2005 Chevrolet Tahoe complaints

HAVE HAD MYSTERY COOLANT LEAK FOR SOME TIME AND AFTER MONTHS OF LOSING ANTIFREEZE I FIND OUT THAT IT IS VERY LIKELY THAT I HAVE A CRACKED HEAD DUE TO POOR CASTING. A PROBLEM THAT GENERAL MOTORS IS FULLY AWARE OF. I THINK THAT THE MANUFACTURER SHOULD HAVE ISSUED A RECALL LONG AGO TO REMEDY THIS PROBLEM. *TR

THERE WAS NO ACCIDENT AT THIS TIME. WE NOTICE RUSTING ON THE FRAME AND AFTER FURTHER INSPECTION WE FOUND LARGE HOLES IN THE FRAME RAILS. THIS VEHICLE IS NO LONGER SAFE TO DRIVE. WE STILL HAVE A LOAN ON IT AND DON'T UNDERSTAND HOW A 8 YEAR OLD VEHICLE CAN HAVE THAT MUCH RUST ON THE FRAME WITH SUCH LOW MILEAGE(49,254). THERE HAS TO BE MORE OUT THERE WITH THIS PROBLEM. NOT SURE WHERE TO GO FROM HERE. *TR

TACHOMETER NEEDLE FELL TO 0 WHILE TRAVELING AT HIGHWAY SPEED. PREVIOUS SERVICE BULLETIN WAS ISSUED WITH A MILEAGE LIMIT ON THE REPAIR. DEALERSHIP WOULD REPLACE PART, HOWEVER, I WOULD BE REQUIRED TO PAY FOR LABOR HOURS. CURRENTLY, THIS PROBLEM STILL EXISTS BECAUSE REPAIR LABOR WOULD HAVE COST IN EXCESS OF $400. ALSO, SHIFT INDICATOR LIGHT IS NOW EXTREMELY DIM AND SOMETIMES DOES NOT LIGHT UP AT ALL. THERE IS A RECALL OUT FOR OTHER 2005 TAHOES, HOWEVER, MY VIN NUMBER IS NOT INCLUDED EVEN THOUGH I AM HAVING THE SAME ISSUE. I CALLED AND SPOKE WITH GM TODAY AND THEY SAID THAT BOTH ITEMS WOULD BE THE SAME AREA AND THAT NEITHER COULD BE FIXED UNDER A TSB OR A RECALL. BOTH PROBLEMS ARE KNOWN TO NHTSA AND GM, BUT GM IS NOT WILLING TO FIX THESE KNOWN PROBLEMS DUE TO A MILEAGE ISSUE. *TR

JUST AFTER COMING OFF OF A MAJOR HIGHWAY,SLOWING DOWN AS I WAS APPROACHING A SET OF LIGHTS,THE BRAKE PEDAL LOST PRESSURE,AND WENT TO THE FLOOR ON MY 2005 CHEVY TAHOE. THE ROTORS,PADS AND CALIPERS HAD JUST BEEN REPLACED 6MTHS PRIOR,SO I KNEW THEY WERE NOT THE PROBLEM. I FIGURED EITHER THE MASTER CYLINDER WENT, OR SOMETHING WAS WRONG WITH THE BRAKE LINES. THE SERVICE BRAKE SYSTEM AND BRAKE LIGHT WERE ON. I WAS ABLE TO USE THE PARKING BRAKE AND DOWNSHIFT THE TRANSMISSION TO COME TO A STOP. TURNS OUT,ONE OF THE BRAKE LINES ROTTED OUT AT THE REAR,CAUSING THE FLUID TO LEAK OUT,AND THE LOSS OF MY BRAKES. LUCKILY I DID NOT GET INTO AN ACCIDENT.VEHICLE IS ONLY 8YRS OLD,WITH JUST TURNING 100000 MI. IN MY OPINION, THIS SHOULD NOT BE HAPPENING THIS SOON. *JS

I OWN A 2005 CHEVY TAHOE I BOUGHT NEW. LAST YEAR IN 2012 THE FUEL LINES COMING OUT OF THE FUEL PUMP ROTTED OUT AND I HAD TO REPLACE THE WHOLE PUMP. EARLY THIS YEAR (2013) THE TRANSMISSION LINES ROTTED OUT AND ALL HAD TO BE REPLACED, IN SEPTEMBER THIS YEAR (2013) THE BRAKE LINES ROTTED OUT AND HAD TO BE REPLACED. LUCKY FOR ME I WAS JUST LEAVING MY DRIVEWAY. I AM VERY DISAPPOINTED WITH THIS GM VEHICLE. I DON'T KNOW IF I WOULD EVER BUY A GM VEHICLE AGAIN. *JS

