2016 Chevrolet Malibu complaints

When I put the car in park and try to turn the car off the Shift Park message comes on preventing me from cutting the car completely off. I put in back in drive or reverse then back in park it still dings and shows the message. I takes a number of repeating these steps for it to stop and turn off and this is happening every time I'm trying to turn the car off.

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle lost power. Additionally, the message “Engine Power Reduced" was displayed. The vehicle was taken to an independent mechanic and was diagnosed and determined that the throttle body sensor needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 107,000.

I am filing a complaint regarding ongoing and worsening issues with my Chevrolet vehicle, which appear to point to broader defects involving the engine and electrical systems. Months ago, while driving, the car suddenly lost power and displayed "Engine Power Reduced." I had to keep using it due to work needs. Over time, it hesitated more during acceleration and felt increasingly unsafe. When I finally brought it to a Chevrolet service center, I was told the issue involved the pistons. The vehicle also regularly shows a "Shift to Park" warning even when the gear is in Park, raising concerns about the transmission's reliability. The power loss continues, especially when going uphill — again triggering the "Engine Power Reduced" alert and dropping the speed to no more than 35 MPH. A diagnostic showed a P0302 code for a cylinder 2 misfire. The radio head unit, already replaced once under warranty, failed again after just 9 months. Prior to the worsening idle and gear issues, I also received network-related codes involving the ECM and transmission computers. Although I’ve replaced the alternator, the car still shows "Service Electric System" warnings, suggesting ongoing electrical problems. I also noticed GM’s N182195660 campaign involving predictive monitoring for Stochastic Pre-Ignition (SPI) on SCP platforms. My car has the 2.0L turbo engine, and I’m concerned it may be experiencing SPI or coolant intrusion issues affecting overall performance and system integrity. I’m requesti

Shift to park message and park not fully engaging. This caused the vehicle to roll back when parked on an incline.

Took my car to Chevy dealership to diagnose my car, as it was rough idling, causing hesitation, and knocking... all while the check engine light was on. They showed me two codes my car was giving from the check engine light. They said he would look further into it. They told me I needed a tune up, though I had gotten a tune up 4 months prior. They fixed some things and charged me over $4,000. The day I drove off the lot, the problems were still present. On my way home going about 50 mph, my car slowed down and the engine reduced power illuminated. I kept driving because I needed a car for work. The car continued to decline and acted like it didn't want to accelerate when pressing the gas. I finally took it back into chevy, and they told me it was my pistons. I'm 90% sure there is a defect that they won't tell me about, or the won't fix. I've had the car 2 years. Now the car won't run.

To whom it may concern, I am writing to formally report a recurring safety-related issue with my 2016 Chevrolet Malibu. The vehicle consistently displays a “Shift to Park” warning message, even when the gear selector is properly in the Park position. This malfunction prevents the car from turning off completely and poses a serious safety and reliability concern. This issue first occurred while the vehicle was under warranty, and the dealership performed a repair. However, the problem has returned, and my warranty has since expired. Despite the previous fix, the issue continues to persist. This malfunction is widely documented among other 2016–2019 Chevy Malibu owners and appears to stem from a design or manufacturing flaw in the shifter assembly or park switch. I am concerned that this defect could: Prevent the vehicle from being securely parked. Lead to battery drain due to the vehicle not shutting off. Pose a risk if the driver believes the car is in park when it is not. I am requesting that Chevrolet consider this a safety defect and either recall the affected vehicles or offer extended coverage for repairs. I also ask that NHTSA investigate this issue further as it compromises the safety, reliability, and proper functioning of the vehicle. Thank you for your attention to this matter. I would appreciate any assistance or updates regarding how this issue will be addressed. Vehicle Info: 2016 Chevrolet Malibu E2 Year: 2016 Make: Chevrolet Model: Malibu Mileage: 60,000 VIN: A

I am writing to report a serious and unacceptable issue with the exterior paint and clear coat on my 2016 Chevrolet Malibu. The clear coat has become dull and faded on the hood and roof, and the side panels are beginning to chip and peel, despite regular washing and maintenance. This paint deterioration started well before what would be expected in a properly manufactured vehicle finish, especially for one that has been well cared for and is only a few years old. The vehicle has never been in an accident, and the finish failure appears to be due to a defect in the clear coat or paint application process at the factory. This not only affects the appearance and value of the vehicle, but also raises concerns about long-term body protection. Once the clear coat is compromised, the base paint and metal underneath are more susceptible to rust and corrosion. There are countless reports online of other GM vehicle owners experiencing similar issues, and I believe this should be investigated as a widespread manufacturing defect. I request that GM address this issue, either through a recall or a goodwill repair/paint reimbursement program. Vehicle Details: Year: 2016 Make: Chevrolet Model: Malibu E2 Color: Black Thank you for your time and attention. I hope to see GM stand behind its product and take responsibility for this defect. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle will display on dashboard “Shift to park” while the vehicle is placed in “P”. The engine will turn off, but the power remains on until the battery is disconnected from the vehicle. Codes have been verified by the Chevrolet dealership.

