2005 Dodge Grand Caravan complaints

DOORS DO NOT LOCK/UNLOCK WHEN YOU PRESS THE AUTOMATIC DOOR LOCK/UNLOCK BUTTON ON EITHER THE KEYLESS ENTRY SYSTEM OR THE DOOR ITSELF. VEHICLE WAS TAKEN TO DEALERSHIP WHO SAYS THAT THERE IS NO PROBLEM WITH THEM AND THEY ARE NOT AWARE OF ANYONE ELSE COMPLAINING. INTERNET IS FULL OF COMPLAINTS FROM CONSUMERS ON ISSUE. *TR

FAILURE OF THE AUTO DOOR LOCKING MECHANISM TO WORK WHILE DRIVING THE CAR OR TRYING TO LOCK CAR UPON EXITING THE VEHICLE. I TEMPORARILY FIXED THE PROBLEM BY REMOVING THE IOD 20 AMP FUSE FOR 20 SECONDS AND THEN REPLACING IT THUS RESETTING THE SYSTEM AND THEN IT WORKS AGAIN. MY RESEARCH LEADS ME TO BELIEVE A FAULT IN THE BCM FIRMWARE OF THE MAIN COMPUTER MODULE FOR THIS CAR. THIS COULD BE VERY DANGEROUS IN CASE OF A ACCIDENT AS YOU CANNOT UNLOCK THE DOORS INSIDE OR OUTSIDE WITH THE REMOTE IF THE DOORS ARE LOCKED MANUALLY OTHER THAN THE DRIVERS DOOR WITH THE KEY IN CASE OF AN ACCIDENT. *TR

2005 GRAND CARAVAN - DASHBOARD LIGHTS FLICKER, GAUGES GO CRAZY, RADIO DIES AND SOMETIMES ENGINE STALLS. WE HAVE NOTICED THESE EVENTS OCCUR AFTER DRIVING THE VAN 30 MINUTES OR MORE. WHERE AS THE FLICKERING WAS AN ANNOYANCE THE STALLING ISSUE COULD BE HAZARDOUS IF THIS SHOULD OCCUR ON THE HIGHWAY. SOME ONLINE RESEARCH HAS SAID A POSSIBLE PROBLEM WITH A WIRING HARNESS BUT MY CLOSEST DEALERSHIP CANT FIND THE ISSUE. *TR

2005 DODGE GRAND CARAVAN. VIN [XXX]. POWER DOOR LOCKS WILL NOT FUNCTION AT ALL. CAN ONLY LOCK EACH DOOR MANUALLY AND SEPARATELY. BEGINNING IN 2007, I TOOK THE VEHICLE TO THE DEALER ON FOUR SEPARATE OCCASIONS TO HAVE THE PROBLEM CORRECTED. DEALER FOLLOWED GUIDELINES EACH TIME AND TOLD ME THE PROBLEM WAS CORRECTED. EACH TIME THE PROBLEM RETURNED WITHIN A FEW DAYS. I CAN NEITHER LOCK OR UNLOCK THE DOORS OF THE VEHICLE USING THE KEY FOB OR THE DOOR LOCK SWITCH INSIDE THE VEHICLE. I SEARCHED ONLINE TO SEE IF OTHERS WERE HAVING THIS SAME PROBLEM, AND I IMMEDIATELY FOUND THAT THE DOOR LOCK ISSUE WAS THE MOST REPORTED PROBLEM FOR THE 2005 DODGE GRAND CARAVAN. THERE SEEMS TO BE NO "FIX" FOR THE PROBLEM WHEN TAKING THE VEHICLE TO THE DEALER. MANY CUSTOMERS HAVE REPORTED THE SAME EXPERIENCE THAT I ENCOUNTERED. THEY TOOK THEIR CARAVAN TO THE DEALER TO GET THE PROBLEM CORRECTED AND WORK WAS DONE ON THE VEHICLE, ONLY TO HAVE THE PROBLEM RECUR WITHIN A FEW DAYS OR SO. I HAVE NOT BEEN ABLE TO FIND ONE SINGLE CUSTOMER ONLINE WHO REPORTS THEY HAVE BEEN ABLE TO GET A PERMANENT SOLUTION FOR THIS ISSUE, AND CHRYSLER CORPORATION SEEMS TO BE IGNORING AND EVEN DENYING THAT THE ISSUE EXISTS. PLEASE HELP IF POSSIBLE!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

