2021 Chevrolet Silverado 1500 complaints

At approximately 67,000 miles I noticed upon starting and putting it in gear the motor would rev/clunk while going into gear. Shifting from one gear to another the truck would shutter. Did not feel safe driving any distance because the truck would lock up when trying to put it in gear. I had the truck looked at after reading numerous complaints about this 8 speed transmission and wanted to make sure it was safe to drive. After test driving it a couple of times during the course of a day it was determined the transmission needed to be replaced/rebuilt. At no time did any warnings appear on the display indicating there was an issue. I had the transmission rebuilt but feel like there are many complaints and no recalls regarding this same issue.

Check engine light is on, code reads emissions fail due to the Evaporative Emissions leak detection pump.( EVAP PURGE PUMP UNDERSPEED) P1467. I see this was a recall on several Chevrolet vehicles but not yet on mine.

While traveling at highway speed an engine lifter collapsed and I was left stranded with a flashing check engine light, severe engine knocking and lack of power.

Engine siezed while on a roadway that speed limit was 75 miles per hour. Was also actively pulling a trailer. Luckily avoided traffic in pulling off to the side of the road and was stuck there for about 8 hours on the side of the road. It broke down 5 hours from home.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the oil pressure level fluctuated between 60 and 0. The contact stated that the low-pressure oil warning light was illuminated. The contact stated that the oil level was continually being topped off. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure but provided no assistance. In addition, the contact was advised to have an oil change every 1,000 miles while waiting for the recall repair to be performed. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 40,000. VIN tool confirms parts not available.

My 2021 Silverado has the same issue as the current recall, whereas the tailgate open by itself when the vehicle is operations. This happens when it rains. The first time I noticed it I lost a cooler out of the back of my truck on the interstate highway. The second time it came down when hauling a trailer and cause minor damage to the tailgate. I have since removed the fuse that controls the tailgate. I notified Chevrolet of the issue, but the stated that my truck is not under the current recall.

Transmission is changing hard and jerking

The Vehicle that I own is a 2021 Chevrolet Silverado 1500 with a 6.2 liter engine. on 6/2/2025 i went to have the oil changed and the service technician informed me there was no oil in the engine. He also informed me that this particular model with the 6.2 liter engine had a recall relating to components in the engine. After researching I found that there was in fact a recall, but my truck was not listed on the NHTSA web site. I made a visit to the local dealership and the service manager informed me that there was in fact a recall but there was nothing they could do at this time. He suggested that I check the oil level every 500 miles and wait on a recall notice. Now the engine is starting to make internal noises that concern me greatly. There is a opportunity that the engine could simply lock up and there is no certainty on what might happen. Please advise

1st incident cracked frame/suspension support for front suspension, 4 months to fix, 2nd incident oil pump, lifter failure, replaced under warranty. 3rd failure engine sieze while driving at 55-60 mph. Warning light flashed loss of oil pressure shut down immediately, put it in neutral to coat to side of road but moment I shifted to N engine failed, had to tow home cuz dealer was a month out to look at it, had to send to a different dealership 60 miles away to get looked at, confirmed castrophic engine failure, GM dealer wanted me to pay to fix it. I have had 2 major engine issues, 1 major suspension frame issue.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while leaving a parking spot and driving approximately 5-10 MPH, there was an abnormal knocking sound coming from the engine before the vehicle lost motive power. There were no warning lights illuminated. The vehicle was towed to the local dealer and was diagnosed with engine failure. The vehicle was repaired. The contact stated that the vehicle had experienced catastrophic engine failure two years prior to the recent failure. The manufacturer was contacted and informed the contact that the VIN was not under recall. The failure mileage was 20,000.

Vehicle started with vibration at speed 45mph and sometimes it gets worse already balance the wheels twice and same issue so I took it to another shop and they found that my vehicle has hesitation and shuddering also really hard down shift

I am facing my second coolant control valve replace in the last 10k miles. The truck errors with a code of P1098 due to the valve failure and the fan continues to run. My truck was then put into limp mode. This valve is a know problem with this motor and not cover under warranty.

