2002 Chevrolet Corvette complaints

LR TIRE BEGAN LOOSING AIR (OVERNIGHT WHILE SITTING IN MY GARAGE), I FILLED THE TIRE ONLY TO FIND IT LOW AGAIN THE NEXT DAY. I TOOK THE CAR TO THE TIRE SHOP EXPECTING TO FIND A NAIL IN THE TREAD, NO HOLES WERE FOUND IN THE TIRE SO THE TECHNICIAN SPRAYED HIS SOLUTION ON THE RIM ONLY TO FIND AIR LEAKING FROM A CRACK IN THE CHROME RIM. FURTHER INVESTIGATION UNCOVERED MULTIPLE CRACKS ON THE RIMS AT THE REAR OF THE CAR WHERE THE SPOKES ATTACHED TO THE RIM. I THOUGHT IF THESE RIMS ARE IN THIS CONDITION THERE MUST BE MORE. THIS CAR IS IN BRAND NEW CONDITION 27,000 MILES GARAGE KEPT AND WELL CARED FOR. THE MANAGER AT PALMEN'S CHEVROLET SENT PICTURES TO CHEVROLET WITH AN EXPLANATION NO BRUISES ON THE RIM NO IDEA OF HOW IT HAPPENED. I AM GUESSING BAD HEAT TREATMENT, CHEVROLET TOLD ME I AM ON MY OWN. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN SEIZED AND HE WAS UNABLE TO DRIVE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER IN 2004 WHERE IT WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V060000 (STEERING:COLUMN LOCKING:ANTITHEFT DEVICE). THE MANUFACTURER WAS AWARE OF THE FAILURE; HOWEVER, OFFERED NO FURTHER ASSISTANCE. NO ADDITIONAL REPAIRS WERE PERFORMED. THE FAILURE AND CURRENT MILEAGES WERE 70,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING LOCKED ABNORMALLY WHILE ATTEMPTING TO START THE VEHICLE. THE CONTACT WAS UNABLE TO UNLOCK THE STEERING WHEEL AND THE MANUFACTURER WAS CONTACTED. THE CONTACT WAS ADVISED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V060000 (STEERING: COLUMN LOCKING: ANTI-THEFT DEVICE) AND THEY WERE UNABLE TO PROVIDE ANY FURTHER ASSISTANCE WITH THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 50,000.

ALUMINUM WHEELS OF SPEEDLINE MANUFACTURE AS SUPPLIED ON GM CORVETTES EXHIBIT CRACKS IN PARTS OF THE STRUCTURE SERIOUSLY COMPROMISING THE SAFETY OF THE VEHICLES. PREDOMINANT MODEL YEARS AFFECTED ARE THE 2002-2004 SERIES. THE WHEELS ARE IDENTIFIED AS THE THIN-SPOKE DESIGN. THE TIP OF THE ICEBERG CAN BE FOUND IN COMPLAINTS ON THE "CORVETTE FORUM". SOMETIMES FAILURE IS REFERENCED BY A LOSS OF AIR PRESSURE DUMB LUCK INSPECTION. MUST THERE BE DEATHS BEFORE ACTION IS TAKEN? *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT WAS ENTERING A PARKING SPACE WHEN THE STEERING WHEEL LOCKED ABNORMALLY. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE STEERING MOTOR AND RELAY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS THEN CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 75,000.

