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.

CAR WAS T-BONED ON DRIVER SIDE, THEN PROPELLED INTO A TREE AND SIDESWIPED A PARKED CAR. AIRBAGS DID NOT DEPLOY. HOOD WAS SLIGHTLY BUCKLED, DRIVER SIDE WAS DAMAGED FROM FRONT TO BEHIND REAR DOOR. PASSENGER SIDE WAS DAMAGED FROM FRONT HEADLIGHT/BUMPER AREA TO REAR DOOR.

I HAVE A 2000 DODGE INTREPID BOUGHT ALMOST A YEAR AGO.HAD A SHORT IN THE IGNITION HAD TO WIGGLE KEY TO GET SOMETHINGS TO KICK ON.THEN A MTH AGO.I WAS AT A STOP LIGHT STARTED TO TAKE OFF IT VIBRATED REALLY BAD AND NOW IT'S STUCK IN LOW GEAR.THEN IT HAD A PROBLEM STARTING, SOMETHING DRAINS THE BATTERY.CHECK ENGINE LIGHT ON.2 MACHINICS LOOKED MY CAR IT WON'T READ DIAGNOSTICS BECAUSE THERE'S A SHORT IN ELECTRONICAL SYSTEM.

THE CAR WAS DRIVEN INTO THE DRIVEWAY AND PUT THE CAR IN PARK. HE GOT OF THE CAR AND OPENED THE GATE. AT THAT TIME, THE VEHICLE SLIPPED OUT OF PARK AND BEGAN ROLLING DOWN THE DRIVEWAY. IT HIT THE CURB, THEN A SMALL TREE ON THE FRONT LAWN OF THE HOUSE ACROSS THE STREET AND FINALLY CAME TO REST ON THE FRONT STOOP OF THE SAID HOUSE. *TR

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. WHILE DRIVING AT 55 MPH, THERE WAS A BURNING ODOR. IN ADDITION, THE STEERING WHEEL MADE AN ABNORMAL NOISE WHEN TURNING IN BOTH DIRECTIONS AND ALL LIGHTS, METERS, AND GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION. THE CONTACT ALSO STATED THAT THE REAR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

EVERY TIME I GO TO SLOW DOWN I STALL. I HAVE TAKEN IT IN TO BE SERVICED. I'M NOT SURE WHAT PART THEY CHANGED BUT IT'S STILL DOING IT. I'M AFRAID TO DRIVE THE CAR. I BOUGHT IT BECAUSE I WAS TOLD IT WAS A GOOD FAMILY CAR. I CAN'T EVEN SEE MY GRAND KIDS I'M TO AFRAID TO DRIVE IT. WHEN I SAY IT STALL ALL THE TIME I LIVE 13 MILES FROM WORK AND I WILL STALL 6 TIMES BEFORE I GET THERE. *TR

I WAS GROCERY SHOPPING AND WHEN I GOT IN THE CAR TO GO HOME THERE WAS A CLUNK NOISE AND I WAS RECLINING IN THE DRIVERS SEAT. I COULD NOT UPRIGHT THE SEAT SO IT WOULD STAY IN PLACE. I PUT THE SEAT BELT ON AND HELD DOWN THE CONSOLE AND MADE IT HOME SCARED BUT SAFE.I LOOKED UNDER THE SEAT AND FOUND A BOLT BROKEN OFF. I DID RECEIVE A RECALL NOTICE FOR THE BOLTS SOME TIME AGO AND TOOK THE CAR TO THE LOCAL DODGE DEALER. I ASSUMED THE PROBLEM WAS FIXED ALTHOUGH I HAD NOT HAD A PROBLEM UNTIL TODAY. CAN I GO BACK TO DODGE TO HAVE IT FIXED? OBVIOUSLY IT WAD EITHER NOT REPLACED OR I GOT A FAULTY BOLT. PLEASE HELP. *TR

