2020 Chevrolet Silverado 1500 complaints

On September 27, 2025 while driving to my nieces soccer game my 2020 Silverado Traill Boss LT started losing power while driving. I was at a Red light when I felt the truck not properly responding to me pushing the gas pedal once it turned green. It slowly started accelerating and then with all the lights still illuminated on the dash, the truck completely stopped working with No response to the gas pedal. I had to let the truck coast forward while driving through an intersection. Thank God there was not that much traffic behind me and any cross traffic. I managed to pull the truck over stuck on the side of the road. My wife had to get a ride from a family member to reach the destination while I had to call a tow truck and have it towed home. Ironically, I believe the truck had just got out of Warranty, what a complete waste of thousands of dollars including the warranty that is always useless. I did not reach out to the dealership because I knew it was going to cost me an arm and a leg just for a diagnostic only for them not to find a problem. There was No Warning Light Flashing to notify me that my truck was taking a dump or any error code of any sort for a diagnostic to pinpoint the issue. I am surprised this has not turned into a Class Action Lawsuit (not yet anyways). My Father made me a Chevrolet person but with all the recent Engine/Powertrain problems with General Motors. I always believed the slogan "The longest lasting dependable trucks on the road". Tanks to YouTub

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that immediately after leaving the dealer after the vehicle was purchased, the check engine warning light illuminated. Several days later, there was a loud knocking sound coming from the engine before the engine failed. The contact referenced NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The vehicle was taken to a dealer and an independent mechanic, but was not repaired. The vehicle had experienced catastrophic engine failure. The check engine warning light was displayed, and audible knocking was coming from the engine. The manufacturer was notified of the failure. The failure mileage was 153,000.

The vehicle experienced a transmission control malfunction related to a transmission solenoid (diagnostic code P0776). The transmission exhibited abnormal shifting behavior and drivability issues, prompting a warning indicator and dealer inspection. The condition affects the powertrain and could impair safe operation of the vehicle, particularly if shifting becomes unpredictable or the transmission enters a reduced-function mode while driving. The issue was confirmed by an authorized Chevrolet dealership, and the vehicle was subsequently deemed inoperable pending replacement of the required transmission solenoid component. The vehicle was inspected by General Motors on November 3, 2025, at which time GM confirmed that the required part was on national backorder with no immediate availability. The vehicle remains unavailable for use due solely to the lack of this GM-supplied component. A warning indicator and drivability symptoms were present prior to removal from service. The component is currently retained by the servicing dealer and is available for inspection upon request. General Motors has advised that this component is subject to a widespread national backorder affecting numerous vehicles, resulting in extended periods where affected vehicles cannot be repaired or safely returned to service.

To Whom It May Concern, I am writing to formally file a complaint regarding my 2020 Chevrolet Silverado 1500 Diesel and to request immediate review and assistance from General Motors. I purchased this vehicle from a GM dealership in 2024 with approximately 70,000 miles for roughly $42,000. The vehicle currently has approximately 121,000 miles. Since purchasing the vehicle, it has suffered major breakdowns approximately every three months, requiring repeated costly repairs and making the vehicle unreliable for regular use. Most notably, the vehicle experienced a full transmission failure at approximately 103,000 miles — just after the factory warranty expired, requiring complete transmission replacement at my expense. To date, I have spent nearly $20,000 in repairs, including but not limited to: •Full transmission replacement •Two alternator replacements •Glow plug system failure •Coolant control valve failure •Engine control / computer module failure •Transmission cooling system failures •Ongoing electrical system issues •Additional drivetrain and mechanical problems These are critical powertrain, electrical, and engine management components — not routine maintenance items. The repeated failure of such systems strongly suggests underlying manufacturing or design defects. The vehicle has been properly maintained and serviced, yet continues to experience serious and recurring defects well beyond what would be considered normal wear and tear for a modern diesel truck. At this po

Transmission/ torque converter. Truck feels like you are riding over rumble strips and shaking steering wheel. Confirmed by dealer. No warning signs

At highway interstate travel speeds, vehicle was losing intermittent power. Exhaust at stopped, idle during trip smelled heavily of gasoline. White smoke blowing from exhaust with only 38k miles on the truck. Dealership is replacing the entire engine now and sounds like GM doesn’t want them to fully explore the cause of failure.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 75 MPH, the vehicle lost motive power with a tapping sound coming from the front passenger’s side of the vehicle. The message "Monitor Brake Service System" was displayed. The vehicle was pulled over to the side of the road and inspected, but no failure was found. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the lifters and camshaft needed to be replaced. The vehicle was not repaired. The vehicle was taken to a different independent mechanic, where it was diagnosed and determined that the lifters and camshaft needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.

