2001 Chevrolet Malibu complaints

INTERMITTENTLY ALL DASH LIGHTS STAY ON WHEN STARTING THE CAR. ALSO THE RADIO/ CLOCK DOES NOT COME ON FOR APPROX. 60 SEC'S. DEALER WANTS TO REPLACE IGNITION SWITCH AND PASSLOCK SENSOR. THIS SEEMS TO BE A COMMON PROBLEM WITH THIS CAR. MANUFACTURER SHOULD BE RESPONSIBLE FOR REPAIRS. *NM

ENGINE STOPS RUNNING, INSTRUMENTS DO NOT LIGHT UP, BOTH GAS AND TEMP GAUGE NEEDLES FALL BACK TO OFF POSITION. CAR CAN BE RESTARTED BY MOVING GEAR SELECTOR LEVER AND TWISTING IGNITION KEY TO ENGAGE STARTER. CAR ALSO IS AT TIMES HARD TO START. IF THE IGNITION KEY IS INSERTED AND TWISTED TO ON, SOMETIMES ICONS DO NOT LIGHT UP, NOR WILL THE GAUGES REGISTER,THE ENGINE WILL CRANK BUT NOT START. IF THE KEY IS TWISTED BACK TO THE OFF POSITION,THEN TWISTED BACK TO THE ON POSITION AND THE NEEDLES OF THE GAS AND TEMP GAUGES MOVE, THE ENGINE WILL START. THIS CAR IS 5 YEARS. OLD AND HAS 45,000 MI. ON THE SPEEDOMETER HAS HAPPENED SEVERAL TIMES,BUT SINCE THE ENGINE RESTARTS,IT HAS NOT BEEN TAKEN FOR REPAIRS. THE PCV VALVE HAS BEEN REPLACED, AND CAR HAS BEEN SUBJECTED TO THE STATE MANDATED TESTING,WHICH REQUIRES USE OF THE OBD PORT. THIS WAS LAST FALL. *JB

DT*: THE CONTACT STATED WITHOUT WARNING THE TURN SIGNALS HAVE BECOME INOPERABLE. THERE WAS A RECALL, #03V327000, CONCERNING THE HAZARD LIGHT SWITCH; HOWEVER, THE COMPONENT HAS FAILED AGAIN. THE DEALERSHIP HAS BEEN NOTIFIED, BUT THE VEHICLE WAS NOT SUBJECT TO THE RECALL ANY LONGER AND NO REPAIRS WERE MADE. UPDATED 03/28/06. *JB

I BOUGHT MY CAR WHEN IT WAS A YEAR OLD, SINCE BUYING THE CAR, I HAVE HAD TO PAY 800 DOLLARS TO HAVE THE IGNITION SWITCH CHANGED, WHICH I FOUND OUT LATER THE DEALERSHIP SHOULD HAVE ONLY CHARGED 400. I HAVE ALSO RESPONDED TO THE TURN SIGNAL RECALL TO HAVE THE HAZARD SWITCH FIXED ONLY TO HAVE THE SAME SWITCH GO OUT AGAIN, NOT EVEN 2 YEARS LATER. I AM BEING TOLD THAT IT WILL COST AT LEAST 200.00 TO FIX. INSTEAD OF THE TURN SIGNALS NOT WORKING NOW THERE IS A CONSTANT CLICKING IN THE DASH, WHICH THEY SAID IS CAUSED BY THE HAZARD SWITCH BEING DEFECTIVE...IF THAT IS THE CASE THEN WHY WOULD THEY REPLACE THE ORIGINAL SWITCH WITH A DEFECTIVE ONE AND NOT REPLACE THE DEFECTIVE ONE? *NM

I TOOK MY 2001 CHEVY MALIBU LS IN TO GET THE OIL CHANGED. THE MECHANIC TOLD ME THAT A COMMON PROBLEM FOR THE GM ENGINES OF MY YEAR AND OTHERS WAS THE INTAKE MANIFOLD GASKET LEAKING COOLANT, AND THAT IF LEFT UN-FIXED, THE ENGINE WOULD EVENTUALLY SEIZE UP. I WAS TOLD THAT THE MATERIAL THAT THE GASKETS WERE MADE OUT OF HAS SINCE BEEN CHANGED, WHICH WOULD IMPLY THAT THEY KNOW IT TO BE FAULTY. I CONTACTED GM AND TOOK IT INTO THE DEALER WHERE THEY CONFIRMED THE PROBLEM. I DON'T KNOW IF THIS ISSUE MAKES THE CAR UNSAFE TO DRIVE, BUT I HAD HEARD THAT THERE WAS A RECALL IN PLACE FOR FAULTY ALTERNATORS AND FIGURED THIS PROBLEM WAS ABOUT EQUAL TO THAT IN POTENTIAL DANGER. OUT OF CURIOSITY, I LOOKED ON THE INTERNET AND THERE ARE PLENTY OF WEBSITES WITH PEOPLE THAT HAVE THE SAME ISSUE. *JB

