2020 Chevrolet Traverse complaints

Vehicle is current at 101,102 Miles, however, the issue started to occur at 75,350 miles. It is the common issue crack in the exhaust pipe just before the flex exhaust tube due to poor welding of the bracket causing the exhaust system to rattle and leak exhaust into the cabin. The same issue has been addressed under Special Coverage N222385510 for 2021 vehicles, and another one was issued for 2019 Chevrolet Traverse and Buick Enclave vehicles. GM Bulletin PIP5681C describes the issue in detail and acknowledges that the same process was used on their 2018-2022 vehicles, but they are only covering the repair of the 2019s and 2021 vehicles. Exhaust fumes do reach inside the cabin of the vehicle especially on calm mornings that have no breeze. This is a potential carbon monoxide hazard. The is no scrape marks or damage to the undercarriage that would have caused the issue, only the heating and cooling of the exhaust system.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while the vehicle was parked and occupied in the vehicle, there was a rattling sound coming from the front of the vehicle while stationary or while driving. An independent mechanic was contacted. The vehicle was taken to a dealer, where it was determined that the exhaust mounts needed to be replaced. The vehicle was not repaired. The contact related the failure to Special Coverage Adjustment: N222385510 (Front Exhaust Pipe); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 118,000.

The vehicle just suddendenly shuts down when driven on the freeway, according to Tillery Chevrolet GMC the engine cracked and needed to replaced for total of $17,291.94

The backup camera system on my 2020 Chevrolet Traverse fails repeatedly and intermittently. When shifting into reverse, the camera frequently displays a black screen, a crossed-out camera icon, or an error message indicating the camera is unavailable. I have brought the vehicle to a Chevrolet dealership multiple times for this issue. The dealer has replaced the rear/front camera twice and replaced a corroded cable, but the problem continues to occur. The repairs have not permanently resolved the issue. The failure happens unpredictably and makes it unsafe to reverse the vehicle, especially around pedestrians, children, or obstacles. This vehicle is equipped with a federally required backup camera, and its repeated failure presents a safety concern. The problem appears to be a recurring defect rather than normal wear, as many other Chevrolet Traverse owners have reported similar issues online. I am concerned this may indicate a broader defect affecting this model year.

Burning oil. There is something wrong. I took it to the dealership i still have warranty i really think this needs to be looked into.

The contact's son owns a 2020 Chevrolet Traverse. The contact stated that while driving at various speeds, the vehicle made an abnormal rattling sound, and the check engine warning light was illuminated. The vehicle was initially taken to an independent mechanic who could not perform the repair. The contact was referred to another independent mechanic, where it was diagnosed that a crack in the catalytic converter had caused a defect within the exhaust manifold. The contact was then informed that the failure was related to Technical Service Bulletin Number: PIP5681C and was referred to the dealer for assistance. The contact had taken the vehicle to the dealer, where the contact was informed that the vehicle no longer qualified for the TSB repair due to the mileage. The manufacturer was notified of the failure and made the same assessment. The contact was then referred to the NHTSA Hotline for assistance. The vehicle had yet to be repaired. The failure mileage was approximately 90,100.

Weld on exhaust was faulty the bracket malfunction. The exhaust system has leak and rattle with exhaust noises, causing the converter fail.

Leaking exhaust noise at start up began around 9/22/25. Noise became louder over the following week. Check engine light came on morning of 9/24/25. Immediately took it to local GM dealership for inspection. Dealership first said it was a cracked front exhaust pipe at the bracket and then they called back and said rear pipe at the bracket was broken also the whole system needed to be replaced because the brackets were not separate but welded directly to the pipe. The estimate was over $1300. Dealership then said the error coded was probably because of the exhaust pipe and catalytic converter and that they require replacement. I discovered there are already recalls and special coverage for the same issue on the 2019, 2021 and 2022 year models of this vehicle. I contacted GM and they acknowledged the problem in other model years before and after but said there isn't enough complaints for this model year. This is a known problem and design flaw. This needs to be addressed by GM immediately. NONE of the welds have held on any parts of the exhaust system or the catalytic converter.

