2006 Chevrolet HHR complaints

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE PARKED, THE CONTACT ATTEMPTED TO OPEN THE FRONT DRIVER SIDE DOOR FROM THE INTERIOR OF THE VEHICLE BUT THE DOOR HANDLE DETACHED ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,900. UPDATED 01/20/12*LJ THE CONSUMER STATED THE ENTIRE DOOR PANEL NEEDED TO BE REPLACED, JUST FOR AN EXPENSIVE HANDLE. UPDATED 01/27/12

DRIVING VEHICLE CITY STREET MAKING TURN POWER STEERING MESSAGE CAME ON POWER STEERING FAILED .PULLED OVER TO SAFE AREA SHUT OFF VEHICLE RESTARTED POWER STEERING FUNCTIONAL FOR A FEW MILES FAILED AGAIN WITH MESSAGE THIS IS A CONSTANT PROBLEM. *TR

THE ELECTRIC STEERING WILL SHUT DOWN AND THE MESSAGE CENTER ON THE DASH WILL SHOW "POWER STEERING" AND THE VEHICLE BECOMES VERY HARD TO STEER. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WAS DEPRESSED AND THE PEDAL WENT TO THE FLOORBOARD ABNORMALLY. THE FAILURE CAUSED THE DRIVER TO CRASH INTO ANOTHER VEHICLE FROM THE REAR. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY AND THE DRIVER WAS INJURED. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND DEEMED AS DESTROYED. THE POLICE STATED THAT THE AIR BAGS SHOULD HAVE DEPLOYED AND THE INSURANCE COMPANY PLANNED TO INSPECT THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 106,000.

BRAKE PEDAL ASSEMBLY: AT THE UPPER BRAKE PEDAL, AT THE CROSS TUBE THERE WAS A DEFECTIVE WELD, ONLY WELDED ON ONE SIDE AND THE WELD DID NOT ADHERE TO CROSS BAR. THE WELD DID NOT PENETRATE METAL, CAUSING THE PEDAL TO SLIDE TO THE LEFT. *KB

AS I WAS EXITING THE FREEWAY I HEARD A CHIME AND POWER STEERING CAME ON THE INFO PANEL AS I MADE A TURN TO FIND OUT WHAT WAS WRONG I FOUND TURNING THE WHEEL TO BE EXTREMELY DIFFICULT AND AS THE POWER ASSIST MOTOR IS THE SAME AS A RECALLED MOTOR (CHEVY COBALT) I FEEL CHEVY SHOULD RECALL HHR AS WELL. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS DRIVING 50 MPH AND LOST CONTROL OF THE VEHICLE DUE TO THE POWER STEERING SYSTEM MALFUNCTIONING. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT THE DEALER COULD NOT LOCATE A FAILURE WITH THE POWER STEERING SYSTEM AND ADVISED THAT THE VEHICLE WAS SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 77,351.

MY GEAR SHIFTER IS MALFUNCTIONING. IT IS STUCK IN PARK. I DO NOT HAVE RELIABLE TRANSPORTATION AND WOULD LIKE THIS REPAIR TO BE ON THE RECALL LIST WITH CHEVY BEING THAT THERE ARE A MULTITUDE OF COMPLAINTS ABOUT THE GEAR SHIFTER. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT NOTICED AFTER RAINY WEATHER THAT THERE WAS A SUBSTANTIAL AMOUNT OF WATER ON THE FRONT PASSENGER SIDE FLOORBOARD OF WATER WAS AT LEAST FOUR INCHES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE WATER LEAK COULD POSSIBLY HAVE COME FROM THE FRONT WINDSHIELD OR SUN ROOF. IN ADDITION, THERE WAS AN INTERMITTENT LOSS OF POWER STEERING. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE DEFECTS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 27,000. THE VIN WAS UNAVAILABLE.

