2005 Chevrolet Silverado 2500 complaints

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE DRIVING 50 MPH, THE BRAKES FAILED. THE CONTACT ATTEMPTED TO REGAIN CONTROL OF THE VEHICLE AND THE STEERING FAILED. THE DRIVER INSPECTED THE VEHICLE FOR LOW FLUIDS, LEAKS, AND OTHER POSSIBLE CAUSES OF FAILURE. THE DEALER ADVISED THE CONTACT TO HAVE THE VEHICLE DIAGNOSED BY A MECHANIC. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED AND THAT THE IMMEDIATE FAILURE COULD CAUSE A CRASH. THERE WERE NO WARNING INDICATOR LIGHTS PRESENT. THE CONTACT HAS NEVER RECEIVED ANY RECALL NOTICES. THE CURRENT AND FAILURE MILEAGES WERE 200,078.

WHILE TOWING APPROXIMATELY 11,000 POUNDS, VEHICLE EXHAUST GAS TEMPERATURE EXCEEDED 1300 DEGREES. THIS HAS HAPPENED SEVERAL TIMES. DEALER, MOSSY CHEVROLET STATED THIS IS NORMAL. *TR

1. I BOUGHT A USED "CERTIFIED" 2500 HD SILVERADO WITH 33000 MILES ON IT. I HAVE OWNED IT ABUT THREE MONTHS. ON THREE SEPARATE OCCASIONS I HAVE NOTICED THE TRANSMISSION SLIP OR "HESITATE" WHEN ACCELERATING FROM A STOP. THE ENGINE WILL REV BUT THE CAR DOES NOT MOVE. WHEN I LET OFF THE GAS I CAN FEEL IT SHIFT SUDDENLY AND THE CAR WILL MOVE. 2. I NOTICED A WHINING SOUND IN THE TRANSMISSION WHEN IT IS IN GEAR. CHEVROLET SERVICE DEPARTMENT TELLS ME IT IS COMMON ON MY TRUCK AND THERE IS NOTHING THEY CAN DO ABOUT IT, IT IS THE PLENARY. THE SOUND IS LOUDER AND CONTINUES THROUGHOUT THE ENTIRE DRIVING RANGE. IT BEGAN AT ABOUT 35000 MILES. THE SERVICE REP STATED THEY HAD A SERVICE ANNOUNCEMENT ON IT, BUT I HAVE NOT SEEN THAT YET. 3. ABOUT THREE WEEKS AFTER I BOUGHT THE TRUCK, I NOTICED A CLICKING AND GRINDING SOUND WHEN THE BRAKES WERE APPLIED LIGHTLY. FIRST TIME IN THE DEALER COULD NOT FIND ANYTHING. SECOND TIME IN THEY FOUND THE LEFT REAR AXLE SEAL LEAKING AND REPLACED THAT. THE THIRD TIME IN THEY ADJUSTED THE BRAKES SO THAT IT WAS ALMOST IMPOSSIBLE TO APPLY LIGHT BREAK PRESSURE. AFTER A COUPLE OF DAYS OF USE THE BRAKES LOOSENED UP SOME AND NOW THE CLICKING AND GRINDING NOISE IS BACK AND IT IS MORE NOTICEABLE WITH EVEN A LITTLE HEAVIER PRESSURE ON THE BRAKES. I WILL BE SCHEDULING A RETURN TRIP FOR THIS AND THE WHINING SOUND IN THE TRANSMISSION, BUT GM SEEMS TO TAKE THE APPROACH THAT IF IT IS "FUNCTIONING" DON'T REPAIR IT. *JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. AT 25 MPH ON A CLEAR DAY, THE CONTACT LOST CONTROL OF THE BRAKES AND STEERING, CAUSING THE VEHICLE TO DRIVE INTO A SNOW BANK. THE CONTACT ATTEMPTED TO DEPRESS THE BRAKE PEDAL COMPLETELY TO THE FLOOR, BUT THE VEHICLE WOULD NOT STOP. THE DEALER REPLACED THE HYDRO BOOST ASSEMBLY IN THE VEHICLE. THE CONTACT STATED THAT THE REPAIR COST $925. THE DEALER NOTIFIED THE CONTACT OF RECALL CAMPAIGN # 05V04300 FOR THE SERVICE BRAKES, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE FAILURE MILEAGE WAS 44,000.*AK UPDATE *4/23/07TR