ON TWO OCCASIONS 2001 CHEVROLET MALIBU HAS FAILED TO START. *TS ***NO ANSWER REQUIRED*** THE VEHICLE WAS TAKEN TO THE DEALER TWICE. DIAGNOSTIC TEST WERE RUN BUT THE DEALER WAS UNABLE TO FIND A CAUSE FOR THE PROBLEM EITHER TIME. *NM

I HAVE HAD TO REPLACE MY 2001 CHEVY MALIBU'S MANIFOLD TWICE, AND I HAVE NOTICE THAT I AM NOT THE ONLY ONE. THIS IS NOT NORMAL WEAR AND TEAR THIS IS A MANUFACTURER DEFECT. *JB

THE VEHICLES HEAT GAUGE STOPPED WORKING AND LOW COOLANT LIGHT CAME ON. CHECKED COOLANT LEVEL AND DISCOVERED SLUDGE IN EXPANSION CHAMBER ( COOLANT RECOVERY TANK). FLUSHED SYSTEM OF SLUDGE AND TROUBLE SHOT REASON FOR COOLANT LOSS. FOUND INTAKE MANIFOLD GASKET LEAKING. VEHICLE WILL REQUIRE NEW INTAKE MANIFOLD GASKET SET, THERMOSTAT, HOSES, WATER PUMP AND POSSIBLY RADIATOR. TRIED TO FLUSH SYSTEM COMPLETELY BUT FOUND SECONDARY PLUMBING SUCH AS HEATER CORE, RADIATOR,COOLANT CROSSOVER AND COOLANT BLEED HOSING GUMMED UP WITH OILY WAXY TYPE SUBSTANCE RESEMBLING GUMBALLS (DEX-COOL?). I THINK GM SHOULD STEP UP TO THE PLATE AND TAKE RESPONSIBILITY FOR THE SO CALLED "WONDER COOLANT". AFTER ALL THE STICKER ON THE EXPANSION CHAMBER DOES SAY ANYTHING ABOUT CHANGING EVERY 5 YEARS OR 150000 MILES. *JB

(1) COOLANT LEAKING IMMEDIATELY AFTER PUTTING IT INTO MY VEHICLE. (2) MY CAR HAS OVERHEATED THREE TIMES ON THE FREEWAY. IT WILL NOT ACCELERATE, STARTS VIOLENTLY VIBRATING, THEN SMOKE BELLOWS OUT OF MY HOOD WHEN I FINALLY STOP. I HAVE BEEN STRANDED ON THE FREEWAY THREE TIMES WITH MY TWO-YEAR-OLD IN THE CAR, AS WELL AS MY UNBORN CHILD. (3) I HAVE TAKEN MY VEHICLE TO A CHEVROLET REPAIR MAN WHO FOUND A TECHNICAL SERVICE BULLETIN ON THE PROBLEM ISSUED BY CHEVROLET. HE EXPLAINED THE INTAKE MANIFOLD WAS MANUFACTURED CROOKED CAUSING COOLANT TO LEAK INTO MY ENGINE AND DILUTE MY OIL WHICH WILL EVENTUALLY BURN MY MOTOR AND RUIN IT COMPLETELY. WHEN I CONTACTED CHEVROLET, THEY WERE VERY UNHELPFUL BOTH TIMES STATING I HAD TO PAY A CHEVY DEALERSHIP TO DIAGNOSE THE PROBLEM AND THAT THEY MIGHT HELP ME WITH A LITTLE COST ASSISTANCE BUT NOT MUCH. IT IS ABOUT $600 TO FIX THIS PROBLEM THAT IS NOT NORMAL MAINTENANCE OR WEAR-AND-TEAR. IT IS A MANUFACTURING DEFECT. I HAVE HAD SEVERAL PEOPLE E-MAIL ME ABOUT THE SAME PROBLEM AFTER POSTING A COMMENT ABOUT IT ON A WEBSITE. *NM

I WENT OUT TO START MY CAR AND IT WOULD NOT START. HAD IT TOWED AND WAS INFORMED IT WAS THE ANTI-THEFT SYSTEM AGAIN. THE SAME THING HAPPENED BACK IN APRIL OF 2005 AND THE WHOLE SYSTEM HAD TO BE REPLACED WHICH WAS $300.00. THEY ARE HAVING TO REPLACING THE WHOLE SYSTEM AGAIN FOR $500.00. *NM

