2002 Chevrolet Trailblazer EXT complaints

FOUND A CRACK IN THE FILLER PIPE LEADING TO THE GASOLINE TANK ON MY 2002 TRAILBLAZER EXT. FIRST STARTED SMELLING GASOLINE, THEN LOSS OF GAS MILEAGE AND THEN CHECK ENGINE SOON LIGHT REMAINED ON. *JB

FAULTY PART - FAN CLUTCH - THAT INNUMERABLE AMOUNT IF NOT 100% OF 02-04 CHEVROLET TRAILBLAZER AND GMC ENVOY OWNERS HAVE HAD TO SUFFER WITH IN THE AMOUNT OF $500+ REPAIR BILL. HOW MANY REPORTS WILL IT TAKE FOR A RECALL . . .

FILLER NECK IS FRACTURED AT THE FUEL TANK

2002 CHEVY TRAILBLAZER 1) CHECK ENGINE LIGHT CAME ON. OBSERVED STRONG GASOLINE ODOR AND LEAKAGE. VEHICLE FAILED EMISSIONS INSPECTION. 2) TOOK CAR FOR SERVICE WHERE THEY IDENTIFIED THAT THE GAS TANK'S FILL NIPPLE HAD SPLIT WHERE IT WAS JOINED TO THE TANK (STRESS FAILURE?). 3) I HEAT-WELDED THE NIPPLE BACK ON TO THE TANK. *JB

CHECK ENGINE LIGHT WAS ON VEHICLE,COMPUTER CHECK SAID FUEL TANK HAS A LEAK OR CRACK. THIS IS A SAFETY HAZARD WHICH COULD CAUSE A FIRE OR EXPLOSION AND SHOULD BE RECALLED. HAD TO HAVE REPLACED BY THE GARAGE AT MY EXPENSE. RESEARCH ON THE INTERNET HAS SHOWN THERE HAVE BEEN A LOT OF THESE TRAILBLAZERS WITH THIS PROBLEM AND THERE SHOULD BE RECALLED. *JB

I BACKED OF THE GARAGE AND HEARD A LOUD NOISE. AS I PULLED FORWARD THE TRUCK MOVED VERY SLOWLY FOR HOW FAR THE GAS PEDAL WAS PUSHED. I WENT TO GO IN REVERSE AGAIN BUT THE TRUCK WOULD NOT GO INTO REVERSE AND COULD HEAR A LOUD WHINING FROM THE MOTOR. I THIS JUST HAPPENED TO DAY BUT I FIGURE IT'S THE TRANSMISSION. ALSO, WHEN I BOUGHT THE TRUCK I HAD PROBLEMS WITH THE TEMP. SENSOR AND THE AIR CONDITIONING THE DEALER TOOK CARE OF THE PROBLEM WITH THE AIR BUT THE OUTSIDE TEMP. SENSOR IS STILL BROKE. I DON'T KNOW WHICH IS WORSE THE FAILURE OF THE TRANSMISSION OR, SEEING ALL THE LIKE COMPLAINTS ON THIS SITE WITH NO ACTION. *JB

TRANSMISSION FAILED. DIAGNOSIS WAS REVERSE SUN SHELL FAILURE (JUST LIKE ALL THE OTHER COMPLAINTS LISTED ON THIS SITE)! GM REFUSES TO OFFER ANY COST ASSISTANCE WITH THE REPAIR OR ACKNOWLEDGE THAT THERE IS AN OBVIOUS DEFECT THAT SHOULD BE RECALLED!!! *NM

I OWN 2002 TRAILBLAZER AND TWICE THE FUEL TANK HAD BROKEN AROUND THE FILLER NECK LETTING FUEL LEAK OUT. THE PROBLEM IS SEVERAL OTHER OWNERS HAVE HAD THE SAME PROBLEM. THE SECOND TIME IT BROKE I REPLACED IT MY SELF AND I AM SURE IT IS A MANUFACTURING DEFECT. IF A OWNER HAD THIS PROBLEM IT COULD CAUSE FIRE/EXPLOSION. *NM