DURING A ROUTINE MORNING COMMUTE, I NOTICED THE CHECK ENGINE LIGHT HAD ILLUMINATED. IMMEDIATELY FOLLOWING THE MALFUNCTION, I NOTICED A SEVERE DECREASE IN ENGINE POWER AND THE ENGINE STARTED TO VIBRATE AND MIS-FIRE HEAVILY. I WAS IN HEAVY TRAFFIC AND HAD TO PULL OFF OF THE ROAD TO AVOID A POTENTIAL ACCIDENT SITUATION. I THEN SHUT THE TRUCK OFF, AND RE-STARTED THE VEHICLE TO POSSIBLY RE-SET THE LIGHT. THE ENGINE STARTED AND SEEMED TO RUN SMOOTHLY AGAIN, BUT THE LIGHT STAYED ILLUMINATED. IT WAS 7AM, SO I DECIDED TO VERY SLOWLY DRIVE TO THE DEALERSHIP WHERE I HAD PURCHASED THE TRUCK. THE TECHNICIAN PERFORMED A DIAGNOSIS, AND FOUND A HARD CODE OF P2146 INSULATE FICM. I WAS THEN TOLD THAT THE MAIN FUEL INJECTOR SYSTEM WIRING HARNESS HAD CHAFFED ON A FACTORY INSTALLED BRACKET AND THAT IT WOULD NEED TO BE REPLACED. I WAS THEN TOLD THAT THEY DID NOT HAVE THE PARTS IN STOCK, AND THAT I WOULD HAVE TO WAIT FOR ONE WEEK TO HAVE THE PARTS REPLACED. IN THE MEANTIME, THE TECHNICIAN STATED THAT HE HAD "INSULATED" THE HARNESS, AND THAT THE LIGHT WAS OUT. HE STATED THAT I SHOULD BE ABLE TO DRIVE THE TRUCK WITHOUT ANY ISSUES, BUT IF THE CHECK ENGINE LIGHT COMES ON AGAIN AND I ALSO RECEIVE A "LOW POWER" MESSAGE ON THE ANNUNCIATOR PANEL IN THE DASHBOARD, THAT I MUST PARK THE TRUCK AND GET A RENTAL VEHICLE UNTIL THE PARTS ARRIVE AND REPAIRS CAN BE MADE. THE TECHNICIAN STATED THAT THIS WOULD CAUSE FOUR OF THE EIGHT CYLINDERS TO SHUT DOWN AND CAUSE A LEAN ENGINE FUEL CONDITION WHICH COULD RESULT IN E

SPEEDOMETER WILL READ VERY HIGH SPEEDS WHEN TRAVELING SLOWLY. E.G. 110 MPH TRAVELING 30 MPH. HAPPENS IN COLD, COLD WEATHER. *NM

THE FRONT END STEERING COMPONENTS CLUNK VIBRATE AND VEER IN WRONG DIRECTION. *NM

DRIVING 50 MPH ON ROAD, I STEPPED ON THE ACCELERATOR PEDAL TO ACCELERATE AND THE VEHICLE ENGINE LIGHT CAME ON. HOWEVER THE VEHICLE WOULD NOT ACCELERATE IT WAS SPITTING AND SPUTTERING AND SLOWED DOWN FOR A WHILE . I PULLED OVER TO THE SIDE OF THE ROAD AND SHUT IT OFF. AFTER TEN MINUTES, THE VEHICLE WAS RESTARTED, AND LIGHT WENT OUT AND IT RAN PERFECTLY. *JB

REAR BRAKE ROTORS RUSTED AND PADS ONLY MAKING 1/2" CONTACT ON INBOARD SIDE OF ROTORS ON 2005 CHEVY SILVERADO 2500 HD WITH LESS THAN 11,000 MILES. GM FIX IS TO TURN ROTORS INSTEAD OF REPLACING WITH ROTORS THAT DON'T RUST THIS QUICKLY. *JB

