2005 Chevrolet Silverado 1500 complaints

MY 2005 SILVERADO Z71 HAS A LOUD GRINDING NOISE COMING FROM THE FRONT DIFFERENTIAL WHEN IT IS IN 4 WHEEL DRIVE. THIS CAR HAS BEEN SERVICED REGULARLY,HOWEVER I HAVE ONLY HAD THIS VEHICLE IN 4WHEEL DRIVE 5 TIMES SINCE I HAVE OWNED IT(NEW). THE POTENTIAL REPAIR IS IN EXCESS OF $1000.00, BECAUSE I HAVE BEEN TOLD THAT IT IS IN THE FRONT TRANSFER CASE BECAUSE THE NOISE IS NOT THERE IN 2 WHEEL DRIVE. CAN YOU PLEASE HELP ME. HAS THIS HAPPENED TO MANY SILVERADO OWNERS. *TR

DRIVING HOME ON THE HIGHWAY THE LEFT REAR WHEEL BECAME DETACHED FROM THE AXLE AND HUB ASSEMBLY. THE TIRE AND WHEEL ASSEMBLY ROLLED AWAY FROM THE VEHICLE TO THE OTHER SIDE OF THE HIGHWAY, CAUSING THE VEHICLE TO LOSE TRACTION AND CRASH INTO THE MEDIAN OF THE HIGHWAY AND SKID TO A HALT. COMPLETELY TORE APART THE DRIVER SIDE REAR SUSPENSION AND BRAKE ASSEMBLY AS WELL AS CONSIDERABLE BODY DAMAGE TO THE REAR QUARTER PANEL, REAR BUMPER, AND TOW HITCH. VEHICLE HAS ONLY LIGHT DUTY USE, MOSTLY COMMUTER MILES, WITH GOOD TIRES, EXCELLENT MAINTENANCE RECORDS, AND LESS THAN 39,000 , JUST OUT OF WARRANTY. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING THE SPEEDOMETER BEGAN TO MALFUNCTION. THE VEHICLE REGISTERED A SPEED OF 120 MPH WHILE DRIVING 35 MPH; HOWEVER, IN A SCHOOL ZONE IT REGISTERED 80 MPH. THE SPEEDOMETER RECENTLY READ 0 MPH AND WOULD NOT INCREASE BEYOND THAT SPEED. THE DEALER STATED THAT THERE WAS NO RECALL OR WARRANTY AVAILABLE. THE DEALER ALSO STATED THAT THE REPAIR COST WOULD BE OVER $500 NOT INCLUDING THE LABOR COSTS. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 64,964 AND THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.UPDATED 03/10/09.*LJ THE CONSUMER STATED THE SPEEDOMETER WAS STUCK AT 20 MPH. UPDATED 03/10/09.*JB

2005 SILVERADO INSTRUMENT PANEL FAILS. THE FIRST REPLACEMENT WAS AT 23K MILES (MAR 07). THE ENGINE HOURS KEPT RESETTING. NOW MY VEHICLE HAS 43K MILES AND ALL GAUGES ARE FAULTY. THE GAS GAUGE GOES FROM FULL TO EMPTY AND BACK REGARDLESS OF THE AMOUNT OF GAS IN THE TANK. THE ENGINE HOUR KEEPS RESETTING BACK TO ZERO AND THE TEMP GAUGE MOVES FROM HOT TO COLD AND BACK. THE SAME THING IS HAPPENING ON OUR OFFICE VEHICLE. ACCORDING TO GM SPECIAL BULLETINS THIS IS COVERED FOR 03 AND 04 MODELS USING THE SAME IPC. WHY ISN'T THIS COVERED FOR 05 MODELS AS WELL? IF THERE IS AN ELECTRICAL PROBLEM SHORTING OUT THE IPC IT NEEDS TO BE FIXED BY GM AND NOT THE CONSUMER. THIS IS ONLY ONE OF MANY PROBLEMS I'VE HAD WITH THIS 2005 MODEL. *TR

ONE MORNING IT JUST DIDN'T WORK. NOW IT WORKS SOMETIMES. IT DOESN'T WORK WHEN THE TRUCK STARTS UP, THEN STARTS WORKING AFTER I STOP ABOUT 40 MILES DOWN THE ROAD. SOMETIMES WORKS, SOMETIMES IT SAYS IM DOING 120 MPH OR 0 MPH. IT HAS A MIND OF ITS OWN. I HAVE TO USE MY GPS SO I KNOW HOW FAST IM GOING. I THINK CHEVROLET SHOULD STEP UP AND CORRECT THIS PROBLEM. I TOOK IT TO THE DEALER AND THEY SAID THERE IS NO RECALL SO I HAVE TO PAY TO FIX THIS PROBLEM. *TR