THIS CAR HAS HAD A PRIOR CRACKED RIM THAT WAS REPLACED OUT OF POCKET. NOW A SECOND RIM CRACKED. THERE ARE MULTIPLE REPORTS OF THE RIMS ON THE 2000-2004 CORVETTES MADE THAT HAVE NOT FOR WHAT EVER REASON SEEM TO NOT BE ADDRESSED BY THIS AGENCY BECAUSE THERE ARE NO RELATED DEATHS OR INJURIES. THERE IS LARGE AMOUNT OF INFORMATION ON THE CORVETTE FORUMS AND THE FOLLOWING INFORMATION AVAILABLE FROM AN EMAIL WHICH THE POSTER CLAIMS WAS SENT OUT BY NHTSA "CURRENTLY THERE ARE 9 REPORTS OF WHEELS CRACKING INVOLVING MODEL YEARS 2001 AND 2002 CHEVROLET CORVETTE VEHICLES IN OUR DATABASE. HOWEVER, AVAILABLE DATA INDICATES THAT THE CRACKS ARE MINOR AND THAT THERE NO REPORTS OF A DRIVER LOSING CONTROL OF THE VEHICLE DUE TO CRACK WHEELS. THUS, THERE DOES NOT APPEAR TO BE A SAFETY-RELATED CONSEQUENCE ASSOCIATED WITH THIS PROBLEM. UNDER THESE CIRCUMSTANCES, THERE IS INSUFFICIENT EVIDENCE TO WARRANT OPENING A SAFETY DEFECT INVESTIGATION AT THIS TIME. THE INFORMATION YOU HAVE PROVIDED HAS BEEN ENTERED INTO OUR DATABASE. WE WILL CONTINUE TO MONITOR THIS ISSUE AND WILL TAKE FARTHER ACTION AS NECESSARY." I MYSELF NOW HAVE A SECOND RIM THAT IS CRACKED AND GM IS REFUSING TO COVER THE REPLACEMENT DUE TO NON WARRANTY. DESPITE THE TSB 070310003 FROM NHTSA ITEM NUMBER : 10021451. IS IT THE POSITION OF NHTSA AND GM THAT A CRACKED RIM IS NOT A SAFETY ISSUE AND IT IS OK TO OPERATE THE VEHICLE AT POSTED SPEEDS IN TEXAS UP TO 80 MILES PER HOUR WITH CRACKED RIMS? IS IT THE POSITION OF NHTSA THAT UNTIL THERE IS

AS I WAS DRIVING, COASTING MY CAR DOWN A HILL IN BUFFALO, NY MY 2002 CHEVROLET Z06'S MOTOR SHUT DOWN COMPLETELY. I WAS MAKING A RIGHT-HAND TURN WHEN THE VEHICLE LOST ALL POWER-ASSISTED STEERING AND THE VEHICLE COULD NOT BE RE-STARTED. I LATER FOUND OUT FROM THE DEALER WHERE I HAD MY CAR TOWED THAT MY Z06 HAD BROKEN A VALVE SPRING IN ITS ENGINE. AFTER SOME RESEARCH, THIS APPEARS TO BE A COMMON PROBLEM WITH 2001 AND 2002 CORVETTE Z06 MODELS MADE BY CHEVROLET. THERE ARE MANY EXAMPLES NEARLY IDENTICAL TO MINE WHERE THE VEHICLE'S VALVE SPRINGS WILL SNAP AND PREVENT THE VALVES IN THE MOTOR FROM OPERATING SUCCESSFULLY AND THUS PREVENTING THE CAR FROM MOVING UNDER ITS OWN POWER. I BELIEVE THIS FREQUENT PROBLEM IS A SAFETY HAZARD AS MANY OF THESE FAILURES OCCUR WHILE THE VEHICLES ARE BEING DRIVEN ON PUBLIC ROADS AND ARE RENDERED INOPERABLE BY THE FAILURE. MOREOVER, AFTER ONE OF THESE VALVE SPRINGS BREAKS, THE CAR LOSES ITS POWER STEERING FUNCTION (THAT MOST DRIVERS ARE ACCUSTOMED TO HAVING IN ASSISTING THEIR STEERING AT LOW SPEEDS); THE FUNCTION A DRIVER WOULD NEED MOST IN AN EMERGENCY SITUATION WHERE THEIR CAR CANNOT MAINTAIN SPEED ON A PUBLIC ROADWAY. *TR

I HAVE A 2002 CHEVY CORVETTE. BOTH OF THE 18" REAR WHEELS HAVE CRACKS AT THE CORNERS OF THE FIVE SPOKES. THE VEHICLE HAS LESS THAN 40,000 MILES. THE FRONT WHEELS ARE 17", THERE ARE NO APPARENT CRACKS ON THE FRONT WHEELS. THESE ARE FACTORY WHEELS WITH ORIGINAL TIRES, NO ABUSIVE DRIVING SINCE THE CAR WAS NEW. *TR