THIS IS THE SECOND TIME IN TWO YEARS AND 7 MONTHS THAT THE DOOR HANDLE (INSIDE DRIVERSIDE FRONT) HAS BROKEN. THE DOOR HANDLE IS MADE OF SOME TYPE PLASTIC. THIS IS NOT ONLY A EXPENSIVE TO REPLACE AT THE DEALER, IT IS ALSO A SAFETY HAZARD IN GETTING OUT OF THE VEHICLE IF THERE WERE AN ACCIDENT. *TR

I PUT MY CAR IN PARK AND WHEN I WENT TO TAKE THE KEY OUT OF THE IGNITION IT WOULD NOT COME OUT. I REALIZED THAT THE KEY WOULD NOT COME OUT BECAUSE THE GEAR SHIFTER PIECE WAS PUSHED ALL THE WAY IN, IT WAS BROKE. THIS MEANT THAT MY CAR WAS LEFT ON AND THE BATTERY WAS DRAINED BECAUSE I COULD NOT TURN MY CAR OFF. NOW MY CAR WILL NOT START AT ALL THE BATTERY IS CHARGED BUT THE CAR WILL NOT TURNOVER. I HAVE LOOKED ONLINE AND HAVE FOUND THAT THERE ARE MANY COMPLAINTS CONCERNING THE SAME PROBLEM WITH THIS VEHICLE. I AM TOLD BY THE DEALERSHIP THAT I HAVE TO PAY $710 TO HAVE THIS PROBLEM FIXED. CAN YOU PLEASE LOOK INTO THIS BECAUSE THIS SEEMS TO BE A BIG PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 45 MPH, THE POWER STEERING CHIME SOUNDED WITH THE WARNING INDICATOR ILLUMINATION. IMMEDIATELY THERE WAS A COMPLETE LOSS IN THE POWER STEERING. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD WITH DIFFICULTY IN TURNING THE STEERING WHEEL. THE ENGINE WAS TURNED OFF AND UPON RESTARTING THE POWER STEERING BEGAN TO FUNCTION NORMALLY. THE FAILURE OCCURRED ON SIX DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DUPLICATE THE DEFECT. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 43,000. THE VIN WAS UNAVAILABLE. UPDATED 12/12/11*LJ UPDATED 12/14/11

KEY DOESN'T COME OUT OF IGNITION, BLINKERS DO NOT TURN OFF ON OWN. HAVE TO MANUALLY TURN OFF BLINKERS. KEY GET STUCK IN IGNITION, LUCKILY WENT ONLINE TO SEE ABOUT THE PROBLEM AND FOUND HUNDREDS OF PEOPLE WITH SAME ISSUE. A QUICK VIDEO SHOWED ME THAT THE DEFECT HAPPENS TO A LOT OF PEOPLE AND YOU HAVE TO GO UNDER THE STEERING COLUMN AND POP OFF A COVER AND MANUALLY PUSH A LITTLE BUTTON TO POP THE KEY OUT OF THE IGNITION, THE CAR WILL CONTINUE TO RUN,IF YOU DON'T DO THIS! *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION AND THE VEHICLE COULD NOT BE TURNED OFF. THE CONTACT HAS TO CONTINUOUSLY MOVE THE SHIFTER THROUGH THE GEARS AND TURN THE VEHICLE ON AND OFF SEVERAL TIMES BEFORE THE KEY COULD BE RELEASED FROM THE IGNITION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 34,000 AND THE CURRENT MILEAGE WAS 35,000.

