2005 Dodge Grand Caravan complaints

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SIDE POWER DOOR WOULD NOT UNLOCK WITH THE KEYLESS ENTRY FOB OR THE INTERIOR AUTOMATIC DOOR LOCKS. THE CONTACT HAD TO MANUALLY UNLOCK THE DOOR. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER REGARDING THE DOOR LOCKS. THE FAILURE MILEAGE WAS 68,000.

ELECTRIC DOOR LOCKS REPEATEDLY STOP WORKING. *TR

THE POWER DOOR LOCKS HAVE BEEN FAILING INTERMITTENTLY FOR 3 YRS. I UNHOOK THE IOD FUSE OR THE BATTERY CABLE MOMENTARILY AND THIS SEEMS TO WORK FOR A WHILE. THE DOOR LOCKS WOULD WORK FOR A SHORT TIME - THEN FAIL AGAIN UNTIL I REPEATED THE FUSE OR BATTERY CABLE REMOVAL PROCEDURE. AS TIME WENT ON THE FIX WOULD LAST LESS & LESS TIME. CURRENTLY, THE LOCKS MAY ONLY WORK FOR A DAY OR SO. THIS IS UNACCEPTABLE. MY WIFE WAS REALLY SCARED THE OTHER DAY WHEN SOMEONE WAS APPROACHING THE CAR AND SHE COULD NOT LOCK THE DOORS. SHE WAS IN AN UNFAMILIAR LOCATION WITH THE 4 YEAR OLD IN THE BACK SEAT. WHILE IT ACTUALLY TURNED OUT TO BE A FALSE ALARM, IT DID OPEN MY EYES. WHILE I HAVE BEEN JUST "FIXING" IT ALL THE TIME, I REALIZED THAT I CANNOT CONTROL WHEN AND WHERE IT WILL HAPPEN AND YOU CANNOT ALWAYS GET OUT AND RESET THE FUSE. THIS IS A PROGRAM (FIRMWARE) THAT IS FAILING ON A LARGE NUMBER OF VEHICLES, SEE LINKS BELOW. THIS POSES A SAFETY HAZARD AS THE VAN CANNOT BE SECURED WITHOUT MANUALLY LOCKING ALL DOORS, WHICH LEAVES THE TAILGATE. WHY SHOULD CONSUMERS HAVE TO PAY FOR A MANUFACTURER DEFECT? SOMEONE NEEDS TO PROTECT THE CONSUMER..... I AM TAKING THE VAN IN TO REQUEST IT BE REPROGRAMMED. I AM NOT GOING TO WAIT UNTIL SOMETHING BAD ACTUALLY HAPPENS FIRST. JUST A COUPLE OF LINKS: HTTP://WWW.CARCOMPLAINTS.COM/DODGE/GRAND_CARAVAN/2005/ELECTRICAL/ELECTRIC_DOOR_LOCK_FAILURE.SHTML HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/DODGE-GRAND_CARAVAN/POWER_LOCKS_WILL_NOT_LOCK_OR_UNLOCK. *TR

POWER DOOR LOCKS FAIL TO WORK INTERMITTENTLY AND ULTIMATELY FAIL PERMANENTLY. THIS IS A PARTICULAR DANGER WHEN CHILDREN ARE SEATED IN THE REAR SEAT AND DOORS DO NOT LOCK DESPITE BEING ACTIVATED. THIS PROBLEM DIFFERS FROM ANOTHER COMMON PROBLEM REPORTED FOR SCORES OF THIS CLASS OF VEHICLE (SEE INTERNET); THE SIMULTANEOUS FAILURE OF ALL LOCKS REQUIRING A COMPUTER RESET TO RETURN THEM TO OPERATION. I ATTEMPTED TO REPORT THIS A FEW DAYS AGO BUT THE FORM ONLY ACCEPTED A 10-DIGIT VIN. THE AUTOMATED RESPONSE WAS NOT CLEAR AS TO WHETHER THE REPORT WAS ACCEPTED DESPITE THE PARTIAL VIN CONSTRAINT OF THE FORM.