I HAVE A 2002 TRAILBLAZER WITH ABOUT 50,200 MILES AND THE OTHER DAY IT BEGAN TO MAKE A HIGH PITCHED SOUND, ALMOST LIKE A PLANE LANDING. WHEN I TOOK IT TO THE DEALER, HE SAID IT'S THE FAN CLUTCH AND IT'S GOING TO COST $711 TO FIX. WHEN I ASKED IF THIS IS NORMAL WEAR & TEAR, I DID NOT GET A PROPER ANSWER. THE RESPONSE WAS THAT THIS HAPPENS A LOT ON THE CHEVY & GM VEHICLES. WHEN I CALLED CHEVY CORPORATION, I WAS GIVEN A CLAIM# & TOLD THAT THEY WILL HAVE TO INVESTIGATE THIS PROBLEM & THEN THEY WILL CALL ME BACK IN ABOUT 3 DAYS TO ADVISE IF THEY WILL HELP WITH THE COSTS OF THE REPAIR. BOTH THE CUSTOMER SERVICE REPS I SPOKE WITH AT CHEVROLET CORPORATION (800-222-1020) TOLD ME THAT THEY'VE PERSONALLY NEVER HAD SUCH A COMPLAINT BEFORE AND THAT THIS WAS NEW TO THEM. BUT WHEN I GOOGLED THIS PROBLEM FOR THE CHEVY TRAILBLAZER 2002, I GOT SEVERAL WEB PAGES INCLUDING NHTSA WHICH DOCUMENTED THIS PROBLEM. THIS SHOULD DEFINITELY BE A RECALL ITEM. I AM NOW WAITING TO SEE IF CHEVROLET WILL HELP AND TO WHAT EXTENT. *NM

2002 CHEVROLET ELECTRONIC CLUTCH FAN FAILURE. MANY OF THESE ELECTRONIC CLUTCH FANS ARE FAILING IN OUR AREA. IMO, DUE TO HIGH HEAT CAUSING O-RING SEAL FAILURE AND LOSS OF SILICON LUBRICANT. IMO, PART IS NOT WELL ENOUGH BUILT TO WITHSTAND SW HEAT. *NM

CLUTCH FAN FAILED TO RELEASE. FAN LOCKED UP WITHOUT WARNING. ENGINE HAS LESS THAN 40,000 MILES. *JB

FACTORY INSTALLED BATTERY LEAKING ACID OUT OF THE SIDE MOUNTED TERMINALS AT 3.5 YEARS 40K MILES. NO WARRANTY COVERAGE AFTER 3 YEARS 36K. OTHER COMPLAINTS AND WEB-POSTINGS WITH SAME PROBLEM, OBVIOUSLY BATTERY IS DEFECTIVE. *NM

DRIVING TO COLUMBUS, THE UPPER MOLDING AROUND THE THIRD BRAKE LIGHT GOT CAUGHT BY THE AIR FLOW BENT UP THEN BROKE FREE FROM TWO ATTACHMENTS. THIS ALLOWS THE UPPER MOLDING AND BRAKE SLIGHT TO "FLAP" IN THE AIR FLOW. IF THIS HAD BROKE FREE HIT COULD HAVE HIT ANOTHER CAR BEHIND AND/OR BROKE THE REAR TAILGATE WINDOW. DID NOTICE A CREAKING SOUND WHEN OPENING TAILGATE EARLY IN THE DAY. LOOKED AND DID NOT SEE ANY PROBLEMS. *NM

TOP OF GAS TANK - POURS OUT GAS. *NM

FAILURE OF ADHESIVE BOND OF REAR HATCH WIDOW HINGE OF 2002 TRAILBLAZER EXT. HINGE STARTED SEPARATING TO A NOTICEABLE GAP TO THE REAR WINDOW FROM THE WINDOW FRAME. *JB

REAR PASSENGER DOORS WILL NOT OPEN OR WILL NOT LATCH CLOSED. *NM

CHECK ENGINE LIGHT CAME ON MY 2002 CHEVROLET TRAILBLAZER (86,000 MILES). TEAM CHEVROLET ANALYZED AND ADVISED THE GAS TANK IS CRACKED. THIS SAME PROBLEM OCCURRED AT 12,000 MILES BUT WAS REPAIRED FOR FREE AS VEHICLE WAS UNDER WARRANTY AND THERE WAS AN ALERT ISSUED FOR THIS PROBLEM. HOWEVER, THE ALERT "POLICY" RAN OUT AT 70,000 MILES SO THE DEALERSHIP, NOR GM WILL COVER THE ESTIMATED EXPENSES OF $850. I PROTESTED THAT THIS WAS A KNOWN AND REPEATED PROBLEM AND A FIRE/SAFETY ISSUE BUT THEY ARE NOT WILLING TO ASSIST IN ANY WAY. *JB