1. POWER SLIDING DOORS ON MY 2005 DODGE GRAND CARAVAN OPENED ABOUT 6 INCHES THEN STOP. NOW THEY HAVE STOPPED WORKING ALTOGETHER 2. THE FAILURE IS CONSTANT 3. I HAVE CHECKED BOTH FUSES AND RELAYS. I TOOK IT INTO MY ELECTRICAL MECHANIC BUT HE COULD NOT RUN A DIAGNOSTIC BECAUSE ONLY CHRYSLER DIAGNOSTIC TOOLS CAN READ THE DOORS. *TR

1. TURN SIGNALS OCCASIONALLY REVERSE SIGNAL RIGHT BUT LEFT SIGNAL ACTUATES, WINDSHIELD WIPERS ARE INTERMITTENT. 2. SELDOM, NEEDED TO PULL OVER IN RAIN SHOWER, HAD TO USE HAND TURNING SIGNALS 3. THE WIPER / SIGNAL SWITCH WAS REPLACED BY A MECHANIC. *TR

2005 DODGE GRAND CARAVAN SXT, DRIVERS SIDE AUTOMATIC SLIDING DOOR DOES NOT WORK.OR LOCK. *TR

HEADLIGHT SWITCH NOT WORKING. *TR

2005 DODGE GRAND CARAVAN FAILING STEERING RACK. *TR

ELECTRONIC DOOR LOCK AND UNLOCK FEATURE FAILS. THERE ARE ONLY 2 DOORS WHERE A MANUAL KEY ENTRY IS AVAILABLE, THE DRIVERS DOOR AND TAILGATE. THIS ALSO DISABLES OPENING THE SLIDING SIDE DOORS AS THEY WON'T AUTOMATICALLY UNLOCK. ALSO DISABLED ARE THE AUTOMATIC DOOR LOCKING AT SPEED FOR SAFETY. YOU CAN TEMPORARILY FIX THIS BY DISCONNECTING THE FUSE OR BATTERY FOR A SHORT TIME AND RECONNECTING. THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET ABOUT THIS PROBLEM. DODGE SHOULD FIX THIS ON A RECALL. *TR

VEHICLE SHUTS DOWN WITHOUT WARNING;POWER DOOR LOCKS INOPERATIVE AT TIMES;PREMATURE FAILURE FRONT STABILIZER BUSHINGS;PREMATURE FAILURE OUTER TIE ROD END. NO REPAIRS MADE BUT ESTIMATES HAVE BEEN OBTAINED. *TR

2005 DODGE GRAND CARAVAN-LOCKED VAN PRIOR TO GOING TO DINNER . NOTED IT DID NOT LOCK ALL THE DOORS. HAD TO GO IN AND MANUALLY LOCK ALL DOORS. NOT SURE HOW TO LOCK THE TRUNK. WHEN WE CAME OUT COULD NOT UNLOCK DOORS HAD TO GO TO ONLY KEYED LOCK AND THEN SEND MY SON IN TO UNLOCK THE REST. WENT TO INTERNET AND FOUND RESEARCHED PROBLEM. FOUND I AM NOT ALONE. PULLED FUSE AND REINSTALLED. THIS WORKS FOR A SHORT PERIOD OF TIME BEFORE IT HAS TO BE DONE AGAIN. NO WARNING WHEN IT WILL HAPPEN. WIFE IS NOT BIG ON DOING THIS AND I CAN'T BLAME HER. CAR ALARM SOUNDS LIKE ALARM IS SET BUT UNLESS YOU VISUALLY CHECK YOU CAN'T BE SURE. AKA VAN HAS BEEN LEFT UNLOCKED WHEN WE THOUGHT IT WAS ? IN ADDITION TO A HUGE PAIN IN THE BUT THIS IS A REAL SAFETY ISSUE WHEN ON TIGHT STREETS WITH SMALL KIDS(WE HAVE 5) .UNLOCKING THE VAN AND RESETTING THE FUSE OR FUMBLING AROUND TO UNLOCK THE DOORS IS NOT RIGHT. *TR