Due to exhaust bracket failure where converter with muffler and side down pipe needs replaced. This was diagnosed at the Chevy dealer and appointment for repair is made. The exhaust suddenly became very loud so I took it to the dealership. There were no messages or warning lamps.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at undisclosed speeds, there were abnormal sounds coming from the exhaust system. The contact stated that the vehicle sounded like a motorcycle. The contact stated that the check engine warning light was illuminated, and DTC: P0171 was displayed. Additionally, the contact stated that there were exhaust fumes entering the cabin of the vehicle. The contact had taken the vehicle to a local dealer, where it was diagnosed, and it was determined that there were cracks in the exhaust pipe and the catalytic converter pipe at Bank 2 and Bank 1 that needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin Number: PIP5681A. The contact had called the dealer to advise that there was a bulletin covering the cracks on the exhaust and the catalytic converter pipes, but was informed that the cracks on the pipes were on the wrong side and that the vehicle was not covered under warranty. The manufacturer was not informed of the failure. The failure mileage was 110,045.

When I put my car in park and turn it off I get an error message that I need to "Shift to Park". It shows in the dash that it is in park but my radio, and lights stay on. I have to restart my car and put it in park, reverse, or neutral and try to put it in park again. I takes several try's to make the error message go away.

The car has 45,000 and started burning oil. The car is in brand new condition and well under mileage for an issue of such to be occurring. Took to car dealership where purchased and was told $8,500 fix!

A few months ago I was driving and without any warning the steering wheel would lock up and I couldn’t turn it at all. I had to use my strength to wiggle it to unlock it. It happened several times on busy roads and highways. It’s currently at the dealership for the past 2 months because there is a short and the steering gear box needs to be replaced but the part is on back order with no date of when it’ll become available. I obviously can’t drive it due to the steering locking up and that it’s a danger to not only myself and my family but other drivers on the road. Anyone could have been seriously injured or killed had it locked up and caused an accident. It would happen no matter what speed I was going.

Receiving a persistent “Shift to Park” message, after the car has been placed in Park. This causes an inability to turn off my engine completely and is draining my battery. As a temp fix, I've had to wiggle the shifter many times, turn the car on and off, place the car from park into drive many times to get the car to realize it's in Park. Scheduled with the dealership and referenced the TSB that was issued for this specific safety issue (in writing). Brought the car in for the repair and the technician and intake person were both aware of this major problem and have seen other Chevy's with the same issue. Repair is $809.00 for a shifter assembly. [XXX] - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

19 Sep 2025. The headlights turn off at night while driving. With the switch in the "auto" position, I turned the switch to "off" then back to "auto" and they came back on for a short period of time. They turned off again, I turned them to "on", they came back on for a brief period. I had to keep switching the headlight switch from "on" to "off" and back to "on" every 20 to 30 seconds (estimated) to keep driving. The dealership could not schedule a diagnosis until 8 Oct 2025. This is a potentially fatal issue.

Rattling noise when starting vehicle started occurring a year ago. Dealership diagnosed a broken bracket weld that holds the exhaust pipes in place. Dealership cut off bracket. A year later there is a hole in one of the exhaust pipes because of the broken bracket and a check engine light comes on. There is a recall for the 2018-2023 Traverse models EXCEPT the 2020 year for the exact same issue. Why is every other covered but not the 2020? Why do I have to pay for a known GM issue that causes a hole in the exhaust pipes from their crappy bracket welds? This is an emissions issue yet we are being denied by our dealership.

Exhaust started to rattle, now it is a loud clangy exhaust. Clearly a part has separated or there are holes in it. Dealership told me my car has a repair out for that for years 2019, 2021, 2022 and 2023 but NOT my year, 2020.

I own two 2020 Chevrolete Traverse. I am currently dealing with my second one that has an exhaust leak at the forward joining exhaust bracket. This is a poor design for a hanging exhaust and is a known issue for the 2019 and 2021 models, but not the 2020. These other years have a special coverage to repair the forward exhaust but not the 2020 traverse because there have not been enough reports on it. I already paid out of pocket to repair my other 2020 traverse with this known problem and I refuse to do it again because of a design flaw. This needs to be addressed by Chevrolete immediately.

Slipping in low gears of transmission. Shaking of vehicle. Potential to break down.

Exhaust and catalytic converters keep breaking off causing loud noise and check engine light to stay on

Check engine light came on day after I purchased this vehicle. Cracks in both front exhaust pipes. Seem to be an issue with 2020 chevy traverse models.