I was on my way home from work on [XXX] coming around the lakes with no median or shoulder when the engine in my 2021 Silverado started rattling, temperature gauge started going up, and losing power. Within a matter of minutes my truck shut off leaving me stranded in the middle of a four lane highway with no safe location to stop. The engine wouldn’t even turn over to try and crank back up so I could get the truck out of the road. After help getting my truck to a safe location I noticed oil and antifreeze leaking out of the bottom side of the engine. This truck was at Love Chevrolet for engine failure on 8/14/24 and was told it was fixed and was never told about ongoing issues with this particular 6.2 engine. I found out a few weeks ago while trying to trade my truck in to Jim Browne Chevrolet dealer that my particular truck the 2021 Chevrolet Silverado High Country with the 6.2 engine had known issue with the engine locking up and was afraid to take my truck in on trade due to his service manger going through this same experience. So I paid top dollar for a high end Chevrolet truck to be stuck with not being able to trade it and now not being able to drive it. I called the dealer and was told that my trucks vin number was not part of the recall for this issue but there are trucks that are the same year, model, and engine type that are covered under this recall. I’m now stuck making a 850 a month payment on a 58000 dollar truck that I can’t drive and can’t afford to replace a

Engine failure with no warning. Driving home from dinner, made a right at a stop light and then warning lights and knocking sound in engine compartment, truck noticeably shaking

Blown engine 6.2 L87 motor

Took my vehicle in on 3/24/2025 for an oil change and to check a perceived issue with transmission hesitation and a noise. Tech confirmed and repaired an issue in the transmission and also confirmed an issue within the engine. A replacement engine was ordered. Vehicle is still at the dealer awaiting the engine with no estimate as to when the engine will be shipped or received. It has now been well over 2 months. A loaner vehicle was provided on 4/30/2025 but is not comparable to my vehicle.

While driving my truck at approximately 50mph it suddenly lost power while in traffic. I was fortunate enough to pull over safely to avoid an accident. The motor was violently shaking and sounded like it was coming apart internally. Almost every warning light on the dashboard came on as I was pulling over. The truck had little power and did not sound normal. I immediately called for a tow truck and had it towed to the nearest Chevrolet dealership. After inspection they confirmed the lifters were bad. The truck had 38,000 original miles on it at the time of this incident. The dealership repaired the defective lifters. With the current GM recall on the 6.2 liter engine my truck does not qualify as it was built 1 month prior to the recall date. This truck needs to be included in the current 6.2 liter engine that GM is recalling. The motor is defective and is a major safety issue. If I was driving with my family on the highway while this abrupt incident happened it could have been catastrophic. There were no signs or warnings whatsoever prior to this incident.

Motor failed. 140k miles shouldn’t happen on a 2021. Meticulously maintained.

First my engine light came on and as I was in my way to the dealership I lost my brakes. It stayed at the shop for a week before I was contacted only for them to tell me that there was metal shaving in my engine oil and they recommend full replacement, meanwhile haven’t even made it to my brakes. GM offered me 3K toward replacing the 13K+ engine. That’s so unacceptable!

The contact owned a 2021 Chevrolet Silverado 1500. The contact stated that while coming to a stop, the contact heard a loud sound coming from the engine compartment. The check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the repair was unavailable. The vehicle was taken to the dealer, where it was diagnosed and determined that the connecting rod and the crankshaft engine components had failed, and the engine needed to be replaced. The vehicle was not repaired, and the dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving approximately 65-70 MPH, the vehicle stalled. The contact stated that several unknown warning lights were illuminated. The message “Reduced Power” was displayed. The vehicle was taken to a local dealer where it was diagnosed and determined that the lifters and push rods needed to be replaced. The vehicle was repaired but the failure recurred. The contact stated that the vehicle started to smoke while driving. The vehicle was taken back to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 7,000.

Engine started making clicking noise when accelerating. Followed by a large screeching noise. Dash read "shift to neutral and start again" pulled to stop and tried to start. Does not crank at all.