MY HEADLIGHTS DO NOT COME ON WHEN TURNED ON. IF I WOULD TURN OFF AND ON THE LIGHTS EVENTUALLY THEY COME BACK ON. NOW IT HAPPENS WHEN I DRIVE DOWN THE ROAD. IT HAPPENED AGAIN TO MY WIFE LAST NIGHT AND SHE ALMOST GOT INTO A CAR WRECK. WE CANNOT DRIVE OUR VAN AT NIGHT ANYMORE. *KB

HEADLIGHTS TURN OFF INTERMITTENTLY DURING OPERATION. THIS IS VERY DISCONCERTING AND DANGEROUS. DRIVER MUST FLIP THE LIGHT SWITCH MULTIPLE TIMES TO BRING THE LIGHTS BACK ON. THE FREQUENCY OF THIS PROBLEM HAS INCREASED RECENTLY. I FEEL THAT THE VEHICLE IS UNSAFE AND UNRELIABLE. RECENTLY, THE HEADLIGHTS WOULD NOT COME BACK ON AND WE HAD TO DRIVE HOME USING THE FOG LAMPS. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT HE WAS UNABLE TO LOCK OR UNLOCK THE DOORS USING THE KEY FOB. IN ORDER TO ENTER OR EXIT THE VEHICLE, THE CONTACT HAD TO DO SO MANUALLY. THE CONTACT ADJUSTED THE FUSE FOR THE INTEGRATED POWER ASSEMBLY MODULE TO REMEDY THE FAILURE, BUT THE FAILURE RECURRED THE FOLLOWING DAY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE ELECTRIC DOOR LOCKING MECHANISM BECAME INOPERABLE WHEN HE ATTEMPTED TO USE THE REMOTE CONTROL. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DISCONNECTED THE FUSE AND THEN RECONNECTED IT AGAIN. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 40,700. THE APPROXIMATE FAILURE MILEAGE WAS 38,000. IN SEARCHING THE INTERNET I FOUND NUMEROUS COMPLAINTS ON THIS VEHICLE. IN MY OPINION IT IS A SAFETY FEATURE WHEN YOU ARE TRANSPORTING CHILDREN, AND SHOULD BE A RECALL BY CHRYLSER. UPDATED 11/15/2011 *LN

THE HEADLIGHT SWITCH DOES NOT ALWAYS TURN ON THE HEADLAMPS. WE HAVE TO SWITCH IT BACK AND FORTH SEVERAL TIMES, AND SOMETIMES IT ONLY TURNS ON PARKING LIGHTS, SOMETIMES ONLY FOG LIGHTS, AND EVENTUALLY HEADLAMPS WILL TURN ON. IT IS NOT CONSISTENT OF WHEN AND WHERE THE SWITCH WILL WORK AND HOW MANY TIMES IT TAKES TO SWITCH IT BACK AND FORTH TO TURN ON. SINCE THIS ISSUE STARTED HAPPENING - WE HAVE EXPERIENCED THE HEADLAMPS ACTUALLY TURNING OFF DURING DRIVING IN THE DARK. LUCKILY THEY HAVE COME BACK ON IF I MESS WITH THE SWITCH - BUT THIS IS DANGEROUS AND IT IS NOT CONSISTENT WHEN IT HAPPENS EITHER. I HAVE ALSO HAD THE FOG LIGHTS FLICKER ON AND OFF WHILE DRIVING EVEN THOUGH I DO NOT HAVE THE SWITCH PULLED OUT FOR THEM TO COME ON AT ALL. *TT

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HEADLIGHTS, INSTRUMENT PANEL LIGHTS AND THE PUSH BUTTON SIDE DOORS DID NOT FUNCTION. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE BODY CONTROL MODULE WOULD MOST LIKELY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE.