LIGHTS ON MY 2005 DODGE GRAND CARAVAN DO NOT COME ON ALL THE TIME AND WHEN THEY DO COME ON THEY TURN OFF WHILE DRIVING DOWN THE ROAD. I HAVE CHECKED THE RELAY AND IT IS FINE, I AM ABLE TO MESS WITH THE SWITCH SOMETIMES TO GET THEM TO WORK. VERY DANGEROUS WHEN TRAVELING IN DARK. *TR

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. AFTER HAVING RECALL REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER 10V008000 (AIR BAGS: FRONTAL: SENSOR/CONTROL MODULE), THE AIR BAG WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE CONTACT WAS ADVISED THAT THE FAILURE WAS NOT ASSOCIATED WITH THE RECALL. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THE AIR BAG WARNING LIGHT WOULD ONLY ILLUMINATE WHEN MAKING A RIGHT OR LEFT TURN. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 70,000.

A 2005 DODGE GRAND CARAVAN SXT. THE CLUSTER GAUGES WILL BOUNCE AROUND AND THE LIGHTS, RADIO, ETC., FLICKER. THE CAR HAS DIED WHILE IDLING. IT HAS DIED WHEN ACCELERATING TO TURN AT A STOP LIGHT. IT HAS DIED WHILE STOPPED AT A STOP LIGHT. OCCASIONALLY THE CAR WILL NOT RESTART RIGHT AWAY AFTER IT HAS DIED. I HAVE NOT BEEN IN AN AUTOMOBILE ACCIDENT AS OF YET, BUT I AM EXTREMELY CONCERNED THAT THIS COULD LEAD TO ME AND MY CHILDREN (WHOM I ALMOST ALWAYS HAVE IN THE CAR WITH ME) BEING INVOLVED IN AN ACCIDENT. OCCASIONALLY THE WIND SHIELD WIPERS HAVE JUST STOPPED WORKING AND THE ELECTRIC DOORS WON'T WORK AND OTHER RANDOM ELECTRICAL ISSUES. WE HAVE TAKEN THE CAR TO THE DEALERSHIP AND THEY TOLD US THAT THE BATTERY HAD AN INTERNAL SHORT IN IT. SO THEY REPLACED THE BATTERY AND SAID THAT ALL WAS FIXED. THAT WORKED FOR ABOUT A WEEK AND NOW WE ARE BACK TO SQUARE ONE. I HAVE FOUND MANY COMPLAINTS ABOUT THIS PROBLEM ON DIFFERENT WEBSITES FROM PEOPLE WITH THE SAME YEAR OF VAN AND NO ONE SEEMS TO HAVE FOUND A WORKING SOLUTION. I THINK IT IS RIDICULOUS THAT DODGE CAN NOT SEEM TO FIX THIS PROBLEM OR DOESN'T SEEM TO KNOW WHAT THE PROBLEM IS WHEN THERE ARE SO MANY OTHER PEOPLE WITH THE SAME ISSUE. THIS IS DEFINITELY A POTENTIALLY LIFE-THREATENING DEFECT IN THIS VAN AND SHOULD BE ADDRESSED ASAP!!! *TR