DT*: THE CONTACT STATED THE ANTI-THEFT SECURITY SYSTEM MALFUNCTIONED. WHILE DRIVING THE ANTI-THEFT WARNING LIGHT ILLUMINATED, AND THE VEHICLE SHUT DOWN. IT HAD TO BE PULLED ONTO THE EMERGENCY SHOULDER AND TO SIT FOR TEN MINUTES. THEN, THE KEY WAS TURNED TO THE ACCESSORY POSITION FOR TEN MORE MINUTES. AFTER THE ANTI-THEFT SYSTEM RESET BY ITSELF THE VEHICLE RESTARTED. THIS HAS BEEN REPORTED TO THE MANUFACTURER UNDER CASE FILE # 1-384-309-432. *AK UPDATED 01/25/06. *JB

LEAKAGE OF OIL AND COOLANT DUE TO THE FAILURE OF A LOWER INTAKE MANIFOLD GASKET. CAUSED A MIXTURE OF COOLANT AND OIL THAT REQUIRED A COMPLETE FLUSH OF THE COOLANT SYSTEM, REPLACEMENT OF COOLANT, OIL FILTER, AND OIL CHANGE. COST OF THE REPAIR WAS OVER $900.00. *NM

DT: THE CONTACT STATED THE ENGINE OVERHEATED DUE TO LEAKING OF COOLANT. THE COOLANT HAD TO BE ADDED WEEKLY. SHE TOOK THE VEHICLE TO A DEALER, WHO DETERMINED THIS WAS A PROBLEM WITH THE INTAKE MANIFOLD GASKET, WHICH WAS REPLACED. *AK

DT: THE CONTACT STATED THE VEHICLE CONTINUED TO ACCELERATE AFTER RELEASING THE GAS PEDAL. THE FIRST TIME WHEN THE PROBLEM OCCURRED THE VEHICLE WORKED PROPERLY AFTER TAPPING THE GAS PEDAL. AFTER THE THIRD TIME THE VEHICLE WAS TAKEN TO A DEALERSHIP, WHO DETERMINED THAT THE PROBLEM WAS THE THROTTLE STICKING. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. *AK

DT: THE CONTACT HAD THE EGR VALVE, THERMOSTAT, WATER PUMP, INTAKE GASKET, AND HEAD GASKET REPLACED. ADDITIONALLY, SHE HAD THE BLOCK INSPECTED FOR CRACKS. IT HAS BEEN 18 MONTHS SINCE THE REPLACEMENT OF THE AFOREMENTIONED DEFECTS, AND THE CHECK ENGINE LIGHT CAME ON AGAIN ,AND THERE WAS A DECREASE IN THE AMOUNT OF GAS MILEAGE. THE DEALER REPROGRAMMED THE COMPUTER, AND INFORMED THE CONTACT THAT THE VEHICLE WAS RUNNING PROPERLY. THE MANUFACTURER HAS ONLY OFFERED A DISCOUNT ON A NEW VEHICLE.*AK

THIRD REPLACEMENT OF ROTORS AND BRAKES WITHIN 3 YEARS OF OWNING CAR. *JB

FAILURE- SLIGHT LEAK IN COOLANT FROM INTAKE SEAL, CONTINUOUS RUNNING OF FANS, AND CHECK ENGINE LIGHT STAYS ON. CORRECTION- NEW THERMOSTAT, NEW SENSOR FOR THE FANS, AND NEW SEAL FOR INTAKE SEAL, $900 WORTH OF SERVICE. *NM

IT APPEARS THAT GM'S CLAIM THAT IT COMPLETED THE TURN SIGNAL AND HAZARD WARNING SWITCH IS NOT ENTIRELY ACCURATE. MY SIGNAL WARNING RELAY, SITUATED IN THE HAZARD WARNING SYSTEM, HASN'T STOPPED CLACKING FOR NEARLY TWO YEARS. PERHAPS IT IS THE ONE THAT SLIPPED THROUGH THE CRACK. THE PROBLEM IS ONGOING (NOT RESOLVED).