I TOOK MY 2005 CHEVY TAHOE IN FOR A SERVICE LITE. I WAS INFORMED THAT THE UNDER DASH CONNECTORS FOR THE AIRBAG SYSTEM NEEDED TO BE REPLACED OR THE AIRBAGS WOULD NOT WORK IN AN ACCIDENT, AT A COST OF JUST OVER $500.00. I ASKED WHAT THE EXACT PROBLEM WAS AND WAS TOLD THAT THE CONNECTOR WAS LOOSE AND NOT MAKING CONNECT. I THEN DID SOME BASIC RESEARCH ON THE WEB LOOKING FOR RECALLS AND SUCH AND FOUND SEVERAL REPORTS OF COLLISIONS INVOLVING 05 TAHOES WHERE THE AIRBAGS DID NOT DEPLOY AT SPEEDS EXCEEDING 35MPH. I WAS ALSO INFORMED THAT GM ALREADY HAD AN UPGRADED CONNECTOR SET TO REPLACE THE BAD ONES AS THE PROBLEM HAS BEEN SEEN MORE THAN ONCE. IT APPEARS TO ME THAT GM KNOWS THAT A MANUFACTURING DEFECT IS AT FAULT, THEY HAVE IDENTIFIED THE PROBLEM AND MADE AN UPGRADED REPLACEMENT PART AND HAVE NO PROBLEM CHARGING CONSUMERS $500.00 TO REPLACE THE PARTS. IN THE MEANTIME PEOPLE ARE DRIVING THE VEHICLES AND I GUESS, HOPING THE AIRBAG WILL DEPLOY IN THE EVENT OF AN ACCIDENT, WHICH IS NOT THE CASE IN SEVERAL CRASHES. I HAVE NO WAY TO CHECK WHAT VEHICLES / MODEL YEARS THOSE CONNECTORS WERE USED ON BUT, IT SEEMS LIKE THERE IS A PROBLEM HERE THAT SHOULD BE LOOKED AT BEFORE MORE ACCIDENTS BECOME FATAL. MY WIFE WAS SAVED BY HER AIRBAG BEING DEPLOYED IN A PREVIOUS ACCIDENT, I AM GLAD WE DID NOT FIND OUT THE HARD WAY THIS ONE WOULD NOT HAVE BEEN THERE FOR HER. *TR

WAS DRIVING SOUTH ON HIGHWAY 77 WHEN MY TAHOE STARTING TO BOUNCE ON THE FRONT END THEN STARTING FISH TAILING FROM WHITE LINE TO WHITE LINE TRIED TO CORRECT AND HAD NO STEERING. THEN WENT OFF THE RIGHT SIDE OF ROAD AND HIT A DRIVEWAY AND FLIPPED END OVER END THEN BACK OVER HEADED IN THE OPPOSITE WAY. THERE WAS A PERSON WATCHING THE ACCIDENT HAPPENED AND HE STATED THAT THE TRUCK WAS BOUNCING GOING DOWN THE ROAD THEN WENT OUT OF CONTROL AND FLIPPED. HAD TAHOE SERVICED IN MARCH FOR A POPPING NOISE AT RICHARD KAY SUPERSTORE IN ANDERSON SOUTH CAROLINA WHERE THEY STATED THEY FIXED THE PROBLEM. STATED WAS A STEERING SHAFT. THEY REPLACED IT. CALLAWAY WRECKER SERVICE STATED THAT THERE WAS A PROBLEM IN THE FRONT END THAT WAS VERY SUSPICIOUS. WITH ONE OF THE WHEELS AND WHERE WAS CONNECTED TO THE FRAME. THIS WOULD HAVE BEEN WHERE THE BOUNCING CAME FROM WHERE THE TIRE WAS TURNED SIDEWAYS . *JB