May 3, 2025 while driving home truck starting making noise and all the dash lights started blinking including the 'check engine' light. Felt not safe to drive, afraid I would lose control of truck. Immediately pulled over and called dealership who advised to have truck towed in. Truck is still in shop and apparently needs a new engine, problem seems to be the same as the recalls for engines made in 2021-2024. The engine on my truck was manufactured in 2020 and not part of the current recall. This is the 2ND time engine has failed. June 7, 2021 at 4,600 miles again driving and engine started making noise, all dash lights flashing. Again didn't feel truck was safe to drive. Towed to dealership. Cause was a 'failure of lifters on cylinder 5 and a bent push rod.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, several unknown messages were displayed before the vehicle shifted to SAFE Mode. Additionally, the contact disconnected and reconnected the battery and restarted the vehicle. The vehicle was taken to a local dealer, where it was diagnosed with a particulate filter failure. The vehicle was repaired; however, the check engine warning light illuminated. The vehicle was taken to another local dealer, Prince Chevrolet Service (4550 N Valdosta Rd, Valdosta, GA 31602); where it was diagnosed, and the contact was informed that the exhaust pressure sensor pipe and exhaust gas recirculation cooler needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was later taken to another local dealer, Nash Chevrolet (630 Scenic Hwy S, Lawrenceville, GA 30046) for a third opinion and was diagnosed with a clogged catalytic converter. The contact was informed that the NOS sensor, EGR Cooler, and DEF fluid injector needed to be replaced. The vehicle was repaired; however, the check engine warning light was illuminated. In addition, the message "LIMP Mode" was displayed on the instrument panel. The manufacturer was made aware of the failure. The failure mileage was approximately 395.

At 2000 miles my truck developed a new “fluttering”, “ticking sound” once all cylinders reactivated as apart of the dynamic fuel management system. After bringing the truck to dealership, they proceeded to replace the lifters, the exhaust system twice, and performed a computer reflash. The truck was at the dealership for over 45 days within the first 6 months of ownership. After all the repairs, the sound is still audible and getting worse. In addition to this sound, at around 30,000 miles the transmission has now developed an audible clunking sound that can be felt once on release the gas peddle under slower operating speeds. After trying to engage with GM on simply understanding what the problem is and why there is the need for so much repair on a brand new vehicle, I am candidly fed up and let down as long term GM customer.

Pulling out to an intersection my 2021 chevy Trailboss stopped going forward. All I had was reverse. Fortunately cars stopped and no one was injured. The truck was towed to a chevy dealership and was inspected and said that the transmission went out on it. The service manager told me that the "transmissions that were put in these trucks were not good" No warning lights ever came on prior to this incident. There was a recall for transmission problems for other chevy models however I have been told that my truck does not qualify for the recall.

At 38,000 miles: While driving, the engine began knocking, vibrating and shut off. The check engine light came on and the vehicle could not be restarted. It was towed to the dealer who diagnosed it with lifter failure. It was still under the powertrain warranty at this time. Several lifters were replaced as well as other engine parts and I was given the truck back after a few weeks. A week later, truck would not start. After looking under the hood I noticed most of the hoses and wires were not clipped off, causing them to just rattle and move around. Upon further investigation, I found that the wire to the starter was loose and had to be wiggled to get the truck to start. This wire should have been secured to the vehicle with the provided clips, but it was not and came loose because of it. I also found a random loose bolt lying in a void space under the hood near the windshield. I took the truck back to the dealership that replaced the lifters and explained my frustration with the condition my truck was put back together after tearing into the engine. I also showed them the random bolt I found. Their manager assured me that they would go through the engine compartment and make sure that the wires and cables were properly secured to the side like it should have been after the initial engine work. I never received an explanation of where the random bolt came from. After this engine work, my truck never seemed to drive the same. It began use more oil and the fuel MPG decreased.