I HAVE A 2006 HHR AND THE PLASTIC DOOR HANDLE ON THE DRIVER'S SIDE HAS BROKEN OFF. I HAVE TO LEAVE MY CAR RUNNING , ROLL THE WINDOW DOWN, STICK MY HAND OUT OF THE WINDOW, OPEN THE DOOR FROM THE OUTSIDE, ROLL MY WINDOW BACK UP AND THEN KILL THE MOTOR. I, TOO, WAS TOLD IT WOULD COST $400.00 TO REPLACE THE DOOR PANEL. THIS IS A TOTAL RIPOFF!!!!!!!!!!!. GM/CHEVROLET OR WHOEVER MANUFACTURED THIS CAR SHOULD BE ASHAMED FOR PUTTING IN A CHEAP PIECE OF PLASTIC. THERE SHOULD BE ANOTHER WAY TO FIX THIS WITHOUT PUTTING OUT $400/$500 FOR A BROKEN PIECE OF PLASTIC! AND THAT PROBABLY DOES NOT INCLUDE TAX AND LABOR! *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE INTERIOR DOOR HANDLE FRACTURED AND THE CONTACT HAD TO OPEN THE DOOR FROM THE EXTERIOR DOOR HANDLE. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE CONTACT STATED THE ENTIRE DRIVER SIDE DOOR PANEL NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 69,000.

THE ELECTRIC POWER STEERING HAS FAILED INTERMITTENTLY OVER THE PAST MONTHS SINCE JULY 4, 2011. THE FIRST INCIDENT WAS ON JULY 4, 2011 WHEN THE POWER STEERING FAILED ON A FAMILY TRIP ALMOST CAUSING AN ACCIDENT AT 65 MPH. THERE HAVE BEEN UP TO A DOZEN INSTANCES SINCE WITH THE LATEST BEING ON OCT 2, 2011 CAUSING MY WIFE TO RUN OFF THE INTERSTATE INTO THE MEDIAN. GM CLAIMS THERE IS NO RECALL, HOWEVER THERE ARE RECALLS FOR THE SAME EXACT ELECTRIC POWER STEERING MOTORS FOR THE COBALTS FROM GM. THE HHR'S NEED TO BE A PART OF THIS RECALL AS THE MOTOR IS THE SAME EXACT ONE AS THE COBALT. PLEASE RECALL THESE ALSO BEFORE SOMEONE GETS HURT OR WORSE. THE INTERNET SITES ARE FILLED WITH COMPLAINTS ON THIS ISSUE. *TR

SUDDEN LOSS OF ELECTRIC POWER STEERING ASSIST IMMEDIATELY UPON STARTING 2006 CHEVY HHR (150,000 MILES). VEHICLE WAS IN PARK WHEN PROBLEM BEGAN. "POWER STEERING" MESSAGE APPEARED ON DASH. VEHICLE WAS REPEATEDLY SHUT OFF AND RESTARTED. MESSAGE HAS DISAPPEARED, YET PROBLEM PERSISTS. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS DRIVING 45 MPH WHEN THE POWER STEERING ASSIST SYSTEM MALFUNCTIONED, MAKING THE VEHICLE DIFFICULT TO STEER. THE CONTACT PULLED OVER AND SHUT THE VEHICLE OFF. THE CONTACT RESTARTED THE VEHICLE AND THE POWER STEERING WAS OPERATING AS NORMAL. AFTER DRIVING SEVERAL MILES, THE POWER STEERING SYSTEM MALFUNCTIONED A SECOND TIME. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE CONTACT BELIEVED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 83,000.

KEY STUCK IN IGNITION, KEY WILL NOT TURN TO OFF POSITION TO ALLOW REMOVAL OF KEY. HAVE TO USE "COLUMN LOCK RELEASE" ON STEERING COLUMN TO TRIP PLUNGER TO ALLOW REMOVAL OF KEY. HAVE SERVICE APPOINTMENT AT JIM SIGEL CHEVROLET. GRANTS PASS, OREGON. FOR SEPT. 19. 2011 ( NEXT MONDAY ) FOR COMPLETE REPLACEMENT OF THE SHIFTER (AUTOMATIC TRANS. ) POSTS ON THE INTERNET INDICATE 6 OUT OF 10 HHR'S HAVE THIS FAILURE. THIS VEHICLE IS BEYOND THE CALENDAR WARRANTY OF 36 MONTHS. BUT IT SURE IS UNDER THE MILEAGE WARRANTY OF 36000. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE PLASTIC DOOR HANDLE FRACTURED. AS A RESULT, THE CONTACT WAS UNABLE TO OPEN THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE ENTIRE DOOR PANEL WOULD NEED REPLACING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO COVER 25 PERCENT OF THE REPAIR COSTS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