AS I WAS DRIVING ALONG AND APPROACHED MY EXIT, THE STEERING WHEEL LOCKED UP AND WOULD NOT ALLOW ME TO CONTROL THE CAR. I WAS ABLE TO STOP THE CAR SAFELY HITTING SOME BRUSH ON THE SIDE OF THE ROAD. NO DAMAGE OR INJURIES WERE INCURRED, BUT THIS WAS VERY FRIGHTENING! NOW, THE STEERING IS STILL GETTING STUCK ON TURNS AND I HAVE NO HORN! THE AIRBAG LIGHT IS NOW SHOWING AND I DON'T KNOW WHATS GOING ON WITH THIS CAR! SOMETHING NEEDS TO BE DONE. NO WARNINGS, OR RECALLS HAVE BEEN MADE, AND THERE A MANY CONCERNS OF OTHERS GOING THROUGH THE SAME ISSUE WITH THIS CAR. PLEASE ADVISE ON WHAT IS GOING TO BE DONE ABOUT THIS PROBLEM BEFORE SOMEONE GETS KILLED! *JS

MY 2000 INTREPID S ENGINE BLEW UP 2 YEARS AGO AND AGAIN 2DAYS AGO THERE WAS NO WARNING. MASTER CYLINDER IS FAILING AND THE STEERING PIN BROKE IN THE CAR AND LEFT ME HELPLESS I ENDED UP IN A DITCH. I CALLED DODGE AND THEY SAID THEY COULDN'T HELP BECAUSE IT WAS OUT OF WARRANTY PAST 7 YEARS AND ITS ONLY BEEN 2. *JS

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH INTO A PARKING SPACE, THE ENGINE STALLED WITHOUT WARNING. UPON RESTARTING, THE VEHICLE RESUMED NORMAL FUNCTION. THE FAILURE RECURRED TWELVE TIMES. IN ADDITION, WHENEVER ACCESSING THE EXTERIOR FRONT AND REAR PASSENGER LOCKED POWER DOORS, THEY FAILED TO RELEASE OPEN WITH THE KEY FOB. THE FAILURE RECURRED TWELVE TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 42,000. THE VIN WAS UNAVAILABLE.

VEHICLE HAS EXCESSIVE PLAY IN STEERING WHICH CAUSES CAR TO WANDER WHILE DRIVING, ESPECIALLY AT HIGHER SPEEDS. REQUIRES CONSTANT ADJUSTING WHILE DRIVING THIS CAR IS UNSAFE AND MAKES ME A LITTLE LEARY ABOUT DRIVING IT AT ALL. THIS SEEMS TO BE A BIG PROMBLEM WITH THIS VEHICLE AND I WONDER WHY THE DEPT. OF TRANSPORTATION AND HIGHWAY SAFETY HASN'T DONE ANYTHING ABOUT IT! *TR

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES, WITH THE ILLUMINATION OF THE CHECK ENGINE OIL WARNING LIGHT. THE TIMING BELT ALSO FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPLACED THE O2 SENSOR, OIL SWITCH RELAY AND THE CAM SHAFT POSITION SENSOR. THE FAILURE WAS NOT CORRECTED AND THE VEHICLE COULD NOT BE DRIVEN. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE AS 59,000.

TL* THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT WHILE HAVING A ROUTINE OIL CHANGED PERFORMED, THE MECHANIC ADVISED THE CONTACT THAT THE OIL WAS TOO THICK TO BE RELEASED FROM THE VEHICLE. THE MECHANIC ADVISED THAT THE OIL PUMP FAILED AND WAS CAUSING A BACKUP OF OIL WITHIN THE VEHICLE. THE MECHANIC ADVISED THAT THE VEHICLE SHOULD BE PARKED UNTIL IT WAS REPAIRED DUE TO THE POSSIBILITY OF SEVERE STALLING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 181,253.

