2016 Chevrolet Silverado 1500 complaints

My truck starts shaking when I attempt to speed up or slow down, and it hesitates, shudders, and engages in a hard shift when changing gears. My mechanic could not fix it. Has been happening since Dec. 2018. Why is there no recall on this major issue?

At 143,000 miles my transmission stopped transmitting engine power to the wheels

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated while driving 15 MPH, the steering wheel became firm intermittently making it difficult to maneuver the vehicle. The power steering warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and stated that the VIN was not included in a recall. The failure mileage was approximately 100,000. The VIN provided was invalid.

The truck has had its major service to replace all fluids at 70,000 miles. One of the services was a notable vibration and shaking through the steering wheel and on the brakes. Higher the speed the more the vibration. When brakes are applied the vibration gets worse. The vehicles brakes and rotors were checked and good. The mechanic said that the brake pump was slightly loose and it was tightened. It did slightly ease the vibration, but less that a few days later it is back to the same vibrating. The brake power feels weak and when I need to brake I feel like the vehicle is not stopping. I have owner a 2014 Silverado before this and did not have this issue. I took it back to the dealer and they did an alignment which did not help.

I brought my truck into the dealership for a routine oil change. They notified me that my radiator is leaking and needs to be replaced. They stated that there is a small leak in the lower right corner of the radiator. I did not notice and fluids leaking from the radiator prior or did not smell any coolant from the engine. The leak did not trigger any warning lights inside of the vehicle. I did notice on a few occasions that the coolant levels looked low and added more to the system. My truck only has 60k miles on it. After researching this issue I've learned that this is a fairly common problem for 2014-2018 Silverados and that Chevy will only fix the 2014's.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the contact noticed that the gear shifter was inoperable. The vehicle was taken to an independent mechanic. The vehicle was diagnosed with a failed transmission temperature sensor and transmission control module. The contact was informed that the transmission wiring harness needed to be replaced. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 52,000.

Tire size 285/45R22 114H . While driving on the interstate at 70 mph had a large vibration that started occurring. When I was pulling over to figure out what was going on I heard a loud bang and suddenly lost air pressure to the Drivers side front tire. Once pulled over I could see the tire was flat. Upon removal of the tire I found the inner sidewall had blown. The tread was also separating in the area where the damage was. The tires are only 2.5 years old and have only 22.5k miles. They have been rejuvenate rotated with the last rotation just 3k miles prior. The company refused to honor their warranty stating it looked like the damage was caused by a pothole (which never occurred).

The ignition switch is defective the truck will not turn on all the time I have to play with the shift lever and key to get it started

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the transmission experienced rough shifting from first to second gear. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.

My truck started shuddering and having shifting issues. Took to Chevrolet dealership and was told that this has become a common issue with this type of transmission. We ended up having to replace the transmission.

While driving on the highway on ramp, the transmission came out of gear. The engine would accelerate but the transmission would not stay engaged. at this time the check engine light came on. Upon having it towed to a dealership and having the vehicle inspected. It was determined that "the Torque Converter came apart causing metal in the pan when hot vehicle would stop pulling". The transmission has been replaced at considerable expense. Dealer had stated to me that they have seen multiple vehicles with this same issue from 2015 to 2020 models. While we were at the dealership two vehicles were checked in with similar issues. This torque converter issue poses a risk while accelerating/passing other vehicles.

I [XXX] purchased a vehicle by trade-in from Augusta Mitsubishi on Tuesday 6/20/2023. Upon further review of the contract, I noticed some things that were not right. 1. They had the vehicle I traded as a Chrysler 200 but I gave them a 2001 GMC Sierra. 2. On the retail purchase agreement, the color of the truck I purchased is gray but it is black. 3. It seems as if the numbers were manipulated to suit the deal. I also had the truck diagnosed and they found a number of issues such as the brakes and rotors were worn. The biggest issue was that the lug studs had been cut which is a major safety issue. In light of everything in this letter, I feel that the dealership should be held accountable, which is why I'm asking that they pay off the truck and send me the title, refund my down payment, and pay for the repair cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission (6L80/E) started slipping at around 100,000 miles and needed completely replaced/rebuilt. This is replicated on multiple trucks with this transmission from 2016-2018. Evidence was slipping while shifting between 2-3rd gears. Dealership advised transmission needed completely replaced. Cost associated was ~$4000

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that the radio in the vehicle had started to switch stations independently. The failure persisted, causing other electrical operations to be affected. The contact stated that occasionally, the failure caused the vehicle to stall while coming to a stop. The vehicle was taken to the dealer and the computer controller was replaced. The manufacturer was made aware of the failure. The approximate failure mileage was 92,800.