2006 DOOR HANDLE BROKE FOR NO REASON. IS UNABLE TO OPEN FROM INSIDE. ITS A SEFETY ISSUE IF U HAVE TO GET OUT IN AN EMERGENCY. *TT

THE POWER STEERING DOESNT WORK ANYMORE, BOTH OF THE FRONT INSIDE DOOR HANDLES BROKE OFF, WATER LEAKING IN PASSENGER FRONT COMING FROM THE MOTER AREA SOMEWHERE I CALLED THE DEALERSHIP BUT NO RECALLS AND I HAVE READ ON NUMORUS FORUMS OF OTHER PEOPLE HAVING THE SAME PROBLEM BUT GM STILL HASN'T ISSUED A RECALL. *TT

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE PARKED, THE INTERIOR DRIVERS SIDE DOOR HANDLE DETACHED FROM THE VEHICLE. AFTER OPENING THE WINDOW, THE CONTACT WAS ABLE TO OPEN THE DOOR FROM THE EXTERIOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TEST AND THE TECHNICIAN STATED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. UPDATED 10/4/11 *CN UPDATED 10/26/11 IN DECEMBER 2013, THE DRIVER'S SIDE SEAT BELT FASTENER JAMMED AND WOULD NOT RELEASE. THE CONSUMER HAD THE DEFECT REPAIRED. IN MARCH 2014, SUDDENLY, WITHOUT WARNING, THE VEHICLE LOST POWER STEERING. THE CONSUMER PAID TO HAVE THE DEFECT CORRECTED. UPDATED 04/14/14

I AM THE SECOND OWNER OF A 2006 CHEVY HHR. CURRENT MILEAGE IS APPROXIMATELY 45500. THREE WEEKS AGO ( 8/14/'11)THE INSIDE DRIVER'S SIDE FRONT DOOR HANDLE BROKE. WHEN I WENT TO REPAIR THE BROKEN HANDLE, I WAS ADVISED THAT IT IS AN INTEGRAL PART OF THE DOOR PANEL, AND WOULD COST OVER $400.00 TO REPLACE. I AM NOT IN A POSITION TO REPLACE SUCH AN EXPENSIVE ITEM; I CAN LIVE WITH ROLLING THE WINDOW DOWN AND OPENING THE DOOR FROM THE OUTSIDE. NOT ONLY IS THIS INCONVENIENT, BUT IT IS A SAFETY HAZARD DUE TO A DESIGN FLAW. IF I NEED TO EXIT THE VEHICLE IN A HURRY, I CANNOT DO SO.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT HANDLE DETACHED FROM THE FRONT DRIVER SIDE DOOR WHEN ENTERING THE VEHICLE. THE SAME FAILURE OCCURRED A MONTH PRIOR TO THE RECENT FAILURE ON THE FRONT PASSENGER SIDE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,500 AND THE CURRENT MILEAGE WAS 74,600.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 5 TO 10 MPH, THE DRIVER SIDEDOOR WOULD SPORADICALLY OPEN. THE DOOR WAS CLOSED BUT LATER, THE CONTACT WAS UNABLE O RE-OPEN THE DOOR FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HIM THAT THERE WAS A PIECE OF PLASTIC INSIDE THE PANEL THAT NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 113,000. THE VIN WAS UNAVAILABLE.