TIMING CHAIN WENT DO TO SLUDGE BUILD UP HAD TO REPLACE ENGINE. *TR

CAR WAS MAINTAINED IMMACULATELY, 3 WEEKS BEFORE THE DOA DATE, THERE WAS A VERY FAINT TICKING SOUND (LIKE A ROULETTE WHEEL SPINNING "CLICK" SOUND) COMING FROM UNDER THE HOOD. TOOK THE CAR TO THE MECHANIC TO HAVE THE OIL CHANGED AND HAVE THE CARS NEW NOISE CHECKED. HE SAID IT COULD BE A LIFTER TICKING AND THE OIL CHANGE SOLVED THE PROBLEM. HE WAS CORRECT ABOUT THE SOUND MUTING HOWEVER THE ISSUE MAY BE THE TINY OIL PORT HOLES IN THESE MITSUBISHI MADE MOPAR ENGINES. ON THE DAY OF THE ENGINES DEATH IT MADE THE SAME TICKING SOUND, MY CUE THAT I COULD SHARE WITH ANYONE ABOUT TO HAVE THIS FAILURE OCCUR, WHEN I WOULD START THE CAR I NOTICED AN EXTRA "SPINNING" SOUND UNDER THE HOOD WHEN I WOULD START THE CAR. IT IS MINOR SO LISTEN CLOSE TO YOUR START-UP. THE TICKING GOT LOUDER AND EVENTUALLY AT A STOP LIGHT ON THE WAY TO THE MECHANIC THE CAR STOPPED AND WOULD NOT RUN. DO AN INTERNET SEARCH FOR DODGE INTREPID 2000 2.7 LITER MOTOR YOU WILL FIND A HORROR SHOW ON THE INTERNET. LOVED THE CAR WHILE IT WORKED BUT THE DEATH WAS TOO PREMATURE, I ONLY DRIVE ABOUT 8,000 MILES PER YEAR. *TR

WHILE BACKING OUT OF A PARKING STALL, FRONT DRIVERS SIDE WHEEL LOWER CONTROL ARM BROKE FREE FROM ENGINE CRADLE RESULTING IN TOTAL IMMOBILIZATION OF VEHICLE. UPON INSPECTION IT WAS OBVIOUS THAT THE MOUNTING BRACKET WHICH IS WELDED TO THE ENGINE CRADLE FRAME HAD RUSTED OUT CAUSING FAILURE. SIMILAR FAILURES ON OLDER MODELS HAVE HAD NHTSA RECALLS, SEE NHTSA CAMPAIGN ID # 99V215000, ISSUED DUE TO LOSS OF POWER OR CONTROL RESULTING IN A POTENTIALLY LIFE THREATENING CONDITION. IT IS UNDERSTANDABLE FOR WEAR PARTS SUCH AS BRAKES, SHOCKS AND SUSPENSION JOINTS TO FAIL DUE TO USE AND MILEAGE BUT FRAME MEMBERS SHOULD BE MADE SOLID AND THE RESPONSIBILITY OF THE AUTO MANUFACTURER TO ENSURE LONG TERM RELIABILITY.

DRIVING VEHICLE ON EXIT 73 IN LISBON,MD. WHEN ACCELERATION HALTS AND CAR WILL NOT ACCELERATE OVER 60MPH AND WAS STEADILY DECREASING. AS I PULLED OFF THE EXIT, THE CAR STALLED AND THE BATTERY LIGHT CAME ON, THEN THE ENGINE LIGHT AND THEN THE TRANSMISSION LIGHT, PROCEEDING WAS ALL LIGHTS IN THE CAR BLACKED OUT AND THE CAR WAS ONLY DRIFTING OFF THE EXIT. AS THE CAR STOPPED AND I PUT IT IN PARK, I NOTICED BLACK SMOKE AND FIRE SUBMERGING IN THE FRONT OF THE CAR WITH FORCE. I THEN HEARD A POP TO REALIZE MY TIRES POPPED FROM THE BURNING HEAT OF THE FIRE. I EXITED THE VEHICLE WITH NOTHING IN TOW AND IN FEAR OF MY LIFE IN ADDITION TO MY PASSENGER WHOM WE BOTH LEFT VALUABLE ITEMS IN THE BURNING CAR. THIS SEEMS TO FALL UNDER A FORM OF DEFECT IN WHICH I WOULD LIKE TO HAVE INVESTIGATED AND A CLAIM FILED AS THIS WAS A VERY TRAUMATIC EXPERIENCE WHICH I WOULD NOT WANT TO HAPPEN TO ANYONE ELSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I BOUGHT MY DODGE INTREPID IN JUNE OF 2010 KNOCKING IN THE ENGINE I HAVE NEVER RAN THE CAR OVER 55 MPH NO WARNING LIGHTS CAME ON KEPT CAR UP TO DATE ON MAINTENANCE OIL CHANGING AND EVERYTHING ELSE CHECKED OIL IT WAS OUT HAD IT CHANGED 2 WEEKS AGO AND ALSO WHEN I ADDED MORE OIL IN THE CAR THE OIL CAME UP ON DIP STICK VERY SLUDGY FOUND OUT I NEED A NEW ENGINE BY A MECHANIC. *TR