The contact owns a 2016 Chevrolet Malibu. The contact stated that upon depression of the brake pedal, the brake pedal made an abnormal grinding sound and became stiff. The check engine warning light was illuminated. The contact's husband replaced the brake sensor; however, the failure recurred several days later. The contact related the failure to NHTSA Campaign Number: 16V272000 (Electronic Stability Control). The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The contact was provided an estimate for a diagnostic test and was referred to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 120,000.

MY SHIFT TO PARK LIGHT IS COMING ON

The contact owns a 2016 Chevrolet Malibu. The contact stated that after shifting to park, the message to shift to park was displayed. The failure occurred intermittently and had become more persistent over time. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.

The contact owns a 2016 Chevrolet Malibu. The contact stated that occasionally while attempting to accelerate the vehicle stalled. The contact stated that the failure also occurred while stopped at a traffic light. The contact was able to restart the vehicle and continued driving; however, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed and the contact was advised that the throttle position sensor, and the intake airflow system were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 163,000.

Shift to park message on odometer after vehicle is already in park

Happened around 46000 miles after receiving a recall notice in the mail about the pedal positioning sensor causing a reduced engine power signal, and immediately reducing speeds on the interstate. Local Chevy dealership replaced. Fast-forward 80K miles and the same incident is happening, however likely not going to be covered by GM. Same message, same code being detected.

Car showing warning : engine power reduced Car decelerate unexpectedly Car won’t accelerate past 20 mph intermittently - when putting car in park, car won’t recognize when in the park positioned and shows warning : shift to park

The contact owns a 2016 Chevrolet Malibu. The contact stated that occasionally while shifting into park(P), the computer failed to register that the vehicle was in park(P). The message "Shift to Park" was displayed on the instrument panel. The contact stated that during the failure, the doors failed to lock. No warning lights were illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the shifter, shifter harness, and shifter switch needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 47,000.

I had my vehicle for about 2 years. I noticed that after I went over a certain amount of mileage, my car went into an engine power reduce mode. With the engine power reduce mode my vehicle could only go 25 mph. This was happening to me when I was driving on major highways, etc.. I would have to pull over and stop the vehicle because after certain amount of time it also would tell me oil pressure low to stop engine. I took it to the Chevy dealership to have it looked at. I got the runaround with trying to figure out exactly what the issue was. They kept telling me that it was something else I spent over $1600 in repairs due to them, telling me that they found the issue and corrected it. After about another week or two, The same issue happened, engine power reduced stop engine oil pressure low. The most dangerous part about it is again I’m driving on interstates heading to work, etc. and the car is slows down on the interstate not allowing me to go over 25 mph again having to pull over on the interstate to give the car a break, crank it back up and get to a safe location. After having multiple mechanics look at it, still unable to fix. It started to get worse where once it pops up engine power reduce, oil pressure low stop engine, the car started jerking & shaking really bad. The only way to stop this from happening is to again shut the car down. I can’t keep shutting the car down in the middle of the interstate and on major roads. I took the vehicle to the Chevy dealership fir

I am writing to formally lodge a complaint regarding an ongoing issue I have encountered with my 2016 Chevrolet Malibu. Recently, I experienced a significant problem with the vehicle’s trunk and rear seat release mechanism, which has made it impossible for me to access the trunk or fold down the rear seats. The specific issues I am facing are as follows: Trunk Latch Stuck: The trunk latch has become stuck, and I am unable to open the trunk manually or with the remote key fob. The latch mechanism appears to be malfunctioning, and it will not unlatch when attempting to open it. Remote Key Fob Failure: The remote key fob, which is typically used to release the trunk, no longer works, making it impossible to access the trunk from outside the vehicle. Seat Release Mechanism: Additionally, the release button for folding down the rear seats is also not functioning, and I cannot lower the seats from inside the cabin. Typically, this release mechanism can be accessed from the trunk; however, due to the trunk being inaccessible, I am unable to release the seats, which is an urgent issue. This situation is highly inconvenient and concerning, as I rely on the trunk and rear seats for storage and daily functionality. The inability to access the trunk or fold down the seats creates a major safety and usability issue, especially in situations where I need access to the trunk in emergencies. I kindly request that this issue be investigated and resolved as soon as possible. Ideally, I would l

The car has a seat belt electrical problem it makes sound once in a while indicating for the driver to put their seat belt on. Also there is issues with the brake sensor. The #1 issue is the Transmission Accumulator Pressure Pipe, when it breaks all your transmission oil pours out from the bottom of the vehicle. The part is about $20 but if not installed right you will think that your transmission is dead but it's not.

