2005 Cottrell C-8enc

Routine

No owner complaints are on file for this vehicle. It has been recalled 1 time.

1 safety recall

Part 573 reports

Structure › Body › Roof and Pillars07V548000

Filed Dec 3, 200768 vehiclesCottrell, Inc.

Defect. ON CERTAIN CAR HAUL TRAILERS THAT ARE EQUIPPED WITH ROOFS THAT RAISE AND LOWER, THE ROOFS ARE ATTACHED TO A RAISING/LOWERING MECHANISM BY ROUND TUBES THAT ARE WELDED TO THE ROOF. THERE ARE 4 TUBES WELDED TO EACH ROOF AND 2 ROOFS PER EACH COMPLETE PIECE OF EQUIPMENT. THE BASE MATERIAL AROUND THE WELDED CONNECTION MAY EXPERIENCE A FATIGUE FAILURE DURING HIGH MILEAGE OPERATION.

Risk. SHOULD FAILURE OCCUR ON ALL FOUR LIFT POINTS, THE ROOF MIGHT SEPARATE FROM THE TRAILER INCREASING THE RISK OF A CRASH TO FOLLOWING VEHICLES.

Remedy. COTTRELL OR A REPAIR FACILITY AUTHORIZED BY COTRELL WILL ADD AN ADDITIONAL WELD PASS AROUND THE ROOF LIFT TUBE, INSTALL AN INNER AND OUTER GUSSET TYING THE ROOF INTO THE ROOF LIFT TUBE FREE OF CHARGE. THE RECALL BEGAN PRIOR TO NOVEMBER 21, 2007. ALL OWNERS HAVE BEEN CONTACTED.

Across model years

Worst on record: 2008

Year	Recalls	Assessment
2008	1	Routine
2007	1	Routine
2006	1	Routine
2005 — this page	1	Routine
2004	2	Routine
2003	2	Routine

Compare every C-8enc year →

Other Cottrell models

All Cottrell models →

Trailer 3

Reading this record

No unusual pattern of severe incidents in the complaint record.

Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.

Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.

Most recent recall on file: Dec 3, 2007. Source: NHTSA Office of Defects Investigation.