MY WIFE WAS DRIVING OUR 2005 CHEVY TAHOE WHEN SHE LOST THE BRAKES. SHE SAID THE PEDAL WENT TO THE FLOOR. SHE WAS NOT IN ANY TRAFFIC BUT THE CAR DID NOT STOP VERY QUICKLY. I THEN DROVE THE CAR VERY CAREFULLY TO OUR LOCAL SERVICE STATION ABOUT 2 MILES AWAY. THE MECHANIC FOUND THAT ONE OF OUR REAR BAKE LINES HAD RUSTED THROUGH CAUSING ALL HYDRAULIC FLUID TO BE LOST. THE REAR BRAKES HAD COMPLETELY FAILED. AFTER LOOKING UNDER THE VEHICLE WITH THE MECHANIC, HE SHOWED ME ALL THE RUST UNDER THIS CAR. HE ALSO POINTED OUT THAT THE OTHER BRAKE LINE WERE ALSO VERY RUSTED AND COULD FAIL. I REPLACED BOTH REAR BRAKE LINES WITH MATERIAL THAT WILL NOT RUST. IT WAS A VERY LABOR INTENSIVE JOB AND ALSO VERY COSTLY. PLEASE LET OTHER PEOPLE THAT OWN THIS TYPE OF VEHICLE TO CHECK THEIR BRAKE LINES. THIS COULD HAVE BEEN A VERY SERIOUS SITUATION IF MY WIFE HAD BEEN TRAVELING FAST ON A HIGHWAY. THE CAR ONLY HAS 53K MILES AND HAS BEEN GARAGED FOR MANY YEARS. IT AMAZING AT HOW MUCH RUST IS ON THIS VEHICLE. I HOPE GM WILL USE MATERIAL THAT DOES NOT RUST IN FUTURE AUTOMOBILES LIKE THIS!!! *TR

SPEEDOMETER FROZE ON 57MPH. IT SEEMED TO FIX ITSELF AFTER A SERIES OF STARTUPS.

MY FAN BLOWER STOPPED WORKING IN JUNE. TOOK MY TAHOE TO LOCAL MECHANIC, WHO DIAGNOSED A FAILED BLOWER RESISTOR. HE REPLACED THE RESISTOR ON 6/19. ABOUT A WEEK LATER, THE FAN STOPPED AGAIN. ON 7/3 HE FOUND THE RESISTOR CORRODED AFTER ONLY TWO WEEKS. HIS PARTS PLACE REPLACED THE RESISTOR ON WARRANTY. ON 7/4 THE FAN BLOWER BLEW UP. 1/3 OF THE BLOWER COVER IS MISSING (CHARDS). I WAS IN REVERSE IN MY DRIVEWAY, WITH THE AC RUNNING ONLY A COUPLE OF MINUTES, AND HER A LOUD BANG AND A PUFF OF SMOKE CAME OUT THE GLOVE BOX. GM HAS SPECIAL COVERAGE BULLETINS 11046, 10240 AND 10240A ON SIMILAR PROBLEMS WITH SIMILAR VEHICLES, BUT THEY SAY THEY DO NOT COVER THE TAHOE. *TR

DROVE 2 MILES TO STORE NEARBY. PARKED VEHICLE WENT INSIDE STORE. WHEN LEAVING I WAS TOLD I COULD NOT USE THIS EXIT BECAUSE OF VEHICLE FIRE. FIRE INVESTIGATOR TOLD ME FRONT LEFT WHEEL BEARING OVERHEATED CAUSING BEARING GREASE TO ACT AS ACCELERANT CAUSING TOTAL VEHICLE FIRE. VEHICLE COMPLETELY ENGULFED WITHIN ONE AND ONE HALF MINUTES. VEHICLE TOTAL LOSS. *TR

MY BOLTS ON MY EXHAUST MANIFOLD ARE BREAKING OFF. I HAVE FIVE GRAND KIDS THAT RIDE IN MY TRUCK AT TIMES. I DON'T WANT CARBON MONOXIDE COMING INTO MY TRUCK. THESE BOLTS SHOULD NOT JUST BREAK OFF, THIS IS AN EXPENSIVE REPAIR AND SHOULD BE RECALLED BY THE MANUFACTURER. I HAVE SEEN WHERE THIS HAS BEEN AN ON GOING ISSUE WITH CHEVY AND GM TRUCKS. THIS TRUCK WAS BUILD WITH FAMILY IN MIND. NOW BECAUSE OF THIS ISSUE MYSELF AND MY FAMILIES SAFETY IS AT RISK. *TR