POWER DOOR LOCKS FAILURE! THIS PROBLEM STARTED A MONTH AGO WHEN THE POWER-LOCKS JUST QUIT WORKING. SO I FOLLOWED THE INSTRUCTIONS IN THE CAR MANUAL WHERE YOU CAN REPROGRAM THE LOCKS BY SWITCHING THE IGNITION KEY 4 TIMES ENDING IN THE OFF POSITION AND THEN AFTER 10 SECONDS TURN THE DOOR LOCK ON, A CHIME WILL SOUND, IT DID BUT LOCKS STILL DO NOT WORK. I THOUGHT IT MIGHT BE A FUSE SO I REMOVED THE IOD FUSE AND PUT IT BACK IN 5 SEC. THE LOCKS STARTED TO WORK AGAIN. THIS LASTED ABOUT 2 OR 3 TIMES AND THEN THE PROBLEM SEEMS TO RETURN EVENTUALLY. THIS IS A SAFETY CONCERN AND THE VEHICLE SHOULD BE A RECALL. DODGE SHOULD BE ACCOUNTABLE FOR THIS AND MADE TO CORRECT THE PROBLEM. *KB

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN SHE ENGAGED THE AUTOMATIC DOOR LOCK MECHANISM BUT THE DOORS FAILED TO LOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

SYSTEM WILL BEEP, DASH LIGHTS AND GAUGES WILL FLASH AND GO DEAD. DOOR LOOKS ALSO STOP WORKING. ONE INCIDENT OF BATTERY BEING DRAINED TO NOTHING, NO EMERGENCY STANDBY POWER FOR STARTING. MANY REPORTS OF THE BCM MODULE BEING THE CAUSE. CAN BE TEMPORARILY FIXED BY PULLING THE IOD FUSE TO RESET THE BCM. DODGE TSB 08-040-04 REPORTED TO OUTLINE THE PROBLEM. REPLACING THE BCM NOT ALWAYS REPORTED TO FIX. FLASHING THE BCM(UPDATING CODE) MORE COMMONLY REPORTED TO FIX, ALSO MENTION OF CORRODED CONTACTS BEING RELATED. REPAIR IS HARD TO DETERMINE AS ANY WORK DONE ON THE BCM WILL RESULT IN A RESET WHERE IT WILL TEMPORARILY START WORKING AGAIN. *KB

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AUTOMATIC DOOR LOCKS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPROGRAMMED THE DOOR LOCKS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 77,117. UPDATED 10/14/11 *BF UPDATED 10/21/11

TL* THE CONTACT OWNS A 2005 CHRYSLER GRAND CARAVAN. THE CONTACT STATED THAT THE DOOR LOCKS WERE INOPERABLE. NEITHER THE MANUFACTURER NOR THE DEALER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,980 AND THE CURRENT MILEAGE WAS 46,000. THE VIN WAS UNAVAILABLE.

HEADLIGHTS EITHER WILL NOT TURN ON OR GO OUT WHILE DRIVING. PARKING AND TAIL LIGHTS NOT EFFECTED. FLIPPING SWITCH ON AND OFF WILL SOMETIMES WORK. UPDATED IVOQ 10/19/11. *JB *TR

FLYWHEEL CRACKED AT AROUND 102,000 MILES CAUSING MAJOR JERKING OF THE VEHICLE WHEN THE TRANSMISSION SHIFTED FROM FIRST TO SECOND GEAR. I WAS TOLD BY MY MECHANIC THAT THIS IS A COMMON PROBLEM WITH THIS VEHICLE AND THERE HAS NEVER BEEN A RECALL. I DID REPLACE THE FLYWHEEL WHICH COST CLOSE TO $800.00. *TR

POWER DOOR LOCKS INOPERABLE, SAFETY ISSUE IF NEED TO OPEN LOCKS IN AN EMERGENCY. CAN BE CORRECTED BY PULLING IOD FUSE BUT SOLUTION ONLY LASTS SEVERAL DAYS. HAVE SEEN ON INTERNET SOME SUCCESS IF DEALER REPROGRAMS BCM. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HEADLIGHTS WOULD FAIL SPORADICALLY. THE CONTACT WOULD OFTEN HAVE TO CONTINUOUSLY ENGAGE THE HEADLIGHT SWITCH TO GET THE LIGHTS TO ILLUMINATE. THE CONTACT HAD TO UTILIZE THE HIGH BEAM HEADLIGHTS. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 103,000.