ENGINE STALLS AFTER DRIVING A FEW BLOCKS AFTER REFUELING CREATING A DANGEROUS SITUATION. *TR

2005 DODGE GRAND CARAVAN - POWER DOOR LOCK FAILURE/INTERMITTENT OPERATION. TEMPORARY FIX OF REMOVING FUSE NO LONGER WORKS. ISSUING OCCURRING EVEN WHEN TRYING TO LOCK DOORS WITH REMOTE. OBVIOUS MANUFACTURE ISSUE DUE TO NUMEROUS SIMILAR COMPLAINTS, DEALER NETWORK IS AWARE OF TSB, DEALERSHIPS WILLING TO CHARGE FOR DIAGNOSIS OF KNOWN ISSUE. *TR

WE OWN A 2005 DODGE GRAND CARAVAN WITH 74.000 MILES ON IT. THE POWER LOCKS WILL REPEATEDLY LOCK WHEN I USE MY KEYLESS REMOTE ENTRY OR THE OVERHEAD CONSOLE BUTTONS TO OPEN THE SLIDING DOORS. THESE DOORS SHOULD BE UNLOCKING BUT INSTEAD EVERYTHING IS LOCKING. WHILE I'M DRIVING, I CAN HEAR THE CLICKING OF THE LOCKS "RE-LOCKING" EVEN THOUGH THEY ARE IN THE LOCKED POSITION. THIS HAPPENS WHEN THE REAR WIPER IS RUNNING OR I PRESS AND RELEASE THE WINDOW CONTROL BUTTON. SOMETIMES I HIT THE POWER LOCK BUTTON ON THE DRIVER DOOR TO LOCK ALL DOORS BUT NOTHING LOCKS. I HAVE HAD THIS HAPPEN BEFORE, BUT FOR SHORTER PERIODS OF TIME. WITH 5 DOORS OF ENTRY, I NEVER KNOW IF MY CAR IS TRULY LOCKED. *TR

MY 2005 DODGE GRAND CARAVAN SXT MINIVAN HAS TWO POWER SLIDING DOORS. BOTH POWER SLIDING DOORS HAVE FAILED. IT IS DIFFICULT TO OPEN THE DOORS MANUALLY. I AM REQUESTING THAT DODGE ISSUE A RECALL TO FIX THE NUMEROUS 2005 DODGE GRAND CARAVAN POWER SLIDING DOORS THAT HAVE FAILED. *TR

I HAVE A 2005 DODGE GRAND CARAVAN. LAST NIGHT MY WIFE AND I WERE TRAVELING ON I-15 FROM LAS VEGAS AT APROX.TIME 9PM IN THE DARK AND OUR HEADLIGHTS TURNED-OFF AND THEN TURNED ON RANDOMLY. THIS WAS AN AWFUL EXPERIENCE DRIVING LIKE THIS FOR MORE THAN 100 MILE IN THE MOJAVE DESERT. CARS THOUGHT I WAS FLASHING THEM. I WAS DRIVING IN THE SLOW LANE AT ONE POINT BEHIND A TRUCKER, I BELIEVE HE THOUGHT I WAS FLASHING HIM. I PASSED HIM AND THEN HE GOT ON MY BUMPER AND HE FLASHED HIS LIGHTS ON OFF SEVERAL TIMES AT ME..I WAS SCARED... THIS SHOULD BE A RECALL....ITS NOT SAFE.!! ....AN ACCIDENT COULD HAVE HAPPENED NOT BEING ABLE TO SEE THE ROAD... [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN THE HEADLIGHTS ARE TURNED ON, THEY DO NOT WORK. THE PARKING LIGHTS AND INTERIOR LIGHTS WORK BUT NOT THE HEADLIGHTS. IT WAS HAPPENING ONCE OR TWICE A MONTH, BUT NOW IT'S 3-4 TIMES A WEEK. WHEN DRIVING AT NIGHT, IT IS A HAZARD. *TR

I HAVE A 2005 DODGE CARAVAN IM HAVING TROUBLE WITH THE DOOR LOCKS NOT WORKING IF YOU PULL THE FUSE AND REINSERT IT WILL FIX THE PROBLEM FOR A DAY OR TWO ALSO WHEN DRIVING AT NIGHT THE HEADLIGHTS WILL FLICKER UNLESS YOU HAVE THE HEATER/AIR CONDITIONER BLOWER ON HIGH. *TR