REAR BUMPER (INSIDE AND OUT) HAS SEVERE RUSTING. AT FIRST PAINT BUBBLED THEN RUSTING SET IN FEW MONTHS LATER. I CALLED GM AND THEY REFUSED TO REPAIR. A 7 YEAR OLD CAR SHOULD NOT HAVE THIS SEVERE RUSTING. THE BUMPER LOOKS AS IF BELONGS TO A VINTAGE 30 YEAR OLD CAR! JUST NOT RIGHT AND EVEN MORE SO THAT GM IS NOT TAKING RESPONSIBILITY FOR SOMETHING THAT SEEMS TO BE A MANUFACTURER DEFECT! *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE SPEEDOMETER FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 92,000.

TAILGATE AND REAR WINDOW WILL NOT LOCK. *TR

WE PURCHASED OUR 2005 TAHOE BRAND NEW AND HAVE KEPT UP WITH REGULAR MAINTENANCE AND IT HAS BEEN A GREAT, SAFE CAR. FOR CHRISTMAS WE WERE OUT OF TOWN VISITING FAMILY AND WHEN WE ARRIVED TO UNLOAD THE CAR, WE DISCOVERED THE LIFT GATE AND THE GLASS WERE STUCK IN THE LOCK POSITION. WE COULD NOT GET EITHER OPEN TO LOAD|UNLOAD OUR LUGGAGE AND|OR GIFTS. THERE IS NO MANUAL KEY HOLE IN THE BUTTON, WHICH I FIND ODD THAT SOME MODELS OF THE SAME YEAR HAS THEM AND SOME DON?T. I AM CONCERNED THAT SINCE I HAVE A 3RD ROW OF SEATS, AND IN MY EYES WITH PASSENGERS IN THE BACK ? THEY CANNOT GET OUT IF THERE IS AN EMERGENCY. TO ME, A RECALL SHOULD BE ISSUED FOR THE SAFETY OF THE INDIVIDUALS WHO RIDE IN THE VEHICLE AND GM SHOULD TAKE OWNERSHIP REGARDLESS OF WARRANTY OR NOT. *TR

2005 CHEVY TAHOE WAS IN AN ACCIDENT AND HIT FRONT DRIVERS SIDE INTO DIRT EMBANKMENT AT 35-40 MPH PUSH DRIVERS SIDE TIRE BACK ABOUT 3" AND BUCKLED HOOD AND FENDER AND THE AIRBAGS DIDN'T GO OFF. *TR

I WENT TO THE STORE APROX AT 8PM AND GO BACK APROX AT 915PM AND PARK MY CAR. APROX AT 11PM MY NEIGHBORS CALL US AND SAID THAT MY TRUCK WAS ON FIRE. THE FIRE DEPARTMENT SAID THAT THIS STARTED APROX FROM THE ENGINE PART. *TR

MECHANIC INFORMED ME THAT MY FUEL AND BRAKE LINES NEED TO BE REPLACED DUE TO THE FACT THAT THEY ARE TOTALLY CORRODED. *TR

WHILE DRIVING SPEEDOMETER STAYS AT 0. INSTRUMENT CLUSTER IS MALFUNCTIONING. *TR

SPEEDOMETER STOPPED WORKING OR WILL DISPLAY FALSE SPEEDS FROM 0 WHILE DRIVING ON HIGHWAY TO 120 WHILE DRIVING ON SURFACE STREETS. WHILE RESEARCHING THIS PROBLEM I HAVE FOUND MANY OTHER 2005 CHEVY TAHOE OWNERS EXPERIENCING THE SAME PROBLEM. *TR

TRUCK SHIFTS INTO 4 LOW AND STABILITY CONTROL SHUTS OFF FOR NO APPARENT REASON. DANGEROUS AT THE LEAST. HEARD OF MANY CASES OF THE SAME ISSUE. REPLACED SWITCH ,STILL HAS ISSUE. *TR

LOST BRAKES GETTING OFF INTERSTATE 20/59, SEEMS TO BE A CORROSION ISSUE ON THE BRAKE LINE GOING TO REAR AXLE. THE LOCATION OF THE LEAK RELATIVE TO THE BODY IS AT THE 2 L DOOR ALONG THE FRAME RAIL. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED WHILE TRAVELING AT AN UNKNOWN SPEED THE GEAR SHIFT INDICATOR LIGHT FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE INSTRUMENT CLUSTER HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V055000 (POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR). THE FAILURE AND CURRENT MILEAGE WAS UNAVAILABLE.