WE LOCKED THE VEHICLE WITH THE REMOTE, SAW THE DOOR CLOSING, AND WHEN WE RETURNED, THE PASSENGER SLIDING DOOR WAS WIDE OPEN! SINCE THE ORIGINAL FAILURE DATE, THIS HAPPENS CONTINUOUSLY. THE DOOR CLOSES ALMOST ALL THE WAY, AND THEN REVERSES, AND OPENS UP. WE HAVE TO MANUALLY SHUT THE SLIDING DOOR (DIFFICULT) IN ORDER TO CLOSE AND LOCK IT. DID NOT NOTIFY MANUFACTURER OR DEALER. *TR

HEADLIGHTS TURN OFF WHILE DRIVING. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE ATTEMPTED TO LOCK THE DOORS USING THE KEY FOB AND THE DOORS WOULD NOT LOCK. THE CONTACT WAS ABLE TO SUCCESSFULLY LOCK THE DOORS MANUALLY. THE CONTACT REPLACED THE FUSES FOR THE DOOR LOCKS, BUT THE FAILURE RECURRED AFTER A FEW WEEKS. THE CONTACT AGAIN REPLACED THE FUSES, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

THE POWER LOCKS STOPPED WORKING, I HAVE TO RESET A FUSE TO GET THE LOCKS TO WORK AGAIN, BUT THIS ISSUE WILL EVENTUALY COME BACK. *TR

DOOR LOCKS ON 05 DODGE GRAND CARAVAN WONT OPEN OR CLOSE. KEEPS HAPPENING EVEN WHEN ITS SUPPOSED TO BE FIXED. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE VEHICLE DOORS POWER LOCK FAILED. THE DOORS WOULD ONLY OPEN MANUALLY. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER TO BE DIAGNOSED, AND THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 83,000.

2005 DODGE GRAND CARAVAN. REAR SLIDING POWER DOOR LOCK FAILURE. DRIVER'S SIDE MANUAL LOCK/UN-LOCK WILL NOT UNLOCK SLIDING DOOR NOR WILL REMOTE. IT HAPPENS FREQUENTLY AND TO FIX THE PROBLEM, YOU HAVE TO REMOVE THE IOD FUSE FOR A FEW SECONDS AND PUT IT BACK IN. *KB

I PURCHASED A DODGE GRAND CARAVAN NEW IN 2005. YESTERDAY I HAD A FLAT TIRE AND TRIED TO ACCESS THE SPARE TIRE. IT WAS IMPOSSIBLE AS IT WAS FROZEN IN PLACE. I CALLED MY LOCAL DEALERSHIP AND THEY SUGGESTED I USE A PRY BAR TO FREE IT. I BELIEVE THIS IS A DESIGN FLAW AND THAT MANY PEOPLE ARE DRIVING AROUND BELIEVING THEY HAVE A SPARE TIRE WHILE IN REALITY, THE SPARE IS INACCESSIBLE. I COULD HAVE BEEN STRANDED OR IN AN UNSAFE AREA. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HORN WAS DEFECTIVE. THE MANUFACTURER WAS NOTIFIED BUT DENIED ANY ASSISTANCE WITH REPAIR TO THE VEHICLE. THE DEALER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