DT: THE CONTACT STATED THE TURN SIGNALS WORK INTERMITTENTLY, AND THEY SEEM TO BE GETTING WORSE. A LOCAL MECHANIC LOOKED AT THE VEHICLE. THERE WAS NHTSA RECALL 03V327000. BUT, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. THIS HAS BEEN HAPPENING FOR APPROXIMATELY TWO YEARS. THERE HAVE BEEN NO REPAIRS FOR THIS PROBLEM AT THIS TIME. *AK

HAZARD FLASHING WARNING LIGHTS DOESN'T WORK AND MY TURN SIGNALS ARE SOMETIMES INOPERATIVE. GM SAID MY VEHICLE IS NOT INCLUDED IN THEY RECALL NO.03043 ALTHOUGH I HAVING SAME KIND OF PROBLEM STATED IN THAT RECALL(NHTSA CAMPAIGN NO.03V327000).*JB

DT: THE VEHICLE HAS COMPLETELY SHUT DOWN FIVE TIMES. THE FIRST TIME WAS IN APRIL OF 2003. THE CONTACT HAD IT TOWED ITO THE DEALERSHIP. THEY TOLD HER THAT THERE WAS A PROBLEM WITH THE IGNITION CYLINDER. THEY REPLACED THE IGNITION CYLINDER. THE THEFT SYSTEM LIGHT CAME ON BEFORE THE VEHICLE SHUTS DOWN. THE SECOND WAS IN JUNE 2004. THE CONTACT HAD JUST PULLED OUT OF DRIVEWAY WHEN IT SHUT DOWN. DEALERSHIP REPLACED THE FUEL PUMP, WHICH DID NOT NEED TO BE REPLACED. THE THIRD TIME WAS IN JULY, 2004 AND THE DEALERSHIP SAID THAT THE BATTERY NEEDED TO BE REPLACED. THE CONTACT HAD THE BATTERY REPLACED. THE FOURTH OCCASION HAPPENED ON OCTOBER 25, 2004. THE DEALERSHIP REPLACED THE IGNITION CYLINDER. IN MARCH OF 2005 THE THEFT SYSTEM LIGHT CAME ON, AND SHE TOOK VEHICLE BACK TO THE DEALERSHIP. THEY TOLD HER THAT THEY COULD NOT DO ANYTHING BECAUSE THERE WAS NO PROBLEM. THE MOST RECENT TIME WAS OCTOBER 4, 2005. SHE HAD IT TOWED TO THE DEALERSHIP, AND THEY REPLACED THE IGNITION CYLINDER AGAIN. THE SERVICE DEALER SAID THAT THE PART WAS KNOWN TO GO OUT BUT, NOT AS OFTEN AS ON CONTACT'S VEHICLE. *AK.

THERE WAS A RECALL ON THE 2001 CHEVY MALIBU FOR TURN SIGNAL/HAZARD LIGHT DEFECT. I HAVE A 2001 CHEVY MALIBU AND I HAD EXPERIENCED THE EXACT SAME PROBLEMS. I CONTACTED GM AND THEY INDICATED THAT MY VIN NUMBER WAS NOT IN THE RECALL AND THEREFORE WILL NOT REIMBURSE ME FOR THE COST OF HAVING MY TURN SIGNALS/HAZARD LIGHTS REPAIRED. *NM

DRIVER'S SIDE WINDOW SWITCH STALLS BEFORE ROLLING UP. TURN SIGNALS DO NOT WORK ALL THE TIME. INTERNAL FAN SWITCH ONLY WORKS ON 5. IF I TURN THE FAN SWITCH ON OR OFF, TURN SIGNALS WILL START WORKING INSTANTLY. TURN SIGNAL PROBLEM STARTED RIGHT AFTER THE BLOWER WENT OUT. I CANNOT LISTEN TO THE RADIO AND RUN THE REAR DEFROSTER AT THE SAME TIME. THE DRIVER'S SIDE SEAT BELT WILL NOT RELEASE ALL THE TIME WHEN I TRY TO PUT IT ON. THE CAR HAS DIED AS I TRIED TO TURN LEFT AT A STOP LIGHT. THIS WAS A USED CAR WITH LESS THAN 30K MILES WHEN I BOUGHT IT IN MARCH 2005, NO PROBLEMS UNTIL ABOUT MAY. NOW A PROBLEM A DAY SEEMS TO APPEAR. THE CAR NOW HAS 39K MILES ON IT AND MY HUSBAND WANTS ME TO TRADE IT IN ALREADY BECAUSE HE SAYS IT IS GOING TO "NICKEL AND DIME US TO DEATH". I HAVE SEEN SEVERAL OF THESE PROBLEMS ON RECALL SITES, BUT THE DEALER SAID THAT MY VIN WAS NOT INCLUDED IN THE RECALL. *JB