2002 CHEVROLET CORVETTE - ABS BRAKING AND TRACTION CONTROL SYSTEM FAILURE. SYSTEMIC AND RECURRING PROBLEM WITH ECBM ELECTRONIC FAILURE. LOSS OF VEHICLE CONTROL IN WET WEATHER AND NO ABS BRAKING. RESEARCH SHOWS REPEATED PROBLEM WITH C5 CORVETTES. VERY DANGEROUS SITUATION WITH A HIGH PERFORMANCE VEHICLE. THIS NEEDS MANUFACTURER'S CORRECTION OF THIS DESIGN AND MANUFACTURING FLAW. PLEASE INVESTIGATE. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT NOTICED THAT THE STEERING WHEEL REMAINED STUCK AND SHE WAS UNABLE TO MOVE IT. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NUMBER: 04V060000 (STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE). THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS ALREADY REPAIRED UNDER THE PREVIOUS RECALL AND OFFERED NO ADDITIONAL ASSISTANCE. NO REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 37,500.

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND THE TRACTION CONTROL WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT HE HAD TO REPLACE THE PUMP AND THE MODULE. THE REMEDY PROVIDED BY THE DEALER WAS ONLY A TEMPORARY FIX SINCE THE PROBLEM RECURRED TWO YEARS LATER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS 70,000 AND THE CURRENT MILEAGE WAS 112,000.

2002 CORVETTE RIGHT REAR WHEEL CRACKED. RPO CODE QF5 STYLE WHEELS. IS A BIG SAFETY ISSUE. IS A KNOWN PROBLEM WITH THESE STYLE WHEELS. CAR HAS APPROX 75,000 MILES ON IT WITH NO OTHER DAMAGE OR ABUSE TO CAR OR WHEEL. DISCOVERED VIA TIRE PRESSURE SENSOR INDICATING TIRE WAS FLAT. ON INSPECTION THE WHEEL WAS CRACKED THROUGH RIM WHICH RESULTED IN THE FLAT TIRE. *TR

2002 CORVETTE WHEELS CRACKING SPOKE UNDER DURESS WITH NOT EVEN 30,000 MILES ON WHEELS ALOT OF CORVETTE OWNERS HAVE THIS COMPLAINT CHEVY NEED TO RECALL BEFORE IT CAUSE A LOSS OF LIFE! *TR

VALVE SPRING FAILURES CORVETTE 2002 TO 2004

I WAS DRIVING DOWN THE HIGHWAY AT NORMAL POSTED SPEEDS (65 MPH) AND MY ENGINE ALL THE SUDDEN CUT OUT. IT STUMBLED AND DIED. I HAD IT TOWED BY L&A WRECKING COMPANY TO THE SHOP. TURNS OUT IT WAS THE VALVE SPRINGS THE FAILED (APPARENTLY VERY COMMON WITH CORVETTES) AND ALMOST CAUSED A HUGE WRECK DUE TO ME HAVING NO POWER.

I HAVE A 2002 CORVETTE CONVERTIBLE. EACH TIME THE FUEL TANK IS FILLED THERE IS A STRONG FUEL ODOR SMELL IN THE PASSENGER COMPARTMENT OF THE CAR. EVEN WITH THE TOP DOWN THE SMELL CAUSES HEADACHES AND NAUSEA! ALL IT WILL REQUIRE IS A SINGLE SPARK TO CAUSE DEATH! IT IS TIME TO FORCE A RECALL ON ALL 1997 TO 2004 C5 CORVETTES! *TR

WHEEL HAS A MAJOR CRACK. *TR

FUEL TANK LEAKS WHEN FUELING CAR. THIS SEEMS TO BE A COMMON ISSUE WITH THE CHEVROLET CORVETTE IN THE YEARS 2000-2004. ON ALL PUBLIC FORUMS THIS DEFECT IS REPORTED BY MANY CORVETTE OWNERS. WHY ISN'T THE EPA OR THE NHTSA INVESTIGATING ALL OF THE YEARS INSTEAD OF JUST THE 2004 MODELS? THE RECALL SHOULD BE EXPANDED. WHAT IS THE DELAY? SHOULD SOMEONE DIE IN A FIRE FIRST? OR SHOULD WE BAND TOGETHER AND FILE A CLASS ACTION SUIT AGAINST ALL PARTIES, INCLUDING THE NHTSA. *TR