I PURCHASED TWO GOODYEAR INTEGRITY TIRES ON 6/10/11 FROM DUNCAN'S AUTO REPAIR IN LINCOLNTON, NC. YESTERDAY, 8/7/11, I DROVE LESS THAN 5 MILES FROM MY HOME TO PICK UP DINNER AND BACK HOME (ALL ON HARD SURFACE ROADS). THERE WAS NO DEBRIS IN THE ROAD, I DID NOT RUN OFF THE SIDE OF THE ROAD, AND I DID NOT HIT ANYTHING. WHEN I PULLED INTO MY GARAGE AND TURNED THE CAR OFF, I HEARD A HISSING NOISE AND FOUND THAT MY TIRE WAS RAPIDLY GOING FLAT. MY HUSBAND TOOK THE TIRE OFF AND FOUND THAT THE INSIDE SIDEWALL ON THE RIGHT FRONT TIRE WAS SPLIT IN THREE PLACES. HE PUT THE SPARE TIRE ON SO THAT I COULD GO TO DUNCAN'S AUTO REPAIR IMMEDIATELY THE NEXT MORNING. I DID SOME ONLINE RESEARCH PRIOR TO TAKING THE TIRE TO THE SHOP WHERE IT WAS PURCHASED AND SAW MULTIPLE COMPLAINTS FOR SIDEWALL SPLITS IN GOODYEAR INTEGRITY TIRES. I HAVE THREE OTHER GOODYEAR INTEGRITY TIRES ON MY CAR, ALL LESS THAN A YEAR OLD. I AM CONCERNED ABOUT SIMILAR INCIDENTS. THANKFULLY I WAS NOT GOING ABOVE 55 MPH AND DID NOT HAVE MY TWO CHILDREN WITH ME. A SERIOUS ACCIDENT COULD HAVE OCCURRED IF I HAD BEEN GOING FASTER OR WAS FURTHER FROM HOME. *TR

ELECTRIC DOOR LOCK DO NOT WORK, THEY WILL WORK MANUALLY, BUT NOT WITH REMOTE OR DOOR SWITCH. HAVE TO REMEMBER TO MANUALLY LOCK DOORS WHEN GOING THRU "BAD" SECTION OF CITY. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT FLUID WAS LEAKING FROM THE AIR CONDITIONING UNIT AND THE UNIT WAS ALSO BLOWING WARM AIR. THE DEALER WAS CONTACTED AND ADVISED THAT A MANUFACTURER RECALL WAS INITIATED FOR THE FAILURE BUT THE CONTACT'S VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 103,000.

AUTOMATIC DOOR LOCKS HAVE FAILED. CAR IS STILL FLASHING HEADLIGHTS & BEEPING THAT CAR IS LOCKED WHEN USING THE REMOTE, BUT THE CAR IS NOT LOCKING. THE CAR IS ALSO NOT LOCKING AFTER REACHING 18 MPH AS IT IS SUPPOSED TO. THE MAIN LOCK SWITCH IN THE CAR CONSOLE IS ALSO NOT LOCKING THE DOORS. ALL DOORS MUST BE OPENED BY HAND AFTER THE DRIVER DOOR IS OPENED WITH THE KEY. *KB

THE BCM WHICH CONTROLS THE AUTOMATIC ELECTRIC DOOR LOCKS AND INSIDE DOOR LOCK CONTROLS, AND AUTO DOOR OPENERS WITH THE EXCEPTION OF THE REAR DOOR SO FAR HAS FAILED.

ELECTRICAL DOOR LOCK SYSTEM FAILED. REAR SLIDING DOOR OPENED BY ITSELF. *TR

EXTERIOR LIGHTS FAIL TO TURN ON. THIS IS AN INTERMITTENT ISSUE AND HAVE TAKEN IT IN BEFORE, BUT THEY SAID THAT THEY CAN'T FIX IT UNLESS IT IS HAPPENING WHEN I BRING IT IN. CONVENIENT THAT THEY ARE NOT OPEN AT NIGHT WHEN I TURN ON MY LIGHTS. *TR