I will be driving at posted speed limits (typically 55 to 60 MPH) and while going up a hill, the engine loses power. I get a notice on my screen that states engine power reduced. Speed reduces to no more than 35 MPH. This can put others in danger if they are too close or if the roads are icy due to it being winter in Indiana. I put on my hazard lights, and I am able to pull off the side of the road, turn off the car for 5 minutes and restart it and have power back. But engine light remains on. Mechanics cannot find anything wrong. No warnings prior to the incident. In fact, the car loses power and then the message appears on screen. This has happened 7 times in the last 4 months.

The contact owns a 2016 Chevrolet Malibu. The contact stated that while the vehicle was parked overnight on an incline with the front of the vehicle facing forward, the contact stated that the electronic parking brake unexpectedly released, and the vehicle rolled away and crashed into the neighbors vehicle, causing damages to the headlights and the bumpers of both vehicles. The contact stated that there was no one inside the vehicles during the crash. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. A Police report was not filed. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 102,000.

Reduce Engine Power - vehicle decreased acceleration drastically while driving on the highway.

The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the "Reduced Power Engine" message displayed and the vehicle inadvertently decelerated. The brake pedal was firm while depressed and the vehicle failed to stop immediately. The vehicle was towed to an independent mechanic, who diagnosed that the vacuum pump needed to be replaced. The vehicle was then taken to the dealer, where it was determined that the vacuum pump deteriorated and went into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000.

I started smelling a strong smell of gas while operating the vehicle. Took to a dealership who diagnosed a turbocharger clamp and exhaust failure. From what I understand I am not the only one with a clamp/exhaust/seal problem. A friend of mine who owned a GM product had similar problems to the point her engine failed altogether. Please investigate!

When putting it in park and shutting the car down it says on dash to “shift to park.” There are other 2016 malibu that have this recall but for some reason not mine.

A couple days ago I went to drive my car and it took a second to actually turn on and it was shaking way more than usual and pooped up with a message saying “engine power is reduced” I haven’t drove my car since because i tried and it was moving very slow, and i also didn’t wanna cause further issues. For some time now my car has been shaky. i have taken it in and balanced my tires because of this issue and nothing had helped. I am always scared to drive it because it has been so shaky but now that this message has popped up it’s even worse and it’s during my whole drive. Also every time i park it isn’t connecting and says “shift to park” even though it is shifted into park. i have to shake it and press some button to go all register that it is shifted into park and can shut my vehicle off. I have read every where that this issue has happened to so many 2016/2017 chevy Malibu’s. I have read the dangers and i do not feel safe driving my car like this. I also didn’t have my car when there was a recall on this exact part before. and i’m guessing the dealership who had it before me did not fix it, causing the problems to worsen other parts of my car. I can’t drive this car due to the safety and i believe it should be a recalled. I am not totally sure what is doing it but as of all the other people online, they said it has to do the gas pedal (2k replacement) and fuel pumps and also could have burned wires which my car also has. thank you.

The contact owns a 2016 Chevrolet Malibu. The contact stated that the shift to park message was displayed while parking the vehicle. There were no warning lights illuminated. The contact called the local dealer and was informed that there were no open recalls on the vehicle. The contact stated that an appointment was scheduled. The vehicle was not diagnosed or repaired. The contact called another local dealer, Reedman Toll Chevrolet (1700 Lincoln Hwy., Langhorne, PA 19047), but the vehicle was not diagnosed or repaired. The manufacturer was contacted and informed that there was no recall coverage on the vehicle for the failure. The failure mileage was approximately 120,000.

I experienced a check engine light and a "reduced engine power" message in the middle of traffic in the stromy rain. I was driving 35 to 40 mph before vehicle slowed to almost a stop and when pressed gas pedal it excel slowly creeped to less than 30 MPH THANKFUL I wasn't rear-ended.Pulled into nearest Autozone part store and diagnostic scan showed the P2138 code. DC severity, sensor, and accelerator pedal position - see photos attached. Waited with engine off for approx over 30 minutes then started vehicle , engine lght off and proceeded to my destination excell with no issues.This has happened several times since purchase of vehicle began 2019. Throttle body repairs, ECM replacements and harness repairs later still reoccurring documented at dealships and repair shops. This is a serious and costly hazard.