WHEN TAKING OFF FROM BEING STOPPED AT A RED LIGHT I NOTICED MY TACHOMETER & SPEEDOMETER BOTH BOUNCING ERRATICALLY. TACHOMETER STILL STAYS IN BETWEEN 4 AND 5 THOUSAND EXCEPT WHEN ENGINE IS OFF. SPEEDOMETER IS ANY WHERE FROM 30 ABOVE TO 30 BELOW ACTUAL SPEED. I HAVE BEEN STOPPED TWICE FOR SPEEDING WHILE TRYING TO MAINTAIN A CONSTANT SPEED WITH THE FLOW OF TRAFFIC SINCE GAUGES DO NOT WORK PROPERLY. ONE OF THE OFFICERS WHO STOPPED ME DID NOT WRITE A TICKET BECAUSE HE OWNS A SILVERADO AS WELL AND HIS SPEEDOMETER HAD BEEN OUT FOR OVER 2 MONTHS ALSO. VEHICLE HAS LESS THAN 80,000 MILES ON IT. *TR

WHILE DRIVING DOWN THE INTERSTATE, MY TRUCK WOULD NOT GO INTO OVERDRIVE. A LITTLE FARTHER DOWN THE ROAD, WHILE SHIFTING INTO 3RD GEAR THE TRUCK WOULD SLIP INTO GEAR. EVENTUALLY 3RD, 4TH AND OD WENT OUT, THE ONLY GEARS THAT WORKED ARE 1ST AND 2ND. THE DEALER SAID IT WOULD COST OVER $2500 TO REBUILD BECAUSE OF THE DAMAGE OR REPLACEMENT WOULD COST $2800. THE TRUCK ONLY HAD 85000 MILES ON IT. *TR

SPEEDOMETER FAILURE. WAS DRIVING 2005 CHEVROLET SILVERADO AND SPEEDOMETER STARTING GOING HIGHER UNTIL IT WAS SHOWING 120 - AT STOP SIGNS - SHOWING 60MPH - NOT WORKING CORRECT. VEHICLE HAS 65,000 MILES ON IT. *TR

SPEEDOMETER NOT WORKING PROPERLY. HAVE 65,000 MILES AND IT IS REGISTERING 120 MPH AND AT STOP SIGNS 60 MPH. DEALER SAID NOTICE WAS ONLY GOOD FOR 2003-2004 MODELS - DEALER SAID THE 2005 MODELS WERE FIXED--THAT IS NOT SO AND I'M PROOF. VERY DISAPPOINTED THAT CHEVROLET DOES NOT ACCEPT RESPONSIBLITY FOR THEIR MALFUNCTION. THIS COULD CREATE A SERIOUS CRASH AS WELL AS TICKETS. *TR

AT 57,055 MY 2005 CHEVY SILVERADO SPEEDOMETER QUIT WORKING AND SINCE I HAD RECEIVED A LETTER ABOUT A CLASS ACTION SUIT I REFERRED TO THIS LETTER HOWEVER IT ONLY COVERED THE 2003 AND 2004 MODELS. I FEEL THAT THE SPEEDOMETER IS AN ESSENTIAL PART IN THE SAFETY OF A VEHICLE AND THEREFORE AM PAYING MY $200 DEDUCTIBLE TO HAVE THE SPEEDOMETER FIXED UNDER MY EXTENDED WARRANTY PLAN, BUT I ALSO FEEL THAT GM IS AWARE OF THAT THIS PROBLEM EXTENDS BEYOND THE 2004 MODELS AND IS FAILING IN THEIR CUSTOMER SERVICE BY NOT EXTENDING THE WARRANTY TO COVER ALL AFFECTED VEHICLES. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT NOTICED THAT THE SPEEDOMETER DISPLAYED 120 MPH. SINCE THIS FIRST INCIDENT, THE SPEEDOMETER REGISTERS THE VEHICLE'S SPEED AT 100 MPH, EVEN WHILE AT A COMPLETE STOP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER AGREED AND STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED AND THERE HAS BEEN NO DEFINITIVE DIAGNOSIS. THE CURRENT MILEAGE WAS 69,032 AND FAILURE MILEAGE WAS 68,500.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CAME TO A COMPLETE STOP. HOWEVER, THE SPEEDOMETER DISPLAYED 120 MPH AND REMAINED AT THIS SPEED ALL THE WAY TO HER RESIDENCE. WHEN THE CONTACT ARRIVED AT HOME, SHE TURNED OFF THE VEHICLE AND THE SPEEDOMETER GRADUALLY BEGAN DECREASING TO 0 MPH. THE DEALER STATED THAT THERE WERE NO RECALLS PERTAINING TO THIS FAILURE. THE VEHICLE WAS NOT INSPECTED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 45,500 AND FAILURE MILEAGE WAS 45,450. UPDATED 12/30/08 *CN UPDATED 12/30/08. *JB