THE SPEEDOMETER WOULD NOT DECREASE SPEED, AND BUT WOULD REGISTER AN INCREASE, AND CONSEQUENTLY WOULD NOT REFLECT ACTUAL SPEED. I COULD CORRECT PROBLEM BY REPEATEDLY STARTING VEHICLE, UNTIL EVENTUALLY IT JUST WOULD NO LONGER REGISTER A CHANGE IN SPEED AT ALL. NOW I HAVE NO IDEA WHAT SPEED MY VEHICLE IS TRAVELING. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE REAR LIFTGATE COULD NOT BE OPENED ELECTRONICALLY OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE DOOR LATCH FAILED DUE TO DEFECTIVE MATERIAL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 80,806.

WHILE DRIVING DOWN FREEWAY AT 65MPH THE SPEEDOMETER WENT TO 105MPH. IT NOW READS 25MPH WHEN STOPPED AND WILL READ 65MPH WHILE ONLY TRAVELING 35MPH. THIS HAS BEEN VERIFIED WITH A GPS. THIS HAS BEEN AN ON GOING PROBLEM WITH A LOT OF GM VEHICLES AND MANY CUSTOMERS HAVE COMPLAINED ABOUT THE SAME PROBLEM. THE ONLY FIX IS A NEW INSTRUMENT CLUSTER. SOMETHING NEEDS TO BE DONE ABOUT THIS, A RECALL NEEDS TO BE DONE! *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE LIFT GATE FAILED. AS A RESULT, WHENEVER THE CONTACT ATTEMPTED TO OPEN THE LIFT GATE IT WOULD NOT LOCK IN PLACE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DECIDED TO GREASE THE LATCH AND THE LIFT GATE FINALLY LOCKED. THE FAILURE RECURRED AND THE VEHICLE WAS NOT REPAIRED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE FAILURE MILEAGE WAS 94,000. UPDATED 10/24/12 *CN UPDATED 11/08/2012 *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE REAR LIFTGATE GLASS WINDOW BECAME LOOSE. THE DEALER WAS NOTIFIED OF THE FAILURE WHO STATED THAT THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE RAN OUT OF FUEL WHEN THE FAILURE OCCURRED, BUT THE FUEL GAUGE DID NOT DISPLAY AN EMPTY READING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL LEVEL SENSOR NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 97,000 UPDATED 10/17/12*LJ

THE SAFETY ISSUE HERE IS THE FACT THAT GM DOOR ACTUATORS DO NOT WORK PROPERLY. GM IS NOT RECALLING THE PARTS AND THIS HAS BEEN GOING ON FOR YEARS. DOORS WILL NOT LOCK, OR OPEN CONSISTENTLY, AND THEY DO NOT COVER THE REPAIRS UNLESS YOU HAVE THE ORIGINAL FACTORY WARRANTY OR IT MIGHT BE COVERED ON MAJOR GUARD WHICH THEY DON'T EVEN OFFER ON MY VEHICLE. THE INTERNET IS FILLED WITH THOUSANDS OF PEOPLE WITH THE ISSUE. PEOPLE CAN BE CARJACKED, OR THEIR VEHICLES STOLEN BECAUSE THEIR DOOR LOCKS WON'T FUNCTION. GM JUST FLAT OUT DOES NOT CARE, AND THE PROBLEM ISN'T JUST ON THE TAHOE & SUBURBAN LINES. HERE ARE JUST A FEW LINKS OUT THERE ON THIS ISSUE. HTTP://TOWNHALL-TALK.EDMUNDS.COM/WEBX?14@@.F206D4B/0 HTTP://WWW.CHEVYMALIBUFORUM.COM/FORUMS/SHOWTHREAD.PHP?T=7950 AND HERE'S SOMEONE WHO APPEARS TO HAVE A FIX, GET RID OF THE CHEAP CHINESE PARTS. HTTP://WWW.GREENHYBRID.COM/DISCUSS/F69/TAHOE-DOOR-LOCK-ACTUATOR-PROBLEM-SOLUTION-27064/ THE FACT THAT THIS BUSINESS PRACTICE IS ALLOWED TO CONTINUE SEEMS ABSURD. THIS PART NEEDS TO BE FIXED AND A RECALL ISSUED. AT A MINIMUM IT SHOULD BE COVERED BY GM FOR ALL FAILURES ON ALL VEHICLES. *TR