WE WERE TOLD THIS IS BECOMING A COMMON PROBLEM THAT WE LOSE THE COOLANT INTAKE ON THE ENGINE OF OUR 01 MALIBU RESULTING IN A $1000 REPAIR - THIS DEALER HAS EXPERIENCED MULTIPLE FAILURES ON THIS PARTICULAR ENGINE. *NM

POWER STEERING PUMP REPLACED. HIGH RESISTANCE TO TURNING LEFT. OFTEN UNABLE TO TURN THE WHEEL AS MUCH AS INTENDED WITH THE MAXIMUM PINION SHAFT MOVEMENT. WHEN TURNING LEFT POWER STEERING IS NON EXISTING WITH EXTREME POWER TO MANEUVER STEERING TO COMPLETE THE LEFT TURN. THE RIGHT TURNING STEERING IS EXTREMELY LOOSE. THE FAILURE IS DUPLICATIVE OF THE RECALL OF THE 1997 AND 1998 MALIBU. *NM

THE FRONT DISC BRAKE ROTORS WERE WARPED TO THE POINT WHERE THEY NEEDED TO BE REPLACED ON THREE SEPARATE OCCASIONS APPROXIMATELY 8K MILES APART. *NM

DT WHEN STARTING THE VEHICLE IN THE MORNING ONE COULD HEAR A METAL PINGING SOUND COMING FROM THE MOTOR. IT WILL RATTLE FOR A MILE OR TWO AND THE NOISE WILL QUIETLY LOWER ITSELF. NOTICED THIS ON JULY 1, 2005. THIS VEHICLE ONLY HAD 40,000 MILES ON IT. HAD IT DIAGNOSED AT THE DEALERSHIP, AND THEY CONFIRMED THAT IT HAD A PISTON SLAP IN THE MOTOR. *AK

1. NORMAL DRIVING 2. TURN SIGNALS FAILED 3. THERE IS A RECALL FOR THIS EXACT PROBLEM ON OTHER VINS THE SAME YEAR, MAKE AND MODEL RECALL #03V327000. *NM

YES I HAVE A CHEVORLET MALIBU 2001 .I TOOK IT BOB RICHARD CHERVOLET BECAUSE SOMETHING WAS ALWAYS WRONG WITH THE ANTI THEFT SYSTEM AND EVERY TIME THEY FIX IT THEY SAID IT WILL NEVER HAPPEN AGAIN . IT HAPPEN AGAIN. THIS IS THE FIFTH TIME IT HAPPEN . HOW I KNOW IT IS THE ANTI THEFT SYSTEM. BECAUSE THE SAME PROBLEM HAPPEN FOUR TIME ALREADY. FIRST OF ALL I'M PAYING CLOSE TO 23,000 FOR THIS CAR THE CAR WAS 14,700 BUT WITH THE FINANCE CHARGES IT COSTING ME 23,000 I AM READY TO GIVE THIS CAR UP BECAUSE OF THE SAME PROBLEM . I JUST DON'T KNOW WHAT TO DO PLEASE HELP. *JB

CAN'T KEEP CAR ALIGNED. TECHNICIANS SAID THAT THEY HAVE ENCOUNTERED THIS WITH OTHER MALIBU'S. THEY CAN'T DO ANY MORE TO KEEP ALIGNMENT IN PLACE. WE DID A TEST BY ALIGNING CAR AND GOING BACK IN 2 WEEKS AND ALIGNMENT HAS ALREADY DEVIATED FROM SET POINTS.*JB

I HAD TO REPAIR A MANIFOLD INTAKE GASKET, LEAKING WATER. . I HAVE TALKED TO SEVERAL AUTO REPAIR SHOPS AND THEY SAID THIS IS A COMMON PROBLEM ON THESE CHEVY MALIBUS. THE CHEVY CO. SHOULD HAVE TO DO A RECALL ON THIS PROBLEM. UNFAIR THAT THE CONSUMER HAS TO PAY THE BILL TO HAVE THIS FIXED. PLEASE CHECK INTO FORCING A RECALL ON THIS PLEASE. *NM

A SLOW RADIATOR LEAK WAS OBSERVED OVER A PERIOD OF 2 MONTHS. I TOOK IT TO A MECHANIC WHO DIAGNOSED A FAULTY INTAKE MANIFOLD GASKET. HE HAD MENTIONED THAT IT IS A VERY COMMON PROBLEM IN THE MALIBU, EVEN THOUGH GM TOLD ME THAT IT WAS NOT. THE MANIFOLD GASKET WAS REPLACED BEFORE ANY ANTI-FREEZE LEAKED INTO THE ENGINE.*JB

WHILE DRIVING HOME FROM WORK IN 90+ DEGREE HEAT MY CAR OVERHEATED TO THE POINT WHERE I HAD TO HAVE IT TOWED IN AND WAS TOLD BY THE MECHANICS THAT MY COOLANT HAD BEEN LEAKING AND CAUSING THE CAR TO OVER HEAT THERE BLOWING THE HEAD GASKET AND CAUSING ME TO HAVE TO PAY $1200.00+ TO HAVE ANOTHER ENGINE PUT IT. I HAVE HEARD THIS IS A COMMOM WITH THE 2001 CHEVROLET MALIBUS. I DON'T KNOW WHAT THE REPAIR SHOP DONE WITH THE OLD MOTOR, BUT IT WAS FRIED.