I PRESENTLY OWN A 2005 CHEVY SILVERADO CREW CAB, PRESENT MILEAGE IS 55,000. AS I WAS DRIVING, I NOTICED MY SPEEDOMETER NEEDLE SHOT UP TO 100 AND THEN PROCEEDED TO MOVE PAST 120 MPH LINE. IT IS CURRENTLY STUCK PAST THE 120MPH LIMIT. THIS IS A SAFETY ISSUE THAT'S NEEDS TO BE CORRECTED. THERE ARE OTHER CONSUMERS WITH THE SIMILAR PROBLEM AND YET THERE IS NO FACTORY RECALL ON THIS. *TR

I AM FILING THIS COMPLAINT FOR MY FATHER. HE HAVE A 2005 CHEVY SILVERADO. MY FATHER WAS DRIVING STRAIGHT DOWN A STREET AT ABOUT 35 MPH WHEN THE DRIVERS SIDE REAR AXLE AND TIRE CAME OFF THE VEHICLE. THE RESULT WAS BODY DAMAGE TO THE VEHICLE. LUCKILY NO BODILY INJURY OR PROPER DAMAGE OCCURRED OTHER THAN THAT DONE ON MY FATHER VEHICLE. AS IT TURNS OUT THE RETAINER BUTTON ON THE END OF THE AXLE SHAFT WAS BROKEN OFF ALLOWING THE AXLE TO COME OUT OF THE AXLE HOUSING. A POLICE REPORT WAS FILED AND AN INSURANCE CLAIM WAS MADE. THE VEHICLE HAS APPRX. 90,000 MILES AND WAS PURCHASED FROM A DEALER 1450 MILES PRIOR TO THE ACCIDENT. (APPROXIMATELY 2 MONTHS AFTER THE PURCHASE) THE VEHICLE IS CURRENTLY BEING REPAIRED BY THE DEALER DESANTIS CHEVY IN BROCKTON MA. THEY WILL NOT COVER THE COST OF THE DAMAGE. I AM THINKING THAT A COMPLAINT HAS BEEN FILED LIKE THIS BEFORE. REFERENCE. HTTP://WWW.ABOUTAUTOMOBILE.COM/TSB/2005/CHEVROLET/SILVERADO LINE NUMBER 151 151 TSB NO.:3364 NHTSA NO.:10014953 TSB DATE:N/A DATE ADDED TO FILE:MAY 12, 2005 FAILING COMPONENT: POWER TRAIN:AXLE ASSEMBLY SUMMARY: REAR AXLE RETAINER BUTTON BREAKAGE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING 75 MPH ON A CROSS COUNTRY TRIP, THE ABS INDICATOR ILLUMINATED. THE DEALER STATED THAT THE INBOARD RETENTION NUT THAT WAS USED TO MAINTAIN THE HUB BEARING ASSEMBLY LOOSENED, WHICH RESULTED IN THE ABS INDICATOR ILLUMINATING, NOISE, AND/OR WHEEL SEPARATION. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07E106000 (WHEELS:CAP/COVER/HUB). THE MANUFACTURER AND DEALER STATED THAT THE REPAIR WOULD COST $711. THE CONTACT WILL PAY FOR THE REPAIR, BUT FEELS THAT HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL SINCE THE FAILURES ARE IDENTICAL. THE FAILURE MILEAGE WAS 61,764. UPDATED 12/11/08. *LJ UPDATED 12/11/08. *JB