INTERMITTENT HEADLIGHT FUNCTION WITH 2005 DODGE GRAND CARAVAN. MY HEADLIGHTS TURNED OFF BY THEMSELVES ON 2 SEPARATE OCCASIONS LAST NIGHT WHILE DRIVING IN THE DARK. I HAD TO CYCLE THE HEADLIGHT SWITCH A FEW TIMES TO GET THEM TO WORK. THIS IS A VERY DANGEROUS SITUATION. INTERNET RESEARCH REVEALED MANY COMPLAINTS ABOUT THIS EXACT ISSUE. *TR

THE PARKING BRAKE CABLE ROUTING ON DODGE G CARAVAN, 2005, SXT. THE CABLE IS RUBBING THE REAR VERTICAL SWAY BAR LINK CAUSING THE RUBBER ON THE LINE TO DETERIORATE AND POSSIBLY CAUSE BREAKAGE OF THE CABLE THUS LEADING TO PARKING BRAKE FAILURE. THE PARKING BRAKE CABLE WAS RE-ROUTED TO AVOID CONTACT WITH THE SWAY BAR LINK. *TR

HEADLIGHTS WILL NOT TURN ON AND HAVE TURNED OFF (ON THEIR OWN) WHILE DRIVING. THIS HAS HAPPENED BEFORE AND I HAD TO MESS WITH THE SWITCH REPEATEDLY ON MULTIPLE OCCASIONS BEFORE THE LIGHTS WOULD COME BACK ON. ALSO, THE DOOR LOCKS STOP LOCKING/UNLOCKING AND WE HAVE TO PULL THE FUSE, THEN PUT IT BACK IN FOR THEM TO WORK AGAIN. VEHICLE IS A 2005 DODGE GRAND CARAVAN SXT. *TR

I HAVE A 2005 DODGE GRAND CARAVAN AND HAVE HAD NOTHING BUT ELECTRICAL PROBLEMS WITH IT. OUR AUTOMATIC SLIDING DOOR ON PASSENGER SIDE HAS BEEN REPAIRED ONCE ALREADY AND QUIT WORKING ABOUT 6 MONTHS LATER. OUR POWER DOOR LOCKS NOW WILL NOT WORK WITH EITHER THE KEY FOB OR FROM INSIDE ON THE SWITCH. THE LIGHTS ON THE DASH GO OUT AND COME ON A VARIOUS TIMES. THESE ARE SERIOUS ISSUES AND DEALERSHIPS ARE CHARGING AN ARM AND LEG TO JUST LOOK AT IT AND YOU STILL AREN'T GUARANTEED HOW LONG IT WILL REMAIN FUNCTIONAL.*TR

2005 DODGE GRAND CARAVAN SXT. REAR PASSENGER SIDE AUTOMATIC DOOR LOCK DOES NOT AUTOMATICALLY LOCK OR UNLOCK. *TR

I HAVE A 2005 DODGE GRAND CARAVAN SXT MODEL AND THE AUTOMATIC DOOR LOCKS NO LONGER FUNCTION. THIS APPEARS TO BE A COMMON PROBLEM WITH THIS MAKE/MODEL YEAR. THIS IS NO SAFE AS THE ONLY WAY TO UNLOCK VEHICLE IS WITH KEY AT DRIVERS SIDE DOOR. THERE ARE NO OTHER DOORS WITH KEY ACCESS. THIS COULD BE VERY DANGEROUS IN A CRASH OR OTHER EMERGENCY SITUATION. *TR

HEADLIGHTS AND DASH LIGHTS INTERMITTENTLY FLICKER OR GO OUT FOR SHORT PERIODS OF TIME WHILE DRIVING. GAUGES ON DASHBOARD ARE ALSO AFFECTED, WITH SPEEDOMETER FLUCTUATING LIKE CRAZY. THIS HAS HAPPENED SEVERAL TIMES OVER THE PAST YEAR. SEEMS TO BE WORSE IN DAMP WEATHER. MECHANIC HAS FAILED TO FIND CAUSE. *TR