TURN SIGNALS ON MY 2001 CHEVY MALIBU STOPPED WORKING. THE BULBS AREN'T BURNED OUT SO MUST BE AN ELECTRICAL PROBLEM (I'M GUESSING) AT FIRST THE SIGNALS WOULD WORK FOR A FEW DAYS THEN STOP FOR A DAY BUT NOW ITS BEEN 4 DAYS AND THE SIGNALS DON'T WORK AT ALL. ALSO THE AIR CONDITIONING SYSTEM DOESN'T "BLOW" ON LEVELS 1-4 ONLY ON LEVEL 5.

CAR WOULD TURN OVER ONCE AND IMMEDIATELY SHUT DOWN. ANT-THEFT LIGHT WOULD BE ON. HAD TO HAVE CAR TOWED TO GARAGE. THEY COULD FIND NOTHING TO EXPLAIN WHAT HAPPENED AND RESET ANTI-THEFT SYSTEM AND RELEASED THE CAR. ALL AT A COST OF APPROXIMATELY $200. THIS IS 2ND TIME IT HAS HAPPENED. FIRST INCIDENT COST $100. IT IS FRUSTRATING BECAUSE YOU CAN NEVER PREDICT WHEN/WHERE IT WILL HAPPEN. FROM RESEARCH I HAVE DONE IT SEEMS THAT OTHER PEOPLE HAVE HAD SIMILAR PROBLEM AND REPLACING IGNITION SWITCH/ANTI-THEFT SYSTEM DOES NOT HELP EITHER. HAVE LOST ALL CONFIDENCE IN MY CAR!

DT: CONTACT STATES WHILE DRIVING THE VEHICLE OVERHEATED, CAUSING IT TO STALL. THE TEMPERATURE GAUGE WENT UP VERY LITTLE BEFORE THE TEMPERATURE GAUGE READ COMPLETELY HOT. VEHICLE WAS TAKEN TO SERVICE DEALER, WHO STATED THAT INTAKE MANIFOLD GASKET FAILED, WHICH CAUSED THE HEAD GASKET TO FAIL, LEADING TO THE WARPING OF THE CYLINDER WALL AND HEAD. THE ENTIRE MOTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS LOOKING INTO THIS MATTER. *AK

THE TURN SIGNALS WORK OFF AND ON ,I NEVER KNOW IF THEY WILL WORK OR NOT .IF THEY DON'T WORK I FOUND IF YOU PUSH ON THE EMERGENCY FLASHER SWITH THEY MIGHT COME ON. THIS CAR WAS RECALLED FOR THIS PROBLEM BUT THE DEALER SAYS IT DOESN'T INCLUDE MY CARS VIN THE NHTSA CAMPAIGN ID NUMBER IS 03V327000

ABS SYSTEM FAILURE ABS ACTIVATES WITH OUT WARNING EVEN IF THE BRAKES ARE NOT APPLIED

2001 CHEVROLET MALIBU HAS DEVELOPED PROBLEMS WITH THE BRAKING AND THE COOLING SYSTEMS.***NO ANSWER REQUIRED***. *MR ONE MONTH AFTER THE VEHICLE WAS PURCHASED THE ROTOR ASSEMBLY WAS REPLACED. THE VEHICLE WOULD TURN OVER BUT IT WOULDN'T START. THE DEALER REPLACED THE FUEL PUMP. WHEN ACCELERATING THE VEHICLE'S COOLANT LIGHT ILLUMINATED ON THE DASH. THE DEALER DETERMINED THAT THERE WAS A LEAK AT THE BY PASS PIPE AT THE LOWER INTAKE MANIFOLD. THE ALTERNATOR WAS REPLACED UNDER WARRANTY. THE HAZARD AND TURN SIGNAL SWITCH WERE REPLACED. THE RIGHT OUTER TIE ROD WERE WORN LOOSE. THE DEALER REPLACED THE RIGHT OUTER TIE ROD ENDS AND SET THE FRONT END. THE RIGHT FRONT WHEEL BEARING WAS REPLACED. THE ABS MALFUNCTIONED. *NM