STEERING RATTLE BOTH FELT AND HEARD. RETURNED TO DEALER 5/18/2006 MILEAGE 18,310. INTERMEDIATE STEERING SHAFT LUBE. PROBLEM RETURNED MONTHS LATER. WROTE TO GM, THEY SAID A NEW SHAFT WAS AVAILABLE BUT I WOULD HAVE TO PAY TO HAVE IT INSTALLED. I ASKED IF THERE WAS CHANCE OF STEERING FAILURE OR EXTREME TIRE WEAR, THEY SAID NO STUDIES HAVE BEEN DONE AND WOULD NOT PREDICT IF A STEERING FAILURE WOULD/WOULD NOT OCCUR. *TR

MY SPEEDOMETER SOME TIMES READS 60 WHEN IM ONLY GOING 40 OR IT READS 120 AT IDLE AND SOME TIMES IT DOESNT READ AT ALL. IT HAPPENS AS MUCH AS TREE TO SIX DAYS OF WEEK. *TR

CLUNKING SOUND IN STEERING SINCE ABOUT 20K MILES. *TR

2005 CHEVY SILVERADO 1500 EXPERIENCING ERRATIC FUEL GAUGE READINGS. VEHICLE HAS APPROX. 25K MILES AND HAS BEEN ACTING ERRATICALLY FOR ABOUT 2 WEEKS. FUEL GAUGE, FUEL LIGHT, AND TEXT DISPLAY SEEM TO BE IN SYNC, SO IT MAY BE THAT THE PROBLEM IS ORIGINATING FROM THE TANK OR THE COMPUTER. EITHER WAY, IT'S NEARLY IMPOSSIBLE TO TELL HOW MUCH FUEL I HAVE AT ANY GIVEN TIME...EVEN AFTER A FILL-UP. IN FACT, I JUST FILLED UP YESTERDAY AND THE GAUGE SHOWED EMPTY WITH THE FUEL LIGHT ON BY THE TIME I GOT HOME. ONCE IN THE DRIVEWAY, THE GAUGE ROSE TO HALF-FULL. THIS IS A SERIOUS PROBLEM. LIVING IN ALASKA, KNOWING THE VEHICLE'S FUEL STATUS IS CRITICAL, ESPECIALLY IN WINTER WHEN THE SAFETY OF A WARM VEHICLE MAY BE THE ONLY PROTECTION FROM THE ELEMENTS. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT WAS UNSUCCESSFUL. THERE WERE NO WARNING INDICATORS ILLUMINATED AND NO POWER. SHE HAD THE VEHICLE TOWED TO THE DEALER AND THEY STATED THAT THE STARTER MOTOR FAILED. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. SHE NOTED THAT SHE PREVIOUSLY EXPERIENCED ELECTRICAL FAILURES WITH THE VEHICLE. THE STEREO SYSTEM HAD TO BE REPLACED THREE TIMES AS WELL AS WIRES WITHIN THE ENGINE AND HEATING SYSTEM. THE MANUFACTURER OFFERED HER NO ASSISTANCE. THE CURRENT MILEAGE WAS 65,873 AND FAILURE MILEAGE WAS 65,870.

2005 CHEVROLET K1500 PICKUP SPEEDOMETER READS BETWEEN 90-120MPH WHEN MOVING EVEN AT SLOW SPEEDS. AT A STOP IT READS 80MPH. 67,000 MILES WHILE LOOKING ONLINE IT LOOKS LIKE THERE ARE MANY OTHER 2003-2005 CHEVROLET OWNER WITH THIS SAME SAFETY ISSUE AND NO RECALL HAS BEEN MADE. *TR

I WAS DRIVING 55 MPH ON A STATE HIGHWAY WHEN THE ENGINE STARTED REVVING UP. THE TRANSMISSION QUIT WHILE DRIVING DOWN THE HIGHWAY WITH ONLY 63,000 MILES THE TRANSMISSION WOULD ENGAGE BUT WOULD SLIP OUT OF GEAR AROUND 45 MPH THE DEALER REPLACED THE TRANSMISSION AT A COST OF $2700. TOOK 3 DAYS 18000 MILES LATER DRIVING DOWN A COUNTRY ROAD THE TRANSMISSION QUIT AGAIN. I WAS ABLE TO LIMP IT HOME (60 MILES) IN FIRST GEAR. THE DEALER SAID IT WAS A RARE OCCURENCE. THE DEALER REBUILT THE TRANSMISSION FREE OF CHARGE BUT IT TOOK 11 DAYS THE DEALER SAID FORWARD SPRING ASSEMBLY BROKE? *TR