I PARKED MY PICKUP TRUCK 2005 CHEV. 2500 HD ON A HILL SIDE IN ORDER TO COLLECT ROCKS TO USE IN CREATING FLOWER BEDS AT HOME. MY WIFE AN I HAD PARKED THE VEHICLE FOR ABOUT 10-15 MINUTES. THE TRUCK WAS PLACED IN PARK WITH THE IGNITION OFF. WE WERE STANDING ABOUT 15 FT FROM THE TRUCK WHEN WE HEARD A LOUD POPPING METALLIC SOUND. THE TRUCK IMMEDIATELY BEGAN TO ROLLED BACK AND TRAVELED ABOUT 20 FEET OR SO BEFORE RUNNING UP AND ONTO A WOOD LOG. I HAVE CONTACTED CHEVROLET AND THEY MADE A COMPUTER CHECK OF THE VEHICLE AND FOUND NOTHING WRONG. I REQUESTED THAT CHEVROLET CHECK THE TRANSMISSION AND STEERING COLUMN. THEY DECLINED. MY WIFE AND I COULD HAVE BEEN SERIOUSLY INJURED BY THE FAILURE OF THE VEHICLE TO STAY IN THE PARKING GEAR POSITION (AUTOMATIC TRANSMISSION). WHAT CAN WE DO TO RECTIFY THIS SITUATION? *JB

WHEN THREE PEOPLE ARE IN BACK SEAT OF TRUCK, PERSON NEAREST LEFT REAR DOOR CANNOT CONNECT SEAT BELT INTO THE SEAT BELT HOLDER. HOLDER WILL NOT STAY UP---A PERSON'S LEFT HAND HAS TO HOLD SEAT BELT OVER THE BODY, WHILE THE RIGHT HAND TRIES TO INSERT THE CLASP. A THIRD HAND IS NEEDED TO KEEP THE SEAT BELT HOLDER RAISED IN ORDER TO DO THIS.----ONLY SOLUTION IS TO ABANDON THE SEAT BELT HOLDER. *JB

DT*: THE CONTACT STATED AFTER PARKING THE VEHICLE IN THE CARPORT FOR TWO HOURS, IT CAUGHT ON FIRE WITHOUT WARNING. THE FIRE DEPARTMENT WAS CALLED AND THE FIRE WAS EXTINGUISHED. THERE WAS PROPERTY DAMAGE TO THE HOUSE AND THE VEHICLE WAS TOTALED. A REPORT WAS TAKEN WITH THE FIRE DEPARTMENT. THE DEALER WAS NOTIFIED.

DT*: THE CONTACT STATED THE VEHICLE HAD BEEN TO THE DEALERSHIP ON 5 OCCASIONS FOR BRAKE REPAIRS. THE VEHICLE VIBRATED AND PULSATED WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE FRONT END OF THE VEHICLE SHOOK. THE FIRST TIME, THE ROTORS WERE CUT AND THE PADS WERE SHAVED. THE SECOND TIME, THE ROTORS WERE CUT AND THE PADS WERE REPLACED. THE THIRD TIME, THE ROTORS WERE CUT AND THE PADS WERE SHAVED. THE FOURTH TIME ON 8-15-06, THE ROTORS WERE CUT AND THE PADS WERE EITHER SHAVED OR REPLACED. ON 8-19-06, THE VEHICLE VIBRATED AGAIN AND THE BRAKE PEDAL PULSATED WHEN DEPRESSED. THE CONTACT TOOK THE VEHICLE BACK ON 8-25-06. THE DEALERSHIP TEST DROVE THE VEHICLE, BUT DID NOT INSPECT THE BRAKES AND COULD NOT DUPLICATE THE PROBLEM. UPON INSPECTING THE ROTORS, THE CONTACT NOTICED GROOVES IN THE ROTORS WITHIN 500 MILES OF THE LAST TIME THE ROTORS WERE CUT.