I BROUGHT MY EXTENDED 2002 TRAILBLAZER IN TO THE DEALER FOR A RECALL ON THE REAR DOORS, A SEAL FOR THE BOTTOM. I THINK IT WAS FOR THE DOOR LATCH RUSTING OUT AND FLYING OPEN WHILE YOUR DRIVING. I TOLD THEM TO CHECK THE ABS BECAUSE THE WARNING LIGHT WAS ON. THEY SUPPOSEDLY CHECKED IT OUT AND TOLD ME THAT THE FRONT DRIVERS SIDE HUB WAS VERY WOBBLY AND IT CAUSED THE SENSOR TO GO BAD. ME BEING A MECHANIC ALSO, DECIDED TO TAKE IT TO MY TRUSTED GARAGE AND TOLD THEM TO REPLACE THE HUB. MY VEHICLE ONLY HAS 45000 MILES ON IT AND I DIDN'T THINK THAT THIS PART SHOULD HAVE GONE BAD. SO I LEFT IT AT THE GARAGE AND ABOUT AN HR LATER I GOT A CALL FROM THEM SAYING THAT NOT ONLY THE HUB BUT BOTH LOWER BALL JOINTS WERE BAD, DRIVERS SIDE CONTROL ARM JOINT WAS READY TO FALL OFF, THIS STEERS THE WHEEL! AND THE BRAKE PADS THAT I JUST PUT ON ABOUT A YR AGO ARE WORN AT AN ANGLE. NOW MIND YOU, I JUST HAD THIS VEHICLE INSPECTED A YR AGO AND IT WAS FINE. ITS PRETTY EMBARRASSING TO HAVE AN ALMOST NEW VEHICLE GO IN THE SHOP AND NEED THE FRONT END REBUILT. THIS REALLY NEEDS TO BE LOOKED INTO BECAUSE THE FRONT WHEEL COULD HAVE BROKEN OFF WHILE DRIVING. ALSO I HAVE A LIST OF WARRANTY WORK THAT WAS DONE ON THIS VEHICLE ABOUT A MILE LONG. NOW I HAVE TO SPEND OVER $1000 TO GET MY VEHICLE BACK ON THE ROAD. THIS JUST ISN'T RIGHT! I THINK I WILL BE GOING TO THE HONDA DEALER WHEN I GET THIS JUNK FIXED!!!!!! CHEVY OUT ---- HONDA IN! *NM

COMPLETE ENGINE FAILURE. BOUGHT THE VEHICLE USED WITH 45,000 MILES ON THE VEHICLE. 4 MONTHS AFTER I BOUGHT IT, AND WITH ONLY 54,000 MILES ON THE ENGINE, IT HAS A LOWER ENGINE FAILURE. *NM

I HAVE A CRACK IN THE FILL NECK OF MY GAS TANK. VERY EXPENSIVE FIX ON A 2002 TRAILBLAZER EXT. CAUSED A LOSS OF SPEED ON THE HIGHWAY AND EFFECTS THE PICK UP ESPECIALLY WHEN GOING UP HILLS, EVEN SMALL INCLINES. *JB

DT*: THE CONTACT STATED THE DRIVER'S SIDE REAR DOOR OPENS WHILE DRIVING AT ANY SPEED. AN NHTSA RECALL, #05V494000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE LATCHES/LOCKS/LINKAGES: DOORS: LATCH HOWEVER; THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP ONLY REPLACED THE WEATHER STRIPPING ALONG THE TWO REAR DOORS. THE DRIVER'S SIDE REAR DOOR STILL OPENS WHILE DRIVING AT ANY SPEED. THE DEALERSHIP WOULD NOT OFFER TO REPLACE THE INOPERABLE LATCH AS INDICATED IN THE RECALL WITHOUT CHARGE. UPDATED 06/15/06. *JB