HEADLIGHTS RANDOMLY GO OUT. *TR

REAR LH SLIDING DOOR ON 2005 DODGE GRAND CARAVAN NO LONGER OPERATING NORMALLY. DOOR STOPS 8" AND MUST BE MANUALLY MOVED THEREAFTER. *TR

2005 DODGE GRAND CARAVAN HAS PROBLEM WITH HEADLIGHTS TURNING ON. IT HAS HAPPENED 2 TIMES THIS WEEK. WHEN I TURN THE SWITCH, THE HEADLIGHTS WILL NOT COME ON. PARKING LIGHTS DO COME ON. BUT AN HOUR LATER WHEN I TURN THE SWITCH, THE HEADLIGHTS COME ON.

2005 DODGE GRAND CARAVAN ALL DOORS LIKE QUIT WORKING. THEY HAVE A BCM SOFTWARE UPDATE THAT FIXES THE PROBLEM. THIS SHOULD BE A RECALL NOTIFICATION.

2005 DODGE CARAVAN POWER DOOR LOCKS QUIT WORKING. ONLY 55,000 MILES ON VEHICLE. THERE IS ONLY ONE KEYED ENTRY INTO THE VEHICLE, MAKING THIS A SAFETY THREAT. THIS IS A WELL-KNOWN ISSUE THAT IS REPORTED ON NUMEROUS WEBSITES, INCLUDING WWW.CARCOMPLAINTS.COM. PROBLEM SEEMS TO BE WIDESPREAD ON THE CARAVAN AND TOWN & COUNTRY MODELS, OCCURRING BETWEEN 50-70,000 MILES. CHRYSLER/DODGE IS NOT RECOGNIZING THIS AS A SYSTEMIC ISSUE WITH THE PLATFORM ALTHOUGH FREQUENCY OF OCCURRENCE WOULD SUGGEST OTHERWISE.

2005 DODGE GRAND CARAVAN HEADLIGHTS INTERMITENTLY WILL NOT TURN ON OR TURN OFF WHILE DRIVING DOWN THE ROAD RESULTING IN LOSS OF VISIBILITY. MAY CASES OF THIS CAN BE FOUND ON INTERNET AND MY OWN DEALERSHIP SERVICE CENTER INDICATED IS A KNOWN ISSUE WITH SWITCH ($100+ FOR NEW SWITCH). FEEL THIS IS A SAFETY ISSUE AND SHOULD BE REQUIRED RECALL. *CN

I WAS DRIVING ALONG AT NIGHT AND THE HEAD LIGHTS JUST TURNED OFF. I PLAYED WITH THE SWITCH AND THEY CAME BACK ON IT HAS HAPPENED SEVERAL TIMES I HAVE BEEN ABLE TO GET THEM TO COME BACK ON SO FAR. IT IS ONLY A MATTER OF TIME BEFORE THIS PROBLEM DOES SERIOUS DAMAGE. *DT

MY 2005 DODGE GRAND CARAVAN HEADLIGHTS INTERMITTENTLY GO OFF AND WON'T WORK. THIS IS A REAL SAFETY ISSUE. *TR

MY 2005 DODGE GRAND CARAVAN POWER LOCKS HAVE QUIT WORKING. IT HAPPENED BACK IN 2006 WHEN I BOUGHT THE VAN. I HAVE RESET THE FUSE SEVERAL TIMES BUT NOW IT GETS SHORTER AND SHORTER BETWEEN RESETS. SEVERAL OTHER DODGE GRAND CARAVAN OWNERS ARE HAVING THIS SAME PROBLEM. MY WIFE DRIVES THE KIDS IN THIS VAN AND NOT KNOWING IF THE VAN LOCKS OR NOT IS VERY DANGEROUS. WHEN LOCKED EVERYTHING "SOUNDS" LIKE IT IS LOCKING SO IT IS HARD TO TELL WITHOUT PAYING VERY CLOSE ATTENTION. *TR