MY CHEVY MAILBU 2001 VIN # [XXX] THE THEFT SYSTEM ALARM SETS ITSELF AND TO RESET IT YOUR HAVING TO WAIT TEN MINUTES. I GOT ON THE INTERNET TO SEE IF ANYONE ELSE WAS HAVING A PROBLEM. I FOUND THAT MOST ALL CHEVY'S FROM THE YEAR 1998 TO 2005 ARE HAVING THE SAME PROBLEM. ONE PERSON SAID THAT IS ALARM SET ITSELF WHILE ON THE FREEWAY DOING 60 MPH SHUT ITSELF OFF. IF THAT'S NOT A SAFETY HAZARD I DON'T KNOW WHAT IS. I WOULD NOT WANT THAT TO HAPPEN TO ME. CAN SOME ONE DO SOMETHING ABOUT THIS THEFT ALARM SYSTEM CHEVY IS PUTTING IN THEIR CARS? IT'S VERY FRUSTRATING. I COULD ONLY WISH SOME ONE WOULD STEAL THE CAR. IT'S A BIG PAIN AND WOULD OF NEVER BOUGHT A CHEVY IF I NEW THIS!*JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DT: WHEN GOING OVER A RAILROAD TRACK OR A MAN HOLE, CONSUMER'S CAR SHUT DOWN. THE VEHICLE STEERING AND BRAKES LOCKED UP AND THE CONSUMER HAD TO MANUALLY MANEUVER THE VEHICLE AND PUT IT IN PARK.*AK *SB *NM

DT: CONSUMER'S VEHICLE TURN SIGNAL WOULD OPERATE INTERMITTENTLY. IT WORKED SOME TIMES, AND SOME TIMES IT WOULD NOT WORK. CONSUMER FIXED, IT WAS AN OPEN CIRCUIT IN THE HAZARD SWITCH. WHICH FAILED. CONSUMER KNEW OF NHTSA RECALL 03V327000 ON SAME MAKE/ MODEL, AND YEAR, BUT CONSUMER'S VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

DT: ON THE 2001 CHEVROLET MALIBU THE RUBBER ON TAIL LIGHT DETERIORATED, RAIN COLLECTED IN TAIL LIGHT, AND DRIVER'S SIDE TAIL LIGHT FAILED DUE TO THIS PROBLEM. CONSUMER RECEIVED TWO TICKETS AS A RESULT.*AK

CAR HAS VIBRATIONS AT HIGHER SPEEDS 60+ WAS TOLD IT WAS TIRES/WHEELS THEY WERE REPLACED FOR $280 FOR TIRES AND $200 FOR JUST STEEL RIMS. CAR STILL VIBRATED AT HIGH SPEEDS AND ALSO FELT LIKE ROTORS NEEDED TO BE REPLACED-THE KIND OF VIBRATING WHEN BRAKING. REPLACED ROTORS AND BRAKE PADS $49 A PIECE FOR ROTORS AND $40 A PIECE FOR BRAKE PADS. CAR CONTINUED TO VIBRATE EXCEPT WHEN STOPPING. AFTER TIME NOW (3 MOS) WHEN THE CAR IS VIBRATING AND YOU GO TO SLOW DOWN IT SHAKES THE CAR EVEN WORSE. WAS THEN TOLD TO REPLACE THE WHEEL BEARINGS. JUST DID THAT YESTERDAY THEY COST ME $230 NOT ONLY DOES THE CAR STILL VIBRATE IT HAS A GRINDING NOISE WHEN YOU TRUN TO THE RIGHT NOW. SINCE IVE BOUGHT IT IT HAS VIBRATIONS AT HIGH SPEEDS AND A "RUBBING" VV, VV, VV NOISE WHEN TURING RIGHT. AFTER REPLACING WHEEL BEARINGS THE CAR STILL MAKES ALL THE NOISES AND GRINDS NOW. DONT KNOW WHAT ELSE TO DO TO FIX IT, BEGINNING TO THINK IM JUST GOING TO HAVE TO REPLACE THE ENTIRE FRONT END. REALLY USED TO TRUST CHEVY NOW IM NOT SO SURE. I HAVE HAD WAY TOO MANY PROBLEMS WITH THIS CAR AND I JUST BOUGHT IT IN JULY2004- RIDICULOUS IF YOU ASK ME.