MORNING OF INCIDENT, WOULD HERE A "CLUNKING" NOISE AFTER ENGAGING THE ACCELERATOR. THAT AFTERNOON, WHILE DRIVING IN FAST LANE OF INTERSTATE AT 65 MILES PER HOUR, UPON ENGAGING THE ACCELERATOR, THE VEHICLE WAS GOING TO HAVE TO DOWN SHIFT, AND INSTEAD, HEARD A LOUD "WHIRRING" NOISE, AND VEHICLE SLOWED DOWN. UPON EVALUATION, THE VEHICLE WILL NOT GO INTO REVERSE, AND HAS TROUBLE SHIFTING. REPAIR SHOPPED DIAGNOSED THAT THE TRANSMISSION HAS GONE OUT. *JB

(1) NO EVENTS LEADING TO PROBLEM (2) FUEL TANK REPLACEMENT LED TO FULL REPLACEMENT (3) REPLACED FUEL TANK WITH DEALERSHIP. *JB

BEFORE I GOT THE RECALL NOTICE ON MY TRAILBLAZER THE PROBLEM WITH THE CAR HAPPENED TO ME. MY 3 YEAR OLD GRANDSON FELL OUT THE BACK DOOR WHEN IT UNLATCHED. NO MESSAGE APPEARED ON THE PANEL. MY OTHER GRANDSON YELLED TO LET ME KNOW THAT HE HAD FALLEN OUT. FURTHER ACTION MAY BE TAKEN IN THIS MATTER. *NM

LOUD CLANKING NOISE COMING FROM THE REAR TO CENTER OF THE VEHICLE WHEN SHIFTING FROM PARK TO FORWARD OR REVERSE, IEEE WHEN LACK OF OR DIRECTION IS CHANGED. 36,000 MILES, VERY POOR QUALITY VEHICLE AS I HAVE HAD SEVERAL OTHER ISSUES. GOOD THING I HAVE EXTENDED WARRANTY, HOWEVER I AM VERY DISPLEASED WITH CHEVROLET AND WILL AVIOD PURCHASING ANY CHEVEROLET PRODUCTS IN THE FUTURE.*AK

TRANSMISSION COOLANT PIPES: ON THE AFTERNOON OF NOVEMBER 12, I WAS DRIVING ON A LOCAL FREEWAY I BEGAN EXPERIENCING DIFFICULTIES MAINTAINING SPEED. WHILE THE ENGINE HAD FULL POWER, I HAD TO PULL OVER AS MY VEHICLE EFFECTIVELY LOST POWER TO THE WHEELS. AT THIS TIME, I HAD THE VEHICLE TOWED TO THE LOCAL CHEVROLET DEALER WHERE I HAVE THE VEHICLE SERVICED. THE VEHICLE HAS ALWAYS BEEN REGULARLY SERVICES AT GM DEALERS. THE FOLLOWING MONDAY, MY SUSPICION OF A TRANSMISSION FAILURE WAS CONFIRMED. SEVERAL DAYS LATER, THE OLD TRANSMISSION WAS REPLACED. AT THAT TIME, THE TRANSMISSION COOLANT PIPE WAS DISCOVERED TO HAVE BEEN RUSTED THROUGH AND THIS WAS IDENTIFIED AS THE LIKELY CAUSE OF MY TRANSMISSION FAILING. I ULTIMATELY HAD TO HAVE THE TRANSMISSION AND THAT COOLANT PIPE REPLACED AT THE COST OF SEVERAL THOUSAND DOLLARS. I BELIEVE A STRONG CASE EXISTS FOR CALLING ATTENTION TO A NEED TO INSPECT AND PERHAPS REPLACE CRITICAL UNDERBODY FLUID PIPES ON SIMILAR VEHICLES DUE TO THE LIKELIHOOD OF RUST-THROUGH AND OTHER FAILURES THAT COULD CAUSE SUBSTANTIAL DAMAGE TO VEHICLES. *JB