SPEEDOMETER STOPPED WORKING AFTER IT RAN AT 120 MPH FOR AWHILE.*TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHEN THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE, THE SPEEDOMETER STOPPED WORKING. THE DEALER STATED THAT THE SPEEDOMETER MODULE NEEDED TO BE REPLACED. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 37,000. UPDATED 01/06/09. *LJ UPDATED 01/06/09.*JB

I HAVE A 2005 SILVERADO WORK TRUCK. IT STARTED AS AN ANNOYING CLUNK' AND HAS TURNED INTO A CONTINUOUS CLUNK. AFTER DOING RESEARCH, I FOUND THE INTERMEDIATE SHAFT IS THE PROBLEM. THE DEALER WONT TOUCH IT EVEN THOUGH THERE IS A BULLETIN FOR '03-'04 MODELS. IF THIS SHAFT FAILS AT HIGHWAY SPEED THE DRIVER IS IN DEEP TROUBLE. WHY HAS THIS NOT BEEN MADE A FULL BLOWN RECALL? *TR

SPEEDOMETER FAILURE ON 2005 CHEVY SILVERADO SPEEDOMETER REGISTERS WRONG SPEED AT 60MPH READS 20MPH. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING 45 MPH, THE SPEEDOMETER STOPPED WORKING PROPERLY. THE CONTACT CRASHED THE VEHICLE INTO A DITCH. THE DEALER HAS NOT DIAGNOSED THE VEHICLE. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 54,000.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT SMELLED SMOKE. SHE PULLED INTO A PARKING LOT AND NOTICED THAT THE FRONT DRIVER'S SIDE TIRE WAS SMOKING. IN ADDITION, THE HUB CAP MELTED AND FELL TO THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE BRAKING SYSTEM FAILED. THE CURRENT AND FAILURE MILEAGES WERE 78,000.

SPEEDOMETER FAILURE ON 2005 CHEVROLET PICKUP WHICH COULD LEAD TO TICKET FOR SPEEDING OR EVENTUALLY ACCIDENT. DEALERSHIP SAID THIS WAS A COMMON OCCURRENCE ON THESE VEHICLES. FOUND OUT THAT THERE IS A RECALL FOR 2003 AND 2004 MODELS. THIS IS AN EXPENSIVE ITEM FOR ME TO PAY OUT OF MY POCKET. WHY IS THERE NOT A VEHICLE RECALL FOR 2005 MODELS WHEN THIS OCCURS ALL THE TIME? MY VEHICLE CURRENTLY HAS 69,000 MILES. *TR

HEATER RESISTOR,AND WIRING CONNECTOR BOTH MELTED TO POINT THAT THEY HAD TO BE REPLACE. THIS IS ON GOING PROBLEM THAT COULD CAUSE AFIRE OR WORST. I TALK TO GM SERVICE PEOPLE AND COULD NOT GET ANSWER. I CHECK INTERNET FOR PART BECAUSE GM WANTED TO MUCH FOR THEIR. THAT WHEN I READ ABOUT ALOT MORE PEOPLE HAVING THE SAME PROBLEM AND GM WONT HELP FIX THE PROBLEM. *TR

2005 CHEVROLET SILVERADO 1500. SMELL FROM HEATER/A/C BLOWER. FIRST TOLD BLOWER MOTOR. UPON CLOSER EXAMINATION FOUND THAT BLOWER MOTOR WAS OK BUT RESISTOR AND WIRING HARNESS HAD MELTED/BURNED. DAMAGE WAS LOCAL TO HARNESS AND RESISTOR. DEALER WILL NOT COVER DAMAGE. SERVICE BULLETIN EXIST BUT WILL NOT HELP PAY. *TR

STEERING COLUMN MAKING RUMBLING SOUNDS. RECALL BY NHSTA POSTED ON INTERNET, HOWEVER, MANUFACTURE STATES THERE ARE NO RECALLS OF SUCH. TRUCK IS JUST OUT OF 3 YEAR WARRANTY. MANUFACTURER NEEDS TO ADDRESS THIS PROBLEM WITH ALL 2005 MODELS IN THIS CLASS. THIS IS A SAFETY ISSUE ACCORDING TO THE NHTSA DUE TO A POSSIBLE LOSS OF STEERING WHILE DRIVING. THE MANUFACTURER SHOULD BE MADE TO FIX THIS PROBLEM PERMANENTLY, AND NOT JUST TEMPORARILY LIKE I HAVE HEARD FROM OTHERS HAVING THIS PROBLEM. THE DEALERS CHARGE FOR A FIX AND THE PROBLEM JUST COMES BACK AFTER A SHORT PERIOD OF TIME. THIS SHOULD DEFINITELY BE A RECALL BY CHEVROLET AND GM AND THEY SHOULD BE MADE TO FIX IT PERMANENTLY. IF MY STEERING GOES AWAY, AND A CRASH FOLLOWS, THEY WILL NOT HAVE TO WORRY ABOUT FIXING THE PROBLEM, THEY WILL HAVE TO WORRY ABOUT BEING SUED. *TR