Transmission bumping or shuddering in 1st-4th gear

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated while driving approximately 25-30 MPH, the power steering became inoperable. The steering wheel was difficult to turn. The power steering fault message was displayed. The vehicle was taken to the local dealer and the contact was informed that the part to repair the vehicle was on backorder. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 104,000.

My 2016 Chevy Silverado had intermittent hard braking. Especially at slower speeds the brake pedal would get very hard to press and needed a lot of effort to stop. I was especially concerned having newer drivers in my household that the truck was unsafe. I nearly hit others vehicles especially at stoplights and in parking lots. The vehicle was taken to the GM dealer who said it was under recall and completed the repairs. However even though the recall repairs were completed the vehicle still continued to have hard braking issues. It was not resolved until I had the brake vacuum booster pump replaced by a 3rd party as GM was unwilling to complete the repair under the recall

Backing up truck to put a boat in the water and no brakes had put push really hard to stop the truck from going in to the lake. When moving slowly there is hardly any brakes on the truck

My vehicle just randomly shuts off, mainly when making a turn. I took it in to the dealership and had several repairs made but none of them fixed the problem. It’s definitely dangerous I almost had a accident at least 3 times. I feel it’s electrical due to the fact everything shuts off, the dash usually flashes before it shuts off. All electronics shut down and the vehicle turns completely off with no control of steering. I’ve come to the conclusion it’s electrical so I’m searching for a solution.

I was driving the other day and slowed to an upcoming vehicle, when I tapped the brakes the stabilitrak light flashed and all my dash lights and radio flickered, then when I used my turn signal the same things happened plus the windshield wipers came on, then when I went to merge back into my lane the pickup completely stalled out jerking us forward into our seat belts and then kept going. Later that day I went thru a drive thru and when I was turning the steering wheel jerked and wasn't able to continue turning and the pickup died. I had to lock the steering wheel in order to get it started again. This isn't the only time the first issues have happened or the steering wheel being jerked and stalling out, but this is the first time it completely stalled out in the highway and that is not okay. That is a complete safety issue and I'm not the only one who has had this issue, however when I have talked to a mechanic about it they couldn't find anything wrong and had no answer for me. There are several recalls on the years before the 2016 chevy silverado but nothing for them, and this is a big safety concern.

Transmission drops out of gear with no warning. No forward or reverse. This is a potential hazard that if it had occurred on an Interstate, whether it be causing an accident or getting hit by other vehicles trying to get to side of road. Vehicle is with a transmission repair shop currently. No repair records yet or actual cause. Mechanic informed me today that transmission needs to replaced due to economics that a rebuilt or re manufactured would be better option. Will save records if when I get all receipts for the repair.

Grounding issue when turning causing the steering wheel to yank the to a random direction and lock up. Multiple Silverado owners have experienced the same issue and I nearly died. Chevy dealer did not identify the issue/ Cannot figure it out.

2021 the driver side seatbelt broke which resulted in a recall. Same thing has happened again; the thick metal coil within the plastic cover snapped. We have a scheduled appointment today with the dealer to have it again replaced. They said it's our responsibility to pay even though the first time we were eventually reimbursed. This is a defective part; no seat belt should break again in two years! Another recall needs to be activated.

Transmission would shudder when driving. Sometimes loud bang when shifting from first to second gear. Torque converter ultimately failed while crossing traffic. Truck would not move. No gears. Only 58,000 miles on transmission. Never used for hauling. Torque converter had broken metal parts that caused the fluid to become blocked so it could not drive. A rebuilt transmission needed to be installed at my cost.

Transmission temperature sensor failure exactly as described in special coverage N192291660 occurred on my vehicle.