The contact owns a 2016 Chevrolet Malibu. The contact stated while the vehicle was parked and attempting to fasten the seat belt, the seat belt failed to retract. The failure occurred with the driver’s and passenger’s side front seat belts. The vehicle was taken to a dealer where it was diagnosed that the retracting mechanism had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

Update to claim #11614644. Car was inspected by Auto Lenders in Lakewood, NJ. Vacuum pump failed and cam shaft has to be replaced, was told the engine **SHOULD* be salvageable. They won't know until they start taking it apart. Was told it will take 12 hrs for each part at $180 an hr. Damage is estimated at $4500. Car is currently under an extended warranty, we are waiting to hear if the warranty will cover the damage. My son still owes $9000 on the car, we bought it 2 yrs ago. Beyond angry that Chevy/GM has not recalled this car!!!

I am having to replace the VACUUM PUMP for the second time. Each time the pump breaks it spreads contaminants inside the camshaft compartment causing further issues. This is a common problem according to the many complaints I've seen on auto sites. This should be a recall.

Vacuum pump failure. Brakes failed while driving the car, brakes became manual power but was able to pull over safely. There was no previous warning or error codes. Car is currently at a Mr. Tire facility. The manager ran diagnostic code - "reduce engine power" error and found the cause as the vacuum pump. Due to the time of the failure, late Saturday 9/14/24, the part cannot be ordered until Monday from the local Chevy dealership. The facility will not know if there is additional engine damage until the part is remove and inspected. There is known issues with vacuum pumps failing and a class action lawsuit currently in ligation.

The car will not turn off when placed in the park position. A warning comes on that states "shift to park" when the car is already in park. I have contacted Chevrolet twice and was notified that their are no open recalls on this. This is a very common and known problem with 2016-2019 Chevy malibu as well as Chevy Cruze model. Chevrolet is no help in this matter. I feel this is a large safety issue as you cannot turn the car off. PLEASE HELP!

The electrical chip in my EBCM has a malfunction and the brakes will grab and grind at random times. Also at the time electronic stability control will mess up increasing the risk of a crash. Other malibu vehicles with the same year have had a recall on these parts. Mine however was not included but has the same malfunctioning part.

The contact owns a 2016 Chevrolet Malibu. The contact stated that while the vehicle was in park(P) on several occasions, the message "Shift to Park" was displayed. The contact stated that upon moving the gear shifter from reverse(R) to park(P) several times within five minutes, the vehicle responded as needed. The vehicle was taken to the dealer, where it was diagnosed that the gear shifter and the jumper harness had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 38,023

Brake vacuum booster failed resulting in the brakes failing.

“Shift to park” intermittently indicated when vehicle is in park. Power will not shut off while indicated. Was repaired twice but has returned

Brake Booster vacuum pump failed and pieces broke off in the engine.. it failed in the middle of driving with my [XXX] daughter.. the brakes padel was hard and was hard to stop.. could have caused a real bad accident even caused death if happened while driving.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Brake booster vacuum pump failed and pieces of the pump broke off and in the engine..

My airbag light comes on intermittently and will show a passenger is not in my front seat when they are. I took my car to the dealer and they got a current and past code B0074 for the passenger presence module. There was a recall (18208) for this on certain 2016 Malibus but my vin was not included.

The main head gasket fails on these vehicles causing oil to leak everywhere and on top of electrical wires. The lost of oil has caused the engine to reduce the engine speed randomly on the highway which had risk of accidents multiple times, by unable to move the vehicle off the road at a reasonable time. The oil sips land on top of electrical wires which creates the risk of fire.

Driving and the car does not shift correctly when speeding up onto the interstate and then engine light comes on and words engine power is reduced comes on. Called Chevrolet and can no longer drive vehicle.

Vehicle listed a warning "engine power is reduced" and check engine light came on. Vehicle was taken to local dealer shop to have issue resolved. Original thought from technician was the oil was low. Upon topping off the oil problem persisted. After having the engine tested it was determined to have a cracked piston.