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT THE ROD MALFUNCTIONED IN THE ENGINE. THERE WAS A TICKING SOUND WITHIN THE ENGINE FOR TWO WEEKS PRIOR TO THE FAILURE. THE CONTACT STATED THAT THERE WERE NO LEAKS COMING FROM THE ENGINE PRIOR TO THE FAILURE. THE CONTACT WAS TOLD BY A MECHANIC THAT THIS WAS A COMMON PROBLEM WITH THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 122000.

MY OIL LIGHT WOULD BLINK ON AND OFF WHEN I WAS STOPPED AT A RED LIGHT. THE CAR ONLY HAS 102,000 MILES ON IT AND THE ENGINE STARTED TO KNOCK REALLY LOUD. I HAVE TAKEN IT TO A GARAGE TO SEE ABOUT GETTING IT FIXED BUT WILL NEED A NEW ENGINE. WITH WHAT I STILL OWE ON THE CAR AND THE PRICE OF THESE ENGINES (THEY ARE HARD TO FIND BECAUSE SO MANY PEOPLE HAVE NEEDED TO REPLACE THEM) IT IS NOT EVEN WORTH GETTING FIXED AT THIS POINT. *TR

2000 DODGE INTREPID, THE CONSUMER WAS TRAVELING WESTBOUND, WHEN HIS RIGHT FRONT TIE ROD BROKE CAUSING HIM TO GO OFF TO THE LEFT SIDE OF THE ROADWAY STRIKING THE CONCRETE MEDIAN. *BF (OHIO TRAFFIC CRASH REPORT # 10-0344-91)*JB UPDATED 08/06/10 *BF

MY 2000 DODGE INTREPID HAS A DEFECTIVE DRIVERS SEAT. FORTUNATELY, IN 2003 I STOPPED MY CAR TO LET A PASSENGER EXIT AND MY DRIVER'S SEAT FELL COMPLETELY BACKWARDS. IN 2006 I LEARNED THAT MY CAR DEALER FIXED THE SEAT AGAIN. IN 2010, I WAS STOPPED AT MY MAILBOX AND MY SEAT FELL COMPLETELY BACKWARDS AGAIN. THE DEALER & DODGE COMPANY REFUSED TO PAY FOR A SEAT REPLACEMENT. WHY NOT? *TR

I WAS DRIVING HOME FROM HAVING BODY WORK DONE, THE ENGINE LIGHT CAME ON, THEN 3 SECONDS LATER THE MOTOR STALLED. I PUT TRANSMISSION IN NEUTRAL AND STARTED THE ENGINE AND DROVE FOR 50 FEET BEFORE IT HAPPENED AGAIN. THIS TIME ENGINE WOULD NOT RESTART. I PULLED OFF THE ROAD AND CALLED THE COMPANY THAT DID THE BODY WORK. THEY RETRIEVED THE CAR SOON AFTER. SUBSEQUENTLY, WAS TOLD MY ENGINE FAILED DUE TO LACK OF MAINTENANCE, IE; OIL CHANGE. *TR

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 50 MPH, THE ENGINE WOULD NOT ACCELERATE NORMALLY AND THE OIL LIGHT ILLUMINATED. THE VEHICLE ALSO BEGAN TO EMIT SMOKE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE ENGINE HAD BLOWN OUT AND IT NEEDED TO BE REBUILT. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

WE LUST PURCHASED A USED 2000 DODGE INTREPID IT HAD 105,000 MILES ON IT , IT WAS IN GREAT CONDITION UNTIL MAY 21,2010, I WAS ON MY WAY TO MY PARENTS HOUSE AND THE CAR STARTING MAKING FUNNY NOISES AND IT JUST CUT OFF WITH US, WE TRIED TO START IT BACK BUT IT FAILED, HAD IT LOOKED AT, THEY ARE TELLING ME IT NEEDS A NEW ENGINE, NEEDLESS TO SAY THE COST IS OUTRAGEOUS!!!!!! I LOVE MY CAR, BUT AS I READ ON THE INTERNET THERE IS ALOT OF ENGINE PROBLEMS WITH THE 2.7L ENGINES, IS THERE ANY THING THAT CAN BE DONE ABOUT THIS? *TR