The truck, while driving at highway speeds on the interstate, experienced catastrophic engine failure, seizing the motor while in driving. Luckily, I was able to pull the truck to the side of the road safely, without a crash occurring. Losing engine/braking power could have been a major concern but thankfully, traffic was light enough I had space to pull to the side of the road. The truck had to be towed to the nearest dealer, where it was discovered the motor had seized. 2021 Chevrolet Silverado Trail Boss 6.2L motor with 47k miles on the factory warranty/no modifications. Since taking the truck to the dealer, they warranty-swapped a remanufactured crate motor in the truck. Hearing of the major increase in issues with this truck, I traded it in on a different manufacturer and now have a different vehicle. Aside from this huge inconvenience and safety issue, GM's customer support line failed to cover the full cost for a rental truck while my vehicle was down for a new motor (late November 2024 until mid January 2025) and I still have yet to receive a refund for my tow bill. This experience that has now lasted almost 6 months (still with no resolution) has been horrible. I hope General Motors is held liable for this major issue.

Airbags did not deploy after a collision based accident

I have a 2021 Chevrolet Silverado 1500 with a 6.2 L engine. There seems to be a recall on this model and particular motor but my VIN does not show up. My engine has failed as described in the recall. I have a bearing failure on the crank according to my mechanics shop. Please add my VIN to the recall so I can get this problem repaired. I have been without my vehicle now for over a month and would appreciate assistance on this problem.

Engine knocking brought to dealership and they found codes P0300 and P0304 #4 cylinder with 15,000 then remove head and so order new engine from General Motors

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while operating the vehicle, there was a popping sound coming from the engine compartment, and the vehicle decelerated unintendedly and started driving rough. The vehicle was driven to the local mechanic who diagnosed an engine cylinder misfire. The mechanic replaced the fuel injector and engine lifter, and the vehicle was repaired. The contact stated that recently while driving, the same popping sound reoccurred, and the vehicle started to lose motive power. The vehicle was towed to the local mechanic who determined that the engine had failed. The exact cause of the engine failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 42,239.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while his wife was driving 35 MPH, the vehicle was making abnormal sounds. The driver drove the vehicle back to the residence. While driving at undisclosed speeds, there was an abnormal ticking and knocking sound coming from the vehicle. The contact stated that the sound went away and came back. While driving at an undisclosed speed, the vehicle lost motive power and stalled. The contact stated that the engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The dealer informed the contact missed an oil change and was negligent in servicing the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 67,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was an abnormal tapping sound coming from the engine, with the check engine warning light displayed on the instrument panel. The contact stated that while driving at various speeds, the vehicle jerked and hesitated while depressing the accelerator pedal. The vehicle was taken to an independent mechanic and a dealer, where diagnostic tests were performed. The contact was informed that the engine lifters were defective; therefore, the engine needed to be replaced. Recently, the contact stated that while at a stoplight, the vehicle shut off and failed to restart. Due to the failure, the contact had the vehicle towed to the residence. The vehicle was not repaired. A mechanic later informed the contact about NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, upon investigation, the contact discovered that the VIN was not included in the recall. The manufacturer was then notified of the failure and confirmed that the vehicle was not included in the recall. The contact was then referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 97,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 40 MPH, the vehicle started shaking abnormally, and the vehicle lost motive power. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the residence. The vehicle was then towed to a dealer where it was diagnosed with engine failure. The contact was informed that some undisclosed parts needed to be replaced. The vehicle was repaired but the contact stated that the vehicle was still shaking slightly. The manufacturer was notified of the failure. The failure mileage was 92,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the engine seized. The check engine warning light was illuminated before the failure. The contact was able to coast to the side of the road. The contact stated that the vehicle was towed to Midas, where it was diagnosed and determined that the fuel pump control unit had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included. The failure mileage was approximately 57,000.

I am filing a formal safety complaint regarding a persistent and unacceptable failure with my 2021 Chevrolet Silverado Trail Boss. The vehicle intermittently fails to start due to a recurring “Service Steering Column Lock” error. While the key fob still locks, unlocks, and remote starts the truck, the push-to-start system becomes entirely non-functional once inside the vehicle. This defect is not only frustrating — it’s dangerous. My wife has already been stranded twice, once in below-freezing temperatures in January, and again in May, causing her to be late for work and left alone at night in unsafe conditions. A truck purchased for over $60,000, marketed as rugged and dependable, should not be experiencing a critical failure like this at just 48,000 miles. What’s more concerning is that this appears to be a known issue within the GM community, with no official recall despite Technical Service Bulletins (TSBs) acknowledging the problem. Customers are being left with unreliable transportation and no consistent fix. This failure is both a mechanical and safety issue, leaving drivers vulnerable without warning. I urge NHTSA to investigate this defect, pressure GM for a formal recall, and ensure corrective action is taken before someone is injured due to being stranded or the failure progressing to more critical steering or ignition malfunctions.