THE DOORS FAIL TO LOCK AT 18 MPH, AND UPON EXITING THE CAR WITH THE KEY FOB. IT OCCURS RANDOMLY, CONSEQUENCES ARE THE DOORS ARE NOT LOCKED WHILE DRIVING (YOU CAN'T LOCK IT), AND WHEN YOU LEAVE THE CAR, THE DOORS ARE UNLOCKED. REMOVING AND REPLACING THE IOD FUSE SEEMS TO CORRECT THE PROBLEM FOR A PERIOD OF TIME. *TR

THE HEADLIGHTS ON MY 2005 DODGE GRAND CARAVAN WENT OUT WHILE DRIVING. FOG LIGHTS COME ON AND GO OFF RANDOMLY. WITHOUT KEY IN THE IGNITION. THIS HAPPEN SHORTLY AFTER WE BOUGHT THE VAN IN 2005. THE DEALER SAID IT WAS THE SWITCH AND REPLACED IT. BUT THE LIGHTS HAVE BEEN COMING ON RANDOMLY EVERY SINCE. NOW, THE HEADLIGHTS WENT OUT WHILE WE WERE DRIVING. A SWITCH ISN'T THAT COMPLICATED. *TR

MY 2005 DODGE GRAND CARAVAN LIGHTS SHORT OUT RANDOM TIMES. I CAN BE DRIVING DOWN THE HIGHWAY AND THEY WILL QUIT WORKING. I HAVE TO TURN THE LIGHTS ON BRIGHT FOR THEM TO WORK AGAIN. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT ALL OF THE POWER DOORS FAILED TO LOCK. THE DEALER REPROGRAMMED THE DOOR LOCK CONTROL MODULE, TO NO AVAIL. HE THEN REPLACED THE WIRING HARNESS IN AN ATTEMPT TO CORRECT THE FAILURE. AFTER THE REPAIRS, THE CONTACT NOTICED THAT THE AIR BAG WARNING LIGHT SPORADICALLY ILLUMINATED ON THE WARNING PANEL. THE DEALER ADVISED HER THAT THERE WERE NO RELATED RECALLS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 63,000 AND THE CURRENT MILEAGE WAS 95,000.

RECENTLY FOUND THE AIR BAG LIGHT COME ON. THE PROBLEM PERSISTED AFTER THE CLOCK SPRING WAS REPLACED. THE PROBLEM WAS TRACED TO FRONT AIRBAG IMPACT SENSORS AND SUB WIRING HARNESSES. I FOUND MANY COMPLAINTS AND RECALLS BASED ON THE YEAR AND STATE THE VEHICLE IS IN. MY CAR WAS ORIGINALLY SOLD IN VIRGINIA AND I BOUGHT IT USED IN NC. IF THE CAR WAS STILL IN VIRGINIA, IT WOULD HAVE BEEN COVERED UNDER THE AUGUST 2007 RECALL. THE RECALL SHOULD BE EXPANDED TO READ "ANY VEHICLE PURCHASED IN THESES STATES XXXX IS SUBJECT TO THIS RECALL". *TR