PARKED ON BOAT RAMP, IN PARK WITH E BRAKE ON. BOAT WAS OFF TRAILER (AFLOAT). I WAS UNHOOKING AND WINDING UP FRONT STRAP WHEN I NOTICED TRUCK MOVING BACKWARD INTO LAKE. I WAS ABLE TO JUMP IN AND STOP VEHICLE BY APPLYING SERVICE BRAKES. A TOW CHAIN WAS ATTACHED, I PUT TRANSMISSION INTO DRIVE AND WAS SAFELY BE PULLED OUT. VEHICLE IS A TOTAL LOSS. SHIFT SELECTOR AND E-BRAKE FAILURES? *NM

AFTER A STOP IN THE PARKING LOT, WITH MY FOOT ON THE BRAKE, SHIFTING FROM DRIVE TO PARK THE VEHICLE WANTED TO JUMP BACKWARDS FOR A SECOND. THIS HAS OCCURRED ON SEVERAL OCCASIONS. IT FEELS LIKE IT WANTS TO GO INTO REVERSE INSTEAD OF PARK. *JB

DT*: THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE DRIVING 60 MPH ON DRY ROADS, THE VEHICLE ENGINE LIGHT ILLUMINATED. THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, HOWEVER THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND SHUT OFF. AFTER TWO MINUTES, THE VEHICLE WAS RESTARTED, AND RESUMED FUNCTIONING PROPERLY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.*AK

AFTER ENTERING VEHICLE WHICH HAD BEEN PARKED FOR 2 WEEKS A HEAVY BRUNT ELECTRICAL FIRE ORDER WAS PRESENT. AT THE SAME TIME A HEAVY SMOKE LIKE HAZE WAS PRESENT. UPON THROUGH EXAM THE FIRE WALL BLANKET IN THE ENGINE COMPARTMENT WAS FOUND MELTED IN A ROUNDISH PATTERN. ONE MONTH LATTER THERE IS STILL A BURNING ODOR IN THE CAB. *NM

IN JUNE OF 2005 I PURCHASED A 2005 CHEVROLET 2500HD WITH THE CAMP EXTENDABLE MIRRORS. UPON LEAVING THE DEALERSHIP I CALLED THE SALES REP AND TOLD HIM THE MIRRORS WERE SHAKING AND I COULD NOT IDENTIFY VEHICLES BEHIND ME. I WAS TOLD DON'T WORRY FOR I WILL HAVE REPLACEMENT MIRRORS ORDERED TOMORROW. I WAS ALLOWED BY GM A REPLACEMENT OF THE DRIVERS SIDE ONLY FOR IT WAS THE WORST. THE REPLACEMENT PROVIDES NO CHANGE PER THE SERVICE TECHNICIAN , BUT HE WAS NOT ALLOWED TO ORDER ANOTHER MIRROR FOR GM HAD RELEASED A BULLETIN OF THE MIRROR ISSUE. I CONTACTED GM RECEIVING NO RECOURSE AND NO ISSUE DATE OF A POSSIBLE FIX. ON 11-28 2005 I WAS INVOLVED IN A ACCIDENT BECAUSE I BELIEVE I WAS STARING IN THE MIRROR AND SIDE SWIPED A DUMP TRUCK THAT CROSSED THE MEDIAN,AND I DID NOT REACT IN TIME TO AVOID THIS ACCIDENT. I HAVE FILED FOR THE FLORIDA LEMON LAW BECAUSE GM TELLS ME "IT'S ONLY MIRRORS AND WE KNOW ABOUT IT SO WHEN THERE IS A FIX YOU WILL BE NOTIFIED. THE 2006'S HAVE THE CURE!!! *NM

DT: THE CONTACT STATED WHILE DRIVING 20 MPH THE SHAFT WENT INTO THE POWER STEERING PUMP AND BROKE IT. THIS CAUSED THE STEERING AND BRAKES NOT TO WORK. HE WAS ABLE TO STOP THE VEHICLE WITH THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND THEY REPLACED THE POWER STEERING PUMP. THE MANUFACTURER HAS BEEN NOTIFIED AND THERE HAVE BEEN NO FURTHER PROBLEMS. *AK UPDATED 01/04/06. *JB