I recently had to replace my transmission (2020 Chevrolet Traverse) due to shuddering from manufacturer's fault in assembly process. Now I'm having to replace the transmission in my mother's 2018 Chevrolet Colorado that has less than 65k miles. These issues cause power loss while driving. I was in the middle of passing another vehicle when my vehicle experienced power loss. This is a HUGE safety issue, not only for my family but many others that I know that are experiencing or have experienced the same issues. I have 3 family members that have had to have the same repairs as well as over 40 acquaintances. I had assumed with the thousands others that I've chatted with on facebook and reddit that this would have been a recall, sadly, GM/Chevrolet doesn't seem to care that it is their fault that their consumers are having to spend THOUSANDS of dollars to correct an issue that leaves the manufacturer at fault. With the thounsands experiencing the same issue, i feel that those that have already had to spend money should be reimbursed.

Catalyst converter bracket on the front of my exhaust is broken causing loud noise and the check engine light to remain on. This should be in connection with specialized coverage program N212356540

Severe transmission shudder, issues accelerating. Torque converter failure is very common with this vehicle, even with following routine scheduled maintenance. There is no engine or MIL light on and symptoms appeared out of nowhere. Failing to be able to safely accelerate can cause accidents, putting lives and property at risk. Looking information up online will show that this is a very common issue with this model year and transmission.

Ive got this vehicle on 5/12/2025 and all of this need to be done CATALYTIC CONVERTER REPLACEMENT. DURING INSPECTION FOUND LOUD EXHAUST ON STARTUP. UPON FURTHER INSPECTION FOUND BANK 1 CATALYTIC CONVERTER CRACKED CAUSING EXHAUST LEAK. BOTH EXHAUST FRONT PIPES DAMAGED AS WELL(BROKEN MOUNTING BRACKETS BETWEEN BOTH PIPES) . RECOMMEND REPLACEMENT OF CATALYTIC CONVERTER AND BOTH EXHAUST FRONT PIPESBRAKE SYSTEM FLUID EXCHANGE-PERFORMED PRESSURIZED FLUID EXCHANGE OF OLD BRAKE FLUID, REMOVED MOISTURE AND AIR CONTAMINATION FROM BRAKE SYSTEM. INSTALLED NEW DOT SPECIFIC FLUID TO MEET MANUFACTURE SPECIFICATIONSAUTOMATIC TRANSMISSION SERVICE FLUID EXCHANGECF - COOLING SYSTEM SERVICE 6830/5881-01 INCLUDES FLUSH COOLING SYSTEM, PRESSURE TEST, CHECK HOSES, CAP AND CHECK CONNECTION. INSTALL COOLING SYSTEM CORROSION CONTROL KIT Drain old Transfer case fluid and replace with new fluid REAR DIFFERENTIAL SERVICE This should have been done when the dealership got the vehicle, and it should be GM or BERGER responsibility. I am sure this was an issue to begin with.

The alternator failed randomly while driving down the road. The vehicle only has 26500 miles. There was no lights on prior to the car stalling. When it failed my whole car started to flash every warning at the screen to me. My car then stopped working and I barely was able to coast into a parking lot. Luckily I was not on the highway and no one was behind me when the car stopped working. The problem was confirmed by the dealer it was the alternator. What sucks though is that the alternator killed the battery. The battery is not covered by warranty so it is $507 to replace a battery.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who retrieved diagnostic trouble code: P0091 (Fuel Pressure Regulator 1 Control Circuit Low). The contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,000.

Leaking exhaust noise at start up began around 7/14/25. Noise became louder over the following week. Check engine light came on morning of 7/25. Immediately took it to local GM dealership for inspection. Dealership first said it was a cracked front exhaust pipe but then they also determined that the check engine light was from the catalytic converter. Dealership said both the exhaust pipe and catalytic converter require replacement. Through research, we discovered there are already recalls and special coverage for the same issue on the 2019, 2021 and 2022 year models of this vehicle.

July 2025 the transmission started stuttering. Took to an outside transmission shop, report showed torch converter failure.

Cracked exhaust & bracket back in 2023 causing a loud rattling noise. Now catalytic converter is cracked & gasket leak. Dealer does have notes that it was cracked & they noticed it in 2023 at 46k miles & that converter has now cracked causing engine light to turn on. Car does not speed up properly & GM only wants to cover 30 percent of cost.

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving at various speeds, the vehicle made an abnormally loud rattling sound. The contact stated that the failure also occurred upon starting the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the mounting bracket on the front exhaust pipe had separated from the pipe and might develop a hole in the exhaust pipe. The dealer determined that the front exhaust pipe mounting bracket needed to be replaced. The vehicle was not repaired due to the cost. The dealer notified the manufacturer of the failure, but no assistance was provided. The failure mileage was approximately 85,000.