LOW TIRE PRESSURE WARNING FOR "RIGHT REAR" ON MY 2002 CHEVROLET CORVETTE. INSPECTION OF THE REMOVED TIRE AND "POLISHED ALUMINUM" WHEEL INDICATE A CRACK IN ONE OF THE SPOKES WHERE IT JOINS THE OUTSIDE OF THE WHEEL. A COMPLETE FAILURE COULD CAUSE A SERIOUS CONDITION INVOLVING PROPERTY DAMAGE, PERSONAL INJURY AND/OR DEATH. *TR

STEERING ON MY 2002 CORVETTE LOCKED UP SEVERAL TIMES WHILE I WAS DRIVING YESTERDAY. MORAN CHEVROLET PUT IN A NEW BATTERY AND RESET THE CODES (SAID SOMETHING LIKE "SERVICE STEERING COLUMN") AND SAYS NOT TO WORRY ABOUT IT. I AM WORRYING ABOUT IT. *TR

2002 CHEVROLET CORVETTE COUPE. ORIGINAL POLISHED ALUMINUM 5-SPOKE WHEELS ARE DEVELOPING STRESS FRACTURES SEPARATING SPOKES FROM THE RIMS AND LEAKING AIR FROM TIRES. I REPLACED WITH SAME TYPE WHEELS FROM UNKNOWN YEAR'S CORVETTE. I FOUND THE PROBLEM BEFORE IT CAUSES ANY ACCIDENT. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH, THE "ENGINE" WARNING LIGHT ILLUMINATED. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE SECONDARY AIR INJECTION SYSTEM. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THE SERVICE COLUMN LOCK WARNING LIGHT WOULD SPORADICALLY ILLUMINATE ON THE INSTRUMENT PANEL FOLLOWED BY THE VEHICLE STALLING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE FAILURE WOULD CONSISTENTLY RECUR. THE DEALER INSTALLED A RESISTOR HOWEVER THE FAILURE RECURRED WITHIN A FEW MONTHS. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND AFTER TWO WEEKS, THE CONTACT WAS ADVISED THAT THE DEALER WAS OVERWHELMED AND HAD NOT YET INSPECTED THE VEHICLE. THE CONTACT INQUIRED WITH THE MANUFACTURER IN REGARDS TO NHTSA CAMPAIGN ID NUMBER: 04V060000 (STEERING: COLUMN LOCKING: ANTITHEFT DEVICE) BUT WAS INFORMED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 73,000.

ON JUNE 10, 2010, MY 2002 CORVETTE, 'MANUAL" TRANSMISSIONS," WAS AT BRANDON AUTO IN ROANOKE VA., WHERE THEY WERE REPLACING THE ORIGINAL TIRES WITH 4 NEWS TIRES. THE CAR HAS JUST OVER 29,100 MILES. BRANDON STATED THAT WHEN THEY ATTEMPTED TO DRIVE THE CAR OUT OF THE GARAGE, A WARNING LIGHT APPEARED STATING, "SERVICE STEERING COLUMN." THE CAR WOULD SHUT OFF, AND COULD NOT BE DRIVING. IT WAS TOWED BY AAA TO PINKERTON CHEVROLET IN SALEM, VA. PINKERTON WAS THE GM DEALERSHIP THAT IN OCT OF 2006 CORRECTED THE "STEERING COLUMN LOCKING DEVICE" UNDER THE NHTSA ACTION NUMBER: EA02031AND GM RECALL NO. 04006. ON JUNE 16TH PINKERTON DIAGNOSED AND REPLACED THE STEERING COLUMN LOCK, AND I WAS BILLED $624.80. WHEN I QUESTIONED THEM ABOUT THE ABOVE RECALL/DEFECT OF THE STEERING COLUMN LOCK, THE PINKERTON SERVICE MANAGER STATED THAT THE CAR WAS NO LONGER UNDER WARRANTY. I PICKED THE CAR UP ON THE 16TH AFTER PAYING THEM IN FULL. THAT SAME DAY I CALLED GM'S CUSTOMER SERVICE AND FILED A COMPLAINT, #71-839793121. ON JUNE18TH I WAS INFORMED BY GM CUSTOMER SERVICE THAT "GM" WAS NOT RESPONSIBLE FOR ANY ADDITIONAL PROBLEMS WITH THE STEERING COLUMN RECALL/DEFECTS. WHEN I ASKED FOR A SUPERVISOR, THEY PUT ME ON "HOLD" FOR OVER 30 MINUTES AND THEN "HUNG UP" ON ME. HAD I BEEN DRIVING THE CAR WHEN THE STEERING COLUMN DEFECT OCCURRED, IT COULD HAVE CAUSE A CRASH RESULTING IN POSSIBLE SERIOUS INJURIES AND PROPERTY DAMAGE. I WOULD APPRECIATE "NHTSA ODI" INVESTIGATION OF THIS SERIOUS VEHICLE DEFECT. ALSO, GM SHOU