GM HAS RECALLED THE COBALT AND OTHER CARS BUILT BETWEEN 2005 AND 2010 WITH A POWER STEERING PROBLEM. THE POWER STEERING IN MY HHR IS BUILT ON THE SAME PLATFORM WITH THE SAME PARTS . BUT GM DID NOT INCLUDE THE HHR . THEY DID SENT A LETTER TO 2006 HHR CANADIAN OWNERS TO FIX THE PROBLEM . WHY NOT IN THE US? THE POWER STEERING STOPS OPERATING AND THE STEERING BECOMES VERY HARD. YOU HAVE TO STOP AND TURN THE CAR OFF TO RESET THE STEERING. THEN IT HAPPENS AGAIN WITH NO WARNING. THERE ARE A LOT OF HHR'S WITH THIS PROBLEM . VERY UNSAFE. AGAIN, THEY WILL FIX THE CARS IN CANADA BUT NOT IN THE USA ? THEY ARE THE EXACT SAME CARS.

I AM SCARED, FOR MY FAMILY'S SAFETY FEAR THAT THIS VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE...WHEN A VEHICLE STALLS YOU LOOSE ALL POWER...THAT IS POWER STEERING, BRAKES.....THE ABILITY TO MAINTAIN CONTROL OF YOUR VEHICLE I AM ATTACHING A LINK THAT GM SHOULD REVIEW.....DANGER THIS VEHICLE IS AN ACCIDENT WAITING TO HAPPEN !!!!!!!!!!!!! COPY THIS LINK TO YOUR WEB BROWSER HTTP-//ABCLOCAL.GO.COM/WTVD/STORY?SECTION=NEWS/ABC11_INVESTIGATES&ID=6811236 IF YOU WOULD PREFER I CAN SEND A TYPED TRANSCRIPT (WORD FOR WORD) OF THIS NEWS BROADCAST? I WILL NOT ALLOW MY WIFE AND KIDS LIFE TO BE PUT IN DANGER, BY LETTING THEM RIDE IN THIS VEHICLE THIS VEHICLE IS UNSAFE AND SHOULD BE RECALLED THE LINK I AM ATTACHING SHOWS A NEWS BROADCAST IN RALEIGH NC. ON CHANNEL 11 NEWS !!!!! INVOLVING NUMBER 12 ISSUE ON MY LONG LIST BELOW WITH THE CHEVY HHR STALLING WHILE DRIVING..... I PURCHASED A 2006 CHEVY HHR LT, IN 2007. SINCE I HAVE PURCHASED THIS VEHICLE THE FOLLOWING ISSUES HAVE OCCURRED. MILEAGE ON CAR 33,346 1) THE KEY LOCKED UP IN IGNITION..9/06/07 2) SHIFTER FROZE UP AND WOULD NOT COME OUT OF PARK. . 9/06/07 3) HEADLINER TRIM ? ENERGY ABSORPTION CAPABILITY 4) FRONT END AND WHOLE CAR STARTED TO SHAKE WHEN APPLYING BRAKE..9/06/07 DEALER TURNED ROTORS( BUT DID NOT FIX ISSUE) 5) REPLACED DRIVER SIDE RUNNING BOARD..9/06/07. 6) GOT IN VEHICLE ONE MORNING TRIED TO TAKE KIDS TO SCHOOL, VEHICLE WOULD NOT GO OVER 15 MPH, HAD TOWED BACK TO LAWSON CHEVROLET. WORKING ON GETTING DATE/MILEAGE..T

DRIVER SIDE INTERNAL DOOR HANDLE BROKE OFF LEAVING THE DOOR INOPERABLE UNLESS THE ELECTRIC WINDOW IS OPENED AND THE HAND PUT OVER THE DOOR AND OPENED ON THE OUTSIDE OF THE CAR. THIS IS ALSO A HAZARD BECAUSE IF THE CAR BATTERY IS DEAD THEN HOW DO YOU GET OUT OF THE CAR? *KB

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING, THE POWER STEERING WOULD GO OUT AT ANY TIME AND THE WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED, BUT DID NOT ASSIST WITH REPAIRS TO THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 103,000 AND THE CURRENT MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN THE VEHICLE WAS SHIFTED INTO PARK, THE GEAR SHIFTER BECAME STUCK AND IT WAS VERY DIFFICULT TO REMOVE THE KEY FROM THE IGNITION. THE CONTACT HAD TO SHAKE THE GEAR SHIFTER IN ORDER TO REMOVE THE KEY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED, BUT THE CONTACT FELT THE GEAR SHIFT ACTUATOR WAS FAILING. THE FAILURE AND CURRENT MILEAGES WERE 55,000.