I PURCHASED A 2000 DODGE INTREPID WITH A 2.7L ENGINE FROM A PREVIOUS OWNER. I PUT AN ADDITIONAL $400.00 IN MAINTENANCE AND REPAIR PARTS (INCLUDING FRESH OIL AND FILTER) INTO IT AND THE ENGINE LITERALLY BLEW UP THE FIRST TIME IT WAS DRIVEN 20 MILES. I AM A 55 YEAR OLD WOMAN THAT HAD TO ABANDON THE VEHICLE ON THE ROAD AND ARRANGE FOR REMOVAL. REPLACING THE ENGINE WITH A NON-DEFECTIVE ONE IS COST PROHIBITIVE TO ME. *TR

30 MILES FROM HOME JAN. 2010 DRIVING A 2000 DODGE INTREPID WITHOUT WARNING BLINKING OIL LIGHT, HAMMERING ENGINE, LESS THAN A MINUTE LATER COMPLETE ENGINE FAILURE. CAR NOW SITS IN MY DRIVEWAY.HAVE MADE NO REPAIRS AS IT IS $3500, I'VE BEEN QUOTED. STILL 10 PAYMENTS TO GO ON THIS VEHICLE. CAR RAN LIKE A DREAM BEFORE THIS EXPERIENCE. NO PROBLEMS AT ALL, REG OIL CHANGES AND MAINTENANCE. *TR

2.7 BAD MOTORS. *TR

CAR WAS RUNNING GREAT, WITHOUT ANY INDICATION OF PROBLEMS. CAR DIED AND WOULD NOT START. RESULTING IN ENGINE FAILURE. *CN

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT UPON STARTING THE ENGINE, BOTH THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED. THE DEALER STATED THAT DIAGNOSTIC TESTING TO ASSESS THE FAILURE COULD BE DONE AT THE OWNERS EXPENSE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE DUE TO THE AGE OF THE VEHICLE. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 90,000. UPDATED 05/13/10. *LJ

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. WHILE THE VEHICLE WAS IN PARK THE AIR BAGS ABRUPTLY DEPLOYED WITHOUT ANY LEVEL OF IMPACT TO THE VEHICLE. THE DRIVER SUSTAINED MINOR INJURY. THE AUTHORIZED DEALER WAS NOTIFIED OF THE MALFUNCTION. THE VEHICLE REPAIR COST WAS APPROXIMATELY $3,500. THE FAILURE AND CURRENT MILEAGE WERE UNKNOWN. THE VIN WAS UNAVAILABLE.

THIS IS A BASIC VEHICLE COMPLAINT THAT I FEEL DODGE/CHRYSLER SHOULD BE MADE TO FIX ON THEIR 2.7L ENGINES. I AND AFTER SEARCHING THE INTERNET HAVE FOUND THAT MANY PEOPLE ARE HAVING THE SAME PROBLEM WITH THIS PROBLEM WITH THEIR 2000 DODGE INTREPID AND THE COMPANY IS DOING NOTHING TO HELP FIX IT WHEN IT IS A KNOWN ISSUE WITH THE ENGINE. OTHER MECHANICS HAVE SAID THE SAME THING. I THINK THAT SOME AUTHORITY SHOULD LOOK INTO THIS AND HAVE THEM RECALL THIS ENGINE. PEOPLE PAY A LOT OF MONEY FOR THEIR VEHICLES AND NEED THEM TO WORK. *TR