INTERMITTENTED,NOT ALL THE TIME BUT I GET A HESITATION WHEN I PUT THE TRAN IN DRIVE PRESS THE ACCERATOR THEN IT LURCH FORWARD UNEXPECTED......

The contact owns a 2020 Chevrolet Silverado 1500. While driving at an undisclosed speed, the brakes failed to engage while the brake pedal was depressed. The message "Service Brake Assist" was displayed on the instrument panel. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The vehicle was taken to a dealer where it was diagnosed and determined that the brake master cylinder was leaking and needed to be replaced. The vehicle was repaired; however, the message "Service Brake Assist" was displayed on the instrument panel again. The manufacturer was notified of the failure. The failure mileage was approximately 101,593.

Vehicle was brought to Payne Chevrolet(Weslaco,Tx)for Recall N242454440. After the software update, the vehicle entered 'Limp Mode' and threw a Permanent Fault Code P2817 (Solenoid 8 Stuck Off). The dealership and GM Executive Resolution (Case #86918646) have confirmed this is a mechanical failure of the valve body, but are refusing/delaying the remedy due to a branded title. The vehicle is currently grounded and unsafe to drive as it risks rear-wheel lockup. GM has failed to provide a timely remedy or alternative safe transportation.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving approximately 40 MPH, the contact stopped for a traffic signal, and the accelerator pedal was depressed when the light changed; however, the vehicle failed to respond. The contact stated that the engine was still running; however, the vehicle failed to respond while the accelerator pedal was depressed or the gear shift lever was moved. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a local dealer, where it was diagnosed, and determined that the Transmission Control Module needed to be re-flashed. The vehicle was repaired; however, the failure reoccurred. The contact had taken the vehicle back to the same dealer two more times for the same failure, however the vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.

The Timing Chain failed. It is at the Dealership available for inspection. Vehicle was unable to accelerate correctly while driving. If it had blown a valve or locked up the engine we would have been stuck on the highway with my kids in the vehicle. Problem has been confirmed with the dealer. It is a known defect with this vehicle but my VIN was not one that was recalled. No issues had came up before it failed. Just went to accelerate and you could feel it slipping and the truck stuttering forward.

I pulled up to a traffic light at a busy intersection in Lubbock, TX, and the engine just shut down on approach to a red light. The vehicle still had power (radio, headlights, AC/heater, etc.) but the engine would not start or even turn over and try to start. The vehicle was towed to a Chevy dealership in Lubbock, TX, and they said they believed it was an internal engine failure but wouldn’t be able to look at it for several weeks. I had it transported to my hometown in Taylor, TX, and my certified mechanic replaced the starter and battery solenoid but the engine still wouldn’t start. They drained the oil and found metal shavings in the oil. They too believe that the engine suffered a catastrophic failure and needs to be replaced.

While driving home from work the truck displayed numerous trouble codes including ebc failure, braking failure, traction control failure and trailer brake failure as well as vehicle governed to 42 mph. I took it to the dealership and they checked all of the braking system and could not find any issues. They reset the codes, and changed all 4 pads and rotors as all 4 wheels were 1/32 out of true as a precaution. I drove it home about 5 miles with no issues. The next morning I was on my way to work and the codes reappeared with me being governed to 62 mph. At the stop sign I had no braking at all. Pumping the brakes resulted in no braking or pressure in the pedal. Luckily there was no traffic and I was able to use a hill to stop. I turned around and went the mile back to my house and was unable to stop again ending up with the front end in my neighbors yard. I had the vehicle towed back to the dealership where they still have not found a cause or a solution to the issue

The contact owns a 2020 Chevrolet Silverado. The contact stated that while the vehicle was parked, turned off, and unoccupied, the rear of the vehicle caught fire. The fire was initially extinguished by a maintenance worker, and the fire department later applied water to the area to prevent the fire from reigniting. The fire department was unable to determine the cause of the fire, and a fire report was not provided. The contact was unaware whether a police report was filed. The vehicle was not destroyed or towed. The vehicle was taken to a dealer, where it was diagnosed that the rear wiring harness had failed and needed to be replaced. The dealer also informed the contact that the rear bumper and tailgate were damaged as a result of the failure and would need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was not available.