THE REAR TAILGATE LOCK STOPPED FUNCTIONING WHICH PREVENTS THE REAR WINDOW OR THE TAILGATE TO BE OPENED. THERE IS NOT A MANUAL WAY TO OPEN THE TAILGATE OR WINDOW FROM THE INSIDE EITHER. *JB

I HAVE A 2005 TAHOE WHICH I BOUGHT NEW. ABOUT 5-6 MONTHS AGO MY SPEEDOMETER WENT OUT. I DIDN'T HAVE THE FUNDS AT THE TIME AND LET IT GO EVEN THOUGH I FELT IT WAS A SAFETY ISSUE. I RECEIVED NO LETTER FROM GM THAT THEY WERE HAVING THIS PROBLEM UNTIL TODAY. I BROUGHT MY CAR INTO MY LOCAL GOODYEAR PLACE AND THEY WERE GOING TO CHARGE ME HUNDREDS OF DOLLARS TO FIX IT. MY SISTER, WHO HAD WORKED AT GM, HAD ME CALL THE CHEVROLET DEALERSHIP JACK BURFORD IN RICHMOND, KENTUCKY. THEY SAID THEY'D GIVE ME A NEW CLUSTER BUT THAT I WOULD HAVE TO PAY FOR THE LABOR ($130), I THEN CALLED GN AT 800-222-1020 AND TALKED WITH A WOMAN NAMED[XXX]. SHE TOLD ME THAT THEY DID NOT HAVE A RECALL ON THAT ISSUE BUT A "SPECIAL POLICY". ALSO, IT WAS GOOD ONLY FOR CARS WITH LESS THAN 80,000 MILES. MINE HAS 97,000. THEY'RE STILL GOING TO FIX IT THOUGH BUT IT MAKES ME UPSET THAT THEY DIDN'T NOTIFY ME ABOUT THIS PROBLEM AND THAT I HAVE TO PAY FOR THE LABOR. THE POLICY APPARENTLY WENT INTO EFFECT IN 2005, WHEN I PURCHASED THE VEHICLE AND EXPIRES IN JULY, 2012. I WONDER IF OTHER PEOPLE HAVE HAD THIS PROBLEM AND, IF SO, SINCE THIS IS POTENTIALLY A SAFETY ISSUE, SHOULD THE CARS BE RECALLED? THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE HAVE A 2005 CHEVY TAHOE AND WE RECENTLY ENCOUNTERED A PROBLEM - THE LIFTGATE WILL NOT UNLOCK. WE DISCOVERED THAT IS NO MANUAL KEY ENTRY AND THERE IS NO INTERNAL UNLOCK SYSTEM. THIS IS A MAJOR SAFETY ISSUE : REPEAT: THERE IS NO INTERNAL UNLOCK SYSTEM WHICH IS A HUGE SAFETY ISSUE IN THE EVENT OF AN EMERGENCY EXIT NEEDED - ESPECIALLY WITH THE THIRD SEAT INSTALLED. THE ONLY WAY TO UNLOCK THE LIFTGATE IS VIA REMOTE KEY - BUT THE LOCK DOES NOT RESPOND TO THE REMOTE KEY SO THE LIFTGATE CANNOT OPEN. THERE ARE TREMENDOUS AMOUNTS OF COMPLAINTS POSTED ON THE INTERNET FORUMS AND WE CAN NOT BELIEVE THAT THERE IS NO RECALL ON THIS HORRIBLY UNSAFE SITUATION - NOT TO MENTION EQUIPMENT FAILURE. WHAT IS BEING DONE ABOUT IT? THANK YOU. *TR