1.- ELECTRICAL SYSTEM FAILURE IN THE TRAILBLAZER EXT 2002 125,278 MILES. AC DELCO PROFESSIONAL BATTERY MAINTENANCE FREE 19001810 CATALOG 1810 (REPLACEMENT 78-6YR) HAS GREEN HYDROMETER COLOR BUT A SENSE ACID SMELL AROUND. 2.- TWO BUSINESS APPOINTMENTS WERE CANCELLED AND NO WAY TO GO OUT WITH THE CAR. I CALLED THE DEALERSHIP FOR ASSISTANCE FRIDAY 18, 7:30 P.M. AND LEAVE A VOICEMAIL. THE DEALER RETURN THE PHONE CALL SATURDAY 19, 7:30 A.M. LATER I CALL BACK 9:00 A.M. AND ASK THEM WHAT THEY THINK ABOUT AND WHERE TO START...WITH THE BATTERY?? BUT THEY SAID THAT THEY ARE BOOKED AND NOT ABLE TO TAKE ANY OTHER APPOINTMENT UNTIL MONDAY....JUST IN CASE HOW MUCH WOULD BE.. 75 $ PLUS LABOR 25 $ TOTAL AROUND 100 $. CONSEQUENCES: TWO POTENTIAL BUSINESS OPPORTUNITIES WERE LOST AS WELL AS THE OPPORTUNITY OF CAR ENJOYMENT AND FREEDOM. BATTERY REPLACED $ 80.99. ACID LEAKS THROUGH THE CAR. REQUEST FRIEND HELP FOR TIME TO BUY, DELIVER AND REPLACE THE BATTERY AT HOME. THE AC DELCO WEB SITE SAID THAT "THE BATTERY THAT COMES WITH A GM VEHICLE IS COVERED BY THE LIMITED WARRANTY OF THREE YEARS OR 36,000 MILES" IT IS REALLY NOT FAIR HOW A BATTERY CAN LOSE IT POSITIVE TERMINAL ITSELF AND WHY CONSUMER IS NOT COVERED AGAINST THIS DEFECT THAT INVOLVE TIME AND MONEY AS WELL AS OPPORTUNITIES AND MAJOR ACCIDENTS. 3.- SATURDAY 19, 10 A.M. I CALLED A FRIEND TO FIND ANOTHER BATTERY. BEFORE THAT WE TAKE OUT THE AC DELCO BATTERY FROM THE CAR THE POSITIVE TERMINAL WAS COMPLETELY SEPARATED FROM THE CASE AND ACID WAS

POWER WINDOW MOTOR FAILURE. THIS IS THE SECOND TIME THE MOTOR HAS GONE OUT ON REAR WINDOW. THE 1ST TIME CAR UNDER WAR. NOW ITS NOT. THERE MUST BE A PROBLEM WITH THE MOTORS. *JB

CHEVY TRAILBLAZER 2002 LTZ - VIN [XXX] THERE IS A CRACK IN THE CONNECTION BETWEEN MY GAS TANK AND THE FILLER PIPE. CHEVY TOLD ME THAT CURRENTLY HAVE A "SPECIAL POLICY" #05012 WHICH COVERS THIS FLAW, HOWEVER MY CAR DOES NOT FALL UNDER THAT EVEN THOUGH THE SYMPTOMS ARE THE SAME. HOW CAN I PURSUE THIS AND GET IT FULLY COVERED. [XXX] *NM UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AFTER SMELLING GAS FUMES AND HAVING THE "SERVICE ENGINE SOON" LAMP ILLUMINATED, I TOOK MY 2002 CHEVROLET TRAILBLAZER EXT TO MY MECHANIC FOR SERVICE. THE ATTACHMENT FROM THE FUEL FILLER LINE AND THE GAS TANK WAS LOOSE. HE RELAYED THAT CHEVY WAS HAVING A LOT OF PROBLEMS WITH THIS. AFTER PURSUING THIS WITH GM, I FOUND A SPECIAL POLICY # 05012. GM WILL FIX THE PROBLEM ON VEHICLES WITH UP TO 70,000 MILES. MY VEHICLE HAS 72,000 MILES. GM REFUSES TO REPAIR THIS DEFECT. *JB

2002 CHEVY TRAILBLAZER LEFT BRAKE LIGHT OUT AFTER TWO REPAIRS. THERE IS A PROBLEM WITH THIS VEHICLE TYPE OTHER TRAILBLAZERS HAVE LEFT LIGHT OUT AS WELL. DEALER HAS REPAIRED TWICE, NOW WARRANTY IS EXPIRED AND POLICE HAVE PULLED ME OVER INFORMING ME THAT I NEED TO GET IT FIXED,AGAIN! I BOUGHT NEW LIGHTS STILL LEFT WON'T WORK. *NM