Rear wheel lockup due to transmission valve body issues.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle unexpectedly sputtered. There were no warning lights illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 73,000.

The component that failed was the wiring harness installed in the engine area. the harness was installed right next to a dip stick. The dip stick has a sharp metal piece welded to it and it punctured the harness cutting wires on the inside. This could have been a potential fire hazard. The problem was able to be reproduced, inspected and confirmed by a certified chevy mechanic at Philips Chevy in Frankfort, IL. The mechanic also showed me the failure point on the vehicle upon a visit. The dashboard lights were flashing randomly, headlights were very dim which it very difficult to see, android auto stopped working and not able to use hands free, so that became a safety issue, cruise control stopped working, and was receiving errors for a failed fuel pump.

The contact owns a 2020 Chevrolet Silverado 1500. While operating in negative (-41°F) degree winter conditions, the "Service Emission System" entered an EPA-mandated speed limitation in LIMP Mode messages were displayed. Dealer diagnostics confirmed DTC: P20B9 (Heater Control Circuit Open) and P20C1. The failure was identified as the melting of the Diesel Exhaust Fluid (DEF) tank electrical connector due to undersized terminal pins overheating (Joule heating). The contact stated that it was a latent design defect that posed a fire risk and a safety hazard due to sudden loss of motive power in arctic climates (-45°F). General Motors acknowledged the defect in 2500HD models, Special Coverage: N212342980; but excluded the 1500 models. The failure mileage was 29,354.

What happened: In mid-December 2025, my 2020 Silverado 1500 (VIN: [XXX] ) suffered a catastrophic failure of the DEF Tank Assembly (P/N 84914535) at 29,354 miles—less than 30% of its warranted life. This is a latent design defect involving undersized terminal pins that suffer thermal degradation and melt the connector during high-amperage heater operation in arctic conditions (Ref: GM TSB 21-NA-006). Component Availability: The failed assembly is held at the dealership. I have submitted a "Part Preservation Request" to ensure it is available for forensic inspection by federal regulators. Safety Risk: The failure triggers an EPA-mandated "Limp Mode," initiating a software-forced reduction in speed. Unexpectedly losing speed on high-speed, icy Alaskan highways—where roadside snowbanks prevent safe egress—creates an extreme risk of rear-end collisions. Furthermore, a vehicle restricted to 5 MPH or rendered inoperable in temperatures of -30°F to -50°F poses a direct, life-threatening risk of cold-weather exposure in remote areas. Confirmation: Failure was confirmed by Lithia Chevrolet GMC of Fairbanks on Jan 7, 2026. GDS2 diagnostic verified DTCs P20B9, P20C1, P205D, and P204C. Data was reviewed by the GM District Manager of Aftersales (DMA) and GM Customer Assistance (Case #[XXX]). Warning Symptoms: Check Engine lamp and "Service Emission System" message appeared in mid-Dec 2025, followed by a "Speed Limited" countdown. The electrical disconnect was abrupt due to terminal pin me

Transmission bucks and truck just stops for no reason.

I own a 2020 Chevy Silverado 1500, the truck currently has 51,400 miles on it. I started noticing a vibration while driving home from work that continued to get worse. After some quick online research I learned that the torque converter on the newer Chevy and GMC trucks is a weak point in their assembly. This is a very common issue and complaint for owners. The manufacturer has done nothing to resolve it or honor repairs on the defective product. My truck was one month out of the 5 year/60,000 mile warranty, they would not honor repairs because it was outside of the time window. The internal parts break up and destroy a transmission. Luckily i caught it early enough before it caused my transmission to fail while driving. I do not have the part with me. I took the truck to a shop for repairs and they did not return the defective part. No warning lights came on the dash.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while his son was driving 75 MPH, there was a knocking sound coming from the vehicle. The driver pulled over and turned the vehicle off, but the vehicle failed to restart. The check engine warning light was illuminated. Upon researching the failure, the contact associated the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine had seized. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no recall coverage on the VIN for the failure. The failure mileage was approximately 165,000.

6L80 transmission shift flared when shifting from 2nd to 3rd gear and shuddered when driving at 45 - 50 mph and about 1400 rpm’s. The Torque Converter Clutch was spasming out causing the the torque converter to shudder which caused the torque converter to overheat at 250 degrees therefore exploding the torque converter that shot metal inside of the transmission blowing it up.