2000 DODGE INTREPID THE POWER STEERING STARTED ACTING UP, PROBLEM'S LIKE WINING AND HARD TO STEER AT TIMES. THAN FINALLY IT WENT OUT ALL TOGETHER WE TOOK THE CAR TO THE LOCAL SHOP AFTER TWO POWER PUMPS AND A NEW STEERING RACK-N-PINION THE MECHANIC STILL COULDN'T FIGURE WHAT THE PROBLEM WAS.WHEN HE CALLED AND SAID THAT THERE WAS NOTHING ELSE HE COULD DO ABOUT THE STEERING PROBLEM AND HE DIDN'T KNOW WHAT WAS CAUSING IT TO STEER SO HARD,SO HE TOLD US TO COME AND GET THE !@#$%'THING OUT OF HIS SIGHT ! SO THAT'S WHEN I WENT ON LINE AND READ ABOUT ALL THE PROBLEM'S EVERYONE ELSE WAS HAVING AND ALSO CONFIRMED MY SUSPICIONS ON WHAT MIGHT BE THE PROBLEM. (THE WRONG FLUID IN RES.)SO NOW THAT I DRAINED THE FLUID AND FLUSHED ALL THE LINES A COUPLE TIMES THE THING WORKS FINE . *TR

I WOULD LIKE TO FILE A COMPLAINT ON THE 2000 DODGE INTREPID, 2.7L ENGINE. I HAD A FRONT END CRASH WITH NO APPARENT ENGINE DAMAGE. WHEN THE COSMETICS WERE REPAIRED AND I CRANKED THE ENGINE AGAIN THE OIL LIGHT CAME ON AND IT WAS NOT RUNNING SMOOTHLY. OIL LIGHT GOES ON AND OFF AT TIMES AND NOW HAS KNOCK IN ENGINE. I BLAME THIS ON A DESIGN FLAW IN THE OIL GALLEYS OF THE 2.7 ENGINE. *TR

I STOPPED AT A STOP SIGN, TURNED LEFT, ACCELERATED TO ABOUT 35 MPH AND HEARD A "CLUNK", THE ENGINE STOPPED RUNNING AND I COASTED TO THE SIDE OF THE ROAD, GOT OUT AND LOOKED UNDER THE HOOD AND SAW THE TIMING CHAIN STICKING THROUGH THE HOUSING. I CALLED A TOW TRUCK AND HAD THE VEHICLE TOWED TO A REPAIR SHOP. THE REPAIR SHOP IS WAITING FOR THE AFTER-MARKET WARRANTY COMPANY TO DECIDE WHAT THEY WILL PAY FOR AND WHAT IS TO BE DONE. *TR

HELLO MY NAME PAULA HOWARD. MY 2000 DODGE INTREPID JUST DIED WHILE DRIVING THE OTHER DAY. I CALLED MY HUSBAND, WHEN HE LIFTING THE HOOD OF MY CAR THERE WAS STEAM COMING OUT OF THE ENGINE. HE THEN CHECKED THE OIL AND SAW ANTIFREEZE IN THE OIL. I HAVE SINCE TAKEN THE CAR BACK TO MY DEALERSHIP SINCE I HAVE OWNED THE CAR FOR LESS THAN A YEAR. THEY OF COURSE WILL NOT TOUCH IT OR WARRANTY IT. THEY WANT A LOT OF MONEY TO EVEN LOOK AT IT. I STARTED RESEARCHING AND FOUND THAT I AM BY FAR NOT THE ONLY PERSON WITH THIS PROBLEM. CAN YOU HELP? *TR

2000 INTREPID WITH A 2.7L ENGINE SEIZED UP DURING DRIVING 12/3/09. AUTO CENTER SUGGESTS THIS IS AN ENGINE FAILURE LIKE SO MANY OTHER CHRYSLER PRODUCT OF THIS TYPE. *TR

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. WHILE DRIVING 40 MPH THE VEHICLE BEGAN LOOSING POWER AND SLOWING DOWN. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE EMERGENCY LANE. NO WARNINGS LIGHTS ILLUMINATED WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DETERMINED THAT THE MOTOR FAILED AND THE REPAIR COST WOULD BE $7,000. NO REPAIRS HAVE BEEN MADE. THE MANUFACTURER INFORMED THE CONTACT TO TAKE THE VEHICLE A DIFFERENT DEALER TO BE INSPECTED. THE FAILURE MILEAGE WAS 78,000.