3mos ago i had a fender bender in Mesa,AZ(my front end to pasenger side)her car was towed my wasn't for the next 28 days my truck was still driving just fine like nothing ever happened to it,at the end of the month my work was done so i drove bk to Cali and it was till the middle of April when this all started 2 months ago like normal I was getting an oil change from there I went home it was 5:30pm didn't go anywhere else that night ,the next morning I put my key into the ignition and it was completely dead, at first I thought it was the battery so I bought a new one, installed the new battery went on my way to run my errands 3hrs pass came home it was around 12:40pm,around 5:30pm I was planning on going to the grocery store went to start my truck wouldn't start truck battery was dead, nothing was left on no door was open no lights were on, so I towed it to my mechanic so he could put it on the scope to find out the general problem,called and told me that it was an electrical problem and my truck would have to be reprogram starting from the main chip in my transmission, going back in forth from my mechanic to the Chevrolet dealer in Victorville ca, it's still not in working condition yet and still trying to reprogram the last of these codes that keep appearing on the dash(2016 Chevy Silverado 6cyl 4door LT, never had any problems at all from the day I got it from the dealer back in 2019 of Mar, with reg oil changes, tune ups, ran like a brand new truck, very confused, upset,

Torque converter shredded itself into my transmission while driving. When I was driving the truck did not show a light on the dashboard to show there was a problem with the engine and I started it up and started to drive. Once I was on a main road it stopped moving in drive and I had to coast to a stop. Once I stopped I had to put it in park and shut off the engine and restart the engine, still no light and now it would move again. I had it towed to the dealership and they said it was the torque converter that shredded metal into my transmission and that I needed a new one.

Trailer brake system warning has been flashing non stop for 2 weeks. I do not use or tow anything with this vehicle. Usually it locks up the steering wheel while parking my truck and shuts down the engine. Yesterday I was going 55 on the highway and the warning came on and it shut down the truck tried to put the vehicle in park and rapidly applied the breaks then the truck electrical system came back too and the truck was rolling I pull off to the shoulder to shut the truck off and turn it back on. At the time I had both my sons in the vehicle 4 years old and 9 months. Again usually it always happens when parking my truck (under 5mph) it will lock the steering wheel and totally shut down the trucks engine. Huge safety concern.

AFM/DOD leafters collapse

I was driving down the road when the transmission would no longer change gears. There were no warning lamps or anything to indicate that this was going to happen.

I was involved in a head on collision. The other vehicle struck me doing between 35-40mph. My vehicle airbags did not deploy.

Myself, My wife, and my oldest son have all three experienced a loss of complete power in the truck during turns. All power on the dash, steering, and stereo goes out. The last incident required my wife to put the vehicle in park and turn the truck off and back on to get it to start.

Son was driving truck in a straight line when it lost all power. Although we have experienced issues during turns that I have noted before here, this is the first incident while driving in a straight line.

Dash board instrument panel and radio loses all power, May even cause vehicle to shut off not able to steer, If the cruise control is set it shuts it off. It mostly happens when you apply the brake or if I operate my passenger window from driver door controls. The problem has not been confirmed by a dealer or independent service center. Has not been inspected by the manufacturer or any other representatives. No it gives no indication prior to the failure. I have been researching it on google and youtube, I have seen a lot of owners with the same problem but no one seem to have a solution. Thank you

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while her husband was driving at an undisclosed speed, the vehicle made an abnormal sound. Additionally, while shifting gear, the vehicle lunged forward. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact stated that the vehicle failed to accelerate or reverse. An independent mechanic arrived at the residence and informed the contact that the transmission and engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 110,000.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the transmission was slipping and failed to properly accelerate. The contact stated that the vehicle lunged forward while attempting to accelerate. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the transmission had failed and needed to be replaced. The vehicle was later taken to the local dealer who confirmed that transmission needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 90,000.