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE SERVICE ACTIVE HANDLING SYSTEM LIGHT ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. WHENEVER THE LIGHT ILLUMINATED THE VEHICLE BEGAN PULLING TO THE RIGHT AND THE BRAKES RESPONDED AS IF SHE WERE DRIVING ON ICE. SHE HAD THE OPTION TO CANCEL THE SERVICE ACTIVE HANDLING SYSTEM OR TURN THE VEHICLE OFF AND RESTART IT SO THAT THE VEHICLE WOULD FUNCTION NORMALLY. OCCASIONALLY ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL WOULD ILLUMINATE WHICH CAUSED THE ACTIVE HANDLING LIGHT TO MALFUNCTION. THE FAILURE WAS IDENTICAL TO RECALL 10V172000, STEERING COLUMN WHICH WAS SPECIFIC TO THE 2005 CHEVROLET CORVETTE. IN AUGUST 2009, A CUSTOMER SERVICE ENGINEER STATED THAT IT MUST BE AN ANOMALY OR A BAD SENSOR THAT CAUSED THE FAILURE TO OCCUR. THE DEALER HAD NOT DIAGNOSED THE FAILURE; HOWEVER, DURING A ROUTINE OIL CHANGE IN JUNE 2010, SHE WAS ADVISED THAT THE SERVICE ACTIVE LIGHT HAD ILLUMINATED. THE CONTACT CAN PROVIDE A COPY OF HER INVOICE. THE CONTACT WAS ALSO CONCERNED THAT CANCELING THE SERVICE ACTIVE HANDLING OPTION WAS A SAFETY RISK. THE FAILURE MILEAGE WAS 55,000. THE CURRENT MILEAGE WAS 62,000. THE VIN WAS UNAVAILABLE.

2002 CHEVROLET CORVETTE FUEL LEAK/SMELL NEAR LEFT SIDE OF FUEL TANK. FUEL IS VISIBLE AND ACCUMULATES NEAR FUEL NECK HOSE. OCCURS FREQUENTLY THROUGH DAILY DRIVING. *TR

2002 CORVETTE CONVERTIBLE HAS REAR WHEEL WITH 2 STRESS CRACKS LEADING TO TOTAL LOSS OF AIR. *TR

I HAVE A 2002 CORVETTE. THE STEERING WHEEL LOCK DOES NOT UNLOCK. THERE WAS A RECALL IN 2004 BUT MY CAR WAS NOT REPAIRED. TODAY IT IS NOT COVERED BY THAT RECALL AND IS DANGEROUS TO DRIVE. *TR