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. THE CONTACT STATED THAT DURING BREAK APPLICATION HE HEARS A GRINDING NOISE. BREAK FAILURE CAN LEAD TO INCREASED STOPPING DISTANCES, WHICH INCREASES THE RISK OF VEHICLE CRASH. ALL THE COMPONENTS IN THE BREAK SYSTEM WERE REPLACED. AFTER THE REPAIR THE FAILURE RESURFACED. THE CURRENT AND FAILURE MILEAGES WERE 99275. BL

ENGINE FAILURE ON 2.7 LITRE ENGINE IN A 2000 DODGE INTREPID. I WAS DRIVING ON A 100KM SPEED LIMIT HIGHWAY WHEN I HAD ENGINE FAILURE. THERE WAS NO PLACE TO GET OFF SAFELY SO PULLED OVER TO THE RIGHT AS FAR AS I COULD. STILL TRAFFIC HAD TO STEER AROUND MY DEAD VEHICLE CAUSING AN UNSAFE ROAD CONDITION WHICH COULD HAVE ENDED IN A BAD OR FATAL WAY. THERE IS A DESIGN FLAW WITH THIS ENGINE WITH MANY COMPLAINTS REGISTERED WITH DIFFERENT ENTITIES DESIGNED TO COLLECT THIS INFORMATION. THE MAKER REFUSES TO ACKNOWLEDGE THE FLAW AND COMPENSATE IN ONE FORM OR ANOTHER. THIS ENGINE MAKE IS A SAFETY HAZARD AND THE MAKER SHOULD BE MADE ACCOUNTABLE. *TR

DRIVING ALONG ROADWAY CAR MADE LOUD NOISE AND STALLED COULD NOT RESTART CAR HAD TOWED TO GARAGE AND WAS TOLD ENGINE HAD SEIZED NEEDS TO BE REPLACED HAD NO WARNING WILL COST BETWEEN 2000AND 3500 TO REPLACE ENGINE. *TR

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. THE VEHICLE HAS DOMINATOR ALL SEASON TIRES, SIZE P225/75R15. WHILE DRIVING 65 MPH, THE CONTACT HEARD A SMACKING NOISE COMING FROM THE REAR OF THE VEHICLE. HE PULLED OVER AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE HAD BEEN SEPARATING AND PEELING OFF, LEAVING PIECES OF RUBBER IN THE MIDDLE OF THE ROAD. HE TOOK THE VEHICLE TO A NEARBY GAS STATION AND HAD THE TIRE REPLACED. THE CONTACT BELIEVES THAT THE TIRE SHOULD NOT HAVE SEPARATED SO QUICKLY AND THAT A RECALL SHOULD BE ISSUED. THE VIN AND DOT NUMBER WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 89,000.

MY WELL MAINTAINED DODGE INTREPID HAS MANY FAILURES STARTING WITH THE CRACKING ON THE CHASIS AND MASSIVE ENGINE PROBLEMS. *TR

ALMOST LOST CONTROL OF THE STEERING WHILE DRIVING ON THE INTERSTATE HIGHWAY. CAR STARTED SHAKING SO WE PULLED OF TO THE SIDE OF THE ROAD AS SOON AS POSSIBLE. THE INNER TIE ROD BUSHINGS WERE COMPLETELY GONE WITH JUST THE BOLT AND WASHER HOLDING THE TIE ROD ON THE STEERING RACK. HAD TO REPLACE THE INNER TIE RODS, BUT STILL NEED TO REPLACE THE STEERING RACK.

TL*THE CONTACT OWNS A 2000 DODGE INTREPID. WHILE DRIVING 55 MPH, THE CONTACT HEARD A PINGING NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND SLUDGE BUILD-UP IN THE ENGINE. THE DIAGNOSTIC COST $235. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND INSPECTED BY A TECHNICIAN, WHO DETERMINED THAT THE ENGINE FAILED. THE ENGINE WAS REPLACED WITH A REBUILT ENGINE AT THE COST OF $4,210. THE CONTACT CALLED THE MANUFACTURER AND WAS ADVISED TO SEND THE ROUTINE MAINTENANCE RECEIPTS TO THE CHRYSLER DEALER TO DETERMINE IF SHE WOULD RECEIVE REIMBURSEMENT. THE CONTACT HAS NOT RECEIVED ANY COMPENSATION OR A FOLLOW UP CALL. THE FAILURE MILEAGE WAS 82,532 AND CURRENT MILEAGE WAS 110,000. UPDATED 08/04/09 *BF UPDATED 08/05/09.*JB