Vehicle takes 6 seconds before it does a hard shift into reverse. It also has hard jerks when switching gears. In April it was taken to Don Hall in which I was told that is how this model does and nothing could be done even though it was under a paid for extended warranty. The radio display also glitches out and is extremely faulty

Backing up slowly with/without a trailer and have to pump the brakes to stop or stand on the brakes or pumping the brakes and having to use the emergency brake to stop, rev up the engine, put in reverse and have to do the previous steps all over again. This only happens going slowly in reverse. I was told by a mechanic it could be the vacuum pump or TSB on the vacuum pump. No warning messages display. This is a safety risk to myself and others and could cause an accident.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated while driving 40 MPH and depressing the brake pedal while making a right turn, the steering wheel independently turned to the left. The contact stated the stabili-trak warning light was illuminated intermittently. The contact took the vehicle to the local dealer but was unable to duplicate the failure. The contact continued to experience the failure. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 19V761000 (Service Brakes, Hydraulic, Electronic Stability Control) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 12,000.

Driving down our road and the truck instantly lost power steering. Got home turned off the truck. Turned it backon and it worked. Each time I turn the vehicle off and turn it on the power steering works for a very brief time and then stops.

Transmission started going out at less than 50,000 miles.

Transmission died. Tried to merge highway traffic and wouldn’t accelerate. Push down gas pedal and mph didn’t change but rpm went to 6rpm. Finally engaged. Continued to shudder and hesitate but eventually smoothed out. Had to stop at a traffic light and it did the same thing. Next time I had to stop I completely lost forward motion. Pushed gas pedal and rpm at 6rpm and wouldn’t move. Transmission light came on and had to have it towed. Transmission is being replaced.

My truck has a shudder/ shake while accelerating as well as rough shifts here and there. If certain speeds are maintained, the shudder is constant. This causes uneven speeds, noises, and distractions. I fear one day the transmission will fully give out while driving and I will crash. My vehicle is available for inspection. The problem is easily reproduced as it happens every time I drive. As well, the truck was recently at an independent service center and the problem was confirmed by an associate. The vehicle has not been inspected by the manufacturer as they told me it would cost me $180 just for a diagnostic which they will need my car for two days. There are no current dash lights on. This is a known issue and Chevrolet should be held accountable.

I just bought the vehicle in the summer of 2022 and the truck started to shudder so I took it to see if the tired were out of balance and they told me it sounded like a transmission issue. I took it to Lynchburg Transmission and they said after they ran their diagnostics test the transmission is shot and I need a new one. The vehicle only has 103,000 miles and should not need a new transmission on it. I have read online there are tons of 2016 chevy 1500s that have had transmission issues around the same mileage. This should be an issue that Chevy should be addressing and recall.

Rear window shattered after a few minutes of defroster use. Seems to be a problem on these years of Silverado but no recall on mine. No warning, window just popped on its own, safety issue to have window failure during driving.

The family was driving down a busy highway and we felt a strong rapid jerk and heard a loud pop sound. The 2016 Chevy Silverado felt very forced and would not go past 20 miles per hour and the RPM's were between 2 and 3. This problem placed our family at risk because the speed was reduced significantly and could have been hit from behind or could no safely exit the highway. An independent mechanic has checked the truck and confirmed the transmission needs to be replaced as he reproduced the issue on a test drive. No warning signs came on prior to the issue but only after we exited the highway did the "check engine" light came on when we parked. *** Please note we had already replaced the original transmission in Nov. 2021, the exact same issue occurred at that time and it was replaced by a Chevy dealership in Pleasanton, Tx due to the pan was full of metal shavings***

The transmission failed at 96,000 miles even though maintenance had been completed. This could have been a catastrophic failure on the highway my family or others at risk. The dealer has the truck now and confirmed a failed transmission. No warning signs other than odd behavior when accelerating which led to odd noises from the transmission.

While in reverse and turning stabilitrack light appears and jerks steering wheel from hand. Then a total loss of power and gait to start. No dash panel or power to vehicle.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle started driving rough. The vehicle was later towed to the local dealer who diagnosed that the engine lifters had failed, and an engine cylinder rod had been damaged. The engine rod and lifters were replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 53,000.

THE TRUCK HAS BEEN HAVING PROBLEMS SINCE A MONTH AFTER WE GOT IT TOOK IT TO THE DEALERS THEY ALWAYS SAID NOTHING WRONG WITH TIME IT HAS GOTTEN WORSE IT FEELS LIKE SOMEONE IS PUSHING IT AND THEN STOPS FOR A BIT AND IT MAKES A LOUD SOUND FEELS LIKE TRAMSMITTION