THE "SERVICE STABILITY" WARNING MESSAGE DISPLAYED, ABS WARNING LIGHT, TC TIRE DEFLATION, AND BRAKE FAILURE LIGHT. THE FIRST FAILURE OCCURRED ON OR ABOUT FEBRUARY 13, 2012. I TOOK THE VEHICLE TO THE CHEVROLET DEALERSHIP IMMEDIATELY AND THE REPAIR WAS COMPLETED BY MARCH 27, 2012 AFTER 3 ATTEMPTS. THE COMPUTER TESTER WAS ALLEGED TO SHOW THAT THE EBCM HAD FAILED AND WAS REPLACED. THIS DID NOT CLEAR THE DEFECT AND THE SAME WARNINGS CONTINUED WHEN EVER THE CAR WAS WASHED OR BECAME WET FROM RAIN. THE DEFECT WAS SAID TO BE IN THE WIRE THAT POWERED THE EBCM IN THE PROXIMITY OF THE FIREWALL. THE WIRE WAS STATED TO BE FRAYED. WHEN THE WIRE WAS REPLACED THE PROBLEM WAS CORRECTED. I AM CONCERNED THAT THE WIRE MAY HAVE BEEN DAMAGED FROM ABRASION NEAR THE FIREWALL COMBINED WITH CORROSION FROM ROAD SALT. THIS COULD HAVE LEAD TO FAILURE OF THE ABS, AIRBAGS, AND STABILITY CONTROL AT A TIME WHEN IT IS MOST NEEDED. *JS

MY SPEEDOMETER HAS RECENTLY EITHER NOT MOVED AT ALL OR DISPLAYS EXCESSIVE SPEEDS INCLUDING 120MPH WHEN TRAVELING ON AVERAGE OF 35MPH TO 50MPH WHICH IS ARE THE REGULAR LIMITS FOR MY AREA. SOME SPEEDS WERE AS LOW AS 25. LATELY, IT HAS ONLY WORKED FOR A SMALL PERCENTAGE OF THE TIME. THE ONSTAR DIAGNOSTIC DOES NOT EVEN DETECT THAT THIS HAS/IS A PROBLEM. *TT

2005 CLUSTER HAS STOPPED WORKING AND OBVIOUSLY THIS IS NOT SOMETHING NEW TO ANYBODY THAT OWNS A TAHOE. PLEASE RECALL!!!

ALL THE GAUGES ON MY DASHBOARD QUIT WORKING ALL AT ONCE EXCEPT MY FUEL GAUGE AND SPEEDOMETER. THERE ARE LOTS OF COMPLAINTS ON THIS AND GM NEEDS TO ISSUE A RECALL AND FIX THIS.

BRAKES FAILED DUE TO RUST IN THE BRAKE LINES CAUSING THEM TO RUPTURE WITHOUT ANY WARNING WHILE VEHICLE WAS IN MOTION. LUCKILY ACCIDENT WAS AVOIDED DUE TO LOW SPEED ON A RESIDENTIAL ROAD. YOUNG CHILDREN WERE TRAVELING IN THE VEHICLE. ALL BRAKE FLUIDS WERE IMMEDIATELY LOST AND BRAKE PEDAL DROPPED ALL THE WAY TO THE FLOOR AND DID NOT SLOW VEHICLE AT ALL. DASH WARNING LIGHTS DID NOT GIVE ANY FOREWARNING! VEHICLE IS ONLY 7 YEARS OLD. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT WAS DRIVING 70 MPH WHEN THE SPEEDOMETER FAILED AND RESET TO ZERO. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 61,890 AND THE CURRENT MILEAGE WAS 62,100.

EXHAUST MANIFOLD BOLTS BREAKING OFF. EPA EMISSIONS . EXHAUST LEAK UNDER HOOD CAN GET INTO PASSENGER COMPARTMENT. *TR

I A 2005 CHEVY TAHOE THAT HAS THE 3RD STEERING BALL JOINT MID SHAFT BROKEN AGAIN. I HAD THE LAST TWO REPAIRS DONE AND NEEDS IT AGAIN, THIS IS A VERY KNOWN PROBLEM WITH THESE MODEL VEHICLES AND WAS TOLD BY THE DEALER THAT GENERAL MOTORS IS NOT GOING TO DO ANYTHING, I WAS TOLD TO DEAL WITH IT. THE FACT IS THAT THIS IS A DISTRACTION TO THE DRIVER WHEN DRIVING AND IN WORRY IF THE STEERING WILL BECOME DISABLED WHEN DRIVING. THIS CONCERN NEEDS TO BE REVIEWED BEFORE AN ACCIDENT DOES HAPPEN. AT THIS TIME THE PROBLEM IS ONLY A DISTRACTION AND FEELS UNSAFE WHEN DRIVING, BUT THIS NEEDS TO BE INVESTIGATED BEFORE AN INJURY OR DEATH OCCURS FOR THIS COMMON COMPLAINT BY MANY CHEVY TAHOE,SUB,TRUCK OWNERS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT ALL OF THE INSTRUMENT PANEL GAUGES WERE DEFECTIVE AND DID NOT PROVIDE AN ACCURATE READING. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THE FAILURE AND ADVISED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 122,000.