1. MY FATHER IN LAW HIT THE EXPOSED HEATING/COOLING FAN MOTOR WIRING WITH HIS FOOT WHEN ENTERING THE PASSENGER SIDE OF THE VEHICLE. THE WIRING OR HARNESS IS NOT COVERED TO PREVENT ENTANGLEMENT OR OTHER OBJECTS FROM CONTACTING THE WIRING. THIS DISLODGED THE WIRING IN THE CONNECTOR TO THE FAN MOTOR RESISTOR. 2. A CONSEQUENCE IS THE WIRING SHORTED IN THE CONNECTOR AND THE FUSE DID NOT FAIL. THE CONNECTOR OVERHEATED AND MELTED TOGETHER. THE FAN MOTOR WAS SHUT DOWN AT THE SIGN OF SMOKE ( BOTH VISUAL AND BY SMELL). FAN MOTOR WOULD NOT OPERATE FROM THIS POINT FORWARD. 3. I WENT TO THE DEALER AND WAS AMAZED THAT THEY STOCKED THIS PARTICULAR HARNESS PN 15862656 AS A REPLACEMENT KIT COMPLETE WITH THE SPLICE CONNECTORS ($95.00). I ALSO PURCHASED THE RESISTOR (PN 89019088, COST $54.97), WHICH ALTHOUGH PROBABLY FUNCTIONED WAS MELTED TO THE HARNESS OF THE CONNECTOR RENDERING IT USELESS. I INSTALLED THE KIT AND REROUTED THE WIRING TO ELIMINATE CONTACT BY A PASSENGERS FOOT OR A TOOL BUCKET. *TR

ANTI-LOCK BRAKE INTERMITTENT MALFUNCTION, AS WITH OTHER YEARS COMES ON AT LOW SPEED. *TR

I HAVE A 2005 CHEVY SILVERADO. THE SPEEDOMETER IS DEFECTIVE AND THE CAUSE IS DUE TO A BAD STEPPER MOTOR. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE WOULD NOT SHIFT INTO THIRD GEAR AND THE INSTRUMENT PANEL WAS BLANK. THE DEALER STATED THAT THE TRANSMISSION AND INSTRUMENT PANEL FAILED. THE DEALER WAS WILLING TO REPLACE THE INSTRUMENT PANEL FOR FREE, BUT THE TRANSMISSION WOULD BE THE CONTACT'S RESPONSIBILITY. THE CONTACT REFERENCED TECHNICAL SERVICE BULLETIN NUMBER 10025462 (POWER TRAIN:AUTOMATIC TRANSMISSION). THE CURRENT AND FAILURE MILEAGES WERE 74,000. UPDATED 11/10/08 *BF THE SPEEDOMETER FAILED 2 DAYS PRIOR. UPDATED 11/13/08. JB

SPEEDOMETER DOES NOT READ CORRECTLY, IE. WHEN IT SAYS I'M GOING THE SPEED LIMIT, I AM FLYING PAST OTHER CARS, IT READS ABOUT 20MPH LOWER THAN I AM REALLY CRUISING AT. CAR IS JUST OUT OF WARRANTY 38K MILES, GM IS AWARE AND WON'T REPLACE FREE OF CHARGE. AS I UNDERSTAND, IT IS A COMMON PROBLEM ON 2005'S AS WELL AS 04 AN 03 MODELS. GM WILL REPLACE 03 AND 04'S (SAME INSTRUMENT CLUSTER) WHY NOT THE 05'S?? *TR

HEARD A NOISE FROM FRONT OF VEHICLE FOLLOWED BY AN ABS WARNING INDICATION, DROVE TO NEAREST DEALER. FAILURE OF LEFT FRONT HUB BEARING, REPLACED PART NUMBER 15863441. *TR