Exhaust system developed a hole due to poor weld, Bulletin # PIP5681A. Updated 10-5-20 to include 2020 Traverse. Fumes are getting into the cabin.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while parking the vehicle, the message “Shift to Park” was displayed and the contact was unable to turn off the vehicle. The contact stated that there was no warning light illuminated. Additionally, while driving at various speeds, the vehicle jolted abnormally while accelerating. The local dealer was contacted; however, the vehicle was not diagnosed since the VIN was not under an open recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 107,000.

For the last year or so my car keeps making this really loud noise and it gets worse within hours/days. We have had it in 3 maybe even 4 different shops to have an exhaust fixed. One shop said that a part of it was never secured like it should have been and they fixed it. Every time we have had it fixed it does it again within a couple weeks/month. I did some research and saw a bunch of people are having the same issue with theirs.

Vehicle started to show error for shift to park. Not able to shut vehicle off. Vehicle drives fine but when I go to park and vehicle is in park. I go to turn vehicle off and error appears. I called dealership according to them just to look at vehicle its going to cost me $275.. For everything else $1,100. After reading all the complaints on this issue why has manufacture done anything. Obviously this is a well known problem I've always loved my chevy

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 55 MPH, there was an abnormally loud sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an unknown dealer, where it was diagnosed and determined that the catalytic converter was leaking and there was a blockage in the catalytic converter. The contact was also informed that coolant was leaking into the engine. The vehicle was not repaired. The contact stated that upon lifting the hood, there was a rodent nest near the engine cover. The contact related the failure to GM Technical Service Bulletin Number: PIP5681C (Exhaust leak, Lean Codes, Rattle Noise, or Catalytic Converter Failure Codes); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure and later informed the contact that the case was closed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 85,600.

The contact owns a 2020 Chevrolet Traverse. The contact stated while driving 45 MPH, the vehicle jerked, with an abnormal sound coming from underneath the vehicle. In addition, the contact stated the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to Firestone, where the contact was provided DTC: P0420 (Catalytic converter was fractured and punctured, and a bracket was missing). The vehicle was not repaired. The contact then took the vehicle to the dealer where it was diagnosed and determined that the muffler was punctured and not the catalytic converter. The vehicle was not repaired. The contact then took the vehicle to a Valvoline Center to be diagnosed and DTC: P0420; was retrieved. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the vehicle was vibrating abnormally while driven with an abnormal rattling sound coming from underneath the vehicle. Upon further investigation, the contact related the failure to Manufacturer's Recall Numbers: N212356540 and N222385510; however, the vehicle was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 102,000.

Purchased the vehicle in 2024, the vehicle recently has been notifying “shift to park” when vehicle is on park and ignition is turned off, the notification stays on and alerting, so I am unable to leave the vehicle. I must turn the vehicle on and off again, while moving the shifting lever back and forth from drive to park, this must be done a minimum of four times before it reads the lever in park position. It’s a safety hazard because, the vehicle cannot be left on shift to park and possibly roll away or drive/excel on its own. Vehicle has not been inspected at this time, when purchasing the vehicle in 2024, car fax report did not indicate any issue with power train. Would also like vehicle to be inspected for missing airbags, when driving 65mph or more, you can hear and feel air coming in and out of side front left passenger side of the vehicle.

Engine light came on couple weeks ago. Code is p0420 so I did some research and inspected the exhaust system and found the weld on the support bracket of the exhaust pipes was cracked and wore a hole between the pipe and the bracket. There are others that have the same problem with different year models Chevrolet traverses. Mine is a 2020 Chevrolet traverse LT

The car started making a weird sound, thought it was transmission because it only happened when i accelerated. Took it to the dealership abd they wanted to charge me $1000 plus labor. I said no,this is a deffect and it should be covefed by the warranty, the said it wasnt. So i took it to a exhaust shop and they welded it but it cracked again and after a while, it actually tore a little hole into the muffler. So i let it be, maybe make the repair when i had the money to spare. But money being the issue, i went to a muffler shop and had it re soldered, it worked for a while, but now its back. It sucks thay gm put out the recall for specific vehicles knowing that it is a very general thing. Plase help me.

It just started showing a error message to SHIFT TO PARK when the car is already in Park. I took it to Register Chevrolet in Brooksville, Fl on May 14, 2025 and they said it needed a whole new shifter that it is defective. This is a major safety issue. I can currently still turn the car off but alarms start going off and was told I may not be able to turn the vehicle off or not lock the doors and could drain the battery. This is absolutely ridiculous there has not been a recall on the safety issue. I have seen that hundreds of others have had the same issue and there has been class action lawsuits. The dealership said it would be around $800 to fix the defective part. Also, I purchased the vehicle in Ohio but moved to Florida in Sep.2021.