I OWN A 2002 CHEVROLET CORVETTE THAT HAS RECENTLY DEVELOPED A SERIOUS FUEL LEAK WHEN REFUELING CAR. NOT ONLY IS THIS A FIRE HAZARD BUT ALSO THE LEAK ALLOWS RAW GAS TO BE RELEASED INTO THE ATMOSPHERE, A POLLUTION PROBLEM. I DID A SEARCH ON THIS PROBLEM ON A CORVETTE WEB SITE ( CORVETTEFORUM.COM ) AND FOUND THIS TO BE A WIDE SPREAD PROBLEM IN THE C5 VERSIONS OF THE CORVETTE. THE CAR WAS BUILT ON 4-3-02, AND FIRST DELIVERED ON 7-19-02. I AM THE SECOND OWNER, CAR HAS 51,156 MILES, HAS HAD ALL REQUIRED MAINTENANCE PERFORMED AND IS KEPT IN LIKE NEW CONDITION. SINCE THIS IS A WIDE SPREAD PROBLEM WITH THIS PARTICULAR VEHICLE, AND THE SAFETY AND POLLUTION HAZARDS IT PRESENTS I FEEL GM SHOULD BE REQUIRED TO REPAIR AT NO COST TO THE CONSUMER THESE BLATANT DESIGN ERRORS. IF NOTHING ELSE, THE REPAIR SHOULD BE COVERED UNDER POLLUTION LAWS. THANK YOU FOR YOUR ASSISTANCE IN THIS MATTER. *TR

AT ABOUT 15000 MILES THE FUEL TANK BEGAN LEAKING/SMELLING OF GAS AFTER A FILL UP. DEALER DID REPLACE TANK UNDER THE EXTENDED WARRANTY. DEALER DESCRIPTION: 25565 LEAKING FUEL TANK LINE L1280 2.1 (GMPP) INSPECTED THE FUEL SYSTEM FOR A LEAK AND FOUND THE HARD LINE TO THE TOP OF THE FUEL TANK IS LEAKING AT THE CONNECTION TO THE TANK. REMOVED THE FUEL TANK AND DRAINED THE TANK. SWAPPED THE SENDING UNIT AND INSTALLED THE NEW TANK. REPAIRS WERE DONE ON THE RIGHT SIDE TANK. TECH 2310. *TR

1. EACH TIME THE FUEL TANK IS FILLED UP THERE IS A STRONG FUEL ODOR SMELL. 2. RECENTLY THERE IS FUEL LEAKAGE ON MY GARAGE FLOOR DIRECTLY IN FRONT OF THE RIGHT REAR TIRE & FUEL ON THE SIDE AND BOTTOM OF THE FUEL TANK. 3. GM SAID CAR WAS OUT OF WARRANTY FOR THIS ISSUE. *TR

I OWN A 2002 CHEVROLET CORVETTE AND HAVE AN ISSUE WITH THE ELECTRICAL SYSTEM THAT APPEARS TO BE AN ISSUE THAT WAS INVESTIGATED SEVERAL YEARS BACK ON ANOTHER VEHICLE. HOWEVER, IN DOING INTERNET RESEARCH, IT APPEARS MANY CORVETTE OWNERS HAVE EXPERIENCED THE SAME PROBLEM WHEREBY THE TURN SIGNALS WORK INTERMITTENTLY AND SOMETIMES NOT AT ALL OR JUST STOP WORKING AFTER THEY HAVE BLINKED FOR A FEW TIMES. I SEE THIS AS A VERY DANGEROUS ISSUE AS THE DRIVERS AROUND YOU DETERMINE THEIR BRAKING AND DRIVING SKILLS ON WHAT THEY SEE AND THEY MAY GET A FALSE SENSE OF WARNING WHEN THE BLINKER GOES OUT AND I STOP ANYWAY TO MAKE THE TURN. I WOULD THINK THAT I WOULD BE CITED BY LAW ENFORCEMENT AND THIS PROBLEM APPEARS TO BE A DEFECT IN THE DESIGN OR THE MANUFACTURER OF THE PART. *TR

FUEL TANK LEAK DUE TO A SPLIT IN NON METAL TANK. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE TURN SIGNALS FAILED INTERMITTENTLY. WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN ,THIS CONDITION COULD RESULT IN A CRASH. FOR TWO YEARS, HE CONCLUDED THAT THE COMPONENT WAS TEMPERATURE SENSITIVE . THE DEALERSHIP CONCLUDED THAT THE HAZARD FLASHER SWITCH WAS THE CAUSE OF THE FAILURE. HIS MODEL TYPE WAS EXCLUDED FROM RECALL #03V327000 ( EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE MANUFACTURER WAS NOTIFIED, BUT BECAUSE OF THE AGE OF THE VEHICLE HE WAS NOT PROVIDED WITH ANY ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 70,000. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