WHEN TURNING MY A/C, DEFROSTER, OR HEATER ON BETWEEN SETTING 3, 4, AND 5 A CLICKING NOISE WOULD OCCUR. THIS HAPPENED EVERY TIME UNTIL IT FINALLY QUIT WORKING. WHEN I FOUND OUT THE PROBLEM IT WAS FOUND THAT THE WIRE HARNESS AND THE BLOWER MOTOR RESISTOR TO THE HEATER/A/C WAS BURNED UP. SEEING THE MELTED PLASTIC SURPRISES ME AND MAKES ME WONDER IF IT WAS CLOSE TO CATCHING ON FIRE. NOW I HAVE NO A/C, HEATER, OR DEFROST. I AM CURRENTLY IN THE PROCESS OF HAVING THE WIRE HARNESS CHANGED AND THE BLOWER MOTOR RESISTOR. I WILL HAVE THE OLD PARTS AVAILABLE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE ATTEMPTING TO TURN THE VEHICLE, THE CONTACT HEARD A LOUD BUMPING NOISE COMING FROM THE STEERING COLUMN. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE INTERMEDIATE STEERING SHAFT. HE IS IN THE PROCESS OF CALLING THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR). THE FAILURE MILEAGE WAS 27,000 AND CURRENT MILEAGE WAS 28,400.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT HEARD A SLIGHT RUBBING NOISE COMING FROM THE VEHICLE AND THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE SERVICE CENTER AND IT MADE A METAL ON METAL RUBBING SOUND WHEN A TURN WAS MADE. THE FRONT PASSENGER SIDE WHEEL WAS LOOSE AND WOBBLING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 07E106000 (WHEEL CAP/COVER/HUB). THE COST OF THE REPAIR WAS $330. THE FAILURE MILEAGE WAS 113,000.

THE SPEEDOMETER AND TACH GAUGES HAVE BEEN MESSED UP FOR NEARLY A YEAR NOW AND I CAN NOT GET GM TO FIX THE PROBLEM. IT IS ON AN 05 SILVERADO AND THEY REFUSE TO DO ANYTHING TO ANY TRUCK AFTER 04. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHEN THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL, THE ABS FAILED AND THE PEDAL EXTENDED TO THE FLOOR. THE VEHICLE WAS UNABLE TO BE STOPPED. THE DEALER REPLACED BOTH SLOW SPEED ABS SENSORS AT THE COST OF $212 EACH. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 16,000 AND CURRENT MILEAGE WAS 18,000.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHEN THE CONTACT LIGHTLY RELEASES THE BRAKE PEDAL, THE BRAKE LIGHTS AUTOMATICALLY DIM. THE FAILURE WAS NOTICED WHILE DRIVING 10 MPH. THE FAILURE OCCURS EVEN THOUGH HIS FOOT IS STILL ON THE BRAKE PEDAL. HE STATED THAT A VEHICLE DRIVING BEHIND HIM WILL NOT REALIZE THAT HE IS ATTEMPTING TO STOP THE VEHICLE; THEREFORE, IT COULD CAUSE A REAR END CRASH WITH ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER A TOTAL OF FIVE TIMES AND THEY ACKNOWLEDGED THE FAILURE, BUT COULD NOT REPAIR IT BECAUSE IT IS AN UNADJUSTABLE SHIFT. THE CONTACT BELIEVES THAT IF THE REAR BRAKE LIGHTS ARE NOT WORKING, IT COULD INCREASE THE RISK OF AN CRASH WITH THE VEHICLES IN THE REAR. THE FAILURE MILEAGE WAS 24,000 AND CURRENT MILEAGE WAS 29,500.UPDATE 09/10/08 *CW UPDATED 09/15/08. *JB