Bad shuttering, slow acceleration, clunking noise, check engine light flashing all started while driving home. Took it to a transmission shop and they said it was the TC and transmission. I then called the dealership to see if there was a recall, and looked up any recalls. Since I have had fluid flushed and changed, and still have the problems. This has been an on going problem for a couple of years now. It was just out of warranty for dealership to fix. It started while I was on a highway and had very poor acceleration control.

The 6.2L engine failed. The same as the 2021-2024 recalls.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving approximately 65 MPH, the vehicle started to hesitate with several unknown warning lights illuminated. The contact stated that there was a misfire in the engine, and her husband pulled off the roadway and turned off the vehicle. The vehicle was restarted and driven back to the residence at speeds no greater than 50 MPH. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the left engine lifters had collapsed and needed to be replaced. The contact was advised by the dealer that the right-side engine lifters should be replaced while the engine was disassembled. The vehicle was not yet repaired. The manufacturer was informed of the failure. The failure mileage was approximately 96,000.

The truck had a lifter failure which caused the pushrod to bend damaging the camshaft as well. I spent $5000 dollars just for the problem to happen again. I’ve have spent nearly $10000 on this issue. This not something you expect from a truck that you pay nearly $60000 for.

Intermittent and sudden loss of power steering. The only message displayed briefly then went out was “service trailer brake controller”. Brought vehicle to Dealership. The grounding strap behind the front right wheel that goes to the frame (Earth Strap) was rotted. This seams to be a very common problem with this model truck and is dangerous.

Driving on highway truck lose power, engine lights start to flash and cracking noises start to come from engine. The lose of speed almos cause another vehicle to rear end me, Truck gave no signs or warnings before. Truck was delivered to a local shop and due abundant amount of metal flakes in oil engine need to be replaced

GM declared my original engine as unfixable and decided to replace my engine luckily with 2 weeks remaining in warranty. It had similar clicking noise to everything else I've seen related to this 6.2L having issues. It currently has a new engine that can be inspected if need be. As well as receipt given to me from Klein Chevy from engine replacement. My engine could've failed while driving if I didnt notice the clicking noise prior to getting it looked at. Putting other in danger if driving on a public roadway. Yes the noise/defect was reproducible upon dealer looking at it. Unsure if the vehicle was inspected by the actual manufacturer but they removed my motor and sent it back to the factory. Was never inspected by police or insurance that im aware of There was no check engine light or warning lamps, only thing I noticed was a clicking noise that the common layman would have probably missed, they appeared roughly around 46,000 miles.

Engine Failure 6 Nov 2025 Yes, engine is available for inspection. Possible loss power, unable to control the vehicle. Vehicle engine failure has been confirmed by dealership, Ruben Milton Chevrolet and Jim Hudson Cadillac in Augusta Georgia. Vehicle has not been inspection by manufacturer, police, insurance representatives. No warning light, no knocking noise, no messages on dashboard.

Back in 7/2025, I was going to a Dr appt in Chandler, Az. When I arrived in Maricopa, Az, my truck stalled at the first stop light and would not start. I went over Kraegan Auto parts and bought a battery. After about 10 days, I was having to jump start my truck for the next few days. I took the battery back and they realized that it wasn’t the battery my truck called for. So, now I have the correct battery and everything working like it supposed to. In Nov 2025, my battery was starting to drain like overnight, and jump starting my truck every morning. I also told them, that the transmission was acting up. When I got on the highway my truck would be at 5000 rpm while doing 60 mph. I be would have to pull over to side of the highway, shut the engine down, and restart. Usually it would be good after the first time. So, up until now, I have no heater, no AC, my windows don’t go up or down, cruise control don’t work, l can’t move my power seat, so my wife has to put a pillow behind her and a pillow beneath her when she drives our truck. And I be still haven’t mentioned all be the little icons that are lit on the steering column. My truck is at the Jerry Seiner Casa Grande, Az. I have the protection plus coverage on my truck with GA Security, and I was told that because it’s a battery issue and found me at fault, they won’t cover me and I need to pick up my truck, because I can’t afford a $680.00 price tag. I’m on Medicare. That’s why I paid the $3500 for the protection plus covera

While driving at highway speeds, multiple warning lights illuminated on the dashboard at the same time, including engine and powertrain warnings. The vehicle suddenly began operating abnormally, with loss of power and unstable driving behavior, making it unsafe to continue driving. This same issue has occurred multiple times previously and the vehicle has been taken to an authorized Chevrolet dealership for repairs on three separate occasions. Each time, repairs were performed, but the problem returned. The most recent incident occurred while driving on the highway and created a serious safety risk to the driver and other vehicles. The vehicle is not safe to drive.