On may 23,2024 I was on a very busy highway going 66. All of a sudden my 2016 malibu lt aburtely slowed to 27 miles an hour and two warnings lights came on 1 -engine power is reduced 2 - speed reduced to 27 I barely avoided getting hit by two semi trucks, as well as a car. The car is available for inspection on request. An independent service person confirmed it was indeed a defective electron control and acceleration peddle position sensor. How very irresponsible of you not to put out a recall on the 2016-2018 models knowing very well of the many class action law suits that have arrived from this issue. I probably can guarantee none of you own a Malibu. How very incredious it is that you put people lives in danger knowing that there was issues with the problem. Unbelievable. I almost got killed because of the lack of responsibility because you dint make a recall.

While driving the engine lost power started idling rough and the MIL came on. The MIL was found to be cyl 1 misfire, mechanic tracked it down to a cracked piston. A KNOWN ISSUE WITH THIS MODEL YEAR AND ENGINE. the VIN does not show it as being included in any recall

Out of nowhere, a notification pops up and it says “engine speed reduced” and all of a sudden you can feel the car losing speed. Took the vehicle to the dealership multiple times and either they always say it’s a fuel injection problem or they have no idea what’s causing it but when they perform that service on the vehicle, it still happens. Dealership even told me once that my car computer system needed to be updated and once updated I wouldn’t have the issue and I still have the issue. Each time the engine speed is reduced, a notification pops up that the StabiliTrak needs to be serviced. My safety and life is at risk because I’m going 65 mph down the interstate and all of sudden my engine speed is reduced like I’m not in the middle of traffic with cars going at speeds between 60-75 mph. I almost got ran over by an 18 wheeler because of the engine speed reduction. I had to swerve hard to the side of the road and risk flipping or crashing to get off the road so I wouldn’t be hit

Vehicle check Engine light on, showing "Reduced Engine Power." Vehicle still able to be driven, but will not accelerate with any proper pace or power. Cannot get above 3000 RPM without losing power, has put me in two dangerous situations in the last two days that almost made me lose my life. On highway, trying to accelerate to match traffic speeds, lose power and had to dive to the emergency lane to not get plowed by a truck. Today, was city driving, at a red light, could not accelerate and had to dive to a crawl the vehicle into a turn lane where I ended up sitting for about 10 minutes till the engine offered enough power to keep driving. By all information I can find online, it seems it is similar to the issues presented by others online and might tie into "Special Coverage N182188250 Loss of Continuity within Accelerator Pedal Position Sensor Circuit" that I found here: [XXX] , this issue has been going for about 3 weeks to a month and is only getting worse. I did stop at McCarthy Chevrolet of Overland Park to have codes run about on [XXX], the codes showing do not show in the above link...codes: U1502, U0422, P06DE, C0760...those all present on the paper as "Current." I have not had it diagnosed yet, planning to, service is just so expensive. I have had the car in my car for 1 year and 1 month, purchased from MAX Motors in Harrisonville, Mo. Reporting here as I also saw online that others are facing the same symptoms, and that there is a suit that might be addressing thes

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the vehicle independently engine seized and the check engine warning light illuminated. In addition, the contact stated that the battery would not stay charged. The vehicle was taken to an independent mechanic where it was diagnosed with a no-start dead battery. The vehicle was not repaired. The contact was informed of TSB 16-NA-209 in which the failure description was similar to that of the contact's vehicle. The contact was advised to take the vehicle to the dealer for repair. The dealer was contacted and made aware of the failure and the vehicle had a scheduled service appointment. The manufacturer was not made aware of the failure. The failure mileage was approximately 176,000.

When driving the car it will stop mid drive and slow to 20MPH. The car has broken down in the middle of the road on multiple occasions. It has locked me in the car where I am unable to get out. On one occasion the battery was dead and the car had locked me out. I had to have someone unlock it. The next day the car was fine with no signs of issues. The car has been taken to multiple mechanics and no one knows the issue. Car doesn’t throw any codes or show any symptoms of issues.

THIS HAS HAPPENED ON AN ALMOST DAILY BASIS SINCE 4/30/2024 stabilitrack warning on Ipc, security light, power steering goes out on freeway-while turning in an intersection-going 75 on the freeway while changing lanes, IPC displays ice warning when 90• outside, erratic shifting(being stuck in 2nd gear until it shifts to 4th), no start no crank condition ( I replaced the battery,had alternator tested, tested fuses, fuel pressure test, checked spark plugs and coil packs) key fob not unlocking doors or remote starting (battery was changed) passenger seat will only recline on one side, power mirrors erratically moving without user adjustment, Climate control sporadically disconnects (no lights in dash no power at all) I have not taken it to a dealership I can’t afford the outrageous prices. I have had my father (certified ford technician) inspect the car. This car has become unsafe for me to drive with my children and I am terrified that it’s going to cause us to wreck and cause serious injury or death