WENT TO CRANK CAR AND IT WOULD NOT CRANK ANTI THEFT LIGHT WAS ON. THIS IS THE 4TH TIME THAT THIS HAS HAPPENED AND EACH TIME I HAVE TO SPEND 300.00 PLUS DOLLARS TO GET IT FIXED. CHEVY SHOULD BE RESPONSIBLE FOR THIS. LAST YEAR I HAD THE SAME THING REPLACED 3 TIMES AND NOW HERE IT IS AGIAN.

I HAD TO HAVE THE FUEL INJECTOR CLEANED ABOUT AYR AFTER I GOT THE CAR? NOW I AM TOLD I HAVE TO HAVE IT DONE AGAIN! ALSO THE ENGINE IS LEAKING ANDTHE COOLANT SYSTEM. I HEAR IT MIGHT NOT HAPPEN AGAIN AS GM MADE NEW PARTS FOR THE ENGINE SO IT SHOULDN'T HAPPEN AGAIN. MY MECHANIC FEELS THE ENGINE SHOULD HAVE BEEN RECALLED. HE ALSO TOLD ME THAT I SHOULD HAVE BROUGHT THE CAR TO HIM WHEN THEY DIAGNOSED THE CAR AS NEEDING THE FUEL INJECTOR CLEANED THE FIRST TIME---IT SHOULDN'T HAVE NEEDED IT AND PROBABLY DIDN'T. I FEEL I MAY BE TAKEN ADVANTAGE OF AGAIN BY THIS DEALERSHIP. I HOPE THIS CAR IS RECALLED FOR THE WRONG OR BAD ENGINE ITTING PARTS. I WAS ONE WHO REPLACED THE HAZARDS BEFORE IT WAS EVER RECALLED-I COULD HAVE BEEN KILLED THE WAY THEY WERE ACTING HALF HAZARDLY! I DID AND THEN THIS SAME DEALERSHIP TOLD ME THAT I HADN'T THAT THE WRONG PART-THE OLD PART WAS PUT IN THE CAR AND REPLACED IT. THIS IS DELAND CHEVROLT/CADILLAC IN DELAND FL. THEY SAID THEY REPLACED IT WITH THE RIGHT PART BUT I DOUBT THEY DID.

AC AUTOMATICALLY SWITCHES FROM INTERNAL CIRCULATION TO VENT INTERMITTENTLY

2001 CHEVROLET MALIBU EXPERIENCING PROBLEMS WITH THE VEHICLE NOT STARTING. THE CONSUMER HAS HAD THE ANTI-THEFT SYSTEM, AND THE IGNITION SWITCHES REPLACED. *MR CONSUMER STATED THE THEFT LIGHT COMES ON AND VEHICLE DOES NOT START. *BF *NM

TYPE OF VEHICLE- 2001 CHEVY MALIBU ON AT LEAST 5 OCCSASIONS, THE VEHICLE HAS FAILED TO START. THE BATTERY IS OK, AS ALL ACCESORIES ORK PERFECT. THE CAR HAS HAD FUEL, AND WE ACTUALLY REPLACED THE FUEL PUMP, JUST TO SEE IF THIS WAS THE PROBLEM. IT WILL ACT AS THOUGH IT WANTS TO START. I HAVE HAD AN AUTOMOTIVE TECHNICIAN TRY TO SEE WHAT IT IS BY HOOKING UP TO A DIAGNOSTICS MACHINE, ALTHOUGH AS QUICK AS IT IS RELEASED FROM THE WHEEL DOLLY, IT STARTS, AS IF JARRING THE CAR MAKES A DIFFERENCE. IN LIGHT OF THIS WE ARE UNABLE TO LOCATE THE PROBLEM, ALTHOUGH WE KNOW IT IS LIKELY RELATED TO A MISFIRING OF A WIRE TO THE COMPUTER. AFTER HOOKING UP TO MACHINE WHEN IT STARTS, NO FAULT CODES ARE SHOWN. IT IS VERY FRUSTRATING. THE ENGINE WILL CRANK, FUEL PRESSURE OK. IGNITION SYSTEM PLUGS AHVE FIRE. ALL NORMAL SYSTEMS ARE GOOD, HOWEVER ENGINE WILL NOT FIRE.

I HAVE RECENTLY HAD TO TAKE MY CAR TO THE MECHANIC TO GET FIXED. IT WAS LEAKING THE ENGINE COOLANT AND THE MANIFOLD GASKET HAD TO BE REPLACED WHICH COST OVER $800 TO FIX. NOW , THE CHECK ENGINE LIGHT IS ON AND THAT WILL BE ANOTHER EXPENSE THAT I WILL HAVE TO MAKE ON A 4 YEAR OLD 26,000 MILE CAR.