THE CHEVROLET TAHOE TAILGATE LOCK DO NOT HAVE AN EMERGENCY RELEASE INSIDE THE CAR. THE TAILGATE ACTUATOR HAS STOP FUNCTIONING ON MY CAR AND THERE NO WAY FOR ME TO OPEN THE DOOR. NOT EVEN TRYING TO OPEN WITH A KEY, BECAUSE THERE IS NO KEY OPTION TO OPEN THE DOOR ON THIS MODEL ON THE OUTSIDE TAILGATE. SINCE, CHEVROLET FAILED TO PLACE A RELEASE INSIDE THE CAR. I FEEL THAT THIS IS A SERIOUS LIFE OR DEATH ISSUE. IF MY KIDS ARE IN THE CAR TRYING TO ESCAPE A FIRE OR CAR SUBMERGED UNDER WATER. THERE WILL BE NO WAY FOR THEM TO ESCAPE. THIS ITEM NEED TO BE CORRECTED AND FIXED. I'M FINDING SEVERAL INCIDENTS ON THE INTERNET WERE THE LOCKING UNIT HAS FAILED. THIS IS A SERIOUS SAFETY ISSUE. *TR

MY 2005 CHEVY TAHOE 71Z SPEEDOMETER HAS FAILED. IT REGISTERS VARIABLE SPEEDS WHICH I KNOW TO BE INCORRECT. INTERNET SEARCH CONFIRMS IT IS THE STEPPER MOTOR WHICH MUST BE REPLACED. SEVERAL COMPLAINTS BY OTHER OWNERS HAVE BEEN FILED. GM SHOULD RECALL THE 2005'S AS THEY DID THE 2003 AND 2004 FOR THE SAME PROBLEM. *TR

FUEL SENDING UNIT NOT FUNCTIONING ON 2005 CHEVROLET TAHOE. SPOKE WITH MY MECHANIC WHO STATED IT WAS A VERY COMMON PROBLEM WITH CHEVROLET TAHOE. THE SENDING UNIT MADE IT SO THE GAS DID NOT REGISTER ON THE FUEL GAUGE MAKING IT LIKELY TO RUN OUT OF GAS AT AN INOPPORTUNE TIME, POSSIBLY CREATING A TRAFFIC HAZARD OR CRASH. *TR

FACTORY INSTALLED HITCH RECEIVER IS SEVERELY TWISTED. THE ISSUE HAS DEVELOPED OVER THE PAST 4 YEARS BUT WITH VERY INFREQUENT USE. IF THE VEHICLE HAD DONE A LOT OF HEAVY TOWING THIS UNIT WOULD HAVE FAILED FOR SURE. THIS COULD HAVE CAUSED A VERY SERIOUS ACCIDENT IF THE FAILURE WERE TO HAVE BECOME CATASTROPHIC. I HAVE COME TO DISCOVER THAT THIS IS A COMMON PROBLEM ENCOUNTERED BY THE MAJORITY OF THOSE WHO HAVE USED THE VEHICLE FOR ANY INTERMEDIATE TOWING. *TR

MY TPMS ARE EXTREMLY CORRODED AND THEY SNAPPED OFF!!!! *TT

I HAVE 4 MICHELIN CROSS TERRAIN TIRES P265/70R17. THEY ARE UNDER WARRANTY WITH PLENTY OF TREAD BUT THE SIDE WALLS (NOT NEAR TREAD) OF ALL FOUR TIRES HAVE DEEP LONG CRACKS (UP TO 8 INCHES IN LENGTH) I NOTICED THIS SEPT. 2010 AND THE DEALER ISN'T VERY HELPFUL AND JUST WANTS TO CHARGE ME MONEY FOR NEW TIRES. I BELIEVE THIS IS A HUGE SAFETY HAZARD AND THEY SHOULD BE RECALLED! *KB

TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT THE HORN WOULD NO LONGER SOUND WHEN PRESSURE WAS APPLIED TO THE CENTER OF THE STEERING WHEEL. THE ONLY TIME THE HORN WOULD SOUND WAS WHEN THE BUTTON ON THE KEY FOB WAS ENGAGED. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 72,000. THE VIN WAS UNAVAILABLE.