1)DRIVING DOWN CITY STREET WITH NO WARNING. WAS NOT ABLE TO CONTROL CAR PULLING TO THE RIGHT. CAR WENT INTO THE YARD OF SOMEONES HOME BOUNCING OVER AN EMBANKMENT OF DIRT. LOOKED AROUND CAR AND FOUND PASSENGER FRONT TIRE WAS AT A 45% ANGLE. ROD HOLDING TIRE IN PLACE NOT CONNECTED AND LOOKED CLEAN ON THE END. TOOK CAR TO A CHEVY REPAIR SHOP AND THEY STATED THAT THE PART THAT CAME LOOSE SHOULD NOT HAVE DO SO WITH THE AGE AND USE OF THE CAR. TRANSMISSION CASE WAS PIERCED AND NEEDED REPLACED, AXLE BENT AND ADJACENT PARTS NEEDED REPLACED. OLD PARTS ARE AVAILABLE. COMPLETE WRITE UP ON DAMAGE AVAILABLE. A POLICE REPORT WAS FILED SINCE I WAS IN SOMEONE'S FRONT YARD IT WAS CONSIDERED AN ACCIDENT.*JB

FRONT END CRASH AND THE AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. *JB

SUN GEAR FAILED IN TRANSMISSION PUT INTO REVERSE WENT 6"-12" LOUD CLUNK COULD DRIVE AHEAD IN LOW GEAR 2002 TRAILBLAZER HAD 43,000 MILES. DEALER FIXED UNDER WARRANTY NO CHARGE BY REPLACING SUN GEAR. *JB

DT THE DRIVERS AND PASSENGERS REAR DOOR HANDLES WILL NOT OPEN PROPERLY. CONSUMER HAS TO GO INSIDE THE VEHICLE TO OPEN THE DOORS. ALSO, THERE WAS A RECALL FOR THE WINDSHEILD WIPER AND WASHER, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. THE WINDSHIEL WIPERS START ON THEIR OWN, AND ONE COULD HEAR THE MOTOR GOING WITHOUT WINDSHIELD WIPERS BEING ON. CONSUME RPULLED THE FUSE ON THE WASHER MOTOR BUT WIPERS CONTINUED TO RUN. THIS HAPPENED LAST TUESDAY JULY 19,2005. *AK

WHILE TAKING OFF FROM A TOLL BOOTH THERE WAS A BIG BANG AND THE TRANSMISSION WOULD NOT SHIFT INTO REVERSE AND MADE A VERY LOUD WHINNING NOISE WHE GOING FORWARD

MY TRANSMISSION WENT IN JANUARY OF 2005. IT IS NOW JULY AND THE SAME THING HAPPENED AGAIN. I HAD TO FIGHT WITH THE DEALERSHIP THEN BECAUSE I ONLY HAD THE VEHICLE FOR 4 MONTHS AND I AM FIGHTING WITH THEM AGAIN. IT IS THE SAME PROBLEM. IT WON'T SHIF OUT OF 1ST AND IT WON'T GO IN REVERSE AND THE LOUD NOISE IS HORRIBLE.

DT: REAR WINDOW BLEW OUT WHILE CONSUMER WAS REMOVING HER CHILDREN FROM THE REAR SEAT. THIS HAPPENED AT ABOUT 7:30 PM IN THE EVENING. TEMPERATURE SAID ABOUT 92 DEGREES. THE PLASTIC COVER OVER THE THIRD BRAKE LIGHT, LOCATED ON TOP AND INSIDE OF THE BACK WINDOW, CRACKED. THE WHOLE HOUSING. THE WINDOW SUPPORTS, WERE THE SHOCK STILE. THEY WERE PULLING AND WINDOW BROKE. VEHICLE WAS SERVICED REGULARLY AT DEALER.*AK

ORIGINAL BF GOODRICH TIRES ARE DRY ROTTED, DEALER CLAIMS TIRES ARE O.K., I FEAR POTENTIAL TIRE FAILURE. CAR WILL NOT PASS INSPECTION AT ALTERNATE FACILITIES.

SMALL "CLUNKING" NOISE FROM UNDER VEHICLE WHEN SHIFTING FROM PARK TO REVERSE OR DRIVE. "CLUNKING ALSO EVIDENT WHEN SLOWING TO A STOP. ULTIMATE TRANSMISSION FAILURE OCCURRED WHILE ACCELLERATING FROM A STOP. A VERY LOUD "CLUNCK" WAS HEARD FROM UNDER THE VEHICLE FOLLOWED BY A LOUD WIRRING NOISE. THE VEHICLE WOULD NOT SHIFT FROM FIRST GEAR AFTERWARDS UNTIL ABOUT 40 MPH. THE "WIRRING" NOISE CONTINUED WHEN THE VEHICLE WAS STOPPED AND THE TRANSMISSION WOULD NOT SHIFT INTO REVERSE. THE DEALER'S MECHANIC OVERHAULED THE TRANSMISSION AND REPLACED THE FOLLOWING "WORN" PARTS: SUN GEAR SHELL, SUN GEAR, 3-4 CLUTCH. VEHICLE HAD 40000 MILES AT TIME OF FAILURE.