THE POWER LOCKS ON THE 2005 DODGE CARAVAN COMPLETELY QUIT WORKING . A QUICK FIX IS TO PULL THE IOD FUSE FOR FIVE SECONDS AND PUT IT BACK . IT WILL WORK FOR A LITTLE WHILE THEN LOCKS GONE AGAIN. THOUGH THE VEHICLE DOES AUTOMATIC LOCK AT 15MPH STILL. THIS POSES A ISSUE BECAUSE IF IN AN ACCIDENT YOU WOULD HAVE TO MANUALLY UNLOCK THE DOORS TO GET OUT .FORUMS HAVE BEEN POSTING THIS ISSUE FOR AWHILE WHILE DODGE WILL NOT RECALL. THIS IS NOT THE ONLY ELECTRICAL ISSUE THE RESISTER TO THE BLOWER MOTOR WILL CONTINUOUSLY GO OUT . PERSONALLY I HAVE HAD TO CHANGE MY 4 TIMES IN ONE YEAR ALREADY. I BELIEVE DODGE NEEDS TO FIND A PERMANENT SOLUTION TO ITS ELECTRICAL ISSUES BEFORE SOMETHING WORSE HAPPENS. *TR

HEADLIGHT SWITCH ON 2005 CHRYSLER TOWN AND COUNTRY AND 2005 DODGE GRAND CARAVAN MALFUNCTIONS WHILE DRIVING. EXTREMELY DANGEROUS WHILE DRIVING AT NIGHT. *TR THE SWITCH ON SOME OF THESE VEHICLES SEEM TO BE INSTALLED INCORRECTLY. THERE ARE 4 SETTINGS ON THE SWITCH THAT WHEN CONNECTED WILL TURN ON THE LIGHTS APPROPRIATELY. IN SOME CASES THE SWITCH IS MISALIGNED AND THE CONTACT WILL EITHER NOT WORK AT ALL, OR, MAKE RANDOM DISCONNECTIONS. THIS IS EXTREMELY DANGEROUS WHEN DRIVING AT NIGHT AS THIS IS A FAMILY VEHICLE, KNOWN TO HAVE MULTIPLE PASSENGERS. IF THE HEADLIGHT FAIL AT NIGHT, THIS COULD BE DEADLY. THERE HAVE BEEN NUMEROUS FORUMS, AND BLOGS DESCRIBING THESE ISSUES WITH TOWN AND COUNTRY, AND CARAVAN, AND GRAND CARAVAN OWNERS. THE FAILURE OCCURS RANDOMLY, AND THE ONLY WAY TO FIX THIS IS TO EITHER OPEN/REPAIR THE SWITCH, OR REPLACE THE SWITCH. CURRENTLY I AM HAVING TO FLIP THIS SWITCH OFF AND ON BACK AND FORTH UNTIL THE CONTACTS CONNECT. IF IT DOES NOT WORK, THEN I HAVE TO DRIVE WHILE I HOLD THE HI-BEAMS ON. THIS IS NOT SAFE FOR MYSELF NOR OTHER DRIVERS DRIVING TOWARD ME.

POWER DOOR WILL NOT SHUT COMPLETELY OR OPEN WHEN BUTTON PUSHED. *TT

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE FRONT DRIVER'S DOOR LOCK WAS THE ONLY FUNCTIONING LOCK ON THE VEHICLE, BUT IT WOULD ONLY FUNCTION IF OPERATED MANUALLY WITH THE KEY. THE VEHICLE WAS NOT YET TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DOORS WOULD NOT LOCK UNLESS THEY WERE MANUALLY LOCKED. THE FAILURE ALSO OCCURRED TWICE IN THE PAST WHEN THE SLIDING DOORS MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON ONE OCCASION AND REPAIRED. THE CONTACT ALSO PREVIOUSLY DISCONNECTED THE BATTERY IN ORDER TO REMEDY THE FAILURE. THE CONTACT STATED THE FRONT STRUTS WERE ALSO REPLACED. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 71,000. THE VIN WAS UNAVAILABLE.