The check engine light is illuminated. The Chevy app indicates there is an emission related concern regarding the catalyst system. After inspected, the catalytic converter bracket has a hole or is separating from the exhaust pipes. This causes the vehicle sound very loud during driving. Additionally the vehicle has less power during acceleration. The vehicles performance is poor and the maintenance is accelerated.

Prematurely damaged exhaust system. Identical to Special Coverage Adjustment N212356540 Front Exhaust Pipe but my dealer and GM says that my VIN it’s not coveted

The car violently shudders when it attempts to shift from 1st to 2nd gear. This happens every time I drive the car and I'm unsure what's wrong with it. I am unable to accelerate quickly when attempting to drive on the highway or when making a turn and am afraid of being hit because it won't accelerate shift gears as it should. I've taken it to the Chevy dealership twice, and the issue was not addressed as requested so, I researched online and learned that this is a common issue in Chevy Traverses, and it doesn't seem to be fixed, even after dealership intervention. I'm wondering if this is why the dealership is hesitant to address the issue. I am concerned for my family's safety.

[XXX] [XXX] [XXX] [XXX] 4/16/2025 General Motors Customer Assistance Center P.O. Box 33170 Detroit, MI 48232-5170 Subject: Power Steering Issue – 2020 Chevy Traverse (VIN: [XXX] ) To Whom It May Concern, I am writing to express my concern and frustration regarding a serious issue with my 2020 Chevrolet Traverse, VIN [XXX] . On [XXX], while driving, the steering wheel suddenly became very stiff, making it extremely difficult to turn right or left. A warning message appeared on the dashboard that read: "Reduced Steering Assist." I immediately took the vehicle to a certified dealership, where it has now been sitting for over two months. Despite multiple follow-ups, I have not been provided with a clear repair date. When I contacted the manufacturer, I was informed that the required part is currently on backorder, but again, no estimated time of resolution has been given. During this extended wait, I have been forced to rent a car to manage my daily responsibilities, and so far I’ve accumulated close to $1,000 in rental expenses. My case number is: [XXX]. I am requesting the following: 1. A clear update regarding the repair status of my vehicle. 2. Urgent assistance in obtaining the necessary replacement part. 3. Reimbursement or compensation for the rental car expenses caused by the extended delay, which has not been my fault. I trust that General Motors values its customers and the reliability of its vehicles, and I hope for a prompt and fair resolution to this matter. Sincerel

Mounting bracket on front exhaust pipe separated from the exhaust pipe while driving.

Broken exhaust pipe brackets

Unknown to some, but yesterday Saturday around 12:30 I was inspecting the speaker ports in the rear 3rd row passenger area and I noticed these square tabs that says airbags, also in the very middle of second row the same thing but in the rear I was removing one of the mouldings to see why the speakers were not playing, upon inspection there are no speakers and neither are there any form of side and or rear collision safety devices ( airbags) other than seatbelts. If that truck were in an accident say like a T-Bone, or rear end collision, or side rear impact no one is guaranteed safely making out without adverse affects on their bodies and health. I'm starting to wonder if this traverse was salvaged and or restored. Why are there no safety features in this truck?!!

Front exhaust pipe broken causing check engine light and vehicle to sound rough. It is an emissions issue. This has been confirmed with a dealership. The issue started around middle of March 2025 when check engine light came on.

TRANSMISSION CHATTER AND SLIPPING. I WAS NOT ABLE TO SECURE AN APPOINTMENT BEFORE MY WARRANTY EXPIRED. ATTEMPTED TO CALL GM FOR ASSISTANCE AND THEY WANTED TO CHARGE ME FOR DIAGNOSIS AND COULD NOT ASURE ME OF ANY ASSISTANCE AND SINCE I HAD A DIFFERENT ISSUE WITH MY CHECK ENGINE LIGHT DUE TO FAULTY CATALYTIC CONVERTER THAT WAS UNDER WARRANTY AND I WAS CHARGED AND DID NOT GET MY MONEY BACK, I WENT A DIFFERENT ROUTE. THE DEALER ACTUALLY WANTED TO CHARGE ME TO REPLACE THE CONVERTER. i HAD MY TRANSMISSION REPAIRED AT AAMCO $6000.00. KNOWN ISSUE WITH THESE TRANSMISSIONS BY MANUFACTURER.