My 2020 Chevy Silverado needs a torque converter replacement. My truck is at 90k miles and out of drivetrain warranty. However, this is a known GM problem with trucks (and other vehicles in this class of engine/transmissions). I have talked to GM corporate and they are only willing to rebate 20% of the cost of this repair. I believe they should pay for the entire repair since this is a known problem for all these vehicles in this class. Please help me to get GM to understand this and fix this known problem.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while starting the vehicle, there was an abnormal odor coming from the vehicle. Upon inspecting the vehicle, the contact became aware of coolant leaking from the front of the vehicle near the transmission, with the check engine warning light illuminated. The contact retrieved DTC: P0016. The vehicle was taken to the dealer, where it was diagnosed, and determined that the coolant control valve, motor mount, and camshaft timing had failed. The dealer informed the contact that the coolant control valve, motor mount, and wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 88,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was an abnormally loud engine camshaft bearing sound coming from the engine. The engine warning light was illuminated. The vehicle was taken to the local dealer, and after three days, it was determined that the camshaft bearing had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact linked the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) and NHTSA Action Number: EA25007 (Engine and Engine and Engine Cooling). The manufacturer was contacted and opened a case. The failure mileage was approximately 45,000.

On Sunday Nov. 16th, my steering wheel felt like it was "slipping", akin to how it feels when your serpentine belt tensioner is failing. I checked it out while wife turned the wheel, didn't see any problem, and we went on our way. Later in the day as we were leaving a parking lot, the problem occurred again but worse. And we got a warning about trailer brake controller needs repair. After reviewing similar problems on Reddit, I found it was still safe to drive, so we drove home without further incident. Monday I decided to take it to O'Reilly auto parts and have a code scan done. Except, as soon as I turned out of the driveway, my wheel completely froze up solid. I could NOT move the wheel (q2)! Since the wheel was still turned, I backed it into the driveway and we took our car to buy our own code scanner. It showed more than just one fault code for the brakes, there were 5. I called Fox Chevrolet to schedule al appointment for the next day. Fortunately, the failure occurred as the Advisor attempted to turn the wheel (q3). Long story short: problem was a rusted/rotted out ground wire (q1)! Behind the front driver side tire, encased in a boot. Tech told the Advisor he'd never seen that one before. $40 part, and $400 to install it (q4). I was happy it wasn't a power steering rack failure (electric) but the more I thought about it, felt I needed to report this. You needed a dealer scanner to catch this and trace it to a ground fault. Probably better for you to contact dealer Adv

Sudden intermittent loss of power steering, issue confirmed by Chevy Dealership. No warning lights were displayed.

Transmission, would lock up for no apparent reason . At random speeds, they continue as if nothing was wrong. Took to dealership, couldn't get to it for a week. End up at a transmission shop said it through some code. required rebuilding the transmission . 88,000 miles on truck. From time of first incident to first shop visit one week. Same transmission in similar trucks is under recall but this vin# is not.

THIS IS A RECALL REMEDY FAILURE REPORT UNDER 49 U.S.C. §30120. My 2020 Chevrolet Silverado 1500 (VIN: [XXX] ) received Recall 24V797000 on June 9, 2025. The ECM update is intended to detect incipient clutch-pressure or gear-ratio deviations—early signs of a developing slip—and automatically force limp mode to prevent rear-wheel lockup. On August 23, 2025, after the recall was performed, the truck experienced rear-wheel lockup at highway speed. Limp mode did not activate, which shows the recall remedy failed to operate as required. Mangino Chevrolet documented symptoms matching the recall defect, including abnormal ratio behavior. No metal debris was found in the pan, indicating the failure was not caused by wear. GM TAC also noted behavior consistent with a developing slip. GM first recommended full transmission replacement at my expense before acknowledging the recall. GM later authorized a valve-body replacement, which also failed. The dealership owner provided a written statement confirming that: (1) the recall remedy did not correct the defect, and (2) the valve-body repair did not correct it. On December 3, 2025, GM Customer Assistance attempted to close my case as “not recall-related,” despite the post-remedy lockup, limp-mode failure, dealer findings, and the written admission that the recall remedy was ineffective. The safety defect persists after recall completion, and GM has not provided a remedy that corrects it, as required under federal law. I am reporting this a

During driving at low speed 15-30mph with 4 wheel drive set to auto. 4 wheel drive engaged and rear wheels locked up. Turned off 4wd no issue. Upon arrival at the dealer a bad sensor was determined to have caused the rear wheels to not perform as designed. After resolving the issue now I hear rubbing metal noise from the drive shaft. Spoke to Chevy about the issue haven’t heard back.