2002 CHEVROLET CORVETTE WITH LESS THAN 43,000 MILES HAS STRESS CRACKS IN REAR WHEELS. RIMS HAVE NO PHYSICAL DAMAGE & HAVE NOT BEEN IN ACCIDENT. FOUND PROBLEM DUE TO TIRE PRESSURE LOSS COMING FROM BOTH REAR RIMS. CAR IS IN EXCELLENT CONDITION(WEEKEND DRIVING). *TR

THERE IS A CLICKING NOISE AT THE REAR WHEELS DURING LOW SPEED FORWARD AND REVERSE TRAVEL. THE DEALER HAS TWICE (JULY 2008 AND MARCH 2009) TIGHTENED THE REAR AXLE NUTS TO TEMPORARILY SOLVE THE PROBLEM. I'M SURE ABOUT THE CONSEQUENCES OF THIS COMPLAINT, BUT IF THE AXLE NUTS WERE TO FALL OFF THERE PROBABLY WOULD BE DAMAGE TO THE VEHICLE AND/OR OTHER VEHICLES BECAUSE OF A CAR ACCIDENT. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS IN PARK, IT SURGED IN REVERSE WHILE THE CONTACT WAS RETRIEVING ITEMS FROM THE TRUNK. HE HAD TO JUMP OUT OF THE WAY OF THE VEHICLE. HIS SPOUSE HAD TO SLAM ON THE BRAKES TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER AND THEY DIAGNOSED THE FAILURE AS A DEFECTIVE CABLE. THE CURRENT AND FAILURE MILEAGES WERE 8,000. UPDATED 09/17/08. *LJ UPDATED 09/24/08. *JB

2002 CORVETTE Z06. VEHICLE WAS OPERATING NORMALLY BUT WHEN I TURNED THE CORNER THE VEHICLE WENT TO FULL THROTTLE BY ITSELF. I MANAGED TO STOP THE VEHICLE BUT ONLY AFTER STRIKING A METAL POST. THIS COULD HAVE BEEN VERY BAD IF I WAS AT AN INTERSECTION. *TR

STEERING COLUMN LOCK SAFETY RECALL HAS NOT BEEN RESOLVED AFTER 6 ATTEMPTS! THIS MORNING THE SERVICE COLUMN LOCK ERROR OCCURRED WHILE ON THE HIGHWAY AT 65 MPH!!!! THE ENGINE WAS DISABLED AND WAS NOT ABLE TO BE RESTARTED! THE CAR WAS TOWED TO MY HOUSE WHERE IT NOW SITS DEAD FOR THE 7TH TIME! CHEVROLET AND GENERAL MOTORS HAVE DECIDED NOT TO CONTINUE TO FIX THIS PROBLEM ANY MORE BECAUSE NOW THEY ARE CLAIMING I AM OUT OF WARRANTY AND THE VEHICLE HAS NOW A BRANDED TITLE FROM LIGHT FLOOD DAMAGE. THE VEHICLE HAS SUPPOSEDLY PASSED CT DMV INSPECTION AND WAS SOLD TO US WITH A BRANDED TITLE FROM A LOCAL LICENSED DEALERSHIP IN MY AREA. *TR

WHEELS ON MY 2002 CHEVY CORVETTE ARE CRACKED AND IT IS A WIDESPREAD PROBLEM. FAILURE OF THIS WHEEL WHILE DRIVING CAN HAVE DISASTROUS RESULTS. *TR

2002 CHEVY CORVETTE WITH DASHBOARD LIGHTS ILLUMINATING. CONSUMER STATES THAT THE SUSPENSION AND BRAKE LIGHTS ILLUMINATED. SHE ALSO STATES THAT THE STEERING COLUMN LOCKED ENGAGED AND SHE COULD NOT DISENGAGE IT. *KB THE CONSUMER STATED ALL THREE PROBLEMS SHE EXPERIENCED WERE RELATED.