2006 CHEVY HHR :: PROBLEM :: POWER STEERING MESSAGE ON DASH AND HARD TO STEER, ABS LIGHT ON, TRANSMISSION MAKING CAR BUCK WHILE DRIVING, AND SPEEDOMETER IS BOUNCING. THIS IS THE SECOND TIME IT HAS HAPPENED, LAST TIME DEALER FOUND ONLY "COMMUNICATION CODES" AND DID NOT FIX ANYTHING SO NOTHING WAS COVERED BY THE EXTENDED WARRANTY. THAT WAS 9 MONTHS AGO AT 50140 MILES. *KB

I PURCHASED A 2006 CHEVROLET HHR FOR MY DAUGHTER WITH A 72 MONTHS /100,000 MILES EXTENDED WARRANTY (WHICH HAS ONE YEAR AND SIX MONTHS LEFT). SHE BROUGHT HER CAR HOME FROM SCHOOL ON SUMMER VACATION SAYING THAT HER CAR WAS SHIFTING FUNNY. WE TOOK IT TARR CHEVROLET SERVICE DEPARTMENT BELIEVING THAT WITH OUR EXTENDED WARRANTY THEY WOULD BE ABLE TO FIGURE OUT THE PROBLEM, REPAIR IT, AND ALL WOULD BE GOOD. HOWEVER, THAT WAS NOT THE CASE. IT TOOK THEM TWO WEEKS TO FIGURE OUT THE TRANSMISSION WAS BLOWN. I WAS CALLED TODAY AND HAD WITH A VERY CONFUSING CONVERSATION WITH THE SERVICE MANAGER. I WAS TOLD THAT I HAD TWO OPTIONS FOR GETTING MY CAR REPAIRED. IT WAS EXPLAINED TO ME THAT I COULD EITHER GET A USED TRANSMISSION WITH 33,000 MILES ON IT ALREADY AND IT WOULD BE COVERED BY A ONE YEAR WARRANTY (THE TRANSMISSION THAT JUST BROKE DOWN WITH ONLY 55,000 MILES ON IT). OR I COULD GET A NEW TRANSMISSION AND PAY THE DIFFERENCE OF 1,500.00 DOLLARS WHICH SEEMS UNFAIR TO ME. THIS IS A SHORT SUMMARY OF WHAT HAS TRANSPIRED AND IT IS VERY DISCOURAGING TO MY DAUGHTER AND I. WE WERE WONDERING IF YOU HAD ANY INSIGHT INTO OUR PREDICAMENT. *TR

DRIVERS DOOR IS BROKEN, HAVE TO ROLL WINDOW DOWN TO GET OUT, ALSO, REMOTE IS NOT WORKING, I HAVE TO LOCK/UNLOCK WITH THE HORN HONKING EVERYTIME I PARK. AFTER DOING A SEARCH ONLINE, I FOUND THAT A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM, AND IT SEEMS TO STEM FROM THE FACT, THAT CHEVY HAS DECIDED NOT TO BE BUILT LIKE A ROCK, INSTEAD, BUILT WITH PLASTIC. (CAN YOU EVEN RECYCLE IT?)