FAN CLUTCH FAILED AT 49,000 MILES AFTER INTERMITTENT ROARING SOUND ALMOST FROM DATE OF NEW PURCHASE 6-20-02. REQUIRED REPLACING AT MY $600 COST. *NM

CONSUMER'S VEHICLE WAS INVOLVED IN A ACCIDENT. THE DRIVER'S SEAT BELT FAILED TO RESTRAIN THE CONSUMER. THE DRIVER SUSTAINED MAJOR INJURIES, AND WAS TRANSPORTED TO THE HOSPITAL BY AMBULANCE. THE VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. THIS INFORMATION WAS PROVIDED BY MR. NATHAN'S WIFE MILDRED CHATMAN.*AK *JB

ELECTRICAL PROBLEM REAR VIEW MIRROR COMPASS NOT READING RIGHT AND OUTSIDE TEMP. NOT READING CORRECT ON A HOT 80 DEGREE DAY. READS -33 AND NOW MY A/C WONT WORK BECAUSE IT SAYING THAT'S ITS TOO COLD FOR THE A/C TO BE ON. *JB

I OWN A 2002 TRAIL BLAZER EXT. I BOUGHT IT BRAND NEW AND I HAVE HAD MANY MANY PROBLEMS WITH IT. I FINALLY HAVE HAD IT AND DECIDED TO SEE IF THE INTERNET REPORTED ANY SIMILAR PROBLEMS AND TO MY AMAZEMENT THERE ARE MANY PEOPLE OUT THERE WITH THE SAME PROBLEMS, BUT HERE IS MY STORY. I HAVE HAD TO HAVE THE BRAKE LIGHTS ELECTRICAL SYSTEM ON BOTH SIDES REPLACED, MOLDING AROUND THE LICENSE PLATE FRAME REPAIRED, OXYGEN SENSOR REPLACED, SWAY BARS REPLACED, WINDSHIELD WIPER MOTORS REPLACED, LEFT SIDE PASSENGER WINDOW MOTOR BROKE TWICE, GAS TANK REPLACED BECAUSE IT WAS LEAKING GAS AND NOW IT IS BACK IN THE SHOP ONCE AGAIN BECAUSE THE ENGINE LIGHT CAME ON AND I HAD THE ONSTAR SYSTEM DO AN ENGINE ANALYSIS AND THEY SAID SOMETHING IS WRONG WITH MY POWER TRAIN. I TOOK IT TO THE DEALERSHIP AND THEY CALL TO TELL ME THE GAS TANK IS LEAKING GAS AND NEEDS TO BE REPLACED. I TOLD THEM I JUST HAD IT DONE IN OCTOBER 2003. THEY TOLD ME I COULD NOT DRIVE MY VEHICLE. I SEE THERE WAS A RECALL DONE ON SOME 2002 TRAILBLAZERS DUE TO A PROBLEM LIKE THIS, BUT THEY SAY MY VEHICLE IS NOT ONE OF THEM. WHY? I AM HAVING THE SAME PROBLEMS WITH THE GAS TANK. THIS IS THE SECOND ONE. I AM LUCKY I TOOK IT IN OR SOMETHING MAY HAVE HAPPENED IF IT IS THIS DANGEROUS. I WOULD APPRECIATE A RESPONSE BACK. THANK YOU, KATHY YATES. *AK

VECHILE TRANSMISSIN FAILURE.*AK

THE BRAKE LIGHTS ON MY 2002 TRAILBALZER HAVE EITHER BURNED OUT OR FAILED TO FUNCTION 3 TIMES IN THE PAST 2 YEARS. A SERIOUS ISSUE SINCE I WAS NOTIFIED BY OTHER DRIVERS WHILE DRIVING IN HEAVY TRAFFIC. ONCE THE BULBS WERE REPLACED AT THE DEALERSHIP AND THE OTHER TIMES AT LOCAL MECHANICS WHILE I WAS TRAVELING. ENOUGH OF AN ISSUE TO MAKE ME CONSIDER TRADING VEHICLES. *AK