THE HEADLAMPS , EXTERIOR LAMPS , ALL LIGHTS ON DASH , WINDOW AND DOOR LOCK SWITCHES , RADIO , A/C SWITCHES AND GAUGES FLICKER. THE GAUGES , IE.. FUEL , WATER TEMP , TACH , VOLTAGE METER AND OIL PRESSURE GAUGE FLUCTUATE. IM AFRAID THEY WILL PERMANENTLY GO OUT WHILE DRIVING AT NIGHT. I'VE TRIED DIMMING THE HEADLAMPS , ADJUSTING THE RHEOSTAT AND OTHER THINGS WITH NO CHANGE. MY TRUCK IS NOW PAST WARRANTY ON THE MILEAGE. I NOTICED A SERVICE BULLETIN ON MY INSURANCE WEBSITE. THE BULLETIN IS 1001986 . ACCORDING TO THIS SERVICE BULLETIN GM HAS BEEN HAVING THIS PROBLEM FOR QUITE SOME TIME AS THE BULLETIN WAS SENT JAN. 2001 AND STILL HAS 2005 MODELS [WHAT I HAVE] INCLUDED IN THAT BULLETIN. I WENT TO MY DEALER AND REQUESTED INFO ON THE SPECIFIC BULLETIN SO THAT I COULD MAKE REPAIRS AND WAS FIRST TOLD BY THE SERV. WRITER THAT SHE DID NOT HAVE ACCESS TO SERV. BULLETINS. I TOLD HER THAT I HAD BEEN A SERVICE MANAGER FOR A TOYOTA DEALER AND KNEW THAT IF SHE WAS A SERVICE WRITER THEN SHE DID INDEED HAVE ACCESS TO BULLETINS SHE ADMITTED SHE DID . I THEN ASKED AGAIN FOR A COPY OF THE BULLETIN AND SHE THEN SAID SHE WASN'T AUTHORIZED TO GIVE THAT INFO. I PAID ALMOST 40K FOR THIS TRUCK AND THAT'S THE SERVICE YOU GET FROM GM. IT SEEMS THAT IF SO MANY VEHICLES HAVING THE SAME PROBLEM AT LEAST 6 CONSECUTIVE YEARS YOU GUYS SHOULD INVESTIGATE AND MANDATE A RECALL AS YOUR DRIVING LAMPS ARE A VITAL PART OF THE SAFETY WITH THE VEHICLE. *TR

2005 SILVERADO TRUCK, INTERIOR OF TRUCK CAUGHT FIRE IN THE MIDDLE OF THE NIGHT WHEN FAMILY IS SLEEPING. BELIEVED TO HAVE STARTED IN POWER SEAT MOTOR ONLY DAYS AFTER A NEW BATTERY REPLACED. WIRING PROBLEMS VERSUS DEFECTIVE INSTRUMENT THAT DREW POWER OFF THE BATTERY TO BEGIN FIRE? *TR

WAS GOING 55 MPH AND CAME TO A STOP LIGHT. THE SPEEDOMETER STAYED AT 55 MPH. WHEN I SPED BACK UP THE SPEEDOMETER WENT UP TO 150 MPH AND STAYED THERE. SOMETIMES IT DROPS BACK DOWN TO 90 MPH AND THE GOES BACK UP TO 150 MPH WHEN I SPEED BACK UP. IT NORMALLY STAYS STUCK AT 150 MPH NO MATTER WHAT SPEED I'M AT. *TR

WAS DRIVING NORMALLY WHEN I CAME TO A STOP LIGHT. INSTEAD OF THE SPEEDOMETER DROPPING DOWN TO ZERO IT STAYED A 60 MPH. THE SPEEDOMETER BOUNCED UP AND DOWN FOR AWHILE AND NOW IT JUST STAYS STUCK ON 150 MPH. EVERY ONCE IN AWHILE IT WILL DROP DOWN TO 90 MPH, BUT THEN GETS STUCK BACK ON 150 MPH WHEN I START DRIVING AGAIN. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING OVER A BUMP IN THE ROAD, THE WHEEL FELT AS IF IT WOULD FALL AND WHEN APPLYING THE BRAKES HE COULD FEEL MOVEMENT IN THE STEERING SHAFT. THIS FAILURE CONTINUED TO OCCUR AT VARIOUS SPEEDS. THE DEALER REPAIRED THE STEERING SHAFT ASSEMBLY; HOWEVER, APPROXIMATELY 8 MONTHS LATER THE FAILURE REOCCURRED. THE DEALER STATED THAT THEY ARE AWARE OF THE DEFECT AND INSTALLED A CURRENT VERSION OF THE STEERING SHAFT. THE FAILURE REOCCURRED ON JULY 27, 2008 ONE HOUR AFTER HE DROVE THE VEHICLE FROM THE DEALER. THE FAILURE MILEAGE WAS 22000 AND THE CURRENT MILEAGE WAS 25700.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT SMELLED BURNING WIRE UNDERNEATH THE DASHBOARD. HE LOOKED UNDER THE DASHBOARD AND DISCOVERED A RED, GLOWING, BURNING WIRING HARNESS, WHICH HE THEN UNPLUGGED. THE BLOWER MOTOR RESISTOR AND THE WIRING HARNESS FAILED. THE CURRENT MILEAGE WAS 68,357 AND FAILURE MILEAGE WAS 66,000.