THE WHOE BRAKE COVER ON THE LEFT REAR FELL OF ON JULY 4TH 2009. I HAVE NOT HAD IT REPLACED YET AS I COULD NOT AFFORD IT, BUT HAVE BEEN USING RED TAPE. YESTERDAY, JULY10TH WHILE COMING OOF THE FREEWAY THE OTHER COVER FELL OFF. THIS TIME I SAW IT AND WENT BACK FOR IT. IT SEEMS THESE ARE ONLY GLUED ON. HAVE THERE BEEN OTHER COMPLAINTS OF THIS HAPPENING TO THESE VANS? IT IS SO EXPENSIVE TO REPLACE. *TT

THE HEADLIGHTS ON MY 2005 DODGE GRAND CARAVAN INTERMITTENTLY TURN OFF WHILE DRIVING. THIS HAS HAPPENED AT LEAST A DOZEN TIMES IN THE LAST YEAR OR SO! *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE AUTOMATIC LOCK ON THE FOB DOES NOT WORK. THE SLIDING DOORS ON THE LEFT AND RIGHT SIDE OF THE VEHICLE WILL NOT UNLOCK AFTER BEING LOCKED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PREVIOUSLY RESET THE COMPUTER WHICH WAS THE BODY CONTROL MODULE AND THE RESETTING OF TWO CODES. THE VEHICLE WILL BE TAKEN BACK TO THE DEALER FOR A SECOND REPAIR. THE MANUFACTURER STATED THIS WAS NOT A KNOWN FAILURE AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 84,000 AND THE CURRENT MILEAGE WAS 164,000.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR UNDERBODY AIR CONDITIONING LINES WERE LEAKING AND WERE COMPROMISED AT THE SEAL PLATE JUNCTION, CAUSING FREON TO LEAK. THE FAILURE WAS PREVENTING THE VEHICLE FROM PRODUCING AIR CONDITIONING IN THE VEHICLE. THE MANUFACTURER AND DEALER WERE CONTACTED BUT DID NOT ASSIST THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 85,000.

THE AIR CONDITIONING FOR THE VEHICLE HAS NEEDED TO BE RECHARGED OR A/C HEATER TUBE FOR THE REAR UNIT HAS BEEN CHANGED OUT BECAUSE OF CORROSION. EVERY YEAR THE A/C HAS NEEDED TO BE RECHARGED BECAUSE THERE IS NO COOLANT IN THE A/C SYSTEM. THIS HAS OCCURRED EVERY YEAR FOR THE PAST 5 YEARS. THIS CAUSES AN EXPENSE OF $70 TO $150 EVERY YEAR. THE FRONT CORE HAS BEEN REPLACED TO THE SUM AMOUNT OF AROUND $750 LAST YEAR. *TR

AUTOMATIC DOOR LOCKS HAVE FAILED, AND THE AUTOMATIC SLIDING DOORS HAVE FAILED. *TR

DRIVING DOWN THE ROAD. HEADLIGHTS WENT OFF AND COULD NOT GET THEM TO COME BACK ON BY TURNING ON THE HEADLIGHT SWITCH. HOW CAN I BE EXPECTED TO DRIVE IN THE DARK WITHOUT HEADLIGHTS?

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE SLIDE ELECTRIC DOOR DOES NOT OPEN ELECTRONICALLY OR MANUALLY. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE CONTACT STATED THAT CHILDREN CAN NOT EXIT THE VEHICLE ON THE PASSENGER SIDE. THE CHILDREN HAVE TO EXIT ON THE DRIVER SIDE WHICH EXITS INTO TO ONGOING TRAFFIC AND IT A SERIOUS SAFETY ISSUE. THE FAILURE MILEAGE WAS 55,970.

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT ALL OF THE ELECTRICAL DOOR LOCKS FAILED TO FUNCTION AND HE HAD TO MANUALLY OPEN AND CLOSE THEM. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE WHEN ATTEMPTING TO START, WHICH ALSO PREVENTED THE DOORS FROM LOCKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INSPECTED AND CONFIRMED THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 130,000.