DODGE 2005 GRAND CARAVAN. DRIVER SIDE DOOR WOULD REFUSE TO OPEN WITH INSIDE BUTTON BY DOOR. WOULD OPEN IF PUSHED CONSOLE BUTTON. THE DOOR WOULD DECIDE THAT IT WAS NOT CLOSED PROPERLY AND FULLY OPEN WHILE DRIVING. (VERY DANGEROUS). THE PASSENGER SIDE WOULD OPEN ONLY IF YOU USED THE KEY BOB AND HAD A JERKY MOTION THAT WOULD TRIP A SENSOR AND CLOSE THE DOOR(USUALLY ON A PASSENGER GETTING IN OR OUT OF THE VEHICLE. THE DOOR WAS ADJUSTED AND DOOR MOTOR REPLACED. STILL HAD A PROBLEM WITH THE DOOR OCCASIONALLY BUMPING THE SIDE OF THE VEHICLE. VERIFIED THAT THE VEHICLE HAD NOT BEEN IN AN ACCIDENT AND RESOLVED BY LEAVING THE PLASTIC INTERIOR DOOR COVER OFF. THE PROBLEM WITH THE DOORS OPENING AND CLOSING BY THEMSELVES WAS FOUND IN BOTH CASES TO BE LINKED TO THE DOOR WIRING HARNESS. ALSO BOTH DOOR REFUSE TO LOCK (NOT A THING THAT YOU CHECK WHEN LOOKING AT A CAR AND WAS FOUND BY ACCIDENT) SEARCHING THE INTERNET SHOWED THAT THIS WAS A WELL KNOWN PROBLEM. *TR

THIS WEBSITE SHOWS JUST A SAMPLE OF THE PEOPLE HAVING TROUBLE WITH THEIR 2005 DODGE CARAVANS' DOOR LOCKS THAT QUIT WORKING...IT'S A SAFETY ISSUE AND DODGE ISN'T DOING ANYTHING ABOUT IT. HOW AM I TO KEEP MY KIDS FROM OPENING DOORS? WE'RE SO BUSY TAKING ISSUE WITH TOYOTA THAT WE'RE IGNORING DODGE'S INABILITY TO DO THE RIGHT THING. PLEASE TAKE THIS AS AN ISSUE --- HOW MANY PEOPLE MUST COMPLAIN BEFORE YOU DO SOMETHING ABOUT IT? DODGE WANTS TO REPLACE A MODULE...BUT AS YOU'LL SEE FROM THE SITE BELOW IT DOESN'T FIX IT. HTTP://WWW.CARCOMPLAINTS.COM/DODGE/CARAVAN/2005/ELECTRICAL/POWER_DOOR_LOCKS_QUIT_WORKING.SHTML. *TR

STARTED HEARING GRINDING NOISE WHEN TURNING SEVERAL MONTHS AGO. DODGE DEALERSHIP DIAGNOSED IT AS FAULTY STRUT AND SPRING AND REPLACED. GRINDING NOISE CONTINUED. NOW, DODGE DEALERSHIP DIAGNOSED AS LEAKING POWER STEERING RACK - WANT $1,100+ TO REPLACE. *TR

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AS HE STARTED HIS VEHICLE AND STEPPED ON THE ACCELERATOR PEDAL,THERE WAS RESISTANCE. WITHIN MINUTES, THE VEHICLE BEGAN TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE OR REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 20,000.

AUTOMATIC DOOR LOCKS DO NOT WORK. CAN PUSH LOCK DOWN BUT KEY AND AUTOMATIC LOCKS DO NOT WORK. HAD TO CRAWL THROUGH BACK OF VAN. CHILDREN LOCKED IN CAR UNABLE TO OPEN LOCKS. *TR

2005 DODGE GRAND CARAVAN THE ANTI-LOCK BRAKE LIGHT CAME ON. THE DEALER HAD TO REPLACE BRAKE MODULE AND THE RIGHT FRONT WHEEL SENSOR. *DT

THE 2005 DODGE GRAND CARAVAN HAS A SERIOUS HEADLIGHT SAFETY ISSUE. SOMETIMES WHEN YOU SWITCH TO THE ON POSITION, THE HEADLIGHTS ARE OFF. I HAVE REPORTED TO DODGE IN NOVEMBER 2006 (REFERENCE NUMBER: 15635986). THEY ASKED ME TO HAVE THE DEALER TO FIX IT. BUT THE DEALER WAS UNABLE TO FIND THE PROBLEM BECAUSE IT ONLY HAPPENED IN RARE CASES. I KNEW IT HAPPENED ABOUT 10 TIMES THESE YEARS. BUT PERHAPS SOMETIMES I DROVE IT WITHOUT KNOWING THE HEADLIGHTS WERE ACTUALLY OFF. *TR