I HAVE A 2002 TRAILBLAZER WITH MULTIPLE TAILLIGHT / BRAKE LIGHT FAILURES. THE DEALERSHIP HAS RESOLVED MY PROBLEM, HOWEVER I THOUGHT THIS INFORMATION MIGHT BE HELPFUL TO YOUR OPEN INVESTIGATION. IN NOVEMBER 03 MY BRAKE LIGHTS FAILED AND MY DEALERSHIP "REPLACED THE BULBS" UNDER MY THEN EXISTING WARRANTY. AGAIN, IN JANUARY, THEY FAILED AGAIN AND I TOOK THE VEHICLE IN TO HAVE THE "BULBS" REPLACED. WHILE SITTING AT THE COUNTER, I WAS SPEAKING TO A MAN BEHIND THE PARTS COUNTER AND EXPLAINING MY PROBLEM TO HIM. I HADN'T FINISHED EXPLAINING WHEN HE TOLD ME I MUST HAVE A TRAILBLAZER. I TOLD HIM YES, AND ASKED HIM WHY. HE REACHED UNDER THE COUNTER AND TOOK OUT A BOX WITH NO LESS THAN 20 TAILLIGHT "CIRCUIT BOARDS" AND TOLD ME THEY WERE ALL FROM TRAILBLAZERS. *JB

WE HAVE A 2002 CHEV. TRAILBLAZER EXT. THIS VEHICLE'S CRUISE CONTROL CUTS OUT WHILE IT IS SET. IT HAS HAPPENED NUMEROUS TIMES - TOO MANY TO COUNT - AND AT DIFFERENT SPEEDS DEPENDING ON THE STATE AND SPEED LIMIT. THE CRUISE LIGHT DOES GO ON WHEN IT IS ORIGINALLY SET BUT GOES OFF AT RANDOM AND WITH TRUCK TRAFFIC BEHIND YOU IT IS NOT A PLACE WHERE YOU WANT TO BE SLOWING DOWN AND NOT REALIZING IT IMMEDIATELY.*AK

THIS PROBLEM CONCERNS A REPEATED LIGHTING SYSTEMS FAILURE. THIS INCIDENT OCCURRED WHEN I WAS NOTIFIED BY ANOTHER MOTORIST THAT WHEN I HAD THE BRAKES ON WHILE STOPPED AT A STOP LIGHT THAT BOTH THE LEFT AND RIGHT TAIL STOP LAMPS WERE NOT LIT ALTHOUGH THE CENTER HIGH MOUNTED STOP LAMP DID LIGHT TO INDICATE THE BRAKES WERE ON. I HAD HAD TO HAVE BOTH OF THESE LAMPS REPLACED ONLY ABOUT 3 MONTHS AGO WHEN THEY BOTH BURNED OUT WITHIN A SHORT PERIOD OF TIME, PERHAPS SIMULTANEOUSLY AS THEY MIGHT HAVE LAST WEEK. AFTER THE INCIDENT LAST WEEK I PUT IN NEW BULBS BUT, UNLIKE THE FIRST INCIDENT 3 MONTHS AGO, THE LAMPS WOULD NOT LIGHT PROPERLY WHEN THE BRAKE PEDAL WAS DEPRESSED. I WILL NOTIFY THE DEALER WHERE I BOUGHT THE VEHICLE NEXT WEEK WHEN THEIR SERVICE DEPARTMENT IS OPEN AGAIN THAT THIS PROBLEM WITH MY VEHICLE NEEDS ATTENTION.*AK

BRAKE LIGHTS CONTINUOUSLY FAIL IN MY 2002 TRAILBLAZER. THE DEALER REPLACED THEM A COUPLE OF TIMES WHILE I WAS HAVING OTHER CHEAP MADE INFERIOR PARTS REPAIRED OR REPLACED UNDER WARRANTY OR RECALL. THE PROBLEM IS THE CONTACTS IN THE BULB SOCKET ARE TO FAR APART AND DO NOT MAKE A SECURE CONNECTION WITH THE BULB CONTACTS AND ALSO DO NOT HAVE ELECTRICAL GREASE IN THEM TO PROTECT AGAINST MOISTURE.*AK