MY STEERING LOCKS UP ON MY 2002 CHEVROLET CORVETTE ! GMC REFUSES TO REIMBURSE ME ON THE REPAIRS. *TR

2002 CHEVY CORVETTE ACTIVE HANDLING PROBLEMS. CUSTOMER STATES THAT THE VEHICLE BRAKES REALLY HARD WHEN THIS HAPPENED WHILE TRAVELING 70 MPH. HE STATES HE HAS SEEN OTHER CASES LIKE THIS BE FIXED BY REPLACING THE STEERING SENSOR IN THE COLUMN. *KB UPDATED 01-15-08. *KB THE CONSUMER STATED THE DEALERSHIP TEST DROVE THE VEHICLE AND THE MECHANIC FOUND MOISTURE IN THE RIGHT WHEEL SENSOR AND PUT GREASE IN THE CONNECTOR. *TR UPDATED 12/12/07. *JB

VEHICLE (2002 CHEVROLET CORVETTE) RIM CRACKING, NEEDED TO REPLACE ALL RIMS. *JB

THE RIGHT REAR OEM FORGED ALUMINUM WHEEL ON THE 2002 CORVETTE HAS DEVELOPED A CRACK. DISCUSSION OF THIS CORVETTE WHEEL CRACKING ISSUE ON VARIOUS WEB FORUMS HAS INDICATED THAT MANY OF THESE SAME OEM CORVETTE WHEELS HAVE CRACKED. I CONSIDER THIS CRACKED WHEEL UNSAFE SINCE IT COULD LEAD TO CATASTROPHIC WHEEL FAILURE AND AN ACCIDENT.*AK

EBCM ISSUES ON THE C5 CHEVROLET CORVETTE. GETTING ABS/AH/TC ERRORS ON DISK. THIS IS A COMMON ISSUE THAT SHOULD HAVE BEEN A RECALL FOR SAFTEY REASON. *AK SEE THE LONG LIST AT CORVETTE FORUM HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T=1387486

TL*THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. SINCE THE VEHICLE WAS PURCHASED, THE ELECTRONIC POWER WINDOWS HAVE FAILED ON A DAILY BASIS. THE VEHICLE WAS PURCHASED FROM A PRIVATE PARTY. THE PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 23,000 AND FAILURE MILEAGE WAS 5,500.

ABS MODULE FAILED WITH 33K MILES IN 02 CORVETTE THERE ARE MANY OTHER WHO HAVE HAD SAME PROBLEM BUT WITH BRAKES THAT LOCK UP WITHOUT TOUCHING THE PEDAL. 18 PAGES OF PEOPLE ON CORVETTEFORUM.COM WITH EBCM (ELECTRONIC BRAKE CONTROL MODULE) THAT ALSO SHUTS OFF TRACTION CONTROL. PARTS FAILING ON A RANGE OF MODEL YEAR CORVETTES. *TR

I HAVE A 2002 C5 CORVETTE, THE REAR RIM HAS A CRACK IN THE SPOKE. I WENT ON CORVETTE FORUM TO SEE IF OTHERS HAVE HAD THIS PROBLEM. THERE WHERE SEVERAL OTHER PEOPLE THAT HAD THE SAME ISSUE. SEVERAL HAD TAKEN THERE CARS TO THE DEALERS, SOME UNDER WARRANTY SOME NOT AND GM WOULD NOT REPLACE THE RIMS. THIS LINK WAS ACTUALLY ON THE CORVETTE FORUM ASKING PEOPLE TO WRITE TO YOU AND POSSIBLY GET A SAFETY RECALL STARTED. I ONLY HAVE 39000 MILES 0N THE CAR. I FEEL THIS IS A BIG SAFETY ISSUE, I DIDN'T NOTICE IT UNTIL I HAD NEW TIRES PUT ON AND THE MECHANIC TOLD ME. THIS COULD BE A VERY DANGEROUS ISSUE SHOULD THE RIMS COME APART ON THE HIGHWAY. CAN YOU PLEASE SEE IF OTHERS HAVE REPORTED SIMILAR ISSUES, I DON'T KNOW WHAT IT TAKES FOR A RECALL TO BE ISSUED, BUT I FEEL OBLIGATED TO REPORT IT. *JB

RIGHT REAR STOCK RIM ON A 2002 CORVETTE COUPE IS CRACKED. CAR ONLY HAS 33,000 MILES ON IT. I WILL HAVE TO GET A NEW RIM IN ORDER TO FIX THE ISSUE. *TR