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED, THE POWER STEERING WOULD FAIL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE POWER STEERING MOTOR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS 43,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 42,000. UPDATED 9/27/11 *CN ALSO, THE CONSUMER WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION WHEN THE VEHICLE WAS PLACED IN PARK. THE SHIFTER WAS REPLACED. UPDATED 02/01/12

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING THE STEERING WHEEL BECAME DIFFICULT TO TURN WHICH WAS A RESULT OF THE POWER STEERING FAILURE. THE CONTACT STATED THE STEERING WHEEL CONTINUED TO FAIL WITHOUT WARNING AND THE VEHICLE HAD TO BE TURNED OFF FOR FIFTEEN TO TWENTY MINUTES BEFORE THE POWER STEERING RESET ITSELF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE ELECTRONIC POWER ASSIST HAD FAILED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 90,000.

LOSS OF POWER STEERING WHILE DRIVE. LOOSE ABILITY TO STEER AT LOW SPEEDS. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THE POWER STEERING WARNING ILLUMINATED WITH A SUDDEN LOSS OF THE POWER STEERING. THE CONTACT MANEUVERED THE VEHICLE TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF AND RESTARTED AS NORMAL. THE IDENTICAL FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY WERE UNABLE TO DETECT A TROUBLE CODE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE CONTACT STATED THE RECALL UNDER NHTSA CAMPAIGN ID 10V073000 (STEERING:ELECTRIC POWER ASSIST SYSTEM) IS THE FAILURE THAT HE EXPERIENCED . THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE ATTEMPTING TO EXIT THE VEHICLE, THE HANDLE FRACTURED, MAKING IT IMPOSSIBLE FOR THE CONTACT TO EXIT THE VEHICLE FROM THE DRIVER SIDE. THE DEALER DIAGNOSED THAT THE DOOR PANEL WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 25,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE CONTACT STATED THAT THE DOOR HANDLE FRACTURED AND HE WAS UNABLE TO EXIT FROM THE VEHICLE. HE STUCK HIS HAND THROUGH THE WINDOW AND OPENED THE DOOR FROM THE OUTSIDE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT HE WOULD NEED TO REPLACE THE ENTIRE DOOR PANEL. THE MANUFACTURER WAS NOT NOTIFIED NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 25,000.

INSIDE DRIVER SIDE HANDLE BROKE OFF, UNABLE TO OPEN DOOR FROM THE INSIDE THE ELECTRONIC WINDOW MUST BE OPENED AND DOOR OPENED FROM THE OUTSIDE. *TR

KEY STUCK IN IGNITION. UNABLE TO REMOVE WITHOUT USING THE RELEASE BUTTON UNDER THE STEERING COLUMN. TAKEN TO REPAIR SHOP TO SEE WHAT THE PROBLEM WAS. WAS ADVISED THAT THE GEAR SHIFT IS NOT GOING COMPLETELY INTO PARK, THEREFORE THE KEY WILL NOT RELEASE. WAS ALSO ADVISED THAT MY CAR IS NOT LOCKED IN ANY ONE POSITION, SO WHILE DRIVING THE SHIFTER WILL SWITCH FROM DRIVE TO NATURAL. NO WORK DONE TO FOSTLY, CONTACTED DEALER WHO ADVISED SAME ISSUE ON 2009 HHR'S AND THEY ARE BEING RECALLED, BUT MO OPEN RECALL ON 2006 AT THIS TIME. *TT

I WAS DRIVING AND JUST WHEN I WAS ON A CURVED STREET MY CAR LET ME KNOW THAT THERE WAS A PROBLEM WITH THE POWER STEERING. I NEEDED TO ACT FAST TO AVOID AN ACCIDENT DUE TO THE FACT THAT I WAS ON A CURVED STREET. I NEVER HAD PROBLEM WITH THIS ELECTRIC SYSTEM UNTIL THAT DAY. AFTER THIS, I HAVE BEEN DRIVING MY CAR FOR ONE WEEK. THE CAR STILL DOING THE SAME EVERY DAY, BUT THE MAIN PROBLEM IS THAT IT HAPPENS RANDOMLY, SO YOU CAN;T PREDICT WHEN YOU WILL START HAVING A POWER STEERING PROBLEM. ONCE YOU TURN OF THE CAR AND TURN IT ON AGAIN SYSTEM WORKS WELL FOR A WHILE. AGAIN, YOU WILL NEVER KNOW WHEN IT WILL START HAVING THE PROBLEM. HOPEFULLY I WILL GO TO CHECK THE SYSTEM AND FIXED AS SOON AS POSSIBLE. I'M NOT SURE IF THERE IS ANY REPLACEMENT FOR THIS PART IN WHICH I CAN BE CONFIDENT THAT IT WILL NEVER HAPPEN AGAIN. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HER. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE STEERING WHEEL WOULD EXHIBIT A CLUNKING NOISE. THE DEALER WAS CONTACTED AND A DIAGNOSIS WAS PERFORMED, BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS ALSO MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000 AND THE CURRENT MILEAGE WAS 82,000.