My truck started acting sluggish like the parking brake was applied while driving. At a traffic light I put the vehicle in park applied and released the parking brake. I put the vehicle back in gear an let off the brake. The vehicle did not move so slightly pressed the accelerator. The vehicle still acted as if the brakes were applied. I could feel the slight movement and torque being applied but only slightly lurching. The traffic light turned green so I proceeded up to 45mph. A vehicle in front of me slowed to make a turn. Applied the brakes and nothing happened. I pressed the brake so hard that I lifted myself off the seat. I swerved to miss the vehicle avoiding a collision. Then warnings started popping up; "brake system failure max speed 62mph", "brake system failure max speed 42mph", Brake system failure", service traction control", "service trailer baking system". among others I was too busy to see all of them. I coasted to a stop in a nearby parking lot with visual and audible warnings still going. I shut the vehicle off then restarted it. Some warnings remained like traction control and the engine light. The vehicle appeared to be operating correctly so I drove it to a local dealer. they said there was a code for low voltage in the brake control module but couldn't get me an appointment for over two weeks. I took the vehicle to a regular mechanic who said what I described was impossible. That mechanic kept my truck for the balance of the day but could find nothing wr

What component or system failed or malfunctioned, and is it available for inspection upon request? Based on information from ODI Resume EA25007 & Safety Recall N252494002, it is more than likely engine connecting rod bearing failure. How was your safety or the safety of others put at risk? I was traveling at freeway speed, 70mph when it occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? 11/25/25 at 12:33 (pacific), I am currently stranded 190 miles from home and waiting for the truck to be towed to the dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has not. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to Failure: Since I’ve owned the vehicle, I’ve notice slight ticking and slight knocking during cold start within the engine bay. At the time the noises seemed normal and not cause-for-concern. At Time of Failure: I was traveling on level grade on the highway when I heard a deep knock from the front, bottom left side of the engine bay. Within about a minute from the initial noise, I received a “check engine” warning light and a message of “ESC Warning” displayed on my instrument cluster. At that moment, I noticed the engine noise become more prevalent and constant. I immediately slowed and coasted to my next exit off the freeway.

Brakes would not release after driving a little ways the brake system failure warning came on. I stopped and killed engine and restarted but it lunged and I lost all braking. I pulled over to side of road and again killed engine a couple minutes I restarted it released. Then drove normal. ????

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the tailgate opened independently without warning. Upon investigation, the contact discovered NHTSA Campaign Number: 24V060000 (LATCHES/LOCKS/LINKAGES) and linked the failure to the recall. The local dealer was notified about the failure, and the contact was informed that the VIN was not covered under the recall, and the contact was provided with an estimate for the repair. The manufacturer was also notified of the failure, but referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 50,000.

While driving it said "service ESC", "brake system failure" and then "trailer brake system failure" "max speed 62." Brakes when pressed would not work. Had to cruise to stop. When truck shut down and restarted it said "max speed 43" and check engine light came on. Truck was then towed to mechanic and waiting to be looked at/worked on.

There was a brake system failure and the brakes stopped working while going 50 mph

Making turn at slow speed. Possibly Transmission slipping and rear tire locking up. engine light turned on

The transmission quite working while I was driving down the road. Took my foot off of the gas pedal and my truck bogged down completely and had no power to it. It is at an auto repair shop so I am unaware if it could be inspected under request. Took time but was able to safely get off the roadway and out of traffic. It did the out of no where. Started having some issues this summer but no warnings lights ever came on, so I didn’t think much about it. Completely stopped in the middle of the road and had little to no power from the transmission to the truck to move off of the road. My truck is currently in an auto repair shop waiting on a new transmission to be installed. I had it towed to an independent auto shop from where it stalled. There were not warning lamps or anything at the time of my transmission quitting. Truck started to run rough and shifting hard this summer but without warning lamps I didn’t take it anywhere. When running on the interstate it was shuttering which I thought was due to possible tire out of balance. It would also hesitate to take off when put into drive. It had several of the same issues that Chevy had on other transmissions that were recalled within this same time frame.