Shuddering when driving. Erratic shifting and downshifting.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving on several occasions at various speeds, the temperature gauge remained at hot (Hot) location, with a dinging warning notification. The check engine and "Transmission idle temperature high" messages were displayed. The vehicle was steered to the side of the road each time and turned off for approximately 45 minutes to allow the vehicle to cool down. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 115,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving 70 MPH, there was an abnormal clunking sound coming from the engine compartment, and the contact discontinued driving the vehicle. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the push rod in cylinder 5. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 64,000.

This is 6.2 l l87 engine that is being recalled but this vin is not on list. already had lifters and rods replaced while back. coming home from trip truck made awful noise and I lost power on the interstate. thankfully was able to get out of traffic but waited 3.5 hours for tow. at dealer but cant tell me when they can look at it. 60,200 miles and they are saying well we will see what we can do but your powertrain warranty ended at 60k. i have had numerous problems and these are all known by gm especially 2021 6.2l.

The 6.2 is using 1-1.5 QT. every 3000 or so miles. I have done the check every 1000 miles. Had a bent lifter replaced 2 christmas ago.

Driving to work my engine failure light came on….the engine immediately sputtered. I immediately drove inside the bay at Ozark Chevrolet. As soon as I pulled in….the technician told me to turn it off and that I wouldn’t be driving it anymore. See my statement for $3,429.15. I have to carry my grandkids in this vehicle. I traded it in on Tundra. And now I find out about the recall. It was the 8cyl engine currently under recall.

A knocking noise coming from the left side drivers wheel

Service Engine Soon lamp illuminated with extremely rough running engine, would barely keep running. Dealer diagnosed misfires on cylinders 1, 3, 7, with cylinder 5 showing the most misfires. Tear down revealed defective lifter on cylinder 5. Repair under warranty included replacing all bank 1 lifters. Mileage of vehicle was 19566 at time of repair

Driving the truck at 45 mph, the engine stalled and the dash had all the lights on showing codes. Had it towed home and called the dealership the next business day. I was told it was the drive belt pulley that had gone bad causing loss of engine power. I had that replaced and the dealership then told me that the lifters were bad. I had to get that replaced because I needed my truck. The dealership had had it for almost three weeks at that point. $1300 to replace a lifter.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving 70 MPH with the cruise control feature activated, the oil pressure message was displayed, and the vehicle stalled. The vehicle was coasted to the side of the road. The vehicle was not able to be restarted. The vehicle was towed to the residence and then to a dealer to be diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 78,000.

The repair estimate includes a complete teardown and replacement of the camshaft, 16 lifters, seals, bolts, gaskets, and associated components. The full cost breakdown is: Labor & Parts Subtotal: $11,402.78 Shop Fees & Tax: $467.13 Total Estimate: $11,869.91 Yes, the vehicle is available for inspection. it has been inspected by a chevrolet dealership and they gave us the above estimate to repair it. The vehicle powered down while driving on the freeway. It has not been inspected by police or insurance representatives, only by the chevrolet dealership service department. No, there were no warning signs prior to it powering down on the freeway. When it stopped producing power needed, the engine light came on as well as emergency brake light. This issue started on the freeway on Tuesday, April 29, 2025. The vehicle is only 4 years with only 130,000 miles and one that has been properly maintained. We believe this failure is not due to neglect or wear, but rather a known manufacturing defect.

The contact owns a 2021 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

I purchased this truck 3/20/2025. I have since realized it wasn't me doing something wrong. The truck hesitates and shakes during shifting upon acceleration from a stop and when putting it in park and attempting to turn the truck off it has a message on the display saying "shift to park" and it will not turn off until you repeatedly restart it and play woth the gear shift to get it to register that it's in park. I have made an appointment to take it to the dealership to be looked at. The truck has 75,000 miles on it.