THE CAR HAS SEVERAL SAFETY ISSUES. THE MAIN CONCERN IS THAT BOTH OF THE FRONT DOORS HAD THE HANDLES BREAK OFF. YOU CANNOT OPEN THE DOORS FROM THE INSIDE. YOU MUST ROLL DOWN THE WINDOW AND OPEN FROM THE OUTSIDE. IF THE VEHICLE WERE INVOLVED IN AN ACCIDENT OR CAUGHT ON FIRE AND THERE WAS NO POWER TO THE VEHICLE YOU ARE LITERALLY TRAPPED INSIDE. I HAVE BROUGHT THIS TO THE ATTENTION OF CHEVROLET BUT THEY HAVE FAILED TO DO ANYTHING.I FEEL LIKE THE VEHICLE IS A ROLLING DEATH TRAP. THE OTHER CONCERN IS THAT THE POWER STEERING WENT OUT ON THE VEHICLE. CHEVROLET DOES NOT MAKE IT A RECALL YET YOU CAN BE DRIVING ALONG AND ALL OF A SUDDEN YOUR POWER STEERING GOES OUT. THE PART IS THE SAME AS THE CHEVROLET COBALT AND CHEVROLET DID A RECALL ON THAT VEHICLE FOR THE VERY SAME POWER STEERING PART.

INSIDE DRIVER DOOR HANDLE, BROKEN OFF, HAVE TO ROLL DOWN WINDOW TO OPEN DOOR OR CROSS OVER TO PASSANGER SEAT TO GET OUT. *TR

DRIVING NORMAL ON HIGHWAY HIT A SMALL BUMP 2006 CHEVY HHR STALLED, SECOND TIME THIS HAPPENED FIRST TIME NO BUMP OCCURRED BUT CAR STALLED, IN BOTH CASES WAS ABLE TO RESTART CAR BY PUTTING IT IN NEUTRAL AND TURNING THE KEY. *TR

INSIDE DOOR HANDLE ON MY 2006 CHEVROLET HHR BROKE OFF WHEN I OPENED THE DOOR. THIS CREATES A SAFETY ISSUE FOR THE DRIVER AS THE DOOR CANNOT BE OPENED FROM THE INSIDE WITHOUT LOWERING THE LEFT FRONT WINDOW AND OPENING WITH THE OUTSIDE HANDLE. IF THE ELECTRICAL SYSTEM IS DAMAGED THEN THE WINDOW WILL NOT OPEN. THE DRIVER WOULD THEN NEED TO CRAWL OVER THE CENTER CONSOLE TO THE RIGHT DOOR OR THE FRONT SEAT TO EXIT THE CARS REAR DOOR. IN A COLLISION OR FIRE THE DRIVER MAY BE INJURED, PANICKED OR CONFUSED AND NOT BE ABLE TO EXIT THE VEHICLE. THE PLASTIC HANDLE SHOULD BE REPLACED WITH A MORE SUBSTANTIAL METAL ONE. *TR

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE ATTEMPTING TO OPEN THE DRIVERS DOOR THE INSIDE DOOR HANDLE DETACHED FROM THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE, AND STATED THAT THE DOOR HANDLE, AND THE DOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 64,000.